NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes, Hydraulic complaints
26 reportsClear category filter56,380 miles · Jul 23, 2009
EquipmentService Brakes, HydraulicFire
I WAS BRAKING AS I WAS DESCENDING A HILL ON THE HIGHWAY WHEN THE FRONT BRAKES GOT SO HOT THAT MY AUTOMOBILE STARTED TO SHIMMY. I STOPPED AND DISCOVERED THAT MY RIGHT FRONT BRAKES WERE ON FIRE. I HAD MY FRONT BRAKES PADS AND ROTORS REPLACED ABOUT 7,000 MILES AGO WITH MOPAR VALUE LINE BRAKES AT THE DODGE DEALERSHIP. MY VEHICLE IS…
Read full complaint
I WAS BRAKING AS I WAS DESCENDING A HILL ON THE HIGHWAY WHEN THE FRONT BRAKES GOT SO HOT THAT MY AUTOMOBILE STARTED TO SHIMMY. I STOPPED AND DISCOVERED THAT MY RIGHT FRONT BRAKES WERE ON FIRE. I HAD MY FRONT BRAKES PADS AND ROTORS REPLACED ABOUT 7,000 MILES AGO WITH MOPAR VALUE LINE BRAKES AT THE DODGE DEALERSHIP. MY VEHICLE IS A 2005 DODGE GRAND CARAVAN WITH 56,380 MILES ON IT. *TR
NHTSA ODI #10278020
21,000 miles · May 14, 2009
Service Brakes, Hydraulic
BOUGHT DODGE GRAND CARAVAN 2005 IN AUG. 2006 WITH 29K MILES, NOW HAS 50K MILES. I'VE REPLACED THE BRAKES FIVE TIMES AND THE ROTOR ONCE AND THEY NEED TO BE REPLACED AGAIN. I HAVE DRIVEN IN CO FOR 43 YRS AND HAVE NEVER HAD THIS PROBLEM WITH ANY OTHER CAR. *TR
NHTSA ODI #10268739
51,500 miles · Mar 3, 2009
Service Brakes, Hydraulic
TL*THE CONTACT OWNS A 2005 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE BRAKE LINE ON HER VEHICLE HAS RUPTURED AT LEAST THREE TIMES WITHIN THE PAST EIGHT MONTHS. WHILE DRIVING AT AN UNKNOWN SPEED, THE BRAKES FAILED. THE VEHICLE WAS REPAIRED BY A MECHANIC WITH PARTS PURCHASED FROM THE DODGE DEALER. THE VEHICLE HAS BEEN RE…
Read full complaint
TL*THE CONTACT OWNS A 2005 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE BRAKE LINE ON HER VEHICLE HAS RUPTURED AT LEAST THREE TIMES WITHIN THE PAST EIGHT MONTHS. WHILE DRIVING AT AN UNKNOWN SPEED, THE BRAKES FAILED. THE VEHICLE WAS REPAIRED BY A MECHANIC WITH PARTS PURCHASED FROM THE DODGE DEALER. THE VEHICLE HAS BEEN REPAIRED THREE TIMES FOR THIS FAILURE AND THE CONTACT IS CURRENTLY TOO AFRAID TO DRIVE THE VEHICLE. THE FAILURES OCCUR WITHOUT WARNING. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED. THE FAILURE MILEAGE WAS 51,500.
NHTSA ODI #10260575
20,000 miles · May 16, 2008
Service Brakes, Hydraulic
BRAKES FAIL COMPLETELY EVERY 20K MILES, REQUIRE FULL ROTOR / PAD REPLACEMENT. OBVIOUS DESIGN FLAW, IF THEY FAIL THAT QUICKLY THEN CERTAINLY SOMETHING MORE DANGEROUS COULD OCCUR. *TR
NHTSA ODI #10228013
50,009 miles · Jan 1, 2008
Service Brakes, Hydraulic
BRAKE SYSTEM FAILURE WHILE DRIVING. NOTHING PREVIOUSLY NOTED PRIOR TO FAILURE. BRAKE PEDAL WENT ALL THE WAY TO FLOOR, COULD NOT RESTORE BRAKING BY PUMPING THE BRAKE PEDDLE. RESORTED TO EMERGENCY BRAKE AND DOWN SHIFT. STOP ACHIEVED WITHOUT ACCIDENT. UNKNOWN CORRECTION AT THIS POINT. *CN
NHTSA ODI #10213351
100 miles · Aug 23, 2007
Service Brakes, HydraulicStructure
CRACKS IN ROOF UNDER PLASTIC MOLDING IN BODY ASSEMBLY , WHICH WAS NOT COVERED AFTER 36,000 MILES,DENIED BY DODGE BUT SOME ASSISTANCE FROM DEALER AFTER YELLING, CAUSED WATER LEAKAGE INTO RIGHT PILLAR ASSEMBLY , FLOOR COMPARTMENT AND UNKNOWING TO US SUB CARPETING. OUR WORRIES ARE STRUCTURAL SAFETY , MOLD AND ODOR POSSIBLY ELECTRI…
Read full complaint
CRACKS IN ROOF UNDER PLASTIC MOLDING IN BODY ASSEMBLY , WHICH WAS NOT COVERED AFTER 36,000 MILES,DENIED BY DODGE BUT SOME ASSISTANCE FROM DEALER AFTER YELLING, CAUSED WATER LEAKAGE INTO RIGHT PILLAR ASSEMBLY , FLOOR COMPARTMENT AND UNKNOWING TO US SUB CARPETING. OUR WORRIES ARE STRUCTURAL SAFETY , MOLD AND ODOR POSSIBLY ELECTRICAL WIRING AND IF THERE ARE MORE IN ROOF THAT WE DON'T KNOW ABOUT ,AND ON ADDED NOTE PREMATURE DISC BRAKE WEAR ROTORS AND PADS DATE IS APPROXIMATE HAVE TO LOOK UP SERVICE RECORD ,DEALER GREENFIELD DODGE LAWRENCEVILLE NJ *TR
NHTSA ODI #10200636
23,000 miles · May 29, 2007
Service Brakes, Hydraulic
TL*THE CONTACT OWNS A 2005 DODGE GRAND CARAVAN. WHILE DRIVING 35 MPH, THE CONTACT HEARD A LOUD GRINDING NOISE AND THE BRAKE PEDAL WENT DOWN TO THE FLOORBOARD. THE DEALER STATED THAT THE FRONT BRAKE PADS WERE WORN. THE DEALER REPLACED THE BRAKE PADS AND TURNED THE ROTORS. APPROXIMATELY THREE MONTHS LATER, THE ABS WARNING LIGH…
Read full complaint
TL*THE CONTACT OWNS A 2005 DODGE GRAND CARAVAN. WHILE DRIVING 35 MPH, THE CONTACT HEARD A LOUD GRINDING NOISE AND THE BRAKE PEDAL WENT DOWN TO THE FLOORBOARD. THE DEALER STATED THAT THE FRONT BRAKE PADS WERE WORN. THE DEALER REPLACED THE BRAKE PADS AND TURNED THE ROTORS. APPROXIMATELY THREE MONTHS LATER, THE ABS WARNING LIGHT ILLUMINATED. THE DEALER STATED THAT THE VEHICLE NEEDED FRONT BRAKE PADS AND PERFORMED THE REPAIR. WHILE DRIVING 25 MPH, THE CONTACT DEPRESSED THE BRAKE PEDAL AND IT WENT DOWN TO THE FLOORBOARD, MAKING THE VEHICLE DIFFICULT TO STOP. HE HAD TO APPLY THE EMERGENCY BRAKE TO STOP THE VEHICLE. THE VEHICLE WAS TOWED TO THE DEALER WHO STATED THAT THE BRAKE LINE FAILED. THE DEALER REPLACED THE BRAKE LINE. APPROXIMATELY TWO MONTHS LATER, THE VEHICLE EXPERIENCED THE SAME FAILURE. THE DEALER HAS NOT DIAGNOSED THE CAUSE OF FAILURE. THE CURRENT MILEAGE IS 55,000 AND FAILURE MILEAGE WAS 23,000.
NHTSA ODI #10191920
27,750 miles · Feb 19, 2007
Electrical SystemFuel System, GasolineService Brakes, Hydraulic
I AM CONCERNED WITH OVERALL QUALITY CONTROL ON THIS VEHICLE. I PURCHASED THIS VEHICLE NEW TO PROVIDE SAFETY AND COMFORT FOR MY GROWING FAMILY. I WAS DISAPPOINTED IN THE VEHICLES PERFORMANCE AND GAS MILEAGE DURING THE FIRST SEVERAL WEEKS OF OWNERSHIP. I RETURNED THE VEHICLE TO THE DEALERSHIP AND THEY REPLACED THE OXYGEN SENSOR UN…
Read full complaint
I AM CONCERNED WITH OVERALL QUALITY CONTROL ON THIS VEHICLE. I PURCHASED THIS VEHICLE NEW TO PROVIDE SAFETY AND COMFORT FOR MY GROWING FAMILY. I WAS DISAPPOINTED IN THE VEHICLES PERFORMANCE AND GAS MILEAGE DURING THE FIRST SEVERAL WEEKS OF OWNERSHIP. I RETURNED THE VEHICLE TO THE DEALERSHIP AND THEY REPLACED THE OXYGEN SENSOR UNITS THAT THEY SAID WHERE DEFECTIVE. SEVERAL MONTHS LATER THE HEATER/AIR CONDITIONING BLOWER WENT OUT. NEXT WITH LESS THAN 20,000 MILES ON THE VEHICLE I HAD TO REPLACE THE BRAKES. NOW WITH LESS THAN 28.000 MILES ON THE VEHICLE I NOTICED THAT THE PASSENGER SIDE FLOOR WAS SOAKED, THE VEHICLE WAS MAKING UNUSUAL SOUNDS WHEN TURNING AND THE PASSENGER SIDE DOOR WOULD NOT CLOSE AUTOMATICALLY. AT THE DEALERSHIP I FOUND OUT THAT THE RACK AND PINION STEERING UNIT HAD FAILED ALONG WITH THE THE CABLE ON THE PASSENGER SIDE DOOR. ON INVESTIGATION OF THE WATER LEAK THE DEALERSHIP FOUND THAT THE PASSENGER SIDE PILLAR HAD NOT BEEN SEALED PROPERLY TO THE ROOF CAUSING WATER TO RUN INTO THE VAN AND ROT THE CARPET. WHILE THE VEHICLE IS IN FOR REPAIRS THE DEALERSHIP IS ALSO REPLACING THE HEATER/AIR CONDITIONER BLOWER WHICH IS MAKING GRINDING SOUNDS AGAIN. *NM
NHTSA ODI #10182973
5,500 miles · Nov 17, 2006
Service Brakes, HydraulicSteeringSuspension
SINCE PURCHASING IN 2004. I HAVE HAD TO TAKE BACK THE VAN NUMEROUS TIMES TO COMPLAIN TO THE DEALERSHIP ABOUT NOISES WHILE DRIVING IN THE STEERING BRAKES AND FRONT RIGHT WHEEL BASE AREA. BRAKES POPPING AND SCRUBBING, WHEEL BASE MAKES A SCRUBBING/CRACKING NOISES, AND THERE WAS A WHINING NOISE WHILE SLOWING AT STOPS AND IN PARKING…
Read full complaint
SINCE PURCHASING IN 2004. I HAVE HAD TO TAKE BACK THE VAN NUMEROUS TIMES TO COMPLAIN TO THE DEALERSHIP ABOUT NOISES WHILE DRIVING IN THE STEERING BRAKES AND FRONT RIGHT WHEEL BASE AREA. BRAKES POPPING AND SCRUBBING, WHEEL BASE MAKES A SCRUBBING/CRACKING NOISES, AND THERE WAS A WHINING NOISE WHILE SLOWING AT STOPS AND IN PARKING LOTS. THEY HAVE REPLACED A MAP LIGHT. MY SLIDING DOORS HAVE STOPPED WORKING ONCE BUT THE PROBLEM HAS NOT OCCURRED AGAIN TO TAKE TO THE DEALER. AT A RED LIGHT WHEN IT TURNED GREEN I WENT TO GO AND THE ENGINE CUT OFF WOULD NOT RESTART IMMEDIATELY. LUCKILY NO ONE WAS BEHIND ME AND NO ONCOMING TRAFFIC. I WAS ON A HILL AND ABLE TO ROLL TO THE SIDE AND PUT THE VAN BACK IN PARK TO RESTART. 08/11/05 TOOK TO DEALER SHIP AND THEY PERFORMED A COMPUTER FLASH UPDATE AND LISTED A LABEL AUT AND LABEL GEN PART. HERE ARE THE SERVICE DATES WHEN I TOOK IN IT EACH TIME TO COMPLAIN ABOUT STEERING AND DRIVING NOISES. 08/04/05 TOOK TO DEALER ORDERED PARTS SERVICED ON 08/11/05 REPLACED POWER STEERING RESERVOIR. 11/17/05 REPLACED RACK AND PINION. 08/16/06 TOOK IN BRAKES STARTING MAKING NOISES TOLD WE HAD 20% LEFT AT 16,812 MILES THEY TOLD US TO REPLACE THE BRAKES. 08/16/06 ALSO HAD THEM LOOK AT THE SAME NOISE AS BEFORE AND THEY LUBED/GREASED STRUT DUST COVERS. 11/08/06 TOOK BACK FOR SAME NOISES AND THEY REPLACED THE SWAY BAR LINKS FOUND MY STEERING FLUID LOW, REPLACED FLUID AND STATED THEY COULD NOT FIND ANY CRACKS/LEAKS. I AM STILL HEARING NOISES COME FROM THE RIGHT FRONT WHEELBASE. THE POWER STEERING FLUID HAS FIXED THE WHINING NOISES AS OF TODAY. THE BRAKES ARE NOT POPPING. THEY SAID THE SWAY BAR LINKS FIXED THE POPPING. *NM
NHTSA ODI #10173745
35,246 miles · Oct 27, 2006
Service Brakes, Hydraulic
PREMATURE FRONT BRAKE FAILURE-- WE PURCHASED OUR 2005 DODGE GRAND CARAVAN NEW, IN LATE SPRING 2004. SINCE THEN, WE HAVE HAD TO REPLACE THE FRONT BRAKES TWICE, ONCE AT 18,000 MILES, AND NOW AT 35,000 MILES. OUR DRIVING HABITS HAVE NOT CHANGED AND PREVIOUSLY (FOR THE LAST 25 YEARS, WITH 5 DIFFERENT CARS) WE HAVE GONE 30,000 - 4…
Read full complaint
PREMATURE FRONT BRAKE FAILURE-- WE PURCHASED OUR 2005 DODGE GRAND CARAVAN NEW, IN LATE SPRING 2004. SINCE THEN, WE HAVE HAD TO REPLACE THE FRONT BRAKES TWICE, ONCE AT 18,000 MILES, AND NOW AT 35,000 MILES. OUR DRIVING HABITS HAVE NOT CHANGED AND PREVIOUSLY (FOR THE LAST 25 YEARS, WITH 5 DIFFERENT CARS) WE HAVE GONE 30,000 - 40,000 MILES BETWEEN BRAKE JOBS. THIS VEHICLE REPLACED A 10-YEAR OLD PLYMOUTH GRAND VOYAGER WHICH HAD NO PROBLEMS WITH BRAKE WEAR. THE DEALER SERVICE MANAGER SAYS HE HAS SEEN 2005 GRAND CARAVANS COMING IN NEEDING BRAKE JOBS AT ABOUT 25,000 MILES, BUT NOT 18,000 MILES. YET, NEITHER THE DEALER NOR CHRYSLER ADMITS THAT THERE IS A SYSTEM OR COMPONENT PROBLEM. I SPOKE WITH CHRYSLER CUSTOMER SERVICE AND THEY WERE, AT BEST, RELUCTANTLY HELPFUL. THEY HAVE AGREED TO PAY FOR THE PARTS, BUT NOT THE LABOR. SO, I HAVE NOW HAD TO PAY, IN PART, FOR FRONT BRAKE JOBS TWICE IN LESS THAN 3 YEARS, AVERAGING LESS THAN 18,000 MILES BETWEEN THE REPAIRS. THIS IS TOTALLY UNACCEPTABLE. NEEDLESS TO SAY, IF CHRYSLER DOESN'T DO SOMETHING ELSE TO REMEDY THIS SITUATION, THIS WILL BE THE LAST CHRYSLER PRODUCT I WILL OWN...AND I WILL NOT BE KEEPING THIS MINIVAN MUCH LONGER. *NM
NHTSA ODI #10171970
NHTSA investigations
7DP14002 · Engine Stall After Refueling
Opened Sep 5, 2014 · Closed Apr 6, 2015
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly
This defect petition evaluates July 7, 2014 allegations from an owner of a model year (MY) 2007 Dodge Grand Caravan minivan that engine stall occurs in these vehicles without warning after refueling.The petitioner's vehicle is a Chrysler RS platform minivan.The RS platform includes MY 2003 through 2007 Dodge Grand Caravan, Dodge Caravan, Chrysler Town and Country and Chrysler Voyager minivans.NHTSA evaluated the petition by analyzing consumer complaints submitted to the Agency, analyzing field data, reviewing technical information provided in Chrysler's response to an Agency information request and testing an RS minivan identified by its owner as experiencing post-refuel engine stalls.After completing this evaluation, NHTSA has concluded that further investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists.The stalls occurring in these vehicles only occur immediately after filling up the fuel tank and happen at low engine speeds. The failure rate is low, even after 8 to 13 years of the vehicles being in service, and there are no reports of crashes or injuries resulting from the stall condition.In the Agency's view, additional investigation is unlikely to result in finding the existence of a safety-related defect in the subject vehicles.Given the need to allocate and prioritize NHTSA's limited resources to best accomplish the Agency's safety mission, the petition is denied.This action does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency will take further action if warranted by future circumstances. More details concerning our review can be found in the Federal Register Notice for this action.The following 161 VOQs are included in the petition evaluation: 10209242, 10229468, 10240708, 10260923, 10275939, 10276532, 10296487, 10298175, 10328669, 10330144, 10346517, 10349789, 10354758, 10363689, 10372112, 10372368, 10372514, 10378031, 10379764, 10382938, 10387448, 10394063, 10398877, 10413918, 10418652, 10420924, 10427063, 10437525, 10445392, 10446902, 10470028, 10471249, 10473733, 10502231, 10503114, 10504260, 10509862, 10511988, 10512120, 10512385, 10512650, 10513147, 10538154, 10549841, 10551763, 10555188, 10555418, 10556754, 10565367, 10574012, 10574398, 10586555, 10587212, 10587559, 10593433, 10607841, 10607913, 10608922, 10615810, 10622468, 10628141, 10632112, 10632128, 10632172, 10632175, 10632231, 10632262, 10632266, 10632270, 10632305, 10632316, 10632326, 10632370, 10632385, 10632399, 10632492, 10632542, 10632765, 10632833, 10632928, 10633197, 10633281, 10633409, 10633421, 10633483, 10633507, 10637752, 10637804, 10637950, 10637975, 10638032, 10638289, 10638290, 10638401, 10638968, 10639218, 10639623, 10641157, 10641603, 10641614, 10641836, 10644339, 10644705, 10649713, 10649895, 10649932, 10650313, 10652590, 10653147, 10653783, 10654533, 10655226, 10658900, 10659679, 10660320, 10662588, 10662645, 10662662, 10663473, 10667056, 10667437, 10668081, 10668094, 10668131, 10668612, 10668969, 10668970, 10669584, 10669678, 10669729, 10669775, 10669866, 10669895, 10669992, 10670422, 10670506, 10676348, 10676732, 10677120, 10679795, 10679934, 10680057, 10680290, 10680342, 10680714, 10681512, 10682584, 10682906, 10683022, 10683114, 10683549, 10683620, 10683697, 10683743, 10689898, 10690761, 10691284, 10691556, 10691751, 10693061, 10694300
EA11010 · Loss Of Headlight Illumination
Opened Sep 6, 2011 · Closed Nov 29, 2012
Status: closed (inferred from source dates) · Electrical System; Exterior Lighting; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
The subject vehicle (SV) population includes MY 2005-2006 vehicles built between March 2004 and December 2005 manufactured with a TRW supplied headlight switch assembly (HSA).The HSA was the primary focus of the investigation; earlier and later vehicles utilized different HSAs.Consumers complain that the headlights in the subject vehicles do not illuminate when the HSA is turned on, or that the headlights extinguish while on (subject failure).No other driving lights are affected.The front marker, tail, and instrument lamps operate.Also, the high beams can be illuminated by holding the turn signal stalk in the up position.As reported by consumers, turning the HSA off and on typically corrects the failure.Initially the failures occur infrequently but they become progressively more frequent with age.Chrysler has indicated its intention to offer of an extended lifetime warranty on the HSA, so that consumers with this problem can have their HSA replaced at no charge when they begin experiencing the subject failure.Commencing sometime in early 2013, Chrysler will send letters to SV owners notifying them of the lifetime warranty.The SV headlight system design is essentially the same as that described in EA 05-009, which involved headlight anomalies in earlier model Chrysler minivans; refer to it to for additional information.The subject failure is caused by friction between the plastic cam and metal surfaces of the electrical contacts in the HSA, which results in the production of plastic particles (debris).Analysis shows that debris can collect on the electrical contact that controls the headlights, resulting in an open circuit and preventing the headlights from turning on.Subsequent operation of the HSA may temporarily displace the debris, at which time the headlights operate correctly.Lubricant was applied to the plastic cam beginning in December 2005, reducing debris production.Consequently, subsequent failure levels were lower.The report counts shown above include only those that involve the subject failure.Reports involving other failure modes which were identified have not been included either because they were not safety related, or if they were safety related, because there was no defect trend.The single crash event listed in the Failure Report Summary Table above involved a deer strike allegedly due to loss of headlights in February 2006.No injuries were reported in this crash.An April 2004 non-crash incident (?Other? above) involved a momentary loss of headlights.The consumer drove into a ditch, and one minor injury was alleged. The subject vehicles experienced a 2.2% warranty claim rate.While standing alone this would appear to be significant, a portion of these warranty claims likely involve other problems with the HSA unrelated to the subject failure.In view of the on road experience of drivers in rapidly restoring headlight illumination by turning the headlight switch off and on again, the rate and particularly the recent trend in problems with the switch, and Chrysler?s extended lifetime warranty coupled with the owner notification of that extended warranty, further investigation does not appear to be warranted.Accordingly, the investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.Details on Chrysler?s lifetime HSA warranty extension for the SV population will be available in the public file for this investigation.
Additional source detail variants (4)
Electrical System
The subject vehicle (SV) population includes MY 2005-2006 vehicles built between March 2004 and December 2005 manufactured with a TRW supplied headlight switch assembly (HSA).The HSA was the primary focus of the investigation; earlier and later vehicles utilized different HSAs.Consumers complain that the headlights in the subject vehicles do not illuminate when the HSA is turned on, or that the headlights extinguish while on (subject failure).No other driving lights are affected.The front marker, tail, and instrument lamps operate.Also, the high beams can be illuminated by holding the turn signal stalk in the up position.As reported by consumers, turning the HSA off and on typically corrects the failure.Initially the failures occur infrequently but they become progressively more frequent with age.Chrysler has indicated its intention to offer of an extended lifetime warranty on the HSA, so that consumers with this problem can have their HSA replaced at no charge when they begin experiencing the subject failure.Commencing sometime in early 2013, Chrysler will send letters to SV owners notifying them of the lifetime warranty.The SV headlight system design is essentially the same as that described in EA 05-009, which involved headlight anomalies in earlier model Chrysler minivans; refer to it to for additional information.The subject failure is caused by friction between the plastic cam and metal surfaces of the electrical contacts in the HSA, which results in the production of plastic particles (debris).Analysis shows that debris can collect on the electrical contact that controls the headlights, resulting in an open circuit and preventing the headlights from turning on.Subsequent operation of the HSA may temporarily displace the debris, at which time the headlights operate correctly.Lubricant was applied to the plastic cam beginning in December 2005, reducing debris production.Consequently, subsequent failure levels were lower.The report counts shown above include only those that involve the subject failure.Reports involving other failure modes which were identified have not been included either because they were not safety related, or if they were safety related, because there was no defect trend.The single crash event listed in the Failure Report Summary Table above involved a deer strike allegedly due to loss of headlights in February 2006.No injuries were reported in this crash.An April 2004 non-crash incident (?Other? above) involved a momentary loss of headlights.The consumer drove into a ditch, and one minor injury was alleged. The subject vehicles experienced a 2.2% warranty claim rate.While standing alone this would appear to be significant, a portion of these warranty claims likely involve other problems with the HSA unrelated to the subject failure.In view of the on road experience of drivers in rapidly restoring headlight illumination by turning the headlight switch off and on again, the rate and particularly the recent trend in problems with the switch, and Chrysler?s extended lifetime warranty coupled with the owner notification of that extended warranty, further investigation does not appear to be warranted.Accordingly, the investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.Details on Chrysler?s lifetime HSA warranty extension for the SV population will be available in the public file for this investigation.
Exterior Lighting
The subject vehicle (SV) population includes MY 2005-2006 vehicles built between March 2004 and December 2005 manufactured with a TRW supplied headlight switch assembly (HSA).The HSA was the primary focus of the investigation; earlier and later vehicles utilized different HSAs.Consumers complain that the headlights in the subject vehicles do not illuminate when the HSA is turned on, or that the headlights extinguish while on (subject failure).No other driving lights are affected.The front marker, tail, and instrument lamps operate.Also, the high beams can be illuminated by holding the turn signal stalk in the up position.As reported by consumers, turning the HSA off and on typically corrects the failure.Initially the failures occur infrequently but they become progressively more frequent with age.Chrysler has indicated its intention to offer of an extended lifetime warranty on the HSA, so that consumers with this problem can have their HSA replaced at no charge when they begin experiencing the subject failure.Commencing sometime in early 2013, Chrysler will send letters to SV owners notifying them of the lifetime warranty.The SV headlight system design is essentially the same as that described in EA 05-009, which involved headlight anomalies in earlier model Chrysler minivans; refer to it to for additional information.The subject failure is caused by friction between the plastic cam and metal surfaces of the electrical contacts in the HSA, which results in the production of plastic particles (debris).Analysis shows that debris can collect on the electrical contact that controls the headlights, resulting in an open circuit and preventing the headlights from turning on.Subsequent operation of the HSA may temporarily displace the debris, at which time the headlights operate correctly.Lubricant was applied to the plastic cam beginning in December 2005, reducing debris production.Consequently, subsequent failure levels were lower.The report counts shown above include only those that involve the subject failure.Reports involving other failure modes which were identified have not been included either because they were not safety related, or if they were safety related, because there was no defect trend.The single crash event listed in the Failure Report Summary Table above involved a deer strike allegedly due to loss of headlights in February 2006.No injuries were reported in this crash.An April 2004 non-crash incident (?Other? above) involved a momentary loss of headlights.The consumer drove into a ditch, and one minor injury was alleged. The subject vehicles experienced a 2.2% warranty claim rate.While standing alone this would appear to be significant, a portion of these warranty claims likely involve other problems with the HSA unrelated to the subject failure.In view of the on road experience of drivers in rapidly restoring headlight illumination by turning the headlight switch off and on again, the rate and particularly the recent trend in problems with the switch, and Chrysler?s extended lifetime warranty coupled with the owner notification of that extended warranty, further investigation does not appear to be warranted.Accordingly, the investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.Details on Chrysler?s lifetime HSA warranty extension for the SV population will be available in the public file for this investigation.
Exterior Lighting:headlights
The subject vehicle (SV) population includes MY 2005-2006 vehicles built between March 2004 and December 2005 manufactured with a TRW supplied headlight switch assembly (HSA).The HSA was the primary focus of the investigation; earlier and later vehicles utilized different HSAs.Consumers complain that the headlights in the subject vehicles do not illuminate when the HSA is turned on, or that the headlights extinguish while on (subject failure).No other driving lights are affected.The front marker, tail, and instrument lamps operate.Also, the high beams can be illuminated by holding the turn signal stalk in the up position.As reported by consumers, turning the HSA off and on typically corrects the failure.Initially the failures occur infrequently but they become progressively more frequent with age.Chrysler has indicated its intention to offer of an extended lifetime warranty on the HSA, so that consumers with this problem can have their HSA replaced at no charge when they begin experiencing the subject failure.Commencing sometime in early 2013, Chrysler will send letters to SV owners notifying them of the lifetime warranty.The SV headlight system design is essentially the same as that described in EA 05-009, which involved headlight anomalies in earlier model Chrysler minivans; refer to it to for additional information.The subject failure is caused by friction between the plastic cam and metal surfaces of the electrical contacts in the HSA, which results in the production of plastic particles (debris).Analysis shows that debris can collect on the electrical contact that controls the headlights, resulting in an open circuit and preventing the headlights from turning on.Subsequent operation of the HSA may temporarily displace the debris, at which time the headlights operate correctly.Lubricant was applied to the plastic cam beginning in December 2005, reducing debris production.Consequently, subsequent failure levels were lower.The report counts shown above include only those that involve the subject failure.Reports involving other failure modes which were identified have not been included either because they were not safety related, or if they were safety related, because there was no defect trend.The single crash event listed in the Failure Report Summary Table above involved a deer strike allegedly due to loss of headlights in February 2006.No injuries were reported in this crash.An April 2004 non-crash incident (?Other? above) involved a momentary loss of headlights.The consumer drove into a ditch, and one minor injury was alleged. The subject vehicles experienced a 2.2% warranty claim rate.While standing alone this would appear to be significant, a portion of these warranty claims likely involve other problems with the HSA unrelated to the subject failure.In view of the on road experience of drivers in rapidly restoring headlight illumination by turning the headlight switch off and on again, the rate and particularly the recent trend in problems with the switch, and Chrysler?s extended lifetime warranty coupled with the owner notification of that extended warranty, further investigation does not appear to be warranted.Accordingly, the investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.Details on Chrysler?s lifetime HSA warranty extension for the SV population will be available in the public file for this investigation.
Exterior Lighting:headlights:switch
The subject vehicle (SV) population includes MY 2005-2006 vehicles built between March 2004 and December 2005 manufactured with a TRW supplied headlight switch assembly (HSA).The HSA was the primary focus of the investigation; earlier and later vehicles utilized different HSAs.Consumers complain that the headlights in the subject vehicles do not illuminate when the HSA is turned on, or that the headlights extinguish while on (subject failure).No other driving lights are affected.The front marker, tail, and instrument lamps operate.Also, the high beams can be illuminated by holding the turn signal stalk in the up position.As reported by consumers, turning the HSA off and on typically corrects the failure.Initially the failures occur infrequently but they become progressively more frequent with age.Chrysler has indicated its intention to offer of an extended lifetime warranty on the HSA, so that consumers with this problem can have their HSA replaced at no charge when they begin experiencing the subject failure.Commencing sometime in early 2013, Chrysler will send letters to SV owners notifying them of the lifetime warranty.The SV headlight system design is essentially the same as that described in EA 05-009, which involved headlight anomalies in earlier model Chrysler minivans; refer to it to for additional information.The subject failure is caused by friction between the plastic cam and metal surfaces of the electrical contacts in the HSA, which results in the production of plastic particles (debris).Analysis shows that debris can collect on the electrical contact that controls the headlights, resulting in an open circuit and preventing the headlights from turning on.Subsequent operation of the HSA may temporarily displace the debris, at which time the headlights operate correctly.Lubricant was applied to the plastic cam beginning in December 2005, reducing debris production.Consequently, subsequent failure levels were lower.The report counts shown above include only those that involve the subject failure.Reports involving other failure modes which were identified have not been included either because they were not safety related, or if they were safety related, because there was no defect trend.The single crash event listed in the Failure Report Summary Table above involved a deer strike allegedly due to loss of headlights in February 2006.No injuries were reported in this crash.An April 2004 non-crash incident (?Other? above) involved a momentary loss of headlights.The consumer drove into a ditch, and one minor injury was alleged. The subject vehicles experienced a 2.2% warranty claim rate.While standing alone this would appear to be significant, a portion of these warranty claims likely involve other problems with the HSA unrelated to the subject failure.In view of the on road experience of drivers in rapidly restoring headlight illumination by turning the headlight switch off and on again, the rate and particularly the recent trend in problems with the switch, and Chrysler?s extended lifetime warranty coupled with the owner notification of that extended warranty, further investigation does not appear to be warranted.Accordingly, the investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.Details on Chrysler?s lifetime HSA warranty extension for the SV population will be available in the public file for this investigation.
AQ10001 · Fleet Vehicle Recall Completion Audit
Opened Nov 18, 2010 · Closed Dec 28, 2015
Status: closed (inferred from source dates) · Unknown Or Other
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.
PE10022 · Loss Of Headlight Illumination
Opened Jul 12, 2010 · Closed Sep 13, 2011
Status: closed (inferred from source dates) · Electrical System; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
To date, ODI has interviewed several complainants who confirmed that the headlights fully extinguish, and remain extinguished, on an intermittent basis.In most cases this occurred while the vehicle was in motion.The occurrences do not show a repeatable pattern, and the problem occurs at a low frequency, typically one or more weeks between failures.For this reason most complainants have not attempted diagnosis or repair of the problem, so the cause is unknown, and the problem continues to occur.In the cases where repairs have been attempted, which consisted mainly of headlight switch and body control module replacements, mixed success is reported.In interviews complainants advised ODI that they can usually toggle the headlight switch, or turn on the high beams by actuating the column stalk (pulling it upward), when the headlights unexpectedly turn off.Complainants report that toggling the switch is usually effective, and the high beams have always been available when the column is used.During the course of the interviews ODI was able to obtain a few suspect headlamp switches for further evaluation.No verifiable crashes or injuries have been identified in the vehicle owner complaints (VOQs).Chrysler notes that its complaints also include allegations of dimming or flickering of the headlights in addition to loss of headlamps, and that their analysis of available data indicates a declining trend occurring in the field.Chrysler data reports two alleged crash incidents; one where a consumers vehicle lost forward lighting and struck a deer, and one where a consumer alleged their lighting stopped working, causing them to depart the roadway and drive into a ditch.A minor injury is alleged in this second incident.Both incidents occurred several years ago, and neither allegation has been confirmed by ODI.ODI is upgrading this investigation to an Engineering Analysis (EA11-010) to continue its analysis of the alleged defect and its consequences, which will include additional analysis of consumer reports, their frequency and trend, and Chrysler's technical information for the headlight system and its components.Additionally testing will be conducted to evaluate possible root cause(s) of the alleged defect, and will include analysis of suspect components collected from the field, and/or assessment of subject vehicles that have reportedly experienced the condition.
Additional source detail variants (3)
Electrical System
To date, ODI has interviewed several complainants who confirmed that the headlights fully extinguish, and remain extinguished, on an intermittent basis.In most cases this occurred while the vehicle was in motion.The occurrences do not show a repeatable pattern, and the problem occurs at a low frequency, typically one or more weeks between failures.For this reason most complainants have not attempted diagnosis or repair of the problem, so the cause is unknown, and the problem continues to occur.In the cases where repairs have been attempted, which consisted mainly of headlight switch and body control module replacements, mixed success is reported.In interviews complainants advised ODI that they can usually toggle the headlight switch, or turn on the high beams by actuating the column stalk (pulling it upward), when the headlights unexpectedly turn off.Complainants report that toggling the switch is usually effective, and the high beams have always been available when the column is used.During the course of the interviews ODI was able to obtain a few suspect headlamp switches for further evaluation.No verifiable crashes or injuries have been identified in the vehicle owner complaints (VOQs).Chrysler notes that its complaints also include allegations of dimming or flickering of the headlights in addition to loss of headlamps, and that their analysis of available data indicates a declining trend occurring in the field.Chrysler data reports two alleged crash incidents; one where a consumers vehicle lost forward lighting and struck a deer, and one where a consumer alleged their lighting stopped working, causing them to depart the roadway and drive into a ditch.A minor injury is alleged in this second incident.Both incidents occurred several years ago, and neither allegation has been confirmed by ODI.ODI is upgrading this investigation to an Engineering Analysis (EA11-010) to continue its analysis of the alleged defect and its consequences, which will include additional analysis of consumer reports, their frequency and trend, and Chrysler's technical information for the headlight system and its components.Additionally testing will be conducted to evaluate possible root cause(s) of the alleged defect, and will include analysis of suspect components collected from the field, and/or assessment of subject vehicles that have reportedly experienced the condition.
Exterior Lighting:headlights
To date, ODI has interviewed several complainants who confirmed that the headlights fully extinguish, and remain extinguished, on an intermittent basis.In most cases this occurred while the vehicle was in motion.The occurrences do not show a repeatable pattern, and the problem occurs at a low frequency, typically one or more weeks between failures.For this reason most complainants have not attempted diagnosis or repair of the problem, so the cause is unknown, and the problem continues to occur.In the cases where repairs have been attempted, which consisted mainly of headlight switch and body control module replacements, mixed success is reported.In interviews complainants advised ODI that they can usually toggle the headlight switch, or turn on the high beams by actuating the column stalk (pulling it upward), when the headlights unexpectedly turn off.Complainants report that toggling the switch is usually effective, and the high beams have always been available when the column is used.During the course of the interviews ODI was able to obtain a few suspect headlamp switches for further evaluation.No verifiable crashes or injuries have been identified in the vehicle owner complaints (VOQs).Chrysler notes that its complaints also include allegations of dimming or flickering of the headlights in addition to loss of headlamps, and that their analysis of available data indicates a declining trend occurring in the field.Chrysler data reports two alleged crash incidents; one where a consumers vehicle lost forward lighting and struck a deer, and one where a consumer alleged their lighting stopped working, causing them to depart the roadway and drive into a ditch.A minor injury is alleged in this second incident.Both incidents occurred several years ago, and neither allegation has been confirmed by ODI.ODI is upgrading this investigation to an Engineering Analysis (EA11-010) to continue its analysis of the alleged defect and its consequences, which will include additional analysis of consumer reports, their frequency and trend, and Chrysler's technical information for the headlight system and its components.Additionally testing will be conducted to evaluate possible root cause(s) of the alleged defect, and will include analysis of suspect components collected from the field, and/or assessment of subject vehicles that have reportedly experienced the condition.
Exterior Lighting:headlights:switch
To date, ODI has interviewed several complainants who confirmed that the headlights fully extinguish, and remain extinguished, on an intermittent basis.In most cases this occurred while the vehicle was in motion.The occurrences do not show a repeatable pattern, and the problem occurs at a low frequency, typically one or more weeks between failures.For this reason most complainants have not attempted diagnosis or repair of the problem, so the cause is unknown, and the problem continues to occur.In the cases where repairs have been attempted, which consisted mainly of headlight switch and body control module replacements, mixed success is reported.In interviews complainants advised ODI that they can usually toggle the headlight switch, or turn on the high beams by actuating the column stalk (pulling it upward), when the headlights unexpectedly turn off.Complainants report that toggling the switch is usually effective, and the high beams have always been available when the column is used.During the course of the interviews ODI was able to obtain a few suspect headlamp switches for further evaluation.No verifiable crashes or injuries have been identified in the vehicle owner complaints (VOQs).Chrysler notes that its complaints also include allegations of dimming or flickering of the headlights in addition to loss of headlamps, and that their analysis of available data indicates a declining trend occurring in the field.Chrysler data reports two alleged crash incidents; one where a consumers vehicle lost forward lighting and struck a deer, and one where a consumer alleged their lighting stopped working, causing them to depart the roadway and drive into a ditch.A minor injury is alleged in this second incident.Both incidents occurred several years ago, and neither allegation has been confirmed by ODI.ODI is upgrading this investigation to an Engineering Analysis (EA11-010) to continue its analysis of the alleged defect and its consequences, which will include additional analysis of consumer reports, their frequency and trend, and Chrysler's technical information for the headlight system and its components.Additionally testing will be conducted to evaluate possible root cause(s) of the alleged defect, and will include analysis of suspect components collected from the field, and/or assessment of subject vehicles that have reportedly experienced the condition.
RQ09003 · Front Air Bag Crash Sensor Failure
Opened Jul 1, 2009 · Closed Feb 18, 2010
Status: closed (inferred from source dates) · Air Bags:frontal; Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:sensor/control MODULE-INACTIVE
CHRYSLER WILL REPLACE THE FRAME RAIL-MOUNTED FRONT AIR BAG CRASH SENSORS IN APPROXIMATELY 312,442 MODEL YEAR (MY) 2005 AND 2006 CHRYSLER MINIVANS (RECALL 10V-008).THESE VEHICLES ARE EQUIPPED WITH FRONT CRASH SENSORS WITH ULTRADUR BRAND PLASTIC HOUSINGS AND STEEL BUSHINGS AND WERE BUILT BETWEEN JANUARY 19, 2005 AND APRIL 5, 2006.THIS ACTION COVERS VEHICLES ORIGINALLY SOLD, OR CURRENTLY REGISTERED, IN 27 STATES (ALASKA, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA AND WISCONSIN) AND THE DISTRICT OF COLUMBIA.VEHICLES SOLD OR CURRENTLY REGISTERED OUTSIDE OF THESE STATES, APPROXIMATELY 185,000 MY 2005-2006 MINIVANS, ARE NOT INCLUDED IN THE RECALL.ALTHOUGH THESE VEHICLES USE THE SAME CRASH SENSORS AND WERE BUILT DURING THE SAME PERIOD AS THE ONES DESCRIBED ABOVE, THEY EXPERIENCE SIGNIFICANTLY LOWER FAILURE RATES BECAUSE OF REDUCED ROAD SALT EXPOSURE.ALSO, MY 2006-2007 MINIVANS BUILT AFTER APRIL 5, 2006, ARE NOT INCLUDED IN THE RECALL.THESE VEHICLES ARE EQUIPPED WITH FRONT CRASH SENSORS WITH CRASTIN BRAND PLASTIC HOUSINGS AND STEEL BUSHINGS AND EXPERIENCE SIGNIFICANTLY LOWER FAILURE RATES COMPARED TO THE RECALLED VEHICLES.NHTSA AND CHRYSLER DIFFER REGARDING THE SIGNIFICANCE AND IMPACT OF THE DEFECT, BUT IN THE INTEREST OF REMEDYING THE AFFECTED VEHICLES EXPEDITIOUSLY AND TO AVOID A PROTRACTED DISPUTE, CHRYSLER IS IMPLEMENTING STEPS TO REPLACE THE FRONT CRASH SENSORS.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED THAT FURTHER USE OF ITS RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THE SUBJECT VEHICLES.THE AGENCY WILL MONITOR THE ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SELECT DOCUMENT SEARCH FOR ADDITIONAL INFORMATION.
Additional source detail variants (3)
Air Bags:frontal
CHRYSLER WILL REPLACE THE FRAME RAIL-MOUNTED FRONT AIR BAG CRASH SENSORS IN APPROXIMATELY 312,442 MODEL YEAR (MY) 2005 AND 2006 CHRYSLER MINIVANS (RECALL 10V-008).THESE VEHICLES ARE EQUIPPED WITH FRONT CRASH SENSORS WITH ULTRADUR BRAND PLASTIC HOUSINGS AND STEEL BUSHINGS AND WERE BUILT BETWEEN JANUARY 19, 2005 AND APRIL 5, 2006.THIS ACTION COVERS VEHICLES ORIGINALLY SOLD, OR CURRENTLY REGISTERED, IN 27 STATES (ALASKA, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA AND WISCONSIN) AND THE DISTRICT OF COLUMBIA.VEHICLES SOLD OR CURRENTLY REGISTERED OUTSIDE OF THESE STATES, APPROXIMATELY 185,000 MY 2005-2006 MINIVANS, ARE NOT INCLUDED IN THE RECALL.ALTHOUGH THESE VEHICLES USE THE SAME CRASH SENSORS AND WERE BUILT DURING THE SAME PERIOD AS THE ONES DESCRIBED ABOVE, THEY EXPERIENCE SIGNIFICANTLY LOWER FAILURE RATES BECAUSE OF REDUCED ROAD SALT EXPOSURE.ALSO, MY 2006-2007 MINIVANS BUILT AFTER APRIL 5, 2006, ARE NOT INCLUDED IN THE RECALL.THESE VEHICLES ARE EQUIPPED WITH FRONT CRASH SENSORS WITH CRASTIN BRAND PLASTIC HOUSINGS AND STEEL BUSHINGS AND EXPERIENCE SIGNIFICANTLY LOWER FAILURE RATES COMPARED TO THE RECALLED VEHICLES.NHTSA AND CHRYSLER DIFFER REGARDING THE SIGNIFICANCE AND IMPACT OF THE DEFECT, BUT IN THE INTEREST OF REMEDYING THE AFFECTED VEHICLES EXPEDITIOUSLY AND TO AVOID A PROTRACTED DISPUTE, CHRYSLER IS IMPLEMENTING STEPS TO REPLACE THE FRONT CRASH SENSORS.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED THAT FURTHER USE OF ITS RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THE SUBJECT VEHICLES.THE AGENCY WILL MONITOR THE ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SELECT DOCUMENT SEARCH FOR ADDITIONAL INFORMATION.
Air Bags:frontal:driver Side:inflator Module
CHRYSLER WILL REPLACE THE FRAME RAIL-MOUNTED FRONT AIR BAG CRASH SENSORS IN APPROXIMATELY 312,442 MODEL YEAR (MY) 2005 AND 2006 CHRYSLER MINIVANS (RECALL 10V-008).THESE VEHICLES ARE EQUIPPED WITH FRONT CRASH SENSORS WITH ULTRADUR BRAND PLASTIC HOUSINGS AND STEEL BUSHINGS AND WERE BUILT BETWEEN JANUARY 19, 2005 AND APRIL 5, 2006.THIS ACTION COVERS VEHICLES ORIGINALLY SOLD, OR CURRENTLY REGISTERED, IN 27 STATES (ALASKA, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA AND WISCONSIN) AND THE DISTRICT OF COLUMBIA.VEHICLES SOLD OR CURRENTLY REGISTERED OUTSIDE OF THESE STATES, APPROXIMATELY 185,000 MY 2005-2006 MINIVANS, ARE NOT INCLUDED IN THE RECALL.ALTHOUGH THESE VEHICLES USE THE SAME CRASH SENSORS AND WERE BUILT DURING THE SAME PERIOD AS THE ONES DESCRIBED ABOVE, THEY EXPERIENCE SIGNIFICANTLY LOWER FAILURE RATES BECAUSE OF REDUCED ROAD SALT EXPOSURE.ALSO, MY 2006-2007 MINIVANS BUILT AFTER APRIL 5, 2006, ARE NOT INCLUDED IN THE RECALL.THESE VEHICLES ARE EQUIPPED WITH FRONT CRASH SENSORS WITH CRASTIN BRAND PLASTIC HOUSINGS AND STEEL BUSHINGS AND EXPERIENCE SIGNIFICANTLY LOWER FAILURE RATES COMPARED TO THE RECALLED VEHICLES.NHTSA AND CHRYSLER DIFFER REGARDING THE SIGNIFICANCE AND IMPACT OF THE DEFECT, BUT IN THE INTEREST OF REMEDYING THE AFFECTED VEHICLES EXPEDITIOUSLY AND TO AVOID A PROTRACTED DISPUTE, CHRYSLER IS IMPLEMENTING STEPS TO REPLACE THE FRONT CRASH SENSORS.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED THAT FURTHER USE OF ITS RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THE SUBJECT VEHICLES.THE AGENCY WILL MONITOR THE ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SELECT DOCUMENT SEARCH FOR ADDITIONAL INFORMATION.
Air Bags:frontal:sensor/control MODULE-INACTIVE
CHRYSLER WILL REPLACE THE FRAME RAIL-MOUNTED FRONT AIR BAG CRASH SENSORS IN APPROXIMATELY 312,442 MODEL YEAR (MY) 2005 AND 2006 CHRYSLER MINIVANS (RECALL 10V-008).THESE VEHICLES ARE EQUIPPED WITH FRONT CRASH SENSORS WITH ULTRADUR BRAND PLASTIC HOUSINGS AND STEEL BUSHINGS AND WERE BUILT BETWEEN JANUARY 19, 2005 AND APRIL 5, 2006.THIS ACTION COVERS VEHICLES ORIGINALLY SOLD, OR CURRENTLY REGISTERED, IN 27 STATES (ALASKA, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA AND WISCONSIN) AND THE DISTRICT OF COLUMBIA.VEHICLES SOLD OR CURRENTLY REGISTERED OUTSIDE OF THESE STATES, APPROXIMATELY 185,000 MY 2005-2006 MINIVANS, ARE NOT INCLUDED IN THE RECALL.ALTHOUGH THESE VEHICLES USE THE SAME CRASH SENSORS AND WERE BUILT DURING THE SAME PERIOD AS THE ONES DESCRIBED ABOVE, THEY EXPERIENCE SIGNIFICANTLY LOWER FAILURE RATES BECAUSE OF REDUCED ROAD SALT EXPOSURE.ALSO, MY 2006-2007 MINIVANS BUILT AFTER APRIL 5, 2006, ARE NOT INCLUDED IN THE RECALL.THESE VEHICLES ARE EQUIPPED WITH FRONT CRASH SENSORS WITH CRASTIN BRAND PLASTIC HOUSINGS AND STEEL BUSHINGS AND EXPERIENCE SIGNIFICANTLY LOWER FAILURE RATES COMPARED TO THE RECALLED VEHICLES.NHTSA AND CHRYSLER DIFFER REGARDING THE SIGNIFICANCE AND IMPACT OF THE DEFECT, BUT IN THE INTEREST OF REMEDYING THE AFFECTED VEHICLES EXPEDITIOUSLY AND TO AVOID A PROTRACTED DISPUTE, CHRYSLER IS IMPLEMENTING STEPS TO REPLACE THE FRONT CRASH SENSORS.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED THAT FURTHER USE OF ITS RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THE SUBJECT VEHICLES.THE AGENCY WILL MONITOR THE ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SELECT DOCUMENT SEARCH FOR ADDITIONAL INFORMATION.
EA06003 · Front Air Bag Crash Sensor Failure
Opened Mar 8, 2006 · Closed May 22, 2007
Status: closed (inferred from source dates) · Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE
DAIMLERCHRYSLER (DCC) WILL REPLACE THE FRAME RAIL-MOUNTED FRONT AIR BAG CRASH SENSORS IN APPROXIMATELY 270,958 MY 2005 DAIMLERCHRYSLER MINIVANS (NHTSA RECALL NO. 07V-192).THESE VEHICLES ARE EQUIPPED WITH FRONT CRASH SENSORS WITH BRASS BUSHINGS AND WERE BUILT BETWEEN APRIL 24, 2003 AND FEBRUARY 2, 2005.THIS ACTION COVERS VEHICLES ORIGINALLY SOLD, OR CURRENTLY REGISTERED, IN 27 STATES (ALASKA, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA AND WISCONSIN) AND THE DISTRICT OF COLUMBIA.VEHICLES SOLD OR CURRENTLY REGISTERED OUTSIDE OF THESE STATES, APPROXIMATELY 133,128 MY 2005 MINIVANS, WILL RECEIVE A LIFETIME WARRANTY ON THE FRONT CRASH SENSORS.ALTHOUGH THESE VEHICLES USE THE SAME BRASS BUSHING SENSORS AND WERE BUILT DURING THE SAME PERIOD AS THE ONES DESCRIBED ABOVE, THEY EXPERIENCE SIGNIFICANTLY LOWER FAILURE RATES BECAUSE OF REDUCED ROAD SALT EXPOSURE.DCC WILL ALSO PROVIDE WRITTEN NOTIFICATION TO ALL AFFECTED VEHICLE OWNERS.NHTSA AND DCC DIFFER REGARDING THE SIGNIFICANCE AND IMPACT OF THE DEFECT, BUT IN THE INTEREST OF REMEDYING THE AFFECTED VEHICLES EXPEDITIOUSLY AND TO AVOID A PROTRACTED DISPUTE, DCC IS IMPLEMENTING STEPS TO REPLACE THE SUBJECT COMPONENTS.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED THAT FURTHER USE OF ITS RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THE SUBJECT VEHICLES.THE AGENCY WILL MONITOR THE ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SELECT DOCUMENT SEARCH FOR ADDITIONAL INFORMATION.
Additional source detail variants (2)
Air Bags:frontal
DAIMLERCHRYSLER (DCC) WILL REPLACE THE FRAME RAIL-MOUNTED FRONT AIR BAG CRASH SENSORS IN APPROXIMATELY 270,958 MY 2005 DAIMLERCHRYSLER MINIVANS (NHTSA RECALL NO. 07V-192).THESE VEHICLES ARE EQUIPPED WITH FRONT CRASH SENSORS WITH BRASS BUSHINGS AND WERE BUILT BETWEEN APRIL 24, 2003 AND FEBRUARY 2, 2005.THIS ACTION COVERS VEHICLES ORIGINALLY SOLD, OR CURRENTLY REGISTERED, IN 27 STATES (ALASKA, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA AND WISCONSIN) AND THE DISTRICT OF COLUMBIA.VEHICLES SOLD OR CURRENTLY REGISTERED OUTSIDE OF THESE STATES, APPROXIMATELY 133,128 MY 2005 MINIVANS, WILL RECEIVE A LIFETIME WARRANTY ON THE FRONT CRASH SENSORS.ALTHOUGH THESE VEHICLES USE THE SAME BRASS BUSHING SENSORS AND WERE BUILT DURING THE SAME PERIOD AS THE ONES DESCRIBED ABOVE, THEY EXPERIENCE SIGNIFICANTLY LOWER FAILURE RATES BECAUSE OF REDUCED ROAD SALT EXPOSURE.DCC WILL ALSO PROVIDE WRITTEN NOTIFICATION TO ALL AFFECTED VEHICLE OWNERS.NHTSA AND DCC DIFFER REGARDING THE SIGNIFICANCE AND IMPACT OF THE DEFECT, BUT IN THE INTEREST OF REMEDYING THE AFFECTED VEHICLES EXPEDITIOUSLY AND TO AVOID A PROTRACTED DISPUTE, DCC IS IMPLEMENTING STEPS TO REPLACE THE SUBJECT COMPONENTS.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED THAT FURTHER USE OF ITS RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THE SUBJECT VEHICLES.THE AGENCY WILL MONITOR THE ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SELECT DOCUMENT SEARCH FOR ADDITIONAL INFORMATION.
Air Bags:frontal:sensor/control MODULE-INACTIVE
DAIMLERCHRYSLER (DCC) WILL REPLACE THE FRAME RAIL-MOUNTED FRONT AIR BAG CRASH SENSORS IN APPROXIMATELY 270,958 MY 2005 DAIMLERCHRYSLER MINIVANS (NHTSA RECALL NO. 07V-192).THESE VEHICLES ARE EQUIPPED WITH FRONT CRASH SENSORS WITH BRASS BUSHINGS AND WERE BUILT BETWEEN APRIL 24, 2003 AND FEBRUARY 2, 2005.THIS ACTION COVERS VEHICLES ORIGINALLY SOLD, OR CURRENTLY REGISTERED, IN 27 STATES (ALASKA, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA AND WISCONSIN) AND THE DISTRICT OF COLUMBIA.VEHICLES SOLD OR CURRENTLY REGISTERED OUTSIDE OF THESE STATES, APPROXIMATELY 133,128 MY 2005 MINIVANS, WILL RECEIVE A LIFETIME WARRANTY ON THE FRONT CRASH SENSORS.ALTHOUGH THESE VEHICLES USE THE SAME BRASS BUSHING SENSORS AND WERE BUILT DURING THE SAME PERIOD AS THE ONES DESCRIBED ABOVE, THEY EXPERIENCE SIGNIFICANTLY LOWER FAILURE RATES BECAUSE OF REDUCED ROAD SALT EXPOSURE.DCC WILL ALSO PROVIDE WRITTEN NOTIFICATION TO ALL AFFECTED VEHICLE OWNERS.NHTSA AND DCC DIFFER REGARDING THE SIGNIFICANCE AND IMPACT OF THE DEFECT, BUT IN THE INTEREST OF REMEDYING THE AFFECTED VEHICLES EXPEDITIOUSLY AND TO AVOID A PROTRACTED DISPUTE, DCC IS IMPLEMENTING STEPS TO REPLACE THE SUBJECT COMPONENTS.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED THAT FURTHER USE OF ITS RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THE SUBJECT VEHICLES.THE AGENCY WILL MONITOR THE ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SELECT DOCUMENT SEARCH FOR ADDITIONAL INFORMATION.
PE05061 · Front Air Bag Crash Sensor Failure
Opened Nov 10, 2005 · Closed Mar 8, 2006
Status: closed (inferred from source dates) · Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE
THE MODEL YEAR (MY) 2005 DAIMLERCHRYSLER (DC) MINIVANS HAVE THE NEW ADVANCED FRONTAL AIR BAG SYSTEMS WITH TWO FRONT CRASH SENSORS MOUNTED ON THE FRAME RAILS BEHIND THE FRONT BUMPER AND A MAIN CRASH SENSOR INSIDE THE AIR BAG CONTROL MODULE MOUNTED IN THE PASSENGER COMPARTMENT.ACCORDING TO DC, THE FRONT CRASH SENSORS ARE DESIGNED TO OPTIMIZE DETECTION OF FRONTAL OFFSET AND ANGULAR CRASHES.THE ADVANCED AIR BAG SYSTEM OFFERS DIFFERENT LEVELS OF AIR BAG INFLATION BASED ON INPUT FROM THE CRASH SENSORS.THIS INVESTIGATION REVEALED THAT THE FRONT CRASH SENSORS CAN CORRODE FROM WATER ENTERING THE SENSOR ASSEMBLY.DC IS STILL INVESTIGATING ALL POTENTIAL ROOT CAUSES OF SENSOR FAILURES.A CORRODED SENSOR CAN SET A FAULT CODE, ILLUMINATE THE AIR BAG WARNING LAMP, AND BECOME DISABLED.IT APPEARS THAT FAILURE OF ONE OR BOTH FRONT CRASH SENSORS CAN POTENTIALLY RESULT IN NO/LATE DEPLOYMENT OF FRONTAL AIR BAGS AND NON-DEPLOYMENT OF DRIVER'S HIGHER INFLATION LEVELS IN CERTAIN FRONTAL CRASHES.IT SHOULD BE NOTED THAT OCCUPANTS OF VEHICLES INVOLVED IN A CRASH MAY NOT BE AWARE OF LATE OR IMPROPERLY REDUCED LEVEL OF AIR BAG INFLATION AND THUS FIELD REPORTING OF SUCH EVENTS MAY BE SUPPRESSED.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA06-003) FOR FURTHER INVESTIGATION OF MY 2005 (AND 2006) DC MINIVANS.NOTE: TOTAL NUMBER OF ODI AND MANUFACTURER COMPLAINTS INCLUDES SOME DUPLICATE REPORTS.
Additional source detail variants (2)
Air Bags:frontal
THE MODEL YEAR (MY) 2005 DAIMLERCHRYSLER (DC) MINIVANS HAVE THE NEW ADVANCED FRONTAL AIR BAG SYSTEMS WITH TWO FRONT CRASH SENSORS MOUNTED ON THE FRAME RAILS BEHIND THE FRONT BUMPER AND A MAIN CRASH SENSOR INSIDE THE AIR BAG CONTROL MODULE MOUNTED IN THE PASSENGER COMPARTMENT.ACCORDING TO DC, THE FRONT CRASH SENSORS ARE DESIGNED TO OPTIMIZE DETECTION OF FRONTAL OFFSET AND ANGULAR CRASHES.THE ADVANCED AIR BAG SYSTEM OFFERS DIFFERENT LEVELS OF AIR BAG INFLATION BASED ON INPUT FROM THE CRASH SENSORS.THIS INVESTIGATION REVEALED THAT THE FRONT CRASH SENSORS CAN CORRODE FROM WATER ENTERING THE SENSOR ASSEMBLY.DC IS STILL INVESTIGATING ALL POTENTIAL ROOT CAUSES OF SENSOR FAILURES.A CORRODED SENSOR CAN SET A FAULT CODE, ILLUMINATE THE AIR BAG WARNING LAMP, AND BECOME DISABLED.IT APPEARS THAT FAILURE OF ONE OR BOTH FRONT CRASH SENSORS CAN POTENTIALLY RESULT IN NO/LATE DEPLOYMENT OF FRONTAL AIR BAGS AND NON-DEPLOYMENT OF DRIVER'S HIGHER INFLATION LEVELS IN CERTAIN FRONTAL CRASHES.IT SHOULD BE NOTED THAT OCCUPANTS OF VEHICLES INVOLVED IN A CRASH MAY NOT BE AWARE OF LATE OR IMPROPERLY REDUCED LEVEL OF AIR BAG INFLATION AND THUS FIELD REPORTING OF SUCH EVENTS MAY BE SUPPRESSED.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA06-003) FOR FURTHER INVESTIGATION OF MY 2005 (AND 2006) DC MINIVANS.NOTE: TOTAL NUMBER OF ODI AND MANUFACTURER COMPLAINTS INCLUDES SOME DUPLICATE REPORTS.
Air Bags:frontal:sensor/control MODULE-INACTIVE
THE MODEL YEAR (MY) 2005 DAIMLERCHRYSLER (DC) MINIVANS HAVE THE NEW ADVANCED FRONTAL AIR BAG SYSTEMS WITH TWO FRONT CRASH SENSORS MOUNTED ON THE FRAME RAILS BEHIND THE FRONT BUMPER AND A MAIN CRASH SENSOR INSIDE THE AIR BAG CONTROL MODULE MOUNTED IN THE PASSENGER COMPARTMENT.ACCORDING TO DC, THE FRONT CRASH SENSORS ARE DESIGNED TO OPTIMIZE DETECTION OF FRONTAL OFFSET AND ANGULAR CRASHES.THE ADVANCED AIR BAG SYSTEM OFFERS DIFFERENT LEVELS OF AIR BAG INFLATION BASED ON INPUT FROM THE CRASH SENSORS.THIS INVESTIGATION REVEALED THAT THE FRONT CRASH SENSORS CAN CORRODE FROM WATER ENTERING THE SENSOR ASSEMBLY.DC IS STILL INVESTIGATING ALL POTENTIAL ROOT CAUSES OF SENSOR FAILURES.A CORRODED SENSOR CAN SET A FAULT CODE, ILLUMINATE THE AIR BAG WARNING LAMP, AND BECOME DISABLED.IT APPEARS THAT FAILURE OF ONE OR BOTH FRONT CRASH SENSORS CAN POTENTIALLY RESULT IN NO/LATE DEPLOYMENT OF FRONTAL AIR BAGS AND NON-DEPLOYMENT OF DRIVER'S HIGHER INFLATION LEVELS IN CERTAIN FRONTAL CRASHES.IT SHOULD BE NOTED THAT OCCUPANTS OF VEHICLES INVOLVED IN A CRASH MAY NOT BE AWARE OF LATE OR IMPROPERLY REDUCED LEVEL OF AIR BAG INFLATION AND THUS FIELD REPORTING OF SUCH EVENTS MAY BE SUPPRESSED.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA06-003) FOR FURTHER INVESTIGATION OF MY 2005 (AND 2006) DC MINIVANS.NOTE: TOTAL NUMBER OF ODI AND MANUFACTURER COMPLAINTS INCLUDES SOME DUPLICATE REPORTS.
Illustration