I HAVE A 1999 DODGE GRAND CARAVAN, VIN # [XXX] WITH 47,300 MILES. HERE LATELY IT WILL SHIFT ROUGH SOMETIMES AND I WOULD LIKE TO KNOW IF THERE IS A SERVICE BULLITTEN CONCERNING THIS SITUATION OR IF IT NEEDS TO BE SERVICED AND WHAT I SHOULD ADVISE THE SERVICE DEPARTMENT TO CHECK. I AM NOT SURE THEY SERVICE THE TRANSMISSION AT 25,0…
Read full complaint
I HAVE A 1999 DODGE GRAND CARAVAN, VIN # [XXX] WITH 47,300 MILES. HERE LATELY IT WILL SHIFT ROUGH SOMETIMES AND I WOULD LIKE TO KNOW IF THERE IS A SERVICE BULLITTEN CONCERNING THIS SITUATION OR IF IT NEEDS TO BE SERVICED AND WHAT I SHOULD ADVISE THE SERVICE DEPARTMENT TO CHECK. I AM NOT SURE THEY SERVICE THE TRANSMISSION AT 25,000 MILES. AS A SERVICE AND TRAINING MANAGER FOR YORK I KNOW THE VALUE OF CORRECT SERVICE. THANKS. *AK UPDATED 07/24/2012 *JS
NHTSA ODI #10105919
69,000 miles · Dec 9, 2004
Exterior LightingPower Train
THE PLANETARY SET FROM THE AUTOMATIC TRANSMISSION WAS DISCOVERED BROKEN BY THE DEALER AFTER THE VEHICLE WOULD NOT START. *AK HEADLIGHTS WERE TO DIM ON THE VEHICLE. *TC
NHTSA ODI #10099891
10,500 miles · Jul 13, 2004
Power Train
AT APPROXIMATELY 80,000 MILES AXLE PIN COME LOOSE AND BREAKS THROUGH THE TRANSMISSION CASE. NEED NEW TRANSMISSION. HAVE TO REPLACE TRANSMISSION BUT THIS IS A COMMON PROBLEM WITH THESE TRANSMISSIONS. I THINK IT SHOULD BE UNDER WARRANTY NO MATTER WHAT THE MILES BECAUSE IT IS A COMMON PROBLEM. THEY DO NOT SELL THE VEHICLE AS A 80,0…
Read full complaint
AT APPROXIMATELY 80,000 MILES AXLE PIN COME LOOSE AND BREAKS THROUGH THE TRANSMISSION CASE. NEED NEW TRANSMISSION. HAVE TO REPLACE TRANSMISSION BUT THIS IS A COMMON PROBLEM WITH THESE TRANSMISSIONS. I THINK IT SHOULD BE UNDER WARRANTY NO MATTER WHAT THE MILES BECAUSE IT IS A COMMON PROBLEM. THEY DO NOT SELL THE VEHICLE AS A 80,000 MILE THEN REPLACE VEHICLE AND IF IT IS COMMON, I THINK THEY SHOULD REPLACE THE TRANSMISSION AND REPAY EVERYONE WHO HAS HAD TO GET THERE TRANSMISSION REPLACED. *LA
NHTSA ODI #10080927
57,000 miles · May 27, 2004
Power Train
WHILE DRIVING ON THE HIGHWAY AT 65 MPH THERE WAS A SUDDEN GRINDING NOISE. A TECHNICIAN INSPECTED THE VEHICLE AND DETERMINED THAT THE TRANSMISSION WAS FALLING APART AND THAT THE VEHICLE SHOULDN'T BE DRIVEN. THE CONSUMER SPOKE TO THE DEALERSHIP WHO INDICATED THAT THESE TRANSMISSIONS HAVE A HIGH FAILURE RATE, BUT THEY DIDN'T INDICA…
Read full complaint
WHILE DRIVING ON THE HIGHWAY AT 65 MPH THERE WAS A SUDDEN GRINDING NOISE. A TECHNICIAN INSPECTED THE VEHICLE AND DETERMINED THAT THE TRANSMISSION WAS FALLING APART AND THAT THE VEHICLE SHOULDN'T BE DRIVEN. THE CONSUMER SPOKE TO THE DEALERSHIP WHO INDICATED THAT THESE TRANSMISSIONS HAVE A HIGH FAILURE RATE, BUT THEY DIDN'T INDICATED WHAT IS CAUSING THE FAILURE. *NM
NHTSA ODI #10074338
102,500 miles · Mar 3, 2004
Power Train
I HAVE A POORLY MANUFACTURED TRANSMISSION, 1999 DODGE GRAND CARAVAN. IT WAS REBUILT ONCE, NOW IT NEEDS TO BE TOTALLY REBUILT AGAIN THIS TIME 1600.00 DOLLARS.MAYBE YOU ALL CAN DO SOMETHING ABOUT THIS PROBLEM . SEARCHING THE INTERNET MANY OTHERS HAVE HAD PROBLEMS WITH FAULLTY CHYSLER TRANSMISSIONS. THANKS. *AK
NHTSA ODI #10060306
55,000 miles · Mar 2, 2004
Power Train
WHILE DRIVING 35 MPH, THE VEHICLE "JERKED", THE SERVICE ENGINE SOON LIGHT CAME ON, SPEEDOMETER WENT TO ZERO AND THE VEHICLE WON'T SHIFT OUT OF 2ND GEAR. MILEAGE = 55000. *AK
NHTSA ODI #10060190
74,480 miles · Feb 24, 2004
Air BagsPower TrainInjury
WHILE DRIVING 25 MPH THE VEHICLE WENT OVER A POT HOLE AND BOTH FRONT AIR BAGS DEPLOYED. THE FRONT PASSENGER'S SIDE AXLE ALSO BROKE. *NLM *SC
NHTSA ODI #10048720
65,075 miles · Jan 15, 2004
Power Train
THE TRANSMISSION FAILED IN MY 1999 DODGE GRAND CARAVAN SPORT WITH LESS THAN 66,000 MILES ON IT. I WAS ABLE TO GET IT TO THE DEALERSHIP WHERE I BOUGHT IT USING THE "LIMP HOME" MODE! I CONTACTED DAIMLERCHRYSLER AND ASKED THEM TO PAY FOR THE REPAIRS AND THEY DECLINED. I WAS AWARE OF THIS PROBLEM WHEN I BOUGHT IT FOUR YEA…
Read full complaint
THE TRANSMISSION FAILED IN MY 1999 DODGE GRAND CARAVAN SPORT WITH LESS THAN 66,000 MILES ON IT. I WAS ABLE TO GET IT TO THE DEALERSHIP WHERE I BOUGHT IT USING THE "LIMP HOME" MODE! I CONTACTED DAIMLERCHRYSLER AND ASKED THEM TO PAY FOR THE REPAIRS AND THEY DECLINED. I WAS AWARE OF THIS PROBLEM WHEN I BOUGHT IT FOUR YEARS AGO BUT WAS TOLD THAT IT HAD BEEN RESOLVED!
NHTSA ODI #10070378
105,000 miles · Jan 12, 2004
Power TrainSteering
WHILE DRIVING AT 45 MPH AND WITHOUT ANY WARNING AUTOMATIC TRANSMISSION FAILED. TOWED VEHICLE TO THE DEALER, TECHNICIAN INDICATED THE NEED FOR A NEW TRANSMISSION, ALSO TIE ROD AND STEERING WHEEL PROBLEMS. *AK
NHTSA ODI #10053819
81 miles · Dec 19, 2003
Power Train
AUTOMATIC TRANSMISSION LOCKED UP IN LOW RANGE WHILE DRIVING ON HIGHWAY. MECHANIC FOUND THAT TRANMISSION WAS SHOT AFTER 80,000 MILES.*AK
ON CERTAIN MINIVANS, THE DRIVER'S AIR BAG MAY BECOME DISABLED DUE TO A FAILURE OF THE CLOCKSPRING, WHICH IS LOCATED IN THE HUB OF THE STEERING WHEEL.
Consequence & remedy
Consequence: THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL COVERED VEHICLES WITH 70,000 MILES OR LESS. FOR THOSE VEHICLES WITH MORE THAN 70,000 MILES, DAIMLERCHRYSLER WILL OFFER AN EXTENDED LIFETIME WARRANTY UNDER WHICH IT WILL REPLACE THE CLOCKSPRING AT NO CHARGE IF IT FAILS. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. THE RECALL BEGAN ON OCTOBER 12, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A SEAL ON THE VEHICLE FUEL RAILS TO PREVENT EXTERNAL LEAKAGE OF FUEL FROM THE FUEL RAIL CROSSOVER TUBE, SHOULD THE EXISTING O-RINGS CONTINUE TO DEGRADE. OWNER NOTIFICATION BEGAN ON JANUARY 25, 2002. DUE TO THE LARGE QUANTITY OF VEHICLES INVOLVED IN THIS CAMPAIGN, THE OWNER NOTIFICATION WILL BE PHASED OVER THE NEXT SEVERAL MONTHS. HOWEVER, IF A VEHICLE IS LEAKING FUEL FROM THE O-RINGS, THE VEHICLE SHOULD BE TAKEN INTO A DEALER TO HAVE THIS REPAIRED AS SOON AS POSSIBLE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
VEHICLE DESCRIPTION: MINI VANS BUILT FOR FLEET SALES ONLY. THE HEADLAMP MODULE DOES NOT IDENTIFY THE PARK LAMP AS "DRL" AS REQUIREMENT OF FMVSS 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence & remedy
Consequence: THESE VEHICLES DO NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 108.
Remedy: ALL FLEET OWNERS/OPERATORS WILL BE MAILED NON-REMOVABLE DECALS WITH THE REQUIRED "DRL" LETTERS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6
EA04013 · Driver Air Bag Clockspring Failure
Opened Jun 4, 2004 · Closed May 25, 2005
Status: closed (inferred from source dates) · Air Bags:frontal
THE DRIVER AIR BAG CLOCKSPRING CAN DEVELOP AN OPEN-CIRCUIT CONDITION RESULTING IN NONFUNCTIONAL DRIVER-SIDE FRONTAL AIR BAG, HORN, CRUISE CONTROL (IF EQUIPPED), AND/OR STEERING WHEEL RADIO CONTROL (IF EQUIPPED).IN ITS OCTOBER 5, 2004 LETTER TO NHTSA, DAIMLERCHRYSLER STATED THAT IT WILL CONDUCT A SAFETY RECALL AND REPLACE THE CLOCKSPRING ASSEMBLY ON ALL MY 1998.5-2000 DAIMLERCHRYSLER MINIVANS, BUILT BETWEEN MARCH 1998 AND AUGUST 2000, WITH 70,000 MILES OR LESS.IT WILL ALSO PROVIDE A LIFETIME WARRANTY FOR THIS COMPONENT ON MY 1998.5-2000 MINIVANS, REGARDLESS OF MILEAGE.THE DETAILS OF THE CORRECTIVE ACTION ARE DESCRIBED IN DAIMLERCHRYSLER'S LETTER (SEE RECALL NO. 04V-480).THE AGENCY BELIEVES THAT FURTHER EXPENDITURE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS WITH RESPECT TO THOSE VEHICLES COVERED ONLY BY THE LIFETIME WARRANTY.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE PAGE 2 FOR ADDITIONAL INFORMATION.
RQ04001 · Driver Air Bag Clockspring Failure
Opened Jan 28, 2004 · Closed Jun 4, 2004
Status: closed (inferred from source dates) · Air Bags:frontal
COMPLAINTS REPORT AIR BAG WARNING LIGHT ILLUMINATES, AND THIS MAY BE ACCOMPANIED WITH A NON-FUNCTIONING HORN AND/OR CRUISE CONTROL (IF EQUIPPED).THIS IS INDICATIVE OF AN OPEN-CIRCUIT CLOCKSPRING FAILURE (RESULTS IN NON-FUNCTIONING DRIVER'S AIR BAG), SIMILAR TO THE FAILURE CONDITION THAT WAS THE SUBJECT OF DAIMLERCHRYSLER'S RECALL OF MODEL YEAR 1996-1998.5 MINIVANS (RECALL NO. 02V-293).THIS RECALL QUERY HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA04-013).
EA01007 · Air Bag Clockspring
Opened Feb 21, 2001 · Closed Nov 22, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
RQ00008 · Dc Minivan Fuel Injector Rail Leak
Opened Mar 9, 2000 · Closed Mar 18, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
EA99013 · Post Collision Fuel System
Opened Jun 11, 1999 · Closed Aug 10, 2001
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
No summary supplied.
PE99010 · POST-COLLISION Fuel System Integrity
Opened Feb 3, 1999 · Closed Jun 11, 1999
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
There is no summary currently available
1999 Dodge Grand Caravan Problems, Complaints & Recalls | Skip That Year
Illustration