IllustrationPURCHASED THIS 2000 DODGE DAKOTA , ENGINE LIGHT CONSTANTLY ON STATING LARGE LEAK IN EVAP SYSTEM. P0455. FUEL LEAK AT GAS CAP. NO WAY TO FIX THIS, ODOR IS STRONG SMELL THE GAS LEAKING OUT. UNABLE TO PASS NYS INSPECTION! *TR
2000 Dodge Dakota
Owner reports · Recalls · Investigations
More warning signs than most Dakota years
Owner complaints for the 2000 Dodge Dakota are substantially higher than the model-year median of 166.
About this comparison →How this year compares
Owner complaints by model year
Compare all Dakota years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
520–25K
11025–50K
11950–75K
4475–100K
24100–150K
10150K+
359 reports with mileage · 447 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Suspension. Review the 282 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 248 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 74 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
60 crash reports14 fire reports35 injury reports
Fuel System, Gasoline complaints
12 reportsTRUCK FUEL LEAK. 2000 DODGE DAKOTA QUAD CAB PURCHASED NEW DECEMBER 1999; MILEAGE 66,000 + ; EXTENSIVE PREVENTATIVE MAINTENANCE PERFORMED ON VEHICLE, ALSO GARAGED WHEN NOT IN USE; TRUCK IS NOT 4WD AND IS ONLY DRIVEN OVER PAVED ROADS. . STARTED SMELLING FUEL IN GARAGE, THEN COULD SMELL FUEL WHEN TRUCK PARKED IN OPEN, FINALLY CO…
Read full complaint
TRUCK FUEL LEAK. 2000 DODGE DAKOTA QUAD CAB PURCHASED NEW DECEMBER 1999; MILEAGE 66,000 + ; EXTENSIVE PREVENTATIVE MAINTENANCE PERFORMED ON VEHICLE, ALSO GARAGED WHEN NOT IN USE; TRUCK IS NOT 4WD AND IS ONLY DRIVEN OVER PAVED ROADS. . STARTED SMELLING FUEL IN GARAGE, THEN COULD SMELL FUEL WHEN TRUCK PARKED IN OPEN, FINALLY COULD SMELL FUEL WHEN STOPPED AT TRAFFIC LIGHT WITH WINDOWS CLOSED AND AIR / FAN NOT ON RECIRCULATE. WENT TO DEALER, FOUND FUEL DRIPPING FROM VEHICLE TANK. DEALER SAYS IT IS A MOLDED FUEL LINE FROM THE TANK, AND IT IS BEING REPLACED NOW. THIS IS THE SECOND FUEL LEAK IN THIS VEHICLE!! JUST OVER 2 YEARS AGO, THE TRUCK INTERMITTENTLY QUIT WHILE DRIVING,AND IT TOOK 4 VISITS TO 3 DEALERS TO GET THE FUEL PUMP / FILTER DIAGNOSED AS THE PROBLEM. THAT REPAIR LEFT A FUEL LEAK WHICH REQUIRED 2 SUBSEQUENT TRIPS TO DEALER [ AND ONE OTHER REPAIR FACILITY] TO GET REPAIRED. DRIVER / OWNER IS 60+, WITH EXTENSIVE DRIVING EXPERIENCE, HAVING OWNED 3 TRUCKS, AND AT LEAST 10 OVER VEHICLES MANUFACTURED IN THE US, JAPAN, AND GERMANY, AND IS A PILOT BY TRAINING. DRIVER / OWNER HAS NEVER EXPERIENCED A FUEL LEAK IN A PREVIOUS VEHICLE; HE ALSO THINKS THAT HIS EXPECTATIONS ARE NOT OUTRAGEOUS , AND THAT THIS IS A SAFETY ISSUE.*JB
WHEN THE TRUCK IS OFF FOR SEVERAL MINUTES OR MORE, IT TAKES SEVERAL SECONDS FOR THE ENGINE TO START. THIS STARTED WHEN IT WAS ABOUT 5 YRS OLD WITH ABOUT 70,000 MILES ON IT. IT WILL START IMMEDIATELY IF IT HAS JUST BEEN TURNED OFF. I SUSPECT A LOWERING OF GAS LINE PRESSURE WHEN THE ENGINE IS OFF. *NM
AT APPROX. 8K MILES, PULSING AND SHIMMY STARTED IN FRONT END. HAD TO RESURFACE ROTORS. HAD TO DO AGAIN LATER AT ABOUT 35K. NOT NORMAL. AT 15K REPORTED FRONT END CREAKS/GROANS DEALER FOUND NO PROBLEM. AT 35K MORE OF THE SAME, DEALER REPLACED FRONT STABILIZER/SWAY BUSHING. AT 38K MILES, REPLACED LOWER STEERING COLUMN. HELP…
Read full complaint
AT APPROX. 8K MILES, PULSING AND SHIMMY STARTED IN FRONT END. HAD TO RESURFACE ROTORS. HAD TO DO AGAIN LATER AT ABOUT 35K. NOT NORMAL. AT 15K REPORTED FRONT END CREAKS/GROANS DEALER FOUND NO PROBLEM. AT 35K MORE OF THE SAME, DEALER REPLACED FRONT STABILIZER/SWAY BUSHING. AT 38K MILES, REPLACED LOWER STEERING COLUMN. HELPED SOME BUT STILL CREAKING WHEN STEERING AT LOW SPEED. AT 53K ASKED AGAIN ABOUT STEERING GROAN. DEALER SAYS HE COULD FIX FOR ABOUT $1000 (OF COURSE OUT OF WARRANTY NOW! AND I'VE BEEN ASKING ABOUT THIS SINCE 15K MILES). ALSO AT 53K, REPLACED LOWER BALL JOINTS LEFT SIDE AND FUEL PUMP. AT 59K BACK IN THE SHOP TODAY TO REPLACE RIGHT BALL JOINTS WHICH CAUSE VEHICLE STEERING TO "WANDER" AND HAVE BADLY WORN INSIDE RIGHT TIRE. QUALITY OF VEHICLE IS LOUSY AND THEY WON'T ADMIT IT OR STAND BEHIND IT. THE ROTOR AND FRONT END PROBLEMS COULD BE VERY DANGEROUS BECAUSE THEY IMPAIR THE DRIVERS CONTROL OF THE VEHICLE. *JB
CONSUMER STATED THAT WHILE DRIVING THE VEHICLE WOULD ONLY SHIFT TO NEUTRAL. DEALER NOTIFIED. *PH WHEN THE VEHICLE WAS IN 3RD GEAR IT WENT TO NEUTRAL AND THE ENGINE RPM'S INCREASED FOR A SHORT PERIOD OF TIME WHEN THE TRANSMISSION SHOULD HAVE CHANGED TO 4TH GEAR. THE VEHICLE HAD BEEN TO THE SERVICE DEALER 6 TIMES FOR REPA…
Read full complaint
CONSUMER STATED THAT WHILE DRIVING THE VEHICLE WOULD ONLY SHIFT TO NEUTRAL. DEALER NOTIFIED. *PH WHEN THE VEHICLE WAS IN 3RD GEAR IT WENT TO NEUTRAL AND THE ENGINE RPM'S INCREASED FOR A SHORT PERIOD OF TIME WHEN THE TRANSMISSION SHOULD HAVE CHANGED TO 4TH GEAR. THE VEHICLE HAD BEEN TO THE SERVICE DEALER 6 TIMES FOR REPAIRS. THERE WAS A VIBRATION IN THE FRONT OF THE VEHICLE DUE TO WARPED ROTORS. FAULTY WHEEL BEARINGS CAUSED A POPPING NOISE IN THE STEERING WHEN THE CONSUMER MADE LEFT TURNS. *SCC *NLM
UPPER AND LOWER BALL JOINTS HAVE FAILED. 40,000 MILES ON VEHICLE. BALL JOINTS SHOULD LAST MUCH LONGER THAN THIS. DEALER WANTS $1,200.00 TO CHANGE THEM. TRUCK HAS ALREADY HAD NEW FRONT DRIVE SHAFT, NEW SWAY BAR BUSHINGS, NEW DRIVER SEAT CUSHION, NEW FUEL INJECTORS, NEW ELECTRIC MOTOR IN RIGHT REAR WINDOW. WHAT HAS HAPPENED …
Read full complaint
UPPER AND LOWER BALL JOINTS HAVE FAILED. 40,000 MILES ON VEHICLE. BALL JOINTS SHOULD LAST MUCH LONGER THAN THIS. DEALER WANTS $1,200.00 TO CHANGE THEM. TRUCK HAS ALREADY HAD NEW FRONT DRIVE SHAFT, NEW SWAY BAR BUSHINGS, NEW DRIVER SEAT CUSHION, NEW FUEL INJECTORS, NEW ELECTRIC MOTOR IN RIGHT REAR WINDOW. WHAT HAS HAPPENED TO "RAM TOUGH". MAY HAVE TO GO BACK TO "LIKE A ROCK". OLD PICKUP 1979 CHEVROLET NEVER HAD BALL JOINT PROBLEMS, MUCH LESS ANY THING ELSE MAJOR. THANKS RICK WORSFOLD. *NLM
THERE WAS A STRONG GAS SMELL IN CAB WITH ALL WINDOWS CLOSED. I CLOSED THE VENT, BUT IT WAS STILL VERY STRONG AND GETTING WORSE. NO FUEL LEAKS FOUND. THIS HAS OCCURRED 5 TIMES. SEEMS TO BE INTERMITTENT AND NOT DIRECTLY CONNECTED WITH RE/FUELING, OR FUEL TANK LEVEL. I WAS TOLD IT WAS POSSIBLY THE ORVR. SOUNDS LIKE A GOOD COMBINAT…
Read full complaint
THERE WAS A STRONG GAS SMELL IN CAB WITH ALL WINDOWS CLOSED. I CLOSED THE VENT, BUT IT WAS STILL VERY STRONG AND GETTING WORSE. NO FUEL LEAKS FOUND. THIS HAS OCCURRED 5 TIMES. SEEMS TO BE INTERMITTENT AND NOT DIRECTLY CONNECTED WITH RE/FUELING, OR FUEL TANK LEVEL. I WAS TOLD IT WAS POSSIBLY THE ORVR. SOUNDS LIKE A GOOD COMBINATION FOR A EXPLOSION. *JB
NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
BAD ROTORS AFTER 12,000K,DEALER WILL NOT COVER. LOW IDLE AND ENGINE STUDDERING AT 400 RPM AFTER 2 PCM RECALLS FOR REPROGRAMING, DEALER CAN'T FIND PROBLEM WITH IDLE. PROBLEM WITH THE BAFFLES IN THE GAS TANK, YOU CAN FEEL THE FUEL MOVING AROUND WHEN YOU COME TO A STOP AT ABOUT 3/4 FULL TANK. CONDENSATION IN OIL FILLER CAP. SOUNDS …
Read full complaint
BAD ROTORS AFTER 12,000K,DEALER WILL NOT COVER. LOW IDLE AND ENGINE STUDDERING AT 400 RPM AFTER 2 PCM RECALLS FOR REPROGRAMING, DEALER CAN'T FIND PROBLEM WITH IDLE. PROBLEM WITH THE BAFFLES IN THE GAS TANK, YOU CAN FEEL THE FUEL MOVING AROUND WHEN YOU COME TO A STOP AT ABOUT 3/4 FULL TANK. CONDENSATION IN OIL FILLER CAP. SOUNDS LIKE I BOUGHT A 2000 DAKOTA. I'VE FOUND COUNTLESS ENTRIES OF THE SAME COMPLAINTS ON THE INTERNET. NHTS NEED TO GET ON CHRYSLER ABOUT THESE PROBLEMS BEFOR SOMEONE REALLY GETS HURT. SPECIALY THE PROBLEM WITH THE BRAKES.*AK
SUBJECT: DAKOTA EXT. CAB 4X4. W/ 3.9L FUEL INJECTED ENGINE. DAIMLER CHRYSLER LEADS CONSUMERS TO BELIEVE THIS VEHICLE WOULD AVERAGE 18 MILES PER/GAL. HIGHWAY DIVING. I NOW HAVE 5400 MILES ON THIS VEHICLE AND THE BEST HIGHWAY MILEAGE I'M ABLE TO OBTAIN IS 13 MILES/PER GAL. AND ABOUT 10MI./PER GAL. CITY ON AN AVERAGE WINTER …
Read full complaint
SUBJECT: DAKOTA EXT. CAB 4X4. W/ 3.9L FUEL INJECTED ENGINE. DAIMLER CHRYSLER LEADS CONSUMERS TO BELIEVE THIS VEHICLE WOULD AVERAGE 18 MILES PER/GAL. HIGHWAY DIVING. I NOW HAVE 5400 MILES ON THIS VEHICLE AND THE BEST HIGHWAY MILEAGE I'M ABLE TO OBTAIN IS 13 MILES/PER GAL. AND ABOUT 10MI./PER GAL. CITY ON AN AVERAGE WINTER DAY. I'VE HAD THIS TRUCK INSPECTED BY THE DEALER AND THEY FIND NOTHING OUT OF SPECS WITH THE ENGINE OR IGNITION. IS ANYONE OTHER THAN MYSELF EXPERIENCING THIS PROBLEM WITH THERE VEHICLE AND WHY IS DAIMLER CHRYSLER ALLOWED TO USE FALSE DOE-EPA INFORMATION TO MARKET THERE TRUCKS? I WOULD BE VERY INTERESTED TO HEAR YOUR COMMENTS ON THIS SUBJECT.*AK
Official recalls
504V596000 · Suspension:front:control Arm:upper Ball Joint
Dec 21, 2004
ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS EQUIPPED WITH FOUR-WHEEL DRIVE (4X4), IF MOISTURE LEAKS INTO THE FRONT SUSPENSION UPPER BALL JOINT, EVACUATION OF THE LUBRICANT AND CORROSION OF THE JOINT MAY CAUSE THE JOINT TO WEAR OVER AN EXTENDED PERIOD OF TIME. THIS COULD CAUSE A CLUNKING NOISE IN THE FRONT SUSPENSION, WHICH MAY NOT ALWAYS BE HEARD BY THE VEHICLE OCCUPANTS.
Consequence & remedy
Consequence: EXCESSIVE WEAR IN THE UPPER BALL JOINT MAY ALLOW IT TO SEPARATE, WHICH COULD RESULT IN LOSS OF CONTROL OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS. THIS SAFETY IMPROVEMENT CAMPAIGN BEGAN ON DECEMBER 21, 2004. OWNERS CAN CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
01V153000 · Air Bags
May 8, 2001
VEHICLE DESCRIPTION: PICKUP TRUCKS. SOUND DEADENER MATERIAL INSIDE THE STEERING WHEEL COULD BECOME DETACHED FROM THE COVER AND HOUSING. NOTE: THE RAM PICKUP TRUCKS WERE BUILT AT THE WARREN ASSEMBLY PLANT ("S" IN THE 11TH VIN POSITION) FROM MAY 16, 2000 THROUGH OCTOBER 23, 2000; ST. LOUIS NORTH ASSEMBLY PLANT ("J" IN THE 11TH VIN POSITION) FROM MAY 19, 2000 THROUGH OCTOBER 23, 2000; LAGO ALBERTO ASSEMBLY PLANT ("M" IN THE 11TH VIN POSITION) FROM MAY 23, 2000 THROUGH OCTOBER 23, 2000; AND SALTILLO ASSEMBLY PLANT ("G" IN THE 11TH VIN POSITION) FROM MAY 23, 2000 THROUGH OCTOBER 23, 2000. IMPORTANT: VEHICLES THAT HAVE ALREADY HAD THE PROPER CLOCKSPRING INSTALLED, ACCORDING TO WARRANTY RECORDS, HAVE BEEN EXCLUDED FROM THIS RECALL. IN ADDITION, 1997-2000 MODEL YEAR VEHICLES THAT HAVE HAD A SUSPECT REPLACEMENT CLOCKSPRING INSTALLED, ACCORDING TO WARRANTY RECORDS, HAVE BEEN ADDED TO THIS RECALL.
Consequence & remedy
Consequence: WHEN THIS OCCURS, THE MATERIAL COULD INTERFERE WITH THE CLOCKSPRING RIBBON AND CAUSE AN OPEN CIRCUIT. THE DRIVER AIR BAG SYSTEM WILL BECOME DISABLED, AND THE AIR BAG WARNING LAMP WILL ILLUMINATE ON THE INSTRUMENT PANEL.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY. OWNER NOTIFICATION BEGAN JUNE 18, 2001. ALSO SOME 1997-200 MODEL YEAR VEHICLES THAT, ACCORDING TO WARRANTY RECORDS, HAVE HAD A SUSPECT REPLACEMENT CLOCKSPRING INSTALLED, WILL ALSO BE INCLUDED IN THIS CAMPAIGN. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
00V193000 · Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
Jul 17, 2000
VEHICLE DESCRIPTION: PICKUP TRUCKS BUILT WITH 2.5L ENGINES. SOME VEHICLES MAY HAVE BEEN BUILT WITH INADEQUATE CLEARANCE BETWEEN THE LEFT FRONT BRAKE TUBE AND THE POWER STEERING HOSE.
Consequence & remedy
Consequence: A PUNCTURE OF THE LEFT FRONT BRAKE TUBE CAN RESULT IN A LOSS OF BRAKING FORCE AT THE FRONT WHEELS, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE BRAKE TUBE AND POWER STEERING HOSE FOR WEAR. IF WEAR IS EVIDENT, THE BRAKE TUBE AND/OR POWER STEERING HOSE WILL BE REPLACED. A POWER STEERING STANDOFF BRACKET WILL BE INSTALLED ON ALL VEHICLES TO ENSURE THAT ADEQUATE CLEARANCE BETWEEN THE BRAKE TUBE AND POWER STEERING HOSE IS MAINTAINED.
00V197000 · Power Train:automatic Transmission
Jul 17, 2000
VEHICLE DESCRIPTION: PICKUP TRUCKS EQUIPPED WITH 4.7L ENGINE AND AUTOMATIC TRANSMISSIONS. THE AUTOMATIC TRANSMISSION MAY EXPEL FLUID FROM THE FILL TUBE DURING NORMAL TEMPERATURE OPERATION.
Consequence & remedy
Consequence: THE TRANSMISSION FLUID COULD COME INTO CONTACT WITH THE HOT EXHAUST SYSTEM AND IGNITION OF THE TRANSMISSION FLUID COULD RESULT.
Remedy: DEALERS WILL SHORTEN THE VENT HOSE AND ASSURE ADEQUATE CLEARANCE.
00V198000 · Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
Jul 17, 2000
VEHICLE DESCRIPTION: PICKUP TRUCKS. SOME VEHICLES MAY HAVE BEEN BUILT WITH INADEQUATE CLEARANCE BETWEEN THE REAR AXLE VENT HOSE AND THE BRAKE HOSE.
Consequence & remedy
Consequence: A PUNCTURE IN THE REAR BRAKE HOSE WILL RESULT IN A LOSS OF BRAKING FORCE AT THE REAR WHEELS.
Remedy: DEALERS WILL INSPECT THE REAR BRAKE HOSE FOR EVIDENCE OF WEAR. WORN BRAKE HOSES WILL BE REPLACED. THE REAR VENT HOSE WILL BE SHORTENED BY 3 INCHES AND A CLIP WILL BE INSTALLED TO ASSURE CLEARANCE BETWEEN THE AXLE VENT LINE AND BRAKE HOSE IS MAINTAINED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4EA03023 · Upper Ball Joint Separation
Opened Nov 19, 2003 · Closed Feb 11, 2005
Status: closed (inferred from source dates) · Suspension; Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:upper Arm; Suspension:front:control Arm:upper Ball Joint
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (5)
Suspension
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm:upper Arm
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm:upper Ball Joint
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
EA01010 · Front Safety Belt Anchorage
Opened Mar 8, 2001 · Closed Aug 17, 2001
Status: closed (inferred from source dates) · Seat Belts:front:anchorage
ALLEGE THAT THE FRONT SAFETY BELT ANCHOR BOLTS DISENGAGE FROM THEIR MOUNTING POINTS OR ARE FOUND TO BE LOOSE.
PE00035 · Stop Lamp Switch
Opened Sep 7, 2000 · Closed Mar 9, 2001
Status: closed (inferred from source dates) · Electrical System
ALLEGED THAT ELECTRICAL FAILURE OF THE BRAKE STOP LAMP SWITCH MAN RESULT IN STOP LAMPS NOT ILLUMINATION DURING SERVICE BRAKE APPLICATION, AND THE VEHICLE'S CRUISE CONTROL SYSTEM MAY FAIL TO DISENGAGE
PE00030 · Front Safety Belt Anchorage Disengagemen
Opened Jul 21, 2000 · Closed Mar 8, 2001
Status: closed (inferred from source dates) · Seat Belts:front:anchorage
ALLEGED THAT THE DRIVER'S SEAT SAFETY BELT ANCHORS DISENGAGE FROM MOUNTING POINTS