NHTSA owner reports · September 18, 2026 snapshot.
Steering complaints
83 reportsClear category filter55 miles · Jan 9, 2006
SteeringStructureSuspensionCrashInjury
SEPTEMBER 13, 2001 MY HUSBAND CURTIS JOYNER WAS KILLED IN A CRASH IN HERNANDO, MS DUE TO POOR WHEEL BASE STRUCTURE AND POOR WHEEL BALANCE STRUCTURE OF DURANGO'S OF HANDLING CURVES, WAS STATED BY ACCIDENT RECONSTRUCTING CREW THAT'S WHAT CAUSED THE VEHICLE TO ROLLOVER IN CURVES. I HIRED ATTORNEY MCGRAW OF OLIVEBRANCH, MS; WHO LATE…
Read full complaint
SEPTEMBER 13, 2001 MY HUSBAND CURTIS JOYNER WAS KILLED IN A CRASH IN HERNANDO, MS DUE TO POOR WHEEL BASE STRUCTURE AND POOR WHEEL BALANCE STRUCTURE OF DURANGO'S OF HANDLING CURVES, WAS STATED BY ACCIDENT RECONSTRUCTING CREW THAT'S WHAT CAUSED THE VEHICLE TO ROLLOVER IN CURVES. I HIRED ATTORNEY MCGRAW OF OLIVEBRANCH, MS; WHO LATER STATED HE DID NOT HAVE THE TIME TO PUT INTO THIS MATTER, BUT WAS CERTAINLY A GOOD CASE. I EMAILED DATELINE REGARDING THIS MATTER ALSO. I SAY ONE NIGHT ON THEIR SHOW WHERE THEY SHOWED HOW THE DURANGO'S DID NOT PASS THE CRASH IN CURVES OR ON THE ROAD. *NM
NHTSA ODI #10147301
Mileage unknown · May 31, 2005
Steering
POWER STEERING SUDDENLY WENT OUT. YESTERDAY AFTERNOON I HAD MY 95 YR OLD MOTHER, 2 YR OLD GRANDSON, SON AND SISTER UP ON GRIZZLY PEAK IN BERKELY AND THE POWER STEERING WITHOUT PRIOR SIGNS JUST ALL OF A SUDDEN DID NOT FUNCTION. I CALLED CHRYSLER 24 HR HELP AND THEY SEND A FLAT BED TOLL TRUCK. MY 2000 DURANGO WITH 44,300 MILES WA…
Read full complaint
POWER STEERING SUDDENLY WENT OUT. YESTERDAY AFTERNOON I HAD MY 95 YR OLD MOTHER, 2 YR OLD GRANDSON, SON AND SISTER UP ON GRIZZLY PEAK IN BERKELY AND THE POWER STEERING WITHOUT PRIOR SIGNS JUST ALL OF A SUDDEN DID NOT FUNCTION. I CALLED CHRYSLER 24 HR HELP AND THEY SEND A FLAT BED TOLL TRUCK. MY 2000 DURANGO WITH 44,300 MILES WAS TOWED TO CONNELL CHRYSLER JEEP DODGE IN OAKLAND.
NHTSA ODI #10122472
65,155 miles · Apr 9, 2005
SteeringSuspension
BALL JOINTS WORE OUT LEADING TO STRESS AND SUBSEQUENT BREAK OF TIE ROD, BALL JOINTS WERE REPLACED DUE TO RECALL, TIE ROD REPAIRED AT OWNERS EXPENSE, WAS TOLD ONE DID NOT RELATE TO THE OTHER . *AK
NHTSA ODI #10116675
16,227 miles · Apr 6, 2005
Steering
CONSUMER COMPLAINED ABOUT ONGOING PROBLEMS WITH INTERMITTENT /MOMENTARY POWER STEERING LOSS WHILE DRIVING. THE POWER STEERING PUMP WAS REPLACED FOUR TIMES WITHIN 16,227 MILES. MECHANIC WAS UNABLE TO LOCATE THE PROBLEM. MANUFACTURER WAS NOT NOTIFIED AT THIS TIME.*AK
NHTSA ODI #10117497
Mileage unknown · Feb 15, 2005
SteeringSuspension
CONSUMER STATED THAT THE BALL JOINT PROBLEM HAS DAMAGED ALL FOUR TIE RODS. THE FRONT END ALIGNMENT IS COMPLETELY OFF. ALSO, WAS TOLD BY THE DEALER THAT RACK AND PINION AND CONTROL ARM HAD TO BE REPLACED. CONSUMER IS INCLUDED IN THE RECALL 04V596000 CONCERNING LOWER BALL JOINT WEAR. *AK
NHTSA ODI #10111517
78,000 miles · Jan 6, 2005
SteeringSuspension
WHILE GETTING AN OIL CHANGE MECHANIC INFORMED THE CONSUMER THAT BOTH LOWER BALL JOINTS AND THE TIE ROD NEEDED TO BE REPLACED. *AK
NHTSA ODI #10106912
27,000 miles · Dec 10, 2004
Air BagsLatches/locks/linkagesPower Train
WINDING SOUND IN STEERING WHEN TUNING WHEEL,HORIBLE SOUND WHILE TURNING WHEELS AND BACKING UP,DOOR LOCKS ARE IN LOCKED POSITION (CAN'T OPEN TO GET OUT OF CAR AND LOUD SOUND GOING OFF WHEN DOOR LOCKS ARE SUPPOSED TO SELF LOCK AT 25 MPH)BOUGHT CAR IN 2001, AFTER 6 MO TOOK CAR TO DEARERSHIP TO REPORT PROBLEMS WHILE STILL UNDER WARR…
Read full complaint
WINDING SOUND IN STEERING WHEN TUNING WHEEL,HORIBLE SOUND WHILE TURNING WHEELS AND BACKING UP,DOOR LOCKS ARE IN LOCKED POSITION (CAN'T OPEN TO GET OUT OF CAR AND LOUD SOUND GOING OFF WHEN DOOR LOCKS ARE SUPPOSED TO SELF LOCK AT 25 MPH)BOUGHT CAR IN 2001, AFTER 6 MO TOOK CAR TO DEARERSHIP TO REPORT PROBLEMS WHILE STILL UNDER WARRANTY AND THEY SAID NOTHING WAS WRONG. STILL HAVE PAPERWORK TO SHOW OF THE COMPLAINTS.I HAVE 3 SMALL GRANDCHILDREN I TAKE CARE OF AND TRANSPORT IN THE VEHICLE. HOPE YOU PEOPLE DO SOMETHING ABOUT THIS BEFORE SOMEONE DIES OR YOU WILL REALLY BE OUT OF POCKET. I HAVE LESS THAT 60,000 MILES ON SUV SO THIS CAN'T BE DUE TO WEAR AND TEAR. ( I MARKED OEM YES IF THAT PERTAINS TO ORIGINAL PARTS ON SUV). *AK
NHTSA ODI #10102598
Mileage unknown · Nov 9, 2004
Power TrainSteeringSuspension
AFTER TWO WEEKS OF PURCHASING OUR (2 YEARS OLD @ THAT TIME)DURANGO, AS WE WERE DRIVING WE HEARD A LOUD SCREACHING NOISE, WE FOUND A PIECE THAT APPEARANTLY BROKE OFF, IT HAD TO DO WITH THE BRAKES WE WERE TOLD. LATER OUR TRANSMISSION WASNT FUNCTIONING PROPERLY, IT NEEDED NEW SENSOR. WHEN STEERING IT SCREACHES (HAD PROBLEM RIGHT …
Read full complaint
AFTER TWO WEEKS OF PURCHASING OUR (2 YEARS OLD @ THAT TIME)DURANGO, AS WE WERE DRIVING WE HEARD A LOUD SCREACHING NOISE, WE FOUND A PIECE THAT APPEARANTLY BROKE OFF, IT HAD TO DO WITH THE BRAKES WE WERE TOLD. LATER OUR TRANSMISSION WASNT FUNCTIONING PROPERLY, IT NEEDED NEW SENSOR. WHEN STEERING IT SCREACHES (HAD PROBLEM RIGHT AFTER PURCHASING) AND ITS BEEN GETTING WORSE, WE TOOK IT TO DEALER AND THEY FLUSHED POWER STEERING FLUID AND WE ALSO HAD TO HAVE RIGHT BALL JOINT REPLACED AT THE SAME TIME. WHEN STEERING IT STILL SOUNDS BAD. WE HAD TO REPLACE THE BATTERY A YEAR AFTER PURCHASING ONE AT THE DEALERSHIP AND A MONTH AFTER THAT OUR TRANSMISSION WENT OUT. DEALER WANTED TO CHARGE $3700.00. WE TOOK IT SOMEWHERE ELSE, HOPE TO PICK UP TODAY FROM SHOP WILL BE PAYING $2570.00. *AK
NHTSA ODI #10098506
6,000 miles · Nov 2, 2004
Power TrainSteeringSuspension
SINCE DAY ONE THIS VEHICLE HAS BEEN IN AND OUT OF DEALERSHIP, FROM TRANSMISSON PROBLEMS, STEERING , NOISES. I STOPPED BRINGING IN TRUCK AT 30,000 MILES WHEN MY WARRANTY EXPIRED, AND KNOW I JUST HAVE LIVE WITH IT.*AK
NHTSA ODI #10098139
48,300 miles · Oct 27, 2004
Steering
WHEN TURINING MY 2000 DODGE DURANGO I HEARD A POPING NOISE, MY MECHANIC TOLD ME ON 10/27/04 MY BALL JOINTS WERE BAD AND THAT THE WHOLE STERRING RACK NEEDED TO BE REPLACED. I CALLED THE LOCAL DEALER AND WAS TOLD IT IS NOT COVERED UNDER WARRANTY, I THEN CALLED DODGE THEY ADVISED THE SAME. I LOOKED ON THE INTERNET AND HAVE FOUND NU…
Read full complaint
WHEN TURINING MY 2000 DODGE DURANGO I HEARD A POPING NOISE, MY MECHANIC TOLD ME ON 10/27/04 MY BALL JOINTS WERE BAD AND THAT THE WHOLE STERRING RACK NEEDED TO BE REPLACED. I CALLED THE LOCAL DEALER AND WAS TOLD IT IS NOT COVERED UNDER WARRANTY, I THEN CALLED DODGE THEY ADVISED THE SAME. I LOOKED ON THE INTERNET AND HAVE FOUND NUMEROUS COMPLAINTS TO CONSUMER AFFAIRS. THE REPAIR WILL COST $1200.00, THIS VEHICLE HAS ONLY 48,000 MILES. FROM WHAT I HAVE READ AND THE CBS NEWS REPORT IT SEEMS THAT DODGE SHOULD HAVE A RECALL FOR THIS PROBLEM BEFORE PEOPLE START GETTING KILLED.*AK
NHTSA ODI #10096499
Official recalls
2Dec 21, 2004
ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS EQUIPPED WITH FOUR-WHEEL DRIVE (4X4), IF MOISTURE LEAKS INTO THE FRONT SUSPENSION UPPER BALL JOINT, EVACUATION OF THE LUBRICANT AND CORROSION OF THE JOINT MAY CAUSE THE JOINT TO WEAR OVER AN EXTENDED PERIOD OF TIME. THIS COULD CAUSE A CLUNKING NOISE IN THE FRONT SUSPENSION, WHICH MAY NOT ALWAYS BE HEARD BY THE VEHICLE OCCUPANTS.
Consequence & remedy
Consequence: EXCESSIVE WEAR IN THE UPPER BALL JOINT MAY ALLOW IT TO SEPARATE, WHICH COULD RESULT IN LOSS OF CONTROL OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS. THIS SAFETY IMPROVEMENT CAMPAIGN BEGAN ON DECEMBER 21, 2004. OWNERS CAN CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
May 8, 2001
VEHICLE DESCRIPTION: PICKUP TRUCKS. SOUND DEADENER MATERIAL INSIDE THE STEERING WHEEL COULD BECOME DETACHED FROM THE COVER AND HOUSING. NOTE: THE RAM PICKUP TRUCKS WERE BUILT AT THE WARREN ASSEMBLY PLANT ("S" IN THE 11TH VIN POSITION) FROM MAY 16, 2000 THROUGH OCTOBER 23, 2000; ST. LOUIS NORTH ASSEMBLY PLANT ("J" IN THE 11TH VIN POSITION) FROM MAY 19, 2000 THROUGH OCTOBER 23, 2000; LAGO ALBERTO ASSEMBLY PLANT ("M" IN THE 11TH VIN POSITION) FROM MAY 23, 2000 THROUGH OCTOBER 23, 2000; AND SALTILLO ASSEMBLY PLANT ("G" IN THE 11TH VIN POSITION) FROM MAY 23, 2000 THROUGH OCTOBER 23, 2000. IMPORTANT: VEHICLES THAT HAVE ALREADY HAD THE PROPER CLOCKSPRING INSTALLED, ACCORDING TO WARRANTY RECORDS, HAVE BEEN EXCLUDED FROM THIS RECALL. IN ADDITION, 1997-2000 MODEL YEAR VEHICLES THAT HAVE HAD A SUSPECT REPLACEMENT CLOCKSPRING INSTALLED, ACCORDING TO WARRANTY RECORDS, HAVE BEEN ADDED TO THIS RECALL.
Consequence & remedy
Consequence: WHEN THIS OCCURS, THE MATERIAL COULD INTERFERE WITH THE CLOCKSPRING RIBBON AND CAUSE AN OPEN CIRCUIT. THE DRIVER AIR BAG SYSTEM WILL BECOME DISABLED, AND THE AIR BAG WARNING LAMP WILL ILLUMINATE ON THE INSTRUMENT PANEL.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY. OWNER NOTIFICATION BEGAN JUNE 18, 2001. ALSO SOME 1997-200 MODEL YEAR VEHICLES THAT, ACCORDING TO WARRANTY RECORDS, HAVE HAD A SUSPECT REPLACEMENT CLOCKSPRING INSTALLED, WILL ALSO BE INCLUDED IN THIS CAMPAIGN. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4EA03023 · Upper Ball Joint Separation
Opened Nov 19, 2003 · Closed Feb 11, 2005
Status: closed (inferred from source dates) · Suspension; Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:upper Arm; Suspension:front:control Arm:upper Ball Joint
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (5)
Suspension
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm:upper Arm
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm:upper Ball Joint
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE03032 · Front Susp. Upper Ball Joint Failure
Opened Jul 16, 2003 · Closed Nov 19, 2003
Status: closed (inferred from source dates) · Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:upper Arm; Suspension:front:control Arm:upper Ball Joint
IN JULY 2003, ODI OPENED PE03-032 BASED ON 4 CONSUMER COMPLAINTS ALLEGING SEPARATION OF AN UPPER BALL JOINT.COMPLAINTS ALLEGED AN UNEXPECTED COLLAPSE IN THE FRONT END AND IN SOME OCCASIONS THE BALL JOINT SEPARATION IS ALLEGED TO HAVE RESULTED IN THE WHEEL, BRAKE ROTOR, AND STEERING KNUCKLE SEPARATING FROM THE VEHICLE.SINCE OPENING THE PE, ODI HAS RECEIVED 23 ADDITIONAL COMPLAINTS RELATED TO BALL JOINT SEPARATION. DAIMLERCHRYSLER HAS IDENTIFIED A WEAROUT CONCERN IN THE SUBJECT BALL JOINTS THAT IS BELIEVED TO OCCUR AFTER WATER INTRUSION EVACUATES THE JOINT LUBRICANT.DAIMLERCHRYSLER DOES NOT BELIEVE THE CONDITION POSES AN UNREASONABLE RISK TO SAFETY BECAUSE THE SUSPENSION DESIGN IN THE SUBJECT VEHICLES SIGNIFICANTLY REDUCES THE LIKELIHOOD OF JOINT SEPARATION.OVER 99 PERCENT OF THE FAILURES ARE RELATED TO WORN BALL JOINTS (E.G., NOISE COMPLAINTS).DAIMLERCHRYSLER REVISED THE REPAIR PROCEDURE IN AUGUST 2003 TO ALLOW THE UPPER BALL JOINTS TO BE SERVICED SEPARATELY FROM THE UPPER CONTROL ARM AND REDUCE REPAIR COSTS. DAIMLERCHRYSLER CHANGED THE SUPPLIER OF THE SUBJECT BALL JOINTS FROM TRW TO NEW CASTLE MACHINING & FORGE FOR MY 2000 VEHICLES.MY 2000 DURANGO VEHICLES ACCOUNT FOR 25 OF THE 37 SEPARATION COMPLAINTS.THE UPPER BALL JOINT WAS REDESIGNED IN MY 2003.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN MY 2000-02 DURANGO VEHICLES.
Additional source detail variants (4)
Suspension:front
IN JULY 2003, ODI OPENED PE03-032 BASED ON 4 CONSUMER COMPLAINTS ALLEGING SEPARATION OF AN UPPER BALL JOINT.COMPLAINTS ALLEGED AN UNEXPECTED COLLAPSE IN THE FRONT END AND IN SOME OCCASIONS THE BALL JOINT SEPARATION IS ALLEGED TO HAVE RESULTED IN THE WHEEL, BRAKE ROTOR, AND STEERING KNUCKLE SEPARATING FROM THE VEHICLE.SINCE OPENING THE PE, ODI HAS RECEIVED 23 ADDITIONAL COMPLAINTS RELATED TO BALL JOINT SEPARATION. DAIMLERCHRYSLER HAS IDENTIFIED A WEAROUT CONCERN IN THE SUBJECT BALL JOINTS THAT IS BELIEVED TO OCCUR AFTER WATER INTRUSION EVACUATES THE JOINT LUBRICANT.DAIMLERCHRYSLER DOES NOT BELIEVE THE CONDITION POSES AN UNREASONABLE RISK TO SAFETY BECAUSE THE SUSPENSION DESIGN IN THE SUBJECT VEHICLES SIGNIFICANTLY REDUCES THE LIKELIHOOD OF JOINT SEPARATION.OVER 99 PERCENT OF THE FAILURES ARE RELATED TO WORN BALL JOINTS (E.G., NOISE COMPLAINTS).DAIMLERCHRYSLER REVISED THE REPAIR PROCEDURE IN AUGUST 2003 TO ALLOW THE UPPER BALL JOINTS TO BE SERVICED SEPARATELY FROM THE UPPER CONTROL ARM AND REDUCE REPAIR COSTS. DAIMLERCHRYSLER CHANGED THE SUPPLIER OF THE SUBJECT BALL JOINTS FROM TRW TO NEW CASTLE MACHINING & FORGE FOR MY 2000 VEHICLES.MY 2000 DURANGO VEHICLES ACCOUNT FOR 25 OF THE 37 SEPARATION COMPLAINTS.THE UPPER BALL JOINT WAS REDESIGNED IN MY 2003.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN MY 2000-02 DURANGO VEHICLES.
Suspension:front:control Arm
IN JULY 2003, ODI OPENED PE03-032 BASED ON 4 CONSUMER COMPLAINTS ALLEGING SEPARATION OF AN UPPER BALL JOINT.COMPLAINTS ALLEGED AN UNEXPECTED COLLAPSE IN THE FRONT END AND IN SOME OCCASIONS THE BALL JOINT SEPARATION IS ALLEGED TO HAVE RESULTED IN THE WHEEL, BRAKE ROTOR, AND STEERING KNUCKLE SEPARATING FROM THE VEHICLE.SINCE OPENING THE PE, ODI HAS RECEIVED 23 ADDITIONAL COMPLAINTS RELATED TO BALL JOINT SEPARATION. DAIMLERCHRYSLER HAS IDENTIFIED A WEAROUT CONCERN IN THE SUBJECT BALL JOINTS THAT IS BELIEVED TO OCCUR AFTER WATER INTRUSION EVACUATES THE JOINT LUBRICANT.DAIMLERCHRYSLER DOES NOT BELIEVE THE CONDITION POSES AN UNREASONABLE RISK TO SAFETY BECAUSE THE SUSPENSION DESIGN IN THE SUBJECT VEHICLES SIGNIFICANTLY REDUCES THE LIKELIHOOD OF JOINT SEPARATION.OVER 99 PERCENT OF THE FAILURES ARE RELATED TO WORN BALL JOINTS (E.G., NOISE COMPLAINTS).DAIMLERCHRYSLER REVISED THE REPAIR PROCEDURE IN AUGUST 2003 TO ALLOW THE UPPER BALL JOINTS TO BE SERVICED SEPARATELY FROM THE UPPER CONTROL ARM AND REDUCE REPAIR COSTS. DAIMLERCHRYSLER CHANGED THE SUPPLIER OF THE SUBJECT BALL JOINTS FROM TRW TO NEW CASTLE MACHINING & FORGE FOR MY 2000 VEHICLES.MY 2000 DURANGO VEHICLES ACCOUNT FOR 25 OF THE 37 SEPARATION COMPLAINTS.THE UPPER BALL JOINT WAS REDESIGNED IN MY 2003.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN MY 2000-02 DURANGO VEHICLES.
Suspension:front:control Arm:upper Arm
IN JULY 2003, ODI OPENED PE03-032 BASED ON 4 CONSUMER COMPLAINTS ALLEGING SEPARATION OF AN UPPER BALL JOINT.COMPLAINTS ALLEGED AN UNEXPECTED COLLAPSE IN THE FRONT END AND IN SOME OCCASIONS THE BALL JOINT SEPARATION IS ALLEGED TO HAVE RESULTED IN THE WHEEL, BRAKE ROTOR, AND STEERING KNUCKLE SEPARATING FROM THE VEHICLE.SINCE OPENING THE PE, ODI HAS RECEIVED 23 ADDITIONAL COMPLAINTS RELATED TO BALL JOINT SEPARATION. DAIMLERCHRYSLER HAS IDENTIFIED A WEAROUT CONCERN IN THE SUBJECT BALL JOINTS THAT IS BELIEVED TO OCCUR AFTER WATER INTRUSION EVACUATES THE JOINT LUBRICANT.DAIMLERCHRYSLER DOES NOT BELIEVE THE CONDITION POSES AN UNREASONABLE RISK TO SAFETY BECAUSE THE SUSPENSION DESIGN IN THE SUBJECT VEHICLES SIGNIFICANTLY REDUCES THE LIKELIHOOD OF JOINT SEPARATION.OVER 99 PERCENT OF THE FAILURES ARE RELATED TO WORN BALL JOINTS (E.G., NOISE COMPLAINTS).DAIMLERCHRYSLER REVISED THE REPAIR PROCEDURE IN AUGUST 2003 TO ALLOW THE UPPER BALL JOINTS TO BE SERVICED SEPARATELY FROM THE UPPER CONTROL ARM AND REDUCE REPAIR COSTS. DAIMLERCHRYSLER CHANGED THE SUPPLIER OF THE SUBJECT BALL JOINTS FROM TRW TO NEW CASTLE MACHINING & FORGE FOR MY 2000 VEHICLES.MY 2000 DURANGO VEHICLES ACCOUNT FOR 25 OF THE 37 SEPARATION COMPLAINTS.THE UPPER BALL JOINT WAS REDESIGNED IN MY 2003.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN MY 2000-02 DURANGO VEHICLES.
Suspension:front:control Arm:upper Ball Joint
IN JULY 2003, ODI OPENED PE03-032 BASED ON 4 CONSUMER COMPLAINTS ALLEGING SEPARATION OF AN UPPER BALL JOINT.COMPLAINTS ALLEGED AN UNEXPECTED COLLAPSE IN THE FRONT END AND IN SOME OCCASIONS THE BALL JOINT SEPARATION IS ALLEGED TO HAVE RESULTED IN THE WHEEL, BRAKE ROTOR, AND STEERING KNUCKLE SEPARATING FROM THE VEHICLE.SINCE OPENING THE PE, ODI HAS RECEIVED 23 ADDITIONAL COMPLAINTS RELATED TO BALL JOINT SEPARATION. DAIMLERCHRYSLER HAS IDENTIFIED A WEAROUT CONCERN IN THE SUBJECT BALL JOINTS THAT IS BELIEVED TO OCCUR AFTER WATER INTRUSION EVACUATES THE JOINT LUBRICANT.DAIMLERCHRYSLER DOES NOT BELIEVE THE CONDITION POSES AN UNREASONABLE RISK TO SAFETY BECAUSE THE SUSPENSION DESIGN IN THE SUBJECT VEHICLES SIGNIFICANTLY REDUCES THE LIKELIHOOD OF JOINT SEPARATION.OVER 99 PERCENT OF THE FAILURES ARE RELATED TO WORN BALL JOINTS (E.G., NOISE COMPLAINTS).DAIMLERCHRYSLER REVISED THE REPAIR PROCEDURE IN AUGUST 2003 TO ALLOW THE UPPER BALL JOINTS TO BE SERVICED SEPARATELY FROM THE UPPER CONTROL ARM AND REDUCE REPAIR COSTS. DAIMLERCHRYSLER CHANGED THE SUPPLIER OF THE SUBJECT BALL JOINTS FROM TRW TO NEW CASTLE MACHINING & FORGE FOR MY 2000 VEHICLES.MY 2000 DURANGO VEHICLES ACCOUNT FOR 25 OF THE 37 SEPARATION COMPLAINTS.THE UPPER BALL JOINT WAS REDESIGNED IN MY 2003.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN MY 2000-02 DURANGO VEHICLES.
PE02082 · Safety Belt Cinching Latch Plate
Opened Nov 6, 2002 · Closed Apr 23, 2003
Status: closed (inferred from source dates) · Seat Belts
THERE ARE NO INJURIES OR FATALITIES ASSOCIATED WITH THIS ALLEGED DEFECT.WHILE CONDUCTING THIS INVESTIGATION, ODI FOUND THAT THE SUBJECT CINCHES MEET THE LOAD BEARING REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD 208, AND THAT MANY OF THE REPORTED FAILURES WERE DUE TO INCORRECT CHILD SAFETY SEAT INSTALLATIONS. ADDITIONALLY, THE REPORT RATE IS LOW (1.60/100K).THE INFORMATION AVAILABLE FAILS TO ESTABLISH THE EXISTENCE OF A DEFECT TREND AT THIS TIME.FURTHER ALLOCATION OF AGENCY RESOURCES TO THIS ISSUE IS UNWARRANTED AND THE PRELIMINARY EVALUATION IS BEING CLOSED.
PE99074 · Steering Wheel/shaft Spline Attachment
Opened Dec 13, 1999 · Closed Feb 24, 2000
Status: closed (inferred from source dates) · Steering
THIS PE WAS OPENED BASED ON ODI'S RECEIPT OF ONE COMPLAINT OF STEERING WHEEL SEPARATION ON THE SUBJECT VEHICLES.ALLEGEDLY (THAT IS, ACCORDING TO THE REPAIRING FACILITY'S SERVICE MANAGER) THE HUB NUT WAS NEVER INSTALLED ON THE SHAFT SPLINE.ALTHOUGH THE DRIVER LOST CONTROL OF THE VEHICLE, HE/SHE WAS ABLE TO STOP WITHOUT IMPACTING ANYTHING.BASED ON OUR INVESTIGATION AND THE MANUFACTURER'S RESPONSE, ODI IS CLOSING THIS INVESTIGATION BECAUSE THE SINGLE KNOWN COMPLAINT APPEARS TO BE AN ISOLATED INCIDENT.FURTHER, CHRYSLER HAS NO OTHER WARRANTY CLAIMS AND HAS NOT ISSUED ANY SERVICE BULLETINS.IN SUMMARY, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.ODI WILL CONTTINUE TO MONITOR THIS MATTER CLOSELY, AND THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION ON THESE MODELS IF WARRANTED BY THE CIRCUMSTANCES.
Illustration