Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 10 of 108 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Power Train. Review the 24 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Structure. Review the 20 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine And Engine Cooling. Review the 14 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
4 crash reports1 fire reports1 injury reports
What owners actually said
108 reports
Mileage unknown · Dec 4, 2003
Structure
THERE IS A STRUCTURAL WEAKNESS IN THE FRONT DOORS OF DODGE/CHRYSLER MINIVANS THAT CAUSES DOOR FAILURE. THE DOORS BECOME IMPROPERLY ALIGNED WITH THE DOOR FRAME, MAKING THEM DIFFICULT OR IMPOSSIBLE TO OPEN AND CLOSE. THE DOOR ALSO FAILS TO LATCH PROPERLY AS A RESULT OF MISALIGNMENT. THIS CAN CAUSE THE DOOR TO FLY OPEN SUDDENLY …
Read full complaint
THERE IS A STRUCTURAL WEAKNESS IN THE FRONT DOORS OF DODGE/CHRYSLER MINIVANS THAT CAUSES DOOR FAILURE. THE DOORS BECOME IMPROPERLY ALIGNED WITH THE DOOR FRAME, MAKING THEM DIFFICULT OR IMPOSSIBLE TO OPEN AND CLOSE. THE DOOR ALSO FAILS TO LATCH PROPERLY AS A RESULT OF MISALIGNMENT. THIS CAN CAUSE THE DOOR TO FLY OPEN SUDDENLY WHILE THE VEHICLE IS MOVING, PARTICULARLY WHEN TURNING A CORNER. IT HAPPENED TO ME, BUT FORTUNATELY MY PASSENGER WAS WEARING HIS SEATBELT AND WAS NOT THROWN OUT OF THE CAR. OTHERS MIGHT NOT BE SO LUCKY. TWO AND A HALF YEARS AGO, WHEN THE DOORS ON MY 1995 GRAND CARAVAN BEGAN TO FAIL, I WENT TO AN AUTOBODY SHOP FOR REPAIR, THINKING IT WAS A SIMPLE MATTER OF REPAIRING WELDS. I WAS TOLD THAT THE DOOR HAD BEEN REPAIRED BEFORE (BY A PREVIOUS OWNER). I HAVE SINCE LEARNED THAT MY LOCAL DODGE/CHRYSLER DEALER HAS REPAIRED MANY DOORS, SO THIS IS NOT AN UNCOMMON PROBLEM. UNFORTUNATELY, AT LEAST IN THE CASE OF MY VEHICLE, THE DOORS WERE BRAISED, MAKING IT IMPOSSIBLE, I UNDERSTAND, TO WELD THEM. IT LOOKS TO ME AS IF THE ONLY LASTING REPAIR WOULD INVOLVE REINFORCING THE DOOR FRAME, WHICH WOULD INVOLVE EXTENSIVE BODY WORK. MY DOORS ARE FAILING AGAIN, AND I WANT A FIX THAT WILL LAST! IT SCARES ME TO DRIVE THE CAR, BECAUSE I'M AFRAID I WON'T BE ABLE TO GET OUT OF IT IN AN EMERGENCY. *NLM
NHTSA ODI #10049202
Mileage unknown · Dec 2, 2003
Child Seat
INTEGRATED CHILD SEAT LOCATED IN THE MIDDLE ROW HAD A FIVE POINT HARNESS SYSTEM. THE CABLE THAT LOCKED THE SEAT BELT IN PLACE BROKE, AND SEAT BELT WILL NOT STAY FASTENED.*AK
NHTSA ODI #10049925
Mileage unknown · Jun 27, 2003
Engine And Engine Cooling
PROBLEMS WITH 1995 DODGE GRAND CARAVAN CUTTING OFF WHILE IN MOTION. *MR MANIFOLD AIR PRESSURE (MAP) SENSOR HAD TO BE REPLACED. *TT *JB
NHTSA ODI #10025062
20,000 miles · Jun 27, 2003
Engine And Engine Cooling
WHILE DRIVING, THE VEHICLE STALLED AND COULD NOT BE RESTARTED FOR ABOUT TEN MINUTES. *NLM THE FIRST OCCURRENCE WAS DIAGNOSED AS A GLITCH, THEN THE PROBLEM WAS DIAGNOSED AS MAP SENSOR. THE CONSUMER HADN'T EXPERIENCE ANOTHER PROBLEM SINCE. *SCC *JB
NHTSA ODI #10018004
Mileage unknown · Jun 26, 2003
Fuel System, Gasoline
THE CONSUMER SMELLED GAS COMING FROM THE TRUCK, HE OPENED THE HOOD AND DISCOVERED A FUEL LEAK. IT WAS CONFIRMED BY A MECHANIC, THERE WAS A FUEL INJECTION RAIL CROSSOVER TUBE LEAK AND THE FUEL RAIL NEEDED TO BE REPLACED. *JB PH *JB
NHTSA ODI #10019524
Mileage unknown · May 1, 2003
Engine And Engine Cooling
WHILE DRIVING THE VEHICLE LEAKED OIL FROM UNDERNEATH THE HOOD. *NLM
NHTSA ODI #10018017
Mileage unknown · Apr 16, 2003
Electrical System
INTERMITTENTLY, THE CRUISE CONTROL, WINDSHIELD WIPERS, AND HORN CAME ON BY THEMSELVES. *JB
NHTSA ODI #10016004
Mileage unknown · Feb 24, 2003
Structure
THE HINGE AND ATTACHMENTS BROKE ON THE VEHICLE. *AK *JB
NHTSA ODI #10007190
Mileage unknown · Feb 12, 2003
Structure
DOOR STRUCTURE : HINGE AND ASSEMBLY.
NHTSA ODI #10007191
103,000 miles · Dec 31, 2002
Structure
THE FRONT DRIVER DOOR FRAME IS BREAKING OFF METAL. TS THE DRIVER DOOR MOUNTING POINT ON THE BODY, IS CRACKING FROM THE FLEX OF THE DOOR AND WILL EVENTUALLY BREAK COMPLETELY OFF. SCC
VEHICLE DESCRIPTION: MINI VANS. THE WIRING THAT INITIATES THE DRIVER AND/OR PASSENGER AIR BAG COULD ELECTRICALLY SHORT CIRCUIT TO GROUND. A SHORT CIRCUIT TO GROUND THAT EXISTS IMMEDIATELY AFTER TURNING THE IGNITION KEY TO THE "ON" OR "START" POSITION CAN CAUSE THE AIR BAG(S) TO INADVERTENTLY DEPLOY.
Consequence & remedy
Consequence: INADVERTENT AIR BAG DEPLOYMENT CAN INJURE A FRONT SEAT OCCUPANT.
Remedy: DEALERS WILL PERFORM AN ELECTRONIC DIAGNOSTIC CHECK. ANY SHORT CIRCUITS IDENTIFIED IN EITHER THE DRIVER'S OR PASSENGER SIDE AIR BAG INITIATOR WIRE CIRCUIT WILL BE REPAIRED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5
DP03002 · Steering Column Separation
Opened May 7, 2003 · Closed Jul 22, 2003
Status: closed (inferred from source dates) · Steering:column
MR. LARRY A. SACKEY SUBMITTED A PETITION TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) BY LETTER DATED APRIL 18, 2003, REQUESTING THAT NHTSAFURTHER INVESTIGATE THE DEFECTIVE COLLAPSIBLE STEERING SHAFT SYSTEM ON 1987-1995 VEHICLES MANUFACTURED BY THE DAIMLERCHRYSLER CORPORATION.IN PART BECAUSE OF 49 CFR ? 30120(G), NHTSA HAS DECIDED TO LIMIT THE SCOPE OF THE PETITION VEHICLES TO 1993-1995 MODELS, EXCLUDING THE 1993 JEEP GRAND CHEROKEE AND 1994-1995 DODGE RAM SERIES TRUCKS THAT WERE RECALLED (93V210 & 96V230) FOR STEERING COLUMN FAILURE.IF THE ANALYSIS OF THESE VEHICLES HAD IDENTIFIED A POTENTIAL PROBLEM, THE SCOPE COULD HAVE BEEN EXPANDED IN AN INVESTIGATION.A REVIEW OF ODI'S DATA BASE SHOWS NO RECENT COMPLAINTS AND A LACK OF A COMPLAINT TREND CONCERNING THE SUBJECT ISSUE ON THE SUBJECT VEHICLES AS A WHOLE OR BY INDIVIDUAL MODELS.THEREFORE, THE PETITION IS DENIED.FOR DETAILS, SEE FEDERAL REGISTER NOTICE VOLUME 68, NO. 130, JULY 8, 2003.
PE97049 · Air Bag Circuit/windshield Wiper Motor
Opened Nov 18, 1997 · Closed Mar 17, 1998
Status: closed (inferred from source dates) · Visibility
There is no summary currently available
EA97003 · Integrated Child Seat Belt Lockup
Opened Jan 31, 1997 · Closed Aug 19, 1998
Status: closed (inferred from source dates) · Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
Additional source detail variants (2)
Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
ODI CONTINUES TO RECEIVE COMPLAINTS ALLEGING LATCHING/RETRACTOR MECHANISM PROBLEMS.CHRYSLER'S ASSESSMENT OF THE PROBLEM INDICATES THAT OWNERS OF THE VEHICLES ARE NOT ADHERING TO THE CLEANING REQUIREMENTS FOR THE SEAT.THE SEAT APPEARS TO MALFUNCTION IF CRUMBS OF FOOD OR BEVERAGE RESIDUE ACCUMULATES ON THE LATCHING TONGUE IN THEWELL LOCATED BETWEEN THE CHILD'S LEGS.ODI HAS 19 COMPLAINTS OF RETRACT LOCKUP.SEVEN OF THESE COMPLAINTS REPORT CUTTING THE STRAPS TO REMOVE THE CHILD.TWO OF THE SEVEN CONSUMERS ALLEGE THE CHILD WAS CHOKING.CHRYSLER REPORTS 60 OWNER/FIELD REPORTS WHICH INDICATED 19 HARNESSES WERE CUT TO REMOVE THE CHILDREN.ADDITIONAL INFORMATION IS NEEDED TO FULLY ASSESS THE SAFETY CONSEQUENCE OF THE ALLEGED DEFECT AND TO EVALUATE THE CHRYSLER CORPORATION'S RATIONAL FOR NOT CONDUCTING A SAFETY RECALL CAMPAIGN.
PE96008 · Safety Blt Latch Operation
Opened Jan 25, 1996 · Closed Jun 28, 1996
Status: closed (inferred from source dates) · Seat Belts
There is no summary currently available
1995 Dodge Grand Caravan Problems, Complaints & Recalls | Skip That Year
Illustration