Air Bags. Review the 45 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 45 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine. Review the 32 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

9 crash reports4 fire reports8 injury reports

What owners actually said

174 reports

65,000 miles · Jan 17, 2015

Engine And Engine Cooling

Read full complaint

I BOUGHT MY CAR USED APPROXIMATELY 3 1/2 YEARS AGO. IT WAS DRIVING FINE UP UNTIL ABOUT 6 / 7 MONTHS AGO WHEN IT STARTED STALLING ON ME WHILE DRIVING. IT HAS DONE THIS TO ME AT LEAST 15 TIMES SINCE THEN AND LATELY HAS STARTED TO NOT START. THERE IS HESITATION AT TIMES AND SOMETIMES IT JUST DIES. THE MOST CONCERNING TO ME IS WHEN IT DIES WHILE I'M DRIVING, NO WARNING, AND THEN I LOSE MY POWER STEERING. THE LAST 4 TIMES I'VE BEEN ABLE TO PULL IT OVER AND RESTART IT BUT I HAVE A 4 YEAR OLD CHILD AND I AM FEARFUL OF THIS HAPPENING AND LOOSING CONTROL OF THE CAR. I WILL BE CALLING THE DEALER THIS WEEK BUT AFTER READING THE COMPLAINTS AND THEIR OUTCOMES I'M NOT HOPEFUL THAT THIS ISSUE WILL BE RESOLVED. VERY CONCERNING THAT THIS ISSUE DOES NOT SEEM TO BE CONSIDERED IMPORTANT TO THE MANUFACTURER. *TR

NHTSA ODI #10676248

113,709 miles · Jan 3, 2015

Electrical SystemService BrakesSteering

Read full complaint

I HAVE HAD ANOTHER INCIDENT WHERE THE AUTOMOBILE HAS HAD ANOTHER MECHANICAL MALFUNCTION. I WAS SLOWING DOWN TO TURN AT A STOP LIGHT. IT DIED, RIGHT BEFORE I STARTED MY TURN. THIS IS NOW THE FOURTH INCIDENT WITH THE SAME ISSUE. THANKFULLY I WAS NOT HURT THIS TIME. THOUGH I AM STILL SUFFERING FROM THE INCIDENT FROM DECEMBER 8TH. MY DAUGHTER WAS WITH ME AGAIN WHEN THIS INCIDENT OCCURRED. SHE SAID, "MOM THE LIGHT IS GREEN". I SAID, "I KNOW, THE CAR IS DEAD". I WOULD LIKE TO KNOW WHAT IS BEING DONE, BEFORE SOMEONE GETS KILLED. *TR

NHTSA ODI #10669873

52,985 miles · Dec 17, 2014

Exterior Lighting

Read full complaint

IN AUGUST OF 2011 I HIT A LARGE PIECE OF SEMI TIRE TREAD. I REALIZED BEFORE WE RETURNED HOME TO IOWA THAT I HAD NO TAIL LIGHTS.IN JANUARY 2012 I TOOK MY CAR INTO THE DEALERSHIP WHERE I PURCHASED IT TO FIND OUT WHY THE CAR HAD SUCH A BAD SHINY AND THE TAIL LIGHTS WERE NOT WORKING. THE FRAME WAS BENT FROM THE TIRE,THE TRANSMISSION ALSO T SOME DAMAGE AND OF COURSE THE CAR WAS SERIOUSLY OUT OF ALIGNMENT. WHEN THE CAR WAS RETURNED THE TAIL LIGHTS WERE WORKING. ABOUT A YEAR LATER I WAS PULLED OVER AND GIVEN A WARNING BECAUSE MY TAIL LIGHTS WERE NOT WORKING. I TOOK THE CAR BACK TO THE DEALERSHIP BECAUSE OF THE TAIL LIGHTS. ONCE AGAIN THEY WORKED WHEN I PICKED IT UP AND I DIDN'T THINK ABOUT IT AGAIN. THEN RECENTLY I WAS PULLED OVER AGAIN, NO TAIL LIGHTS AND A WARNING. I MADE AN APPOINTMENT WITH THE DEALERSHIP, TOOK MY CAR IN(THIRD TIME), LIGHTS AND TRUNK WERE WORKING PROPERLY. I DECIDED TO CHECK MY LIGHTS WHEN I GOT HOME AND GUESS WHAT, NO TAIL LIGHTS. I NOW DRIVE WITH MY FLASHERS ON SINCE THE LAST PULLOVER. I AM TAKING THE CAR BACK ON THURSDAY, DECEMBER 18, 2014. THIS IS TRY NO. 4. I ALSO FOUND OUT WITH THAT MY LIFE TIME WARRANTY ON MY CAR NO LONGER EXISTED. I HAD RECEIVED A CARD TO BRING MY CAR IN TO HAVE IT CHECKED OUT. I CALLED THE DEALERSHIP THREE TIMES LEAVING A MESSAGE EACH TIME WHICH INCLUDED MY PHONE NUMBER BUT NEVER RECEIVED A CALL BACK. AT THIS POINT I DECIDED IT MUST NOT BE A BIG DEAL SINCE NO ONE WAS RETURNING MY CALLS. I DON'T BELIEVE THE CAR SAYING ANYTHING ABOUT THIS AFFECTING MY WARRANTY. I DO FEEL FORTUNATE THAT I DON'T HAVE TO DRIVE MY CAR A LOT AFTER SUNDOWN AND THAT I HAVE NOT BEEN AWARENESS IN THE DARK. I WAS INJURED IN 2001 AND DON'T NEED ANY FURTHER INJURIES TO MAKE MY PAIN LEVELS WORSE THAN THEY ARE NOW. I SAW A YOUNG GIRL ON TELEVISION TONIGHT AND IS NOW PARALYZED BECAUSE SOMEONE HIT IN THE REAR END OF HER PARENTS CAR. *TR

NHTSA ODI #10667003

150,000 miles · Dec 9, 2014

Air BagsEngineWheelsCrashInjury

Read full complaint

IN THE LAST FOUR MONTHS, MY 2009 DODGE CHARGER HAS STALLED THREE TIMES WITHOUT WARNING. IT DOESN'T SPUTTER, THEN DIE. IT JUST SHUTS DOWN. THE FIRST TWO TIMES, I WAS DRIVING STRAIGHT. THIS LAST TIME, 12/08/14, I WAS TURNING IN A PARKING LOT. I LOST MY POWER STEERING AND MY POWER BREAKS. I HIT THE CONCRETE BASE OF A LIGHT POLE HARD ENOUGH TO BLOW OUT MY FRONT DRIVER-SIDE TIRE AND BENT THE TIE ROD. THERE IS QUITE A BIT OF DAMAGE TO THE FRONT QUARTER PANEL, BUMPER AND BROKE THE HEADLIGHT. NOT TO MENTION, IT HAS GIVEN ME WHIPLASH. I HAVE NOT SEEKED MEDICAL ATTENTION AT THIS TIME, BUT I HAVE HAD IT BEFORE, AND AM QUITE CERTAIN I HAVE IT AGAIN. I AM NOT CERTAIN AS TO WHY THE AIRBAG DID NOT DEPLOY??? I HAVE READ THAT THIS IS A KNOWN ISSUE, BUT THERE HAS NOT BEEN A RECALL. I HAVE SEEN OTHER ISSUES LISTED ON THIS SITE REGARDING THIS PARTICULAR CAR. I HAVE HAD TO REPLACE A TPMS ON ONE OF MY TIRES AS WELL. I HAVEN'T LOOK AT ALL THE COMPLAINTS. BUT I ALSO HAVE AN ONGOING ISSUE WITH MY CAR NOT STARTING, NUMEROUS TIMES A WEEK. I HAVE TAKEN IT TO THE DEALERSHIP AT LEAST THREE TIMES, AND THEY CANNOT EVER GET IT TO DUPLICATE. WHEN I TURN THE KEY, IT JUST TURNS OVER LIKE IT IS GOING TO START, THEN SHUTS DOWN, WITHOUT A SINGLE SPUTTER. KIND OF LIKE HOW IT IS JUST SHUTTING DOWN WHILE DRIVING. THE DEALERSHIP REPLACED THE BATTERY IN MY KEY THINKING THAT WAS THE ISSUE, NOTHING HAS HELPED. I WOULD LIKE TO ADD MY INFORMATION INTO THE GROUP OF INDIVIDUALS WHO HAVE HAD PROBLEMS WITH THIS PARTICULAR CAR. AFTER TODAY'S INCIDENT, MY HUSBAND WANTS TO GET RID OF IT. I LOVE MY CAR, I JUST DON'T LOVE THE ISSUES I AM HAVING WITH IT, ESPECIALLY NOW THAT I AM HURT. I AM JUST THANKFUL I AM DID NOT HIT OR HURT ANYONE ELSE, DUE TO THIS MECHANICAL FAILURE. *TR

NHTSA ODI #10663025

68,000 miles · Nov 21, 2014

EngineTires

Read full complaint

TL* THE CONTACT OWNS A 2009 DODGE CHARGER. THE CONTACT STATED THAT THE TIRE PRESSURE MONITORING SYSTEM WARNING LIGHT ILLUMINATED AND THE TIRE PRESSURE BECAME LOW. THE CONTACT STATED THAT WHILE DRIVING 5 MPH, THE VEHICLE SHIFTED INDEPENDENTLY FROM DRIVE TO NEUTRAL. THE CONTACT ALSO STATED THAT THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 68,000. MAILED OUT 01/22/15*LJ

NHTSA ODI #10659939

Mileage unknown · Oct 23, 2014

Engine And Engine Cooling

Read full complaint

TWO WEEKS AGO I PURCHASED A 2009 DODGE CHARGER. ON TUESDAY OCTOBER 21, 2014, I ATTEMPTED TO START MY VEHICLE AND FOUND THAT THE ENGINE WOULD NOT START. ON THE INSTRUMENT PANEL I COULD SEE A RED LIGHT BLINK INDICATING THE THEFT SYSTEM WAS ACTIVATED, THE MILEAGE DISPLAYED, AND THE OPEN DOORS INDICATOR WAS ACTIVATED. MY REMOTE ALLOWED ME TO LOCK AND UNLOCK MY DOORS AND OPEN MY TRUNK. I ATTEMPTED TO JUMP START THE BATTERY WHICH WORKED PERFECTLY. I TOOK ADDITIONAL STEPS TO INSURE THE PROBLEM WAS NOT THE BATTERY BY HAVING IT TESTED. THE RESULT WAS 100%. UPON RESEARCHING THE SYMPTOMS ONLINE, I FOUND THERE IS AN ONGOING PROBLEM WITH THE WIN MODULE IN MY VEHICLE. I FOUND MORE THAN 100 COMPLAINTS AND YOUTUBE VIDEOS BY OWNERS WITH THE SAME PROBLEM YET NO RECALL HAS BEEN CREATED. WHEN WILL CHRYSLER LLC BE HELD ACCOUNTABLE FOR THIS KNOWN AND WELL DOCUMENTED PROBLEM WITH 2009 DODGE CHARGERS AND GIVE THEM SOME RELIEF? IT SHOULD ALSO BE NOTED, A RECALL WAS MADE FOR 2008 DODGE CHARGERS FOR THE SAME PROBLEM. I'D LIKE TO KNOW WHAT STEPS I NEED TO TAKE FOR A RECALL TO BE DONE. MY VEHICLE IS CURRENTLY SITTING IDLE. I FEAR HAVING THE SAME EXPERIENCE GM CUSTOMERS HAVE HAD WHERE THE COMPANY IS AWARE OF A MANUFACTURING ISSUE THAT THEY REFUSE TO ADDRESS. I HAVE ALREADY SPOKEN TO CHRYSLER LLC AND MY DODGE DEALERSHIP AND THEY REFUSE TO ISSUE A RECALL EVEN AFTER ACKNOWLEDGING THIS IS AN ONGOING ISSUE WITH 2009 DODGE CHARGERS. ONE EMPLOYEE EVEN STATED, "I'M SURPRISED THEY HAVEN'T DONE A RECALL YET. I'VE FIXED THIS PROBLEM OVER 1000 TIMES IN THE SHORT TIME I'VE BEEN HERE." *TR

NHTSA ODI #10649479

29,800 miles · Oct 5, 2014

Electrical SystemSteering

KEY STUCK IN IGNITION.....HAVE TO WAIT APPROX. 5 TO 30 MINUTES AFTER I STOPPED THE VEHICLE AND IT IS IN PARK .....AND THEN MY DEAR $ 60000 CAR DECIDES TO RELEASE THE KEY. *TR

NHTSA ODI #10641519

42,611 miles · Aug 4, 2014

Tires

Read full complaint

TL* THE CONTACT OWNS A 2009 DODGE CHARGER. THE CONTACT STATED THAT THE TIRE PRESSURE MONITOR SENSORS WOULD NOT TRANSMIT THE ACTUAL TIRE PRESSURE IN THE VEHICLE. THE CONTACT MENTIONED THAT THERE WERE LEAKS COMING FROM TWO TIRE VALVES. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING, WHO STATED THAT THE TPM VALVES NEEDED TO BE REPLACED. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 08V642000 (TIRES) HOWEVER THE VIN WAS NOT INCLUDED IN THE RECALL. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 42,611. ..UPDATED 08-26-14 *BF UPDATED 09/02/2014 *JS

NHTSA ODI #10618667

Mileage unknown · Aug 2, 2014

Tires

VALVE STEM CORRODED AND CAUSED TIRE TO GO FLAT. WAS TOLD BY BELLE TIRE THIS IS A VERY COMMON PROBLEM ON DODGE CHARGERS. VERY DANGEROUS. *TR

NHTSA ODI #10618397

30,000 miles · Jul 21, 2014

StructureVisibility

Read full complaint

WHILE LEAVING THE GAS STATION I HEARD A LOUD CRACKING SOUND COMING FROM THE ROOF. I DID NOT PAY ANY ATTENTION TO THE SOUND UNTIL LATER THAT WEEK WHEN I WASHED THE CAR AND SAW A QUARTER INCH CRACK ON THE ROOF NEXT TO THE SUNROOF. I TOOK THE CAR TO A LOCAL DEALERSHIP TO SHOW THEM THE CRACK AND I WAS TOLD THAT IT WAS NOTHING THEY COULD DO BECAUSE MY CAR WAS OUT OF WARRANTY. I DID SOME SEARCHING ON LINE AND CAME ACROSS MANY CUSTOMERS WITH SIMILAR ISSUES. I DIDN'T PRESS THE ISSUE BECAUSE I DIDN'T KNOW WHAT OPTIONS TO TAKE. MY ROOF IS STARTING TO LEAK DUE TO THE CRACK AND I DEVELOPED ANOTHER CRACK ON THE OPPOSITE SIDE. THE OCCURRENCES OF THE CRACKS IN MY ROOF ARE DUE TO EXTREME FLEXING IN THE FRAME OF THE VEHICLE. IN MY OPINION, THIS IS A STRUCTURAL ISSUE AND A SAFETY CONCERN. I BELIEVE THE VEHICLE IS STRUCTURALLY UNSOUND AND I WOULD LIKE DODGE TO FIX IT OR REPLACE IT. *TR

NHTSA ODI #10615058

Official recalls

18V021000 · Air Bags:frontal:passenger Side:inflator Module

Jan 9, 2018

Chrysler (FCA US LLC) is recalling certain 2009-2013 Jeep Wrangler, Chrysler 300, Dodge Challenger and Dodge Charger vehicles, and 2009-2011 Dodge Dakota vehicles sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." Additionally, Chrysler is recalling certain 2009-2010 RAM 4500 Cab Chassis, RAM 5500 Cab Chassis, RAM 3500 Cab Chassis, Jeep Wrangler, Chrysler 300, Dodge Dakota, Dodge Challenger, and Dodge Charger vehicles ever registered in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." Chrysler is also recalling certain 2009 RAM 3500, RAM 2500, RAM 4500 Cab Chassis, RAM 5500 Cab Chassis, Dodge Durango, Chrysler Aspen, RAM 3500 Cab Chassis, Jeep Wrangler, Chrysler 300, Dodge Dakota, Dodge Challenger, and Dodge Charger vehicles ever registered in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming. In the event of a crash necessitating deployment of the passenger frontal air bag, these passenger air bag inflator may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

Consequence & remedy

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy: Owners are advised not to drive their vehicle until the recall repair is complete. Chrysler will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. The recall began February 28, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U03.

16V352000 · Air Bags:frontal:passenger Side:inflator Module

May 24, 2016

Chrysler (FCA US LLC) expanded the affected population to include 73,712 2005-2009 RAM 2500 trucks produced at the St. Louis North Assembly Plant. With this change, Chrysler is recalling certain model year 2004-2008 RAM 1500, 2005-2009 RAM 2500, 2006-2009 RAM 3500, 2007-2010 RAM 3500 Cab Chassis, 2008-2010 RAM 4500 and 5500 Cab Chassis, 2004-2009 Dodge Durango, 2007-2009 Chrysler Aspen, 2007-2012 Jeep Wrangler, 2008-2012 Dodge Challenger, 2005-2008 Dodge Magnum, 2005-2012 Chrysler 300, 2006-2012 Dodge Charger, 2005-2011 Dodge Dakota, and 2006-2009 Mitsubishi Raider vehicles originally sold, or ever registered, in AL, CA, FL, GA, HI, LA, MS, SC, TX, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Chrysler is also recalling 2004-2008 RAM 1500, 2005-2009 RAM 2500, 2006-2009 RAM 3500, 2007-2009 RAM 3500 Cab Chassis, 2008-2009 RAM 4500 and 5500 Cab Chassis, 2004-2009 Dodge Durango, 2007-2009 Chrysler Aspen, 2007-2009 Jeep Wrangler, 2008-2009 Dodge Challenger, 2005-2008 Dodge Magnum, 2005-2009 Chrysler 300, 2006-2009 Dodge Charger, 2005-2009 Dodge Dakota and 2006-2009 Mitsubishi Raider vehicles originally sold, or ever registered, in AZ, AR, DE, Washington D.C., IL, IN, KS, KY, MD, MO, NE, NV, NJ, NM, NC, OH, OK, PA, TN, VA, and WV, or "Zone B." Lastly, unless included in "Zone A" or "Zone B" above, Chrysler is recalling certain 2005-2008 RAM 2500, 2006-2008 RAM 3500, 2007-2008 RAM 3500 Cab Chassis, 2008 RAM 4500 and 5500 Cab Chassis, 2004-2008 Dodge Durango, 2007-2008 Chrysler Aspen, 2007-2008 Jeep Wrangler, 2008 Dodge Challenger, 2005-2008 Dodge Magnum, 2005-2008 Chrysler 300, 2006-2008 Dodge Charger, 2005-2008 Dodge Dakota, and 2006-2008 Mitsubishi Raider vehicles originally sold, or registered, in AK, CO, CT, ID, IA, ME, MA, MI, MN, MT, NH, NY, ND, OR, RI, SD, UT, VT, WA, WI, and WY.

Consequence & remedy

Consequence: These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. These inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling. An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.

Remedy: Owners are advised not to drive their vehicle until the recall repair is complete. Chrysler will notify the Chrysler, Dodge, Jeep and RAM owners. Mitsubishi owners will be notified by their company. Dealers will replace the passenger frontal air bag inflator, free of charge. The recall began on March 27, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S43. Note: This recall supersedes recall 14V-7700.

15V313000 · Air Bags:frontal:driver Side:inflator Module

May 26, 2015

Chrysler (FCA US LLC) is recalling certain model year 2005-2009 Dodge Ram 2500, 2004-2008 Dodge Ram 1500 and Durango, 2006-2009 Dodge Ram 3500, 2008-2010 Dodge Ram 4500 and 5500, 2007-2008 Chrysler Aspen, 2005-2010 Chrysler 300, 300C, 300S, and SRT8, 2006-2010 Dodge Charger, 2005-2008 Magnum, 2005-2011 Dodge Dakota, and 2006-2009 Mitsubishi Raider vehicles. The affected vehicles are equipped with a dual-stage driver frontal air bag that may be susceptible to moisture intrusion which, over time, could cause the inflator to rupture.

Consequence & remedy

Consequence: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy: Owners are advised not to drive their vehicle until the recall repair is complete. Chrysler will notify the affected Chrysler and Dodge owners and Mitsubishi will notify the affected Raider owners. Dealers will replace the driver's frontal air bag inflator, free of charge. The recall began for Chrylser on June 8, 2015. The recall for Mitsubishi started on June 24, 2015. Chrysler and Dodge owners may contact Chrysler customer service at 1-800-853-1403. Mitsubishi owners may call 1-888-648-7820. Chrysler's number for this recall is R25. Note: This recall supersedes recall 14V817 in its entirety. Vehicles that have had their driver side frontal air bag replaced previously need to have their air bag replaced under this recall as well.

09V420000 · Wheels:lugs/nuts/bolts/studs

Oct 29, 2009

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2009 THROUGH 2010 PASSENGER VEHICLES EQUIPPED WITH REAR WHEEL DRIVE. THESE VEHICLES MAY HAVE BEEN BUILT WITHOUT A FRONT WHEEL SPINDLE NUT.

Consequence & remedy

Consequence: WHILE DRIVING, A TIRE AND WHEEL SEPARATION COULD OCCUR INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSPECT THE TIRE AND WHEEL ASSEMBLY AND IF FOUND WITHOUT A SPINDLE NUT IT WILL BE REPAIRED FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 2, 2009. OWNERS MAY CONTACT CHRYSLER AT 1-800-835-1403.

08V642000 · Tires:pressure Monitoring And Regulating Systems

Dec 5, 2008

CHRYSLER IS RECALLING 175 MY 2009 DODGE CHARGER, CHALLENGER, AND CHRYSLER 300 VEHICLES. THE TIRE PRESSURE MONITOR (TPM) SENSORS MAY NOT TRANSMIT THE ACTUAL TIRE PRESSURE. THIS COULD RESULT IN THE DRIVER NOT BEING AWARE OF LOW TIRE PRESSURE.

Consequence & remedy

Consequence: OPERATION OF THE VEHICLE WITH LOW TIRE PRESSURE COULD RESULT IN TIRE DAMAGE AND CAUSE A CRASH WITHOUT WARNING.

Remedy: DEALERS WILL REPLACE THE TPM SENSORS. THE RECALL IS EXPECTED TO BEGIN ON FEBRUARY 9, 2009. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

08V583000 · Power Train:automatic Transmission:lever And Linkage:column Shift

Nov 6, 2008

CHRYSLER IS RECALLING 20,283 MY 2006-2009 CHARGER AND MAGNUM VEHICLES BUILT WITH THE POLICE PACKAGE AND EQUIPPED WITH A COLUMN SHIFTER. THE GEARSHIFT CABLE MAY BECOME DISENGAGED FROM THE STEERING COLUMN MOUNTING BRACKET AND CAUSE AN INCORRECT TRANSMISSION GEARSHIFT POSITION DISPLAY.

Consequence & remedy

Consequence: THIS COULD ALLOW THE VEHICLE TO MOVE IN AN UNEXPECTED DIRECTION STARTLING THE DRIVER, AND CAUSE A CRASH WITHOUT WARNING.

Remedy: DEALERS WILL ADD A REDUNDANT LOCKING MECHANISM TO THE GEARSHIFT CABLE AT THE MOUNTING BRACKET TO ENSURE PROPER RETENTION AND SHIFT LINKAGE FUNCTION. THE RECALL BEGAN ON NOVEMBER 10, 2008. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

EA21002 · Desiccated Air Bag Inflator Rupture

Opened Sep 17, 2021 · No close date supplied

Status: open (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.

Additional source detail variants (2)

Air Bags:frontal:driver Side:inflator Module

Air Bags:frontal:passenger Side:inflator Module

PE08052 · Prndl Misalignment

Opened Sep 2, 2008 · Closed Nov 10, 2008

Status: closed (inferred from source dates) · Power Train:automatic Transmission:lever And Linkage:column Shift

IN A NOVEMBER 5, 2008 LETTER, CHRYSLER SUBMITTED A DEFECT INFORMATION REPORT DESCRIBING A DEFECT CONDITION THAT COULD RESULT IN PRNDL MISALIGNMENT (I.E., INCORRECT GEAR INDICATION) IN APPROXIMATELY 20,300 MODEL YEAR (MY) 2006 THROUGH 2009 DODGE CHARGER AND MAGNUM POLICE VEHICLES BUILT FROM MAY 17, 2005 THROUGH OCTOBER 21, 2008 (NHTSA RECALL NO. 08V-583, CHRYSLER RECALL H37).ACCORDING TO CHRYSLER, THE GEARSHIFT CABLE MAY BECOME DISENGAGED FROM THE STEERING COLUMN MOUNTING BRACKET AND CAUSE AN INCORRECT TRANSMISSION GEARSHIFT POSITION DISPLAY.THIS COULD ALLOW THE VEHICLE TO MOVE INADVERTENTLY AND CAUSE A CRASH WITHOUT WARNING.CHRYSLER DEALERS WILL REMEDY THE DEFECT CONDITION BY INSTALLING A REDUNDANT LOCKING MECHANISM TO THE GEARSHIFT CABLE AND THE MOUNTING BRACKET TO ENSURE PROPER RETENTION AND SHIFT LINKAGE FUNCTION. CHRYSLER USES A UNIQUE COLUMN SHIFTER IN THESE POLICE VEHICLES.AFTER PE08-052 WAS OPENED, CHRYSLER INSPECTED A MY 2009 POLICE VEHICLE AND NOTED THAT THOUGH THE GEARSHIFT CABLE APPEARED FULLY SEATED INTO THE STEERING COLUMN MOUNTING BRACKET, THE CABLE RETENTION FEATURE (LOCKING PIN) WAS NOT FULLY SEATED.CHRYSLER SUBSEQUENTLY DETERMINED THAT IF THE RETENTION FEATURE IS NOT FULLY SEATED, THE CABLE MAY DISENGAGE FROM THE MOUNTING BRACKET, RESULTING IN THE SHIFT LINKAGE SYSTEM NOT FUNCTIONING TO DESIGN INTENT WITH THE POTENTIAL FOR INCORRECT GEAR POSITION INDICATION VIA THE PRNDL DISPLAY.CHYSLER'S INSPECTION OF 59 MY 2009 DODGE CHARGER AND MAGNUM POLICE VEHICLES IN SEPTEMBER AND OCTOBER FOUND 30 WHERE THE GEARSHIFT CABLE WAS NOT FULLY ENGAGED TO THE MOUNTING BRACKET.THERE ARE NO REPORTED CRASHES OR INJURIES RELATED TO THE DEFECT CONDITION TO DATE. THIS INVESTIGATION IS CLOSED.