IllustrationPARKED IN MY DRIVEWAY, I STARTED THE CAR REVERSED OUT OF THE DRIVE WAY AND THE GEAR SHIFTER IS NOW STUCK IN REVERSE, ALL I CAN DO IS APPLY MY EMERGENCY BRAKE BECAUSE I CAN'T SHIFT THE GEAR UP OR DOWN THEREFORE I CAN'T REMOVE MY IGNITION KEY EITHER. HAD TO HAVE IT TOWED TO DEALER
2014 Dodge Dart
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Dart years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
790–25K
6725–50K
5250–75K
3575–100K
22100–150K
5150K+
260 reports with mileage · 110 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 132 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 103 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 74 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
20 crash reports7 fire reports7 injury reports
Power Train complaints
132 reportsTHE MOTOR HAS HAD AN OIL LEAK THAT STARTED AT 3000 MILES AND THEY HAVE NOT BEEN ABLE TO RESOLVE. I AM WORRIED THAT THIS MIGHT LEAD TO AN ENINE FIRE. I HAVE HAD IT AT THE DEALER SEVERAL TIMES FOR THIS PROBLEM AND IT KEEPS HAPPENING. WITH THE POWERTRAIN THE VEHICLE WILL NOT MOVE THEN SURGES FORWARD. THIS STARTED AROUND THE …
Read full complaint
THE MOTOR HAS HAD AN OIL LEAK THAT STARTED AT 3000 MILES AND THEY HAVE NOT BEEN ABLE TO RESOLVE. I AM WORRIED THAT THIS MIGHT LEAD TO AN ENINE FIRE. I HAVE HAD IT AT THE DEALER SEVERAL TIMES FOR THIS PROBLEM AND IT KEEPS HAPPENING. WITH THE POWERTRAIN THE VEHICLE WILL NOT MOVE THEN SURGES FORWARD. THIS STARTED AROUND THE 5000 MILE MARK AND CONTINUES TO HAPPEN. IT ACTS LIKE THE CLUTCH SLIPS BUT I HAVE HAD IT IN THE SHOP SEVERAL TIMES AND EVERY TIME I AM TOLD NOTHING IS WRONG. THIS ISSUE IS DANGEROUS WHEN SITTING IN TRAFFICE OR TAKING OFF FROM A DEAD STOP BECAUE THE CAR DOES NOT WANT TO MOVE AT FIRST AND THEN WHEN IT DOES LUNGE FORWARD IT IS NOT CONTROLABLE HOW FAR IT WILL ACTUALL GO.
LOUD HUMMING FROM THE FRONT WHEEL WHILE MAKING A LONG TURN ON THE HIGHWAY TO THE RIGHT. BROUGHT IT INTO THE DEALER OF PURCHASE, THEY FOUND OUT IT WAS THE REAR WHEEL BEARING, A DAY LATER I'M STILL EXPERIENCING THE SAME ISSUES WITH IMPROVED SOUND REDUCTION FROM THE REAR, SO THE REAR WAS FIXED NOW I'M HAVING THE FRONT WHEEL BEARING…
Read full complaint
LOUD HUMMING FROM THE FRONT WHEEL WHILE MAKING A LONG TURN ON THE HIGHWAY TO THE RIGHT. BROUGHT IT INTO THE DEALER OF PURCHASE, THEY FOUND OUT IT WAS THE REAR WHEEL BEARING, A DAY LATER I'M STILL EXPERIENCING THE SAME ISSUES WITH IMPROVED SOUND REDUCTION FROM THE REAR, SO THE REAR WAS FIXED NOW I'M HAVING THE FRONT WHEEL BEARING REPLACED.
TRANSMISSION OVERHEATING
I WOULD LIKE TO VOICE MY OPINION ON A SAFETY ISSUE INVOLVING THESE CARS WITH THE 2.4 LITER ENGINE. THESE CARS ARE USING OIL, WAY FASTER THAN THEY SHOULD. THE CARS STALL OUT LOSING ALL POWER AND STEERING IF THE OIL BECOMES TOO LOW. THERE ISN'T ANY INDICATOR LIGHT THAT YOU ARE LOW OR ANY SIGN UNTIL IT HAPPENS. CURRENTLY MY CAR…
Read full complaint
I WOULD LIKE TO VOICE MY OPINION ON A SAFETY ISSUE INVOLVING THESE CARS WITH THE 2.4 LITER ENGINE. THESE CARS ARE USING OIL, WAY FASTER THAN THEY SHOULD. THE CARS STALL OUT LOSING ALL POWER AND STEERING IF THE OIL BECOMES TOO LOW. THERE ISN'T ANY INDICATOR LIGHT THAT YOU ARE LOW OR ANY SIGN UNTIL IT HAPPENS. CURRENTLY MY CAR IS USING JUST SHY OF A QUART OF OIL EVERY 1K MILES AND THIS IS ACCEPTABLE IN DODGE'S EYES. THEY ADVERTISE THESE CARS TO GO 6-8K MILES BETWEEN OIL CHANGES - NO MORE THAN 10K MILES! WELL, AT 5.5 QT CAPACITY... YOU WILL ALWAYS RUN OUT PLUS SOME BEFORE A CHANGE IS DUE! I HAVE SEEN MANY PEOPLE COMMENTING ABOUT THEIR VEHICLE STALLING OUT ON HIGHWAYS, ETC WITHOUT ANY WARNING. MAJORITY OF PEOPLE I'M SURE ARE NOT THINKING TO CHECK THEIR OIL ON THEIR NEW CAR WITH EVERY GAS FILL UP TO BE SURE THE LEVEL IS OK. THIS IS TOTALLY UNACCEPTABLE! THESE CARS USE THE 0W20 SYNTHETIC OIL AND IT AVERAGES ABOUT $9 A QT. THIS IS DOUBLING THE COST OF OIL CHANGES SINCE YOU NEED TO FILL IT UP SEVERAL TIMES IN BETWEEN. PLUS WHERE IS THIS OIL GOING? MINE HAS RECENTLY STARTED SPUTTERING AND WILL BE TAKING IT BACK TO THE SHOP .. AGAIN.. HAVE A FEELING THIS OIL IS POOLING SOMEWHERE AND NOW CAUSING A CLOG IN SOMETHING! *TR
TAKATA RECALL , WHEN I GOT THE CAR FORM THE DEALERSHIP TILL NOW I PUT A BIT OVER SEVEN THOUSAND MILES ON A VERY NEW 2014 DODGE DART GT BESIDES THE OCCASIONAL CLUTCH GETTING STUCK WHEN I ENGAGED IT FORCING ME TO HAVE TO PICK IT UP WITH MY TOE I HAD NO PROBLEMS WITH THE CAR NO STALLING OR ROUGH SHIFTS UNTIL LAST NIGHT WHEN I LOS…
Read full complaint
TAKATA RECALL , WHEN I GOT THE CAR FORM THE DEALERSHIP TILL NOW I PUT A BIT OVER SEVEN THOUSAND MILES ON A VERY NEW 2014 DODGE DART GT BESIDES THE OCCASIONAL CLUTCH GETTING STUCK WHEN I ENGAGED IT FORCING ME TO HAVE TO PICK IT UP WITH MY TOE I HAD NO PROBLEMS WITH THE CAR NO STALLING OR ROUGH SHIFTS UNTIL LAST NIGHT WHEN I LOST ALL CONTROL WHILE ON THE HIGHWAY CAUSING ME TO HAVE TO QUICKLY SWERVE OF THE ROAD OR BE HIT BY THE VEHICLE BEHIND ME . ENGINE WHICH STILL RUN AND CAN ACCELERATE THE CAR WILL NOT MORE IN ANY GEAR 1-6 OR EVEN REVERSE AND EVEN THOUGH THIS IS A CONSTANT PROBLEM ON LOTS ODD DODGE DARTS THAT HAVE BEEN RECALLED THEY SAID MY VIN DOESN'T FALL UNDER THERE RECALL DATES. *TR
TAKATA RECALL THIS 2014 DODGE DART AERO HAS NOW HAD MULTIPLE PROBLEMS WITH THE CLUTCH AND AXLES. IT IS CURRENTLY IN THE SHOP TO HAVE THE SLAVE CYLINDER FOR THE CLUTCH AS WELL AS THE AXLES FIXED FOR THE SECOND TIME IN 2 YEARS. THEY ARE ALSO IN THE PROCESS OF CHECKING IN TO WHY THE CHECK ENGINE LIGHT CAME ON FOR THE MASS AIR FL…
Read full complaint
TAKATA RECALL THIS 2014 DODGE DART AERO HAS NOW HAD MULTIPLE PROBLEMS WITH THE CLUTCH AND AXLES. IT IS CURRENTLY IN THE SHOP TO HAVE THE SLAVE CYLINDER FOR THE CLUTCH AS WELL AS THE AXLES FIXED FOR THE SECOND TIME IN 2 YEARS. THEY ARE ALSO IN THE PROCESS OF CHECKING IN TO WHY THE CHECK ENGINE LIGHT CAME ON FOR THE MASS AIR FLOW SENSOR. THIS MAKES 2 TIMES THAT IT HAS GONE TO THE SHOP FOR CLUTCH AND AXLE ISSUES. THEY ALSO DON'T KNOW WHAT THE REAL PROBLEM IS FOR THE CHECK ENGINE LIGHT. I HAVE ASKED THEM TO BUY THE CAR BACK AND THEY WONT. THEY ALSO STATED THAT I MAY BE HAVING TO PAY SOME OUT OF POCKET TO GET MY CAR FIXED THIS TIME. THIS CAR IS NOTHING BUT PROBLEMS. LIKE I MENTIONED BEFORE; TWICE FOR THE CLUTCH AND AXLES, THE ENGINE LIGHT IS ON FOR A REASON THEY DON'T KNOW OTHER THAT THEY THINK IT IS THE MASS AIR FLOW SENSOR, THE THIRD TIME I TOOK IT TO DODGE FOR AN OIL CHANGE THEY TOLD ME THAT NO OIL CAME OUT OF THE ENGINE AND THEN TRIED TO EXPLAIN TO ME THAT MY ENGINE WAS "KNOWN" TO DO THAT. NOW I HAVE JUST GOTTEN OFF THE PHONE WITH THE MANUFACTURER CUSTOMER SERVICE AND THEY REPLIED WITH THEY WILL COVER ALL THE COSTS EXCEPT FOR $100. SEEMS KIND OF ODD TO SETTLE ON THAT AMOUNT. PLUS THEY WONT BUY IT BACK. THEREFORE, THIS CAR IS KNOWN TO HAVE CLUTCH AND ENGINE PROBLEMS AND DODGE EXPECTS ME TO DRIVE AROUND NOT HAVING TO WORRY ABOUT IF MY LIFE IS AT RISK. I SHOULD ALSO MENTION THAT THE TIRES THAT CAME ON THE CAR WERE FAULTY AS WELL AS I HAD TO REPLACE TWO OF THEM ALREADY. THE BANDS ON THE INSIDE OF THE TIRE CAME LOOSE AND CAUSED PROBLEMS WITH THE DRIVING AS WELL. THIS IS JUNKER CAR THAT I PURCHASED NEW AND DODGE COULD CARE LESS THAT IT IS FALLING APART.
WHILE DRIVING MY 2014 DODGE DART, THE CLUTCH DROPPED COMPLETELY TO THE FLOOR BOARD IN BETWEEN SHIFTING FROM SECOND TO THIRD GEAR MAKING SHIFTING IMPOSSIBLE, WHILE I WAS DRIVING UP A 2 LANE HILL IN MY NEIGHBORHOOD. THERE WAS NO SHOULDER TO PULL OVER TO AT THE MOMENT THE CLUTCH DROPPED, CAUSING ME TO HAVE TO REACH DOWN AND GRAB IT…
Read full complaint
WHILE DRIVING MY 2014 DODGE DART, THE CLUTCH DROPPED COMPLETELY TO THE FLOOR BOARD IN BETWEEN SHIFTING FROM SECOND TO THIRD GEAR MAKING SHIFTING IMPOSSIBLE, WHILE I WAS DRIVING UP A 2 LANE HILL IN MY NEIGHBORHOOD. THERE WAS NO SHOULDER TO PULL OVER TO AT THE MOMENT THE CLUTCH DROPPED, CAUSING ME TO HAVE TO REACH DOWN AND GRAB IT WITH MY LEFT HAND. I WAS UNABLE TO RE ENGAGE THE CLUTCH, THUS STAYED IN SECOND GEAR UNTIL I REACHED THE TOP OF THE HILL WHERE A SHOULDER BECAME AVAILABLE. I GENTLY USED THE BRAKE TO SLOW THE CAR DOWN WHILE IN THE SHOULDER UNTIL THE CARE STALLED OUT. AFTER SITTING IN THE CARE FOR SEVERAL MINUTES I TRIED TO START MY CAR BUT WAS UNABLE TO BECAUSE OF THE CLUTCH RESTING ON THE FLOOR BOARD, I WAS ABLE TO PULL IT UP WITH MY HAND AND UPON RELEASE IT WOULD FALL BACK TO THE FLOOR BOARD. AFTER SEVERAL MORE MINUTES THE CLUTCH SEEMED TO CORRECT ITSELF, LETTING ME STAT MY CAR AND RESUME MY TRIP HOME, APPROXIMATELY 1 MILE FURTHER. WHILE CONTINUING MY TRIP, THE CLUTCH SEEMED TO LOOSE "PRESSURE" AND HAD TO PRESS THE CLUTCH COMPLETELY TO THE FLOOR BOARD IN ORDER TO SHIFT. THIS IS THE SECOND TIME THIS ISSUE HAS COM UP, THE FIRST TIME BEING REPAIRED IN JULY 2015.
I BOUGHT A BRAND NEW 2014 DODGE DART AERO AND ABOUT 3 WEEKS AFTER PURCHASING MY CAR STALLED AND SHUT OFF, THE TRANSMISSION LIGHT CAME ON. I TOOK IT TO DODGE AND THEY SAID THEY DID NOT HAVE A CODE BUT THEY SAW AN ISSUE WITH MY ANTI-LOCK BRAKE SYSTEM. A PART TO MY TRANSMISSION WAS RECALLED, WE WAITING FOR OVER 3 MONTHS FOR THE PAR…
Read full complaint
I BOUGHT A BRAND NEW 2014 DODGE DART AERO AND ABOUT 3 WEEKS AFTER PURCHASING MY CAR STALLED AND SHUT OFF, THE TRANSMISSION LIGHT CAME ON. I TOOK IT TO DODGE AND THEY SAID THEY DID NOT HAVE A CODE BUT THEY SAW AN ISSUE WITH MY ANTI-LOCK BRAKE SYSTEM. A PART TO MY TRANSMISSION WAS RECALLED, WE WAITING FOR OVER 3 MONTHS FOR THE PART AND UPON BRINGING MY CAR TO THE DEALERSHIP THEY REPORTED MY CAR NOT STARTING. ABOUT 3 WEEKS AFTER MY TRANSMISSION RECALL WAS "FIXED" MY ENGINE STARTING SMOKING UPON STARTING THE CAR AT LEAST 5 TIMES AND MY ENGINE WAS COMPLETELY REPLACED, THEY AGAIN REPORTED MY CAR WOULD NOT CRANK. MY CAR WAS IN THE SHOP FOR 27 DAYS, TWO DAYS AFTER PICKING MY CAR UP IT WAS BROUGHT BACK TO THE DEALOR FOR THE CAR FEELING LIKE THE TRANSMISSION WAS SLIPPING AT VARIOUS SPEEDS. IT'S BEEN ALMOST 2 WEIEKS WITH NO UPDATE. DODGE RESOLUTIONS HAS SENT AN INSPECTOR. INITIALLY THE CAR WAS PURCHASED WITH ABOUT 220 MILES ON IT, THE CAR IS ONLY AT 17,000 NOW.
AFTER DRIVING THE VEHICLE FOR MORE THAN 15 OR 20 MINUTES, WHEN ACCELERATING FROM A STOP THE VEHICLE SHIFTS ERRATICALLY CAUSING THE VEHICLE TO JOLT AND OCCASIONALLY STALL. IT FEELS AS IF THE VEHICLE IS TRYING TO DOWNSHIFT BEFORE RETURNING TO THE APPROPRIATE GEAR. PROCEEDING FORWARD OR TURNING MAKES NO DIFFERENCE. I CONTACTED T…
Read full complaint
AFTER DRIVING THE VEHICLE FOR MORE THAN 15 OR 20 MINUTES, WHEN ACCELERATING FROM A STOP THE VEHICLE SHIFTS ERRATICALLY CAUSING THE VEHICLE TO JOLT AND OCCASIONALLY STALL. IT FEELS AS IF THE VEHICLE IS TRYING TO DOWNSHIFT BEFORE RETURNING TO THE APPROPRIATE GEAR. PROCEEDING FORWARD OR TURNING MAKES NO DIFFERENCE. I CONTACTED THE DEALER ABOUT THIS OVER A YEAR AGO AND WAS TOLD THE OIL NEEDED TO BE CHANGED. I CONTACTED THE DEALER AGAIN THIS WEEK AFTER SEEING THAT THE VEHICLE WAS POTENTIALLY PART OF A NATIONAL RECALL BUT WAS TOLD I COULD BRING THE VEHICLE IN TO SERVICE BUT IT WAS NOT PART OF THE RECALL (THE MAKE, MODEL AND DATE OF MANUFACTURE MATCH THE RECALL DATA BUT SINCE THE VIN ISN'T SPECIFICALLY LISTED AS BEING RECALLED ON THE SAFECAR.GOV WEB SITE IT WAS NOT COVERED). THIS HAS BEEN OCCURRING SINCE APPROXIMATELY 6 MONTHS AFTER PURCHASING THE VEHICLE AND CONTINUES UNTIL THIS DAY.
Official recalls
425V674000 · Power Train:automatic Transmission:lever And Linkage:floor Shift
Oct 9, 2025
Chrysler (FCA US LLC) is recalling certain 2013-2016 Dodge Dart vehicles. The shifter cable may detach from the transmission, preventing the vehicle from shifting into the park (P) position and causing a loss of park function.
Consequence & remedy
Consequence: A loss of park function may allow the vehicle to rollaway, increasing the risk of a crash.
Remedy: Vehicles that were previously repaired under recall 19V293 will need to have the new remedy completed. The remedy is currently under development. Interim notification letters, explaining the safety risk, were mailed November 6, 2025. A second notice will be sent once the final remedy is available. Owners may contact Chrysler customer service at 800-853-1403. Chrysler's number for this recall is A0C. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning October 16, 2025.
19V293000 · Power Train:automatic Transmission; Power Train:automatic Transmission:lever And Linkage:floor Shift
Apr 11, 2019
Chrysler (FCA US LLC) is recalling certain 2013-2016 Dodge Dart vehicles equipped with 6-speed automatic transmissions. The shifter cable bushing may fail allowing the shift cable to detach from the transmission.
Consequence & remedy
Consequence: If the shifter cable detaches from the transmission, the vehicle may not perform the shifts performed by the driver. Additionally, despite selecting PARK with the shifter, the vehicle may roll away. These scenarios may increase the risk of a crash.
Remedy: This recall will be replaced by NHTSA recall number 25V674. Vehicles already repaired under this recall will need to have the new remedy completed. Chrysler will notify owners, and dealers will replace the transmission side shifter cable bushing, free of charge. The recall began September 5, 2019. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is V34.
Additional source detail variants (2)
Power Train:automatic Transmission:lever And Linkage:floor Shift
Chrysler (FCA US LLC) is recalling certain 2013-2016 Dodge Dart vehicles equipped with 6-speed automatic transmissions. The shifter cable bushing may fail allowing the shift cable to detach from the transmission.
Consequence: If the shifter cable detaches from the transmission, the vehicle may not perform the shifts performed by the driver. Additionally, despite selecting PARK with the shifter, the vehicle may roll away. These scenarios may increase the risk of a crash.
Remedy: This recall will be replaced by NHTSA recall number 25V674. Vehicles already repaired under this recall will need to have the new remedy completed. Chrysler will notify owners, and dealers will replace the transmission side shifter cable bushing, free of charge. The recall began September 5, 2019. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is V34.
Power Train:automatic Transmission
Chrysler (FCA US LLC) is recalling certain 2013-2016 Dodge Dart vehicles equipped with 6-speed automatic transmissions. The shifter cable bushing may fail allowing the shift cable to detach from the transmission.
Consequence: If the shifter cable detaches from the transmission, the vehicle may not perform the shifts performed by the driver. Additionally, despite selecting PARK with the shifter, the vehicle may roll away. These scenarios may increase the risk of a crash.
Remedy: This recall will be replaced by NHTSA recall number 25V674. Vehicles already repaired under this recall will need to have the new remedy completed. Chrysler will notify owners, and dealers will replace the transmission side shifter cable bushing, free of charge. The recall began September 5, 2019. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is V34.
15V800000 · Service Brakes, Hydraulic:power Assist:vacuum
Nov 25, 2015
Chrysler Group LLC (Chrysler) is recalling certain model year 2013-2014 Dodge Dart vehicles manufactured February 27, 2012 to January 23, 2014 and equipped with either a 2.0L or 2.4L engine. In affected vehicles, engine oil from the vacuum pump may seep into the brake booster, damaging a component within the brake booster.
Consequence & remedy
Consequence: Internal damage to brake booster could result in a loss of brake assist, lengthening the distance needed to stop the vehicle and increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will inspect the brake booster grommet for the presence of oil. If no oil is found, the vacuum tube assembly will be replaced. If oil is found, the vacuum pump, vacuum tube assembly, brake booster and master cylinder will be replaced. The recall began on May 9, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R63.
15V542000 · Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
Aug 25, 2015
Chrysler (FCA US LLC) is recalling certain model year 2013-2015 Dodge Dart vehicles manufactured February 24, 2012, to June 16, 2015. The affected vehicles may experience failure of the transmission control module (TCM), causing the transmission to unexpectedly shift into neutral.
Consequence & remedy
Consequence: If the transmission shifts into neutral, it can cause loss of motive power, increasing the risk of a vehicle crash.
Remedy: Chrysler will notify owners, and dealers will replace the TCM and bracket, free of charge. Chrysler issued an interim notification to owners on October 14, 2015. The recall began on January 15, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R42.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2RQ25002 · Recall 19V-293 Post Remedy Failures
Opened Jun 30, 2025 · Closed Dec 12, 2025
Status: closed (inferred from source dates) · Power Train:automatic Transmission:lever And Linkage:floor Shift; Power Train:shift Linkage/cable/rod; Power Train:shift Linkage/cable/rod:retaining Fasteners/hardware
On June 30, 2025, the Office of Defects Investigations (ODI) opened RQ25002 to investigate and review the effectiveness of Recall 19V-293. This recall was intended to address deterioration and detachment of shifter cable bushings by replacing them with an improved bushing that is less susceptible to deterioration from chemicals, oils, and solvents in MY2013-2016 Dodge Dart vehicles equipped with automatic transmissions and manufactured by Fiat Chrysler Automotive US LLC (FCA US). If the shifter cable becomes detached from the transmission, the transmission gear position may not match the driver’s intended gear selection. This mismatch could result in unintended vehicle movement or rollaway when the driver believes the transmission is in PARK, increasing the risk of a crash and/or injury. ODI has received sixty-three (63) Vehicle Owner Questionnaires (VOQ) alleging worn or misadjusted shifter cables and/or shifter cable detachments in subject vehicles that had already received the remedy for Recall 19V-293. Complainants reported incidents of bushing deterioration and detachment, resulting in gear-selection mismatch despite the prior recall repair, raising concerns regarding the effectiveness and durability of the implemented remedy and the adequacy of the recall. ODI’s investigation sought to determine whether the remedy used in recall 19V-293 adequately addressed the cause of the failure and whether other vehicles using the same bushing design might be affected. In response, FCA US and Dura Automotive Systems Inc. (Dura) determined that the repair for Recall 19V-293 did not sufficiently address the issue, and therefore, a safety defect exists in the subject vehicle population. As a result, FCA US and Dura initiated the following recall actions: · Recall 25V-674 (FCA US) is intended to address MY 2013–2016 Dodge Dart vehicles repaired under 19V-293 or otherwise equipped with suspect service parts. Remedy is under development. · Recall 25E-065 (Dura) is intended to address the defect at the equipment level by recalling affected gearshift control cable assemblies distributed as service components. Remedy is under development. The recalls initiated by FCA US (25V-674), and Dura Automotive Systems Inc. (25E-065) were received prior to ODI sending an Information Request (IR) letter to FCA. These two recalls seem to resolve the concerns that prompted investigation RQ25002 by replacing the previously recalled and service-supplied shifter cable assembly with an improved design, currently under development. The vehicle scope concern identified in this query was addressed by the new recalls including all Model Year 2013–2016 Dodge Dart vehicles produced and equipped with the affected shifter cable assembly. Accordingly, ODI is closing Investigation RQ25002. The agency will continue to monitor field performance and recall completion data to evaluate the effectiveness of the new remedy. ODI reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (6)
Power Train:automatic Transmission:lever And Linkage:floor Shift
On June 30, 2025, the Office of Defects Investigations (ODI) opened RQ25002 to investigate and review the effectiveness of Recall 19V-293. This recall was intended to address deterioration and detachment of shifter cable bushings by replacing them with an improved bushing that is less susceptible to deterioration from chemicals, oils, and solvents in MY2013-2016 Dodge Dart vehicles equipped with automatic transmissions and manufactured by Fiat Chrysler Automotive US LLC (FCA US). If the shifter cable becomes detached from the transmission, the transmission gear position may not match the driver’s intended gear selection. This mismatch could result in unintended vehicle movement or rollaway when the driver believes the transmission is in PARK, increasing the risk of a crash and/or injury. ODI has received sixty-three (63) Vehicle Owner Questionnaires (VOQ) alleging worn or misadjusted shifter cables and/or shifter cable detachments in subject vehicles that had already received the remedy for Recall 19V-293. Complainants reported incidents of bushing deterioration and detachment, resulting in gear-selection mismatch despite the prior recall repair, raising concerns regarding the effectiveness and durability of the implemented remedy and the adequacy of the recall. ODI’s investigation sought to determine whether the remedy used in recall 19V-293 adequately addressed the cause of the failure and whether other vehicles using the same bushing design might be affected. In response, FCA US and Dura Automotive Systems Inc. (Dura) determined that the repair for Recall 19V-293 did not sufficiently address the issue, and therefore, a safety defect exists in the subject vehicle population. As a result, FCA US and Dura initiated the following recall actions: · Recall 25V-674 (FCA US) is intended to address MY 2013–2016 Dodge Dart vehicles repaired under 19V-293 or otherwise equipped with suspect service parts. Remedy is under development. · Recall 25E-065 (Dura) is intended to address the defect at the equipment level by recalling affected gearshift control cable assemblies distributed as service components. Remedy is under development. The recalls initiated by FCA US (25V-674), and Dura Automotive Systems Inc. (25E-065) were received prior to ODI sending an Information Request (IR) letter to FCA. These two recalls seem to resolve the concerns that prompted investigation RQ25002 by replacing the previously recalled and service-supplied shifter cable assembly with an improved design, currently under development. The vehicle scope concern identified in this query was addressed by the new recalls including all Model Year 2013–2016 Dodge Dart vehicles produced and equipped with the affected shifter cable assembly. Accordingly, ODI is closing Investigation RQ25002. The agency will continue to monitor field performance and recall completion data to evaluate the effectiveness of the new remedy. ODI reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Power Train:automatic Transmission:lever And Linkage:floor Shift
On June 30, 2025, the Office of Defects Investigations (ODI) opened RQ25002 to investigate and review the effectiveness of Recall 19V-293. This recall was intended to address deterioration and detachment of shifter cable bushings by replacing them with an improved bushing that is less susceptible to deterioration from chemicals, oils, and solvents in MY2013-2016 Dodge Dart vehicles equipped with automatic transmissions and manufactured by Fiat Chrysler Automotive US LLC (FCA US). If the shifter cable becomes detached from the transmission, the transmission gear position may not match the driver’s intended gear selection. This mismatch could result in unintended vehicle movement or rollaway when the driver believes the transmission is in PARK, increasing the risk of a crash and/or injury. ODI has received sixty-three (63) Vehicle Owner Questionnaires (VOQ) alleging worn or misadjusted shifter cables and/or shifter cable detachments in subject vehicles that had already received the remedy for Recall 19V-293. Complainants reported incidents of bushing deterioration and detachment, resulting in gear-selection mismatch despite the prior recall repair, raising concerns regarding the effectiveness and durability of the implemented remedy and the adequacy of the recall. ODI’s investigation sought to determine whether the remedy used in recall 19V-293 adequately addressed the cause of the failure and whether other vehicles using the same bushing design might be affected. In response, FCA US and Dura Automotive Systems Inc. (Dura) determined that the repair for Recall 19V-293 did not sufficiently address the issue, and therefore, a safety defect exists in the subject vehicle population. As a result, FCA US and Dura initiated the following recall actions: · Recall 25V-674 (FCA US) is intended to address MY 2013–2016 Dodge Dart vehicles repaired under 19V-293 or otherwise equipped with suspect service parts. Remedy is under development. · Recall 25E-065 (Dura) is intended to address the defect at the equipment level by recalling affected gearshift control cable assemblies distributed as service components. Remedy is under development. The recalls initiated by FCA US (25V-674), and Dura Automotive Systems Inc. (25E-065) were received prior to ODI sending an Information Request (IR) letter to FCA. These two recalls seem to resolve the concerns that prompted investigation RQ25002 by replacing the previously recalled and service-supplied shifter cable assembly with an improved design, currently under development. The vehicle scope concern identified in this query was addressed by the new recalls including all Model Year 2013–2016 Dodge Dart vehicles produced and equipped with the affected shifter cable assembly. Accordingly, ODI is closing Investigation RQ25002. The agency will continue to monitor field performance and recall completion data to evaluate the effectiveness of the new remedy. ODI reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Power Train:shift Linkage/cable/rod
On June 30, 2025, the Office of Defects Investigations (ODI) opened RQ25002 to investigate and review the effectiveness of Recall 19V-293. This recall was intended to address deterioration and detachment of shifter cable bushings by replacing them with an improved bushing that is less susceptible to deterioration from chemicals, oils, and solvents in MY2013-2016 Dodge Dart vehicles equipped with automatic transmissions and manufactured by Fiat Chrysler Automotive US LLC (FCA US). If the shifter cable becomes detached from the transmission, the transmission gear position may not match the driver’s intended gear selection. This mismatch could result in unintended vehicle movement or rollaway when the driver believes the transmission is in PARK, increasing the risk of a crash and/or injury. ODI has received sixty-three (63) Vehicle Owner Questionnaires (VOQ) alleging worn or misadjusted shifter cables and/or shifter cable detachments in subject vehicles that had already received the remedy for Recall 19V-293. Complainants reported incidents of bushing deterioration and detachment, resulting in gear-selection mismatch despite the prior recall repair, raising concerns regarding the effectiveness and durability of the implemented remedy and the adequacy of the recall. ODI’s investigation sought to determine whether the remedy used in recall 19V-293 adequately addressed the cause of the failure and whether other vehicles using the same bushing design might be affected. In response, FCA US and Dura Automotive Systems Inc. (Dura) determined that the repair for Recall 19V-293 did not sufficiently address the issue, and therefore, a safety defect exists in the subject vehicle population. As a result, FCA US and Dura initiated the following recall actions: · Recall 25V-674 (FCA US) is intended to address MY 2013–2016 Dodge Dart vehicles repaired under 19V-293 or otherwise equipped with suspect service parts. Remedy is under development. · Recall 25E-065 (Dura) is intended to address the defect at the equipment level by recalling affected gearshift control cable assemblies distributed as service components. Remedy is under development. The recalls initiated by FCA US (25V-674), and Dura Automotive Systems Inc. (25E-065) were received prior to ODI sending an Information Request (IR) letter to FCA. These two recalls seem to resolve the concerns that prompted investigation RQ25002 by replacing the previously recalled and service-supplied shifter cable assembly with an improved design, currently under development. The vehicle scope concern identified in this query was addressed by the new recalls including all Model Year 2013–2016 Dodge Dart vehicles produced and equipped with the affected shifter cable assembly. Accordingly, ODI is closing Investigation RQ25002. The agency will continue to monitor field performance and recall completion data to evaluate the effectiveness of the new remedy. ODI reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Power Train:shift Linkage/cable/rod
On June 30, 2025, the Office of Defects Investigations (ODI) opened RQ25002 to investigate and review the effectiveness of Recall 19V-293. This recall was intended to address deterioration and detachment of shifter cable bushings by replacing them with an improved bushing that is less susceptible to deterioration from chemicals, oils, and solvents in MY2013-2016 Dodge Dart vehicles equipped with automatic transmissions and manufactured by Fiat Chrysler Automotive US LLC (FCA US). If the shifter cable becomes detached from the transmission, the transmission gear position may not match the driver’s intended gear selection. This mismatch could result in unintended vehicle movement or rollaway when the driver believes the transmission is in PARK, increasing the risk of a crash and/or injury. ODI has received sixty-three (63) Vehicle Owner Questionnaires (VOQ) alleging worn or misadjusted shifter cables and/or shifter cable detachments in subject vehicles that had already received the remedy for Recall 19V-293. Complainants reported incidents of bushing deterioration and detachment, resulting in gear-selection mismatch despite the prior recall repair, raising concerns regarding the effectiveness and durability of the implemented remedy and the adequacy of the recall. ODI’s investigation sought to determine whether the remedy used in recall 19V-293 adequately addressed the cause of the failure and whether other vehicles using the same bushing design might be affected. In response, FCA US and Dura Automotive Systems Inc. (Dura) determined that the repair for Recall 19V-293 did not sufficiently address the issue, and therefore, a safety defect exists in the subject vehicle population. As a result, FCA US and Dura initiated the following recall actions: · Recall 25V-674 (FCA US) is intended to address MY 2013–2016 Dodge Dart vehicles repaired under 19V-293 or otherwise equipped with suspect service parts. Remedy is under development. · Recall 25E-065 (Dura) is intended to address the defect at the equipment level by recalling affected gearshift control cable assemblies distributed as service components. Remedy is under development. The recalls initiated by FCA US (25V-674), and Dura Automotive Systems Inc. (25E-065) were received prior to ODI sending an Information Request (IR) letter to FCA. These two recalls seem to resolve the concerns that prompted investigation RQ25002 by replacing the previously recalled and service-supplied shifter cable assembly with an improved design, currently under development. The vehicle scope concern identified in this query was addressed by the new recalls including all Model Year 2013–2016 Dodge Dart vehicles produced and equipped with the affected shifter cable assembly. Accordingly, ODI is closing Investigation RQ25002. The agency will continue to monitor field performance and recall completion data to evaluate the effectiveness of the new remedy. ODI reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Power Train:shift Linkage/cable/rod:retaining Fasteners/hardware
On June 30, 2025, the Office of Defects Investigations (ODI) opened RQ25002 to investigate and review the effectiveness of Recall 19V-293. This recall was intended to address deterioration and detachment of shifter cable bushings by replacing them with an improved bushing that is less susceptible to deterioration from chemicals, oils, and solvents in MY2013-2016 Dodge Dart vehicles equipped with automatic transmissions and manufactured by Fiat Chrysler Automotive US LLC (FCA US). If the shifter cable becomes detached from the transmission, the transmission gear position may not match the driver’s intended gear selection. This mismatch could result in unintended vehicle movement or rollaway when the driver believes the transmission is in PARK, increasing the risk of a crash and/or injury. ODI has received sixty-three (63) Vehicle Owner Questionnaires (VOQ) alleging worn or misadjusted shifter cables and/or shifter cable detachments in subject vehicles that had already received the remedy for Recall 19V-293. Complainants reported incidents of bushing deterioration and detachment, resulting in gear-selection mismatch despite the prior recall repair, raising concerns regarding the effectiveness and durability of the implemented remedy and the adequacy of the recall. ODI’s investigation sought to determine whether the remedy used in recall 19V-293 adequately addressed the cause of the failure and whether other vehicles using the same bushing design might be affected. In response, FCA US and Dura Automotive Systems Inc. (Dura) determined that the repair for Recall 19V-293 did not sufficiently address the issue, and therefore, a safety defect exists in the subject vehicle population. As a result, FCA US and Dura initiated the following recall actions: · Recall 25V-674 (FCA US) is intended to address MY 2013–2016 Dodge Dart vehicles repaired under 19V-293 or otherwise equipped with suspect service parts. Remedy is under development. · Recall 25E-065 (Dura) is intended to address the defect at the equipment level by recalling affected gearshift control cable assemblies distributed as service components. Remedy is under development. The recalls initiated by FCA US (25V-674), and Dura Automotive Systems Inc. (25E-065) were received prior to ODI sending an Information Request (IR) letter to FCA. These two recalls seem to resolve the concerns that prompted investigation RQ25002 by replacing the previously recalled and service-supplied shifter cable assembly with an improved design, currently under development. The vehicle scope concern identified in this query was addressed by the new recalls including all Model Year 2013–2016 Dodge Dart vehicles produced and equipped with the affected shifter cable assembly. Accordingly, ODI is closing Investigation RQ25002. The agency will continue to monitor field performance and recall completion data to evaluate the effectiveness of the new remedy. ODI reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Power Train:shift Linkage/cable/rod:retaining Fasteners/hardware
On June 30, 2025, the Office of Defects Investigations (ODI) opened RQ25002 to investigate and review the effectiveness of Recall 19V-293. This recall was intended to address deterioration and detachment of shifter cable bushings by replacing them with an improved bushing that is less susceptible to deterioration from chemicals, oils, and solvents in MY2013-2016 Dodge Dart vehicles equipped with automatic transmissions and manufactured by Fiat Chrysler Automotive US LLC (FCA US). If the shifter cable becomes detached from the transmission, the transmission gear position may not match the driver’s intended gear selection. This mismatch could result in unintended vehicle movement or rollaway when the driver believes the transmission is in PARK, increasing the risk of a crash and/or injury. ODI has received sixty-three (63) Vehicle Owner Questionnaires (VOQ) alleging worn or misadjusted shifter cables and/or shifter cable detachments in subject vehicles that had already received the remedy for Recall 19V-293. Complainants reported incidents of bushing deterioration and detachment, resulting in gear-selection mismatch despite the prior recall repair, raising concerns regarding the effectiveness and durability of the implemented remedy and the adequacy of the recall. ODI’s investigation sought to determine whether the remedy used in recall 19V-293 adequately addressed the cause of the failure and whether other vehicles using the same bushing design might be affected. In response, FCA US and Dura Automotive Systems Inc. (Dura) determined that the repair for Recall 19V-293 did not sufficiently address the issue, and therefore, a safety defect exists in the subject vehicle population. As a result, FCA US and Dura initiated the following recall actions: · Recall 25V-674 (FCA US) is intended to address MY 2013–2016 Dodge Dart vehicles repaired under 19V-293 or otherwise equipped with suspect service parts. Remedy is under development. · Recall 25E-065 (Dura) is intended to address the defect at the equipment level by recalling affected gearshift control cable assemblies distributed as service components. Remedy is under development. The recalls initiated by FCA US (25V-674), and Dura Automotive Systems Inc. (25E-065) were received prior to ODI sending an Information Request (IR) letter to FCA. These two recalls seem to resolve the concerns that prompted investigation RQ25002 by replacing the previously recalled and service-supplied shifter cable assembly with an improved design, currently under development. The vehicle scope concern identified in this query was addressed by the new recalls including all Model Year 2013–2016 Dodge Dart vehicles produced and equipped with the affected shifter cable assembly. Accordingly, ODI is closing Investigation RQ25002. The agency will continue to monitor field performance and recall completion data to evaluate the effectiveness of the new remedy. ODI reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
PE15024 · Brake Power Assist Failure
Opened Jun 18, 2015 · Closed Dec 9, 2015
Status: closed (inferred from source dates) · Service Brakes; Service Brakes, Hydraulic; Service Brakes, Hydraulic:power Assist
On November 24, 2015, Fiat Chrysler Automobiles, US LLC, (FCA), submitted a Defect Information Report (DIR) to NHTSA regarding a brake booster defect in approximately 105,458 model year (MY) 2013 through 2014Dodge Dart vehicles equipped with a 2.0L or 2.4L engine and produced between February 27, 2012 and January 23, 2014 (NHTSA Recall# 15V-800, FCA Recall# R63).According to FCA's DIR, the affected vehicles, may experience engine oil migration from the vacuum pump to the brake booster.Brake booster diaphragms exposed to oil may become damaged, resulting in a loss of brake power assist.FCA's recall will inspect the affected vehicles for the presence of engine oil in the brake booster.If no oil is found, the vacuum tube assembly will be replaced with a new design part.If oil is found, the vacuum pump, vacuum tube assembly, brake booster and master cylinder will be replaced.On June 18, 2015, the Office of Defects Investigations opened Preliminary Evaluation PE15-024 to investigate complaints alleging sudden increases in brake pedal effort with corresponding reductions in brake performance in MY 2013 Dodge Dart vehicles.The vehicle population and Failure Report figures in this resume are limited to the MY 2013 Dodge Dart vehicles that are the subject vehicles of PE15-024 all of which are included in the FCA recall.Some of the complaints reported hearing a popping noise during a brake application, which corresponded with sudden reaction force from the brake pedal, increased difficulty in applying the pedal and decreased brake effectiveness.FCA's analysis of field return booster assemblies indicated that some brake booster diaphragms exposed to the engine oil leak condition experienced sudden catastrophic ruptures, resulting in complete loss of booster function.This investigation is hereby closed based on the FCA recall.The VOQs associated with the closing of this investigation are: 10795258, 10795140, 10790670, 10790397, 10786152, 10786142, 10783492, 10783153, 10781418, 10779446, 10778244, 10776581, 10765244, 10765141, 10763566, 10763143, 10762254, 10761075, 10760965, 10759817, 10758707, 10758639, 10750235, 10748935, 10747634, 10745494, 10745395, 10745185, 10744577, 10744361, 10744052, 10736149, 10734443, 10734108, 10732067, 10726648, 10715993, 10713690, 10695212, 10668965, 10660526, 10659435, 10638228, 10620713, 10619184, 10610512, 10597398, 10583883, 10569142, 10565689, 10556239, and 10533008.
Additional source detail variants (3)
Service Brakes
On November 24, 2015, Fiat Chrysler Automobiles, US LLC, (FCA), submitted a Defect Information Report (DIR) to NHTSA regarding a brake booster defect in approximately 105,458 model year (MY) 2013 through 2014Dodge Dart vehicles equipped with a 2.0L or 2.4L engine and produced between February 27, 2012 and January 23, 2014 (NHTSA Recall# 15V-800, FCA Recall# R63).According to FCA's DIR, the affected vehicles, may experience engine oil migration from the vacuum pump to the brake booster.Brake booster diaphragms exposed to oil may become damaged, resulting in a loss of brake power assist.FCA's recall will inspect the affected vehicles for the presence of engine oil in the brake booster.If no oil is found, the vacuum tube assembly will be replaced with a new design part.If oil is found, the vacuum pump, vacuum tube assembly, brake booster and master cylinder will be replaced.On June 18, 2015, the Office of Defects Investigations opened Preliminary Evaluation PE15-024 to investigate complaints alleging sudden increases in brake pedal effort with corresponding reductions in brake performance in MY 2013 Dodge Dart vehicles.The vehicle population and Failure Report figures in this resume are limited to the MY 2013 Dodge Dart vehicles that are the subject vehicles of PE15-024 all of which are included in the FCA recall.Some of the complaints reported hearing a popping noise during a brake application, which corresponded with sudden reaction force from the brake pedal, increased difficulty in applying the pedal and decreased brake effectiveness.FCA's analysis of field return booster assemblies indicated that some brake booster diaphragms exposed to the engine oil leak condition experienced sudden catastrophic ruptures, resulting in complete loss of booster function.This investigation is hereby closed based on the FCA recall.The VOQs associated with the closing of this investigation are: 10795258, 10795140, 10790670, 10790397, 10786152, 10786142, 10783492, 10783153, 10781418, 10779446, 10778244, 10776581, 10765244, 10765141, 10763566, 10763143, 10762254, 10761075, 10760965, 10759817, 10758707, 10758639, 10750235, 10748935, 10747634, 10745494, 10745395, 10745185, 10744577, 10744361, 10744052, 10736149, 10734443, 10734108, 10732067, 10726648, 10715993, 10713690, 10695212, 10668965, 10660526, 10659435, 10638228, 10620713, 10619184, 10610512, 10597398, 10583883, 10569142, 10565689, 10556239, and 10533008.
Service Brakes, Hydraulic
On November 24, 2015, Fiat Chrysler Automobiles, US LLC, (FCA), submitted a Defect Information Report (DIR) to NHTSA regarding a brake booster defect in approximately 105,458 model year (MY) 2013 through 2014Dodge Dart vehicles equipped with a 2.0L or 2.4L engine and produced between February 27, 2012 and January 23, 2014 (NHTSA Recall# 15V-800, FCA Recall# R63).According to FCA's DIR, the affected vehicles, may experience engine oil migration from the vacuum pump to the brake booster.Brake booster diaphragms exposed to oil may become damaged, resulting in a loss of brake power assist.FCA's recall will inspect the affected vehicles for the presence of engine oil in the brake booster.If no oil is found, the vacuum tube assembly will be replaced with a new design part.If oil is found, the vacuum pump, vacuum tube assembly, brake booster and master cylinder will be replaced.On June 18, 2015, the Office of Defects Investigations opened Preliminary Evaluation PE15-024 to investigate complaints alleging sudden increases in brake pedal effort with corresponding reductions in brake performance in MY 2013 Dodge Dart vehicles.The vehicle population and Failure Report figures in this resume are limited to the MY 2013 Dodge Dart vehicles that are the subject vehicles of PE15-024 all of which are included in the FCA recall.Some of the complaints reported hearing a popping noise during a brake application, which corresponded with sudden reaction force from the brake pedal, increased difficulty in applying the pedal and decreased brake effectiveness.FCA's analysis of field return booster assemblies indicated that some brake booster diaphragms exposed to the engine oil leak condition experienced sudden catastrophic ruptures, resulting in complete loss of booster function.This investigation is hereby closed based on the FCA recall.The VOQs associated with the closing of this investigation are: 10795258, 10795140, 10790670, 10790397, 10786152, 10786142, 10783492, 10783153, 10781418, 10779446, 10778244, 10776581, 10765244, 10765141, 10763566, 10763143, 10762254, 10761075, 10760965, 10759817, 10758707, 10758639, 10750235, 10748935, 10747634, 10745494, 10745395, 10745185, 10744577, 10744361, 10744052, 10736149, 10734443, 10734108, 10732067, 10726648, 10715993, 10713690, 10695212, 10668965, 10660526, 10659435, 10638228, 10620713, 10619184, 10610512, 10597398, 10583883, 10569142, 10565689, 10556239, and 10533008.
Service Brakes, Hydraulic:power Assist
On November 24, 2015, Fiat Chrysler Automobiles, US LLC, (FCA), submitted a Defect Information Report (DIR) to NHTSA regarding a brake booster defect in approximately 105,458 model year (MY) 2013 through 2014Dodge Dart vehicles equipped with a 2.0L or 2.4L engine and produced between February 27, 2012 and January 23, 2014 (NHTSA Recall# 15V-800, FCA Recall# R63).According to FCA's DIR, the affected vehicles, may experience engine oil migration from the vacuum pump to the brake booster.Brake booster diaphragms exposed to oil may become damaged, resulting in a loss of brake power assist.FCA's recall will inspect the affected vehicles for the presence of engine oil in the brake booster.If no oil is found, the vacuum tube assembly will be replaced with a new design part.If oil is found, the vacuum pump, vacuum tube assembly, brake booster and master cylinder will be replaced.On June 18, 2015, the Office of Defects Investigations opened Preliminary Evaluation PE15-024 to investigate complaints alleging sudden increases in brake pedal effort with corresponding reductions in brake performance in MY 2013 Dodge Dart vehicles.The vehicle population and Failure Report figures in this resume are limited to the MY 2013 Dodge Dart vehicles that are the subject vehicles of PE15-024 all of which are included in the FCA recall.Some of the complaints reported hearing a popping noise during a brake application, which corresponded with sudden reaction force from the brake pedal, increased difficulty in applying the pedal and decreased brake effectiveness.FCA's analysis of field return booster assemblies indicated that some brake booster diaphragms exposed to the engine oil leak condition experienced sudden catastrophic ruptures, resulting in complete loss of booster function.This investigation is hereby closed based on the FCA recall.The VOQs associated with the closing of this investigation are: 10795258, 10795140, 10790670, 10790397, 10786152, 10786142, 10783492, 10783153, 10781418, 10779446, 10778244, 10776581, 10765244, 10765141, 10763566, 10763143, 10762254, 10761075, 10760965, 10759817, 10758707, 10758639, 10750235, 10748935, 10747634, 10745494, 10745395, 10745185, 10744577, 10744361, 10744052, 10736149, 10734443, 10734108, 10732067, 10726648, 10715993, 10713690, 10695212, 10668965, 10660526, 10659435, 10638228, 10620713, 10619184, 10610512, 10597398, 10583883, 10569142, 10565689, 10556239, and 10533008.