IllustrationWARNING LIGHTS MALFUNCTIONED, CAUSING BRAKE LIGHTS TO FLASH INTERMITTENTLY, AND AIR BAG SENSOR TO STAYS ON. *AK THE BRAKE LIGHT FLASHED, THE ENGINE LIGHT AND AIR BAG LIGHT ILLUMINATED AND THE HORN WAS INOPERATIVE. THE AIR BAG AND HORN PROBLEM MAY BE THE RESULT OF A CLOCKSPRING FAILURE. *PH *NLM
1997 Dodge Caravan
Owner reports · Recalls · Investigations
More warning signs than most Caravan years
Owner complaints for the 1997 Dodge Caravan are substantially higher than the model-year median of 182.
About this comparison →How this year compares
Owner complaints by model year
Compare all Caravan years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 113 of 714 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 152 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 133 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 123 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
43 crash reports36 fire reports39 injury reports
Air Bags complaints
152 reportsTHE DEALERSHIP IS REFUSING TO HONOR RECALL 02V293000 FOR THE AIR BAG CLOCKSPRING, INDICATING THAT THERE WASN'T ANY RECALL ALTHOUGH THE CONSUMER PROVIDED THE RECALL LETTER.*AK
WHILE DRIVING 35 MPH THE VEHICLE WAS INVOLVED IN A FRONTAL COLLISION. UPON IMPACT THE AIR BAGS DIDN'T DEPLOY AND THE THIRD ROW SEAT SEPARATED FROM THE TRACK AN SLID FORWARD. NO INJURIES WERE REPORTED. *AK *NLM
WHILE DRIVING AT 35 MPH VEHICLE WAS IN A FRONTAL COLLISION. NONE OF THE FRONTAL AIR BAGS DEPLOYED UPON IMPACT. DRIVER SUSTAINED SERIOUS LIFETIME INJURIES FROM IMPACTING THE STEERING WHEEL.*AK
WINDSHIELD WIPERS COME ON BY THEMSELVES ALL THE TIME, SOMETIMES THEY STOP AFTER A FEW SWIPES AND SOMETIMES I NEED TO TURN THE SWITCH ON AND THEN OFF AGAIN TO MAKE THEM STOP. SO FAR THEY HAVE WORKED WHEN I NEEDED THEM BUT IT MAY ONLY BE A MATTER OF TIME BEFORE COMPLETE FAILURE. THIS SHOULD BE A RECALL ITEM, IT IS VERY UNSAFE! (…
Read full complaint
WINDSHIELD WIPERS COME ON BY THEMSELVES ALL THE TIME, SOMETIMES THEY STOP AFTER A FEW SWIPES AND SOMETIMES I NEED TO TURN THE SWITCH ON AND THEN OFF AGAIN TO MAKE THEM STOP. SO FAR THEY HAVE WORKED WHEN I NEEDED THEM BUT IT MAY ONLY BE A MATTER OF TIME BEFORE COMPLETE FAILURE. THIS SHOULD BE A RECALL ITEM, IT IS VERY UNSAFE! (1999) AIRBAG LIGHT COMES ON AND STAYS ON NEARLY ALL THE TIME NOW. (JUN 2003) SLIDING DOOR LOCK DOESN'T ALWAYS ENGAGE OR DISENGAGE WHEN USING THE POWER LOCKS. *JB
CLOCK SPRING REPLACEMENT / CONSUMER REQUESTED REIMBURSEMENT FOR REPAIRS. *MR THE VEHICLE WAS TRADED TO CONSUMER WITH THE AIRBAG LIGHT ON. UPON DIAGNOSING THE PROBLEM, THE AIR BAG CLOCK SPRING WAS BROKEN. *TS. ALSO THE RIGHT AXLE OUTPUT SHAFT LEAKED OIL, AND THE ENGINE LIGHT ILLUMINATED ON THE DASH BOARD, THE DEALER REPLACED THE…
Read full complaint
CLOCK SPRING REPLACEMENT / CONSUMER REQUESTED REIMBURSEMENT FOR REPAIRS. *MR THE VEHICLE WAS TRADED TO CONSUMER WITH THE AIRBAG LIGHT ON. UPON DIAGNOSING THE PROBLEM, THE AIR BAG CLOCK SPRING WAS BROKEN. *TS. ALSO THE RIGHT AXLE OUTPUT SHAFT LEAKED OIL, AND THE ENGINE LIGHT ILLUMINATED ON THE DASH BOARD, THE DEALER REPLACED THE SPARK PLUGS. *JB
IN JANUARY 2003, I RECEIVED A RECALL NOTICE FROM CHRYSLER FOR THE AIR BAG CLOCK SPRING ON MY 1997 DODGE CARAVAN. THE NOTICE SAID THAT IF I HAD ALREADY HAD THE CLOCK SPRING REPLACED ( I HAD), THAT I SHOULD SUBMIT THE REQUESTED INFORMATION AND THEY WOULD PAY ME BACK. I SENT THIS INFORMATION ON JANUARY 12, 2003 TO THE ADDRESS ON TH…
Read full complaint
IN JANUARY 2003, I RECEIVED A RECALL NOTICE FROM CHRYSLER FOR THE AIR BAG CLOCK SPRING ON MY 1997 DODGE CARAVAN. THE NOTICE SAID THAT IF I HAD ALREADY HAD THE CLOCK SPRING REPLACED ( I HAD), THAT I SHOULD SUBMIT THE REQUESTED INFORMATION AND THEY WOULD PAY ME BACK. I SENT THIS INFORMATION ON JANUARY 12, 2003 TO THE ADDRESS ON THE RECALL NOTICE. THE REPAIR COST $142.22.I HEARD NOTHING UNTI APRIL 4, 2003, WHEN I RECEIVED A LETTER ASKING FOR THE SAME COPIES I HAD SUBMITTED IN JANUARY. I RESENT THEM, AND HAVE HEARD NOTHING SINCE. IT HAS NOW BEEN SIX MONTHS SINCE I RECEIVED THE ORIGINAL NOTICE FROM CHRYSLER (REFERENCE # 10925018-VR102141-B24) AND STILL HAVE NO REIMBURSEMENT. IT APPEARS CHRYSLER HAS NO INTENTION OF COMPLYING WITH THE INFORMATION IN THEIR RECALL NOTICE. WHAT SHOULD I DO?*AK
THE VEHICLE HIT A CONCRETE WALL, AND THE DRIVER'S AIR BAG FAILED TO DEPLOY. *JB
THE VEHICLES CLOCK SPRING FAILED PRIOR TO RECALL NOTICE 02V-293000. THE CONSUMER REQUESTED REIMBURSEMENT BUT ONLY RECEIVED PARTIAL REIMBURSEMENT. *MR *SCC *NLM
THE VEHICLE CLOCK SPRING FAILED PRIOR TO RECALL NOTICE #B24. THE CONSUMER REQUESTED REIMBURSEMENT. *AK *NLM
Official recalls
702V293000 · Air Bags:frontal
Nov 7, 2002
ON CERTAIN MINI VANS, THE CLOCKSPRING ASSEMBLY MAY HAVE BEEN WOUND INCORRECTLY DURING THE VEHICLE ASSEMBLY PROCESS.
Consequence & remedy
Consequence: THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL VEHICLES WITH 70,000 MILES OR LESS. AN EXTENDED LIFETIME WARRANTY WILL ALSO BE PLACED ON THIS COMPONENT FOR ALL AFFECTED VEHICLES, REGARDLESS OF MILEAGE. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. OWNER NOTIFICATION BEGAN NOVEMBER 18, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
02V076000 · Seat Belts:rear/other
Mar 8, 2002
ON CERTAIN MINIVANS, SOME TRIM MATERIAL CAN LOOSEN AND DROP INTO THE REAR OUTBOARD SEAT BELT ASSEMBLY, CAUSING THE SEAT BELT TO BECOME INOPERATIVE.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE TRIM WITH FOAM BLOCKERS AND INSPECT AND REPLACE ALL 3RD ROW SEAT BELT ASSEMBLIES. OWNER NOTIFICATION BEGAN JUNE 3, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
00V268000 · Fuel System, Gasoline:fuel Injection System
Sep 13, 2000
VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A SEAL ON THE VEHICLE FUEL RAILS TO PREVENT EXTERNAL LEAKAGE OF FUEL FROM THE FUEL RAIL CROSSOVER TUBE, SHOULD THE EXISTING O-RINGS CONTINUE TO DEGRADE. OWNER NOTIFICATION BEGAN ON JANUARY 25, 2002. DUE TO THE LARGE QUANTITY OF VEHICLES INVOLVED IN THIS CAMPAIGN, THE OWNER NOTIFICATION WILL BE PHASED OVER THE NEXT SEVERAL MONTHS. HOWEVER, IF A VEHICLE IS LEAKING FUEL FROM THE O-RINGS, THE VEHICLE SHOULD BE TAKEN INTO A DEALER TO HAVE THIS REPAIRED AS SOON AS POSSIBLE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
98V185000 · Child Seat
Aug 6, 1998
VEHICLE DESCRIPTION: MINI VANS EQUIPPED WITH INTEGRATED CHILD SEATS. THE SHOULDER HARNESS RESTRAINT ON THE INTEGRATED CHILD SEAT CAN BECOME DIFFICULT TO EXTRACT WHEN THE SAFETY BELT LATCH PLATE BECOMES CONTAMINATED.
Consequence & remedy
Consequence: THIS CAN CAUSE DIFFICULTY IN RELEASING A CHILD FROM THE RESTRAINT.
Remedy: DEALERS WILL CLEAN THE LATCH MECHANISM. AN EXTENDER WILL BE ADDED TO THE EMERGENCY RELEASE ANCHOR FOR THE CHILD SEAT SAFETY BELTS SO THAT THE RELEASE CLIPS ARE MORE VISIBLE AND ACCESSIBLE TO THE OPERATOR IN THE EVENT THAT THE RETRACTOR MECHANISM CAN NOT BE UNLOCKED. IN ADDITION, AN INSTRUCTIONAL OWNER'S MANUAL SUPPLEMENT CARD WILL BE PROVIDED.
97V200000 · Tires:bead
Nov 13, 1997
VEHICLE DESCRIPTION: PASSENGER MINIVANS EQUIPPED WITH P215/65R15 GOODYEAR CONQUEST TIRES MOUNTED ON STEEL WHEEL. THE TIRES CAN EXPERIENCE A SUDDEN AIR PRESSURE LOSS WITHOUT WARNING.
Consequence & remedy
Consequence: SUDDEN TIRE FAILURE COULD RESULT IN A LOSS OF DRIVER CONTROL OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE TIRES THAT WERE MOUNTED ON STEEL WHEELS.
97V070000 · Wheels:rim
Apr 28, 1997
THE STEEL ROAD WHEELS WERE DAMAGED BY THE EQUIPMENT USED TO MATCH MOUNT THE WHEEL TO THE TIRE.
Consequence & remedy
Consequence: A SCORE MARK WAS MADE ON THE WHEEL, AFFECTING THE DURABILITY OF THE WHEEL.
Remedy: DEALERS WILL REPLACE ALL ROAD WHEELS (AND FULL SIZE SPARE TIRES) WITH NEW WHEELS.
96V215000 · Service Brakes, Hydraulic:foundation Components:master Cylinder
Oct 29, 1996
THE MASTER CYLINDER REAR SEAL, BETWEEN THE HYDRAULIC FLUID AND THE VACUUM RESERVOIR, MAY NOT SEAL ADEQUATELY ALLOWING HYDRAULIC FLUID TO BE DRAWN INTO THE POWER ASSIST VACUUM RESERVOIR.
Consequence & remedy
Consequence: AS THE HYDRAULIC FLUID IN THE MASTER CYLINDER RESERVOIR DECREASES, THE LEVEL SENSOR WILL DETECT THE LOSS OF FLUID AND ILLUMINATE THE INSTRUMENT PANEL BRAKE WARNING LAMP. CONTINUED OPERATION OF THE VEHICLE WITH THE WARNING LAMP ILLUMINATED CAN RESULT IN EXTENDED STOPPING DISTANCES.
Remedy: DEALERS WILL REPLACE THE BRAKE MASTER CYLINDER ON ALL AFFECTED VEHICLES. ADDENDUM (4-14-97): VEHICLES INSPECTED PER CHRYSLER RECALL NO. 707 AND FOUND TO BE OUTSIDE THE LISTED SUSPECT MASTER CYLINDER DATE CODE RANGE, MUST NOW HAVE THE MASTER CYLINDER PRIMARY PISTON REPLACED (CHRYSLER RECALL NO. 714).
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
7PE02004 · Rear Seat Belt Malfunction
Opened Jan 16, 2002 · Closed Mar 11, 2002
Status: closed (inferred from source dates) · Seat Belts:rear/other
THIS INVESTIGATION WAS OPENED JANUARY 16, 2002, BASED ON SEVEN REPORTS ALLEGING THE THIRD ROW SEAT BELT RETRACTORS FAILED ON CERTAIN 1997 AND 1998 MODEL YEAR CARAVAN AND VOYAGER VEHICLES.THE REPORTS INDICATED A TAR LIKE SUBSTANCE ENTERED THE RETRACTOR MECHANISM, THUS CAUSING THE RETRACTOR TO JAM OR BIND.IN THIS CONDITION THE SEAT BELT IS RENDERED INOPERABLE, AS THE WEBBING CANNOT RETRACT OR BE WITHDRAWN FROM THE RETRACTORS FOR USE.RECALL SCOPE:THE AFFECTED VEHICLES ARE 1997 THROUGH 1999 DODGE CARAVAN, PLYMOUTH VOYAGER, AND CHRYSLER TOWN & CONTRY BUILT ON A SHORT WHEEL BASE CHASSIS.THE INCLUSIVE DATES OF PRODUCTION ARE JUNE 1996 THROUGH OCTOBER 31, 1999.RECALL REMEDY: DAIMLERCHRYSLER DEALERS WILL REPLACE THE MASTIC SOUND BARRIER PATCHES WITH FOAM BLOCKERS, AS WELL AS, INSPECT AND REPLACE ALL THIRD ROW REAR SEAT BELT ASSEMBLIES CONTAMINATED BY THE MASTIC PATCH.
EA01007 · Air Bag Clockspring
Opened Feb 21, 2001 · Closed Nov 22, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
RQ00008 · Dc Minivan Fuel Injector Rail Leak
Opened Mar 9, 2000 · Closed Mar 18, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
EA99013 · Post Collision Fuel System
Opened Jun 11, 1999 · Closed Aug 10, 2001
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
No summary supplied.
PE99010 · POST-COLLISION Fuel System Integrity
Opened Feb 3, 1999 · Closed Jun 11, 1999
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
There is no summary currently available
EA97003 · Integrated Child Seat Belt Lockup
Opened Jan 31, 1997 · Closed Aug 19, 1998
Status: closed (inferred from source dates) · Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
Additional source detail variants (2)
Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
SQ96016 · Integrated Child Seat Belt Lockup
Opened Sep 18, 1996 · Closed Feb 4, 1997
Status: closed (inferred from source dates) · Seat Belts:integrated Child Seat
ODI CONTINUES TO RECEIVE COMPLAINTS ALLEGING LATCHING/RETRACTOR MECHANISM PROBLEMS.CHRYSLER'S ASSESSMENT OF THE PROBLEM INDICATES THAT OWNERS OF THE VEHICLES ARE NOT ADHERING TO THE CLEANING REQUIREMENTS FOR THE SEAT.THE SEAT APPEARS TO MALFUNCTION IF CRUMBS OF FOOD OR BEVERAGE RESIDUE ACCUMULATES ON THE LATCHING TONGUE IN THEWELL LOCATED BETWEEN THE CHILD'S LEGS.ODI HAS 19 COMPLAINTS OF RETRACT LOCKUP.SEVEN OF THESE COMPLAINTS REPORT CUTTING THE STRAPS TO REMOVE THE CHILD.TWO OF THE SEVEN CONSUMERS ALLEGE THE CHILD WAS CHOKING.CHRYSLER REPORTS 60 OWNER/FIELD REPORTS WHICH INDICATED 19 HARNESSES WERE CUT TO REMOVE THE CHILDREN.ADDITIONAL INFORMATION IS NEEDED TO FULLY ASSESS THE SAFETY CONSEQUENCE OF THE ALLEGED DEFECT AND TO EVALUATE THE CHRYSLER CORPORATION'S RATIONAL FOR NOT CONDUCTING A SAFETY RECALL CAMPAIGN.