THIS COMPLAINT IS RELATED TO THE DODGE DURANGO FRONT SUSPENSION UPPER BALL JOINTS AND CONTROL ARMS WEARING OUT PREMATURELY. AT 28,433 MILES I EXPERIENCED FRONT SUSPENSION PROBLEMS. THE LOCAL CHRYSLER DEALERSHIP COULD NOT FIND ANYTHING WRONG. AT 38,801 MILES "THEY" WERE ABLE TO PINPOINT THE PROBLEM AND REPLACED THE FRONT AND R…
Read full complaint
THIS COMPLAINT IS RELATED TO THE DODGE DURANGO FRONT SUSPENSION UPPER BALL JOINTS AND CONTROL ARMS WEARING OUT PREMATURELY. AT 28,433 MILES I EXPERIENCED FRONT SUSPENSION PROBLEMS. THE LOCAL CHRYSLER DEALERSHIP COULD NOT FIND ANYTHING WRONG. AT 38,801 MILES "THEY" WERE ABLE TO PINPOINT THE PROBLEM AND REPLACED THE FRONT AND REAR SWAY BAR BUSHINGS AND INNER AND OUTER TIE RODS. AT 45,390 MILES THE PROBLEM REOCURRED AND THE TIE RODS, UPPER BALL JOINTS AND CONTROL ARMS WERE REPLACED AGAIN! AFTER READING THE RELATED ARTICLE ON YOUR WEBSITE, I WANTED TO EXPRESS MY CONCERN AND ENCOURAGE YOU TO FURTHER YOUR INVESTIGATION.*AK
NHTSA ODI #10029117
63,000 miles · Jul 23, 2003
Steering
STEERING MAKES POPPING NOISES WHEN TURNING RIGHT OR LEFT. STEERING HAS BEGUN TO FREEZE WHEN TURN TO THE RIGHT.MOSTLY OCCURS ON INTERSTATE ON/OFF RAMPS. *AK
NHTSA ODI #10029040
73,019 miles · Jul 22, 2003
Steering
VEHICLE'S STEERING GEAR AND IMMEDIATE SHAFT HAD TO BE REPLACED, DUE TO PART FAILURE , WHILE HAVING A ROUTINE INSPECTION DONE.
NHTSA ODI #10029788
Mileage unknown · Jul 22, 2003
SteeringCrashFire
POWER STEERING
NHTSA ODI #10028847
Mileage unknown · Jun 3, 2003
SteeringCrash
WHILE TRAVELING ABOUT 30MPH ON A SIDE STREET HIT A DIP IN THE STREET AND THE PASSENGER SIDE WHEEL ASSEMBLY FELL OFF INTO THE STREET. *AK
NHTSA ODI #10022232
75,000 miles · Apr 28, 2003
Steering
THE STEERING PUMP AND RACK FAILED WHILE DRIVING AT 35 MPH. WHICH MADE THE VEHICLE DIFFICULT TO STEER. *JB THE POWER STEERING PUMP WAS REMOVED AND REPLACED ALONG THE STEERING RACK. *SCC
NHTSA ODI #10017633
60,000 miles · Feb 25, 2003
SteeringSuspension
CONSUMER LOST ALL STEERING, THE VEHICLE WAS TOWED TO THE MECHANIC AND INDICATED THE FRONT TRACK BAR AND TIE ROD BROKE. *JB WHEN THE TIE RODS BROKE, THE LEFT THE FRONT WHEELS WERE WITHOUT THE ABILITY TO STEER AND WAS UNABLE TO SLOW OR STOP. THE ENTIRE RACK ASSEMBLY WAS REPLACED. SCC
NHTSA ODI #10009224
Mileage unknown · Jan 22, 2003
Steering
CONSUMER STATED THAT WHILE DRIVING AT ANY SPEED AND WITHOUT WARNING THE STEERING BOLTS ARE LOSE AND IT IS CAUSING STEERING WHEEL TO JUMP. DEALER NOTIFIED. TS
NHTSA ODI #10004366
Mileage unknown · Sep 16, 2002
Air BagsSteeringCrash
AT 55MPH CONSUMER LOST CONTROL OF VEHICLE, WENT INTO A DITCH, AND VEHICLE ROLLED OVER. UPON IMPACT, NONE OF THE AIRBAGS DEPLOYED. PLEASE PROVIDE ANY FURTHER INFORMATION.*AK
NHTSA ODI #8018685
Mileage unknown · Aug 13, 2002
Steering
STEERING WHEEL GRIP WORE DOWN, STEERING BECAME SLICK. DEALER REPLACED STEERING, AND 10,000 MILES LATER THE GRIP WORE DOWN AGAIN.*AK
ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS EQUIPPED WITH FOUR-WHEEL DRIVE (4X4), IF MOISTURE LEAKS INTO THE FRONT SUSPENSION UPPER BALL JOINT, EVACUATION OF THE LUBRICANT AND CORROSION OF THE JOINT MAY CAUSE THE JOINT TO WEAR OVER AN EXTENDED PERIOD OF TIME. THIS COULD CAUSE A CLUNKING NOISE IN THE FRONT SUSPENSION, WHICH MAY NOT ALWAYS BE HEARD BY THE VEHICLE OCCUPANTS.
Consequence & remedy
Consequence: EXCESSIVE WEAR IN THE UPPER BALL JOINT MAY ALLOW IT TO SEPARATE, WHICH COULD RESULT IN LOSS OF CONTROL OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS. THIS SAFETY IMPROVEMENT CAMPAIGN BEGAN ON DECEMBER 21, 2004. OWNERS CAN CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
VEHICLE DESCRIPTION: PICKUP TRUCKS. SOUND DEADENER MATERIAL INSIDE THE STEERING WHEEL COULD BECOME DETACHED FROM THE COVER AND HOUSING. NOTE: THE RAM PICKUP TRUCKS WERE BUILT AT THE WARREN ASSEMBLY PLANT ("S" IN THE 11TH VIN POSITION) FROM MAY 16, 2000 THROUGH OCTOBER 23, 2000; ST. LOUIS NORTH ASSEMBLY PLANT ("J" IN THE 11TH VIN POSITION) FROM MAY 19, 2000 THROUGH OCTOBER 23, 2000; LAGO ALBERTO ASSEMBLY PLANT ("M" IN THE 11TH VIN POSITION) FROM MAY 23, 2000 THROUGH OCTOBER 23, 2000; AND SALTILLO ASSEMBLY PLANT ("G" IN THE 11TH VIN POSITION) FROM MAY 23, 2000 THROUGH OCTOBER 23, 2000. IMPORTANT: VEHICLES THAT HAVE ALREADY HAD THE PROPER CLOCKSPRING INSTALLED, ACCORDING TO WARRANTY RECORDS, HAVE BEEN EXCLUDED FROM THIS RECALL. IN ADDITION, 1997-2000 MODEL YEAR VEHICLES THAT HAVE HAD A SUSPECT REPLACEMENT CLOCKSPRING INSTALLED, ACCORDING TO WARRANTY RECORDS, HAVE BEEN ADDED TO THIS RECALL.
Consequence & remedy
Consequence: WHEN THIS OCCURS, THE MATERIAL COULD INTERFERE WITH THE CLOCKSPRING RIBBON AND CAUSE AN OPEN CIRCUIT. THE DRIVER AIR BAG SYSTEM WILL BECOME DISABLED, AND THE AIR BAG WARNING LAMP WILL ILLUMINATE ON THE INSTRUMENT PANEL.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY. OWNER NOTIFICATION BEGAN JUNE 18, 2001. ALSO SOME 1997-200 MODEL YEAR VEHICLES THAT, ACCORDING TO WARRANTY RECORDS, HAVE HAD A SUSPECT REPLACEMENT CLOCKSPRING INSTALLED, WILL ALSO BE INCLUDED IN THIS CAMPAIGN. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (5)
Suspension
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm:upper Arm
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm:upper Ball Joint
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
IN JULY 2003, ODI OPENED PE03-032 BASED ON 4 CONSUMER COMPLAINTS ALLEGING SEPARATION OF AN UPPER BALL JOINT.COMPLAINTS ALLEGED AN UNEXPECTED COLLAPSE IN THE FRONT END AND IN SOME OCCASIONS THE BALL JOINT SEPARATION IS ALLEGED TO HAVE RESULTED IN THE WHEEL, BRAKE ROTOR, AND STEERING KNUCKLE SEPARATING FROM THE VEHICLE.SINCE OPENING THE PE, ODI HAS RECEIVED 23 ADDITIONAL COMPLAINTS RELATED TO BALL JOINT SEPARATION. DAIMLERCHRYSLER HAS IDENTIFIED A WEAROUT CONCERN IN THE SUBJECT BALL JOINTS THAT IS BELIEVED TO OCCUR AFTER WATER INTRUSION EVACUATES THE JOINT LUBRICANT.DAIMLERCHRYSLER DOES NOT BELIEVE THE CONDITION POSES AN UNREASONABLE RISK TO SAFETY BECAUSE THE SUSPENSION DESIGN IN THE SUBJECT VEHICLES SIGNIFICANTLY REDUCES THE LIKELIHOOD OF JOINT SEPARATION.OVER 99 PERCENT OF THE FAILURES ARE RELATED TO WORN BALL JOINTS (E.G., NOISE COMPLAINTS).DAIMLERCHRYSLER REVISED THE REPAIR PROCEDURE IN AUGUST 2003 TO ALLOW THE UPPER BALL JOINTS TO BE SERVICED SEPARATELY FROM THE UPPER CONTROL ARM AND REDUCE REPAIR COSTS. DAIMLERCHRYSLER CHANGED THE SUPPLIER OF THE SUBJECT BALL JOINTS FROM TRW TO NEW CASTLE MACHINING & FORGE FOR MY 2000 VEHICLES.MY 2000 DURANGO VEHICLES ACCOUNT FOR 25 OF THE 37 SEPARATION COMPLAINTS.THE UPPER BALL JOINT WAS REDESIGNED IN MY 2003.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN MY 2000-02 DURANGO VEHICLES.
Additional source detail variants (4)
Suspension:front
IN JULY 2003, ODI OPENED PE03-032 BASED ON 4 CONSUMER COMPLAINTS ALLEGING SEPARATION OF AN UPPER BALL JOINT.COMPLAINTS ALLEGED AN UNEXPECTED COLLAPSE IN THE FRONT END AND IN SOME OCCASIONS THE BALL JOINT SEPARATION IS ALLEGED TO HAVE RESULTED IN THE WHEEL, BRAKE ROTOR, AND STEERING KNUCKLE SEPARATING FROM THE VEHICLE.SINCE OPENING THE PE, ODI HAS RECEIVED 23 ADDITIONAL COMPLAINTS RELATED TO BALL JOINT SEPARATION. DAIMLERCHRYSLER HAS IDENTIFIED A WEAROUT CONCERN IN THE SUBJECT BALL JOINTS THAT IS BELIEVED TO OCCUR AFTER WATER INTRUSION EVACUATES THE JOINT LUBRICANT.DAIMLERCHRYSLER DOES NOT BELIEVE THE CONDITION POSES AN UNREASONABLE RISK TO SAFETY BECAUSE THE SUSPENSION DESIGN IN THE SUBJECT VEHICLES SIGNIFICANTLY REDUCES THE LIKELIHOOD OF JOINT SEPARATION.OVER 99 PERCENT OF THE FAILURES ARE RELATED TO WORN BALL JOINTS (E.G., NOISE COMPLAINTS).DAIMLERCHRYSLER REVISED THE REPAIR PROCEDURE IN AUGUST 2003 TO ALLOW THE UPPER BALL JOINTS TO BE SERVICED SEPARATELY FROM THE UPPER CONTROL ARM AND REDUCE REPAIR COSTS. DAIMLERCHRYSLER CHANGED THE SUPPLIER OF THE SUBJECT BALL JOINTS FROM TRW TO NEW CASTLE MACHINING & FORGE FOR MY 2000 VEHICLES.MY 2000 DURANGO VEHICLES ACCOUNT FOR 25 OF THE 37 SEPARATION COMPLAINTS.THE UPPER BALL JOINT WAS REDESIGNED IN MY 2003.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN MY 2000-02 DURANGO VEHICLES.
Suspension:front:control Arm
IN JULY 2003, ODI OPENED PE03-032 BASED ON 4 CONSUMER COMPLAINTS ALLEGING SEPARATION OF AN UPPER BALL JOINT.COMPLAINTS ALLEGED AN UNEXPECTED COLLAPSE IN THE FRONT END AND IN SOME OCCASIONS THE BALL JOINT SEPARATION IS ALLEGED TO HAVE RESULTED IN THE WHEEL, BRAKE ROTOR, AND STEERING KNUCKLE SEPARATING FROM THE VEHICLE.SINCE OPENING THE PE, ODI HAS RECEIVED 23 ADDITIONAL COMPLAINTS RELATED TO BALL JOINT SEPARATION. DAIMLERCHRYSLER HAS IDENTIFIED A WEAROUT CONCERN IN THE SUBJECT BALL JOINTS THAT IS BELIEVED TO OCCUR AFTER WATER INTRUSION EVACUATES THE JOINT LUBRICANT.DAIMLERCHRYSLER DOES NOT BELIEVE THE CONDITION POSES AN UNREASONABLE RISK TO SAFETY BECAUSE THE SUSPENSION DESIGN IN THE SUBJECT VEHICLES SIGNIFICANTLY REDUCES THE LIKELIHOOD OF JOINT SEPARATION.OVER 99 PERCENT OF THE FAILURES ARE RELATED TO WORN BALL JOINTS (E.G., NOISE COMPLAINTS).DAIMLERCHRYSLER REVISED THE REPAIR PROCEDURE IN AUGUST 2003 TO ALLOW THE UPPER BALL JOINTS TO BE SERVICED SEPARATELY FROM THE UPPER CONTROL ARM AND REDUCE REPAIR COSTS. DAIMLERCHRYSLER CHANGED THE SUPPLIER OF THE SUBJECT BALL JOINTS FROM TRW TO NEW CASTLE MACHINING & FORGE FOR MY 2000 VEHICLES.MY 2000 DURANGO VEHICLES ACCOUNT FOR 25 OF THE 37 SEPARATION COMPLAINTS.THE UPPER BALL JOINT WAS REDESIGNED IN MY 2003.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN MY 2000-02 DURANGO VEHICLES.
Suspension:front:control Arm:upper Arm
IN JULY 2003, ODI OPENED PE03-032 BASED ON 4 CONSUMER COMPLAINTS ALLEGING SEPARATION OF AN UPPER BALL JOINT.COMPLAINTS ALLEGED AN UNEXPECTED COLLAPSE IN THE FRONT END AND IN SOME OCCASIONS THE BALL JOINT SEPARATION IS ALLEGED TO HAVE RESULTED IN THE WHEEL, BRAKE ROTOR, AND STEERING KNUCKLE SEPARATING FROM THE VEHICLE.SINCE OPENING THE PE, ODI HAS RECEIVED 23 ADDITIONAL COMPLAINTS RELATED TO BALL JOINT SEPARATION. DAIMLERCHRYSLER HAS IDENTIFIED A WEAROUT CONCERN IN THE SUBJECT BALL JOINTS THAT IS BELIEVED TO OCCUR AFTER WATER INTRUSION EVACUATES THE JOINT LUBRICANT.DAIMLERCHRYSLER DOES NOT BELIEVE THE CONDITION POSES AN UNREASONABLE RISK TO SAFETY BECAUSE THE SUSPENSION DESIGN IN THE SUBJECT VEHICLES SIGNIFICANTLY REDUCES THE LIKELIHOOD OF JOINT SEPARATION.OVER 99 PERCENT OF THE FAILURES ARE RELATED TO WORN BALL JOINTS (E.G., NOISE COMPLAINTS).DAIMLERCHRYSLER REVISED THE REPAIR PROCEDURE IN AUGUST 2003 TO ALLOW THE UPPER BALL JOINTS TO BE SERVICED SEPARATELY FROM THE UPPER CONTROL ARM AND REDUCE REPAIR COSTS. DAIMLERCHRYSLER CHANGED THE SUPPLIER OF THE SUBJECT BALL JOINTS FROM TRW TO NEW CASTLE MACHINING & FORGE FOR MY 2000 VEHICLES.MY 2000 DURANGO VEHICLES ACCOUNT FOR 25 OF THE 37 SEPARATION COMPLAINTS.THE UPPER BALL JOINT WAS REDESIGNED IN MY 2003.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN MY 2000-02 DURANGO VEHICLES.
Suspension:front:control Arm:upper Ball Joint
IN JULY 2003, ODI OPENED PE03-032 BASED ON 4 CONSUMER COMPLAINTS ALLEGING SEPARATION OF AN UPPER BALL JOINT.COMPLAINTS ALLEGED AN UNEXPECTED COLLAPSE IN THE FRONT END AND IN SOME OCCASIONS THE BALL JOINT SEPARATION IS ALLEGED TO HAVE RESULTED IN THE WHEEL, BRAKE ROTOR, AND STEERING KNUCKLE SEPARATING FROM THE VEHICLE.SINCE OPENING THE PE, ODI HAS RECEIVED 23 ADDITIONAL COMPLAINTS RELATED TO BALL JOINT SEPARATION. DAIMLERCHRYSLER HAS IDENTIFIED A WEAROUT CONCERN IN THE SUBJECT BALL JOINTS THAT IS BELIEVED TO OCCUR AFTER WATER INTRUSION EVACUATES THE JOINT LUBRICANT.DAIMLERCHRYSLER DOES NOT BELIEVE THE CONDITION POSES AN UNREASONABLE RISK TO SAFETY BECAUSE THE SUSPENSION DESIGN IN THE SUBJECT VEHICLES SIGNIFICANTLY REDUCES THE LIKELIHOOD OF JOINT SEPARATION.OVER 99 PERCENT OF THE FAILURES ARE RELATED TO WORN BALL JOINTS (E.G., NOISE COMPLAINTS).DAIMLERCHRYSLER REVISED THE REPAIR PROCEDURE IN AUGUST 2003 TO ALLOW THE UPPER BALL JOINTS TO BE SERVICED SEPARATELY FROM THE UPPER CONTROL ARM AND REDUCE REPAIR COSTS. DAIMLERCHRYSLER CHANGED THE SUPPLIER OF THE SUBJECT BALL JOINTS FROM TRW TO NEW CASTLE MACHINING & FORGE FOR MY 2000 VEHICLES.MY 2000 DURANGO VEHICLES ACCOUNT FOR 25 OF THE 37 SEPARATION COMPLAINTS.THE UPPER BALL JOINT WAS REDESIGNED IN MY 2003.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN MY 2000-02 DURANGO VEHICLES.
PE02082 · Safety Belt Cinching Latch Plate
Opened Nov 6, 2002 · Closed Apr 23, 2003
Status: closed (inferred from source dates) · Seat Belts
THERE ARE NO INJURIES OR FATALITIES ASSOCIATED WITH THIS ALLEGED DEFECT.WHILE CONDUCTING THIS INVESTIGATION, ODI FOUND THAT THE SUBJECT CINCHES MEET THE LOAD BEARING REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD 208, AND THAT MANY OF THE REPORTED FAILURES WERE DUE TO INCORRECT CHILD SAFETY SEAT INSTALLATIONS. ADDITIONALLY, THE REPORT RATE IS LOW (1.60/100K).THE INFORMATION AVAILABLE FAILS TO ESTABLISH THE EXISTENCE OF A DEFECT TREND AT THIS TIME.FURTHER ALLOCATION OF AGENCY RESOURCES TO THIS ISSUE IS UNWARRANTED AND THE PRELIMINARY EVALUATION IS BEING CLOSED.
PE99074 · Steering Wheel/shaft Spline Attachment
Opened Dec 13, 1999 · Closed Feb 24, 2000
Status: closed (inferred from source dates) · Steering
THIS PE WAS OPENED BASED ON ODI'S RECEIPT OF ONE COMPLAINT OF STEERING WHEEL SEPARATION ON THE SUBJECT VEHICLES.ALLEGEDLY (THAT IS, ACCORDING TO THE REPAIRING FACILITY'S SERVICE MANAGER) THE HUB NUT WAS NEVER INSTALLED ON THE SHAFT SPLINE.ALTHOUGH THE DRIVER LOST CONTROL OF THE VEHICLE, HE/SHE WAS ABLE TO STOP WITHOUT IMPACTING ANYTHING.BASED ON OUR INVESTIGATION AND THE MANUFACTURER'S RESPONSE, ODI IS CLOSING THIS INVESTIGATION BECAUSE THE SINGLE KNOWN COMPLAINT APPEARS TO BE AN ISOLATED INCIDENT.FURTHER, CHRYSLER HAS NO OTHER WARRANTY CLAIMS AND HAS NOT ISSUED ANY SERVICE BULLETINS.IN SUMMARY, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.ODI WILL CONTTINUE TO MONITOR THIS MATTER CLOSELY, AND THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION ON THESE MODELS IF WARRANTED BY THE CIRCUMSTANCES.
2000 Dodge Durango Problems, Complaints & Recalls | Skip That Year
Illustration