Power Train. Review the 95 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine And Engine Cooling. Review the 76 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Suspension. Review the 56 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

27 crash reports13 fire reports15 injury reports

Power Train complaints

95 reports

Clear category filter

Mileage unknown · Apr 11, 2003

Power Train

WHEN THE VEHICLE WAS IN SECOND GEAR, IT BECAME STUCK. THE DEALER INFORMED CONSUMER, THE TRANSMISSION NEEDED TO BE REPLACED. *JB

NHTSA ODI #10015647

60,050 miles · Apr 7, 2003

Power Train

PINION PIN OF THE AUTOMATIC TRANSMISSION CAME OUT AND DESTROYED THE TRANSMISSION. A STANDARD PIN RETAINING CLIP WOULD HAVE PRECLUDED THE PROBLEM. *JB

NHTSA ODI #10014070

Mileage unknown · Apr 4, 2003

Power Train

THE CONSUMER HEARD A NOISE FROM THE UNDER CARRIAGE OF THE VEHICLE, WHEN THE CONSUMER DEPRESSED THE GAS PEDAL, THE RPMS INCREASED, BUT THE SPEED DID NOT. THE DEALER DIAGNOSED THE TRANSMISSION DIFFERENTIAL FAILED WHICH RESULTED IN A $3000 REPAIR. *JB

NHTSA ODI #10015215

39,000 miles · Mar 27, 2003

Power Train

I HAVE OWNED A 2000 GRAND CARAVAN FOR 6 MONTHS AND IT HAS 40 THOUSAND MILES ON IT AND I AM ALREADY HAVING TRANSMISSION PROBLEMS. THIS IS THE 4TH TIME I HAVE HAD TO TAKE IT TO BE LOOKED AT ABOUT THE TRANSMISSION, NOW THE DEALERSHIP SAYS IT NEEDS A TOTALLY NEW TRANSMISSION THIS VAN IS NOT THAT OLD AND DOES NOT HAVE THAT MANY MILES…

Read full complaint

NHTSA ODI #10013580

Mileage unknown · Mar 14, 2003

EquipmentPower Train

Read full complaint

I HAVE BEEN HAVING A PROBLEM WITH MY TRANSMISSION LEAKING FROM THE TRANSMISSION COOLANT HOSE. VEHICLE WAS STILL UNDER WARRANTY, TOOK TO DODGE DEALER AND THEY REPLACED HOSES AND CLAMPS, 1 MONTH LATER LEAKING AGAIN AND THEY STATED THAT IT WAS PROBABLY A BAD PART. THEY REPLACED THEM AGAIN. 1 YEAR LATER PROBLEM RETURNS AND NOW THEY WANT TO CHARGE ME TO REPLACE THE HOSES, THE REASON THIS HAPPENED ACCORDING TO THEM WAS THE HOSE CLAMPS THEY USED. NOW THEY HAVE CHANGED THE CLAMPS, THIS SHOULD NOT BE MY RESPONSIBILITY TO PAY FOR SINCE THEY ARE CHANGING A MANUFACTURER'S PART. THIS SHOULD BE A RECALL. *JB

NHTSA ODI #10010479

50,000 miles · Mar 12, 2003

Power Train

THE TRANSMISSION FAILED WITHOUT WARNING, THE DEALER STATED THE DIFFERENTIAL PIN WENT THROUGH THE TRANSFER CASE.*JB

NHTSA ODI #10011514

37,700 miles · Mar 10, 2003

Power Train

POWER TRAIN:TRANSMISSION COOLER LINES LEAKING. *JB

NHTSA ODI #10010257

58,460 miles · Mar 4, 2003

Power Train

Read full complaint

IN JANUARY 2003 I EXPERIENCED A PROBLEM GETTING MY VAN TO SHIFT INTO DRIVE AFTER I HAD BACKED OUT OF MY DRIVEWAY. ON FEBRUARY 17, 2003 MY HUSBAND WAS DRIVING THE VAN AND EXPERIENCED PROBLEMS GETTING IT TO SHIFT GEARS WHILE HE WAS DRIVING IT. HE ADDED TRANSMISSION FLUID AND LATER THAT EVENING I DROVE THE VAN TO A STORE TWO MILES FROM OUR HOUSE AND AT 35 MPH THE RPMS WOULD NOT GO BELOW 3 AND THE CHECK ENGINE LIGHT CAME ON. I CALLED THE DEALERSHIP FIRST THING TUESDAY MORNING AND TOOK IT THE SHOP ON THURSDAY. THEY REPAIRED A LEAK IN THE TRANSMISSION (WHICH WE HAD HAD REPAIRED PREVIOUSLY) AND REPLACED THE WATER PUMP. TWO DAYS LATER WHILE OUT RUNNING ERRANDS THE CHECK ENGINE LIGHT CAME ON AGAIN. I HAD TO EXIT THE FREEWAY BECAUSE THE ENGINE WOULD NOT SHIFT GEARS AGAIN AND AT 50 MPH (IN A 60 MPH ZONE) THE ENGINE WAS AT 4 RPMS. BEFORE I COULD GET HOME THE ENGINE QUIT IN THE MIDDLE OF A HIGHWAY INTERSECTION WITH TRAFFIC COMING AT ME FROM BEHIND AT 55 MPH. I WAS ABLE TO GET IT STARTED BUT IT LURCHED FOR ABOUT A QUARTER MILE OR SO AND I JUST DROVE NO MORE THAN 30 MPH FOR THE NEXT 5 MILES TO MY HOME. MY HUSBAND TOOK IT BACK TO THE DEALERSHIP ON MONDAY AND WAS TOLD THAT THE SOLENOID (SORRY IF I MISSPELLED IT) NEEDED TO BE REPLACED. HE WAS TOLD TO TAKE THE VAN HOME AND THEY WOULD CALL WHEN THE PART CAME IN. ON MONDAY, MARCH 3, HE CALLED AND SPOKE WITH THE PARTS DEPARTMENT AND THEY INFORMED HIM THAT THERE ARE 24,000 OF THIS PART ON BACKORDER NATIONWIDE. *NLM

NHTSA ODI #10008374

42,000 miles · Feb 28, 2003

Power Train

Read full complaint

MY CAR JUST DIED IN THE MIDDLE NOWHERE ON ROUTE 42 ON THE WAY TO WORK. ONLY TO FIND OUT THAT THE TRANSMISSION NEEDS TO BE REPLACED. THE CARAVAN I OWN HAS ONLY 42,000 MILES ON IT. I DO NOT EVEN OWN IT FOR 2 YEARS. IT WAS A BUY BACK FROM THE DEALER. THE WARRANTY WAS ONLY FOR 3 YEARS OF 36,000 MILES. I WAS TOLD BY THE MECHANIC FROM THE DEALER I PURCHASED THE VEHICLE FROM THAT THIS SHOULD NOT HAVE HAPPENED. NOW I AM FORCED TO PAY OVER $1100 FOR A NEW TRANSMISSION. I WAS TOLD THAT THEY HAVE AGREED TO SPLIT THE BILL OF APPROXIMATELY $2200. I FEEL I SHOULD NOT HAVE TO PAY ANYTHING AS THIS SHOULD NEVER HAVE HAPPENED AND IS A DEFECT FROM THE CHRYSLER MANUFACTURER. I AM NOT THE ONLY ONE COMPLAINING. THERE IS A WHOLE WEB SITE DEDICATED TO COMPLAINTS BY CONSUMERS WHICH I HAVE DOWN LOADED AND IS OVER 11 PAGES LONG. *JB

NHTSA ODI #10008259

47,000 miles · Feb 26, 2003

Power Train

THE VEHICLE BEGAN TO MAKE A LOUD NOISE, CONSUMER PULLED OVER AND NOTICED TRANSMISSION FLUID ALL OVER THE GROUND. THE VEHICLE WAS TOWED TO THE DEALER, AFTER THE VEHICLE WAS INSPECTED, IT WAS DETERMINED THE PINS WHICH WERE LOCATED INSIDE OF THE DIFFERENTRAL WAS BENT AND HAD SHOT OUT OF THE CASING. *JB

NHTSA ODI #10009425

Official recalls

10V270000 · Seats

Jun 17, 2010

ACCESS OPTIONS IS RECALLING CERTAIN TRUCKS AND VANS BUILT ON FORD E150, E350, TOYOTA SIENNA, AND DODGE GRAND CARAVAN CHASSIS AND EQUIPPED WITH VMI/RICON 6-WAY POWER SEAT BASES. THE SIX WAY POWER SEAT BASE MAY HAVE A DEFECTIVE (COLD) WELD ON THE PIVOT PIN WHICH IS WELDED TO THE SWIVEL PLATE. THE WELD COULD FAIL.

Consequence & remedy

Consequence: THE SEAT OCCUPANT MAY BE INJURED IF THE SEAT BASE PIN WERE TO BREAK.

Remedy: THE SWIVEL PLATE WILL BE REPLACED FREE OF CHARGE IF NECESSARY. THE RECALL BEGAN ON JUNE 8, 2010. OWNERS MAY CONTACT ACCESS OPTION AT 831-722-6804.

04V480000 · Air Bags

Oct 6, 2004

ON CERTAIN MINIVANS, THE DRIVER'S AIR BAG MAY BECOME DISABLED DUE TO A FAILURE OF THE CLOCKSPRING, WHICH IS LOCATED IN THE HUB OF THE STEERING WHEEL.

Consequence & remedy

Consequence: THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.

Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL COVERED VEHICLES WITH 70,000 MILES OR LESS. FOR THOSE VEHICLES WITH MORE THAN 70,000 MILES, DAIMLERCHRYSLER WILL OFFER AN EXTENDED LIFETIME WARRANTY UNDER WHICH IT WILL REPLACE THE CLOCKSPRING AT NO CHARGE IF IT FAILS. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. THE RECALL BEGAN ON OCTOBER 12, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

03V505000 · Equipment:other:labels

Dec 10, 2003

ON CERTAIN MINIVANS AND 4X2 PICKUP TRUCKS, THE VEHICLE CERTIFICATION LABEL MAY HAVE GROSS AXLE WEIGHT RATINGS (GAWR) THAT EXCEED THE MAXIMUM TIRE LOAD CAPACITY AS DEFINED IN FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."

Consequence & remedy

Consequence: IMPROPERLY LOADING YOUR VEHICLE CAN CAUSE TIRE FAILURE AND RESULT IN A CRASH.

Remedy: OWNERS WILL BE PROVIDED WITH VEHICLE CERTIFICATION LABEL OVERLAYS CONTAINING CORRECTED INFORMATION RELATIVE TO VEHICLE GAWR AND TIRE SIZE. OWNER NOTIFICATION BEGAN MARCH 1, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-992-1997.

03V094000 · Structure

Mar 7, 2003

CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.

Consequence & remedy

Consequence: THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.

Remedy: DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.

00V268000 · Fuel System, Gasoline:fuel Injection System

Sep 13, 2000

VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.

Consequence & remedy

Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.

Remedy: DEALERS WILL INSTALL A SEAL ON THE VEHICLE FUEL RAILS TO PREVENT EXTERNAL LEAKAGE OF FUEL FROM THE FUEL RAIL CROSSOVER TUBE, SHOULD THE EXISTING O-RINGS CONTINUE TO DEGRADE. OWNER NOTIFICATION BEGAN ON JANUARY 25, 2002. DUE TO THE LARGE QUANTITY OF VEHICLES INVOLVED IN THIS CAMPAIGN, THE OWNER NOTIFICATION WILL BE PHASED OVER THE NEXT SEVERAL MONTHS. HOWEVER, IF A VEHICLE IS LEAKING FUEL FROM THE O-RINGS, THE VEHICLE SHOULD BE TAKEN INTO A DEALER TO HAVE THIS REPAIRED AS SOON AS POSSIBLE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

EA04013 · Driver Air Bag Clockspring Failure

Opened Jun 4, 2004 · Closed May 25, 2005

Status: closed (inferred from source dates) · Air Bags:frontal

THE DRIVER AIR BAG CLOCKSPRING CAN DEVELOP AN OPEN-CIRCUIT CONDITION RESULTING IN NONFUNCTIONAL DRIVER-SIDE FRONTAL AIR BAG, HORN, CRUISE CONTROL (IF EQUIPPED), AND/OR STEERING WHEEL RADIO CONTROL (IF EQUIPPED).IN ITS OCTOBER 5, 2004 LETTER TO NHTSA, DAIMLERCHRYSLER STATED THAT IT WILL CONDUCT A SAFETY RECALL AND REPLACE THE CLOCKSPRING ASSEMBLY ON ALL MY 1998.5-2000 DAIMLERCHRYSLER MINIVANS, BUILT BETWEEN MARCH 1998 AND AUGUST 2000, WITH 70,000 MILES OR LESS.IT WILL ALSO PROVIDE A LIFETIME WARRANTY FOR THIS COMPONENT ON MY 1998.5-2000 MINIVANS, REGARDLESS OF MILEAGE.THE DETAILS OF THE CORRECTIVE ACTION ARE DESCRIBED IN DAIMLERCHRYSLER'S LETTER (SEE RECALL NO. 04V-480).THE AGENCY BELIEVES THAT FURTHER EXPENDITURE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS WITH RESPECT TO THOSE VEHICLES COVERED ONLY BY THE LIFETIME WARRANTY.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE PAGE 2 FOR ADDITIONAL INFORMATION.

EA01007 · Air Bag Clockspring

Opened Feb 21, 2001 · Closed Nov 22, 2002

Status: closed (inferred from source dates) · Electrical System

There is no summary currently available

RQ00008 · Dc Minivan Fuel Injector Rail Leak

Opened Mar 9, 2000 · Closed Mar 18, 2002

Status: closed (inferred from source dates) · Vehicle Speed Control:linkages

There is no summary currently available