NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
695 reportsMileage unknown · Jul 18, 2019
Air BagsSteeringWheels
PASSENGER AIR BAG LIGHT COMES ON AND STAYS ILLUMINATED IN DASH, TIRE PRESSURE LIGHT COMES ON AND GOES OFF OFTEN WHEN DRIVING AND WHEN I PURCHASED THE VEHICLE A SENSOR WAS REPLACED AND SINCE I PURCHASED THE VEHICLE IN 2016 THE CAR HAS BEEN HARD TO STEER. THE CARS STEERING IS STILL HARD TO STEER WHEN MAKING TURNS. IT ACTS AS IF IT…
Read full complaint
PASSENGER AIR BAG LIGHT COMES ON AND STAYS ILLUMINATED IN DASH, TIRE PRESSURE LIGHT COMES ON AND GOES OFF OFTEN WHEN DRIVING AND WHEN I PURCHASED THE VEHICLE A SENSOR WAS REPLACED AND SINCE I PURCHASED THE VEHICLE IN 2016 THE CAR HAS BEEN HARD TO STEER. THE CARS STEERING IS STILL HARD TO STEER WHEN MAKING TURNS. IT ACTS AS IF IT IS GOING TO LOCK UP
NHTSA ODI #11232974
64,000 miles · Jul 14, 2019
Fuel/propulsion System
I SMELLED THE STRONG ODOR OF GASOLINE INSIDE MY CHARGER. I BROUGHT IT TO THE DEALERSHIP WHO ADVISED THAT THE VEHICLE WAS LEAKING GAS FROM AROUND THE O RING AT THE FUEL PUMP WHICH IS LOCATED UNDER THE REAR PASSENGER SEAT. THE MECHANIC TIGHTENED THE COVER TO THE FUEL PUMP AND RETURNED THE VEHICLE. ABOUT A MONTH LATER THE VEHICLE…
Read full complaint
I SMELLED THE STRONG ODOR OF GASOLINE INSIDE MY CHARGER. I BROUGHT IT TO THE DEALERSHIP WHO ADVISED THAT THE VEHICLE WAS LEAKING GAS FROM AROUND THE O RING AT THE FUEL PUMP WHICH IS LOCATED UNDER THE REAR PASSENGER SEAT. THE MECHANIC TIGHTENED THE COVER TO THE FUEL PUMP AND RETURNED THE VEHICLE. ABOUT A MONTH LATER THE VEHICLE WAS NOW VISIBLY LEAKING GAS FONTO THE GROUND AND THE FUEL SMELL INSIDE THE VEHICLE WAS INTOLERABLE. I RETURNED TO THE DEALER AND LEFT IT WITH THEM FOR A DAY IN WHICH TIME THEY REPLACED THE RING, TESTED IT AND FOUND NO FURTHER LEAKAGE AND RETURNED THE VEHICLE TO ME. BY THE NEXT MORNING THE VEHICLE WAS LEAKING AGAIN, THIS TIME MUCH WORSE. I HAD TO PARK IT AWAY FROM THE HOUSE FOR FEAR THAT IT MIGHT CAUSE AN EXPLOSION WHEN IF LEFT IN THE HOT GARAGE WITH THE FUMES FILLING UP THE GARAGE. I SEE THAT THERE HAVE BEEN 71 COMPLAINTS FILED WITH NHTSA. THIS IS TRULY A DANGEROUS DEFECT AND SHOULD BE RECALLED BEFORE SOMEONE GETS KILLED. I JUST HAD MY DAUGHTER AND GRAND KIDS IN THE CAR WITH SOME OF THE GRAND KIDS SITTING OVER THE FUEL PUMP LOCATED UNDER THE SEAT. WHO IN THERE RIGHT MIND WOULD PUT FUEL PUMPS UNDER THE REAR SEAT. THE PROBLEM SEEMS TO OCCUR WHEN THE VEHICLE'S FUEL TANK IS FULL. WHEN I MOVED IT AWAY FROM THE HOUSE IT LEFT A TRAIL OF GASOLINE TO WHERE I PARKED IT AND BY THE NEXT MORNING THERE WAS A HUGE SPOT ON THE GROUND AND THE CAR WAS FULL OF FUMES. THIS IS A SAFETY HAZARD IF THERE EVERY WAS ONE.
NHTSA ODI #11231818
Mileage unknown · May 18, 2019
Electrical System
WE HAD RECALL P08 HEADLAMP WIRING PERFORMED ON 2/22/15 AT PALMEN DODGE IN RACINE WI. 2 MONTHS LATER WE MOVED TO ARIZONA. WITHIN 6 MONTHS AFTER THIS RECALL WAS ADDRESSED WE CONTINUED TO HAVE HEADLIGHTS GO OUT. AFTER A COUPLE OF TIMES I STARTED KEEPING RECEIPTS. APPROX. EVERY 6 MONTHS WE HAD TO REPLACE OUR HEADLIGHTS (SOMETIME…
Read full complaint
WE HAD RECALL P08 HEADLAMP WIRING PERFORMED ON 2/22/15 AT PALMEN DODGE IN RACINE WI. 2 MONTHS LATER WE MOVED TO ARIZONA. WITHIN 6 MONTHS AFTER THIS RECALL WAS ADDRESSED WE CONTINUED TO HAVE HEADLIGHTS GO OUT. AFTER A COUPLE OF TIMES I STARTED KEEPING RECEIPTS. APPROX. EVERY 6 MONTHS WE HAD TO REPLACE OUR HEADLIGHTS (SOMETIMES 1, SOMETIMES BOTH). WE FINALLY HAD A DEALERSHIP BUILT NEAR OUR HOUSE THIS YEAR (RODEO DODGE- SAN TAN VALLEY AZ) SO WE WERE ABLE TO TAKE IT IN WITHOUT TOO MUCH INCONVENIENCE- WE ONLY HAVE 1 CAR & NO RENTAL WAS OFFERED. THE IDENTIFIED THE ISSUE WAS A HEADLAMP HARNESS AND NEEDED TO REPLACE IT. THE COST FOR THIS WORK WAS $729.77. THEY ADVISED THAT IT WASN'T COVERED UNDER THE PREVIOUS RECALL. HOWEVER WHEN READING THE P08 RECALL IT DOES INDICATE "YOUR DEALER WILL REPLACE THE HEADLAMP HARNESSES AND REPLACE THEM IF REQUIRED". IT SEEMS OBVIOUS TO ME THAT THERE WAS A HARNESS OVERLOOKED WHEN THE RECALL WAS ADDRESSED IN 2015 THAT CAUSED US TO CONTINUALLY REPLACE HEADLAMPS EVERY 6 MONTHS. I HAVE RECEIPTS FROM THESE HEADLAMPS FROM: FEB 2017, DEC 2017, MAY 2018. THERE WERE A COUPLE ADDITIONAL TIMES BETWEEN MAR 2016 AND FEB 2017 THAT I DID NOT THINK TO KEEP RECEIPTS. I FINALLY HAD THE ISSUE ADDRESSED WHEN BOTH HEADLAMPS WENT OUT IN DEC 2018. SERVICE WASN'T COMPLETED UNTIL 3/5/19 AS IT WAS DIFFICULT FOR US TO BE WITHOUT A CAR FOR THE LENGTH OF TIME WE KNEW IT WOULD TAKE TO HAVE FIXED. I AM ASKING FOR REIMBURSEMENT FROM DODGE IN THE AMOUNT OF $971.37 TO COVER THE WORK DONE TO REPLACE THE HARNESSES AND REIMBURSEMENT FOR THE HEADLIGHTS I NEEDED TO HAVE REPLACED OVER TIME (ONLY THE ONES I HAVE RECEIPTS FOR). SEE ATTACHED. WE WILL BE PURCHASING ANOTHER CAR IN THE NEXT 6-12 MONTHS AND THIS WOULD GO A LONG WAY IN BUILDING MY CONFIDENCE IN DODGE PRODUCTS/SERVICE.
NHTSA ODI #11208420
100,000 miles · May 8, 2019
Engine
TL* THE CONTACT OWNS A 2011 DODGE CHARGER. WHILE DRIVING APPROXIMATELY 30 MPH, THE VEHICLE SUDDENLY STALLED AND THE VEHICLE WAS TOWED TO THE CONTACT'S HOME. AN INDEPENDENT MECHANIC EXAMINED THE VEHICLE AND DIAGNOSED THAT THE ENGINE HEAD GASKET FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE DEALER AND MANUFAC…
Read full complaint
TL* THE CONTACT OWNS A 2011 DODGE CHARGER. WHILE DRIVING APPROXIMATELY 30 MPH, THE VEHICLE SUDDENLY STALLED AND THE VEHICLE WAS TOWED TO THE CONTACT'S HOME. AN INDEPENDENT MECHANIC EXAMINED THE VEHICLE AND DIAGNOSED THAT THE ENGINE HEAD GASKET FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 100,000.
NHTSA ODI #11206279
151,544 miles · May 2, 2019
Electronic Stability Control (esc)Vehicle Speed Control
MY ABS AND STABILITY CONTROL LIGHTS COME ON BUT THEY GO OFF. BUT WHEN DRIVING THEY COME ON SUDDENLY I DONT HAVE BRAKES FOR SEVERAL CRUCIAL SECONDS WHEN ATTEMPTING TO STOP. THEN THE LIGHTS GO OFF AGAIN.
NHTSA ODI #11205214
54,000 miles · Apr 8, 2019
Exterior Lighting
MY VEHICLE IS HAVING ALL OF THE PROBLEMS ASSOCIATED WITH THE P08 RECALL. MY LOW BEAM HEADLIGHTS INTERMITTENTLY GO OUT WHILE DRIVING AT NIGHT. COMPLETELY DANGEROUS FOR ME TO DRIVE THIS WAY. FACTORY SAYS MY VEHICLE VIN IS NOT PART OF THE RECALL. I BELIEVE THAT YOU CLEARLY MISSED DIAGNOSED WHAT VEHICLES WERE EFFECTED AS MINE IS. PL…
Read full complaint
MY VEHICLE IS HAVING ALL OF THE PROBLEMS ASSOCIATED WITH THE P08 RECALL. MY LOW BEAM HEADLIGHTS INTERMITTENTLY GO OUT WHILE DRIVING AT NIGHT. COMPLETELY DANGEROUS FOR ME TO DRIVE THIS WAY. FACTORY SAYS MY VEHICLE VIN IS NOT PART OF THE RECALL. I BELIEVE THAT YOU CLEARLY MISSED DIAGNOSED WHAT VEHICLES WERE EFFECTED AS MINE IS. PLEASE HELP!
NHTSA ODI #11194579
54,000 miles · Apr 2, 2019
EngineCrashInjury
I GAVE THE CAR FUEL THROTTLE AND IT STALLED THEN DIED ON THE FREEWAY. AFTER BEING STRUCK BY ANOTHER CAR FROM BEHIND, THE CAR STARTED FINE AND STILL RUNS PERFECT. NO CHECK ENGINE LIGHT. MY RESEARCH SUGGEST THE PCM ON THESE CARS ARE FAULTY.
NHTSA ODI #11193431
108,000 miles · Mar 23, 2019
Exterior Lighting
WHEN I START THE VEHICLE, THE LOW BEAMS WORK NORMALLY. WITHIN FIVE MINUTES OF LIGHTS BEING ON, WHETHER IDLE OR DURING DRIVING, THEY WILL TURN OFF ON THERE OWN. I AM THEN FORCED TO USE HIGH BEAMS IN ORDER TO HAVE LIGHTING AT NIGHT.
NHTSA ODI #11191038
56,000 miles · Mar 11, 2019
Electrical SystemUnknown Or Other
AT FIRST I WAS UNABLE TO CALL OUT THROUGH MY CARS BLUETOOTH, BUT IF I USED MY PHONE TO CALL OUT I COULD HEAR AND SPEAK THROUGH MY CAR. HOWEVER THIS DID NOT LAST LONG SINCE THE SPEAKERS QUIT WORKING. A LOUD CLICKING STARTED IN MY DASH. THE RADIO TURNS ON BUT NO SOUND. WHEN THIS HAPPENED I COULD NOT START MY CAR AFTER GOGGLING T…
Read full complaint
AT FIRST I WAS UNABLE TO CALL OUT THROUGH MY CARS BLUETOOTH, BUT IF I USED MY PHONE TO CALL OUT I COULD HEAR AND SPEAK THROUGH MY CAR. HOWEVER THIS DID NOT LAST LONG SINCE THE SPEAKERS QUIT WORKING. A LOUD CLICKING STARTED IN MY DASH. THE RADIO TURNS ON BUT NO SOUND. WHEN THIS HAPPENED I COULD NOT START MY CAR AFTER GOGGLING THE ISSUE I FOUND THAT OTHERS HAD THE SAME ISSUE AND SAID THAT IF YOU TAKE THE REMOTE ITSELF TO PUSH THE START BUTTON THEIR CAR STARTED. I TRIED THIS AND AT THIS TIME MY CAR WILL START THIS WAY. ALSO MY TRUNK JUST OPENS ON IT'S OWN. THIS HAPPENS CONSTANTLY. I CALLED DEALERSHIP ABOUT IT AND THEY SAID IT WAS NOT A RECALL. I'M A DISABLED PERSON, AND I NEED MY CAR TO GET TO AND FROM DOCTOR APPOINTMENTS. I DO NOT HAVE A LOT OF MONEY AND CAN NOT AFFORD TO PAY TO GET THESE ISSUES FIXED. I FEEL THAT SINCE THERE HAS BEEN SO MANY OTHER PEOPLE W OATH THE SAME ISSUES THAT THESE THINGS SHOULD BE RECALLED AND CUSTOMERS HAVE THEIR VEHICLES TAKEN CARE OF. THANK YOU FOR YOUR TIME. DONNA [XXX] THESE THINGS HAPPENED OVER TIME SO I HAVE NO CERTAIN DATES. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).' *PM
NHTSA ODI #11185876
Mileage unknown · Mar 7, 2019
Air BagsElectrical SystemStructure
TL* TAKATA RECALL. THE CONTACT OWNS A 2011 DODGE CHARGER. THE CONTACT STATED THAT WITHIN LESS THAN A WEEK OF OWNING THE VEHICLE, THE STARTER BURNED OUT. THE PART WAS ORDERED AND REPLACED FROM THE MANUFACTURER FOR THE ALTERNATOR ASSEMBLY; HOWEVER, THE FAILURE RECURRED. THE CONTACT WAS UNABLE TO DRIVE THE VEHICLE FOR MONTHS. A DEA…
Read full complaint
TL* TAKATA RECALL. THE CONTACT OWNS A 2011 DODGE CHARGER. THE CONTACT STATED THAT WITHIN LESS THAN A WEEK OF OWNING THE VEHICLE, THE STARTER BURNED OUT. THE PART WAS ORDERED AND REPLACED FROM THE MANUFACTURER FOR THE ALTERNATOR ASSEMBLY; HOWEVER, THE FAILURE RECURRED. THE CONTACT WAS UNABLE TO DRIVE THE VEHICLE FOR MONTHS. A DEALER WAS NOT CONTACTED. THE PLACE WHERE THE VEHICLE WAS PURCHASED MADE NO MENTION OF THE THREE RECALLS PERTAINING TO THE VIN. THE CONTACT HAD NOT BEEN NOTIFIED OF NHTSA CAMPAIGN NUMBERS: 19V018000 (AIR BAGS), 16V043000 (STRUCTRE), AND 17V435000 (ELECTRICAL SYSTEM). THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS NOT AVAILABLE.
NHTSA ODI #11184883
Official recalls
11Jan 15, 2019
Chrysler (FCA US LLC) is recalling certain 2010 Dodge Ram 3500, Ram 4500/5500, 2010-2011 Dodge Dakota, 2010-2014 Dodge Challenger, 2010-2015 Dodge Challenger, Chrysler 300, and 2010-2016 Jeep Wrangler vehicles. Upon deployment of the driver's frontal air bag, excessive internal pressure may cause the inflator to explode.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the passenger's frontal air bag, the inflator could explode with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicle until the recall repair is complete. Chrysler will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. The recall began February 4, 2019. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is V01.
Jan 9, 2018
Chrysler (FCA US LLC) is recalling certain 2009-2013 Jeep Wrangler, Chrysler 300, Dodge Challenger and Dodge Charger vehicles, and 2009-2011 Dodge Dakota vehicles sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." Additionally, Chrysler is recalling certain 2009-2010 RAM 4500 Cab Chassis, RAM 5500 Cab Chassis, RAM 3500 Cab Chassis, Jeep Wrangler, Chrysler 300, Dodge Dakota, Dodge Challenger, and Dodge Charger vehicles ever registered in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." Chrysler is also recalling certain 2009 RAM 3500, RAM 2500, RAM 4500 Cab Chassis, RAM 5500 Cab Chassis, Dodge Durango, Chrysler Aspen, RAM 3500 Cab Chassis, Jeep Wrangler, Chrysler 300, Dodge Dakota, Dodge Challenger, and Dodge Charger vehicles ever registered in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming. In the event of a crash necessitating deployment of the passenger frontal air bag, these passenger air bag inflator may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicle until the recall repair is complete. Chrysler will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. The recall began February 28, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U03.
Jul 10, 2017
Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Dodge Challenger, Dodge Charger, Chrysler 300, Dodge Durango, and 2012-2014 Jeep Grand Cherokee vehicles. The affected vehicles have electro-hydraulic power steering (EHPS) and are equipped with a 5.7L or a 3.6L engine and a 160, 180 or 220 amp alternator. In the affected vehicles, the alternator may suddenly fail.
Consequence & remedy
Consequence: If the alternator fails, the vehicle may stall without warning, increasing the risk of a crash. There is also the possibility that the alternator may short circuit, increasing the risk of a fire.
Remedy: Chrysler will notify owners, and dealers will inspect the alternator and depending on the part number, will replace the alternator, if necessary, free of charge. The recall began February 12, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is T36.
May 24, 2016
Chrysler (FCA US LLC) expanded the affected population to include 73,712 2005-2009 RAM 2500 trucks produced at the St. Louis North Assembly Plant. With this change, Chrysler is recalling certain model year 2004-2008 RAM 1500, 2005-2009 RAM 2500, 2006-2009 RAM 3500, 2007-2010 RAM 3500 Cab Chassis, 2008-2010 RAM 4500 and 5500 Cab Chassis, 2004-2009 Dodge Durango, 2007-2009 Chrysler Aspen, 2007-2012 Jeep Wrangler, 2008-2012 Dodge Challenger, 2005-2008 Dodge Magnum, 2005-2012 Chrysler 300, 2006-2012 Dodge Charger, 2005-2011 Dodge Dakota, and 2006-2009 Mitsubishi Raider vehicles originally sold, or ever registered, in AL, CA, FL, GA, HI, LA, MS, SC, TX, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Chrysler is also recalling 2004-2008 RAM 1500, 2005-2009 RAM 2500, 2006-2009 RAM 3500, 2007-2009 RAM 3500 Cab Chassis, 2008-2009 RAM 4500 and 5500 Cab Chassis, 2004-2009 Dodge Durango, 2007-2009 Chrysler Aspen, 2007-2009 Jeep Wrangler, 2008-2009 Dodge Challenger, 2005-2008 Dodge Magnum, 2005-2009 Chrysler 300, 2006-2009 Dodge Charger, 2005-2009 Dodge Dakota and 2006-2009 Mitsubishi Raider vehicles originally sold, or ever registered, in AZ, AR, DE, Washington D.C., IL, IN, KS, KY, MD, MO, NE, NV, NJ, NM, NC, OH, OK, PA, TN, VA, and WV, or "Zone B." Lastly, unless included in "Zone A" or "Zone B" above, Chrysler is recalling certain 2005-2008 RAM 2500, 2006-2008 RAM 3500, 2007-2008 RAM 3500 Cab Chassis, 2008 RAM 4500 and 5500 Cab Chassis, 2004-2008 Dodge Durango, 2007-2008 Chrysler Aspen, 2007-2008 Jeep Wrangler, 2008 Dodge Challenger, 2005-2008 Dodge Magnum, 2005-2008 Chrysler 300, 2006-2008 Dodge Charger, 2005-2008 Dodge Dakota, and 2006-2008 Mitsubishi Raider vehicles originally sold, or registered, in AK, CO, CT, ID, IA, ME, MA, MI, MN, MT, NH, NY, ND, OR, RI, SD, UT, VT, WA, WI, and WY.
Consequence & remedy
Consequence: These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. These inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling. An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicle until the recall repair is complete. Chrysler will notify the Chrysler, Dodge, Jeep and RAM owners. Mitsubishi owners will be notified by their company. Dealers will replace the passenger frontal air bag inflator, free of charge. The recall began on March 27, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S43. Note: This recall supersedes recall 14V-7700.
Jan 28, 2016
FCA US LLC (Chrysler) is recalling certain model year 2011-2016 Dodge Charger vehicles manufactured August 23, 2010, to January 7, 2016. When an affected vehicle is lifted using the supplied tire jack without chocking the wheels, the vehicle's body-side sill may give causing the tire jack to fail and the car to fall.
Consequence & remedy
Consequence: A car that falls unexpectedly increases the risk of injury.
Remedy: Chrysler will notify owners, and dealers will provide owners with wheel chocks and instructions for their use, free of charge. The recall began on March 21, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S03.
Jul 27, 2015
Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Dodge Charger vehicles manufactured May 6, 2010, to June 5, 2014. In the affected vehicles, the side impact sensor calibrations may be overly sensitive, and as a result, the side air bag inflatable curtains and seat air bags may unexpectedly deploy and the seat belt pre-tensioners may activate.
Consequence & remedy
Consequence: Air bags that unexpectedly deploy increase the risk of a crash or injury.
Remedy: Chrysler will notify owners, and dealers will update the Occupant Restraint Control module calibration, free of charge. The recall began on August 25, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R35.
Additional source detail variants (2)
Seat Belts
Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Dodge Charger vehicles manufactured May 6, 2010, to June 5, 2014. In the affected vehicles, the side impact sensor calibrations may be overly sensitive, and as a result, the side air bag inflatable curtains and seat air bags may unexpectedly deploy and the seat belt pre-tensioners may activate.
Consequence: Air bags that unexpectedly deploy increase the risk of a crash or injury.
Remedy: Chrysler will notify owners, and dealers will update the Occupant Restraint Control module calibration, free of charge. The recall began on August 25, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R35.
Air Bags:side/window
Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Dodge Charger vehicles manufactured May 6, 2010, to June 5, 2014. In the affected vehicles, the side impact sensor calibrations may be overly sensitive, and as a result, the side air bag inflatable curtains and seat air bags may unexpectedly deploy and the seat belt pre-tensioners may activate.
Consequence: Air bags that unexpectedly deploy increase the risk of a crash or injury.
Remedy: Chrysler will notify owners, and dealers will update the Occupant Restraint Control module calibration, free of charge. The recall began on August 25, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R35.
Oct 8, 2014
Chrysler Group LLC (Chrysler) is recalling certain model year 2011-2014 Chrysler 300, Dodge Charger, Challenger, and Durango; and 2012-2014 Jeep Grand Cherokee vehicles manufactured April 22, 2010, to January 2, 2014, and equipped with a 3.6L engine and a 160 amp alternator. In the affected vehicles, the alternator may suddenly fail.
Consequence & remedy
Consequence: If the alternator fails, the vehicle may stall without warning, increasing the risk of a crash.
Remedy: Chrysler has notified owners, and dealers will replace the alternator, free of charge. The recall began on February 27, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P60.
Mar 4, 2014
Chrysler Group LLC (Chrysler) is recalling certain model year 2011-2012 Dodge Charger vehicles manufactured May 20, 2010, through November 8, 2011, and equipped with halogen headlamps. In the affected vehicles, a sub-harness for the headlights may overheat and cause the low beam headlights to go out.
Consequence & remedy
Consequence: Loss of headlights reduces the driver's visibility, increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the headlamp jumper harnesses and bulbs, or the headlamp assemblies, as necessary, free of charge. The recall began on May 2, 2014. Owners may contract Chrysler at 1-800-853-1403. Chrysler's number associated with this recall is P08. This recall concerns non-police vehicles. A separate campaign was launched in 2012 to address police vehicles. See NHTSA recall 12V-042.
Apr 3, 2013
Chrysler Group LLC (Chrysler) is recalling certain model year 2011-2012 Chrysler 300, Dodge Challenger, and Dodge Charger vehicles manufactured April 11, 2011, through December 14, 2011. The affected vehicles may have improperly sized terminal crimps on the seat side-airbag wiring harness which may cause the seat side-airbags to malfunction and illuminate the airbag warning light.
Consequence & remedy
Consequence: In the event of a crash necessitating airbag deployment the airbags may not operate as designed, increasing the risk of injury.
Remedy: Chrysler will notify owners, and dealers will replace both driver and passenger seat airbag wiring harnesses, free of charge. The recall began on April 22, 2013. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign number is N07.
May 2, 2012
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2011 AND 2012 300 AND DODGE CHARGER VEHICLES. THESE VEHICLES MAY LOSE ABS/ESC SYSTEM FUNCTION DUE TO AN OVERHEATED POWER DISTRIBUTION CENTER.
Consequence & remedy
Consequence: THIS COULD LEAD TO LOSS OF VEHICLE CONTROL, INCREASING THE RISK OF A CRASH.
Remedy: CHRYSLER WILL NOTIFY OWNERS, AND DEALERS WILL RELOCATE THE ABS/ESC SYSTEM FUSE, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 18, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Additional source detail variants (2)
Electrical System:wiring:fuses And Circuit Breakers
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2011 AND 2012 300 AND DODGE CHARGER VEHICLES. THESE VEHICLES MAY LOSE ABS/ESC SYSTEM FUNCTION DUE TO AN OVERHEATED POWER DISTRIBUTION CENTER.
Consequence: THIS COULD LEAD TO LOSS OF VEHICLE CONTROL, INCREASING THE RISK OF A CRASH.
Remedy: CHRYSLER WILL NOTIFY OWNERS, AND DEALERS WILL RELOCATE THE ABS/ESC SYSTEM FUSE, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 18, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Service Brakes, Air:antilock:control Unit/module
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2011 AND 2012 300 AND DODGE CHARGER VEHICLES. THESE VEHICLES MAY LOSE ABS/ESC SYSTEM FUNCTION DUE TO AN OVERHEATED POWER DISTRIBUTION CENTER.
Consequence: THIS COULD LEAD TO LOSS OF VEHICLE CONTROL, INCREASING THE RISK OF A CRASH.
Remedy: CHRYSLER WILL NOTIFY OWNERS, AND DEALERS WILL RELOCATE THE ABS/ESC SYSTEM FUSE, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 18, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Feb 7, 2012
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2011 and 2012 DODGE CHARGER POLICE VEHICLES. THE LOW BEAM HEADLAMPS OF SOME VEHICLES COULD FAIL DUE TO AN OVERHEATED BULB HARNESS CONNECTOR. OTHER VEHICLES MAY LOSE ABS/ESC SYSTEM FUNCTION DUE TO AN OVERHEATED POWER DISTRIBUTION CENTER.
Consequence & remedy
Consequence: THIS COULD LEAD TO LOSS OF VISIBILITY AND/OR BRAKING ABILITY, INCREASING THE RISK OF A CRASH.
Remedy: CHRYSLER WILL NOTIFY OWNERS AND DEALERS WILL REPLACE THE HEADLAMP JUMPER HARNESSES AND RELOCATE THE ABS/ESC SYSTEM FUSE WITHIN THE POWER DISTRIBUTION CENTER, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 2, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Additional source detail variants (4)
Electrical System:wiring:fuses And Circuit Breakers
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2011 and 2012 DODGE CHARGER POLICE VEHICLES. THE LOW BEAM HEADLAMPS OF SOME VEHICLES COULD FAIL DUE TO AN OVERHEATED BULB HARNESS CONNECTOR. OTHER VEHICLES MAY LOSE ABS/ESC SYSTEM FUNCTION DUE TO AN OVERHEATED POWER DISTRIBUTION CENTER.
Consequence: THIS COULD LEAD TO LOSS OF VISIBILITY AND/OR BRAKING ABILITY, INCREASING THE RISK OF A CRASH.
Remedy: CHRYSLER WILL NOTIFY OWNERS AND DEALERS WILL REPLACE THE HEADLAMP JUMPER HARNESSES AND RELOCATE THE ABS/ESC SYSTEM FUSE WITHIN THE POWER DISTRIBUTION CENTER, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 2, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Exterior Lighting:headlights
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2011 and 2012 DODGE CHARGER POLICE VEHICLES. THE LOW BEAM HEADLAMPS OF SOME VEHICLES COULD FAIL DUE TO AN OVERHEATED BULB HARNESS CONNECTOR. OTHER VEHICLES MAY LOSE ABS/ESC SYSTEM FUNCTION DUE TO AN OVERHEATED POWER DISTRIBUTION CENTER.
Consequence: THIS COULD LEAD TO LOSS OF VISIBILITY AND/OR BRAKING ABILITY, INCREASING THE RISK OF A CRASH.
Remedy: CHRYSLER WILL NOTIFY OWNERS AND DEALERS WILL REPLACE THE HEADLAMP JUMPER HARNESSES AND RELOCATE THE ABS/ESC SYSTEM FUSE WITHIN THE POWER DISTRIBUTION CENTER, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 2, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Electrical System:wiring
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2011 and 2012 DODGE CHARGER POLICE VEHICLES. THE LOW BEAM HEADLAMPS OF SOME VEHICLES COULD FAIL DUE TO AN OVERHEATED BULB HARNESS CONNECTOR. OTHER VEHICLES MAY LOSE ABS/ESC SYSTEM FUNCTION DUE TO AN OVERHEATED POWER DISTRIBUTION CENTER.
Consequence: THIS COULD LEAD TO LOSS OF VISIBILITY AND/OR BRAKING ABILITY, INCREASING THE RISK OF A CRASH.
Remedy: CHRYSLER WILL NOTIFY OWNERS AND DEALERS WILL REPLACE THE HEADLAMP JUMPER HARNESSES AND RELOCATE THE ABS/ESC SYSTEM FUSE WITHIN THE POWER DISTRIBUTION CENTER, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 2, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2011 and 2012 DODGE CHARGER POLICE VEHICLES. THE LOW BEAM HEADLAMPS OF SOME VEHICLES COULD FAIL DUE TO AN OVERHEATED BULB HARNESS CONNECTOR. OTHER VEHICLES MAY LOSE ABS/ESC SYSTEM FUNCTION DUE TO AN OVERHEATED POWER DISTRIBUTION CENTER.
Consequence: THIS COULD LEAD TO LOSS OF VISIBILITY AND/OR BRAKING ABILITY, INCREASING THE RISK OF A CRASH.
Remedy: CHRYSLER WILL NOTIFY OWNERS AND DEALERS WILL REPLACE THE HEADLAMP JUMPER HARNESSES AND RELOCATE THE ABS/ESC SYSTEM FUSE WITHIN THE POWER DISTRIBUTION CENTER, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 2, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA21002 · Desiccated Air Bag Inflator Rupture
Opened Sep 17, 2021 · No close date supplied
Status: open (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
PE14022 · Alternator Failure
Opened Jul 22, 2014 · Closed Nov 6, 2014
Status: closed (inferred from source dates) · Electrical System:alternator/generator/regulator
On July 22, 2014, the Office of Defects Investigation (ODI) opened PE14-022 to investigate 14 complaints (VOQs) alleging incidents of alternator failure resulting in engine stall while driving in model year (MY) 2011 through 2012 Dodge Charger vehicles.The MY 2011 through 2012 Dodge Charger vehicles were sold with three different engine options:1) 3.6L V6 (VIN8 = G), 88,766 vehicles; 2) 5.7L V8 (VIN8 = T), 38,615 vehicles; and 3) 6.4L V8 (VIN8 = J), 2,406 MY 2012 vehicles.The 14 VOQs identified in the PE14-022 opening resume involve 13 vehicles with 3.6L V6 engines and 1 vehicle with unknown engine (no VIN provided).In an October 7, 2014 letter to NHTSA, Chrysler described a safety defect condition that could result in rapid alternator failure having limited or no detection in approximately 434,581 MY 2011 through 2014 Chrysler 300, Dodge Charger, Dodge Challenger, Dodge Durango and Jeep Grand Cherokee vehicles equipped with 3.6L engines and 160 amp alternators (NHTSA Recall No. 14V-634, Chrysler P60).The subject alternators are used in vehicles equipped with 3.6L V6 engines and without towing packages.According to Chrysler, the silicone diodes in the alternator rectifier bridge may experience thermal fatigue due to cyclic loading from the Electric Hydraulic Power Steering (EHPS) system, eventually resulting in no output, reduced output, or a fully shorted to ground condition.These failure modes vary in their time to failure and warning to the driver.Depending on the failure mode and timing, system voltage may drop to critically low levels, disabling systems such as the Anti-lock Brake System/Electronic Stability Control, Engine Control Module/Central Body Controller, or a total vehicle electrical system shut down (in the event of a short to ground failure mode).Analysis of complaints to ODI and Chrysler identified a total of 146 incidents of alternator failure resulting in engine stall while driving in MY 2011 through 2012 Dodge Charger vehicles, including 142 involving vehicles equipped with the 3.6L V6 engines (1.6 IPTV) that were included in 14V-634 and 4 involving vehicles with 5.7L V8 engines (0.1 IPTV), which are equipped with different alternators.Analysis of all alternator failure complaints found that approximately 48 percent of VOQs and 21 percent of Chrysler complaints involved allegations of engine stall.Many (98) complaints reported fire and/or smoke, but analysis of these determined that they involved thermal damage to the alternator diode and did not identify any incidents involving damage beyond the alternator assembly.One VOQ identified in the opening resume for PE14-022 alleged a crash, but further evaluation determined that this involved a minor rear-end impact with slight bumper damage.This investigation is closed based on Chrysler's decision to conduct a safety recall.The VOQs associated with this investigation are:10641479,10641366,10641349,10642017,10640770,10640687,10640553,10639692,10638810,10638356,10638175,10638143,10637460,10633806,10633304,10632943,10632006,10631704,10631613,10631420,10631088,10630991,10630854,10630844,10630108,10629623,10629603,10628228,10628150,10627941,10627342,10626452,10626254,10625962,10622385,10622340,10621603,10620961,10619481,10618950,10618948,10618539,10618476,10618334,10618081,10618107,10616834,10616461,10616456,10615754,10615719,10606580,10605090,10604958,10597295,10592085,10588675,10587141,10562463,10559730,10511407
Illustration