Power Train. Review the 93 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Air Bags. Review the 67 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine And Engine Cooling. Review the 67 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

53 crash reports6 fire reports35 injury reports

Engine And Engine Cooling complaints

67 reports

Clear category filter

Mileage unknown · Jan 17, 2004

Engine And Engine CoolingPower Train

Read full complaint

DEALER WAS GOING TO REPLACE THE TRANSMISSION, BUT AFTER SEVERAL HOURS OF LABOR, THEY DECIDED TO REPLACE A DIFFERENTIAL PIN ON THE TRANSMISSION AFTER ONLY 52,000 MILES. DEALER WOULD NOT COVER COST OF REPAIR. IT SOUNDS LIKE MANY PEOPLE HAVE HAD SIMILAR PROBLEM, IS THERE GOING TO BE A RECALL? ALSO, THE DEALER HAS RECHARGED THE AIR CONDITIONER 3 TIMES WITHIN THE PAST 3 YEARS. EACH TIME THEY CHARGED ME FOR IT. I FIND IT HARD TO BELIEVE THAT A CHARGE WOULD LAST ONLY ONE SUMMER. *CB

NHTSA ODI #10054363

Mileage unknown · Jan 15, 2004

Engine And Engine Cooling

Read full complaint

THE AIR-CONDITIONING UNIT STOPPED BLOWING COLD AIR WITHOUT WARNING. WHEN I TOOK MY VAN TO THE MECHANIC, HE INFORMED ME THAT HE WAS UNABLE TO DETECT ANY LEAK IN THE SYSTEM AND WITH MY PERMISSION RECHARGED THE SYSTEM BACK IN SEPTEMBER. IT WORKED FINE FOR ABOUT TWO MONTHS THEN ONCE AGAIN,WITHOUT WARNING,IT STOPPED BLOWING COLD AIR.I CALLED THE MANUFACTURER,AND THEY BLUNTLY TOLD ME THAT IT WAS MY PROBLEM SINCE THE 3 YEAR/36,000 MILE WARRANTY HAD LONG EXPIRED. I COUNTERED TO NO AVAIL THAT TWO SEPERATE INDEPENDANT MECHANICS HAD INFORMED ME THAT A NUMBER OF DODGE OWNERS WITH THE SAME AIR-CONDITIONING UNITS HAD BEEN COMPLAINING TO THEM OF THE SAME PROBLEM.IN ADDITION, I ALSO HAD FOUND OUT THAT CHRYSLER HAD EXTENDED SEVERAL MODEL WARRANTIES TO 7 YEAR/70,000 MILES INCLUDING THE GRAND CHEROKEE BECAUSE OF FAULTY AIR-CONDITIONING EVAPORATORS WHICH I BELIEVE IS THE SAME OR SIMILAR ONE PRESENTLY FAILING IN MY VAN. ON A SEPERATE NOTE,I WAS INFORMED EARLIER IN DECEMBER THAT I HAD AN OIL LEAK COMING OUT OF AN AREA WHERE A SECTION OF THE HEAD GASKET WAS SEATED. TO MAKE A LONG STORY SHORT,I HAD ALSO INFORMED THE MANUFACTURER OF THIS PROBLEM THAT COULD HAVE COST ME OVER $1000.00 TO REPLACE. BELIEVE IT OR NOT, THE REPRESENTATIVE THAT I HAD SPOKEN TO ADMITTED OVER THE PHONE TO ME THAT THERE WAS A GASKET PROBLEM WITH A NUMBER OF 90'S MODELS AND THE PROBLEM WAS CORRECTED WITH A CHANGE IN 1999 SELECT VEHICLES INCLUDING THE 2.4 LITRE MINIVANS.FORTUNATELY, I WAS ONLY CHARGED A $100.00 DEDUCTIBLE BY A LOCAL DODGE DEALERSHIP TO REPLACE THE DEFECTIVE HEAD GASKET.

NHTSA ODI #10069813

99,859 miles · Jan 8, 2004

Engine And Engine Cooling

SERPENTINE BELT MALFUNCTIONED, CAUSING ENGINE TO FAIL. *AK

NHTSA ODI #10053699

Mileage unknown · Dec 10, 2002

Engine And Engine CoolingEquipmentStructure

OTHER PROBLEMS THE SAME AS OTHERS IN DATABASE. DT

NHTSA ODI #770712

Mileage unknown · Aug 1, 2002

Engine And Engine Cooling

CONSUMER STATES VEHICLE STALLS OUT WHILE DRIVING. INTERMITTENTLY LURCHES AND MISSES EITHER AT A STOP OR WHEN GOING ABOUT 50 MPH. WILL HAPPEN EITHER COLD OR WARM. LACK OF POWER WHEN TRYING TO ACCELERATE. *TT

NHTSA ODI #565555

Mileage unknown · Mar 19, 2002

Engine And Engine Cooling

INTERMITTENTLY VEHICLE WILL STALL OUT AND DIE WITHOUT WARNING AT 30 TO 40MPH. DEALER HAS NOT BEEN ABLE TO DUPLICATE THE PROBLEM. PLEASE PROVIDE ADDITIONAL INFORMATION.*AK

NHTSA ODI #8005875

Mileage unknown · Mar 19, 2002

Engine And Engine Cooling

INTERMITTENTLY VEHICLE WILL STALL OUT AND DIE WITHOUT WARNING AT 30 TO 40MPH. DEALER AND MANUFACTURER HAVE BEEN NOTIFIED. PLEASE PROVIDE ADDITIONAL INFORMATION.*AK

NHTSA ODI #8005874

Mileage unknown · Jan 2, 2002

Engine And Engine Cooling

HEAD GASKET BLEW AND ENGINE CHECK LIGHTR ILLUMINATED ON THE DASH. PLEASE PROVIDE ANY FURTHER INFORMATION. PLEASE PROVIDE VEHICLE IDENTIFICATION NUMBER.*AK

NHTSA ODI #8001385

Mileage unknown · Dec 31, 2001

Engine And Engine Cooling

WHILE DRIVING, VEHICLE ENGINE CHECK ILLUMINATED, THE TEMPERATURE GAUGE MALFUNCTIONED, AND THE HEAD GASKET BLEWOUT. *AK. CONSUMER WAS INFORMED THAT THE REASON THE GUAGES WERE ACTING ERRACTICALLY WAS DUE TO THE BLOWN HEAD GASKET.*SLC

NHTSA ODI #8001255

Mileage unknown · Nov 6, 2001

Engine And Engine Cooling

Read full complaint

AT APPROXIMATELY 58500 MILES THE HEAD GASKET ON THE ENGINE FAILED. IT WAS REPLACED UNDER A PURCHASED EXTENDED WARRANTEE. I WAS NOT INFORMED BY ANYONE THAT CHRYSLER HAD A PROGRAM IN PLACE TO COVER THE COST OF REPAIRS THOUGH SUCH A PROGRAM EXISTED. AT 75419 MILES THE HEADGASKET BLEW AGAIN. ONLY THIS TIME THE HEAD WAS CRACKED AS WELL. I WAS CHARGED OVER $1625.00 FOR THE REPAIRS EVENTHOUGH IT APPEARS THE ORIGINAL REPAIRS WERE INEFFECTIVE. AFTER MUCH DISCUSSION THE CAR DEALER WARRANTEED THE REPAIRS FOR 36000 MILES OR 3 YEARS. THIS OFFER WAS NEVER MADE ON THE ORIGINAL REPAIRS. OTHER PROBLEMS WITH THE CAR INCLUDE THE FRONT STRUTS GOING OUT AT 42000 MILES (IT TOOK OVER FOUR TRIPS TO THE DEALER TO GET THE PROBLEM MOSTLY CORRECTED), A FROZEN BRAKE CALIPER CAUSING PREMATURE WARE OUT OF THE LEFT FRONT BRAKES, A SUSPENSION SYSTEM THAT BOTTOMS OUT HARSHLY ON ROADS WITH DIPS. WITH THE LATEST REPAIR THE TEMPERATURE GAUGE READ A HALF UNIT HIGHER THAN EVER BEFORE AND THE VENT BLOWS WARM AIR REGARDLESS OF OUTSIDE TEMPERATURE (EVEN IF IT IS VERY COLD). I AM VERY DISSATISFIED WITH THIS VEHICLE. *AK

NHTSA ODI #754176

Official recalls

99V113000 · Air Bags

May 6, 1999

VEHICLE DESCRIPTION: MINI VANS. THE WIRING THAT INITIATES THE DRIVER AND/OR PASSENGER AIR BAG COULD ELECTRICALLY SHORT CIRCUIT TO GROUND. A SHORT CIRCUIT TO GROUND THAT EXISTS IMMEDIATELY AFTER TURNING THE IGNITION KEY TO THE "ON" OR "START" POSITION CAN CAUSE THE AIR BAG(S) TO INADVERTENTLY DEPLOY.

Consequence & remedy

Consequence: INADVERTENT AIR BAG DEPLOYMENT CAN INJURE A FRONT SEAT OCCUPANT.

Remedy: DEALERS WILL PERFORM AN ELECTRONIC DIAGNOSTIC CHECK. ANY SHORT CIRCUITS IDENTIFIED IN EITHER THE DRIVER'S OR PASSENGER SIDE AIR BAG INITIATOR WIRE CIRCUIT WILL BE REPAIRED.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

DP03002 · Steering Column Separation

Opened May 7, 2003 · Closed Jul 22, 2003

Status: closed (inferred from source dates) · Steering:column

MR. LARRY A. SACKEY SUBMITTED A PETITION TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) BY LETTER DATED APRIL 18, 2003, REQUESTING THAT NHTSAFURTHER INVESTIGATE THE DEFECTIVE COLLAPSIBLE STEERING SHAFT SYSTEM ON 1987-1995 VEHICLES MANUFACTURED BY THE DAIMLERCHRYSLER CORPORATION.IN PART BECAUSE OF 49 CFR ? 30120(G), NHTSA HAS DECIDED TO LIMIT THE SCOPE OF THE PETITION VEHICLES TO 1993-1995 MODELS, EXCLUDING THE 1993 JEEP GRAND CHEROKEE AND 1994-1995 DODGE RAM SERIES TRUCKS THAT WERE RECALLED (93V210 & 96V230) FOR STEERING COLUMN FAILURE.IF THE ANALYSIS OF THESE VEHICLES HAD IDENTIFIED A POTENTIAL PROBLEM, THE SCOPE COULD HAVE BEEN EXPANDED IN AN INVESTIGATION.A REVIEW OF ODI'S DATA BASE SHOWS NO RECENT COMPLAINTS AND A LACK OF A COMPLAINT TREND CONCERNING THE SUBJECT ISSUE ON THE SUBJECT VEHICLES AS A WHOLE OR BY INDIVIDUAL MODELS.THEREFORE, THE PETITION IS DENIED.FOR DETAILS, SEE FEDERAL REGISTER NOTICE VOLUME 68, NO. 130, JULY 8, 2003.

PE97049 · Air Bag Circuit/windshield Wiper Motor

Opened Nov 18, 1997 · Closed Mar 17, 1998

Status: closed (inferred from source dates) · Visibility

There is no summary currently available

EA97003 · Integrated Child Seat Belt Lockup

Opened Jan 31, 1997 · Closed Aug 19, 1998

Status: closed (inferred from source dates) · Child Seat

THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.

Additional source detail variants (2)

Child Seat

DP96014 · Defective Air Bag Crash Sensor

Opened Nov 14, 1996 · No close date supplied

Status: open (inferred from source dates) · Air Bags:frontal:sensor/control MODULE-INACTIVE

CFAS SENT A FOLLOW-UP LETTER ON DECEMBER 12, 1996, TO CHANGE THE INTENT OF THE PETITION TO AIRBAG AGGRESSIVITY AND DEPLOYMENT VARIABILITY.NHTSA RECEIVED THE LETTER ON 12/12/96; ACCORDINGLY, THE PETITION DUE DAY WAS CHANGED TO APRIL 12, 1997.CFAS PETITIONED THE AGENCY TO CONDUCT AN INVESTIGATION TO DETERMINE WHETHER THE AIRBAG CRASH SENSOR AND/OR DEPLOYMENT SYSTEMS FOR THE 1991-92 CHEVROLET CORSICA/BERETTA, 1990-92 FORD TAURUS, AND 1994-96 CHRYSLER MINIVANS ARE DEFECTIVE.CFAS ALLEGE THAT INFORMATION ON LOW SPEED CRASHES HERE OCCUPANTS HAVE SUFFERED FATAL INJURIES SUGGESTS [THAT THE ABOVE VEHICLES] HAVE DEFECTIVE AIRBAG CRASH SENSOR AND/OR DEPLOYMENT SYSTEMS.

SQ96016 · Integrated Child Seat Belt Lockup

Opened Sep 18, 1996 · Closed Feb 4, 1997

Status: closed (inferred from source dates) · Seat Belts:integrated Child Seat

ODI CONTINUES TO RECEIVE COMPLAINTS ALLEGING LATCHING/RETRACTOR MECHANISM PROBLEMS.CHRYSLER'S ASSESSMENT OF THE PROBLEM INDICATES THAT OWNERS OF THE VEHICLES ARE NOT ADHERING TO THE CLEANING REQUIREMENTS FOR THE SEAT.THE SEAT APPEARS TO MALFUNCTION IF CRUMBS OF FOOD OR BEVERAGE RESIDUE ACCUMULATES ON THE LATCHING TONGUE IN THEWELL LOCATED BETWEEN THE CHILD'S LEGS.ODI HAS 19 COMPLAINTS OF RETRACT LOCKUP.SEVEN OF THESE COMPLAINTS REPORT CUTTING THE STRAPS TO REMOVE THE CHILD.TWO OF THE SEVEN CONSUMERS ALLEGE THE CHILD WAS CHOKING.CHRYSLER REPORTS 60 OWNER/FIELD REPORTS WHICH INDICATED 19 HARNESSES WERE CUT TO REMOVE THE CHILDREN.ADDITIONAL INFORMATION IS NEEDED TO FULLY ASSESS THE SAFETY CONSEQUENCE OF THE ALLEGED DEFECT AND TO EVALUATE THE CHRYSLER CORPORATION'S RATIONAL FOR NOT CONDUCTING A SAFETY RECALL CAMPAIGN.

PE96008 · Safety Blt Latch Operation

Opened Jan 25, 1996 · Closed Jun 28, 1996

Status: closed (inferred from source dates) · Seat Belts

There is no summary currently available