Power Train. Review the 95 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine And Engine Cooling. Review the 76 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Suspension. Review the 56 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

27 crash reports13 fire reports15 injury reports

Power Train complaints

95 reports

Clear category filter

Mileage unknown · Dec 30, 2001

Power Train

2 FRIENDS HAVE HAD SAME PROBLEM WITH TRANSMISSION LEAKING FLUID.*AK

NHTSA ODI #756218

Mileage unknown · Nov 17, 2001

Power Train

Read full complaint

ANYONE CAN MOVE THE SHIFT LEVER FROM PARK TO REVERSE WITHOUT TOUCHING THE BRAKE. THIS IS VERY DANGEROUS. NO ONE HAS TO BE IN THE DRIVER SEAT, A CHILD CAN BE IN BETWEEN THE DRIVER AND PASSENGER SEATS, TAKE HOLD OF THE SHIFT LEVER AND PULL IT DOWN INTO GEAR. WE CONTACTED SOUTHLAND DODGE AND THEY SAID THEY ALL DO THIS. THIS IS NOT RIGHT. ALL OTHER VEHICLES YOU HAVE TO DEPRESS THE BRAKE BEFORE YOU CAN SHIFT OUT OF PARK. THIS REPORT WAS SENT TO YOU ONCE BEFORE ON 6/3/01 WITH NO RESPONSE. *AK

NHTSA ODI #754644

Mileage unknown · Jul 9, 2001

Power Train

YOU CAN MOVE THE SHIFT LEVER FROM PARK TO DRIVE WITH OUT ANY CONTACT WITH THE BRAKE. NORMALLY IN OTHER VEHICLES, YOU MUST DEPRESS THE BRAKE BEFORE YOU CAN MOVE THE SHIFT LEVER OUT OF PARK. THIS IS DANGEROUS AS A CHILD COULD TAKE HOLD OF THE SHIFT LEVER AND MOVE IT INTO GEAR CAUSING A POSSIBLE ACCIDENT/INJURY. I CONTACTED THE…

Read full complaint

NHTSA ODI #748167

Mileage unknown · Jul 8, 2001

Power TrainInjury

MY 2 YEAR OLD SON TURNED THE KEY AND PUT THE CAR IN GEAR. WHEN IT STARTED MOVING, HE FELL OUT AND THE CAR CAME TO REST AGAINST HIS HIP. MY OTHER TWO CHILDREN WERE IN THE CAR, AND HAD IT NOT STOPPED ON HIS LEG, IT WOULD HAVE ROLLED INTO THE PATH OF AN ONCOMING TRACTOR TRAILER TRUCK.*AK

NHTSA ODI #748086

Mileage unknown · Jun 26, 2001

Power Train

Read full complaint

THERE IS NO BRAKE SHIFT INTERLOCK ON THE 2000 DODGE GRAND CARAVANS. THE OMISSION OF THIS IMPORTANT SAFETY DEVICE CAUSES THE VEHICLE TO BE ABLE TO EASILY SHIFT INTO ANY GEAR, WITHOUT HAVING TO FIRST PRESS THE BRAKE. THIS IS A MAJOR SAFETY CONCERN WITH SMALL CHILDREN ESPECIALLY, AND EVEN FOR ADULTS WHO MAY BUMP THE GEAR SHIFTER. I KNOW THAT 12 STATES ARE CURRENTLY INVOLVED IN A CLASS ACTION LAWSUIT AGAINST DAIMLERCHRYSLER REGARDING THIS SAFETY ISSUE. I HAVE CONTACTED 2 DODGE DEALERSHIPS, AS WELL AS THE DAIMLERCHRYSLER CORPORATION IN MICHIGAN REGARDING THIS. NO ONE WILL FIX THE PROBLEM, NOR WILL THEY ESCALATE THE ISSUE FOR ME. ONE DEALERSHIP SAID THEY THINK IT WILL EVENTUALLY BECOME A NATIONAL RECALL. NO ONE SHOULD HAVE TO WAIT UNTIL THAT POINT IN TIME COMES (IF IT EVER DOES). THEIR HAVE ALREADY BEEN AT LEAST TWO FATALITIES REPORTED BECAUSE THIS SHIFT INTERLOCK WAS NOT INSTALLED ON THE DODGE CARAVAN VEHICLE. WHEN AND OR WHAT WILL IT TAKE TO HAVE ACTION ON THIS ISSUE?!?*AK

NHTSA ODI #747422

Mileage unknown · Jun 21, 2001

Power Train

INTERMITTENTLY AND WITHOUT PRIOR WARNING TRANSMISSION LOCKS UP WHILE DRIVING DUE TO A WEAK PIN WITHIN TRANSMISSION. DEALER IS REPAIRING TRANSMISSION. PLEASE PROVIDE ANY FURTHER DETAILS. *AK

NHTSA ODI #890853

Mileage unknown · May 25, 2001

Power Train

WHILE TRAVELING AT APPROXIMATELY 25 MPH VEHICLE SUDDENLY THREW ITSELF INTO PARK AND BROUGHT VEHICLE TO A COMPLETE STOP. DEALERSHIP COULD NOT REPRODUCE PROBLEM WITH VEHICLE, AND INFORMED CONSUMER THEY COULD FIND NOTHING WRONG. PLEASE PROVIDE ANY ADDITIONAL INFORMATION/ATTACHMENTS. *AK

NHTSA ODI #889157

Mileage unknown · May 23, 2001

Power Train

WHILE VEHICLE WAS PARKED COULD SHIFT GEAR WITHOUT STEPPING ON BRAKE PEDAL. HAD CONTACTED DEALER FOR THIS SITUATION BECAUSE BELIEVED IT WAS A SAFTY PROBLEM. *AK CONSUMER TOOK VEHICLE TO DEALER AND WAS TOLD THAT SHIFTER OPERATION IS OPERATING TO DESIGN INTENT.*JB

NHTSA ODI #888997

Mileage unknown · May 9, 2001

Power TrainSeatsCrashInjury

Read full complaint

MY GRAND CARAVAN WAS HIT FROM BEHIND WITH SUCH FORCE THE REAR OF THE VAN LIFTED OFF THE GROUND. AT IMPACT MY DRIVERS SEAT BROKE, RECLINING ME, MAKING IT IMPOSSIBLE FOR ME TO REACH THE BRAKES TO STOP MY VAN. I HIT THE CENTER MEDIAN (FAST LANE) WITH THE LEFT FRONT FENDER, BLOWING THE TIRE AND BREAKING AXLE THE VAN THEN BOUNCED ACROSS LANES HITTING BRIDGE RAILING AND CEMENT WALL WITH RIGHT FRONT FENDER BLOWING THAT TIRE AND THEN BACK TO THE MEDIAN (FAST LANE), AND CAME TO A STOP AGAINST THE MEDIAN. I WAS TOLD BY THE INSURANCE INVESTAGATOR MY CARAVAN WAS BEYOND REPAIR DUE TO THE AMOUNT OF DAMAGE.*AK

NHTSA ODI #745123

Mileage unknown · May 8, 2001

Power TrainInjury

VEHICLE WENT INTO REVERSE WHEN GEAR SHIFTER WAS BRUSHED LIGHTLY BY A CHILD BECAUSE THERE WAS NO SHIFT INTERLOCK SYSTEM. DEALER HAS BEEN NOTIFIED.*AK CONSUMER WAS INJURED WHILE ATTEMPTING TO STOP VEHICLE, SHE WAS HIT WITH THE DOOR ON LEFT SIDE AND TWISTED HER ANKLE. *SLC

NHTSA ODI #887698

Official recalls

10V270000 · Seats

Jun 17, 2010

ACCESS OPTIONS IS RECALLING CERTAIN TRUCKS AND VANS BUILT ON FORD E150, E350, TOYOTA SIENNA, AND DODGE GRAND CARAVAN CHASSIS AND EQUIPPED WITH VMI/RICON 6-WAY POWER SEAT BASES. THE SIX WAY POWER SEAT BASE MAY HAVE A DEFECTIVE (COLD) WELD ON THE PIVOT PIN WHICH IS WELDED TO THE SWIVEL PLATE. THE WELD COULD FAIL.

Consequence & remedy

Consequence: THE SEAT OCCUPANT MAY BE INJURED IF THE SEAT BASE PIN WERE TO BREAK.

Remedy: THE SWIVEL PLATE WILL BE REPLACED FREE OF CHARGE IF NECESSARY. THE RECALL BEGAN ON JUNE 8, 2010. OWNERS MAY CONTACT ACCESS OPTION AT 831-722-6804.

04V480000 · Air Bags

Oct 6, 2004

ON CERTAIN MINIVANS, THE DRIVER'S AIR BAG MAY BECOME DISABLED DUE TO A FAILURE OF THE CLOCKSPRING, WHICH IS LOCATED IN THE HUB OF THE STEERING WHEEL.

Consequence & remedy

Consequence: THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.

Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL COVERED VEHICLES WITH 70,000 MILES OR LESS. FOR THOSE VEHICLES WITH MORE THAN 70,000 MILES, DAIMLERCHRYSLER WILL OFFER AN EXTENDED LIFETIME WARRANTY UNDER WHICH IT WILL REPLACE THE CLOCKSPRING AT NO CHARGE IF IT FAILS. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. THE RECALL BEGAN ON OCTOBER 12, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

03V505000 · Equipment:other:labels

Dec 10, 2003

ON CERTAIN MINIVANS AND 4X2 PICKUP TRUCKS, THE VEHICLE CERTIFICATION LABEL MAY HAVE GROSS AXLE WEIGHT RATINGS (GAWR) THAT EXCEED THE MAXIMUM TIRE LOAD CAPACITY AS DEFINED IN FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."

Consequence & remedy

Consequence: IMPROPERLY LOADING YOUR VEHICLE CAN CAUSE TIRE FAILURE AND RESULT IN A CRASH.

Remedy: OWNERS WILL BE PROVIDED WITH VEHICLE CERTIFICATION LABEL OVERLAYS CONTAINING CORRECTED INFORMATION RELATIVE TO VEHICLE GAWR AND TIRE SIZE. OWNER NOTIFICATION BEGAN MARCH 1, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-992-1997.

03V094000 · Structure

Mar 7, 2003

CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.

Consequence & remedy

Consequence: THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.

Remedy: DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.

00V268000 · Fuel System, Gasoline:fuel Injection System

Sep 13, 2000

VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.

Consequence & remedy

Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.

Remedy: DEALERS WILL INSTALL A SEAL ON THE VEHICLE FUEL RAILS TO PREVENT EXTERNAL LEAKAGE OF FUEL FROM THE FUEL RAIL CROSSOVER TUBE, SHOULD THE EXISTING O-RINGS CONTINUE TO DEGRADE. OWNER NOTIFICATION BEGAN ON JANUARY 25, 2002. DUE TO THE LARGE QUANTITY OF VEHICLES INVOLVED IN THIS CAMPAIGN, THE OWNER NOTIFICATION WILL BE PHASED OVER THE NEXT SEVERAL MONTHS. HOWEVER, IF A VEHICLE IS LEAKING FUEL FROM THE O-RINGS, THE VEHICLE SHOULD BE TAKEN INTO A DEALER TO HAVE THIS REPAIRED AS SOON AS POSSIBLE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

EA04013 · Driver Air Bag Clockspring Failure

Opened Jun 4, 2004 · Closed May 25, 2005

Status: closed (inferred from source dates) · Air Bags:frontal

THE DRIVER AIR BAG CLOCKSPRING CAN DEVELOP AN OPEN-CIRCUIT CONDITION RESULTING IN NONFUNCTIONAL DRIVER-SIDE FRONTAL AIR BAG, HORN, CRUISE CONTROL (IF EQUIPPED), AND/OR STEERING WHEEL RADIO CONTROL (IF EQUIPPED).IN ITS OCTOBER 5, 2004 LETTER TO NHTSA, DAIMLERCHRYSLER STATED THAT IT WILL CONDUCT A SAFETY RECALL AND REPLACE THE CLOCKSPRING ASSEMBLY ON ALL MY 1998.5-2000 DAIMLERCHRYSLER MINIVANS, BUILT BETWEEN MARCH 1998 AND AUGUST 2000, WITH 70,000 MILES OR LESS.IT WILL ALSO PROVIDE A LIFETIME WARRANTY FOR THIS COMPONENT ON MY 1998.5-2000 MINIVANS, REGARDLESS OF MILEAGE.THE DETAILS OF THE CORRECTIVE ACTION ARE DESCRIBED IN DAIMLERCHRYSLER'S LETTER (SEE RECALL NO. 04V-480).THE AGENCY BELIEVES THAT FURTHER EXPENDITURE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS WITH RESPECT TO THOSE VEHICLES COVERED ONLY BY THE LIFETIME WARRANTY.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE PAGE 2 FOR ADDITIONAL INFORMATION.

EA01007 · Air Bag Clockspring

Opened Feb 21, 2001 · Closed Nov 22, 2002

Status: closed (inferred from source dates) · Electrical System

There is no summary currently available

RQ00008 · Dc Minivan Fuel Injector Rail Leak

Opened Mar 9, 2000 · Closed Mar 18, 2002

Status: closed (inferred from source dates) · Vehicle Speed Control:linkages

There is no summary currently available