IllustrationBOTH UPPER BALL JOINTS ARE LOOSE REQUIRING REPLACEMENT. *JB
2000 Dodge Dakota
Owner reports · Recalls · Investigations
More warning signs than most Dakota years
Owner complaints for the 2000 Dodge Dakota are substantially higher than the model-year median of 166.
About this comparison →How this year compares
Owner complaints by model year
Compare all Dakota years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
520–25K
11025–50K
11950–75K
4475–100K
24100–150K
10150K+
359 reports with mileage · 447 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Suspension. Review the 282 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 248 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 74 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
60 crash reports14 fire reports35 injury reports
Suspension complaints
282 reportsDODGE DAKOTA TIE RODS. TIE ROD ACTUALLY BROKE. *BF THE CONSUMER SENT IN A COMPLAINT TO THE NHTSA ON LINE BUT HAD TROUBLE. *TC
NOTICED VERY LOUD SQUEAKING IN FRONT END OF 2000 DODGE DAKOTA. TOOK IN FOR DEALER TO SERVICE(46,000 MILES). MENTIONED BALL JOINTS. THEY REPLACED SWAY BAR BUSHINGS. FOUR MONTHS LATER SQUEAKING WAS BACK(51,000 MILES). RETURNED TO DEALER QUESTIONING BALL JOINTS AGAIN. THEY LUBRICATED THE SWAY BAR BUSHINGS. FIVE MONTHS LATER…
Read full complaint
NOTICED VERY LOUD SQUEAKING IN FRONT END OF 2000 DODGE DAKOTA. TOOK IN FOR DEALER TO SERVICE(46,000 MILES). MENTIONED BALL JOINTS. THEY REPLACED SWAY BAR BUSHINGS. FOUR MONTHS LATER SQUEAKING WAS BACK(51,000 MILES). RETURNED TO DEALER QUESTIONING BALL JOINTS AGAIN. THEY LUBRICATED THE SWAY BAR BUSHINGS. FIVE MONTHS LATER VEHICLE IN FOR STATE INSPECTION AND DRIVERS SIDE UPPER BALL JOINT FAILED, PASSENGER SIDE UPPER BALL JOINT ALMOST OUT OF TOLERANCE (55,000 MILES). HAD BOTH REPLACED WITH OEM FROM DODGE. SENT EMAIL TO SERVICE MANAGER QUESTIONING COVERAGE BY DODGE AND RECEIVED NO RESPONSE. *JB
I HAVE A 2000 DODGE DAKOTA. ON NOVEMBER 2,2004 WHILE DRIVING ON CITY SIDE STREETS THE FRONT PASSENGER WHEEL FELL OFF THE VEHICLE. WHILE WAITING FOR A TOW TRUCK TO ARRIVE, I CALLED THE DODGE DEALERSHIP WHERE I PURCHASED MY VEHICLE AND WAS TOLD THIS WOULD NOT BE COVERED UNDER WARRANTY. I HAD MY VECHILE TOWED TO MY MECHANIC WHO …
Read full complaint
I HAVE A 2000 DODGE DAKOTA. ON NOVEMBER 2,2004 WHILE DRIVING ON CITY SIDE STREETS THE FRONT PASSENGER WHEEL FELL OFF THE VEHICLE. WHILE WAITING FOR A TOW TRUCK TO ARRIVE, I CALLED THE DODGE DEALERSHIP WHERE I PURCHASED MY VEHICLE AND WAS TOLD THIS WOULD NOT BE COVERED UNDER WARRANTY. I HAD MY VECHILE TOWED TO MY MECHANIC WHO DID MOST OF THE REPAIRS (TOTALING ABOUT $1,300). HE HANDED ME A BOX WITH THE BALL JOINTS FROM MY VEHICLE AND TOLD ME TO HANG ONTO THEM. THE UPPER AND LOWER BALL JOINT ON BOTH SIDES NEEDED TO BE REPLACED. THE CAUSE OF THE ACCIDENT WAS THE UPPER BALL JOINT LOSING ALL IT'S GREASE (THIS IS SUPPOSED TO BE A SEALED UNIT!), CAUSING UNDO STRESS ON THE JOINT UNTIL IT EVENTUALLY SHEARED AWAY FROM THE VEHICLE. I STILL HAVE TO TAKE MY VEHICLE IN FOR SOME REPAIRS THAT NEED TO BE COMPLETED (CV BOOT REPLACEMENT AND A TIE ROD THAT IS TWISTED) - WHICH IS ESTIMATED TO BE AN ADDITIONAL $400. I DO HAVE THE BALL JOINTS - ALL IN VARYING DEGREES OF DEFECTIVE DAMAGE ALONG WITH PHOTOS OF THE VEHICLE AT THE PLACE OF THE ACCIDENT. PHOTOS INCLUDE CLOSE UP SHOTS OF THE WHEEL AND BALL JOINT. I HAVE WRITTEN A LETTER TO DODGE CORPORATION AS I FEEL THEY SHOULD PAY FOR THE REPAIRS SINCE THE PARTS WERE OBVIOUSLY DEFECTIVE. THIS IS ALSO A SERIOUS SAFETY CONCERN AS IF THIS WHEEL HAD FALLEN OFF MY VEHICLE JUST 2 MILES SOONER, I WOULD HAVE BEEN TRAVELING AT 65 MPH COMING DOWN THE HIGHWAY FROM THE ROCKY MOUNTAINS! THE WRECK WOULD HAVE ALMOST CERTAINLY KILLED ME!! THE WRECK WOULD HAVE ALSO TAKEN OUT ANY VEHICLES TRAVELING NEAR ME! THIS IS A VERY SERIOUS SAFETY RISK.
WHILE DRIVING STEERING WHEEL JUMPED ON ITS ON. CONSUMER WAS ABLE TO MAINTAIN CONTROL OF THE VEHICLE, AND TOOK IT TO THE DEALER FOR INSPECTION. MECHANIC DETERMINED THAT THE RACK AND PINION STEERING AND UPPER BALL JOINT NEEDED TO BE REPLACED. *AK
I NOTICED THAT MY DODGE DAKOTA 2000 4 X4 WITH 39,000 MILES WAS PULLING TO THE RIGHT. I TOOK IT IN TO HAVE THE ALIGNMENT ADJUSTED AND WAS TOLD THAT IT COULD NOT BE PERFORMED BECAUSE THE LOWER BALL JOINT ON THE FRONT DRIVER SIDE WAS FAILING. SEEMS TO ME THAT NO PART OF THE BALL JOINT SHOULD BE FAILING AT 39,000 MILES. FROM WHAT …
Read full complaint
I NOTICED THAT MY DODGE DAKOTA 2000 4 X4 WITH 39,000 MILES WAS PULLING TO THE RIGHT. I TOOK IT IN TO HAVE THE ALIGNMENT ADJUSTED AND WAS TOLD THAT IT COULD NOT BE PERFORMED BECAUSE THE LOWER BALL JOINT ON THE FRONT DRIVER SIDE WAS FAILING. SEEMS TO ME THAT NO PART OF THE BALL JOINT SHOULD BE FAILING AT 39,000 MILES. FROM WHAT LITTLE RESEARCH I'VE DONE, THERE SEEMS TO BE A WIDESPREAD PROBLEM WITH DODGE DAKOTA/DURANGO BALL JOINT FAILURES. *JB
HEARD A CLUNKING NOISE FROM FRONT END. VEHICLE ALSO SHAKES WHEN APPLY BRAKES. *BF WHILE DRIVING OVER 65 MPH THE FRONT END OF THE VEHICLE SHOOK AS THOUGH IT WAS MISALIGNED OR UNBALANCED. IT ALSO SHOOK WHEN THE BRAKES WERE APPLIED AT SPEEDS OF 50 MPH OR HIGHER. THE VEHICLE'S WHEELS HAVE BEEN BALANCED, THE STEERING ALIGNED, TH…
Read full complaint
HEARD A CLUNKING NOISE FROM FRONT END. VEHICLE ALSO SHAKES WHEN APPLY BRAKES. *BF WHILE DRIVING OVER 65 MPH THE FRONT END OF THE VEHICLE SHOOK AS THOUGH IT WAS MISALIGNED OR UNBALANCED. IT ALSO SHOOK WHEN THE BRAKES WERE APPLIED AT SPEEDS OF 50 MPH OR HIGHER. THE VEHICLE'S WHEELS HAVE BEEN BALANCED, THE STEERING ALIGNED, THE BRAKES AND ROTORS HAVE BEEN REPLACED YET THE PROBLEM RECURS. *NM
FRONT DRIVER'S SIDE UPPER AND LOWER BALL JOINTS FAILED. *AK
FAILURE OF UPPER BALL JOINT. 2000 DODGE DAKOTA. DISCOVERED DURING A TIRE PURCHASE. HAVING FIXED AT DEALERSHIP. WEAR IS PREMATURE.*AK
I OWN A 2000 DODGE DAKOTA THAT I BOUGHT NEW. IT IS A CLUB CAB 4X4 WITH THE 4.7L V8 AN AUTOMATIC. THE VEHICLE HAS NEVER BEEN OFF ROAD AND HAS JUST TURNED 51,000 MILES. WITHOUT WARNING THE PASS. SIDE UPPER AND LOWER BALL JOINTS BOTH WORE OUT AND NEEDED TO BE REPLACED. THIS OF COURSE WAS NOT COVERED UNDER THE WARRANTY . LUCKILY I …
Read full complaint
I OWN A 2000 DODGE DAKOTA THAT I BOUGHT NEW. IT IS A CLUB CAB 4X4 WITH THE 4.7L V8 AN AUTOMATIC. THE VEHICLE HAS NEVER BEEN OFF ROAD AND HAS JUST TURNED 51,000 MILES. WITHOUT WARNING THE PASS. SIDE UPPER AND LOWER BALL JOINTS BOTH WORE OUT AND NEEDED TO BE REPLACED. THIS OF COURSE WAS NOT COVERED UNDER THE WARRANTY . LUCKILY I CAUGHT THE PROBLEM BEFORE THE WHEEL FELL OFF. I DRIVE APPROX. 90 MILES A DAY ON A MAJOR HIGHWAY AND IF THE WHEEL WOULD HAVE COME OFF IT COULD HAVE CAUSED A MAJOR ACCIDENT. *JB
Official recalls
504V596000 · Suspension:front:control Arm:upper Ball Joint
Dec 21, 2004
ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS EQUIPPED WITH FOUR-WHEEL DRIVE (4X4), IF MOISTURE LEAKS INTO THE FRONT SUSPENSION UPPER BALL JOINT, EVACUATION OF THE LUBRICANT AND CORROSION OF THE JOINT MAY CAUSE THE JOINT TO WEAR OVER AN EXTENDED PERIOD OF TIME. THIS COULD CAUSE A CLUNKING NOISE IN THE FRONT SUSPENSION, WHICH MAY NOT ALWAYS BE HEARD BY THE VEHICLE OCCUPANTS.
Consequence & remedy
Consequence: EXCESSIVE WEAR IN THE UPPER BALL JOINT MAY ALLOW IT TO SEPARATE, WHICH COULD RESULT IN LOSS OF CONTROL OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS. THIS SAFETY IMPROVEMENT CAMPAIGN BEGAN ON DECEMBER 21, 2004. OWNERS CAN CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
01V153000 · Air Bags
May 8, 2001
VEHICLE DESCRIPTION: PICKUP TRUCKS. SOUND DEADENER MATERIAL INSIDE THE STEERING WHEEL COULD BECOME DETACHED FROM THE COVER AND HOUSING. NOTE: THE RAM PICKUP TRUCKS WERE BUILT AT THE WARREN ASSEMBLY PLANT ("S" IN THE 11TH VIN POSITION) FROM MAY 16, 2000 THROUGH OCTOBER 23, 2000; ST. LOUIS NORTH ASSEMBLY PLANT ("J" IN THE 11TH VIN POSITION) FROM MAY 19, 2000 THROUGH OCTOBER 23, 2000; LAGO ALBERTO ASSEMBLY PLANT ("M" IN THE 11TH VIN POSITION) FROM MAY 23, 2000 THROUGH OCTOBER 23, 2000; AND SALTILLO ASSEMBLY PLANT ("G" IN THE 11TH VIN POSITION) FROM MAY 23, 2000 THROUGH OCTOBER 23, 2000. IMPORTANT: VEHICLES THAT HAVE ALREADY HAD THE PROPER CLOCKSPRING INSTALLED, ACCORDING TO WARRANTY RECORDS, HAVE BEEN EXCLUDED FROM THIS RECALL. IN ADDITION, 1997-2000 MODEL YEAR VEHICLES THAT HAVE HAD A SUSPECT REPLACEMENT CLOCKSPRING INSTALLED, ACCORDING TO WARRANTY RECORDS, HAVE BEEN ADDED TO THIS RECALL.
Consequence & remedy
Consequence: WHEN THIS OCCURS, THE MATERIAL COULD INTERFERE WITH THE CLOCKSPRING RIBBON AND CAUSE AN OPEN CIRCUIT. THE DRIVER AIR BAG SYSTEM WILL BECOME DISABLED, AND THE AIR BAG WARNING LAMP WILL ILLUMINATE ON THE INSTRUMENT PANEL.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY. OWNER NOTIFICATION BEGAN JUNE 18, 2001. ALSO SOME 1997-200 MODEL YEAR VEHICLES THAT, ACCORDING TO WARRANTY RECORDS, HAVE HAD A SUSPECT REPLACEMENT CLOCKSPRING INSTALLED, WILL ALSO BE INCLUDED IN THIS CAMPAIGN. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
00V193000 · Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
Jul 17, 2000
VEHICLE DESCRIPTION: PICKUP TRUCKS BUILT WITH 2.5L ENGINES. SOME VEHICLES MAY HAVE BEEN BUILT WITH INADEQUATE CLEARANCE BETWEEN THE LEFT FRONT BRAKE TUBE AND THE POWER STEERING HOSE.
Consequence & remedy
Consequence: A PUNCTURE OF THE LEFT FRONT BRAKE TUBE CAN RESULT IN A LOSS OF BRAKING FORCE AT THE FRONT WHEELS, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE BRAKE TUBE AND POWER STEERING HOSE FOR WEAR. IF WEAR IS EVIDENT, THE BRAKE TUBE AND/OR POWER STEERING HOSE WILL BE REPLACED. A POWER STEERING STANDOFF BRACKET WILL BE INSTALLED ON ALL VEHICLES TO ENSURE THAT ADEQUATE CLEARANCE BETWEEN THE BRAKE TUBE AND POWER STEERING HOSE IS MAINTAINED.
00V197000 · Power Train:automatic Transmission
Jul 17, 2000
VEHICLE DESCRIPTION: PICKUP TRUCKS EQUIPPED WITH 4.7L ENGINE AND AUTOMATIC TRANSMISSIONS. THE AUTOMATIC TRANSMISSION MAY EXPEL FLUID FROM THE FILL TUBE DURING NORMAL TEMPERATURE OPERATION.
Consequence & remedy
Consequence: THE TRANSMISSION FLUID COULD COME INTO CONTACT WITH THE HOT EXHAUST SYSTEM AND IGNITION OF THE TRANSMISSION FLUID COULD RESULT.
Remedy: DEALERS WILL SHORTEN THE VENT HOSE AND ASSURE ADEQUATE CLEARANCE.
00V198000 · Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
Jul 17, 2000
VEHICLE DESCRIPTION: PICKUP TRUCKS. SOME VEHICLES MAY HAVE BEEN BUILT WITH INADEQUATE CLEARANCE BETWEEN THE REAR AXLE VENT HOSE AND THE BRAKE HOSE.
Consequence & remedy
Consequence: A PUNCTURE IN THE REAR BRAKE HOSE WILL RESULT IN A LOSS OF BRAKING FORCE AT THE REAR WHEELS.
Remedy: DEALERS WILL INSPECT THE REAR BRAKE HOSE FOR EVIDENCE OF WEAR. WORN BRAKE HOSES WILL BE REPLACED. THE REAR VENT HOSE WILL BE SHORTENED BY 3 INCHES AND A CLIP WILL BE INSTALLED TO ASSURE CLEARANCE BETWEEN THE AXLE VENT LINE AND BRAKE HOSE IS MAINTAINED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4EA03023 · Upper Ball Joint Separation
Opened Nov 19, 2003 · Closed Feb 11, 2005
Status: closed (inferred from source dates) · Suspension; Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:upper Arm; Suspension:front:control Arm:upper Ball Joint
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (5)
Suspension
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm:upper Arm
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm:upper Ball Joint
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
EA01010 · Front Safety Belt Anchorage
Opened Mar 8, 2001 · Closed Aug 17, 2001
Status: closed (inferred from source dates) · Seat Belts:front:anchorage
ALLEGE THAT THE FRONT SAFETY BELT ANCHOR BOLTS DISENGAGE FROM THEIR MOUNTING POINTS OR ARE FOUND TO BE LOOSE.
PE00035 · Stop Lamp Switch
Opened Sep 7, 2000 · Closed Mar 9, 2001
Status: closed (inferred from source dates) · Electrical System
ALLEGED THAT ELECTRICAL FAILURE OF THE BRAKE STOP LAMP SWITCH MAN RESULT IN STOP LAMPS NOT ILLUMINATION DURING SERVICE BRAKE APPLICATION, AND THE VEHICLE'S CRUISE CONTROL SYSTEM MAY FAIL TO DISENGAGE
PE00030 · Front Safety Belt Anchorage Disengagemen
Opened Jul 21, 2000 · Closed Mar 8, 2001
Status: closed (inferred from source dates) · Seat Belts:front:anchorage
ALLEGED THAT THE DRIVER'S SEAT SAFETY BELT ANCHORS DISENGAGE FROM MOUNTING POINTS