NHTSA owner reports · September 18, 2026 snapshot.
Power Train complaints
133 reportsClear category filterMileage unknown · Jul 5, 2001
Electrical SystemFuel System, GasolinePower TrainFire
WHILE DRIVING AT 25 MPH CONSUMER NOTICED WHITE SMOKE COMING FROM TAIL PIPE. THEN, WHITE SMOKE AND FLAMES WERE COMING FROM UNDER THE HOOD. CONSUMER STOPPED CAR AND TURNED IGNITION OFF. CONSUMER EXITED THE CAR, AND VEHICLE CAUGHT ON FIRE. CONSUMER FEELS THIS MAY RELATED TO RECALL FOR FUEL LEAKAGE. *AK CONSUMER STATES VEHICLE…
Read full complaint
WHILE DRIVING AT 25 MPH CONSUMER NOTICED WHITE SMOKE COMING FROM TAIL PIPE. THEN, WHITE SMOKE AND FLAMES WERE COMING FROM UNDER THE HOOD. CONSUMER STOPPED CAR AND TURNED IGNITION OFF. CONSUMER EXITED THE CAR, AND VEHICLE CAUGHT ON FIRE. CONSUMER FEELS THIS MAY RELATED TO RECALL FOR FUEL LEAKAGE. *AK CONSUMER STATES VEHICLE WAS IN SHOP FOR TRANSMISSION PROBLEMS ON FEBRUARY 16TH, 2001. *SLC
NHTSA ODI #892015
Mileage unknown · Jun 21, 2001
Power Train
WHILE DRIVING VEHICLE SUDDENLY SLOWED DOWN AND EVENTUALLY STOPPED. AFTER DEALER INSPECTED VEHICLE IT WAS DETERMINED THAT GEAR HAD BROKEN, AFFECTING TRANSMISSION.*AK
NHTSA ODI #890900
Mileage unknown · Jun 12, 2001
Air BagsElectrical SystemPower Train
I HAVE EXPERIENCED FAILURES IN MY STEERING COLMN WHICH DOES NOT ALLOW ME TO USE MY HORN, CRUISE CONTROL, AND I AM AFRAID THAT MY AIR BAG DOES NOT WORK. THE AIRBAG LIGHT STAYS ON ALONG WITH ABS AND INTERMITANT OTHER LIGHTS. I HAVE HAD TO REPAIR MY TRANSMISSION AND IT STILL DOES NOT WORK PROPERLY. SLIPPING FROM TIME TO TIME. THE R…
Read full complaint
I HAVE EXPERIENCED FAILURES IN MY STEERING COLMN WHICH DOES NOT ALLOW ME TO USE MY HORN, CRUISE CONTROL, AND I AM AFRAID THAT MY AIR BAG DOES NOT WORK. THE AIRBAG LIGHT STAYS ON ALONG WITH ABS AND INTERMITANT OTHER LIGHTS. I HAVE HAD TO REPAIR MY TRANSMISSION AND IT STILL DOES NOT WORK PROPERLY. SLIPPING FROM TIME TO TIME. THE REAR A/C FAN SWITCH ONLY WORKS IN THE LOW AND HIGH POSITION. TRASSMISION GIVES OFF A BURNING SMELL WHEN HOT.*AK
NHTSA ODI #746743
Mileage unknown · Jun 4, 2001
Air BagsElectrical SystemEngine And Engine Cooling
VEHICLE EXPERIENCED SEVERAL ELECTRICAL PROBLEMS: WINDSHIELD WIPERS INOPERABLE DUE TO A SHORT IN SWITCH, RADIATOR FAN RELAY REPLACED, GROUND WIRE LOOSE IN ENGINE CAUSING DASH CLUSTER TO GO HAYWIRE, HORN, POWER WINDOWS, RADIO, SPEEDOMETER, AND AIR CONDITIONER INOPERABLE AT TIMES. *SLC
NHTSA ODI #561449
Mileage unknown · May 22, 2001
Power Train
CONSUMER WAS PULLING INTO GARAGE AND HEARD A NOISE COMING FROM UNDERNEATH OF VEHICLE. IT WAS A BROKEN PIN FROM TRANSMISSION. DEALERSHIP TOLD HER THAT TRANSMISSION HAD TO BE REPLACED.*AK
NHTSA ODI #888862
Mileage unknown · May 1, 2001
Power Train
AFTER STOPPING AT LIGHT, VAN WOULD NOT MOVE. VAN TOWED TO DEALERSHIP. OWNER TOLD THAT VAN NEEDED A NEW TRANSMISSION.
NHTSA ODI #9002069
Mileage unknown · May 1, 2001
Power Train
3RD GEAR CLUTCH PACK IN TRANSMISSION FAILED AND VEHICLE STUCK IN SECOND GEAR. RESEARCH HAS SHOWN THAT THESE TRANSMISSIONS HAVE AN EXTREMELY HIGH FAILURE RATE AT LOW MILEAGE.*AK
NHTSA ODI #744776
Mileage unknown · Apr 16, 2001
Power Train
WHILE DRIVING 25 MPH IN MIDDLE OF INTERSECTION VEHICLE STOPPED MOVING, BUT ENGINE WAS RUNNING. TTOK VEHICLE TO DEALER WHO FOUND THAT TRANSMISSION NEEDED TO BE REPLACED.*AK
NHTSA ODI #885946
Mileage unknown · Mar 23, 2001
Air BagsElectrical SystemEngine And Engine Cooling
AIRBAG LIGHT CAME ON AND HORN STOPPED WORKING, MECHANIC STATED CLOCK SPRING ASSEMBLY NEEDED TO BE REPLACED. *AK ALSO CONSUMER WAS HAVING PROBLEM WITH THE RADIO THAT HAS BEEN WORKED ON FIVE TIMES AND REPLACED TWICE AND STILL DOESNOT WORK TO CONSUMER'S SATISFACTION, CONSUMER ALSO HAD BRAKES REPLACED, ALSO THE TENSIONER BELT ON…
Read full complaint
AIRBAG LIGHT CAME ON AND HORN STOPPED WORKING, MECHANIC STATED CLOCK SPRING ASSEMBLY NEEDED TO BE REPLACED. *AK ALSO CONSUMER WAS HAVING PROBLEM WITH THE RADIO THAT HAS BEEN WORKED ON FIVE TIMES AND REPLACED TWICE AND STILL DOESNOT WORK TO CONSUMER'S SATISFACTION, CONSUMER ALSO HAD BRAKES REPLACED, ALSO THE TENSIONER BELT ON THE TIMING BELT, ALSO THE WATER PUMP BROKE, ALSO TRANSMISSION WENT OUT.*JB
NHTSA ODI #884000
Mileage unknown · Mar 22, 2001
Engine And Engine CoolingPower Train
WHEN DRIVING IN A PARKING LOT AND ATTEMPTING TO PULL INTO A PARKING SPACE CONSUMER NOTICED A NOISE COMING FROM FRONT END, PLACED VEHICLE IN REVERSE AND VEHICLE WOULD NOT RESPOND, THEN PLACED VEHICLE IN DRIVE, AND THE VEHICLE WOULD NOT RESPOND IN DRIVE, CONSUMER CONTACTED DEALER AND DEALER NOTICED MAJOR PROBLEMS WITHIN TRANSMIS…
Read full complaint
WHEN DRIVING IN A PARKING LOT AND ATTEMPTING TO PULL INTO A PARKING SPACE CONSUMER NOTICED A NOISE COMING FROM FRONT END, PLACED VEHICLE IN REVERSE AND VEHICLE WOULD NOT RESPOND, THEN PLACED VEHICLE IN DRIVE, AND THE VEHICLE WOULD NOT RESPOND IN DRIVE, CONSUMER CONTACTED DEALER AND DEALER NOTICED MAJOR PROBLEMS WITHIN TRANSMISSION AND OIL PAN, TRANSMISSION NEEDED REPLACING. *AK *SLC
NHTSA ODI #883756
Official recalls
7Nov 7, 2002
ON CERTAIN MINI VANS, THE CLOCKSPRING ASSEMBLY MAY HAVE BEEN WOUND INCORRECTLY DURING THE VEHICLE ASSEMBLY PROCESS.
Consequence & remedy
Consequence: THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL VEHICLES WITH 70,000 MILES OR LESS. AN EXTENDED LIFETIME WARRANTY WILL ALSO BE PLACED ON THIS COMPONENT FOR ALL AFFECTED VEHICLES, REGARDLESS OF MILEAGE. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. OWNER NOTIFICATION BEGAN NOVEMBER 18, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Mar 8, 2002
ON CERTAIN MINIVANS, SOME TRIM MATERIAL CAN LOOSEN AND DROP INTO THE REAR OUTBOARD SEAT BELT ASSEMBLY, CAUSING THE SEAT BELT TO BECOME INOPERATIVE.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE TRIM WITH FOAM BLOCKERS AND INSPECT AND REPLACE ALL 3RD ROW SEAT BELT ASSEMBLIES. OWNER NOTIFICATION BEGAN JUNE 3, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Sep 13, 2000
VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A SEAL ON THE VEHICLE FUEL RAILS TO PREVENT EXTERNAL LEAKAGE OF FUEL FROM THE FUEL RAIL CROSSOVER TUBE, SHOULD THE EXISTING O-RINGS CONTINUE TO DEGRADE. OWNER NOTIFICATION BEGAN ON JANUARY 25, 2002. DUE TO THE LARGE QUANTITY OF VEHICLES INVOLVED IN THIS CAMPAIGN, THE OWNER NOTIFICATION WILL BE PHASED OVER THE NEXT SEVERAL MONTHS. HOWEVER, IF A VEHICLE IS LEAKING FUEL FROM THE O-RINGS, THE VEHICLE SHOULD BE TAKEN INTO A DEALER TO HAVE THIS REPAIRED AS SOON AS POSSIBLE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Aug 6, 1998
VEHICLE DESCRIPTION: MINI VANS EQUIPPED WITH INTEGRATED CHILD SEATS. THE SHOULDER HARNESS RESTRAINT ON THE INTEGRATED CHILD SEAT CAN BECOME DIFFICULT TO EXTRACT WHEN THE SAFETY BELT LATCH PLATE BECOMES CONTAMINATED.
Consequence & remedy
Consequence: THIS CAN CAUSE DIFFICULTY IN RELEASING A CHILD FROM THE RESTRAINT.
Remedy: DEALERS WILL CLEAN THE LATCH MECHANISM. AN EXTENDER WILL BE ADDED TO THE EMERGENCY RELEASE ANCHOR FOR THE CHILD SEAT SAFETY BELTS SO THAT THE RELEASE CLIPS ARE MORE VISIBLE AND ACCESSIBLE TO THE OPERATOR IN THE EVENT THAT THE RETRACTOR MECHANISM CAN NOT BE UNLOCKED. IN ADDITION, AN INSTRUCTIONAL OWNER'S MANUAL SUPPLEMENT CARD WILL BE PROVIDED.
Nov 13, 1997
VEHICLE DESCRIPTION: PASSENGER MINIVANS EQUIPPED WITH P215/65R15 GOODYEAR CONQUEST TIRES MOUNTED ON STEEL WHEEL. THE TIRES CAN EXPERIENCE A SUDDEN AIR PRESSURE LOSS WITHOUT WARNING.
Consequence & remedy
Consequence: SUDDEN TIRE FAILURE COULD RESULT IN A LOSS OF DRIVER CONTROL OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE TIRES THAT WERE MOUNTED ON STEEL WHEELS.
Apr 28, 1997
THE STEEL ROAD WHEELS WERE DAMAGED BY THE EQUIPMENT USED TO MATCH MOUNT THE WHEEL TO THE TIRE.
Consequence & remedy
Consequence: A SCORE MARK WAS MADE ON THE WHEEL, AFFECTING THE DURABILITY OF THE WHEEL.
Remedy: DEALERS WILL REPLACE ALL ROAD WHEELS (AND FULL SIZE SPARE TIRES) WITH NEW WHEELS.
Oct 29, 1996
THE MASTER CYLINDER REAR SEAL, BETWEEN THE HYDRAULIC FLUID AND THE VACUUM RESERVOIR, MAY NOT SEAL ADEQUATELY ALLOWING HYDRAULIC FLUID TO BE DRAWN INTO THE POWER ASSIST VACUUM RESERVOIR.
Consequence & remedy
Consequence: AS THE HYDRAULIC FLUID IN THE MASTER CYLINDER RESERVOIR DECREASES, THE LEVEL SENSOR WILL DETECT THE LOSS OF FLUID AND ILLUMINATE THE INSTRUMENT PANEL BRAKE WARNING LAMP. CONTINUED OPERATION OF THE VEHICLE WITH THE WARNING LAMP ILLUMINATED CAN RESULT IN EXTENDED STOPPING DISTANCES.
Remedy: DEALERS WILL REPLACE THE BRAKE MASTER CYLINDER ON ALL AFFECTED VEHICLES. ADDENDUM (4-14-97): VEHICLES INSPECTED PER CHRYSLER RECALL NO. 707 AND FOUND TO BE OUTSIDE THE LISTED SUSPECT MASTER CYLINDER DATE CODE RANGE, MUST NOW HAVE THE MASTER CYLINDER PRIMARY PISTON REPLACED (CHRYSLER RECALL NO. 714).
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
7PE02004 · Rear Seat Belt Malfunction
Opened Jan 16, 2002 · Closed Mar 11, 2002
Status: closed (inferred from source dates) · Seat Belts:rear/other
THIS INVESTIGATION WAS OPENED JANUARY 16, 2002, BASED ON SEVEN REPORTS ALLEGING THE THIRD ROW SEAT BELT RETRACTORS FAILED ON CERTAIN 1997 AND 1998 MODEL YEAR CARAVAN AND VOYAGER VEHICLES.THE REPORTS INDICATED A TAR LIKE SUBSTANCE ENTERED THE RETRACTOR MECHANISM, THUS CAUSING THE RETRACTOR TO JAM OR BIND.IN THIS CONDITION THE SEAT BELT IS RENDERED INOPERABLE, AS THE WEBBING CANNOT RETRACT OR BE WITHDRAWN FROM THE RETRACTORS FOR USE.RECALL SCOPE:THE AFFECTED VEHICLES ARE 1997 THROUGH 1999 DODGE CARAVAN, PLYMOUTH VOYAGER, AND CHRYSLER TOWN & CONTRY BUILT ON A SHORT WHEEL BASE CHASSIS.THE INCLUSIVE DATES OF PRODUCTION ARE JUNE 1996 THROUGH OCTOBER 31, 1999.RECALL REMEDY: DAIMLERCHRYSLER DEALERS WILL REPLACE THE MASTIC SOUND BARRIER PATCHES WITH FOAM BLOCKERS, AS WELL AS, INSPECT AND REPLACE ALL THIRD ROW REAR SEAT BELT ASSEMBLIES CONTAMINATED BY THE MASTIC PATCH.
EA01007 · Air Bag Clockspring
Opened Feb 21, 2001 · Closed Nov 22, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
RQ00008 · Dc Minivan Fuel Injector Rail Leak
Opened Mar 9, 2000 · Closed Mar 18, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
EA99013 · Post Collision Fuel System
Opened Jun 11, 1999 · Closed Aug 10, 2001
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
No summary supplied.
PE99010 · POST-COLLISION Fuel System Integrity
Opened Feb 3, 1999 · Closed Jun 11, 1999
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
There is no summary currently available
EA97003 · Integrated Child Seat Belt Lockup
Opened Jan 31, 1997 · Closed Aug 19, 1998
Status: closed (inferred from source dates) · Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
Additional source detail variants (2)
Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
SQ96016 · Integrated Child Seat Belt Lockup
Opened Sep 18, 1996 · Closed Feb 4, 1997
Status: closed (inferred from source dates) · Seat Belts:integrated Child Seat
ODI CONTINUES TO RECEIVE COMPLAINTS ALLEGING LATCHING/RETRACTOR MECHANISM PROBLEMS.CHRYSLER'S ASSESSMENT OF THE PROBLEM INDICATES THAT OWNERS OF THE VEHICLES ARE NOT ADHERING TO THE CLEANING REQUIREMENTS FOR THE SEAT.THE SEAT APPEARS TO MALFUNCTION IF CRUMBS OF FOOD OR BEVERAGE RESIDUE ACCUMULATES ON THE LATCHING TONGUE IN THEWELL LOCATED BETWEEN THE CHILD'S LEGS.ODI HAS 19 COMPLAINTS OF RETRACT LOCKUP.SEVEN OF THESE COMPLAINTS REPORT CUTTING THE STRAPS TO REMOVE THE CHILD.TWO OF THE SEVEN CONSUMERS ALLEGE THE CHILD WAS CHOKING.CHRYSLER REPORTS 60 OWNER/FIELD REPORTS WHICH INDICATED 19 HARNESSES WERE CUT TO REMOVE THE CHILDREN.ADDITIONAL INFORMATION IS NEEDED TO FULLY ASSESS THE SAFETY CONSEQUENCE OF THE ALLEGED DEFECT AND TO EVALUATE THE CHRYSLER CORPORATION'S RATIONAL FOR NOT CONDUCTING A SAFETY RECALL CAMPAIGN.
Illustration