CLOCK SPRING FAILED, DISABLING HORN, AIRBAG, AND CRUISE CONTROL. WHEN WE BROUGHT IT TO THE DEALER, WE WERE TOLD THAT IT IS A COMMON PROBLEM, BUT THAT SINCE THE VEHICLE WAS OUT OF WARRANTY WE WOULD HAVE TO PAY $250 FOR THE REPAIR. SINCE THEN, TWO OTHER FRIENDS WITH THE SAME CAR HAVE HAD THEIR CLOCK SPRING FAIL, AND THEY HAVE HAD …
Read full complaint
CLOCK SPRING FAILED, DISABLING HORN, AIRBAG, AND CRUISE CONTROL. WHEN WE BROUGHT IT TO THE DEALER, WE WERE TOLD THAT IT IS A COMMON PROBLEM, BUT THAT SINCE THE VEHICLE WAS OUT OF WARRANTY WE WOULD HAVE TO PAY $250 FOR THE REPAIR. SINCE THEN, TWO OTHER FRIENDS WITH THE SAME CAR HAVE HAD THEIR CLOCK SPRING FAIL, AND THEY HAVE HAD TO PAY FOR THE REPAIR. CHRYSLER HAS ISSUED A SERVICE BULLETIN (08-010-01) FOR THE REPAIR, BUT REFUSES TO PROVIDE THE REPAIR AT NO, OR A REDUCED, COST. AS THE HORN AND AIRBAG WERE DISABLED, I FEEL THAT THIS SHOULD HAVE BEEN COVERED AS A SAFETY ISSUE RECALL.*AK
NHTSA ODI #754015
Mileage unknown · Oct 21, 2001
Air BagsElectrical SystemVehicle Speed Control
AIRBAG LIGHT CAME ON INTERMITTENTLY FOR A WEEK; HAS STAYED ON PERMANENTLY EVER SINCE OCT 8, 2001. CRUISE CONTROL NO LONGER WORKS. HORN IS STILL WORKING AS OF 10/21/01.
NHTSA ODI #753488
Mileage unknown · Sep 20, 2001
Air BagsElectrical SystemVehicle Speed Control
AIRBAG, CRUISE CONTROL AND HORN WERE INOPERABLE CAUSING A SAFETY ISSUE. *AK
NHTSA ODI #752407
Mileage unknown · Aug 20, 2001
Air BagsElectrical SystemVehicle Speed Control
WHILE TRAVELING 45MPH AIR BAG LIGHT FLASHED ON/OFF UNTIL IT REMAINED CONTINOUSLY ON. PROBLEM EFFECTED HORN USAGE AND CRUISE CONTROL. TOOK VEHICLE TO DEALERSHIP, AND WAS INFORMED BY MECHANIC THAT CLOCK SPRING NEEDED TO BE REPLACED DUE TO BEING BROKEN. *AK
NHTSA ODI #894715
Mileage unknown · Aug 13, 2001
Air BagsVehicle Speed Control
AIRBAG LIGHT INTERMITTENTLY COMES ON AND OFF. CRUISE CONTROL OFF SWITCH DOESN'T DISENGAGE VEHICLE, ONLY IF BRAKES ARE APPLIED CRUISE CONTROL SHUTS OFF. STEERING WHEEL MAKES A SQUEAKY NOISE, BUT DOESN'T SEEM TO AFFECT CONSUMER'S STEERING ABILITY. DEALER ADVISED CONSUMER TO BRING VEHICLE IN TO BE INSPECTED.*AK
NHTSA ODI #894115
Mileage unknown · Aug 10, 2001
Air BagsElectrical System
HORN DOESN'T WORK. CLOCKSPRING WAS BAD.*AK
NHTSA ODI #750205
Mileage unknown · Aug 10, 2001
Air Bags
AIR BAG LIGHTON. CLOCKSPRING WAS BAD.*AK
NHTSA ODI #750203
Mileage unknown · Aug 7, 2001
Air Bags
NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
NHTSA ODI #749997
Mileage unknown · Aug 6, 2001
Air BagsVehicle Speed Control
AIR BAG LIGHT WOULD COME ON/OFF WHILE CRUISE CONTROL FAILED TO OPERATE PROPERLY. DEALERSHIP EXAMINED VEHICLE AND DETERMINED THAT CLOCK SPRING NEEDED TO BE REPLACED. *AK *SLC
NHTSA ODI #893449
Mileage unknown · Jul 30, 2001
Air Bags
SERVICE DETERMINED THAT CLOCKSPRING NEEDED REPLACEMENT CAUSING AIR BAG LIGHT TO STAY ON. I SAW SHOW ON FOX 5 THAT SAID THIS MAY BE A MANUFACTURER'S DEFECT SUBJECT TO RECALL. *AK
ON CERTAIN MINI VANS, THE CLOCKSPRING ASSEMBLY MAY HAVE BEEN WOUND INCORRECTLY DURING THE VEHICLE ASSEMBLY PROCESS.
Consequence & remedy
Consequence: THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL VEHICLES WITH 70,000 MILES OR LESS. AN EXTENDED LIFETIME WARRANTY WILL ALSO BE PLACED ON THIS COMPONENT FOR ALL AFFECTED VEHICLES, REGARDLESS OF MILEAGE. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. OWNER NOTIFICATION BEGAN NOVEMBER 18, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A SEAL ON THE VEHICLE FUEL RAILS TO PREVENT EXTERNAL LEAKAGE OF FUEL FROM THE FUEL RAIL CROSSOVER TUBE, SHOULD THE EXISTING O-RINGS CONTINUE TO DEGRADE. OWNER NOTIFICATION BEGAN ON JANUARY 25, 2002. DUE TO THE LARGE QUANTITY OF VEHICLES INVOLVED IN THIS CAMPAIGN, THE OWNER NOTIFICATION WILL BE PHASED OVER THE NEXT SEVERAL MONTHS. HOWEVER, IF A VEHICLE IS LEAKING FUEL FROM THE O-RINGS, THE VEHICLE SHOULD BE TAKEN INTO A DEALER TO HAVE THIS REPAIRED AS SOON AS POSSIBLE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
VEHICLE DESCRIPTION: MINI VANS EQUIPPED WITH INTEGRATED CHILD SEATS. THE SHOULDER HARNESS RESTRAINT ON THE INTEGRATED CHILD SEAT CAN BECOME DIFFICULT TO EXTRACT WHEN THE SAFETY BELT LATCH PLATE BECOMES CONTAMINATED.
Consequence & remedy
Consequence: THIS CAN CAUSE DIFFICULTY IN RELEASING A CHILD FROM THE RESTRAINT.
Remedy: DEALERS WILL CLEAN THE LATCH MECHANISM. AN EXTENDER WILL BE ADDED TO THE EMERGENCY RELEASE ANCHOR FOR THE CHILD SEAT SAFETY BELTS SO THAT THE RELEASE CLIPS ARE MORE VISIBLE AND ACCESSIBLE TO THE OPERATOR IN THE EVENT THAT THE RETRACTOR MECHANISM CAN NOT BE UNLOCKED. IN ADDITION, AN INSTRUCTIONAL OWNER'S MANUAL SUPPLEMENT CARD WILL BE PROVIDED.
VEHICLE DESCRIPTION: PASSENGER MINIVANS EQUIPPED WITH P215/65R15 GOODYEAR CONQUEST TIRES MOUNTED ON STEEL WHEEL. THE TIRES CAN EXPERIENCE A SUDDEN AIR PRESSURE LOSS WITHOUT WARNING.
Consequence & remedy
Consequence: SUDDEN TIRE FAILURE COULD RESULT IN A LOSS OF DRIVER CONTROL OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE TIRES THAT WERE MOUNTED ON STEEL WHEELS.
THE MASTER CYLINDER REAR SEAL, BETWEEN THE HYDRAULIC FLUID AND THE VACUUM RESERVOIR, MAY NOT SEAL ADEQUATELY ALLOWING HYDRAULIC FLUID TO BE DRAWN INTO THE POWER ASSIST VACUUM RESERVOIR.
Consequence & remedy
Consequence: AS THE HYDRAULIC FLUID IN THE MASTER CYLINDER RESERVOIR DECREASES, THE LEVEL SENSOR WILL DETECT THE LOSS OF FLUID AND ILLUMINATE THE INSTRUMENT PANEL BRAKE WARNING LAMP. CONTINUED OPERATION OF THE VEHICLE WITH THE WARNING LAMP ILLUMINATED CAN RESULT IN EXTENDED STOPPING DISTANCES.
Remedy: DEALERS WILL REPLACE THE BRAKE MASTER CYLINDER ON ALL AFFECTED VEHICLES. ADDENDUM (4-14-97): VEHICLES INSPECTED PER CHRYSLER RECALL NO. 707 AND FOUND TO BE OUTSIDE THE LISTED SUSPECT MASTER CYLINDER DATE CODE RANGE, MUST NOW HAVE THE MASTER CYLINDER PRIMARY PISTON REPLACED (CHRYSLER RECALL NO. 714).
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6
EA01007 · Air Bag Clockspring
Opened Feb 21, 2001 · Closed Nov 22, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
RQ00008 · Dc Minivan Fuel Injector Rail Leak
Opened Mar 9, 2000 · Closed Mar 18, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
EA99013 · Post Collision Fuel System
Opened Jun 11, 1999 · Closed Aug 10, 2001
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
No summary supplied.
PE99010 · POST-COLLISION Fuel System Integrity
Opened Feb 3, 1999 · Closed Jun 11, 1999
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
There is no summary currently available
EA97003 · Integrated Child Seat Belt Lockup
Opened Jan 31, 1997 · Closed Aug 19, 1998
Status: closed (inferred from source dates) · Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
Additional source detail variants (2)
Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
ODI CONTINUES TO RECEIVE COMPLAINTS ALLEGING LATCHING/RETRACTOR MECHANISM PROBLEMS.CHRYSLER'S ASSESSMENT OF THE PROBLEM INDICATES THAT OWNERS OF THE VEHICLES ARE NOT ADHERING TO THE CLEANING REQUIREMENTS FOR THE SEAT.THE SEAT APPEARS TO MALFUNCTION IF CRUMBS OF FOOD OR BEVERAGE RESIDUE ACCUMULATES ON THE LATCHING TONGUE IN THEWELL LOCATED BETWEEN THE CHILD'S LEGS.ODI HAS 19 COMPLAINTS OF RETRACT LOCKUP.SEVEN OF THESE COMPLAINTS REPORT CUTTING THE STRAPS TO REMOVE THE CHILD.TWO OF THE SEVEN CONSUMERS ALLEGE THE CHILD WAS CHOKING.CHRYSLER REPORTS 60 OWNER/FIELD REPORTS WHICH INDICATED 19 HARNESSES WERE CUT TO REMOVE THE CHILDREN.ADDITIONAL INFORMATION IS NEEDED TO FULLY ASSESS THE SAFETY CONSEQUENCE OF THE ALLEGED DEFECT AND TO EVALUATE THE CHRYSLER CORPORATION'S RATIONAL FOR NOT CONDUCTING A SAFETY RECALL CAMPAIGN.
1997 Dodge Grand Caravan Problems, Complaints & Recalls | Skip That Year
Illustration