SPARE TIRE FELL OFF VEHICLE WHILE VEHICLE WAS IN MOTION. NO REDUNDANCY IN THE MECHANISM THAT HOLDS THE SPARE TIRE IN PLACE. METAL CLIP THAT FITS IN THE CENTER BORE OF THE WHEEL IS THE ONLY THING HOLDING THE SPARE TIRE IN PLACE. IN THE CASE OF MY VEHICLE THE CLIP HAD RUSTED AND FAILED ALLOWING THE SPARE TIRE TO FALL OFF THE …
Read full complaint
SPARE TIRE FELL OFF VEHICLE WHILE VEHICLE WAS IN MOTION. NO REDUNDANCY IN THE MECHANISM THAT HOLDS THE SPARE TIRE IN PLACE. METAL CLIP THAT FITS IN THE CENTER BORE OF THE WHEEL IS THE ONLY THING HOLDING THE SPARE TIRE IN PLACE. IN THE CASE OF MY VEHICLE THE CLIP HAD RUSTED AND FAILED ALLOWING THE SPARE TIRE TO FALL OFF THE VEHICLE. IF THIS HAD OCCURRED ON A BUSY ROAD AT SPEED IT COULD HAVE BEEN VERY DANGEROUS. *TR
NHTSA ODI #10640134
17,685 miles · Mar 8, 2014
Tires
THE LEFT REAR ORIGINAL GOODYEAR WRANGLER RT/S P265/70R16 TIRE ON MY 2002 DODGE DAKOTA 4WD PICK-UP TRUCK HAS BELT SEPARATION. THE TRUCK HAS ONLY 17,685 MILES ON IT. THE TRUCK IS USED THROUGHOUT THE YEAR PRIMARILY AS A SPARE VEHICLE WHEN THE CAR IS BEING USED. I WAS UNABLE TO LOCATE THE DOT NUMBER. *TR
NHTSA ODI #10567940
24,000 miles · Oct 24, 2005
Tires
DT: THE CONTACT HAS A PICKUP TRUCK THAT HAS ORIGINAL FACTORY GOODYEAR WRANGLER ST TIRES, P215/75R15. WHEN THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP FOR MAINTENANCE THE TECHNICIAN NOTICED SLITS UP TO THREE INCHES LONG ON THE SIDEWALL ABOVE THE BEAD RUNNING WITH THE CIRCUMFERENCE OF THE TIRE DOWN TO THE INNER FABRIC ON ALL F…
Read full complaint
DT: THE CONTACT HAS A PICKUP TRUCK THAT HAS ORIGINAL FACTORY GOODYEAR WRANGLER ST TIRES, P215/75R15. WHEN THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP FOR MAINTENANCE THE TECHNICIAN NOTICED SLITS UP TO THREE INCHES LONG ON THE SIDEWALL ABOVE THE BEAD RUNNING WITH THE CIRCUMFERENCE OF THE TIRE DOWN TO THE INNER FABRIC ON ALL FOUR TIRES. THERE HAVE BEEN NO PREVIOUS PROBLEMS WITH THE TIRES. BECAUSE THE TIRES WERE NO LONGER COVERED BY WARRANTY HE REPLACED ALL FOUR TIRES WITH A DIFFERENT BRANDS. HE EXPERIENCED NO FURTHER PROBLEMS AFTER THE TIRE REPLACEMENT. *AK THERE WERE CRACKS ON 3 OF THE 4 TIRES. UPDATED 11/29/05. *JB
NHTSA ODI #10140595
Mileage unknown · Oct 7, 2004
Seat BeltsTiresCrashInjury
MY HUSBAND'S TRUCK WAS STRUCK ON THE REAR DRIVER'S SIDE. ALMOST @ THE BUMPER. POLICE REPORT STATED DAMAGE TO THE OTHER VEHICLE "NEGLIGIBLE". MY HUSBAND WAS KILLED. HE WAS PARTIALLY EJECTED. THE TRUCK ROLLED OVER ON HIM. GREAT ROAD/WEATHER CONDITIONS. LIGHT TRAFFIC-JUST THE 2 VEHICLES. 45 MPH SPEED LIMIT. HIS BACK TIRES WERE…
Read full complaint
MY HUSBAND'S TRUCK WAS STRUCK ON THE REAR DRIVER'S SIDE. ALMOST @ THE BUMPER. POLICE REPORT STATED DAMAGE TO THE OTHER VEHICLE "NEGLIGIBLE". MY HUSBAND WAS KILLED. HE WAS PARTIALLY EJECTED. THE TRUCK ROLLED OVER ON HIM. GREAT ROAD/WEATHER CONDITIONS. LIGHT TRAFFIC-JUST THE 2 VEHICLES. 45 MPH SPEED LIMIT. HIS BACK TIRES WERE BOTH RIPPED FROM THE VEHICLE. ALL HE EVER HIT WAS A CURB. HE WAS KILLED INSTANTLY. *NM
NHTSA ODI #10093740
12,112 miles · Jul 20, 2004
Tires
THE RIGHT REAR TIRE HAD A BLOWOUT WHILE DRIVING 70 MPH ( ORIGINAL EQUIPMENT, TIRE SIZE P265/70R16, DOT# 25.4 0FFSET) *JB
NHTSA ODI #10083324
21,000 miles · Jun 4, 2004
SuspensionTires
CONSUMER HEARD A NOISE IN THE FRONT END WHEN THE BRAKE PEDAL WAS DEPRESSED, WHEN MAKING RIGHT TURNS AND WHEN DOWN HILL. UPON INSPECTION OF THE FRONT END BY A MECHANIC IT WAS DETERMINED THAT FRONT DRIVER SIDE TIRE AND FRONT UPPER BALL JOINT WERE LOOSE. VEHICLE WAS THEN TAKEN TO A DEALERSHIP WHO INDICATED THAT THE BALL JOINTS…
Read full complaint
CONSUMER HEARD A NOISE IN THE FRONT END WHEN THE BRAKE PEDAL WAS DEPRESSED, WHEN MAKING RIGHT TURNS AND WHEN DOWN HILL. UPON INSPECTION OF THE FRONT END BY A MECHANIC IT WAS DETERMINED THAT FRONT DRIVER SIDE TIRE AND FRONT UPPER BALL JOINT WERE LOOSE. VEHICLE WAS THEN TAKEN TO A DEALERSHIP WHO INDICATED THAT THE BALL JOINTS WERE NOT LOOSE ENOUGH TO BE REPLACED.*AK *NM
NHTSA ODI #10066889
26,577 miles · Jan 6, 2004
Tires
WHEN TURNING LEFT THE PASSENGERS SIDE TIRE PRODUCED A THUMPING NOISE. CONSUMER WAS CONCERNED THAT THE TIRE WILL SEPARATE FROM THE RIM. *AK
NHTSA ODI #10053471
65,000 miles · Dec 31, 2003
SteeringTiresCrashInjury
WHILE DRIVING 25 MPH, THE CONSUMER HEARD A NOISE COMING FROM THE FRONT END OF THE VEHICLE. A FEW SECONDS LATER THE VEHICLE WENT TO ONE SIDE AND COLLIDED WITH A TREE. THE CONSUMER WAS KNOCKED UNCONSCIOUS IN THE COLLISION. THE CAUSE OF THE COLLISION WAS THE SPINDLE AND THE WHEEL SEPARATED FROM THE VEHICLE. THE MANUFACTURER AND…
Read full complaint
WHILE DRIVING 25 MPH, THE CONSUMER HEARD A NOISE COMING FROM THE FRONT END OF THE VEHICLE. A FEW SECONDS LATER THE VEHICLE WENT TO ONE SIDE AND COLLIDED WITH A TREE. THE CONSUMER WAS KNOCKED UNCONSCIOUS IN THE COLLISION. THE CAUSE OF THE COLLISION WAS THE SPINDLE AND THE WHEEL SEPARATED FROM THE VEHICLE. THE MANUFACTURER AND THE DEALER WERE AWARE OF THE PROBLEM. *JB *MR
NHTSA ODI #10052222
Mileage unknown · Jul 25, 2003
SuspensionTires
2002 DODGE DAKOTA 4X2 PICKUP HAS PREMATURE FAILURE OF UPPER BALL JOINTS AND SEVERE TIRE WEAR. 32,000 MILES HAVING TO REPLACE UPPER BALL JOINTS, BAD FRONT END SUSPENSION AND HANDLING.*AK
NHTSA ODI #10029209
Mileage unknown · Apr 18, 2003
Tires
WHILE DRIVING THE REAR PASSENGER SIDE TIRE BLEW OUT WITHOUT WARNING . THE DEALER WAS NOTIFIED ( SIZE#P26570R16 AND DOT#PK72WDWR4001). *NLM
ON CERTAIN VAN AND PICKUP TRUCKS EQUIPPED WITH AUTOMATIC TRANSMISSIONS, THE IGNITION/PARK SHIFT INTERLOCK SYSTEM MAY BECOME INOPERATIVE. THIS CAN ALLOW THE SHIFTER TO BE MOVED OUT OF THE "PARK" POSITION WITH THE IGNITION KEY REMOVED (OR IN THE "LOCK" POSITION). THIS CAN ALSO ALLOW THE IGNITION KEY TO BE REMOVED WHEN THE SHIFTER HAS NOT BEEN PLACED IN THE "PARK" POSITION.
Consequence & remedy
Consequence: EITHER OF THESE CONDITIONS COULD ALLOW THE VEHICLE TO ROLL AWAY CAUSING A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL REPLACE THE GEARSHIFT BLOCKER AND BRACKET ASSEMBLY FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JANUARY 2008. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS EQUIPPED WITH FOUR-WHEEL DRIVE (4X4), IF MOISTURE LEAKS INTO THE FRONT SUSPENSION UPPER BALL JOINT, EVACUATION OF THE LUBRICANT AND CORROSION OF THE JOINT MAY CAUSE THE JOINT TO WEAR OVER AN EXTENDED PERIOD OF TIME. THIS COULD CAUSE A CLUNKING NOISE IN THE FRONT SUSPENSION, WHICH MAY NOT ALWAYS BE HEARD BY THE VEHICLE OCCUPANTS.
Consequence & remedy
Consequence: EXCESSIVE WEAR IN THE UPPER BALL JOINT MAY ALLOW IT TO SEPARATE, WHICH COULD RESULT IN LOSS OF CONTROL OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS. THIS SAFETY IMPROVEMENT CAMPAIGN BEGAN ON DECEMBER 21, 2004. OWNERS CAN CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE WINDSHIELD WIPER MODULE MOTOR MAY BE SUSCEPTIBLE TO WATER INTRUSION THAT COULD CAUSE INTERNAL CORROSION AND RESULT IN PARTIAL OR COMPLETE LOSS OF FRONT WINDSHIELD WIPING CAPABILITY.
Consequence & remedy
Consequence: DRIVER VISIBILITY COULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE FRONT WINDSHIELD WIPER MODULE. OWNER NOTIFICATION BEGAN ON JULY 12, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
ON CERTAIN MINIVANS AND 4X2 PICKUP TRUCKS, THE VEHICLE CERTIFICATION LABEL MAY HAVE GROSS AXLE WEIGHT RATINGS (GAWR) THAT EXCEED THE MAXIMUM TIRE LOAD CAPACITY AS DEFINED IN FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."
Consequence & remedy
Consequence: IMPROPERLY LOADING YOUR VEHICLE CAN CAUSE TIRE FAILURE AND RESULT IN A CRASH.
Remedy: OWNERS WILL BE PROVIDED WITH VEHICLE CERTIFICATION LABEL OVERLAYS CONTAINING CORRECTED INFORMATION RELATIVE TO VEHICLE GAWR AND TIRE SIZE. OWNER NOTIFICATION BEGAN MARCH 1, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-992-1997.
ON CERTAIN PICKUP TRUCKS EQUIPPED WITH MANUAL TRANSMISSIONS, THE HEADLAMP AND DASH WIRING HARNESS MAY BE CHAFED BY THE ACTUATION OF THE CLUTCH PEDAL. THIS COULD RESULT IN ABNORMAL OPERATION OF THE WIPERS, TURN SIGNALS, HORN OR LIGHTING SYSTEMS.
Consequence & remedy
Consequence: THIS COULD AFFECT DRIVER VISIBILITY, COULD PREVENT A DRIVER FROM SOUNDING A WARNING BY USING THE HORN, AND, WHEN THE TURN SIGNALS ARE INOPERATIVE, THE DRIVER CANNOT USE THEM TO SIGNAL INTENT TO TURN, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REROUTE THE WIRE HARNESS AND REPAIR THE HARNESS IF NECESSARY. OWNER NOTIFICATION BEGAN NOVEMBER 3, 2003. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-992-1997.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (5)
Suspension
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm:upper Arm
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm:upper Ball Joint
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
2002 Dodge Dakota Problems, Complaints & Recalls | Skip That Year
Illustration