IllustrationBAD FUEL LEAK FROM FUEL RAIL. HUGE POTENTIAL FOR FIRE. *TR
1995 Dodge Caravan
Owner reports · Recalls · Investigations
More warning signs than most Caravan years
Owner complaints for the 1995 Dodge Caravan are substantially higher than the model-year median of 182.
About this comparison →How this year compares
Owner complaints by model year
Compare all Caravan years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 26 of 489 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 93 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 67 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 67 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
53 crash reports6 fire reports35 injury reports
Fuel System, Gasoline complaints
22 reportsI PURCHASED A 1995 DODGE CARAVAN ON JUNE 12, 2004. IT WAS HAVING A FUEL INJECTOR PROBLEM AND THE DEALERSHIP I PURCHASED IT FROM REPAIRED A FUEL INJECTOR. 9 DAYS LATER GAS FUMES FILLED THE CAB AND THE VEHICLE CAUGHT FIRE ON THE LEFT SIDE FACING THE ENGINE. I GOT MYSELF & 6MO OLD DAUGHTER OUT AND THE FIRE DEPT. PUT OUT THE FIRE…
Read full complaint
I PURCHASED A 1995 DODGE CARAVAN ON JUNE 12, 2004. IT WAS HAVING A FUEL INJECTOR PROBLEM AND THE DEALERSHIP I PURCHASED IT FROM REPAIRED A FUEL INJECTOR. 9 DAYS LATER GAS FUMES FILLED THE CAB AND THE VEHICLE CAUGHT FIRE ON THE LEFT SIDE FACING THE ENGINE. I GOT MYSELF & 6MO OLD DAUGHTER OUT AND THE FIRE DEPT. PUT OUT THE FIRE. ENGINE COMPLETELY BURNED, HOOD. HAVE DETAILED PHOTOS. DEALERSHIP WON'T TAKE RESPONSIBILITY, DODGE WON'T RESPOND. I WANT TO KNOW WHAT CAUSED THIS.*AK
THE VEHICLE EXPERIENCED THE SAME PROBLEM AS STATED IN RECALL # 00 V 268 000, HOWEVER THE VEHICLE IDENTIFICATION NUMBER WAS NOT INCLUDED IN THE RECALL. *JB
MANUFACTURER'S INCIDENT REPORT 8962625 / NHTSA SIMILIAR REPORT 702363 01/16/1999 / MY ORIGINAL REPORT 749642 ORIGINAL PART (2) FUEL LINES HAVE BEEN SAVED FOR INSPECTION IF NECESSARY / ADDITIONAL NHTSA REPORTS OF ENGINE FIRES 810648 03/30/1997 AND 978765 01/07/1996 ... QUESTION "WERE THESE ENGINE COMPARTMENT FIRES CAUSED BY FUEL …
Read full complaint
MANUFACTURER'S INCIDENT REPORT 8962625 / NHTSA SIMILIAR REPORT 702363 01/16/1999 / MY ORIGINAL REPORT 749642 ORIGINAL PART (2) FUEL LINES HAVE BEEN SAVED FOR INSPECTION IF NECESSARY / ADDITIONAL NHTSA REPORTS OF ENGINE FIRES 810648 03/30/1997 AND 978765 01/07/1996 ... QUESTION "WERE THESE ENGINE COMPARTMENT FIRES CAUSED BY FUEL LINE LEAKS"
FUEL LINE LEAK, GAS FUMES ENTERING INTERIOR VENTILATION. *AK
THE BRAKE PADS HAVE BEEN REPALCED TWICE AND THE MASTER CYLINDE WAS REPLACED ONCE. NLM
GAS IS LEAKING FROM VEHICLE EVERYTIME CONSUMER PARKS CAR. MECHANIC SAID IT WAS THE CORROSION OF THE SENDING UNIT. CONSUMER IS HAVING ALMOST THE SAME PROBLEM AS THE RECALL ON DODGE NEON 1996 96V228000. CONSUMER FEELS THIS IS A MANUFACTURING DEFECT.*AK
DROVE VEHICLE OVER METAL DEBRIS LEFT IN ROAD. THE DEBRIS RUPTURED THE FUEL TANK AND FUEL SPILLED INTO THE ROAD AND ONTO REAR OF VEHICLE. FIRE DEPT ARRIVED & SPRAYED FOAM CHEMICAL ON FUEL. TOOK VEHICLE TO DEALER AND ENTIRE FUEL TANK SYSTEM REPLACED. MJS
WHEN COMING TO A STOP AFTER LONG DISTANCE DRIVING , VEHICLE LOSES POWER. DEALER HAS REPLACED FUEL INJECTION SYSTEM. MANUFACTURERS HAVE BEEN NOTIFIED. *AK
THE ENGINE STOPS AND STALLS AT ABOUT 25MPH. HAS TO BEEN REVVED UP IN ORDER TO GET IT STARTED AGAIN. DEALER REPLACED FUEL PUMP, BUT STALLING CONTINUED. DEALER CAN'T FIND THE PROBLEM. *AK
Official recalls
199V113000 · Air Bags
May 6, 1999
VEHICLE DESCRIPTION: MINI VANS. THE WIRING THAT INITIATES THE DRIVER AND/OR PASSENGER AIR BAG COULD ELECTRICALLY SHORT CIRCUIT TO GROUND. A SHORT CIRCUIT TO GROUND THAT EXISTS IMMEDIATELY AFTER TURNING THE IGNITION KEY TO THE "ON" OR "START" POSITION CAN CAUSE THE AIR BAG(S) TO INADVERTENTLY DEPLOY.
Consequence & remedy
Consequence: INADVERTENT AIR BAG DEPLOYMENT CAN INJURE A FRONT SEAT OCCUPANT.
Remedy: DEALERS WILL PERFORM AN ELECTRONIC DIAGNOSTIC CHECK. ANY SHORT CIRCUITS IDENTIFIED IN EITHER THE DRIVER'S OR PASSENGER SIDE AIR BAG INITIATOR WIRE CIRCUIT WILL BE REPAIRED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6DP03002 · Steering Column Separation
Opened May 7, 2003 · Closed Jul 22, 2003
Status: closed (inferred from source dates) · Steering:column
MR. LARRY A. SACKEY SUBMITTED A PETITION TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) BY LETTER DATED APRIL 18, 2003, REQUESTING THAT NHTSAFURTHER INVESTIGATE THE DEFECTIVE COLLAPSIBLE STEERING SHAFT SYSTEM ON 1987-1995 VEHICLES MANUFACTURED BY THE DAIMLERCHRYSLER CORPORATION.IN PART BECAUSE OF 49 CFR ? 30120(G), NHTSA HAS DECIDED TO LIMIT THE SCOPE OF THE PETITION VEHICLES TO 1993-1995 MODELS, EXCLUDING THE 1993 JEEP GRAND CHEROKEE AND 1994-1995 DODGE RAM SERIES TRUCKS THAT WERE RECALLED (93V210 & 96V230) FOR STEERING COLUMN FAILURE.IF THE ANALYSIS OF THESE VEHICLES HAD IDENTIFIED A POTENTIAL PROBLEM, THE SCOPE COULD HAVE BEEN EXPANDED IN AN INVESTIGATION.A REVIEW OF ODI'S DATA BASE SHOWS NO RECENT COMPLAINTS AND A LACK OF A COMPLAINT TREND CONCERNING THE SUBJECT ISSUE ON THE SUBJECT VEHICLES AS A WHOLE OR BY INDIVIDUAL MODELS.THEREFORE, THE PETITION IS DENIED.FOR DETAILS, SEE FEDERAL REGISTER NOTICE VOLUME 68, NO. 130, JULY 8, 2003.
PE97049 · Air Bag Circuit/windshield Wiper Motor
Opened Nov 18, 1997 · Closed Mar 17, 1998
Status: closed (inferred from source dates) · Visibility
There is no summary currently available
EA97003 · Integrated Child Seat Belt Lockup
Opened Jan 31, 1997 · Closed Aug 19, 1998
Status: closed (inferred from source dates) · Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
Additional source detail variants (2)
Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
DP96014 · Defective Air Bag Crash Sensor
Opened Nov 14, 1996 · No close date supplied
Status: open (inferred from source dates) · Air Bags:frontal:sensor/control MODULE-INACTIVE
CFAS SENT A FOLLOW-UP LETTER ON DECEMBER 12, 1996, TO CHANGE THE INTENT OF THE PETITION TO AIRBAG AGGRESSIVITY AND DEPLOYMENT VARIABILITY.NHTSA RECEIVED THE LETTER ON 12/12/96; ACCORDINGLY, THE PETITION DUE DAY WAS CHANGED TO APRIL 12, 1997.CFAS PETITIONED THE AGENCY TO CONDUCT AN INVESTIGATION TO DETERMINE WHETHER THE AIRBAG CRASH SENSOR AND/OR DEPLOYMENT SYSTEMS FOR THE 1991-92 CHEVROLET CORSICA/BERETTA, 1990-92 FORD TAURUS, AND 1994-96 CHRYSLER MINIVANS ARE DEFECTIVE.CFAS ALLEGE THAT INFORMATION ON LOW SPEED CRASHES HERE OCCUPANTS HAVE SUFFERED FATAL INJURIES SUGGESTS [THAT THE ABOVE VEHICLES] HAVE DEFECTIVE AIRBAG CRASH SENSOR AND/OR DEPLOYMENT SYSTEMS.
SQ96016 · Integrated Child Seat Belt Lockup
Opened Sep 18, 1996 · Closed Feb 4, 1997
Status: closed (inferred from source dates) · Seat Belts:integrated Child Seat
ODI CONTINUES TO RECEIVE COMPLAINTS ALLEGING LATCHING/RETRACTOR MECHANISM PROBLEMS.CHRYSLER'S ASSESSMENT OF THE PROBLEM INDICATES THAT OWNERS OF THE VEHICLES ARE NOT ADHERING TO THE CLEANING REQUIREMENTS FOR THE SEAT.THE SEAT APPEARS TO MALFUNCTION IF CRUMBS OF FOOD OR BEVERAGE RESIDUE ACCUMULATES ON THE LATCHING TONGUE IN THEWELL LOCATED BETWEEN THE CHILD'S LEGS.ODI HAS 19 COMPLAINTS OF RETRACT LOCKUP.SEVEN OF THESE COMPLAINTS REPORT CUTTING THE STRAPS TO REMOVE THE CHILD.TWO OF THE SEVEN CONSUMERS ALLEGE THE CHILD WAS CHOKING.CHRYSLER REPORTS 60 OWNER/FIELD REPORTS WHICH INDICATED 19 HARNESSES WERE CUT TO REMOVE THE CHILDREN.ADDITIONAL INFORMATION IS NEEDED TO FULLY ASSESS THE SAFETY CONSEQUENCE OF THE ALLEGED DEFECT AND TO EVALUATE THE CHRYSLER CORPORATION'S RATIONAL FOR NOT CONDUCTING A SAFETY RECALL CAMPAIGN.
PE96008 · Safety Blt Latch Operation
Opened Jan 25, 1996 · Closed Jun 28, 1996
Status: closed (inferred from source dates) · Seat Belts
There is no summary currently available