2000 Dodge Grand Caravan

I WAS DRIVING DOWN 422 AWAY FROM 76. I WAS JUST ABOUT TO TURN OFF ON TO TROOPER ROAD IN NORRISTOWN WHEN I HEARD A CLICKING NOISE. I THEN TURNED THE RADIO OFF AND IT WAS PRETTY LOUD. IT GOT LOUDER THE MORE I PUSHED ONTO THE GAS PEDAL, AND STOPPED WHEN I TOOK MY FOOT OFF. IT WAS SLIGHTLY UPHILL FOR A FEW HUNDRED FEET AND I KNEW IF I JUST MADE IT TO THE TOP AND HOPED FOR 2 GREEN LIGHTS I MAY BE SAFE. I STARTED GOING UP AND MADE IT TO THE SECOND GREEN LIGHT (THANK GOD) BUT MY ENGINE JUST CUT OFF AND I LOST POWER STEERING AND BREAKS. I HAD TO FORCE MY CAR TO TURN AND ALMOST DIDN'T MAKE THE TURN IN TIME. I THEN HAD TO COAST 1/4 MILE TO GET OFF THE ROAD TO PULL INTO A PARKING LOT WHERE MY CAR SAT UNTIL IT WAS TOWED. THIS WAS ALL IN THE MIDDLE OF A SNOW STORM, WHERE I WAS LATER PLOWED IN AND HAD TO DIG MY WAY OUT OF 3 FEET OF SNOW TO GET IT TOWED. IT WENT TO THE SHOP WHERE I WAS TOLD THE TIMING CHAIN BROKE. LUCKILY NOTHING BAD HAPPENED OUT OF THE WHOLE THING, BUT IT COULD HAVE BEEN MUCH WORSE. *NM

I HAVE REPLACED THE SERPENTINE BELT AND PULLEY/TENSIONER ASSEMBLY ON MY 2000 GRAND CARAVAN 4 TIMES IN THE LAST 3 YEARS. THE DESIGN IS FLAWED AND MUST BE FIXED BY DODGE. I HAVE USED BOTH DODGE REPLACEMENT AND NAPA REPLACEMENT PARTS TO NO AVAIL. I CAN NOT TRUST THIS VEHICLE FOR A LONG DISTANCE WHICH IS WHAT I BOUGHT A VAN FOR. *NM

2000 DODGE GRAND CARAVAN - SERPENTINE BELT SLIPS OFF IN THE RAIN CAUSING STEERING AND ELECTRICAL SYSTEM TO QUIT FUNCTIONING. THIS IS VERY VERY DANGEROUS AND HAPPENED LAST TIME IN A VAN FULL OF KIDS. CHRYSLER HAS "FIXED" THIS PROBLEM OVER 7 TIMES IN THE LAST 2 YEARS. TODAY IS THE 8TH TIME IT IS GETTING FIXED YET AGAIN. BRAZIL RECALLED ALL THEIR VANS BETWEEN 1996 AND 2000 FOR THIS VERY PROBLEM - WHY ISN'T THE CAR BEING RECALLED IN THE US? *JB

SERPENTINE BELT HAS COME OFF MY 2000 DODGE GRAND CARAVAN 4 TIMES. FIRST TIME, I HIT A POCKET OF WATER ON A SMALL HIGHWAY IN A CONSTRUCTION AREA. DROVE VEHICLE TO A SAFER LOCATION, LEFT MY WIFE AND 3 KIDS ON THE SIDE OF THE ROAD AT NIGHT WHILE I WALKED A MILE HOME IN THE RAIN TO GET MY FORD RANGER TO LOAD ALL 5 OF US IN TO GET HOME SAFELY. HAD IT TOWED TO A REPAIR SHOP WHO REPLACED THE BELT TENSIONER AND BELT. SECOND TIME, ABOUT A YEAR LATER, MY WIFE HIT WATER WHICH ALSO KNOCKED THE BELT OFF AND STRANDED HER AND MY 3 CHILDREN 15 MILES FROM HOME. BROTHER IN LAW WAS ABLE TO COME AND SPENT AN HOUR OF GUT WRENCHING LABOR TO PUT THE BELT BACK ON. THIRD TIME, A MONTH LATER IT CAME OFF AGAIN SHREDDING THE BELT AND LEAVING MY WIFE STRANDED BY HERSELF AFTER DROPPING MY KIDS OFF FOR SCHOOL. I HAD IT TOWED TO A REPUTABLE REPAIR SHOP WHO SAID IT NEEDED ANOTHER BELT TENSIONER AND ASSURED ME THE NAPA PRODUCT WOULD PERFORM BETTER THAN THE PREVIOUS ONE. HE TRIED TO SEE IF A KIT WAS AVAILABLE FOR OUR LARGE 6 CYLINDER ENGINE BUT COULD NOT FIND ONE. FOURTH TIME, ONE MONTH LATER AS MY WIFE WAS DRIVING 2 OF MY CHILDREN TO SCHOOL IN THE RAIN, THE BELT CAME OFF AGAIN BUT THIS TIME SHE DIDN'T HIT ANY WATER. HAD IT TOWED BACK TO THE REPAIR SHOP. THEY CHECKED ALL COMPONETS CONNECTED TO THE SERPENTINE BELT AND TRIED FOR 30 MINUTES TO DUPLICATE THE PROBLEM BY POURING WATER OVER THE BELT, ETC. WITH NO SUCCESS. OWNER SAYS HE DOESN'T KNOW WHAT IS CAUSING THIS PROBLEM EVEN THOUGH HE IS AWARE THAT THIS IS A COMMON PROBLEM FOR DODGE VANS. QUESTION: IF THIS IS SUCH A WIDE SPREAD PROBLEM AS SHOWN BY ALL THE COMPLAINTS FOR THE SAME PROBLEM ON THIS WEBSITE WHY HAS THERE NOT BEEN A RECALL TO CORRECT WHATEVER IS CAUSING THIS PROBLEM? ANSWER: BECAUSE IT WILL COST DODGE/ CHRYSLER TOO MUCH MONEY. SOLUTION: UNLESS YOU CAN ONLY DRIVE A DODGE VAN ON WARM SUNNY DAYS DON'T BOTHER BUYING A DODGE VAN. ESPECIALLY IF YOU VALUE YOUR FAMILY'S SAFETY. *JB

THIS IS THE THIRD TIME IN A YEAR THAT THE SERPENTINE BELT HAS SHREDDED AND/OR FELL OFF. I REPLACED THE TENSIONER THE SECOND TIME. IT LOOKS AS IF THE PULLEYS ARE NOT ALIGNED WITH THE TENSIONER SO THE BELT EVENTUALLY RIDES OFF THE EDGE OF THE TENSIONER. ALL TIMES IT WAS NOT RAINING OR SNOW LIKE SOME OF THE OTHER COMPLAINTS I HAVE RESEARCHED ON THE WEB. DODGE GRAND CARAVAN WITH 107,000 MILES. 3.8L WITH A/C. *NM

I HAVE A 2000 DODGE GRAND CARAVAN, 3.0 L ENGINE. I HAVE BEEN EXPERIENCING THE BELT SLIPPING OFF THE TENSIONER DURING WET WEATHER. THE FIRST TIME WE HIT A SMALL (1 - 2" DEEP) PUDDLE OF WATER WHEN TURNING A CORNER. WE IMMEDIATELY LOST POWER STEERING. I CONTACTED MY LOCAL, INDEPENDENT MECHANIC, WHO TOLD ME THIS IS AN ON-GOING PROBLEM WITH 1996 - 2000 CARAVANS. HE EVEN WENT SO FAR AS TO PRINT OUT A SERVICE BULLETIN DETAILING THE PROBLEM. THE SECOND TIME IT HAPPENED WAS LESS THAN TWO WEEKS LATER, HIT A SMALL PUDDLE OF WATER ON A RAINY DAY, LOST POWER STEERING AGAIN. LUCKILY, I WAS GOING SLOWLY BOTH TIMES, BUT WORRY ABOUT A SERIOUS SITUATION OF GOING AT HIGHWAY SPEEDS. I HAVE CONTACTED THE DEALERSHIP, WHO ACKNOWLEDGE THAT THEY HAVE HEARD OF SUCH A PROBLEM, BUT THERE IS NO SERVICE ANNOUNCEMENT FROM DODGE/CHRYSLER, AND NO "FIX" - ONLY TO REPLACE BELTS AND TENSIONERS. I THEN RESEARCHED THROUGH INTERNET, FOUND SITUATION AS STATED BY FIRST (INDEPENDENT) MECHANIC LISTED ON MULTIPLE WEBSITES BY MANY OWNERS. CHRYSLER IS AVOIDING ACKNOWLEDGING THE PROBLEM, YET 2 AFTERMARKET PARTS COMPANIES HAVE DEVELOPED PARTS TO FIX THIS ISSUE. BOTH GATES AND GOODYEAR ACKNOWLEDGE A SAFETY ISSUE, SO I BELIEVE CHRYSLER/DODGE SHOULD HAVE TO ENSURE THE SAFETY OF THEIR VEHICLES. THESE ARE MINI-VANS. SOLD PRIMARILY TO FAMILIES. SO, THE TYPICAL SCENARIO IS A MOTHER WITH KIDS STRANDED IN THE RAIN. I NOW FEAR DRIVING MY VAN IN THE RAIN, AND AM PETRIFIED OF DRIVING HIGHWAY SPEEDS IN THE RAIN. *NM