NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
79 reportsClear category filter94,850 miles · Jan 14, 2004
Air BagsElectrical SystemVehicle Speed Control
WE WERE DRIVING OUR CARAVAN AND HAD TO USE THE HORN. ONCE I PRESSED THE PAD FOR THE HORN, THE AIR BAG LIGHT CAME ON, THE HORN DID NOT BLOW AND THEN I DETERMINED THAT THE CRUISE CONTROL WAS NOT WORKING. BEFORE DOING ANY RESEARCH I HAD THE REPAIRS COMPLETED AT THE DEALER. IT WAS A DEFECTIVE CLOCK SPRING AND THE COST TO REPLACE IT …
Read full complaint
WE WERE DRIVING OUR CARAVAN AND HAD TO USE THE HORN. ONCE I PRESSED THE PAD FOR THE HORN, THE AIR BAG LIGHT CAME ON, THE HORN DID NOT BLOW AND THEN I DETERMINED THAT THE CRUISE CONTROL WAS NOT WORKING. BEFORE DOING ANY RESEARCH I HAD THE REPAIRS COMPLETED AT THE DEALER. IT WAS A DEFECTIVE CLOCK SPRING AND THE COST TO REPLACE IT CAME TO $269.01. I THEN CAME TO THIS SITE AND FOUND DOZENS OF OTHER COMPLAINTS EXACTLY LIKE MINE. I WOULD LIST EVERYONE I FOUND BUT I'M SURE YOU CAN LOOK THEM UP FASTER THAN I COULD TYPE THE ID NUMBERS. I ALSO FOUND A RECALL CAMPAIGN ID NUMBER 02V293000 ON YOUR SITE. I ASKED THE DEALER ABOUT THIS AND THEY CLAIM OUR CARAVAN IS NOT INCLUDED IN THAT RECALL. I FIND THIS HARD TO BELEAVE SINCE THEY ADMIT THEY ARE DEFECTIVE IN THE RECALL SO WHY ISN'T OURS COVERED UNDER IT?*AK
NHTSA ODI #10053154
Mileage unknown · Nov 30, 2003
Electrical System
WHILE GOING DOWN THE ROAD THE INTSURMENTS WILL HAVE A LOSS OF POWER. NO GAUGES, ODOMETER SPEEDOMETER. WHEN IT COMES BACK THE DOORS RELOCK.*AK
NHTSA ODI #10048851
65,000 miles · Oct 17, 2003
Electrical SystemVisibility
1998 DODGE GRAND CARAVAN - WINDSHIELD WIPERS OPERATE SPORADICALLY ON THEIR OWN; IN ADDTION, THE GAS GAUGE GOES FULL TO EMPTY AND BACK AGAIN SPORADICALLY. AN INTERNET SEARCH POINTS TO A FAULTY WIRING HARNESS AS THE PROBLEM. *LA
NHTSA ODI #10043099
93,000 miles · Aug 4, 2003
Air BagsElectrical SystemEquipment
CONSUMER STATES THAT AIR COMPRESSOR HAS COMPLETELY SHUT DOWN. CONSUMER ALSO, HORN IS NOT FUNCTIONING, AND THE WARNING LIGHT FOR AIR BAGS IS ON AT ALL TIMES.*AK
NHTSA ODI #10032019
Mileage unknown · Feb 5, 2003
Air BagsElectrical SystemEngine And Engine Cooling
ALL OF THE ORIGINAL TIRES ON THE VEHICLE EXPERIENCED TREAD SEPARATION. *JG PH
NHTSA ODI #10004549
Mileage unknown · Nov 9, 2002
Electrical System
WILL NOT PAY FOR THIS REPAIR! CONSIDERING BUYING ANOTHER GM PRODUCT INSTEAD. THIS IS THE 3RD AND FINAL CHRYSLER PURCHASE. LOVE THE VEHICLE, BUT TOO MANY DEFECTS FOR THE PRICE PAID. DT
NHTSA ODI #769503
103,700 miles · Oct 2, 2002
Electrical System
THIS IS THE SECOND TIME THAT I HAVE REPLACED THE IGNITION CYLINDER LOCK. THE FIRST TIME AT AROUND 40,000 MILES AND THE KEY WOULDN'T TURN IN THE LOCK AT ALL. THIS TIME THE KEY WOULD TURN, BUT IT WAS VERY STIFF. EVEN THOUGH THERE IS A TSB ABOUT THIS PROBLEM, NEITHER THE DEALER NOR CHRYSLER WILL HELP DEFER THE COST OF THIS COMMON P…
Read full complaint
THIS IS THE SECOND TIME THAT I HAVE REPLACED THE IGNITION CYLINDER LOCK. THE FIRST TIME AT AROUND 40,000 MILES AND THE KEY WOULDN'T TURN IN THE LOCK AT ALL. THIS TIME THE KEY WOULD TURN, BUT IT WAS VERY STIFF. EVEN THOUGH THERE IS A TSB ABOUT THIS PROBLEM, NEITHER THE DEALER NOR CHRYSLER WILL HELP DEFER THE COST OF THIS COMMON PROBLEM. *PH *JB **DIMSII IVOQ ENTRY POSTED AFTER 12/12/02 CUT OVER TO ARTEMIS**768019
NHTSA ODI #10007437
Mileage unknown · Aug 9, 2002
Air BagsElectrical SystemVehicle Speed Control
MY CLOCKSPRING BROKE,IT MAKES THE AIRBAG LIGHT STAY ON AND DISABLES THE HORN, CRUISE CONTROL AND AIRBAGS. DEALER WANTS ABOUT $200 TO REPAIR, I BOUGHT THE PART FROM THE DEALER FOR $73.15 AND REPLACED IT MYSELF. I HAVE FRIEND WITH THE SAME PROBLEM IN HER 97 CARAVAN.S
NHTSA ODI #765407
Mileage unknown · Aug 8, 2002
Air BagsElectrical SystemVehicle Speed Control
EA 01 007/AIR BAG CLOCK SPRING: AIR BAG LIGHT REMAINED ON WHILE DRIVING, HORN AND CRUISE CONTROL WERE INOPERATIVE. DEALER CONTACTED. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION.*AK
NHTSA ODI #8015866
Mileage unknown · Jul 19, 2002
Air BagsElectrical System
AIR BAG LIGHT WILL INTERMITTENTLY COME ON AND OFF WHEN CONSUMER IS DRIVING. AFTER CONTACTING DEALER, DEALER NOTED THAT AIR BAG MIGHT NOT WORK. ALSO, THE HORN WILL NOT WORK. CONTACTED DEALER. *AK
NHTSA ODI #8014355
Official recalls
4Oct 6, 2004
ON CERTAIN MINIVANS, THE DRIVER'S AIR BAG MAY BECOME DISABLED DUE TO A FAILURE OF THE CLOCKSPRING, WHICH IS LOCATED IN THE HUB OF THE STEERING WHEEL.
Consequence & remedy
Consequence: THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL COVERED VEHICLES WITH 70,000 MILES OR LESS. FOR THOSE VEHICLES WITH MORE THAN 70,000 MILES, DAIMLERCHRYSLER WILL OFFER AN EXTENDED LIFETIME WARRANTY UNDER WHICH IT WILL REPLACE THE CLOCKSPRING AT NO CHARGE IF IT FAILS. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. THE RECALL BEGAN ON OCTOBER 12, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Nov 7, 2002
ON CERTAIN MINI VANS, THE CLOCKSPRING ASSEMBLY MAY HAVE BEEN WOUND INCORRECTLY DURING THE VEHICLE ASSEMBLY PROCESS.
Consequence & remedy
Consequence: THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL VEHICLES WITH 70,000 MILES OR LESS. AN EXTENDED LIFETIME WARRANTY WILL ALSO BE PLACED ON THIS COMPONENT FOR ALL AFFECTED VEHICLES, REGARDLESS OF MILEAGE. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. OWNER NOTIFICATION BEGAN NOVEMBER 18, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Sep 13, 2000
VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A SEAL ON THE VEHICLE FUEL RAILS TO PREVENT EXTERNAL LEAKAGE OF FUEL FROM THE FUEL RAIL CROSSOVER TUBE, SHOULD THE EXISTING O-RINGS CONTINUE TO DEGRADE. OWNER NOTIFICATION BEGAN ON JANUARY 25, 2002. DUE TO THE LARGE QUANTITY OF VEHICLES INVOLVED IN THIS CAMPAIGN, THE OWNER NOTIFICATION WILL BE PHASED OVER THE NEXT SEVERAL MONTHS. HOWEVER, IF A VEHICLE IS LEAKING FUEL FROM THE O-RINGS, THE VEHICLE SHOULD BE TAKEN INTO A DEALER TO HAVE THIS REPAIRED AS SOON AS POSSIBLE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Dec 15, 1997
VEHICLE DESCRIPTION: PASSENGER MINIVANS EQUIPPED WITH INTEGRATED CHILD SEATS. THE SHOULDER HARNESS RESTRAINT WEBBING WAS INCORRECTLY ROUTED AROUND THE METAL REINFORCEMENT BAR ON THESE SEATS.
Consequence & remedy
Consequence: THE CHILD SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED IN THE EVENT OF A COLLISION.
Remedy: DEALERS WILL INSPECT THE ROUTING OF THE SHOULDER BELT WEBBING AND ANY FOUND INCORRECT WILL BE PROPERLY ROUTED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6EA04013 · Driver Air Bag Clockspring Failure
Opened Jun 4, 2004 · Closed May 25, 2005
Status: closed (inferred from source dates) · Air Bags:frontal
THE DRIVER AIR BAG CLOCKSPRING CAN DEVELOP AN OPEN-CIRCUIT CONDITION RESULTING IN NONFUNCTIONAL DRIVER-SIDE FRONTAL AIR BAG, HORN, CRUISE CONTROL (IF EQUIPPED), AND/OR STEERING WHEEL RADIO CONTROL (IF EQUIPPED).IN ITS OCTOBER 5, 2004 LETTER TO NHTSA, DAIMLERCHRYSLER STATED THAT IT WILL CONDUCT A SAFETY RECALL AND REPLACE THE CLOCKSPRING ASSEMBLY ON ALL MY 1998.5-2000 DAIMLERCHRYSLER MINIVANS, BUILT BETWEEN MARCH 1998 AND AUGUST 2000, WITH 70,000 MILES OR LESS.IT WILL ALSO PROVIDE A LIFETIME WARRANTY FOR THIS COMPONENT ON MY 1998.5-2000 MINIVANS, REGARDLESS OF MILEAGE.THE DETAILS OF THE CORRECTIVE ACTION ARE DESCRIBED IN DAIMLERCHRYSLER'S LETTER (SEE RECALL NO. 04V-480).THE AGENCY BELIEVES THAT FURTHER EXPENDITURE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS WITH RESPECT TO THOSE VEHICLES COVERED ONLY BY THE LIFETIME WARRANTY.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE PAGE 2 FOR ADDITIONAL INFORMATION.
RQ04001 · Driver Air Bag Clockspring Failure
Opened Jan 28, 2004 · Closed Jun 4, 2004
Status: closed (inferred from source dates) · Air Bags:frontal
COMPLAINTS REPORT AIR BAG WARNING LIGHT ILLUMINATES, AND THIS MAY BE ACCOMPANIED WITH A NON-FUNCTIONING HORN AND/OR CRUISE CONTROL (IF EQUIPPED).THIS IS INDICATIVE OF AN OPEN-CIRCUIT CLOCKSPRING FAILURE (RESULTS IN NON-FUNCTIONING DRIVER'S AIR BAG), SIMILAR TO THE FAILURE CONDITION THAT WAS THE SUBJECT OF DAIMLERCHRYSLER'S RECALL OF MODEL YEAR 1996-1998.5 MINIVANS (RECALL NO. 02V-293).THIS RECALL QUERY HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA04-013).
EA01007 · Air Bag Clockspring
Opened Feb 21, 2001 · Closed Nov 22, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
RQ00008 · Dc Minivan Fuel Injector Rail Leak
Opened Mar 9, 2000 · Closed Mar 18, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
EA99013 · Post Collision Fuel System
Opened Jun 11, 1999 · Closed Aug 10, 2001
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
No summary supplied.
PE99010 · POST-COLLISION Fuel System Integrity
Opened Feb 3, 1999 · Closed Jun 11, 1999
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
There is no summary currently available
Illustration