IllustrationWHEN DRIVING (USUALLY ACCELERATING) THE ENGINE WILL STOP RUNNING CAUSING DIFFICULT BREAKING AND STEERING. THIS HAS HAPPENED ON MULTIPLE OCCASIONS AND GETTING WORSE!!!!! THE STEERING WHEEL MUST BE TILTED UP BEFORE IT WILL RESTART. *TR
2000 Dodge Grand Caravan
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2000 Dodge Grand Caravan do not stand out strongly from the model-year median of 284.
About this comparison →How this year compares
Owner complaints by model year
Compare all Grand Caravan years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
190–25K
4425–50K
5450–75K
3875–100K
64100–150K
29150K+
248 reports with mileage · 194 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 95 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 76 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 56 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
27 crash reports13 fire reports15 injury reports
Service Brakes complaints
4 reportsREAR BRAKE LINES HAVE RUSTED AND FAILED. THEY HAVE RUSTED AND FAILED IN THE AREA JUST BEHIND THE ABS MODULE WHERE THE BRAIDED LINES ARE CONNECTED TO THE RIGID LINES. THE REST OF THE BRAKE LINES ARE IN FINE SHAPE. THE ONLY AREAS WHERE THEY ARE BAD IS WHERE THE BRAIDED SECTIONS CONNECT TO THE RIGID SECTIONS. *TR
MILEAGE AT TIME OF INCIDENT: 123860 MILES. WHILE DRIVING THIS LOANER VEHICLE OF A FRIEND. I ENCOUNTERED A SUDDEN AND UNEXPECTED HYDRAULIC BRAKE FAILURE WHILE STOPPING. LOSS OF BRAKE FLUID. MECHANICAL BRAKING WAS AVAILABLE. ASSESSMENT OF SYSTEM SHOWED NO LEAKS ON OR AROUND BOOSTER, MASTER CYLINDER OR ABS DISTRIBUTION MODULE. A…
Read full complaint
MILEAGE AT TIME OF INCIDENT: 123860 MILES. WHILE DRIVING THIS LOANER VEHICLE OF A FRIEND. I ENCOUNTERED A SUDDEN AND UNEXPECTED HYDRAULIC BRAKE FAILURE WHILE STOPPING. LOSS OF BRAKE FLUID. MECHANICAL BRAKING WAS AVAILABLE. ASSESSMENT OF SYSTEM SHOWED NO LEAKS ON OR AROUND BOOSTER, MASTER CYLINDER OR ABS DISTRIBUTION MODULE. APPROXIMATELY 50MM OF SEVERE CORROSION OF THE TWO, RIGID STEEL BRAKE TUBING SECTIONS, ORIGINATING FROM THE SECOND JUNCTIONS OF THE FLEXIBLE HOSES TO THE RESPECTIVE RIGID STEEL BRAKE TUBING, THAT RUN ALONG THE DRIVER SIDE FRAME. WHEN THE BRAKING SYSTEM WAS USED TO STOP, THE SUDDEN INCREASE OF HYDRAULIC PRESSURE CAUSED A STRUCTURAL FAILURE OF THE DEGRADED TUBING. THIS FAILURE CAUSED THE CATASTROPHIC LOSS OF HYDRAULIC BRAKE FLUID AND LOSS OF THE HYDRAULIC BRAKING SYSTEM. THIS FAILURE RESULTED IN A NEAR COLLISION WITH ANOTHER VEHICLE. PHOTOGRAPHS WERE TAKEN OF THE BRAKE LINE TUBING AND JUNCTION AND SHOW THE SEVERITY OF THE CORROSION. THIS COMPLAINT IS CONSISTENT WITH OTHER SIMILAR COMPLAINTS FOR THIS MODEL AND VEHICLE AND MODEL YEAR AS POSTED ON THE NHTSA.GOV WEBSITE. *TR
WHILE DRIVING @ 35 MPH I TRIED TO APPLY MY BRAKES AND THE PEDAL WENT TO THE FLOOR. I WAS ABLE TO GET THE CAR STOPPED AND OFF THE ROADWAY. WHEN I LOOKED UNDER MY VAN I HAD LOST ALL BRAKE FLUID. I WAS TOWED TO A REPAIR SHOP AND INFORMED THE BRAKE LINES BURST. THIS VAN HAS BEEN IN THE FAMILY SINCE 2003. EVERY YEAR THE BRAKE LINES M…
Read full complaint
WHILE DRIVING @ 35 MPH I TRIED TO APPLY MY BRAKES AND THE PEDAL WENT TO THE FLOOR. I WAS ABLE TO GET THE CAR STOPPED AND OFF THE ROADWAY. WHEN I LOOKED UNDER MY VAN I HAD LOST ALL BRAKE FLUID. I WAS TOWED TO A REPAIR SHOP AND INFORMED THE BRAKE LINES BURST. THIS VAN HAS BEEN IN THE FAMILY SINCE 2003. EVERY YEAR THE BRAKE LINES MUST BE REPLACED. THIS SHOULD NOT BE. THANKS TO MY EXPERTISE I WAS ABLE TO PREVENT AN ACCIDENT TODAY. WAS I LUCKY??? *TR
Official recalls
510V270000 · Seats
Jun 17, 2010
ACCESS OPTIONS IS RECALLING CERTAIN TRUCKS AND VANS BUILT ON FORD E150, E350, TOYOTA SIENNA, AND DODGE GRAND CARAVAN CHASSIS AND EQUIPPED WITH VMI/RICON 6-WAY POWER SEAT BASES. THE SIX WAY POWER SEAT BASE MAY HAVE A DEFECTIVE (COLD) WELD ON THE PIVOT PIN WHICH IS WELDED TO THE SWIVEL PLATE. THE WELD COULD FAIL.
Consequence & remedy
Consequence: THE SEAT OCCUPANT MAY BE INJURED IF THE SEAT BASE PIN WERE TO BREAK.
Remedy: THE SWIVEL PLATE WILL BE REPLACED FREE OF CHARGE IF NECESSARY. THE RECALL BEGAN ON JUNE 8, 2010. OWNERS MAY CONTACT ACCESS OPTION AT 831-722-6804.
04V480000 · Air Bags
Oct 6, 2004
ON CERTAIN MINIVANS, THE DRIVER'S AIR BAG MAY BECOME DISABLED DUE TO A FAILURE OF THE CLOCKSPRING, WHICH IS LOCATED IN THE HUB OF THE STEERING WHEEL.
Consequence & remedy
Consequence: THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL COVERED VEHICLES WITH 70,000 MILES OR LESS. FOR THOSE VEHICLES WITH MORE THAN 70,000 MILES, DAIMLERCHRYSLER WILL OFFER AN EXTENDED LIFETIME WARRANTY UNDER WHICH IT WILL REPLACE THE CLOCKSPRING AT NO CHARGE IF IT FAILS. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. THE RECALL BEGAN ON OCTOBER 12, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
03V505000 · Equipment:other:labels
Dec 10, 2003
ON CERTAIN MINIVANS AND 4X2 PICKUP TRUCKS, THE VEHICLE CERTIFICATION LABEL MAY HAVE GROSS AXLE WEIGHT RATINGS (GAWR) THAT EXCEED THE MAXIMUM TIRE LOAD CAPACITY AS DEFINED IN FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."
Consequence & remedy
Consequence: IMPROPERLY LOADING YOUR VEHICLE CAN CAUSE TIRE FAILURE AND RESULT IN A CRASH.
Remedy: OWNERS WILL BE PROVIDED WITH VEHICLE CERTIFICATION LABEL OVERLAYS CONTAINING CORRECTED INFORMATION RELATIVE TO VEHICLE GAWR AND TIRE SIZE. OWNER NOTIFICATION BEGAN MARCH 1, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-992-1997.
03V094000 · Structure
Mar 7, 2003
CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.
Consequence & remedy
Consequence: THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.
Remedy: DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.
00V268000 · Fuel System, Gasoline:fuel Injection System
Sep 13, 2000
VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A SEAL ON THE VEHICLE FUEL RAILS TO PREVENT EXTERNAL LEAKAGE OF FUEL FROM THE FUEL RAIL CROSSOVER TUBE, SHOULD THE EXISTING O-RINGS CONTINUE TO DEGRADE. OWNER NOTIFICATION BEGAN ON JANUARY 25, 2002. DUE TO THE LARGE QUANTITY OF VEHICLES INVOLVED IN THIS CAMPAIGN, THE OWNER NOTIFICATION WILL BE PHASED OVER THE NEXT SEVERAL MONTHS. HOWEVER, IF A VEHICLE IS LEAKING FUEL FROM THE O-RINGS, THE VEHICLE SHOULD BE TAKEN INTO A DEALER TO HAVE THIS REPAIRED AS SOON AS POSSIBLE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA04013 · Driver Air Bag Clockspring Failure
Opened Jun 4, 2004 · Closed May 25, 2005
Status: closed (inferred from source dates) · Air Bags:frontal
THE DRIVER AIR BAG CLOCKSPRING CAN DEVELOP AN OPEN-CIRCUIT CONDITION RESULTING IN NONFUNCTIONAL DRIVER-SIDE FRONTAL AIR BAG, HORN, CRUISE CONTROL (IF EQUIPPED), AND/OR STEERING WHEEL RADIO CONTROL (IF EQUIPPED).IN ITS OCTOBER 5, 2004 LETTER TO NHTSA, DAIMLERCHRYSLER STATED THAT IT WILL CONDUCT A SAFETY RECALL AND REPLACE THE CLOCKSPRING ASSEMBLY ON ALL MY 1998.5-2000 DAIMLERCHRYSLER MINIVANS, BUILT BETWEEN MARCH 1998 AND AUGUST 2000, WITH 70,000 MILES OR LESS.IT WILL ALSO PROVIDE A LIFETIME WARRANTY FOR THIS COMPONENT ON MY 1998.5-2000 MINIVANS, REGARDLESS OF MILEAGE.THE DETAILS OF THE CORRECTIVE ACTION ARE DESCRIBED IN DAIMLERCHRYSLER'S LETTER (SEE RECALL NO. 04V-480).THE AGENCY BELIEVES THAT FURTHER EXPENDITURE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS WITH RESPECT TO THOSE VEHICLES COVERED ONLY BY THE LIFETIME WARRANTY.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE PAGE 2 FOR ADDITIONAL INFORMATION.
EA01007 · Air Bag Clockspring
Opened Feb 21, 2001 · Closed Nov 22, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
RQ00008 · Dc Minivan Fuel Injector Rail Leak
Opened Mar 9, 2000 · Closed Mar 18, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available