IllustrationWHY are brake lines on vehicles not required to be made so as not to rust? Brake lines failed on my vehicle, and need to be replaced. How many accidents are caused by brake line failures?
2002 Dodge Dakota
Owner reports · Recalls · Investigations
More warning signs than most Dakota years
Owner complaints for the 2002 Dodge Dakota are substantially higher than the model-year median of 166.
About this comparison →How this year compares
Owner complaints by model year
Compare all Dakota years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1550–25K
15925–50K
8450–75K
4975–100K
36100–150K
22150K+
505 reports with mileage · 173 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Suspension. Review the 226 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 177 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 89 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
55 crash reports18 fire reports22 injury reports
Service Brakes complaints
26 reportsII HAVE REPLACE FRONT ROTORS, FRONT CALIPERS, REAR WHEEL CYLINDERS AND SHOES, THE BRAKES HAVE BEEN BLEED SEVERAL TIMES, AND BRAKE SYSTEM WAS LOOKED AT SEVERAL TIMES BY ASE MASTER MECHANIC. GOING DOWN THE ROAD ON THE INITIAL PUSH ON THE PEDDLE THE PEDDLE GOES MORE THAN HALF WAY DOWN TO THE FLOOR, YOU THEN RELEASE PEDAL AND RE APP…
Read full complaint
II HAVE REPLACE FRONT ROTORS, FRONT CALIPERS, REAR WHEEL CYLINDERS AND SHOES, THE BRAKES HAVE BEEN BLEED SEVERAL TIMES, AND BRAKE SYSTEM WAS LOOKED AT SEVERAL TIMES BY ASE MASTER MECHANIC. GOING DOWN THE ROAD ON THE INITIAL PUSH ON THE PEDDLE THE PEDDLE GOES MORE THAN HALF WAY DOWN TO THE FLOOR, YOU THEN RELEASE PEDAL AND RE APPLY AND IT STOPS AS IT SHOULD WITH THE CORRECT PEDDLE HEIGHT. ALL WORK WAS DONE WITHIN 10K MILES. THE TRUCK HAS 116K MILES.THIS STARTED ABOUT 5 MONTHS AGO.
THIS IS THE SECOND TIME ONE OF THE BREAK LINES HAS RUSTED THRU. THIS TIME I HIT THE BRAKES HARD TO MISS TWO DEAR AND THE PEDAL WENT TO THE FLOOR. I ONLY COULD STOP THE TRUCK WITH THE EMERGENCY BREAK. THE TRUCK HAS NOT BEEN USED OFF ROAD AND HAS BEEN DRIVEN IN VIRGINIA IS HOLE LIFE. THE FIRST TIME MY MECHANIC CAUGHT A LEAK IN TH…
Read full complaint
THIS IS THE SECOND TIME ONE OF THE BREAK LINES HAS RUSTED THRU. THIS TIME I HIT THE BRAKES HARD TO MISS TWO DEAR AND THE PEDAL WENT TO THE FLOOR. I ONLY COULD STOP THE TRUCK WITH THE EMERGENCY BREAK. THE TRUCK HAS NOT BEEN USED OFF ROAD AND HAS BEEN DRIVEN IN VIRGINIA IS HOLE LIFE. THE FIRST TIME MY MECHANIC CAUGHT A LEAK IN THE LINE BEFORE ANY PROBLEM.
TL* THE CONTACT OWNS A 2002 DODGE DAKOTA. WHILE DRIVING VARIOUS SPEEDS, THE BRAKE PEDAL WAS APPLIED AND BEGAN TO GRIND AND SQUEAK. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE FRONT DRIVER SIDE BRAKE CALIPER AND BRAKE PADS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE D…
Read full complaint
TL* THE CONTACT OWNS A 2002 DODGE DAKOTA. WHILE DRIVING VARIOUS SPEEDS, THE BRAKE PEDAL WAS APPLIED AND BEGAN TO GRIND AND SQUEAK. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE FRONT DRIVER SIDE BRAKE CALIPER AND BRAKE PADS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 160,000.
RECALL WAS DRIVING AND ALL OF MY BREAKS AND CALIBERS SEIZED UP..HAD TO STOP AND SPRAY THEM DOWN
BOUGHT A 2002 DODGE DAKOTA BRAKES AREN'T STRONG ENOUGH TO DRIVE ON INTERSTATE OR IN CITY , WENT TO DODGE DARCARS DEALERSHIP IN MARYLAND THEY LOOKED AT THE TRUCK , SAID THIS IS FINE THIS IS THE WAY DODGE BRAKES ARE TERRIBLY WRONG . WENT TO REPAIR THE EMERGENCY BRAKE CABLES DODGE DON'T MAKE THE PARTS ANY MORE THIS DODGE DON'T MAKE…
Read full complaint
BOUGHT A 2002 DODGE DAKOTA BRAKES AREN'T STRONG ENOUGH TO DRIVE ON INTERSTATE OR IN CITY , WENT TO DODGE DARCARS DEALERSHIP IN MARYLAND THEY LOOKED AT THE TRUCK , SAID THIS IS FINE THIS IS THE WAY DODGE BRAKES ARE TERRIBLY WRONG . WENT TO REPAIR THE EMERGENCY BRAKE CABLES DODGE DON'T MAKE THE PARTS ANY MORE THIS DODGE DON'T MAKE THE PARTS ANYMORE IS TERRIBLY WRONG . DODGE , DARARS ARE PUTTING CONSUMERS LIFE A RISK . 2002 4X4 DODGE DAKOTA SHOULD RECALLED BRAKES ,BRAKE PARTS UPGRADED TO STRONG , SAFE BRAKES , DODGE NEEDS TO KEEP MAKING THE PARTS FOR 2002 DODGE DAKOTA 4X4 OR HIRE SOMEBODY WHO CAN . , DODGE DARCARS VISUAL BRAKE CHECK IS THE WORST IDEA YET . BRAKES NEED TO BE FELT LOOK AT , BLEEDED .
TL* THE CONTACT OWNS A 2002 DODGE DAKOTA. WHILE DRIVING VARIOUS SPEEDS, THE FRONT PASSENGER SIDE BRAKES SEIZED WITHOUT THE BRAKE PEDAL BEING DEPRESSED. IN ADDITION, THE CONTACT NOTICED SMOKE COMING FROM THE FRONT PASSENGER SIDE WHERE THE BRAKE WAS LOCATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE …
Read full complaint
TL* THE CONTACT OWNS A 2002 DODGE DAKOTA. WHILE DRIVING VARIOUS SPEEDS, THE FRONT PASSENGER SIDE BRAKES SEIZED WITHOUT THE BRAKE PEDAL BEING DEPRESSED. IN ADDITION, THE CONTACT NOTICED SMOKE COMING FROM THE FRONT PASSENGER SIDE WHERE THE BRAKE WAS LOCATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE CALIPERS OR THE BRAKE LINES NEEDED TO BE REPLACED. THE CONTACT INDEPENDENTLY REPLACED THE BRAKE LINES, BRAKE CALIPERS, AND BRAKE PADS; HOWEVER, THE FAILURE RECURRED AND THE CONTACT NOTICED SMOKE AND FIRE COMING FROM THE FRONT PASSENGER SIDE WHERE THE BRAKE WAS LOCATED. THE CONTACT WAS ABLE TO EXTINGUISH THE FIRE. A POLICE REPORT WAS NOT FILED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 165,000.
I HAD JUST PURCHASED THE CAR 2 WEEKS EARLIER. I WAS ACCELERATING TO MERGE ONTO THE FREEWAY AND THE ACCELERATOR STUCK AT 60 MPH. NO MATTER WHAT I DID TO THE PEDAL, IT WAS STUCK AT 60 MPH. THE BRAKES WOULD NOT WORK EITHER. I WAS IN A RUNAWAY CAR ON A BUSY FREEWAY. I TRIED TO NEGOTIATE THE TRAFFIC FOR 2 MILES THEN DECIDED I NEEDED…
Read full complaint
I HAD JUST PURCHASED THE CAR 2 WEEKS EARLIER. I WAS ACCELERATING TO MERGE ONTO THE FREEWAY AND THE ACCELERATOR STUCK AT 60 MPH. NO MATTER WHAT I DID TO THE PEDAL, IT WAS STUCK AT 60 MPH. THE BRAKES WOULD NOT WORK EITHER. I WAS IN A RUNAWAY CAR ON A BUSY FREEWAY. I TRIED TO NEGOTIATE THE TRAFFIC FOR 2 MILES THEN DECIDED I NEEDED TO GET OFF THE FREEWAY. I STARTED TO SMASH INTO THE FREEWAY OFF-RAMP RETAINING WALL IN THE EFFORT TO SLOW THE TRUCK DOWN WHICH IT DID TO SOME DEGREE. THEN HAD TO BARREL THROUGH A RED LIGHT WITH FLASHERS AND HORN GOING AND TO STOP THE TRUCK I DELIBERATELY RAMMED IT INTO A WROUGHT IRON FENCE, 2 LANDSCAPING BOULDERS AND A LIGHT POST. THE AIRBAG ALSO FAILED. I WAS RUSHED BY AMBULANCE TO THE HOSPITAL WITH HEAD TRAUMA AND CONCUSSION, BROKEN GLASSES THAT CUT MY EYEBROW. I HAVE PICTURES. THE WORST PART HAS BEEN THE PTSD THAT I HAVE SUFFERED AS A RESULT OF THE ACCIDENT -- MULTIPLE FAILURE - ACCELERATOR, BRAKES AND AIRBAG. *TR
STEPPED ON BRAKE ON WET ROAD,ABS KICKED IN ON REAR AXLE AND TRUCK WOULD NOT SLOW DOWN. ALMOST HAD A REAR END COLLISION. VERY DANGEROUS, HAVE SEEN A LOT OF OTHER COMPLAINTS ABOUT SAME THING. ALSO LOSE ALL ELECTRICAL POWER WITH HEADLIGHTS ON MOMENTARILY LEAVING YOU WITHOUT LIGHTS. *TR
RIGHT FRONT BRAKE STUCK, BRAKE GOT HOT, SMOKE CAME OUT OF WHEEL WELL. *TR
Official recalls
507V555000 · Power Train:automatic Transmission:lever And Linkage:column Shift
Dec 4, 2007
ON CERTAIN VAN AND PICKUP TRUCKS EQUIPPED WITH AUTOMATIC TRANSMISSIONS, THE IGNITION/PARK SHIFT INTERLOCK SYSTEM MAY BECOME INOPERATIVE. THIS CAN ALLOW THE SHIFTER TO BE MOVED OUT OF THE "PARK" POSITION WITH THE IGNITION KEY REMOVED (OR IN THE "LOCK" POSITION). THIS CAN ALSO ALLOW THE IGNITION KEY TO BE REMOVED WHEN THE SHIFTER HAS NOT BEEN PLACED IN THE "PARK" POSITION.
Consequence & remedy
Consequence: EITHER OF THESE CONDITIONS COULD ALLOW THE VEHICLE TO ROLL AWAY CAUSING A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL REPLACE THE GEARSHIFT BLOCKER AND BRACKET ASSEMBLY FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JANUARY 2008. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
04V596000 · Suspension:front:control Arm:upper Ball Joint
Dec 21, 2004
ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS EQUIPPED WITH FOUR-WHEEL DRIVE (4X4), IF MOISTURE LEAKS INTO THE FRONT SUSPENSION UPPER BALL JOINT, EVACUATION OF THE LUBRICANT AND CORROSION OF THE JOINT MAY CAUSE THE JOINT TO WEAR OVER AN EXTENDED PERIOD OF TIME. THIS COULD CAUSE A CLUNKING NOISE IN THE FRONT SUSPENSION, WHICH MAY NOT ALWAYS BE HEARD BY THE VEHICLE OCCUPANTS.
Consequence & remedy
Consequence: EXCESSIVE WEAR IN THE UPPER BALL JOINT MAY ALLOW IT TO SEPARATE, WHICH COULD RESULT IN LOSS OF CONTROL OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS. THIS SAFETY IMPROVEMENT CAMPAIGN BEGAN ON DECEMBER 21, 2004. OWNERS CAN CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
04V216000 · Visibility:windshield Wiper/washer
May 5, 2004
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE WINDSHIELD WIPER MODULE MOTOR MAY BE SUSCEPTIBLE TO WATER INTRUSION THAT COULD CAUSE INTERNAL CORROSION AND RESULT IN PARTIAL OR COMPLETE LOSS OF FRONT WINDSHIELD WIPING CAPABILITY.
Consequence & remedy
Consequence: DRIVER VISIBILITY COULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE FRONT WINDSHIELD WIPER MODULE. OWNER NOTIFICATION BEGAN ON JULY 12, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
03V505000 · Equipment:other:labels
Dec 10, 2003
ON CERTAIN MINIVANS AND 4X2 PICKUP TRUCKS, THE VEHICLE CERTIFICATION LABEL MAY HAVE GROSS AXLE WEIGHT RATINGS (GAWR) THAT EXCEED THE MAXIMUM TIRE LOAD CAPACITY AS DEFINED IN FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."
Consequence & remedy
Consequence: IMPROPERLY LOADING YOUR VEHICLE CAN CAUSE TIRE FAILURE AND RESULT IN A CRASH.
Remedy: OWNERS WILL BE PROVIDED WITH VEHICLE CERTIFICATION LABEL OVERLAYS CONTAINING CORRECTED INFORMATION RELATIVE TO VEHICLE GAWR AND TIRE SIZE. OWNER NOTIFICATION BEGAN MARCH 1, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-992-1997.
03V389000 · Electrical System:wiring
Oct 10, 2003
ON CERTAIN PICKUP TRUCKS EQUIPPED WITH MANUAL TRANSMISSIONS, THE HEADLAMP AND DASH WIRING HARNESS MAY BE CHAFED BY THE ACTUATION OF THE CLUTCH PEDAL. THIS COULD RESULT IN ABNORMAL OPERATION OF THE WIPERS, TURN SIGNALS, HORN OR LIGHTING SYSTEMS.
Consequence & remedy
Consequence: THIS COULD AFFECT DRIVER VISIBILITY, COULD PREVENT A DRIVER FROM SOUNDING A WARNING BY USING THE HORN, AND, WHEN THE TURN SIGNALS ARE INOPERATIVE, THE DRIVER CANNOT USE THEM TO SIGNAL INTENT TO TURN, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REROUTE THE WIRE HARNESS AND REPAIR THE HARNESS IF NECESSARY. OWNER NOTIFICATION BEGAN NOVEMBER 3, 2003. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-992-1997.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA03023 · Upper Ball Joint Separation
Opened Nov 19, 2003 · Closed Feb 11, 2005
Status: closed (inferred from source dates) · Suspension; Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:upper Arm; Suspension:front:control Arm:upper Ball Joint
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (5)
Suspension
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm:upper Arm
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm:upper Ball Joint
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.