IllustrationTHE CLOCK SPRING INSIDE OF THE STEERING WHEEL MALFUNCTIONED. AS A RESULT THE AIR BAG SENSOR LIGHT STAYED ON AND THE HORN BECAME INOPERATIVE. *AK THE CRUISE CONTROL WAS ALSO INOPERATIVE AND THERE WAS A CHANCE THAT THE AIR BAG WOULD NOT HAVE FUNCTIONED DURING A CRASH. *NM
1999 Dodge Grand Caravan
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1999 Dodge Grand Caravan do not stand out strongly from the model-year median of 284.
About this comparison →How this year compares
Owner complaints by model year
Compare all Grand Caravan years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
70–25K
2125–50K
3750–75K
4475–100K
51100–150K
19150K+
179 reports with mileage · 253 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 83 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 72 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 62 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
26 crash reports13 fire reports16 injury reports
Air Bags complaints
83 reportsAIR BAG SENSOR LIGHT STAYED ON. AS A RESULT, THE HORN FAILED. *AK
CONSUMER STATED THAT AIR BAG LIGHT CAME ON, AND TOOK VEHICLE TO THE DEALER. UPON EXAMINING THE VEHICLE MECHANIC FOUND THAT CLOCK SPRING WAS DEFECTIVE. LOOKED AT THE INTERNET, AND WAS TOLD THAT PART WAS ON ODI INVESTIGATION. *AK
FIRST AIR BAG LIGHT CAME ON, FOLLOWED BY SUBSEQUENT FAILURE OF HORN & CRUISE CONTROL. OUR DEALERSHIP MENTIONED THE CLOCKSPRING AND THE AIR BAG MODULE NEEDED REPLACEMENT. THANKS TO THE SUMARRIES ON THIS SITE, WE WILL NOT BE APPROVING THE MODULE REPLACMENT (AN ADDITIONAL COST OF ABOUT 650). LAST EIGHT VIN: XB527782. *AK
MY AIR BAG LIGHT KEPT COMING ON AND I WAS TOLD BY A DEALER THAT MY AIR BAG WOULD NOT DEPLOY AND MY CAR WOULD NOT PASS INSPECTION UNLESS I GOT IT FIXED. WHICH I DID AND IT COST $250.00. MY CAR IS A 1999 GRAND CARAVAN. THERE WAS A RECALL ON THIS, BUT ONLY UP TO YEAR 1998. WHEN I WROTE TO DODGE THEY TOLD ME THERE WAS NOTHING THEY …
Read full complaint
MY AIR BAG LIGHT KEPT COMING ON AND I WAS TOLD BY A DEALER THAT MY AIR BAG WOULD NOT DEPLOY AND MY CAR WOULD NOT PASS INSPECTION UNLESS I GOT IT FIXED. WHICH I DID AND IT COST $250.00. MY CAR IS A 1999 GRAND CARAVAN. THERE WAS A RECALL ON THIS, BUT ONLY UP TO YEAR 1998. WHEN I WROTE TO DODGE THEY TOLD ME THERE WAS NOTHING THEY COULD DO, AND MY EMAILS WOULD NOT BE ACKNOWLEDGED. *LA
WELL A FEW MONTHS AGO WE HAD ELECTRICAL PROBLEMS WITH OUR 1999 GRAND CARAVAN. THE MILEAGE, GAS GAUGE, ODOMETER, SPEEDOMETER STOPPED WORKING WHILE I WAS IN THE VAN WITH IT RUNNING IN PARK . IT TURNED OUT BY A CERTIFIED TECH TO BE A MANUFACTURER'S DEFECT BECAUSE IT WAS A WIRE WAS RUBBING ON A MANUFACTURER'S WELD LOCATED IN THE OV…
Read full complaint
WELL A FEW MONTHS AGO WE HAD ELECTRICAL PROBLEMS WITH OUR 1999 GRAND CARAVAN. THE MILEAGE, GAS GAUGE, ODOMETER, SPEEDOMETER STOPPED WORKING WHILE I WAS IN THE VAN WITH IT RUNNING IN PARK . IT TURNED OUT BY A CERTIFIED TECH TO BE A MANUFACTURER'S DEFECT BECAUSE IT WAS A WIRE WAS RUBBING ON A MANUFACTURER'S WELD LOCATED IN THE OVERHEAD COMPARTMENT AREA. SO WE PAID FOR IT TO BE FIXED $500 AND NO PROBLEM SINCE. SO CURRENTLY WE HAD OUR AIRBAG LIGHT COME ON ALONG WITH NO HORN OR CRUISE CONTROL. SO I CONTACTED DODGE LIKE SOME OF THESE SITES I READ SAID TO DO BECAUSE SOME OTHER PEOPLE HAD THEIRS WORKED ON FOR FREE AND I GOT A EMAIL WHICH STATES THEY WILL NOT WORK ON EITHER REIMBURSEMENT FOR THE ONE AND NOT EVEN FOR THE AIRBAG LIGHT. I AM CURRENTLY NOT DRIVING THE VAN BECAUSE I WAITED FOR MY RESPONSE FROM DODGE. OUR VAN ONLY HAS AROUND 67,000 MILES ON IT. I HAVE THE EMAIL FROM DODGE IF YOU ARE INTERESTED IN SHOWING HOW THEY RESPOND. *JB
AIR BAG INDICATOR LIGHT IS ON, HORN AND CRUISE CONTROL DO NOT WORK ON MY 1999 DODGE GRAND CARAVAN. HIGHLY LIKELY, THE PROBLEM IS THE CLOCK SPRING. THERE IS AN EXISTING RECALL FOR 1996 - 1998 GRAND CARAVANS WITH THE EXACT SAME SYMPTOMS. DODGE WILL NOT FIX THE PROBLEM UNTIL THERE IS A RECALL. THEY HAVE SAID THAT IT IS CURRENTL…
Read full complaint
AIR BAG INDICATOR LIGHT IS ON, HORN AND CRUISE CONTROL DO NOT WORK ON MY 1999 DODGE GRAND CARAVAN. HIGHLY LIKELY, THE PROBLEM IS THE CLOCK SPRING. THERE IS AN EXISTING RECALL FOR 1996 - 1998 GRAND CARAVANS WITH THE EXACT SAME SYMPTOMS. DODGE WILL NOT FIX THE PROBLEM UNTIL THERE IS A RECALL. THEY HAVE SAID THAT IT IS CURRENTLY UNDER INVESTIGATION FOR THE 1999 - 2000 MODEL YEAR, BUT APPARENTLY THAT HAS BEEN THE CASE AT THE NHTSA SINCE 2001. MY LAST 8 DIGITS OF MY VIN ARE XR412677. *JB
AIRBAG LIGHT CAME ON, HORN DOESN'T WORK, CRUISE CONTROL DOESN'T WORK. TOOK IT TO THE DEALER SAID THAT THERE HAD BEEN SOME RECALLS ON IT BUT NOT ON MY MODEL...DID SOME RESEARCH AND FOUND THAT THIS IS A CONSISTANT PROBLEM ON THE CARAVANS INCLUDING MY MODEL.*AK
NO EVENTS LEAD TO THE FAILURE, JUST AN IMMEDIATE FAILURE OF MY HORN, CRUISE CONTROL AND AIR BAG SIMULTANEOUSLY. I HAD THE CLOCKSPRING REPLACED.*AK
WHILE DRIVING/IDLING THE HORN/CRUISE CONTROL FAILED TO WORK. AIR BAG LIGHT ILLUMINATED INTERMITTENTLY. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK
Official recalls
304V480000 · Air Bags
Oct 6, 2004
ON CERTAIN MINIVANS, THE DRIVER'S AIR BAG MAY BECOME DISABLED DUE TO A FAILURE OF THE CLOCKSPRING, WHICH IS LOCATED IN THE HUB OF THE STEERING WHEEL.
Consequence & remedy
Consequence: THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL COVERED VEHICLES WITH 70,000 MILES OR LESS. FOR THOSE VEHICLES WITH MORE THAN 70,000 MILES, DAIMLERCHRYSLER WILL OFFER AN EXTENDED LIFETIME WARRANTY UNDER WHICH IT WILL REPLACE THE CLOCKSPRING AT NO CHARGE IF IT FAILS. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. THE RECALL BEGAN ON OCTOBER 12, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
00V268000 · Fuel System, Gasoline:fuel Injection System
Sep 13, 2000
VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A SEAL ON THE VEHICLE FUEL RAILS TO PREVENT EXTERNAL LEAKAGE OF FUEL FROM THE FUEL RAIL CROSSOVER TUBE, SHOULD THE EXISTING O-RINGS CONTINUE TO DEGRADE. OWNER NOTIFICATION BEGAN ON JANUARY 25, 2002. DUE TO THE LARGE QUANTITY OF VEHICLES INVOLVED IN THIS CAMPAIGN, THE OWNER NOTIFICATION WILL BE PHASED OVER THE NEXT SEVERAL MONTHS. HOWEVER, IF A VEHICLE IS LEAKING FUEL FROM THE O-RINGS, THE VEHICLE SHOULD BE TAKEN INTO A DEALER TO HAVE THIS REPAIRED AS SOON AS POSSIBLE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
99V116000 · Exterior Lighting:headlights
May 6, 1999
VEHICLE DESCRIPTION: MINI VANS BUILT FOR FLEET SALES ONLY. THE HEADLAMP MODULE DOES NOT IDENTIFY THE PARK LAMP AS "DRL" AS REQUIREMENT OF FMVSS 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence & remedy
Consequence: THESE VEHICLES DO NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 108.
Remedy: ALL FLEET OWNERS/OPERATORS WILL BE MAILED NON-REMOVABLE DECALS WITH THE REQUIRED "DRL" LETTERS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6EA04013 · Driver Air Bag Clockspring Failure
Opened Jun 4, 2004 · Closed May 25, 2005
Status: closed (inferred from source dates) · Air Bags:frontal
THE DRIVER AIR BAG CLOCKSPRING CAN DEVELOP AN OPEN-CIRCUIT CONDITION RESULTING IN NONFUNCTIONAL DRIVER-SIDE FRONTAL AIR BAG, HORN, CRUISE CONTROL (IF EQUIPPED), AND/OR STEERING WHEEL RADIO CONTROL (IF EQUIPPED).IN ITS OCTOBER 5, 2004 LETTER TO NHTSA, DAIMLERCHRYSLER STATED THAT IT WILL CONDUCT A SAFETY RECALL AND REPLACE THE CLOCKSPRING ASSEMBLY ON ALL MY 1998.5-2000 DAIMLERCHRYSLER MINIVANS, BUILT BETWEEN MARCH 1998 AND AUGUST 2000, WITH 70,000 MILES OR LESS.IT WILL ALSO PROVIDE A LIFETIME WARRANTY FOR THIS COMPONENT ON MY 1998.5-2000 MINIVANS, REGARDLESS OF MILEAGE.THE DETAILS OF THE CORRECTIVE ACTION ARE DESCRIBED IN DAIMLERCHRYSLER'S LETTER (SEE RECALL NO. 04V-480).THE AGENCY BELIEVES THAT FURTHER EXPENDITURE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS WITH RESPECT TO THOSE VEHICLES COVERED ONLY BY THE LIFETIME WARRANTY.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE PAGE 2 FOR ADDITIONAL INFORMATION.
RQ04001 · Driver Air Bag Clockspring Failure
Opened Jan 28, 2004 · Closed Jun 4, 2004
Status: closed (inferred from source dates) · Air Bags:frontal
COMPLAINTS REPORT AIR BAG WARNING LIGHT ILLUMINATES, AND THIS MAY BE ACCOMPANIED WITH A NON-FUNCTIONING HORN AND/OR CRUISE CONTROL (IF EQUIPPED).THIS IS INDICATIVE OF AN OPEN-CIRCUIT CLOCKSPRING FAILURE (RESULTS IN NON-FUNCTIONING DRIVER'S AIR BAG), SIMILAR TO THE FAILURE CONDITION THAT WAS THE SUBJECT OF DAIMLERCHRYSLER'S RECALL OF MODEL YEAR 1996-1998.5 MINIVANS (RECALL NO. 02V-293).THIS RECALL QUERY HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA04-013).
EA01007 · Air Bag Clockspring
Opened Feb 21, 2001 · Closed Nov 22, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
RQ00008 · Dc Minivan Fuel Injector Rail Leak
Opened Mar 9, 2000 · Closed Mar 18, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
EA99013 · Post Collision Fuel System
Opened Jun 11, 1999 · Closed Aug 10, 2001
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
No summary supplied.
PE99010 · POST-COLLISION Fuel System Integrity
Opened Feb 3, 1999 · Closed Jun 11, 1999
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
There is no summary currently available