NHTSA owner reports · September 18, 2026 snapshot.
Steering complaints
39 reportsClear category filter66,000 miles · Oct 3, 2014
Electrical SystemSteering
I WAS PULLING INTO THE RESIDENTIAL AREA THAT I LIVE IN AT APPROXIMATELY 17 MPH AND MY STEREO SHUT OFF, AND I NOTICED ON THE DASHBOARD A WARNING MESSAGE THAT READ "POWER SAVING MODE" THEN THE ABS LIGHT AND THE STABILITY CONTROL LIGHT CAME ON ALONG WITH THE LIGHTNING BOLT CAME ON, THEN THE AIR SHUT OFF AND IT FELT LIKE THE HEATER …
Read full complaint
I WAS PULLING INTO THE RESIDENTIAL AREA THAT I LIVE IN AT APPROXIMATELY 17 MPH AND MY STEREO SHUT OFF, AND I NOTICED ON THE DASHBOARD A WARNING MESSAGE THAT READ "POWER SAVING MODE" THEN THE ABS LIGHT AND THE STABILITY CONTROL LIGHT CAME ON ALONG WITH THE LIGHTNING BOLT CAME ON, THEN THE AIR SHUT OFF AND IT FELT LIKE THE HEATER WAS TURNED ON, THE DASHBOARD SHOW THE TEMPERATURE BEING 105 AND THERE WAS A WEIRD SMELL THAT CAME THROUGH THE AC VENTS. I WAS ABLE TO PUSH THE VEHICLE INTO MY DRIVEWAY AND UPON OPENING THE HOOD OF THE VEHICLE YOU COULD FEEL THE HEAT IMMEDIATELY AND WHEN ATTEMPTING TO JUMP START THE CAR THE CAR WOULD TURN ON BUT THEN WHEN THE JUMPER CABLES WHERE REMOVED THE VEHICLE'S WIPERS BEGAN TO WIPE AND THE SAME ISSUES AS BEFORE BEGAN OCCURRING. I CALLED ONE OF MY FRIENDS THAT IS A DODGE TECHNICIAN AND HE SAID THAT BASED ON THE INFORMATION I TOLD HIM HE WAS 95% SURE THAT IT WAS A BAD ALTERNATOR. THIS IS A 2011 DODGE CHARGER WITH 66,000 MILES. THIS SHOULD BE RECALLED IMMEDIATELY TO HELP THOSE THAT HAVE HAD THIS PROBLEM AND TO AVOID ANY MORE OWNERS HAVE THIS PROBLEM. *TR
NHTSA ODI #10641349
45,670 miles · Sep 8, 2014
EngineService BrakesSteering
I HAVE A 2011 DODGE CHARGER THAT I SAVED UP A LONG TIME TO BUY. LAST WEEK ON 9/3/14 ON MY TO TAKE MY KIDS TO SCHOOL THE AUDIO IN THE CAR WENT OUT. THE TOUCH SCREEN STILL HAD FUNCTIONALITY JUST NO AUDIO, FIGURED A FUSE MAY HAVE BLOWN. CHECK THE FUSES AND EVERYTHING SEEMED OK. LATER ON THE SAME DAY, ON THE WAY TO PICK THE KIDS UP …
Read full complaint
I HAVE A 2011 DODGE CHARGER THAT I SAVED UP A LONG TIME TO BUY. LAST WEEK ON 9/3/14 ON MY TO TAKE MY KIDS TO SCHOOL THE AUDIO IN THE CAR WENT OUT. THE TOUCH SCREEN STILL HAD FUNCTIONALITY JUST NO AUDIO, FIGURED A FUSE MAY HAVE BLOWN. CHECK THE FUSES AND EVERYTHING SEEMED OK. LATER ON THE SAME DAY, ON THE WAY TO PICK THE KIDS UP FROM SCHOOL THE RADIO WAS WORKING FINE. I APPROACHED A INTERSECTION AND STARTED TO SLOW DOWN WHEN THE RADIO CUT OFF. THE CAR STARTED PUTTERING AND THE INSIDE GAUGES BEGAN FLASHING AND THE WIPERS JUST TURNED ON BY THEMSELVES. NEXT THING I KNOW EVERYTHING IN THE CAR SHUT OFF. THE RADIO,THE ENGINE, THE LIGHTS, EVERYTHING. I COULD NOT GET IT TO GO INTO NEUTRAL TO PUSH THE CAR OUT OF THE ROAD BECAUSE NOTHING IN THE CAR WOULD COME ON. *TR
NHTSA ODI #10631428
89,999 miles · Aug 30, 2014
EngineSteeringVehicle Speed Control
ON 8/24 I WAS DRIVING ABOUT 30 MPH WHEN MY CAR STARTED CUTTING OUT. THE RADIO WENT OFF, MY ENGINE DIED AND MY STEERING LOCKED. I ALMOST HIT A PEDESTRIAN AND WHAT COULD HAVE BEEN A FEW CARS BUT I WAS ABLE TO AVOID IT. I STOPPED AND WAS ABLE TO START MY CAR TO GET IT TO THE SIDE OF THE ROAD. I HAD IT TOWED HOME, NEXT DAY I HAD IT …
Read full complaint
ON 8/24 I WAS DRIVING ABOUT 30 MPH WHEN MY CAR STARTED CUTTING OUT. THE RADIO WENT OFF, MY ENGINE DIED AND MY STEERING LOCKED. I ALMOST HIT A PEDESTRIAN AND WHAT COULD HAVE BEEN A FEW CARS BUT I WAS ABLE TO AVOID IT. I STOPPED AND WAS ABLE TO START MY CAR TO GET IT TO THE SIDE OF THE ROAD. I HAD IT TOWED HOME, NEXT DAY I HAD IT TOWED TO MOMENTUM DODGE BECAUSE I LOOKED ONLINE AND HAD 3 RECALLS, DOOR HANDLES, HEADLIGHTS AND I DON'T KNOW THE 3RD ONE. I WAS HOPING IT WAS THE PROBLEM. IT WAS NOT. I THEN HAD MY CAR TOWED TO ANOTHER SHOP WHO VERIFIED MY ALTERNATOR IS OUT. AS OF NOW THE ONLY PLACE I CAN THE FIND THE ALTERNATOR IS, OF COURSE, THE DODGE DEALER WHICH I CANNOT AFFORD. *TR
NHTSA ODI #10629603
53,000 miles · Aug 25, 2014
Electrical SystemSeat BeltsSteering
TL* THE CONTACT OWNS A 2011 DODGE CHARGER. THE CONTACT STATED THAT IT WAS DIFFICULT TO UNLATCH THE BUCKLE OF THE DRIVER SIDE SEAT BELT. IN ADDITION, THE HORN FAILED AND WAS NO LONGER OPERABLE. THE CONTACT ALSO HEARD A LOUD SCREECHING SOUND WHEN THE BRAKE PEDAL WAS DEPRESSED. THE DEALER STATED THAT THE LOWER CONTROL ARM, TIE ROD …
Read full complaint
TL* THE CONTACT OWNS A 2011 DODGE CHARGER. THE CONTACT STATED THAT IT WAS DIFFICULT TO UNLATCH THE BUCKLE OF THE DRIVER SIDE SEAT BELT. IN ADDITION, THE HORN FAILED AND WAS NO LONGER OPERABLE. THE CONTACT ALSO HEARD A LOUD SCREECHING SOUND WHEN THE BRAKE PEDAL WAS DEPRESSED. THE DEALER STATED THAT THE LOWER CONTROL ARM, TIE ROD END, AND WHEEL BEARING NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURES RECURRED. THE FAILURE MILEAGE WAS 53,000.
NHTSA ODI #10628059
63,200 miles · Aug 14, 2014
Electrical SystemSteeringFire
WITHOUT WARNING WHILE DRIVING AT HIGHWAY SPEEDS I BEGAN TO SMELL A PLASTIC MELTING SMELL. ALMOST IMMEDIATELY THE RADIO SHUT OFF AND I GOT A "BATTERY SAVER MODE" MESSAGE. WITHIN SECONDS THE CAR'S ENGINE QUIT. WHEN THE ENGINE STOPPED SO DID ALL POWER TO THE CONTROLS INCLUDING STEERING AND BRAKES. WHEN GOT THE CAR TO THE SIDE O…
Read full complaint
WITHOUT WARNING WHILE DRIVING AT HIGHWAY SPEEDS I BEGAN TO SMELL A PLASTIC MELTING SMELL. ALMOST IMMEDIATELY THE RADIO SHUT OFF AND I GOT A "BATTERY SAVER MODE" MESSAGE. WITHIN SECONDS THE CAR'S ENGINE QUIT. WHEN THE ENGINE STOPPED SO DID ALL POWER TO THE CONTROLS INCLUDING STEERING AND BRAKES. WHEN GOT THE CAR TO THE SIDE OF THE ROAD I COULD SEE VISIBLE BLUE SMOKE COMING FROM THE FRONT OF THE PASSENGER'S SIDE ENGINE COMPARTMENT. POPPED THE HOOD AND IDENTIFIED THAT THE SMOKE WAS COMING FROM THE ALTERNATOR. CAR WOULD NOT START AGAIN. HAD TOWED TO SHOP AND ALTERNATOR IS SHOT. APPARENTLY THERE IS A 2 TO 3 WEEK BACK ORDER DUE TO HIGH DEMAND RELATED TO FAILED ALTERNATORS. I COULD HAVE BEEN KILLED OR KILLED OTHERS EASILY WHEN I LOST POWER AT HIGHWAY SPEED. *TR
NHTSA ODI #10622385
47,040 miles · Aug 1, 2014
Electrical SystemEngineSteering
I WAS TRAVELING NORTHBOUND ON A HIGHWAY AT APPROXIMATELY 1730 AND MY RADIO SCREEN COMPLETELY WENT OUT, FOLLOWED BY EVERYTHING ELSE THAT USES POWER IN THE VEHICLE I STARTED GETTING SEVERAL WARNING LIGHTS FOR BREAKS, TIRE PRESSURE, PRETTY MUCH EVERY WARNING, VEHICLE ENTERED BATTERY SAVER MODE WHILE DRIVING. STEERING WHEEL WAS ALMO…
Read full complaint
I WAS TRAVELING NORTHBOUND ON A HIGHWAY AT APPROXIMATELY 1730 AND MY RADIO SCREEN COMPLETELY WENT OUT, FOLLOWED BY EVERYTHING ELSE THAT USES POWER IN THE VEHICLE I STARTED GETTING SEVERAL WARNING LIGHTS FOR BREAKS, TIRE PRESSURE, PRETTY MUCH EVERY WARNING, VEHICLE ENTERED BATTERY SAVER MODE WHILE DRIVING. STEERING WHEEL WAS ALMOST IMPOSSIBLE TO MANIPULATE MAYBE AFTER A COUPLE MINUTES MY VEHICLE COMPLETELY SHUT OFF IN THE MIDDLE OF TRAFFIC WITHOUT WARNING. I WAS UNABLE TO TURN ON HAZARDS, OR ROLL WINDOWS DOWN OR DO ANYTHING WITH MY VEHICLE, THIS WAS VERY UNSAFE AND COULD HAVE CAUSED A MAJOR ACCIDENT. THE ISSUE SEEMS TO STEM FROM THE ALTERNATOR COMPLETELY FAILING WHILE DRIVING. THIS WAS VERY STRESSFUL FOR ME AND EVERYONE INVOLVED. *TR
NHTSA ODI #10618081
55,000 miles · Aug 1, 2014
Electrical SystemSteeringVehicle Speed Control
I WAS DRIVING HOME WITH MY 2 KIDS ON THE FREEWAY. BATTERY SAVER MODE MESSAGE CAME ON. THE LIGHTS ON THE DASH STARTED FLICKERING. THE ABS LIGHT AND ELECTRONIC STABILITY LIGHTS WENT ON AND OFF. AS I WAS EXCITING FREEWAY THE RPMS STARTED JUMPING UP AND DOWN. AC STARTED BLOWING HOT. RADIO SHUT OFF AND THE GAS PEDAL BARELY WORKED. A…
Read full complaint
I WAS DRIVING HOME WITH MY 2 KIDS ON THE FREEWAY. BATTERY SAVER MODE MESSAGE CAME ON. THE LIGHTS ON THE DASH STARTED FLICKERING. THE ABS LIGHT AND ELECTRONIC STABILITY LIGHTS WENT ON AND OFF. AS I WAS EXCITING FREEWAY THE RPMS STARTED JUMPING UP AND DOWN. AC STARTED BLOWING HOT. RADIO SHUT OFF AND THE GAS PEDAL BARELY WORKED. AFTER THAT I LOST POWER STEERING AND HAD TO MUSCLE THE CAR AROUND A CAR IN FRONT OF ME AND INTO A PARKING LOT. THE ALTERNATOR DIED ON ME. I HAVE READ MANY OTHER PEOPLE HAVING THE SAME THING HAPPEN TO THEM. *TR
NHTSA ODI #10618070
34,596 miles · Jul 26, 2014
Electrical SystemEngineSteering
3/9/13 - VEHICLE IN FOR OIL CHANGE. BATTERY SAVER MODE MESSAGE DISPLAYED ON DASH 2 MILES DOWN THE ROAD. PULLED OVER TO CHECK OWNER'S MANUAL WHICH STATES IMMEDIATE VEHICLE SERVICE REQUIRED. TO AIRPARK DODGE DEALERSHIP APPROX 7 MILES DOWN THE ROAD AND POWER STEERING FAILURE AND THEN ENGINE STALLS WHILE MAKING LEFT TURN THROUGH …
Read full complaint
3/9/13 - VEHICLE IN FOR OIL CHANGE. BATTERY SAVER MODE MESSAGE DISPLAYED ON DASH 2 MILES DOWN THE ROAD. PULLED OVER TO CHECK OWNER'S MANUAL WHICH STATES IMMEDIATE VEHICLE SERVICE REQUIRED. TO AIRPARK DODGE DEALERSHIP APPROX 7 MILES DOWN THE ROAD AND POWER STEERING FAILURE AND THEN ENGINE STALLS WHILE MAKING LEFT TURN THROUGH INTERSECTION. HAD BOTH MY CHILDREN AGES 2 AND 5 IN THE VEHICLE AT THE TIME AND THANKFULLY NO ON COMING TRAFFIC DURING THE TURN. 3/12/13 - ALTERNATOR AND BATTERY REPLACED AT AIRPARK DODGE. 4/23/13 (35,690 MILES) - VEHICLE BACK TO AIRPARK DODGE FOR ANOTHER BATTERY SAVER MODE MESSAGE. SOURCE COULD NOT BE FOUND, NO REPAIRS MADE. 7/25/14 (47,900 MILES) - BATTERY SAVER MODE MESSAGE, NO DASH LIGHTS, NO A/C, NO POWER STEERING, NO HEADLIGHTS WHILE DOING 30 MPH. VEHICLE TO AIRPARK DODGE AGAIN ON 7/29/14. *TR
NHTSA ODI #10616461
55,600 miles · Jul 23, 2014
Electronic Stability Control (esc)SteeringUnknown Or Other
WHILE DRIVING ON SUNDAY EVENING AROUND 8:30 PM ABOUT 2 MILES FROM MY HOME GOING TO GET SOME COLD MEDICINES MY CAR ALL OF A SUDDEN THE RADIO STOP WORKING AND IT STARTED STALLING AND MY ABS BRAKES LIGHT AND TRACTION CONTROL LIGHTS CAME ON AND WAS ABOUT TO CUT OFF AND EVERYTHING JUST STOP WORKING WAS ABLE TO GET IT OFF THE ROAD. RE…
Read full complaint
WHILE DRIVING ON SUNDAY EVENING AROUND 8:30 PM ABOUT 2 MILES FROM MY HOME GOING TO GET SOME COLD MEDICINES MY CAR ALL OF A SUDDEN THE RADIO STOP WORKING AND IT STARTED STALLING AND MY ABS BRAKES LIGHT AND TRACTION CONTROL LIGHTS CAME ON AND WAS ABOUT TO CUT OFF AND EVERYTHING JUST STOP WORKING WAS ABLE TO GET IT OFF THE ROAD. REMEMBER SMELLING SOMETHING THAT WAS BURNING NO SMOKE OR FIRE HAVE DONE RESEARCH ON THE INTERNET AND THERE ARE SEVERAL COMPLAINTS ABOUT PEOPLE HAVING THE SAME PROBLEM WITH THE SAME AMOUNT OF MILEAGE AS MY CAR OR LESSER. DID CALL DODGE AND THEY HAD NO COMPLAINTS THEY CLAIM OF THIS PROBLEM BUT IT COULD HAVE HAPPEN DUE TO A RECENT RECALL THEY CALL A M10. NO OTHER ASSISTANCE FROM THE MAKER OF THIS CAR BUT IT NEEDS TO BE INVESTIGATED PERIOD.IF IT IS THE ALTERNATOR AND BATTERY IT IS COSTING OVER $1000.00 TO GET THE REPAIRS DONE AND THIS IS BAD WHEN THE WARRANTY JUST WENT OUT ON IT. NOT INCLUDING CAR NOTE AND CAR INSURANCE. *TR
NHTSA ODI #10615754
50,000 miles · Jul 21, 2014
Electrical SystemEngineSteering
CAR WENT INTO BATTERY SAVER MODE, RADIO SHUT OFF, TRIED TO MAKE IT HOME HAD TO PULL OVER AND HAVE TOWED, ALTERNATOR WAS OUT. WE JUST HAD TO PUT ANOTHER ALTERNATOR ON IN MAY OF YEAR 2014, SAME THING, RADIO OUT, MADE IT TO AUTO REPAIR SHOP, THE PART WAS ON BACK ORDER BECAUSE THERE IS SUCH A HIGH DEMAND, WE WERE TOLD THIS IS A COM…
Read full complaint
CAR WENT INTO BATTERY SAVER MODE, RADIO SHUT OFF, TRIED TO MAKE IT HOME HAD TO PULL OVER AND HAVE TOWED, ALTERNATOR WAS OUT. WE JUST HAD TO PUT ANOTHER ALTERNATOR ON IN MAY OF YEAR 2014, SAME THING, RADIO OUT, MADE IT TO AUTO REPAIR SHOP, THE PART WAS ON BACK ORDER BECAUSE THERE IS SUCH A HIGH DEMAND, WE WERE TOLD THIS IS A COMMON PROBLEM IN THIS CAR. *TR
NHTSA ODI #10615118
Official recalls
11Jan 15, 2019
Chrysler (FCA US LLC) is recalling certain 2010 Dodge Ram 3500, Ram 4500/5500, 2010-2011 Dodge Dakota, 2010-2014 Dodge Challenger, 2010-2015 Dodge Challenger, Chrysler 300, and 2010-2016 Jeep Wrangler vehicles. Upon deployment of the driver's frontal air bag, excessive internal pressure may cause the inflator to explode.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the passenger's frontal air bag, the inflator could explode with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicle until the recall repair is complete. Chrysler will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. The recall began February 4, 2019. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is V01.
Jan 9, 2018
Chrysler (FCA US LLC) is recalling certain 2009-2013 Jeep Wrangler, Chrysler 300, Dodge Challenger and Dodge Charger vehicles, and 2009-2011 Dodge Dakota vehicles sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." Additionally, Chrysler is recalling certain 2009-2010 RAM 4500 Cab Chassis, RAM 5500 Cab Chassis, RAM 3500 Cab Chassis, Jeep Wrangler, Chrysler 300, Dodge Dakota, Dodge Challenger, and Dodge Charger vehicles ever registered in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." Chrysler is also recalling certain 2009 RAM 3500, RAM 2500, RAM 4500 Cab Chassis, RAM 5500 Cab Chassis, Dodge Durango, Chrysler Aspen, RAM 3500 Cab Chassis, Jeep Wrangler, Chrysler 300, Dodge Dakota, Dodge Challenger, and Dodge Charger vehicles ever registered in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming. In the event of a crash necessitating deployment of the passenger frontal air bag, these passenger air bag inflator may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicle until the recall repair is complete. Chrysler will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. The recall began February 28, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U03.
Jul 10, 2017
Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Dodge Challenger, Dodge Charger, Chrysler 300, Dodge Durango, and 2012-2014 Jeep Grand Cherokee vehicles. The affected vehicles have electro-hydraulic power steering (EHPS) and are equipped with a 5.7L or a 3.6L engine and a 160, 180 or 220 amp alternator. In the affected vehicles, the alternator may suddenly fail.
Consequence & remedy
Consequence: If the alternator fails, the vehicle may stall without warning, increasing the risk of a crash. There is also the possibility that the alternator may short circuit, increasing the risk of a fire.
Remedy: Chrysler will notify owners, and dealers will inspect the alternator and depending on the part number, will replace the alternator, if necessary, free of charge. The recall began February 12, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is T36.
May 24, 2016
Chrysler (FCA US LLC) expanded the affected population to include 73,712 2005-2009 RAM 2500 trucks produced at the St. Louis North Assembly Plant. With this change, Chrysler is recalling certain model year 2004-2008 RAM 1500, 2005-2009 RAM 2500, 2006-2009 RAM 3500, 2007-2010 RAM 3500 Cab Chassis, 2008-2010 RAM 4500 and 5500 Cab Chassis, 2004-2009 Dodge Durango, 2007-2009 Chrysler Aspen, 2007-2012 Jeep Wrangler, 2008-2012 Dodge Challenger, 2005-2008 Dodge Magnum, 2005-2012 Chrysler 300, 2006-2012 Dodge Charger, 2005-2011 Dodge Dakota, and 2006-2009 Mitsubishi Raider vehicles originally sold, or ever registered, in AL, CA, FL, GA, HI, LA, MS, SC, TX, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Chrysler is also recalling 2004-2008 RAM 1500, 2005-2009 RAM 2500, 2006-2009 RAM 3500, 2007-2009 RAM 3500 Cab Chassis, 2008-2009 RAM 4500 and 5500 Cab Chassis, 2004-2009 Dodge Durango, 2007-2009 Chrysler Aspen, 2007-2009 Jeep Wrangler, 2008-2009 Dodge Challenger, 2005-2008 Dodge Magnum, 2005-2009 Chrysler 300, 2006-2009 Dodge Charger, 2005-2009 Dodge Dakota and 2006-2009 Mitsubishi Raider vehicles originally sold, or ever registered, in AZ, AR, DE, Washington D.C., IL, IN, KS, KY, MD, MO, NE, NV, NJ, NM, NC, OH, OK, PA, TN, VA, and WV, or "Zone B." Lastly, unless included in "Zone A" or "Zone B" above, Chrysler is recalling certain 2005-2008 RAM 2500, 2006-2008 RAM 3500, 2007-2008 RAM 3500 Cab Chassis, 2008 RAM 4500 and 5500 Cab Chassis, 2004-2008 Dodge Durango, 2007-2008 Chrysler Aspen, 2007-2008 Jeep Wrangler, 2008 Dodge Challenger, 2005-2008 Dodge Magnum, 2005-2008 Chrysler 300, 2006-2008 Dodge Charger, 2005-2008 Dodge Dakota, and 2006-2008 Mitsubishi Raider vehicles originally sold, or registered, in AK, CO, CT, ID, IA, ME, MA, MI, MN, MT, NH, NY, ND, OR, RI, SD, UT, VT, WA, WI, and WY.
Consequence & remedy
Consequence: These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. These inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling. An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicle until the recall repair is complete. Chrysler will notify the Chrysler, Dodge, Jeep and RAM owners. Mitsubishi owners will be notified by their company. Dealers will replace the passenger frontal air bag inflator, free of charge. The recall began on March 27, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S43. Note: This recall supersedes recall 14V-7700.
Jan 28, 2016
FCA US LLC (Chrysler) is recalling certain model year 2011-2016 Dodge Charger vehicles manufactured August 23, 2010, to January 7, 2016. When an affected vehicle is lifted using the supplied tire jack without chocking the wheels, the vehicle's body-side sill may give causing the tire jack to fail and the car to fall.
Consequence & remedy
Consequence: A car that falls unexpectedly increases the risk of injury.
Remedy: Chrysler will notify owners, and dealers will provide owners with wheel chocks and instructions for their use, free of charge. The recall began on March 21, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S03.
Jul 27, 2015
Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Dodge Charger vehicles manufactured May 6, 2010, to June 5, 2014. In the affected vehicles, the side impact sensor calibrations may be overly sensitive, and as a result, the side air bag inflatable curtains and seat air bags may unexpectedly deploy and the seat belt pre-tensioners may activate.
Consequence & remedy
Consequence: Air bags that unexpectedly deploy increase the risk of a crash or injury.
Remedy: Chrysler will notify owners, and dealers will update the Occupant Restraint Control module calibration, free of charge. The recall began on August 25, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R35.
Additional source detail variants (2)
Seat Belts
Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Dodge Charger vehicles manufactured May 6, 2010, to June 5, 2014. In the affected vehicles, the side impact sensor calibrations may be overly sensitive, and as a result, the side air bag inflatable curtains and seat air bags may unexpectedly deploy and the seat belt pre-tensioners may activate.
Consequence: Air bags that unexpectedly deploy increase the risk of a crash or injury.
Remedy: Chrysler will notify owners, and dealers will update the Occupant Restraint Control module calibration, free of charge. The recall began on August 25, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R35.
Air Bags:side/window
Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Dodge Charger vehicles manufactured May 6, 2010, to June 5, 2014. In the affected vehicles, the side impact sensor calibrations may be overly sensitive, and as a result, the side air bag inflatable curtains and seat air bags may unexpectedly deploy and the seat belt pre-tensioners may activate.
Consequence: Air bags that unexpectedly deploy increase the risk of a crash or injury.
Remedy: Chrysler will notify owners, and dealers will update the Occupant Restraint Control module calibration, free of charge. The recall began on August 25, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R35.
Oct 8, 2014
Chrysler Group LLC (Chrysler) is recalling certain model year 2011-2014 Chrysler 300, Dodge Charger, Challenger, and Durango; and 2012-2014 Jeep Grand Cherokee vehicles manufactured April 22, 2010, to January 2, 2014, and equipped with a 3.6L engine and a 160 amp alternator. In the affected vehicles, the alternator may suddenly fail.
Consequence & remedy
Consequence: If the alternator fails, the vehicle may stall without warning, increasing the risk of a crash.
Remedy: Chrysler has notified owners, and dealers will replace the alternator, free of charge. The recall began on February 27, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P60.
Mar 4, 2014
Chrysler Group LLC (Chrysler) is recalling certain model year 2011-2012 Dodge Charger vehicles manufactured May 20, 2010, through November 8, 2011, and equipped with halogen headlamps. In the affected vehicles, a sub-harness for the headlights may overheat and cause the low beam headlights to go out.
Consequence & remedy
Consequence: Loss of headlights reduces the driver's visibility, increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the headlamp jumper harnesses and bulbs, or the headlamp assemblies, as necessary, free of charge. The recall began on May 2, 2014. Owners may contract Chrysler at 1-800-853-1403. Chrysler's number associated with this recall is P08. This recall concerns non-police vehicles. A separate campaign was launched in 2012 to address police vehicles. See NHTSA recall 12V-042.
Apr 3, 2013
Chrysler Group LLC (Chrysler) is recalling certain model year 2011-2012 Chrysler 300, Dodge Challenger, and Dodge Charger vehicles manufactured April 11, 2011, through December 14, 2011. The affected vehicles may have improperly sized terminal crimps on the seat side-airbag wiring harness which may cause the seat side-airbags to malfunction and illuminate the airbag warning light.
Consequence & remedy
Consequence: In the event of a crash necessitating airbag deployment the airbags may not operate as designed, increasing the risk of injury.
Remedy: Chrysler will notify owners, and dealers will replace both driver and passenger seat airbag wiring harnesses, free of charge. The recall began on April 22, 2013. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign number is N07.
May 2, 2012
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2011 AND 2012 300 AND DODGE CHARGER VEHICLES. THESE VEHICLES MAY LOSE ABS/ESC SYSTEM FUNCTION DUE TO AN OVERHEATED POWER DISTRIBUTION CENTER.
Consequence & remedy
Consequence: THIS COULD LEAD TO LOSS OF VEHICLE CONTROL, INCREASING THE RISK OF A CRASH.
Remedy: CHRYSLER WILL NOTIFY OWNERS, AND DEALERS WILL RELOCATE THE ABS/ESC SYSTEM FUSE, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 18, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Additional source detail variants (2)
Electrical System:wiring:fuses And Circuit Breakers
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2011 AND 2012 300 AND DODGE CHARGER VEHICLES. THESE VEHICLES MAY LOSE ABS/ESC SYSTEM FUNCTION DUE TO AN OVERHEATED POWER DISTRIBUTION CENTER.
Consequence: THIS COULD LEAD TO LOSS OF VEHICLE CONTROL, INCREASING THE RISK OF A CRASH.
Remedy: CHRYSLER WILL NOTIFY OWNERS, AND DEALERS WILL RELOCATE THE ABS/ESC SYSTEM FUSE, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 18, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Service Brakes, Air:antilock:control Unit/module
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2011 AND 2012 300 AND DODGE CHARGER VEHICLES. THESE VEHICLES MAY LOSE ABS/ESC SYSTEM FUNCTION DUE TO AN OVERHEATED POWER DISTRIBUTION CENTER.
Consequence: THIS COULD LEAD TO LOSS OF VEHICLE CONTROL, INCREASING THE RISK OF A CRASH.
Remedy: CHRYSLER WILL NOTIFY OWNERS, AND DEALERS WILL RELOCATE THE ABS/ESC SYSTEM FUSE, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 18, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Feb 7, 2012
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2011 and 2012 DODGE CHARGER POLICE VEHICLES. THE LOW BEAM HEADLAMPS OF SOME VEHICLES COULD FAIL DUE TO AN OVERHEATED BULB HARNESS CONNECTOR. OTHER VEHICLES MAY LOSE ABS/ESC SYSTEM FUNCTION DUE TO AN OVERHEATED POWER DISTRIBUTION CENTER.
Consequence & remedy
Consequence: THIS COULD LEAD TO LOSS OF VISIBILITY AND/OR BRAKING ABILITY, INCREASING THE RISK OF A CRASH.
Remedy: CHRYSLER WILL NOTIFY OWNERS AND DEALERS WILL REPLACE THE HEADLAMP JUMPER HARNESSES AND RELOCATE THE ABS/ESC SYSTEM FUSE WITHIN THE POWER DISTRIBUTION CENTER, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 2, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Additional source detail variants (4)
Electrical System:wiring:fuses And Circuit Breakers
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2011 and 2012 DODGE CHARGER POLICE VEHICLES. THE LOW BEAM HEADLAMPS OF SOME VEHICLES COULD FAIL DUE TO AN OVERHEATED BULB HARNESS CONNECTOR. OTHER VEHICLES MAY LOSE ABS/ESC SYSTEM FUNCTION DUE TO AN OVERHEATED POWER DISTRIBUTION CENTER.
Consequence: THIS COULD LEAD TO LOSS OF VISIBILITY AND/OR BRAKING ABILITY, INCREASING THE RISK OF A CRASH.
Remedy: CHRYSLER WILL NOTIFY OWNERS AND DEALERS WILL REPLACE THE HEADLAMP JUMPER HARNESSES AND RELOCATE THE ABS/ESC SYSTEM FUSE WITHIN THE POWER DISTRIBUTION CENTER, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 2, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Exterior Lighting:headlights
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2011 and 2012 DODGE CHARGER POLICE VEHICLES. THE LOW BEAM HEADLAMPS OF SOME VEHICLES COULD FAIL DUE TO AN OVERHEATED BULB HARNESS CONNECTOR. OTHER VEHICLES MAY LOSE ABS/ESC SYSTEM FUNCTION DUE TO AN OVERHEATED POWER DISTRIBUTION CENTER.
Consequence: THIS COULD LEAD TO LOSS OF VISIBILITY AND/OR BRAKING ABILITY, INCREASING THE RISK OF A CRASH.
Remedy: CHRYSLER WILL NOTIFY OWNERS AND DEALERS WILL REPLACE THE HEADLAMP JUMPER HARNESSES AND RELOCATE THE ABS/ESC SYSTEM FUSE WITHIN THE POWER DISTRIBUTION CENTER, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 2, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Electrical System:wiring
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2011 and 2012 DODGE CHARGER POLICE VEHICLES. THE LOW BEAM HEADLAMPS OF SOME VEHICLES COULD FAIL DUE TO AN OVERHEATED BULB HARNESS CONNECTOR. OTHER VEHICLES MAY LOSE ABS/ESC SYSTEM FUNCTION DUE TO AN OVERHEATED POWER DISTRIBUTION CENTER.
Consequence: THIS COULD LEAD TO LOSS OF VISIBILITY AND/OR BRAKING ABILITY, INCREASING THE RISK OF A CRASH.
Remedy: CHRYSLER WILL NOTIFY OWNERS AND DEALERS WILL REPLACE THE HEADLAMP JUMPER HARNESSES AND RELOCATE THE ABS/ESC SYSTEM FUSE WITHIN THE POWER DISTRIBUTION CENTER, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 2, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2011 and 2012 DODGE CHARGER POLICE VEHICLES. THE LOW BEAM HEADLAMPS OF SOME VEHICLES COULD FAIL DUE TO AN OVERHEATED BULB HARNESS CONNECTOR. OTHER VEHICLES MAY LOSE ABS/ESC SYSTEM FUNCTION DUE TO AN OVERHEATED POWER DISTRIBUTION CENTER.
Consequence: THIS COULD LEAD TO LOSS OF VISIBILITY AND/OR BRAKING ABILITY, INCREASING THE RISK OF A CRASH.
Remedy: CHRYSLER WILL NOTIFY OWNERS AND DEALERS WILL REPLACE THE HEADLAMP JUMPER HARNESSES AND RELOCATE THE ABS/ESC SYSTEM FUSE WITHIN THE POWER DISTRIBUTION CENTER, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 2, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA21002 · Desiccated Air Bag Inflator Rupture
Opened Sep 17, 2021 · No close date supplied
Status: open (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
PE14022 · Alternator Failure
Opened Jul 22, 2014 · Closed Nov 6, 2014
Status: closed (inferred from source dates) · Electrical System:alternator/generator/regulator
On July 22, 2014, the Office of Defects Investigation (ODI) opened PE14-022 to investigate 14 complaints (VOQs) alleging incidents of alternator failure resulting in engine stall while driving in model year (MY) 2011 through 2012 Dodge Charger vehicles.The MY 2011 through 2012 Dodge Charger vehicles were sold with three different engine options:1) 3.6L V6 (VIN8 = G), 88,766 vehicles; 2) 5.7L V8 (VIN8 = T), 38,615 vehicles; and 3) 6.4L V8 (VIN8 = J), 2,406 MY 2012 vehicles.The 14 VOQs identified in the PE14-022 opening resume involve 13 vehicles with 3.6L V6 engines and 1 vehicle with unknown engine (no VIN provided).In an October 7, 2014 letter to NHTSA, Chrysler described a safety defect condition that could result in rapid alternator failure having limited or no detection in approximately 434,581 MY 2011 through 2014 Chrysler 300, Dodge Charger, Dodge Challenger, Dodge Durango and Jeep Grand Cherokee vehicles equipped with 3.6L engines and 160 amp alternators (NHTSA Recall No. 14V-634, Chrysler P60).The subject alternators are used in vehicles equipped with 3.6L V6 engines and without towing packages.According to Chrysler, the silicone diodes in the alternator rectifier bridge may experience thermal fatigue due to cyclic loading from the Electric Hydraulic Power Steering (EHPS) system, eventually resulting in no output, reduced output, or a fully shorted to ground condition.These failure modes vary in their time to failure and warning to the driver.Depending on the failure mode and timing, system voltage may drop to critically low levels, disabling systems such as the Anti-lock Brake System/Electronic Stability Control, Engine Control Module/Central Body Controller, or a total vehicle electrical system shut down (in the event of a short to ground failure mode).Analysis of complaints to ODI and Chrysler identified a total of 146 incidents of alternator failure resulting in engine stall while driving in MY 2011 through 2012 Dodge Charger vehicles, including 142 involving vehicles equipped with the 3.6L V6 engines (1.6 IPTV) that were included in 14V-634 and 4 involving vehicles with 5.7L V8 engines (0.1 IPTV), which are equipped with different alternators.Analysis of all alternator failure complaints found that approximately 48 percent of VOQs and 21 percent of Chrysler complaints involved allegations of engine stall.Many (98) complaints reported fire and/or smoke, but analysis of these determined that they involved thermal damage to the alternator diode and did not identify any incidents involving damage beyond the alternator assembly.One VOQ identified in the opening resume for PE14-022 alleged a crash, but further evaluation determined that this involved a minor rear-end impact with slight bumper damage.This investigation is closed based on Chrysler's decision to conduct a safety recall.The VOQs associated with this investigation are:10641479,10641366,10641349,10642017,10640770,10640687,10640553,10639692,10638810,10638356,10638175,10638143,10637460,10633806,10633304,10632943,10632006,10631704,10631613,10631420,10631088,10630991,10630854,10630844,10630108,10629623,10629603,10628228,10628150,10627941,10627342,10626452,10626254,10625962,10622385,10622340,10621603,10620961,10619481,10618950,10618948,10618539,10618476,10618334,10618081,10618107,10616834,10616461,10616456,10615754,10615719,10606580,10605090,10604958,10597295,10592085,10588675,10587141,10562463,10559730,10511407
Illustration