TL* THE CONTACT OWNS A 1994 DODGE GRAND CARAVAN. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBERS: 00V305000 (STEERING), 99V213000 (STRUCTURE), 99V113000 (AIR BAGS), AND 95I00100 (LATCHES/LOCKS/LINKAGES); HOWEVER, THE PARTS TO DO THE REPAIRS WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONA…
Read full complaint
TL* THE CONTACT OWNS A 1994 DODGE GRAND CARAVAN. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBERS: 00V305000 (STEERING), 99V213000 (STRUCTURE), 99V113000 (AIR BAGS), AND 95I00100 (LATCHES/LOCKS/LINKAGES); HOWEVER, THE PARTS TO DO THE REPAIRS WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.
NHTSA ODI #10716533
140,716 miles · Jan 14, 2005
Structure
CONSUMER STATED THE SLIDING DOOR FELL OFF TRACK . THE PART HAD BEEN REPAIRED THREE TIMES, HOWEVER THE PROBLEM RECURRED. *AK THE CONSUMER STATED THAT THE PARTS SEEM TO WEAR TO EASY AND RUST WHEN THEY SHOULD NOT. *TC
NHTSA ODI #10092039
120,000 miles · Jul 28, 2003
Structure
WHEN THE CONSUMER CLOSED THE REAR HATCH THE HINGE ON THE UPPER RIGHT CAME OFF. UPON FURTHER INVESTIGATION IT WAS DISCOVERED THAT THE BOLT HAD BROKEN IN HALF AND ONE HALF OF THE BOLT WAS STILL ATTACHED TO THE DOOR WHILE OTHER HALF FELL TO THE GROUND. THE PRESSURIZED MECHANISM WAS LOCKED IN THE OPEN POSITION AND IN ORDER TO CLOSE…
Read full complaint
WHEN THE CONSUMER CLOSED THE REAR HATCH THE HINGE ON THE UPPER RIGHT CAME OFF. UPON FURTHER INVESTIGATION IT WAS DISCOVERED THAT THE BOLT HAD BROKEN IN HALF AND ONE HALF OF THE BOLT WAS STILL ATTACHED TO THE DOOR WHILE OTHER HALF FELL TO THE GROUND. THE PRESSURIZED MECHANISM WAS LOCKED IN THE OPEN POSITION AND IN ORDER TO CLOSE THE DOOR THE CONSUMER HAD NO CHOICE BUT TO PUNCTURE THE ROOF. *NLM *CB *NLM
NHTSA ODI #10020004
Mileage unknown · Sep 25, 2002
Structure
NHTSA RECALL 99V213000 LIFTGATE SUPPORT BRACKET; SHE HAD THIS RECALL REPAIRED TWO YEARS AGO. THE OWNER STATES THAT SHE HEARD SOMETHING, MOVED OUT THE WAY AND THE LIFTGATE SLAMMED SHUT ON ITS' OWN. PLEASE DESCRIBE DETAILS. NLM
NHTSA ODI #8019401
Mileage unknown · Jun 13, 2002
StructureInjury
WHILE TRYING TO OPEN HATCH GATE UP STRUT THAT HOLDS HATCH GATE SHEARED OFF FRAME, AND GATE CAME DOWN ON CONSUMER, CAUSING SOME MINOR DAMAGES ON SHOULDER, ARM AND BACK.*AK *YH
NHTSA ODI #8011708
Mileage unknown · Feb 28, 2002
Structure
REAR DOOR IS FALLING APART FROM THE TOP HINGE WHERE IT COULD SEPARATE LIKE IT HAD HAPPEN BEFORE. DEALER HAD BEEN CONTACTED. PLEASE PROVIDE MORE INFORMATION.*AK
NHTSA ODI #8004784
Mileage unknown · Feb 28, 2002
Structure
SLIDING DOOR, HAD COLLAPSED WITHOUT A PRIOR WARNING. HAD TAKEN VEHICLE TO A BODY SHOP FOR REPAIRS, AND THEY COULD NOT DETERMINE WHAT HAD BEEN THE CAUSE OF SLIDING DOOR FALLING OUT. PLEASE PROVIDE MORE INFORMATION.*AK
NHTSA ODI #8004783
Mileage unknown · Feb 27, 2001
Structure
SLIDING DOOR WOULD INTERMITTENTLY FLY OPEN WHEN MAKING A TURN OR COMING TO A STOP. MANUFACTURER NOTIFIED AND INFORMED OF NO RECALL AND VEHICLE OUT OF ITS WARRANTY. *AK DOOR FLEW OPEN ON ONE OCCASION DURING AN ACCIDENT WHEN IMPACT WAS TO THE FRONT OF THE VEHICLE, THE DOOR POPPED OPEN. *SLC
NHTSA ODI #881637
Mileage unknown · Nov 2, 2000
Structure
THE REAR HINGE WHICH SUPPORTS THE SLIDING PASSENGER SIDE DOOR FAILED AND CAME OUT OF IT'S TRACK, CONSUMER WAS UNABLE TO KEEP THE SIDE DOOR CLOSED. NLM
NHTSA ODI #557425
Mileage unknown · Jul 18, 2000
Structure
DRIVER'S DOOR HAS A STRESS CRACK AT THE WELDS AND HINGES OF THE DOOR WHICH WON'T SHUT THE DOOR PROPERLY, WON'T SHUT TO THE 2ND LATCH. PLEASE PROVIDE FURTHER INFORMATION. *AK
VEHICLE DESCRIPTION: MINI VANS EQUIPPED WITH 2-SPOKE LUXURY WHEELS MANUFACTURED JULY 1992 THROUGH JUNE 1993; OR EQUIPPED WITH 4-SPOKE SPORT WHEELS MANUFACTURED FROM JULY 1992 THROUGH SEPTEMBER 1993. THE STEERING WHEEL ARMATURE STAMPING CAN CRACK AND SEPARATE FROM THE CENTER HUB ATTACHMENT TO THE STEERING COLUMN.
Consequence & remedy
Consequence: IF THE STEERING WHEEL SEPARATES FROM THE CENTER HUB ATTACHMENT TO THE STEERING COLUMN, LOSS OF CONTROL CAN OCCUR INCREASING THE RISK OF AN ACCIDENT.
Remedy: DEALERS WILL INSPECT THE STEERING WHEEL FOR CRACKS AND ANY WHEELS WITH CRACKS WILL BE REPLACED. ALL OTHER VEHICLES WILL HAVE A REINFORCEMENT PLATE INSTALLED TO PREVENT STEERING WHEEL SEPARATION IN THE EVENT CRACKING OCCURS.
VEHICLE DESCRIPTION: MINI VANS. THE BOLTS USED TO ATTACH THE STRUT TO THE BODY AND THE REAR LIFTGATE CAN ACCUMULATE FATIGUE DAMAGE IF THREE FACTORS COMBINE. IF THE BOLT IS LOOSE, THE GAS STRUT IS OVER-PRESSURIZED, AND THE FREQUENCY OF OPENING AND CLOSING CYCLES IS HIGHER THAN FOR THE AVERAGE CUSTOMER, THE BOLT CAN FAIL.
Consequence & remedy
Consequence: PERSONAL INJURY COULD OCCUR IF THE BOLTS BREAK ALLOWING THE LIFTGATE TO FALL SUDDENLY.
Remedy: DEALERS WILL INSPECT FOR LOOSE FASTENERS, IF THE FASTENERS ARE LOOSE, THE STRUT (AND INTEGRAL BOLTS) WILL BE REPLACED. IF THE BOLT SHOWS EVIDENCE OF TORQUE, THE BOLT WILL BE REMOVED, LARGER WASHERS WILL REPLACE THE EXISTING WASHER AND THE BOLT WILL BE REINSTALLED AND HAND TIGHTENED TO THE TARGET TORQUED.
VEHICLE DESCRIPTION: MINI VANS. THE WIRING THAT INITIATES THE DRIVER AND/OR PASSENGER AIR BAG COULD ELECTRICALLY SHORT CIRCUIT TO GROUND. A SHORT CIRCUIT TO GROUND THAT EXISTS IMMEDIATELY AFTER TURNING THE IGNITION KEY TO THE "ON" OR "START" POSITION CAN CAUSE THE AIR BAG(S) TO INADVERTENTLY DEPLOY.
Consequence & remedy
Consequence: INADVERTENT AIR BAG DEPLOYMENT CAN INJURE A FRONT SEAT OCCUPANT.
Remedy: DEALERS WILL PERFORM AN ELECTRONIC DIAGNOSTIC CHECK. ANY SHORT CIRCUITS IDENTIFIED IN EITHER THE DRIVER'S OR PASSENGER SIDE AIR BAG INITIATOR WIRE CIRCUIT WILL BE REPAIRED.
WHEELS WITH MISFORMED LUG NUT SEATS WERE INSTALLED ON THESE VEHICLES. THIS CAUSES REDUCED NUT TO WHEEL CONTACT AREA AND LIMITS THE WHEEL SELF-CENTERING CAPABILITY DURING INSTALLATION. THIS RESULTS IN LOSS OF WHEEL LUG NUT TORQUE RETENTION.
Consequence & remedy
Consequence: LOSS OF LUG NUT TORQUE RETENTION MAY LEAD TO WHEEL LUGFAILURE WHICH MAY CAUSE WHEEL SEPARATION AND AN ACCIDENT.
Remedy: INSPECT THE WHEEL ASSEMBLY PLANT CODE; REPLACE WHEELS KNOWN TO HAVE THE PROBLEM AND INSTALL NEW LUG NUTS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5
DP03002 · Steering Column Separation
Opened May 7, 2003 · Closed Jul 22, 2003
Status: closed (inferred from source dates) · Steering:column
MR. LARRY A. SACKEY SUBMITTED A PETITION TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) BY LETTER DATED APRIL 18, 2003, REQUESTING THAT NHTSAFURTHER INVESTIGATE THE DEFECTIVE COLLAPSIBLE STEERING SHAFT SYSTEM ON 1987-1995 VEHICLES MANUFACTURED BY THE DAIMLERCHRYSLER CORPORATION.IN PART BECAUSE OF 49 CFR ? 30120(G), NHTSA HAS DECIDED TO LIMIT THE SCOPE OF THE PETITION VEHICLES TO 1993-1995 MODELS, EXCLUDING THE 1993 JEEP GRAND CHEROKEE AND 1994-1995 DODGE RAM SERIES TRUCKS THAT WERE RECALLED (93V210 & 96V230) FOR STEERING COLUMN FAILURE.IF THE ANALYSIS OF THESE VEHICLES HAD IDENTIFIED A POTENTIAL PROBLEM, THE SCOPE COULD HAVE BEEN EXPANDED IN AN INVESTIGATION.A REVIEW OF ODI'S DATA BASE SHOWS NO RECENT COMPLAINTS AND A LACK OF A COMPLAINT TREND CONCERNING THE SUBJECT ISSUE ON THE SUBJECT VEHICLES AS A WHOLE OR BY INDIVIDUAL MODELS.THEREFORE, THE PETITION IS DENIED.FOR DETAILS, SEE FEDERAL REGISTER NOTICE VOLUME 68, NO. 130, JULY 8, 2003.
RQ00011 · Steering Wheel Separation
Opened May 1, 2000 · Closed Apr 1, 2002
Status: closed (inferred from source dates) · Steering
There is no summary currently available
Additional source detail variants (2)
Steering
There is no summary currently available
Steering
There is no summary currently available
PE97049 · Air Bag Circuit/windshield Wiper Motor
Opened Nov 18, 1997 · Closed Mar 17, 1998
Status: closed (inferred from source dates) · Visibility
There is no summary currently available
PE96008 · Safety Blt Latch Operation
Opened Jan 25, 1996 · Closed Jun 28, 1996
Status: closed (inferred from source dates) · Seat Belts
There is no summary currently available
EA94005 · Liftgate Latches
Opened Jan 31, 1994 · Closed Oct 25, 1995
Status: closed (inferred from source dates) · Structure
LIFTGATE LATCHES IN THE SUBJECT VEHICLES HAVE FAILED IN LOW AND MODERATE SPEED IMPACTS RESULTING IN OCCUPANT EJECTIONS, INJURIES, AND FATALITIES.THERE ARE TWO FAILURE MODES ASSOCIATED WITH LATCH FAILURE: FORK BOLT-DETENT LEVER BYPASS, AND INERTIAL UNLATCHING.NHTSA ANALYSES OF CHRYSLER AND PEER MINIVANS TOOK THE FORM OF STATIC AND DYNAMIC CRASH TESTING, ENGINEERING EVALUATIONS, COMPLAINT AND FIELD ANALYSES, AND REAL WORLD DATA ANALYSES.A TECHNICAL REPORT DISCUSSING THESE ANALYSES CAN BE FOUND IN THE ENGINEERING ANALYSIS TECHNICAL REPORT IN THE PUBLIC VIEWING FILE.CHRYSLER HAS ADVISED NHTSA THAT IT WILL CONDUCT A CAMPAIGN TO REPLACE THE LATCHES ON ALL THE SUBJECT VEHICLES.THE CHRYSLER CAMPAIGN WILL CONSIST OF NOTIFICATION LETTERS TO ALL OWNERS; FREE REPLACEMENT OF ALL LATCHES WITH STRONGER, SAFER LATCHES REGARDLESS OF THE AGE OF THE MINIVANS; NATIONAL ADVERTISING TO PROMOTE CUSTOMER AWARENESS OF THE CAMPAIGN; QUARTERLY REPORTS REGARDING CAMPAIGN COMPLETION RATES; AS WELL AS ADDITIONAL MEASURES TO ENSURE A HIGH COMPLETION RATE, ABOVE AND BEYOND THE ACTIONS THAT NORMALLY WOULD BE TAKEN IN A FORMAL SAFETY RECALL.THESE INCLUDE FOLLOW UP WRITTEN AND TELEPHONIC NOTIFICATIONS TO OWNERS WHO DO NOT BRING THEIR VEHICLES IN FOR CORRECTIVE ACTION.NHTSA FIRMLY BELIEVES THAT THE CRASH PERFORMANCE OF THE LATCHES ON THESE MINIVANS RAISES SERIOUS SAFETY CONCERNS, AND THAT THE CAMPAIGN ADDRESSES THESE CONCERNS.THE CHRYSLER CORRECTIVE ACTION WILL INCREASE THE STRENGTH OF THE LIFTGATE LATCHES AND DECREASE THE POTENTIAL FOR INERTIAL UNLATCHING, THEREBY REDUCING THE RISK OF CRASH-RELATED OPENINGS OF THE LIFTGATE AND POSSIBLE OCCUPANT EJECTION THROUGH THE LIFTGATE OPENING.OWNERS OF CHRYSLER MINIVANS WILL GET A STRONGER, SAFER LATCH FREE OF CHARGE AT THE EARLIEST POSSIBLE TIME, WITHOUT THE NEED FOR FURTHER TECHNICAL INVESTIGATION AND COMPLEX AND TIME-CONSUMING LITIGATION WITH AN UNCERTAIN OUTCOME.BASED ON THE ABOVE, ODI IS CLOSING THIS INVESTIGATION.
1994 Dodge Grand Caravan Problems, Complaints & Recalls | Skip That Year
Illustration