NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes, Hydraulic complaints
321 reportsClear category filterMileage unknown · Jan 15, 2003
Service Brakes, Hydraulic
CONSUMER WANTED TO BE REIMBURSED FOR A REPAIR HE PAID FOR THAT SHOULD HAVE BEEN COVERED UNDER THE RECALL. THE ABS LIGHT ILLUMINATED SO THE CONSUMER TOOK THE VEHICLE TO HIS MECHANIC, THE MECHANIC REPLACED THE DUAL PRESSURE SWITCH FOR $340.00 BUT IT DID NOT COMPLETELY FIX THE PROBLEM. THE MECHANIC DID SOME RESEARCH AND DISCOVERE…
Read full complaint
CONSUMER WANTED TO BE REIMBURSED FOR A REPAIR HE PAID FOR THAT SHOULD HAVE BEEN COVERED UNDER THE RECALL. THE ABS LIGHT ILLUMINATED SO THE CONSUMER TOOK THE VEHICLE TO HIS MECHANIC, THE MECHANIC REPLACED THE DUAL PRESSURE SWITCH FOR $340.00 BUT IT DID NOT COMPLETELY FIX THE PROBLEM. THE MECHANIC DID SOME RESEARCH AND DISCOVERED THE RECALL. THE DEALER REPLACED THE PUMP MOTOR ASSEMBLY FREE OF CHARGE, HOWEVER THE CONSUMER IS REQUESTING REIMBURSEMENT FOR THE 340 THAT HIS MECHANIC CHARGED TO FIX THE DUEL PRESSURE SWITCH WHICH WAS APART OF THE LIFE TIME WARRANTY RECALL. CHRYSLER HOTLINE INFORMED THE CONSUMER IT WAS NOT APART OF THE RECALL. ( RECALL #96V099000). *JB
NHTSA ODI #10003886
Mileage unknown · Jan 6, 2003
Electrical SystemEngine And Engine CoolingService Brakes, Hydraulic
THE SLIDING DOOR SEPARATED FROM THE HINGES, ALSO THERE WAS PROBLEMS WITH THE OIL, COOLANT, BALL JOINTS, STARTER, BRAKE LINE, TIE ROD, TRANSMISSION, EXHAUST AND THE FRONT BRAKES. TS *JB
NHTSA ODI #10002079
98,000 miles · Jan 6, 2003
Service Brakes, Hydraulic
AFTER HAVING RECALL DONE FOR THE ABS BRAKES 96 V 099 000,BY THE DEALERSHIP DAYTONA DODGE;DAYTON BEACH FL;386-274-0571, THE BRAKES FAILED 4 TIMES. THIS ALMOST RESULTED IN AN ACCIDENT. PH
NHTSA ODI #10002040
Mileage unknown · Nov 5, 2002
Service Brakes, Hydraulic
WHILE TRAVELING AT NORMAL SPEEDS, CONSUMER STATES' WHEN PRESSING BRAKES AND BRAKE PEDAL WENT TO THE FLOOR, AND VEHICLE SLOWLY CAME TO A STOP. CAUSE OF FAILURE IS UNKNOWN. PLEASE PROVIDE ANY FURTHER INFORMATION. TS
NHTSA ODI #8022154
Mileage unknown · Oct 24, 2002
Service Brakes, Hydraulic
WHILE TRAVELING ON THE HIGHWAY THE ABS BRAKING LIGHT APPEAR ON THE DASHBOARD. AND THE PEDAL GOES ALL THE WAY DOWN TO THE FLOOR. THE DEALERSHIP IS AWARE OF THE PROBLEM TS
NHTSA ODI #8021566
Mileage unknown · Oct 21, 2002
Service Brakes, Hydraulic
CONSUMER STATES THAT WHEN BRAKING, THEY NEED TO ADD EXCESSIVE FORCE TO BRAKE PEDAL TO STOP VEHICLE.
NHTSA ODI #8021243
Mileage unknown · Sep 16, 2002
Engine And Engine CoolingService Brakes, HydraulicVisibility
THE CONSUMER HAD A BRAKE RECALL# 96V099000-REPAIRS DONE, AND TWO MONTHS LATER THE BRAKES FAILED AGAIN. *AK THE ABS WERE CHECKED AND THE CONSUMER WAS TOLD THAT THEY WERE OKAY. THE FIRST TIME THE BRAKES FAILED, THE CONSUMER WAS THEN NOTIFIED OF A RECALL. THE SECOND INCIDENT OCCURED WHEN THE DAUGHTER EXPERIENCED TOTAL BRAKE FAI…
Read full complaint
THE CONSUMER HAD A BRAKE RECALL# 96V099000-REPAIRS DONE, AND TWO MONTHS LATER THE BRAKES FAILED AGAIN. *AK THE ABS WERE CHECKED AND THE CONSUMER WAS TOLD THAT THEY WERE OKAY. THE FIRST TIME THE BRAKES FAILED, THE CONSUMER WAS THEN NOTIFIED OF A RECALL. THE SECOND INCIDENT OCCURED WHEN THE DAUGHTER EXPERIENCED TOTAL BRAKE FAILURE-ON THE HIGHWAY. THE VEHICLE WAS TOWED TO A DODGE DEALER AND THE CONSUMERS WERE TOLD THAT THE BRAKE FAILURE WAS DETERMINED AND REPAIRS WERE DONE. (BUT BECAUSE OF THE CONTINUED PROBLEMS, THE VEHICLE STAYED AT THE SHOP FOR ABOUT 2 WEEKS PLUS) THE LAST INCIDENT HAPPENED ONE MONTH LATER, WHERE THE BRAKE LIGHT HAD COME ON. PER INVOICE-FOUND THAT THE ACTUATOR PISTON IN THE HYDRAULIC ASSEMBLY WAS LEAKING-REPLACED, ALSO REPLACED THE BRAKE VALVE AND BRAKE LINE, THE FITTING WAS FROZEN IN THE VALVE-REPLACED, FOUND A LOW ACCUMULATER TO BE DEFECTIVE-REPLACED, AND THE REAR HEATER COOLANT LINES LEAKING ANTI-FREEZE. *SCC
NHTSA ODI #8018738
Mileage unknown · Sep 11, 2002
Service Brakes, Hydraulic
WHEN BRAKES ARE APPLIED BRAKE PEDAL GOES ALL THE WAY DOWN TO THE FLOOR. DEALERSHIP IS AWARE OF PROBLEM.*AK
NHTSA ODI #8018443
Mileage unknown · Sep 10, 2002
Service Brakes, Hydraulic
THE ABS BRAKKES FAILED AND THE ABS LIGHT ILLUMINATED. REPAIRS WERE MADE TO THE DUAL-PRESSURE SWITCH WHICH IS ATTACHED TO THE BRAKE ACTUATOR PISTON ASSEMBLY. THIS REPAIR DID NOT REMEDY THE PROBLEM. TEH MECHANIC INFORMED CONSUMER OF THE RECALL 96V099. CONSUMER TOOK VEHICLE INTO CHRYSLER WHO REPAIRED THE PUMP MOTOR ASSEMBLY FRE…
Read full complaint
THE ABS BRAKKES FAILED AND THE ABS LIGHT ILLUMINATED. REPAIRS WERE MADE TO THE DUAL-PRESSURE SWITCH WHICH IS ATTACHED TO THE BRAKE ACTUATOR PISTON ASSEMBLY. THIS REPAIR DID NOT REMEDY THE PROBLEM. TEH MECHANIC INFORMED CONSUMER OF THE RECALL 96V099. CONSUMER TOOK VEHICLE INTO CHRYSLER WHO REPAIRED THE PUMP MOTOR ASSEMBLY FREE OF CHARGE. THE PREVIOUS MECHANIC ADVISED CONSUMER TO GET REIMBURSEMENT FOR REPAIRS TO THE DUAL PRESSURE SWITCH BECASUE AS STATED IN THE RECALL IT IS A PART OF THE BRAKE ACTUATOR AND THERE FORE IS SUBJECT TO THE LIFETIME WARRANTY CLAUSE. *JG
NHTSA ODI #786318
Mileage unknown · Jun 26, 2002
Service Brakes, Hydraulic
AT 20MPH ABS WENT OUT, MAKING IT HARD TO STOP. CAUSE UNKNOWN. DEALER NOTIFIED.*AK
NHTSA ODI #8012721
Official recalls
8Oct 12, 2000
VEHICLE DESCRIPTION: MINI VANS EQUIPPED WITH 2-SPOKE LUXURY WHEELS MANUFACTURED JULY 1992 THROUGH JUNE 1993; OR EQUIPPED WITH 4-SPOKE SPORT WHEELS MANUFACTURED FROM JULY 1992 THROUGH SEPTEMBER 1993. THE STEERING WHEEL ARMATURE STAMPING CAN CRACK AND SEPARATE FROM THE CENTER HUB ATTACHMENT TO THE STEERING COLUMN.
Consequence & remedy
Consequence: IF THE STEERING WHEEL SEPARATES FROM THE CENTER HUB ATTACHMENT TO THE STEERING COLUMN, LOSS OF CONTROL CAN OCCUR INCREASING THE RISK OF AN ACCIDENT.
Remedy: DEALERS WILL INSPECT THE STEERING WHEEL FOR CRACKS AND ANY WHEELS WITH CRACKS WILL BE REPLACED. ALL OTHER VEHICLES WILL HAVE A REINFORCEMENT PLATE INSTALLED TO PREVENT STEERING WHEEL SEPARATION IN THE EVENT CRACKING OCCURS.
Sep 2, 1999
VEHICLE DESCRIPTION: MINI VANS. THE BOLTS USED TO ATTACH THE STRUT TO THE BODY AND THE REAR LIFTGATE CAN ACCUMULATE FATIGUE DAMAGE IF THREE FACTORS COMBINE. IF THE BOLT IS LOOSE, THE GAS STRUT IS OVER-PRESSURIZED, AND THE FREQUENCY OF OPENING AND CLOSING CYCLES IS HIGHER THAN FOR THE AVERAGE CUSTOMER, THE BOLT CAN FAIL.
Consequence & remedy
Consequence: PERSONAL INJURY COULD OCCUR IF THE BOLTS BREAK ALLOWING THE LIFTGATE TO FALL SUDDENLY.
Remedy: DEALERS WILL INSPECT FOR LOOSE FASTENERS, IF THE FASTENERS ARE LOOSE, THE STRUT (AND INTEGRAL BOLTS) WILL BE REPLACED. IF THE BOLT SHOWS EVIDENCE OF TORQUE, THE BOLT WILL BE REMOVED, LARGER WASHERS WILL REPLACE THE EXISTING WASHER AND THE BOLT WILL BE REINSTALLED AND HAND TIGHTENED TO THE TARGET TORQUED.
Jul 16, 1999
VEHICLE DESCRIPTION: MINIVANS. THE LEFT HAND WINDSHIELD WIPER PIVOT DRIVE ARM WAS NOT MECHANICALLY STAKED TO THE PIVOT SHAFT.
Consequence & remedy
Consequence: THIS COULD ALLOW THE DRIVE ARM TO DISENGAGE FROM THE SHAFT LEADING TO A LOSS OF WIPER FUNCTION. THE DRIVER'S VISIBILITY WOULD BE IMPAIRED, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE LEFT HAND SIDE WINDSHIELD WIPER PIVOT ASSEMBLY.
May 6, 1999
VEHICLE DESCRIPTION: MINI VANS. THE WIRING THAT INITIATES THE DRIVER AND/OR PASSENGER AIR BAG COULD ELECTRICALLY SHORT CIRCUIT TO GROUND. A SHORT CIRCUIT TO GROUND THAT EXISTS IMMEDIATELY AFTER TURNING THE IGNITION KEY TO THE "ON" OR "START" POSITION CAN CAUSE THE AIR BAG(S) TO INADVERTENTLY DEPLOY.
Consequence & remedy
Consequence: INADVERTENT AIR BAG DEPLOYMENT CAN INJURE A FRONT SEAT OCCUPANT.
Remedy: DEALERS WILL PERFORM AN ELECTRONIC DIAGNOSTIC CHECK. ANY SHORT CIRCUITS IDENTIFIED IN EITHER THE DRIVER'S OR PASSENGER SIDE AIR BAG INITIATOR WIRE CIRCUIT WILL BE REPAIRED.
Sep 9, 1997
VEHICLE DESCRIPTION: PASSENGER MINI-VANS. COVERS ON THE SOLID STALK MOUNTED SEAT BELT BUCKLES CAN BECOME DISLODGED CAUSING THE RELEASE BUTTON TO STICK INSIDE THE COVER. THE BUCKLE WOULD THEN BE ONLY PARTIALLY LATCHED.
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL INSTALL A COVER RETAINING CLIP TO THE STALK MOUNTED BUCKLE COVER TO PREVENT DISLOCATION OF THE BUCKLE COVER.
Sep 9, 1997
VEHICLE DESCRIPTION: PASSENGER MINI-VANS. THE CENTER REAR SEAT, RIGHT OUTBOARD SIDE, SAFETY BELT ANCHOR HOOK CAN BECOME UNATTACHED FROM THE BODY ANCHOR POSITION.
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE ANCHOR HOOK RETAINING CLIP WITH A REVISED PROFILE CLIP AND A COVER PLATE.
Jun 13, 1996
THE ABS HYDRAULIC CONTROL UNIT CAN EXPERIENCE EXCESSIVE BRAKE ACTUATOR PISTON SEAL WEAR CAUSING PUMP-MOTOR DETERIORATION.
Consequence & remedy
Consequence: IF THIS CONDITION OCCURS, THE ABS FUNCTION COULD BE LOST AND REDUCED POWER ASSIST WOULD BE EXPERIENCED DURING VEHICLE BRAKING INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy: DEALERS WILL TEST THE VEHICLE'S ANTI-LOCK BRAKE SYSTEM AND REPAIR THE VEHICLES IF NECESSARY. ALSO THE WARRANTY ON ALL ABS COMPONENTS WILL BE EXTENDED TO 10 YEARS OR 100,000 MILES (EXCEPT FOR THE BRAKE ACTUATOR PISTON ASSEMBLY AND THE PUMP-MOTOR ASSEMBLY WHICH WILL HAVE A LIFETIME COVERAGE). OWNERS WILL ALSO BE REIMBURSED FOR PREVIOUS ABS COMPONENT REPAIR COSTS.
Jun 4, 1993
THE 15 INCH WHEELS HAVE MALFORMED LUG NUT SEAT CONFIGURATION WHICH CAUSES POOR NUT-TO-WHEEL CONTACT AND CENTERING OF THE WHEEL DURING INSTALLATION.
Consequence & remedy
Consequence: POOR NUT-TO-WHEEL CONTACT DURING INSTALLATION CAN LEAD TOPOSSIBLE LOSS OF A WHEEL, RESULTING IN LOSS OF VEHICLE CONTROL AND AN ACCIDENT.
Remedy: THE ROAD AND SPARE WHEELS WITH THE MALFORMED LUG NUT SEAT CONFIGURATION WILL BE REPLACED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
13DP03002 · Steering Column Separation
Opened May 7, 2003 · Closed Jul 22, 2003
Status: closed (inferred from source dates) · Steering:column
MR. LARRY A. SACKEY SUBMITTED A PETITION TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) BY LETTER DATED APRIL 18, 2003, REQUESTING THAT NHTSAFURTHER INVESTIGATE THE DEFECTIVE COLLAPSIBLE STEERING SHAFT SYSTEM ON 1987-1995 VEHICLES MANUFACTURED BY THE DAIMLERCHRYSLER CORPORATION.IN PART BECAUSE OF 49 CFR ? 30120(G), NHTSA HAS DECIDED TO LIMIT THE SCOPE OF THE PETITION VEHICLES TO 1993-1995 MODELS, EXCLUDING THE 1993 JEEP GRAND CHEROKEE AND 1994-1995 DODGE RAM SERIES TRUCKS THAT WERE RECALLED (93V210 & 96V230) FOR STEERING COLUMN FAILURE.IF THE ANALYSIS OF THESE VEHICLES HAD IDENTIFIED A POTENTIAL PROBLEM, THE SCOPE COULD HAVE BEEN EXPANDED IN AN INVESTIGATION.A REVIEW OF ODI'S DATA BASE SHOWS NO RECENT COMPLAINTS AND A LACK OF A COMPLAINT TREND CONCERNING THE SUBJECT ISSUE ON THE SUBJECT VEHICLES AS A WHOLE OR BY INDIVIDUAL MODELS.THEREFORE, THE PETITION IS DENIED.FOR DETAILS, SEE FEDERAL REGISTER NOTICE VOLUME 68, NO. 130, JULY 8, 2003.
RQ00011 · Steering Wheel Separation
Opened May 1, 2000 · Closed Apr 1, 2002
Status: closed (inferred from source dates) · Steering
There is no summary currently available
Additional source detail variants (2)
Steering
There is no summary currently available
Steering
There is no summary currently available
RQ99004 · Rear Liftgate Support
Opened Apr 19, 1999 · No close date supplied
Status: open (inferred from source dates) · Structure:body:hatchback/liftgate:support Device/strut
ON MAY 7, 1997, CHRYSLER FILED A DEFECT INFORMATION REPORT TO RECALL 436,000 1992 DODGE CARAVAN/GRAND CARAVAN, PLYMOUTH VOYAGER/GRAND VOYAGER AND CHRYSLER TOWN AND COUNTRY VEHICLES TO REPAIR THE LIFTGATE SUPPORTS; SAFETY RECALL 97V-079.ODI HAD INVESTIGATION THE REAR LIFTGATE SUPPORT PROBLEM FOR 1991-1993 CHRYSLER MINIVANS IN PE 96-035 AND EA96-027.AT THE TIME OF CLOSING EA96-027 ON MAY 16, 1997, A SAFETY RELATED DEFECT TREND HAD NOT BEEN IDENTIFIED ON THE 1991 AND 1993 MODELS.SINCE THE CLOSING OF EA96-027, ODI HAS RECEIVED 34 COMPLAINTS OF REAR LIFTGATE SUPPORT ATTACHING BOLT FAILURES, INCLUDING TEN INJURIES, ON THE SUBJECET VEHICLES.IT IS RECOMMENDED THAT A RECALL QUERY BE OPENED TO DETERMINE THE SCOPE OF LIFTGATE SUPPORT FAILURES ON THE SUBJECT VEHICLES.CLOSING NOTE: ON JULY 19, 1999, DAMILERCHRYSLER AGREED TO RECALL 1991, 1993, AND 1994 MODEL YEAR VEHICLES TO REMEDY REAR LIFTGATE SUPPORTS; SAFETY RECALL 99V-213.IT IS RECOMMENDED THAT RQ99-004 BE CLOSED.
Additional source detail variants (2)
Structure:body:hatchback/liftgate:support Device/strut
ON MAY 7, 1997, CHRYSLER FILED A DEFECT INFORMATION REPORT TO RECALL 436,000 1992 DODGE CARAVAN/GRAND CARAVAN, PLYMOUTH VOYAGER/GRAND VOYAGER AND CHRYSLER TOWN AND COUNTRY VEHICLES TO REPAIR THE LIFTGATE SUPPORTS; SAFETY RECALL 97V-079.ODI HAD INVESTIGATION THE REAR LIFTGATE SUPPORT PROBLEM FOR 1991-1993 CHRYSLER MINIVANS IN PE 96-035 AND EA96-027.AT THE TIME OF CLOSING EA96-027 ON MAY 16, 1997, A SAFETY RELATED DEFECT TREND HAD NOT BEEN IDENTIFIED ON THE 1991 AND 1993 MODELS.SINCE THE CLOSING OF EA96-027, ODI HAS RECEIVED 34 COMPLAINTS OF REAR LIFTGATE SUPPORT ATTACHING BOLT FAILURES, INCLUDING TEN INJURIES, ON THE SUBJECET VEHICLES.IT IS RECOMMENDED THAT A RECALL QUERY BE OPENED TO DETERMINE THE SCOPE OF LIFTGATE SUPPORT FAILURES ON THE SUBJECT VEHICLES.CLOSING NOTE: ON JULY 19, 1999, DAMILERCHRYSLER AGREED TO RECALL 1991, 1993, AND 1994 MODEL YEAR VEHICLES TO REMEDY REAR LIFTGATE SUPPORTS; SAFETY RECALL 99V-213.IT IS RECOMMENDED THAT RQ99-004 BE CLOSED.
Structure:body:hatchback/liftgate:support Device/strut
ON MAY 7, 1997, CHRYSLER FILED A DEFECT INFORMATION REPORT TO RECALL 436,000 1992 DODGE CARAVAN/GRAND CARAVAN, PLYMOUTH VOYAGER/GRAND VOYAGER AND CHRYSLER TOWN AND COUNTRY VEHICLES TO REPAIR THE LIFTGATE SUPPORTS; SAFETY RECALL 97V-079.ODI HAD INVESTIGATION THE REAR LIFTGATE SUPPORT PROBLEM FOR 1991-1993 CHRYSLER MINIVANS IN PE 96-035 AND EA96-027.AT THE TIME OF CLOSING EA96-027 ON MAY 16, 1997, A SAFETY RELATED DEFECT TREND HAD NOT BEEN IDENTIFIED ON THE 1991 AND 1993 MODELS.SINCE THE CLOSING OF EA96-027, ODI HAS RECEIVED 34 COMPLAINTS OF REAR LIFTGATE SUPPORT ATTACHING BOLT FAILURES, INCLUDING TEN INJURIES, ON THE SUBJECET VEHICLES.IT IS RECOMMENDED THAT A RECALL QUERY BE OPENED TO DETERMINE THE SCOPE OF LIFTGATE SUPPORT FAILURES ON THE SUBJECT VEHICLES.CLOSING NOTE: ON JULY 19, 1999, DAMILERCHRYSLER AGREED TO RECALL 1991, 1993, AND 1994 MODEL YEAR VEHICLES TO REMEDY REAR LIFTGATE SUPPORTS; SAFETY RECALL 99V-213.IT IS RECOMMENDED THAT RQ99-004 BE CLOSED.
EA97020 · Front Windshield Wiper
Opened Sep 30, 1997 · Closed Jul 27, 1999
Status: closed (inferred from source dates) · Visibility
ALLEGED FAILURES OF WINDSHIELD WIPER SYSTEMS
EA97005 · Safety Belt Anchorage Failures
Opened Apr 10, 1997 · Closed Dec 23, 1997
Status: closed (inferred from source dates) · Seat Belts:front:anchorage
There is no summary currently available
PE97013 · Windshield Wiper Failure
Opened Apr 2, 1997 · Closed Sep 30, 1997
Status: closed (inferred from source dates) · Visibility
ALLEGED WINDSHIELD WIPERS FAIL WHILE IN USE
DP97001 · Windshield Wiper Failure
Opened Mar 12, 1997 · Closed Apr 2, 1997
Status: closed (inferred from source dates) · Visibility
CFAS PETITIONED THE AGENCY TO CONDUCT A DEFECT INVESTIGATION ON WINDSHIELD WIPER FAILURE ON 1989 AND LATER CHRYSLER MODELS WHICH SHOULD INCLUDE, BUT NOT LIMITED TO SPIRIT/ACCLAIM: DYNASTY/NEW YORKER/LANDAU; LANCE/LEBARON; SHADOW/SUNDANCE; CARAVAN/VOYAGER.HOWEVER, BASED ON ODI'S COMPLAINT RECORDS, ONLY CERTAIN MINIVANS WILL BE INVESTIGATED
EA96027 · Alleged Rear Liftgate Support Failure
Opened Oct 31, 1996 · Closed May 16, 1997
Status: closed (inferred from source dates) · Structure
THE RETAINER BOLT OF THE REAR LIFTGATE SUPPORT CYLINDERS MAY SHEAR RESULTING IN SUDDEN COLLAPSE OF THE REAR HATCH DOOR.
PE96035 · Alleged Rear Liftgate Support Failure
Opened May 6, 1996 · Closed Oct 31, 1996
Status: closed (inferred from source dates) · Structure
THE RETAINER BOLT OF THE REAR LIFT GATE SUPPORT CYLINDERS MAY SHEER RESULTING IN THE SUDDEN COLLAPSE OF THE REAR HATCH DOOR.
PE96008 · Safety Blt Latch Operation
Opened Jan 25, 1996 · Closed Jun 28, 1996
Status: closed (inferred from source dates) · Seat Belts
There is no summary currently available
EA94028 · Abs Braking System Fails
Opened Jul 29, 1994 · Closed Jun 24, 1996
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
PE94024 · Abs Braking System Fails
Opened Mar 7, 1994 · Closed Jul 29, 1994
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
EA94005 · Liftgate Latches
Opened Jan 31, 1994 · Closed Oct 25, 1995
Status: closed (inferred from source dates) · Structure
LIFTGATE LATCHES IN THE SUBJECT VEHICLES HAVE FAILED IN LOW AND MODERATE SPEED IMPACTS RESULTING IN OCCUPANT EJECTIONS, INJURIES, AND FATALITIES.THERE ARE TWO FAILURE MODES ASSOCIATED WITH LATCH FAILURE: FORK BOLT-DETENT LEVER BYPASS, AND INERTIAL UNLATCHING.NHTSA ANALYSES OF CHRYSLER AND PEER MINIVANS TOOK THE FORM OF STATIC AND DYNAMIC CRASH TESTING, ENGINEERING EVALUATIONS, COMPLAINT AND FIELD ANALYSES, AND REAL WORLD DATA ANALYSES.A TECHNICAL REPORT DISCUSSING THESE ANALYSES CAN BE FOUND IN THE ENGINEERING ANALYSIS TECHNICAL REPORT IN THE PUBLIC VIEWING FILE.CHRYSLER HAS ADVISED NHTSA THAT IT WILL CONDUCT A CAMPAIGN TO REPLACE THE LATCHES ON ALL THE SUBJECT VEHICLES.THE CHRYSLER CAMPAIGN WILL CONSIST OF NOTIFICATION LETTERS TO ALL OWNERS; FREE REPLACEMENT OF ALL LATCHES WITH STRONGER, SAFER LATCHES REGARDLESS OF THE AGE OF THE MINIVANS; NATIONAL ADVERTISING TO PROMOTE CUSTOMER AWARENESS OF THE CAMPAIGN; QUARTERLY REPORTS REGARDING CAMPAIGN COMPLETION RATES; AS WELL AS ADDITIONAL MEASURES TO ENSURE A HIGH COMPLETION RATE, ABOVE AND BEYOND THE ACTIONS THAT NORMALLY WOULD BE TAKEN IN A FORMAL SAFETY RECALL.THESE INCLUDE FOLLOW UP WRITTEN AND TELEPHONIC NOTIFICATIONS TO OWNERS WHO DO NOT BRING THEIR VEHICLES IN FOR CORRECTIVE ACTION.NHTSA FIRMLY BELIEVES THAT THE CRASH PERFORMANCE OF THE LATCHES ON THESE MINIVANS RAISES SERIOUS SAFETY CONCERNS, AND THAT THE CAMPAIGN ADDRESSES THESE CONCERNS.THE CHRYSLER CORRECTIVE ACTION WILL INCREASE THE STRENGTH OF THE LIFTGATE LATCHES AND DECREASE THE POTENTIAL FOR INERTIAL UNLATCHING, THEREBY REDUCING THE RISK OF CRASH-RELATED OPENINGS OF THE LIFTGATE AND POSSIBLE OCCUPANT EJECTION THROUGH THE LIFTGATE OPENING.OWNERS OF CHRYSLER MINIVANS WILL GET A STRONGER, SAFER LATCH FREE OF CHARGE AT THE EARLIEST POSSIBLE TIME, WITHOUT THE NEED FOR FURTHER TECHNICAL INVESTIGATION AND COMPLEX AND TIME-CONSUMING LITIGATION WITH AN UNCERTAIN OUTCOME.BASED ON THE ABOVE, ODI IS CLOSING THIS INVESTIGATION.
Illustration