NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
1,157 reports110,000 miles · Feb 27, 2004
Service Brakes, Hydraulic
WHILE DRIVING VEHICLE LOST BRAKE POWER, AND SOMEHOW THE DRIVER STOPPED THE VEHICLE WITHOUT INCIDENT. CONSUMER DETERMINED THAT A HOLE IN THE BRAKE DIFFERENTIAL PROPORTIONAL VALVE CAUSED THE BRAKE FLUID TO LEAK. VEHICLE WAS TAKEN TO THE DEALER, WHO STATED THAT VALVE WAS WELDED IN THE WRONG SPOT, CAUSING THE VALVE TO WEAR OUT O…
Read full complaint
WHILE DRIVING VEHICLE LOST BRAKE POWER, AND SOMEHOW THE DRIVER STOPPED THE VEHICLE WITHOUT INCIDENT. CONSUMER DETERMINED THAT A HOLE IN THE BRAKE DIFFERENTIAL PROPORTIONAL VALVE CAUSED THE BRAKE FLUID TO LEAK. VEHICLE WAS TAKEN TO THE DEALER, WHO STATED THAT VALVE WAS WELDED IN THE WRONG SPOT, CAUSING THE VALVE TO WEAR OUT OVER A PERIOD OF TIME. BRAKE DIFFERENTIAL PROPORTIONAL VALVE WAS REPLACED . *AK
NHTSA ODI #10060951
114,800 miles · Feb 22, 2004
Air BagsVehicle Speed Control
"AIR BAG" LIGHT IS ILLUMINATED (KNOWN PROBLEM), THE CRUISE CONTROL WILL ACTIVATE UPON PUSHING THE BUTTON, BUT THE CANCEL BUTTON WHEN PUSHED DOES NOT DEACTIVATE THE CRUISE CONTROL...THE DEACTIVATION OF THE CRUISE CONTROL REQUIRES THE BRAKE TO BE APPLIED. CONTROL OF THE VEHICLE ON WET ROADS, USING CRUISE CONTROL, AND HAVING TO D…
Read full complaint
"AIR BAG" LIGHT IS ILLUMINATED (KNOWN PROBLEM), THE CRUISE CONTROL WILL ACTIVATE UPON PUSHING THE BUTTON, BUT THE CANCEL BUTTON WHEN PUSHED DOES NOT DEACTIVATE THE CRUISE CONTROL...THE DEACTIVATION OF THE CRUISE CONTROL REQUIRES THE BRAKE TO BE APPLIED. CONTROL OF THE VEHICLE ON WET ROADS, USING CRUISE CONTROL, AND HAVING TO DEACTIVATE THE CRUISE CONTROL VIA THE BRAKES....CAN BE A BIT OF A CHALLENGE...THANKS!! - STEVE DOWLING. *JB
NHTSA ODI #10058700
90,000 miles · Feb 20, 2004
Fuel System, Gasoline
FUEL RAIL LEAKED. RECALL 00V26800 REPAIRS WERE PERFORMED; HOWEVER PROBLEM STILL EXISTS. *AK
NHTSA ODI #10059399
109,000 miles · Feb 19, 2004
Electrical SystemFire
SMOKE APPEARED FROM UNDER THE HOOD, THEN BURST INTO FLAMES. THIS OCCURRED WHILE THE VEHICLE WAS PARKED AND TURNED OFF. THE VEHICLE WAS TOTALED. *AK *SC
NHTSA ODI #10053348
109,000 miles · Feb 12, 2004
Engine And Engine Cooling
WHEN DRIVING THROUGH WATER SERPENTINE BELT SLIPPED OFF FROM THE ENGINE, CAUSING VEHICLE TO LOSE POWER STEERING. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK
NHTSA ODI #10058023
Mileage unknown · Feb 11, 2004
Electrical System
HAD THE 1696 DODGE GRAND CARAVAN FOR ALMOST 3 YEARS , ELECTRICAL PROBLEMS I THINK. THE SPEEDOMETER, ODOMETER, GEAR SELECTOR, WATER COOLANT GAUGE, FUEL GAUGE STOPS WORKING WHILE DRIVING AND WHEN I SHUT CAR OFF THE GEAR SELECTOR AND ODOMETER STAYS ILLUMINATED EVEN WITH THE CAR OFF AND LIGHTS OFF , OR ON.. ALSO THE TACHOMETER FREEZ…
Read full complaint
HAD THE 1696 DODGE GRAND CARAVAN FOR ALMOST 3 YEARS , ELECTRICAL PROBLEMS I THINK. THE SPEEDOMETER, ODOMETER, GEAR SELECTOR, WATER COOLANT GAUGE, FUEL GAUGE STOPS WORKING WHILE DRIVING AND WHEN I SHUT CAR OFF THE GEAR SELECTOR AND ODOMETER STAYS ILLUMINATED EVEN WITH THE CAR OFF AND LIGHTS OFF , OR ON.. ALSO THE TACHOMETER FREEZES UP ON A CERTAIN RPM . DEPENDING WHAT THE RPM WAS WHEN EVERYTHING STOPED WORKING RIGHT.. WINDSHIELD WIPERS TURN ON AUTOMATICALLY BUT 99.9% OF THE TIME THEY WONT SHUT OFF EVEN IF I SELECT IT TO SHUT OFF , THEY KEEP GOING AND GOING EVEN ON DRY DAYS AND NO RAIN .TOOK IT TO MECHANIC AND THEY CANT FIND WHAT IS WRONG WITH IT AND THEY CHARGE ME 60 TO 90 DOLLARS JUST TO TEST IT AND THEY NEVER COME UP WITH A SOLUTION UNLESS THEY DISCONNECT THE BATTERY AND LET IT SIT FOR A FEW MINUTES SO THE COMPUTER OR SOMETHING RESETS, BUT THIS HAPPENS ABOUT EVERY 3 TO 6 MONTHS AND ALSO BEFORE THIS HAPPENS THE CAR RUNS ROUGH AT IDLE OR SITTING AT A RED LIGHT OR AT A STOP . THE DRIVER SEAT BUCKLE SOMETIMES DONT UNLATCH, I HAVE TO USE EXTRA FORCE TO UNLATCH THEM, SOMETIMES I DONT EVEN WEAR A SEAT BELT CAUSE I AM SCARED THAT IF SOMETHING HAPPENS AND I NEED TO GET OUT OF THE CAR QUICKLY THAT I WONT BE ABLE TO. THE MIDDLE BENCH SEAT SEEMS LOOSE , EVERYTHIME I COME TO A STOP OR I TAKE OFF A CLUCKING SOUND COMES FROM THE MIDDLE ROW SEATS, I CHECKED IT AND IT SEEMED LIKE ITS ALL LOCKED IN BUT I DONT TRUST IT.. I WOULD NEVER PURCHASE A CHRYSLER PRODUCT EVER AGAIN EVEN IF IT IS GIVEN TO ME FOR FREE OR EVEN GIVE IT TO MY WORST ENEMY.. THANK YOU .. JZ.*AK
NHTSA ODI #10056979
149,000 miles · Feb 10, 2004
Engine And Engine Cooling
CONSUMER COMPLAINED ABOUT GAS FUMES. WHILE DRIVING THE SMELL OF GAS FUMES WAS STRONG, AND WAS COMING THROUGH THE VENTS. *AK
NHTSA ODI #10057839
98,000 miles · Feb 5, 2004
Engine And Engine Cooling
WHILE STOPPED THE BELT TENSIONER SNAPPED AND CAUSED LOSS OF POWER STEERING. THE CONSUMER MANAGED TO PULL OVER AND HAD THE VEHICLE TOWED. *NM
NHTSA ODI #10057596
Mileage unknown · Jan 31, 2004
Power Train
TRANSMISSION FAILURE 1996 DODGE GRAND CARAVAN. WILL NOT GO INTO GEAR, WILL NOT DRIVE OR GO IN REVERSE. LOUD CLUNKING NOISE AND CAR JERKED. COULD HAVE CAUSED ACCIDENT. *JB
NHTSA ODI #10056227
Mileage unknown · Jan 16, 2004
Exterior Lighting
THE VEHICLE DIDN'T PASS THE STATE INSPECTION BECAUSE OF POOR LIGHTING. THE HEADLIGHTS NEEDED TO BE REPLACED. THE COST WAS $300 EACH PLUS LABOR. *AK THE OUTSIDE OF THE HEADLIGHT LENSES WERE COVERED WITH FROSTED LIKE COVERING OVER THE LENSES. THIS ALSO CUT THE VISIBILITY AT NIGHT TO AN UNSAFE LIGHTING. *SC *JB
NHTSA ODI #10040530
Official recalls
9Nov 7, 2002
ON CERTAIN MINI VANS, THE CLOCKSPRING ASSEMBLY MAY HAVE BEEN WOUND INCORRECTLY DURING THE VEHICLE ASSEMBLY PROCESS.
Consequence & remedy
Consequence: THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL VEHICLES WITH 70,000 MILES OR LESS. AN EXTENDED LIFETIME WARRANTY WILL ALSO BE PLACED ON THIS COMPONENT FOR ALL AFFECTED VEHICLES, REGARDLESS OF MILEAGE. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. OWNER NOTIFICATION BEGAN NOVEMBER 18, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Sep 13, 2000
VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A SEAL ON THE VEHICLE FUEL RAILS TO PREVENT EXTERNAL LEAKAGE OF FUEL FROM THE FUEL RAIL CROSSOVER TUBE, SHOULD THE EXISTING O-RINGS CONTINUE TO DEGRADE. OWNER NOTIFICATION BEGAN ON JANUARY 25, 2002. DUE TO THE LARGE QUANTITY OF VEHICLES INVOLVED IN THIS CAMPAIGN, THE OWNER NOTIFICATION WILL BE PHASED OVER THE NEXT SEVERAL MONTHS. HOWEVER, IF A VEHICLE IS LEAKING FUEL FROM THE O-RINGS, THE VEHICLE SHOULD BE TAKEN INTO A DEALER TO HAVE THIS REPAIRED AS SOON AS POSSIBLE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Aug 9, 1999
VEHICLE DESCRIPTION: MINIVANS. FUEL CAN LEAK FROM THE FUEL TANK AT THE INTERFACE OF THE FUEL PUMP MODULE ATTACHMENT.
Consequence & remedy
Consequence: IF A FUEL LEAK OCCURS IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Remedy: DEALERS WILL REPLACE THE FUEL PUMP MODULE ATTACHING NUT WITH A NUT THAT INCLUDES TIGHTER DESIGN TOLERANCES. THE SEALING O-RING WILL ALSO BE REPLACED.
Aug 6, 1998
VEHICLE DESCRIPTION: MINI VANS EQUIPPED WITH INTEGRATED CHILD SEATS. THE SHOULDER HARNESS RESTRAINT ON THE INTEGRATED CHILD SEAT CAN BECOME DIFFICULT TO EXTRACT WHEN THE SAFETY BELT LATCH PLATE BECOMES CONTAMINATED.
Consequence & remedy
Consequence: THIS CAN CAUSE DIFFICULTY IN RELEASING A CHILD FROM THE RESTRAINT.
Remedy: DEALERS WILL CLEAN THE LATCH MECHANISM. AN EXTENDER WILL BE ADDED TO THE EMERGENCY RELEASE ANCHOR FOR THE CHILD SEAT SAFETY BELTS SO THAT THE RELEASE CLIPS ARE MORE VISIBLE AND ACCESSIBLE TO THE OPERATOR IN THE EVENT THAT THE RETRACTOR MECHANISM CAN NOT BE UNLOCKED. IN ADDITION, AN INSTRUCTIONAL OWNER'S MANUAL SUPPLEMENT CARD WILL BE PROVIDED.
Jul 18, 1996
THE BOLTS WHICH SECURE THE INTEGRATED CHILD SEAT MODULES TO THE SEAT FRAME CAN BREAK.
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE ACCIDENT, THE CHILD SEAT MAY NOT PROVIDE ADEQUATE PROTECTION TO THE OCCUPANT.
Remedy: DEALERS WILL REPLACE THE INTEGRATED CHILD SEAT MODULE BOLTS.
Jan 16, 1996
A STATIC ELECTRIC CHARGE CAN BUILD UP ON THE UNGROUNDED METAL SECTION OF THE FUEL FILLER TUBE.
Consequence & remedy
Consequence: THIS CONDITION COULD CAUSE A SPARK TO OCCUR WHEN FUELING THE VEHICLE AND POSSIBLY IGNITE THE FUEL VAPORS.
Remedy: DEALERS WILL INSTALL A GROUND STRAP FOR THE FUEL FILLER TUBE.
Jan 11, 1996
IN CERTAIN VEHICLES, THE ENGINE CYLINDER HEAD OIL GALLEY PLUG DOES NOT SEAL PROPERLY AND ENGINE CYLINDER HEAD OIL IS NOT ADEQUATELY RETAINED.
Consequence & remedy
Consequence: INADEQUATE SEALING AND RETENTION OF THE PLUG CAN RESULT IN OIL LEAKAGE WHICH COULD CAUSE A FIRE IN THE ENGINE COMPARTMENT.
Remedy: DEALERS WILL INSTALL AN EXPANSION PLUG AND RETAINING BRACKET OVER THE CYLINDER HEAD OIL GALLEY PLUG.
Dec 8, 1995
THE FUEL TANK ROLLOVER VALVE CAN ALLOW FUEL TO PASS INTO THE VAPOR CANISTER RESULTING IN THE POTENTIAL FOR FUEL LEAKAGE.
Consequence & remedy
Consequence: FUEL LEAKAGE INCREASES THE POTENTIAL FOR A VEHICLE FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL TANK FILLER TUBE WITH A FILLER TUBE THAT HAS AN ADDITIONAL ROLLOVER VALVE. THE ASSOCIATED ROLLOVER VALVE VAPOR HOSES WILL BE REROUTED.
Nov 28, 1995
THE BOLTS WHICH SECURE THE REAR BENCH SEATS TO THE SEAT RISERS MAY BE EMBRITTLED AND FRACTURE.
Consequence & remedy
Consequence: IN CASE OF AN ACCIDENT, THE BOLT MAY FAIL AND CAN CAUSE THE SEAT TO BREAK AWAY FROM THE SEAT RISERS, WHICH INCREASES THE POTENTIALOF INJURY TO ITS OCCUPANTS.
Remedy: DEALERS WILL REPLACE THE REAR BENCH SEAT TO RISER BOLTS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
11EA01007 · Air Bag Clockspring
Opened Feb 21, 2001 · Closed Nov 22, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
PE00032 · Air Bag Clockspring
Opened Aug 8, 2000 · Closed Feb 21, 2001
Status: closed (inferred from source dates) · Air Bags
There is no summary currently available
RQ00008 · Dc Minivan Fuel Injector Rail Leak
Opened Mar 9, 2000 · Closed Mar 18, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
EA99013 · Post Collision Fuel System
Opened Jun 11, 1999 · Closed Aug 10, 2001
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
No summary supplied.
PE99010 · POST-COLLISION Fuel System Integrity
Opened Feb 3, 1999 · Closed Jun 11, 1999
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
There is no summary currently available
EA97002 · Fuel Tank Leaks
Opened Jan 31, 1997 · Closed Feb 10, 1998
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
THIS ENGINEERING ANALYSIS WAS OPENED ON JANUARY 31, 1997 BASED ON INFORMATION GATHERED DURING PRELIMINARY EVALUATION (PE), PE96-051. THE PE WAS OPENED ON AUGUST 19, 1996, TO INVESTIGATE ALLEGATIONS OF FUEL LEAKAGE FROM THE AREA WHERE THE FUEL PUMP/SENDING UNIT JOINS THE FUEL TANK.FOR BREVIDY, THIS AREA WILL BE REFERRED TO AS THE PUMP/TANK INTERFACE.THESE ALLEGATIONS WERE FIRST RECEIVED BY ODI ON AUGUST 2, 1996 WHILE INVESTIGATING ALLEGATIONS OF CHRYSLER MINIVAN THROTTLE SHAFT HAND-UP, AND UNCONTROLLED ENGINE SPEED, IN PE96-036.WHILE DISCUSSING THAT ISSUE WITH A FLEET, IT WAS ALLEGED THAT AT LEAST 10(OUT OF 40) 1996 EARLY PRODUCTION CHRYSLER MINIVANS LEAKED FUEL FROM THE PUMP/TANK INTERFACE.ANALYSIS OF THE COMPLAINT AND WARRANTY DATA INDICATE FUEL TANK LEAKAGE INCIDENTS IN THE SUBJECT VEHICLES PREDOMINATLY AFFECTED EARLY PRODUCTION VEHICLES.THE DATA INVOLVING CONFIRMED INCIDENTS OF TANK/PUMP INTERFACE LEAKS SUGGEST THAT THOSE FAILURES HAVE BEEN DECLINING SINCE JULY 1996.ODI HAS RECEIVED NO REPORTS OF THE SUBJECT CONDITION INVOLVING ORIGINAL EQUIPMENT PUMPS AND TANKS SINCE SEPTEMBER, 1997.CURRENTLY THIS ISSSUE DOES NOT REQRESENT A CONTINUING FIELD CONCERN.ODI WILL CONTINUE TO MONITOR THE SUBJECT VEHICLES FOR FUEL LEAKS OF ANY TYPE.A SAFETY RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURED DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA97003 · Integrated Child Seat Belt Lockup
Opened Jan 31, 1997 · Closed Aug 19, 1998
Status: closed (inferred from source dates) · Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
Additional source detail variants (2)
Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
SQ96016 · Integrated Child Seat Belt Lockup
Opened Sep 18, 1996 · Closed Feb 4, 1997
Status: closed (inferred from source dates) · Seat Belts:integrated Child Seat
ODI CONTINUES TO RECEIVE COMPLAINTS ALLEGING LATCHING/RETRACTOR MECHANISM PROBLEMS.CHRYSLER'S ASSESSMENT OF THE PROBLEM INDICATES THAT OWNERS OF THE VEHICLES ARE NOT ADHERING TO THE CLEANING REQUIREMENTS FOR THE SEAT.THE SEAT APPEARS TO MALFUNCTION IF CRUMBS OF FOOD OR BEVERAGE RESIDUE ACCUMULATES ON THE LATCHING TONGUE IN THEWELL LOCATED BETWEEN THE CHILD'S LEGS.ODI HAS 19 COMPLAINTS OF RETRACT LOCKUP.SEVEN OF THESE COMPLAINTS REPORT CUTTING THE STRAPS TO REMOVE THE CHILD.TWO OF THE SEVEN CONSUMERS ALLEGE THE CHILD WAS CHOKING.CHRYSLER REPORTS 60 OWNER/FIELD REPORTS WHICH INDICATED 19 HARNESSES WERE CUT TO REMOVE THE CHILDREN.ADDITIONAL INFORMATION IS NEEDED TO FULLY ASSESS THE SAFETY CONSEQUENCE OF THE ALLEGED DEFECT AND TO EVALUATE THE CHRYSLER CORPORATION'S RATIONAL FOR NOT CONDUCTING A SAFETY RECALL CAMPAIGN.
PE96051 · Fuel Leaks From The Gas Tank
Opened Aug 19, 1996 · Closed Jan 31, 1997
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
ANALYSIS TO DATE INDICATES THAT SOME OF THE SUBJECT VEHICLESCONTINUE TO EXPERIENCE FUEL LEAKS FROM THE FUEL TANK AT THE SENDING UNIT INTERFACE.MOST OFTEN THE LEAK INVOLVES THE O-RING SEAL.
PE96008 · Safety Blt Latch Operation
Opened Jan 25, 1996 · Closed Jun 28, 1996
Status: closed (inferred from source dates) · Seat Belts
There is no summary currently available
PE95053 · Fuel Leakeage From Rollover Valve
Opened Oct 25, 1995 · Closed Dec 22, 1995
Status: closed (inferred from source dates) · Engine And Engine Cooling:exhaust System:emission Control
There is no summary currently available
Illustration