IllustrationLOCAL REPAIR SHOP DOING OIL CHANGE NOTICED FRONT CROSS MEMBER WAS RUSTED OUT. *TR
2012 Dodge Caliber
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2012 Dodge Caliber do not stand out strongly from the model-year median of 165.
About this comparison →How this year compares
Owner complaints by model year
Compare all Caliber years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
40–25K
325–50K
1050–75K
975–100K
2100–150K
0150K+
28 reports with mileage · 21 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 17 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Seat Belts. Review the 13 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Vehicle Speed Control. Review the 7 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
9 crash reports3 fire reports4 injury reports
What owners actually said
49 reportsI RECENTLY BROUGHT A USED VEHICLE, WHEN I TOOK IT FOR A TEST DRIVE EVERYTHING RAN SMOOTHLY AND THINGS WERE WORKING JUST FINE, NO PROBLEMS. I DROVE THE CAR HOME AND WHEN I GOT OUT THE VEHICLE AND TRIED TO USE THE KEYPAD TO LOCK THE DOORS, IT DIDN'T WORK AND ACTUALLY STARTED THE CAR THAN THE ALARM WENT OFF. I HAD TO START THE ENGI…
Read full complaint
I RECENTLY BROUGHT A USED VEHICLE, WHEN I TOOK IT FOR A TEST DRIVE EVERYTHING RAN SMOOTHLY AND THINGS WERE WORKING JUST FINE, NO PROBLEMS. I DROVE THE CAR HOME AND WHEN I GOT OUT THE VEHICLE AND TRIED TO USE THE KEYPAD TO LOCK THE DOORS, IT DIDN'T WORK AND ACTUALLY STARTED THE CAR THAN THE ALARM WENT OFF. I HAD TO START THE ENGINE AND SHUT IT BACK OFF AND MANUALLY GO AND LOCK ALL DOORS BECAUSE I ALSO NOTICED THE LOCK DOOR BUTTON ON THE DOOR DID NOT WORK BUT THE WINDOW BUTTONS DOES. I IMMEDIATELY CALLED THEM AND INFORMED THEM OF THE ISSUE THAT I WAS EXPERIENCING. ABOUT 1 WEEK WENT BY AND I STARTED TO FEEL THE CAR DRAGGING WHEN TRYING TO ACCELERATE AS WELL AS THE CHECK ENGINE LIGHT AND GAS CAP LIGHT COMING ON. AND MOST OF ALL I NOTICED HOW QUICKLY THE MILEAGE WAS MOVING VERSUS THE MILEAGE I SIGNED IT AT. I ALSO CALLED IN AND REPORTED WHAT I WAS EXPERIENCING, THEY SUGGESTED I BRING IN THE VEHICLE TO A SHOP THEY CONTRACT WITH TO SEE THE PROBLEM AND RESOLVE IT. I TOOK THE VEHICLE IN ON THE NEXT AVAILABLE DAY FOR ME FOR ABOUT 4-6 HOURS, I WAS CALLED BACK TO PICK THE VEHICLE BACK UP. THE CHECK ENGINE LIGHT AND GAS CAP LIGHT WAS OFF BUT NOTHING ELSE AS FAR AS THE ELECTRICAL PROBLEM WITHIN THE CAR, AND THE DRAGGING FEELING AS WELL AS THE MILEAGE TROUBLESHOOTING. I WASN'T SATISFIED WITH THE WORK THAT WAS DONE, SO I CALLED AGAIN TO REPORT THE TROUBLES AND REQUEST FOR A REFUND BECAUSE I WAS NOT SATISFIED WITH THE VEHICLE AND HOW HIGH THE MILEAGE GOES WHEN I ONLY DRIVE 25 MILES BACK AND FORTH 6 DAYS A WEEK. I'VE HAD THE VEHICLE FOR 8 WEEKS NOW, AND THIS CAR MAINTENANCE IS POOR AS WELL AS I HAVE A STRONG FEELING THE CARS BEEN TAMPERED WITH BECAUSE OF THE DAMAGE TO ONE OF THE VENTS IN THE CAR ON THE DASH BOARD, AS WELL AS THE CAR NEEDING AN OIL CHANGE ALREADY AND I ONLY HAD THE VEHICLE SINCE MARCH 20, 2020. *TR
I RECENTLY BOUGHT THIS CAR FROM NORTHTOWN DODGE IN BUFFALO NY IN JAN OF 2019. AS THE WEATHER GOT WARMER MY TRANSMISSION OVERHEATED LITE COMES ON. I CAN'T DRIVE MORE THAN 50 MILES TOPS WITH OUT IT OVER HEATING. I'M THE SECOND OWNER. I AM FINANCING THIS CAR AND CAN ONLY DRIVE IT LOCALLY. I'VE ALSO READ THAT THERE IS A LIFETIME WAR…
Read full complaint
I RECENTLY BOUGHT THIS CAR FROM NORTHTOWN DODGE IN BUFFALO NY IN JAN OF 2019. AS THE WEATHER GOT WARMER MY TRANSMISSION OVERHEATED LITE COMES ON. I CAN'T DRIVE MORE THAN 50 MILES TOPS WITH OUT IT OVER HEATING. I'M THE SECOND OWNER. I AM FINANCING THIS CAR AND CAN ONLY DRIVE IT LOCALLY. I'VE ALSO READ THAT THERE IS A LIFETIME WARRANTY FOR THE POWERTRAIN ONLY IF YOUR THE ORIGINAL OWNER. THE CAR ONLY HAD 64000 MILES ON IT AND IT HAS 69771. SO PLEASE HELP ME WITH THIS ISSUE I AM A DISABLED VETERAN AND THIS CAR IS MY ONLY MEANS OF TRANSPORTATION.
ENGINE CRADLE RUSTED OUT AFTER ONLY 7YEARS
WAS DRIVING AND LOST ALL POWER WHEN THE LIGHTENING BOLT LIGHT CAME ON. HAD THE THROTTLE BODY REPLACED AND WAS FINE FOR A FEW MONTHS. NOW THE LIGHT KEEPS COMING ON AGAIN AND I'VE TAKEN THE CAR TO THE DEALER AT LEAST 15 TIMES AND THEY KEEP RELPLACING DIFFERENT SENSORS AND WIRING. I HAVE SPENT THOUSANDS OF DOLLARS FOR AN ISSUE …
Read full complaint
WAS DRIVING AND LOST ALL POWER WHEN THE LIGHTENING BOLT LIGHT CAME ON. HAD THE THROTTLE BODY REPLACED AND WAS FINE FOR A FEW MONTHS. NOW THE LIGHT KEEPS COMING ON AGAIN AND I'VE TAKEN THE CAR TO THE DEALER AT LEAST 15 TIMES AND THEY KEEP RELPLACING DIFFERENT SENSORS AND WIRING. I HAVE SPENT THOUSANDS OF DOLLARS FOR AN ISSUE THAT WILL NOT GO AWAY AND NO ONE CAN SEEM TO FIGURE OUT WHAT THE REAL ISSUE IS BECAUSE EVERYTIME THEY 'FIX' ONE THING IT SEEMS TO BRING UP OTHER CODES.
WHEN BRAKING THE ELECTRIC THROTTLE CONTROL LIGHT FLASHES MOMENTARILY. IT DOES NOT STAY ON. THE CAR DOES NOT BRAKE COMPLETELY AT THESE TIMES AND CONTINUES TO ACCELERATE AND MOVE FORWARD ANOTHER FOOT OR TWO DESPITE PRESSING THE BRAKE. WHEN BRAKING TODAY THE CAR CONTINUED TO ACCELERATE FASTER WHILE THE FOOT WAS ON THE BRAKE. IN RES…
Read full complaint
WHEN BRAKING THE ELECTRIC THROTTLE CONTROL LIGHT FLASHES MOMENTARILY. IT DOES NOT STAY ON. THE CAR DOES NOT BRAKE COMPLETELY AT THESE TIMES AND CONTINUES TO ACCELERATE AND MOVE FORWARD ANOTHER FOOT OR TWO DESPITE PRESSING THE BRAKE. WHEN BRAKING TODAY THE CAR CONTINUED TO ACCELERATE FASTER WHILE THE FOOT WAS ON THE BRAKE. IN RESEARCHING THIS, IT SEEMS THE CALIBER SPECIFICALLY HAS A HISTORY OF ETC OR ELECTRIC THROTTLE ISSUES. YEARS AFFECTED BY THIS SAFETY ISSUE INCLUDE 2007 THROUGH 2012; BUT THERE IS NO OFFICIAL RECALL FROM DODGE. THIS IS A RECALL NECESSARY ISSUE! THE ESSENTIAL FUNCTION OF ACCELERATION AND BRAKING ARE NON COMPROMISE AREAS OF VEHICLE DESIGN THAT DODGE HAS DONE LITTLE TO ADDRESS IN THE CALIBER MODEL.
THE STRUCTURE/FRAME IN THE FRONT OF OUR 2012 DODGE CALIBER WAS SO RUSTED THAT IT BROKE WHILE WE WERE DRIVING. THE FRAME BROKE WHEN WE PULLED OFF OF THE INTERSTATE AND STOPPED AT THE END OF AN EXIT. THIS ISSUE HAS NOT BEEN ADDRESSED BY A RECALL, B UT A BULLETIN HAS BEEN RELEASED.
PER THE X69 WARRANTY NOTICE I HAD THE CROSSMEMBER REPLACED. THE DEALERSHIP STATES THAT DODGE DOES NOT COVER THE ALIGNMENT THAT IS NEEDED DUE TO THE CROSSMEMBER REPAIR. THE REPAIR OF THE DEFECT CAUSED THE NEED FOR THE ALIGNMENT. THIS SEEMS TO BE A SCAM
MY DRIVERS SIDE SEAT BELT AUTOMATICALLY UNLATCHES ITSELF. I DON'T HAVE TO BE DOING ANYTHING. I GIVE IT TUG EVERY TIME I BUCKLE TO MAKE SURE IT FASTEN. BUT WHILE DRIVING IT WILL ON IT'S ON COME UNLATCHED AND RELEASED. IT HAS HAPPENED WHILE DRIVING AND JUST SITTING AT RED LIGHT. I IMMEDIATELY REFASTEN IT BUT THIS HAS HAPPENED ENOU…
Read full complaint
MY DRIVERS SIDE SEAT BELT AUTOMATICALLY UNLATCHES ITSELF. I DON'T HAVE TO BE DOING ANYTHING. I GIVE IT TUG EVERY TIME I BUCKLE TO MAKE SURE IT FASTEN. BUT WHILE DRIVING IT WILL ON IT'S ON COME UNLATCHED AND RELEASED. IT HAS HAPPENED WHILE DRIVING AND JUST SITTING AT RED LIGHT. I IMMEDIATELY REFASTEN IT BUT THIS HAS HAPPENED ENOUGH TIME TO RAISE CONCERN IF I WOULD BE SAFE IN THE EVENT OF AN ACCIDENT.
2012 DODGE CALIBER BEEN HAVING PROBLEMS WITH THE THROTTLE CONTROL, CAR WILL NOT DRIVE, IT JERKS IT YOU TRY TO CHANGE GEARS. THIS HAS BEEN A PROBLEM FOR THESE CARS FOR YEARS, AND IT SEEMS THE COMPANY WILL NOT LOOK INTO IT, NOT ONLY 2012 MODELS BUT LATER MODELS TOO. THIS IS AN EXPENSIVE JOB, AND THE CONSUMER HAS TO PAY THE PRICE.
Official recalls
116V668000 · Air Bags; Air Bags:frontal:sensor/control MODULE-INACTIVE ; Seat Belts:pretensioner
Sep 15, 2016
Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Chrysler 200, 2010 Chrysler Sebring, 2010-2012 Dodge Caliber and 2010-2014 Jeep Patriot, Compass and Dodge Avenger vehicles. The Occupant Restraint Control (OCR) module may short circuit, preventing the frontal air bags, seat belt pretensioners, and side air bags from deploying in the event of a crash.
Consequence & remedy
Consequence: If the frontal air bags, seat belt pretensioners, and side air bags are disabled, there is an increased risk of injury to the vehicle occupants in the event of a vehicle crash that necessitates deployment of these safety systems.
Remedy: Chrysler will notify owners, and dealers will replace the OCR, free of charge. Interim letters informing owners that parts are not available yet were mailed on October 26, 2016. The recall began on August 15, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S61.
Additional source detail variants (3)
Seat Belts:pretensioner
Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Chrysler 200, 2010 Chrysler Sebring, 2010-2012 Dodge Caliber and 2010-2014 Jeep Patriot, Compass and Dodge Avenger vehicles. The Occupant Restraint Control (OCR) module may short circuit, preventing the frontal air bags, seat belt pretensioners, and side air bags from deploying in the event of a crash.
Consequence: If the frontal air bags, seat belt pretensioners, and side air bags are disabled, there is an increased risk of injury to the vehicle occupants in the event of a vehicle crash that necessitates deployment of these safety systems.
Remedy: Chrysler will notify owners, and dealers will replace the OCR, free of charge. Interim letters informing owners that parts are not available yet were mailed on October 26, 2016. The recall began on August 15, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S61.
Air Bags:frontal:sensor/control MODULE-INACTIVE
Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Chrysler 200, 2010 Chrysler Sebring, 2010-2012 Dodge Caliber and 2010-2014 Jeep Patriot, Compass and Dodge Avenger vehicles. The Occupant Restraint Control (OCR) module may short circuit, preventing the frontal air bags, seat belt pretensioners, and side air bags from deploying in the event of a crash.
Consequence: If the frontal air bags, seat belt pretensioners, and side air bags are disabled, there is an increased risk of injury to the vehicle occupants in the event of a vehicle crash that necessitates deployment of these safety systems.
Remedy: Chrysler will notify owners, and dealers will replace the OCR, free of charge. Interim letters informing owners that parts are not available yet were mailed on October 26, 2016. The recall began on August 15, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S61.
Air Bags
Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Chrysler 200, 2010 Chrysler Sebring, 2010-2012 Dodge Caliber and 2010-2014 Jeep Patriot, Compass and Dodge Avenger vehicles. The Occupant Restraint Control (OCR) module may short circuit, preventing the frontal air bags, seat belt pretensioners, and side air bags from deploying in the event of a crash.
Consequence: If the frontal air bags, seat belt pretensioners, and side air bags are disabled, there is an increased risk of injury to the vehicle occupants in the event of a vehicle crash that necessitates deployment of these safety systems.
Remedy: Chrysler will notify owners, and dealers will replace the OCR, free of charge. Interim letters informing owners that parts are not available yet were mailed on October 26, 2016. The recall began on August 15, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S61.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE19014 · Active Head Rest Inadvertent Deployment
Opened Sep 9, 2019 · Closed Feb 25, 2026
Status: closed (inferred from source dates) · Seats; Seats:front Assembly:head Restraint
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Seats
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Seats:front Assembly:head Restraint
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.