Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
190–25K
4425–50K
5450–75K
3875–100K
64100–150K
29150K+
248 reports with mileage · 194 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Power Train. Review the 95 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine And Engine Cooling. Review the 76 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Suspension. Review the 56 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
27 crash reports13 fire reports15 injury reports
What owners actually said
442 reports
42,000 miles · Dec 16, 2004
Power Train
TRANSMISSION FAILURE AT 42,000 MILES. PROBLEMS WITH TRANSMISSION SHUDDER, TSB 18-05-94. I HAD BROUGHT THE TRANSMISSION SHUDDER TO THE DEALERS ATTENTION STARTING AT AROUND 32,000 MILES. DEALER SAID THEY COULD NOT FIND ANYTHING WRONG. THEY RE-FLASHED THE COMPUTER, ETC. VAN WAS BROUGHT BACK TO DEALER TWICE BEFORE 36,000 MILE WARRAN…
Read full complaint
TRANSMISSION FAILURE AT 42,000 MILES. PROBLEMS WITH TRANSMISSION SHUDDER, TSB 18-05-94. I HAD BROUGHT THE TRANSMISSION SHUDDER TO THE DEALERS ATTENTION STARTING AT AROUND 32,000 MILES. DEALER SAID THEY COULD NOT FIND ANYTHING WRONG. THEY RE-FLASHED THE COMPUTER, ETC. VAN WAS BROUGHT BACK TO DEALER TWICE BEFORE 36,000 MILE WARRANTY EXPIRED. BROUGHT THE VAN BACK AT 37,000 MILES TO COMPLAIN AGAIN AND DEALER PROCEEDED TO TELL US THAT THEY HAVE NO RECORDS OF ANY PRIOR COMPLAINT REGARDING THE TRANSMISSION, THEREFORE THEY WOULD HAVE TO CHARGE US TO RE-FLASH THE TRANSMISSION. (I WILL NEVER LOSE OR THROW AWAY ANY WARRANTY RELATED RECEIPTS AGAIN). AFTER GOING BACK AND FORTH AND GETTING NOWHERE WE PAID THE RE-FLASH FEE AND ONCE AGAIN THE THEY TOLD US THERE WAS NOTHING WRONG. THEN AT ABOUT 42,000 MILES THE TRANSMISSION BLEW. THIS AFTER THE DEALER TOLD US ON A MINIMUM OF 4 OCCASIONS THE TRANSMISSION WAS FINE. AFTER SOME "POLITE" NEGOTIATION I GOT THE DEALER TO COVER HALF OF THE $1300.00 REPAIR COST TO REPLACE THE TRANSMISSION PUMP. OF COURSE THEY DIDN'T COVER THE FLATBED & RENTAL CAR EXPENSES. I HAVE NEVER OWNED A CAR THAT I HAVE HAD TO REPAIR OR REPLACE A TRANSMISSION AND I HAD DRIVEN MOST OF THEM WELL OVER 100,000 MILES. I DO NOT UNDERSTAND HOW CHRYSLER CAN GET AWAY WITH THIS. WITH ALL OF THE DISGRUNTLED CHRYSLER CUSTOMERS ON THE INTERNET I CAN'T BELEIVE THE NHTSA ISN'T INVESTIGATING THEIR TRANSMISSIONS. WHO IS PAYING OFF WHO?*AK
NHTSA ODI #10103065
18,222 miles · Dec 11, 2004
Power TrainSuspension
MAKE : DODGE MODEL : GRAND CARAVAN YEAR : 2000 MANUFACTURER : DAIMLERCHRYSLER CORPORATION CRASH : NO FIRE : NO NUMBER OF INJURIES: 0 ODI ID NUMBER : 10100418 DATE OF FAILURE: NOVEMBER 20, 2004. *JB VIN : NOT AVAILABLE COMPONENT: CV JOINT.AXLE PROBLEM SUMMARY: I TOOK MY 2000 DODGE GRAND CARAVAN IN ON A FRIDAY TO…
Read full complaint
MAKE : DODGE MODEL : GRAND CARAVAN YEAR : 2000 MANUFACTURER : DAIMLERCHRYSLER CORPORATION CRASH : NO FIRE : NO NUMBER OF INJURIES: 0 ODI ID NUMBER : 10100418 DATE OF FAILURE: NOVEMBER 20, 2004. *JB VIN : NOT AVAILABLE COMPONENT: CV JOINT.AXLE PROBLEM SUMMARY: I TOOK MY 2000 DODGE GRAND CARAVAN IN ON A FRIDAY TO THE DEALER FOR THE AIR BAG RECALL (CLOCKSPRING- WHICH BY THE WAY THE AIRBAG REALLY STAYS ON NOW, WHERE IT DID NOT BEFORE THE DEALER REPLACED/REPAIRED THE CLOCKSPRING) AND PLUS THE DEALER CALLED ME TO TELL ME THAT HAD FOUND A LEAK IN THE MASTER CYLINDER WHICH THEY WANTED TO FIX. I SAID YES (NOW I SEE THERE ARE SEVERAL COMPLAINTS ABOUT MASTER CYLINDER LEAKS) I PICKED UP MY VAN UP ON FRIDAY EVENING AFTER WORK. SATURDAY MORNING I RAN A COUPLE OF ERRANDS AROUND TOWN AND AT 12:30 P.M. BEGAN TO BACK OUT OF A PARKING SPOT AND HEARD A LOUD NOISE. I PROCEEDED OUT OF THE PARKING STRUCTURE AND ONLY MADE IT AS FAR AS THE STREET BEFORE COMING TO A COMPLETE STOP. I CALLED FOR A TOW. THE TOW TRUCK DRIVER SAID THAT MY WHEEL ON THE FRONT DRIVER'S SIDE DID NOT APPEAR TO BE COMPLETELY ATTACHED TO THE AXLE. HE TOWED IT TO THE DEALER. THE SERVICE DEPARTMENT ON MONDAY INFORMED ME THAT MY CV JOINT/AXLE HAD BROKEN. A BROKEN AXLE ON A 2000 THAT HAS 18,222 MILES ON IT. HOW DOES THIS HAPPEN UNDER NORMAL DRIVING CONDITIONS? MY KIDS AND I WERE LUCKY THAT I WAS NOT GOING FAST OR DRIVING DOWN A FREEWAY. NOW I SEE ON THE NEWS THIS MORNING THAT THERE IS A RECALL FOR DAKOTA TRUCKS AND DURANGOS, BUT NOT CARAVANS. WHAT'S UP WITH THAT? *JB
NHTSA ODI #10102711
Mileage unknown · Dec 7, 2004
Air Bags
AIR BAG LIGHT APPEARED ON THE DASHBOARD AND REMAINED ON. CONSUMER TOOK VEHICLE TO THE DEALER FOR INSPECTION, AND MECHANIC DETERMINED THAT THE RECALL WAS NOT FOR THIS VEHICLE. *AK *TC
NHTSA ODI #10099800
55,000 miles · Dec 1, 2004
Engine And Engine Cooling
SERPENTINE BELT CAME OFF EVERY TIME CONSUMER HIT A PUDDLE. THE BELT CAME OFF FOUR TIMES, AND WAS BEING SERVICED AGAIN.*AK
NHTSA ODI #10101926
109,000 miles · Nov 26, 2004
Engine And Engine Cooling
CONSUMER STATED EVERYTIME IT RAINED THE OIL SENSOR LIGHT CAME ON AND STAYED ON. DEALER STATED THEY COULD NOT DUPLICATE THE PROBLEM. *AK
NHTSA ODI #10101654
18,222 miles · Nov 23, 2004
Suspension
I TOOK MY 2000 DODGE GRAND CARAVAN IN ON A FRIDAY TO THE DEALER FOR THE AIR BAG RECALL (CLOCKSPRING) AND PICKED UP MY VAN UP ON FRIDAY EVENING AFTER WORK. SATURDAY MORNING I RAN A COUPLE OF ERRANDS AROUND TOWN AND AT 12:30 P.M. BEGAN TO BACK OUT OF A PARKING SPOT AND HEARD A LOUD NOISE. I PROCEEDED OUT OF THE PARKING STRUCTURE…
Read full complaint
I TOOK MY 2000 DODGE GRAND CARAVAN IN ON A FRIDAY TO THE DEALER FOR THE AIR BAG RECALL (CLOCKSPRING) AND PICKED UP MY VAN UP ON FRIDAY EVENING AFTER WORK. SATURDAY MORNING I RAN A COUPLE OF ERRANDS AROUND TOWN AND AT 12:30 P.M. BEGAN TO BACK OUT OF A PARKING SPOT AND HEARD A LOUD NOISE. I PROCEEDED OUT OF THE PARKING STRUCTURE AND ONLY MADE IT AS FAR AS THE STREET BEFORE COMING TO A COMPLETE STOP. I CALLED FOR A TOW. THE TOW TRUCK DRIVER SAID THAT MY WHEEL ON THE FRONT DRIVER'S SIDE DID NOT APPEAR TO BE COMPLETE ATTACHED TO THE AXLE. HE TOWED IT TO THE DEALER. THE SERVICE DEPARTMENT ON MONDAY INFORMED ME THAT MY AXLE HAD BROKEN. A BROKEN AXLE ON A 2000 THAT HAS 18,222 MILES ON IT. HOW DOES THIS HAPPEN UNDER NORMAL DRIVING CONDITIONS? I WAS VERY LUCKY THIS DID NOT HAPPEN ON A BUSY STREET OR FREEWAY. *AK
NHTSA ODI #10100418
50,000 miles · Nov 12, 2004
Air BagsCrashInjury
CONSUMER RECEIVED RECALL 04V480000 CONCERNING AIR BAG CLOCK SPRING FAILURE FROM THE MANUFACTURER. HOWEVER, 1 YEAR AGO VEHICLE WAS IN AN ACCIDENT. VEHICLE WAS TOTALED. ALSO, UPON IMPACT, AIR BAGS DID NOT DEPLOY.*AK
NHTSA ODI #10099877
16,000 miles · Nov 5, 2004
Power Train
VEHICLE CAN BE PUT INTO GEAR WITHOUT THE BRAKE PEDAL BEING DEPRESSED . CONSUMER'S CHILD WAS ABLE TO PUT THE VEHICLE IN GEAR, ALMOST CAUSING AN ACCIDENT WHILE PARKED IN DRIVEWAY.*AK
NHTSA ODI #10099511
100 miles · Nov 5, 2004
Structure
DODGE GRAND CARAVAN 2000 - FRONT PASSENGER DOOR AREA LEAK CONTINUES DESPITE HAVING HAD IT "REPAIRED" AT THE DEALER TWICE. MOST NOTICEABLE IS THAT THE LEAK OCCURS WHEN THE VAN SITS IN THE DRIVE WITH THE WINDOWS ROLLED UP. NO EVIDENCE OF WHERE THE WATER COMES FROM, JUST THE PUDDLE AT THE PASSENGER FRONT DOOR SILL.*AK
NHTSA ODI #10098330
Mileage unknown · Nov 3, 2004
Exterior Lighting
CONSUMER NOTICED THAT THE TAIL LIGHTS WERE INOPERATIVE. VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION. *AK
ACCESS OPTIONS IS RECALLING CERTAIN TRUCKS AND VANS BUILT ON FORD E150, E350, TOYOTA SIENNA, AND DODGE GRAND CARAVAN CHASSIS AND EQUIPPED WITH VMI/RICON 6-WAY POWER SEAT BASES. THE SIX WAY POWER SEAT BASE MAY HAVE A DEFECTIVE (COLD) WELD ON THE PIVOT PIN WHICH IS WELDED TO THE SWIVEL PLATE. THE WELD COULD FAIL.
Consequence & remedy
Consequence: THE SEAT OCCUPANT MAY BE INJURED IF THE SEAT BASE PIN WERE TO BREAK.
Remedy: THE SWIVEL PLATE WILL BE REPLACED FREE OF CHARGE IF NECESSARY. THE RECALL BEGAN ON JUNE 8, 2010. OWNERS MAY CONTACT ACCESS OPTION AT 831-722-6804.
ON CERTAIN MINIVANS, THE DRIVER'S AIR BAG MAY BECOME DISABLED DUE TO A FAILURE OF THE CLOCKSPRING, WHICH IS LOCATED IN THE HUB OF THE STEERING WHEEL.
Consequence & remedy
Consequence: THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL COVERED VEHICLES WITH 70,000 MILES OR LESS. FOR THOSE VEHICLES WITH MORE THAN 70,000 MILES, DAIMLERCHRYSLER WILL OFFER AN EXTENDED LIFETIME WARRANTY UNDER WHICH IT WILL REPLACE THE CLOCKSPRING AT NO CHARGE IF IT FAILS. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. THE RECALL BEGAN ON OCTOBER 12, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
ON CERTAIN MINIVANS AND 4X2 PICKUP TRUCKS, THE VEHICLE CERTIFICATION LABEL MAY HAVE GROSS AXLE WEIGHT RATINGS (GAWR) THAT EXCEED THE MAXIMUM TIRE LOAD CAPACITY AS DEFINED IN FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."
Consequence & remedy
Consequence: IMPROPERLY LOADING YOUR VEHICLE CAN CAUSE TIRE FAILURE AND RESULT IN A CRASH.
Remedy: OWNERS WILL BE PROVIDED WITH VEHICLE CERTIFICATION LABEL OVERLAYS CONTAINING CORRECTED INFORMATION RELATIVE TO VEHICLE GAWR AND TIRE SIZE. OWNER NOTIFICATION BEGAN MARCH 1, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-992-1997.
CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.
Consequence & remedy
Consequence: THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.
Remedy: DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.
VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A SEAL ON THE VEHICLE FUEL RAILS TO PREVENT EXTERNAL LEAKAGE OF FUEL FROM THE FUEL RAIL CROSSOVER TUBE, SHOULD THE EXISTING O-RINGS CONTINUE TO DEGRADE. OWNER NOTIFICATION BEGAN ON JANUARY 25, 2002. DUE TO THE LARGE QUANTITY OF VEHICLES INVOLVED IN THIS CAMPAIGN, THE OWNER NOTIFICATION WILL BE PHASED OVER THE NEXT SEVERAL MONTHS. HOWEVER, IF A VEHICLE IS LEAKING FUEL FROM THE O-RINGS, THE VEHICLE SHOULD BE TAKEN INTO A DEALER TO HAVE THIS REPAIRED AS SOON AS POSSIBLE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
EA04013 · Driver Air Bag Clockspring Failure
Opened Jun 4, 2004 · Closed May 25, 2005
Status: closed (inferred from source dates) · Air Bags:frontal
THE DRIVER AIR BAG CLOCKSPRING CAN DEVELOP AN OPEN-CIRCUIT CONDITION RESULTING IN NONFUNCTIONAL DRIVER-SIDE FRONTAL AIR BAG, HORN, CRUISE CONTROL (IF EQUIPPED), AND/OR STEERING WHEEL RADIO CONTROL (IF EQUIPPED).IN ITS OCTOBER 5, 2004 LETTER TO NHTSA, DAIMLERCHRYSLER STATED THAT IT WILL CONDUCT A SAFETY RECALL AND REPLACE THE CLOCKSPRING ASSEMBLY ON ALL MY 1998.5-2000 DAIMLERCHRYSLER MINIVANS, BUILT BETWEEN MARCH 1998 AND AUGUST 2000, WITH 70,000 MILES OR LESS.IT WILL ALSO PROVIDE A LIFETIME WARRANTY FOR THIS COMPONENT ON MY 1998.5-2000 MINIVANS, REGARDLESS OF MILEAGE.THE DETAILS OF THE CORRECTIVE ACTION ARE DESCRIBED IN DAIMLERCHRYSLER'S LETTER (SEE RECALL NO. 04V-480).THE AGENCY BELIEVES THAT FURTHER EXPENDITURE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS WITH RESPECT TO THOSE VEHICLES COVERED ONLY BY THE LIFETIME WARRANTY.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE PAGE 2 FOR ADDITIONAL INFORMATION.
EA01007 · Air Bag Clockspring
Opened Feb 21, 2001 · Closed Nov 22, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
RQ00008 · Dc Minivan Fuel Injector Rail Leak
Opened Mar 9, 2000 · Closed Mar 18, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
2000 Dodge Grand Caravan Problems, Complaints & Recalls | Skip That Year
Illustration