IllustrationAFTER HAVING RAIN ON THANKSGIVING DAY I WENT TO THE CAR TO LOAD UP LEFTOVERS AND RETURN HOME AND THERE WAS WATER ON THE BACK PASSENGER SIDE FLOOR. THIS HAD NEVER HAPPENED BEFORE THIS DAY. *TR
2010 Dodge Caliber
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2010 Dodge Caliber do not stand out strongly from the model-year median of 165.
About this comparison →How this year compares
Owner complaints by model year
Compare all Caliber years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
140–25K
1325–50K
2650–75K
2675–100K
29100–150K
7150K+
115 reports with mileage · 42 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 32 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 31 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 26 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
12 crash reports3 fire reports9 injury reports
What owners actually said
157 reportsTL* THE CONTACT OWNS A 2010 DODGE CALIBER. THE CONTACT STATED THAT THE HEAD LIGHT COVERS WERE FORMING CONDENSATIONS, WHICH THE CONTACT WAS CONCERNED THAT THE FAILURE COULD POSSIBLY CAUSE AN ELECTRICAL SHORT. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE TECHNICIAN DIAGNOSED THAT THE HEADLIGHT ASSEMBLY NEEDED TO BE R…
Read full complaint
TL* THE CONTACT OWNS A 2010 DODGE CALIBER. THE CONTACT STATED THAT THE HEAD LIGHT COVERS WERE FORMING CONDENSATIONS, WHICH THE CONTACT WAS CONCERNED THAT THE FAILURE COULD POSSIBLY CAUSE AN ELECTRICAL SHORT. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE TECHNICIAN DIAGNOSED THAT THE HEADLIGHT ASSEMBLY NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 52,000.
TL* THE CONTACT OWNS A 2010 DODGE CALIBER. THE CONTACT STATED THAT THE ELECTRONIC THROTTLE CONTROL LIGHT ILLUMINATED THEN THE VEHICLE STALLED. THE VEHICLE WAS TAKEN TO THE DEALER WHO STATED THE THROTTLE BODY NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE…
Read full complaint
TL* THE CONTACT OWNS A 2010 DODGE CALIBER. THE CONTACT STATED THAT THE ELECTRONIC THROTTLE CONTROL LIGHT ILLUMINATED THEN THE VEHICLE STALLED. THE VEHICLE WAS TAKEN TO THE DEALER WHO STATED THE THROTTLE BODY NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE.
AFTER DRIVING ON INTERSTATE FOR 3 HOURS, THE CAR WOULD HESITATE TO GO FROM A STOP. OVER THE NEXT 2 YEARS, THE PROBLEM HAS WORSENED!! IT IS TO THE POINT WHERE AFTER A 2-3 HOUR TRIP, THERE IS SUCH HESITATION THAT IF I'M ON AN INCLINE THE CAR WILL ACTUALLY ROLL BACKWARDS WHILE PRESSING ACCELERATOR!! THIS HAS SHOWN A STORED CODE OF …
Read full complaint
AFTER DRIVING ON INTERSTATE FOR 3 HOURS, THE CAR WOULD HESITATE TO GO FROM A STOP. OVER THE NEXT 2 YEARS, THE PROBLEM HAS WORSENED!! IT IS TO THE POINT WHERE AFTER A 2-3 HOUR TRIP, THERE IS SUCH HESITATION THAT IF I'M ON AN INCLINE THE CAR WILL ACTUALLY ROLL BACKWARDS WHILE PRESSING ACCELERATOR!! THIS HAS SHOWN A STORED CODE OF P0730 (WHICH DEALERSHIP TELLS ME THEY WON'T DO ANYTHING ABOUT UNLESS THEY CAN DUPLICATE PROBLEM). I WON'T ALLOW MY CHILDREN AND GRANDCHILDREN TO TRAVEL WITH ME IN THIS CAR ANYMORE BECAUSE I FEAR FOR THEIR SAFETY!! I WOULD GREATLY APPRECIATE ANY HELP YOUR AGENCY CAN PROVIDE FOR THIS DANGEROUS PROBLEM!!!!! *TR
WHENEVER I HAVE THE LIGHTS ON, RADIO ON, FAN BLOWER ON, AND I'M STOPPED AT A LIGHT IN DRIVE MODE (AUTOMATIC TRANSMISSION), THE ENGINE SHAKES AND DIES. IT'S ALMOST AS IF THE CAR IS EXPERIENCING COMPUTER OVERLOAD. TOO MANY THINGS GOING ON FOR THE CAR TO HANDLE SO THE COMPUTER CRASHES CAUSING THE CAR TO DIE. THE CAR ALWAYS START…
Read full complaint
WHENEVER I HAVE THE LIGHTS ON, RADIO ON, FAN BLOWER ON, AND I'M STOPPED AT A LIGHT IN DRIVE MODE (AUTOMATIC TRANSMISSION), THE ENGINE SHAKES AND DIES. IT'S ALMOST AS IF THE CAR IS EXPERIENCING COMPUTER OVERLOAD. TOO MANY THINGS GOING ON FOR THE CAR TO HANDLE SO THE COMPUTER CRASHES CAUSING THE CAR TO DIE. THE CAR ALWAYS STARTS BACK UP. NO INDICATOR LIGHTS GO OFF ON THE DASH. IT ONLY HAPPENS OCCASIONALLY UNDER THE ABOVE MENTIONED CIRCUMSTANCES. IF YOU ADD ON THE FRONT & REAR WIPERS SAME THING HAPPENS. I'VE HAD IT CHECKED OUT AT 3 DIFFERENT PLACES, PAYING AND FOR FREE, AND THEY ALL TELL ME THEY COULD NOT FIND ANYTHING WRONG WITH THE CAR. THIS IS A SERIOUS SAFETY ISSUE ESPECIALLY SINCE I HAVE A BABY IN THE CAR. I HAVE AAA AND ROAD SIDE ASSISTANCE THROUGH MY INSURANCE BUT THEY ALWAYS TAKE AN HOUR TO GET TO YOU. I'VE NEVER HAD TO USE THEM BECAUSE THE CAR ALWAYS STARTS BACK UP AGAIN. THIS CAR NEEDS TO BE RECALLED BECAUSE OTHER WISE THE CAR FUNCTIONS NORMALLY AS LONG AS I DON'T HAVE THE LIGHTS ON, RADIO ON, FAN BLOWER ON, AND I'M STOPPED AT A LIGHT IN DRIVE MODE. IF YOU PUT IT IN NEUTRAL SOMETIMES THE CAR WANTS TO STALL BUT IT DOESN'T ALWAYS PREVENT THE CAR FROM SHUTTING DOWN. READ LOTS OF COMPLAINTS ABOUT THIS MODEL, SIMILAR ISSUE. *TR
TL* THE CONTACT OWNS A 2010 DODGE CALIBER. THE CONTACT STATED THAT WHILE TRAVELING 75 MPH, THE VEHICLE SUDDENLY STALLED. THE CONTACT MENTIONED THAT THE ELECTRONIC COMPONENTS IN THE VEHICLE ALSO FAILED. THE VEHICLE WAS MOVED TO THE SHOULDER WHERE IT WAS RESTARTED AND RESUMED NORMAL FUNCTION. THE VEHICLE WAS TAKEN TO THE DEALER W…
Read full complaint
TL* THE CONTACT OWNS A 2010 DODGE CALIBER. THE CONTACT STATED THAT WHILE TRAVELING 75 MPH, THE VEHICLE SUDDENLY STALLED. THE CONTACT MENTIONED THAT THE ELECTRONIC COMPONENTS IN THE VEHICLE ALSO FAILED. THE VEHICLE WAS MOVED TO THE SHOULDER WHERE IT WAS RESTARTED AND RESUMED NORMAL FUNCTION. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE FAILURE COULD NOT BE REPLICATED. THE FAILURE RECURRED AND THE CONTACT WAS AWAITING A SECOND DIAGNOSIS. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 68,000.
STEERING WHEEL HAS A SLIGHT NOISE WHEN TURNING .IT FEELS LIKE A CLICKING SOUND WHEN I TURN THE WHEEL. *TR
I HAD BEEN DRIVING FOR A FEW HOURS AT APPROXIMATE 65 MPH. SOME OF WHICH WAS ON CRUISE. ALL OF A SUDDEN MY VEHICLE STARTED SLOWING DOWN. MY SPEEDOMETER SAID 60 MPH. HOWEVER, I WAS PROBABLY AT 30. I STEPPED ON THE GAS AND THE RPM WENT HIGH BUT I DIDN'T GET ANY SPEED. BASICALLY, THE SPEEDOMETER WASN'T RECORDING THE SPEED I WAS AT A…
Read full complaint
I HAD BEEN DRIVING FOR A FEW HOURS AT APPROXIMATE 65 MPH. SOME OF WHICH WAS ON CRUISE. ALL OF A SUDDEN MY VEHICLE STARTED SLOWING DOWN. MY SPEEDOMETER SAID 60 MPH. HOWEVER, I WAS PROBABLY AT 30. I STEPPED ON THE GAS AND THE RPM WENT HIGH BUT I DIDN'T GET ANY SPEED. BASICALLY, THE SPEEDOMETER WASN'T RECORDING THE SPEED I WAS AT AND THE TRANSMISSION WAS NOT WORKING IN INCREASING SPEED. I HAD IT TOWED BACK TO PHOENIX AND THE DODGE DEALERSHIP IN MESA, AZ CHECKED IT OVER AND TOLD ME THAT THERE WAS A "FLUKE" WITH THE CTV TRANSMISSION IN THIS MODEL AND THEY HAD BEEN SEEING A LOT OF THIS AS PEOPLE WERE DRIVING FROM PHOENIX TO FLAGSTAFF WHICH IS A GRADUAL INCREASE OVER A NUMBER OF MILES AND PEOPLE WERE HAVING THE SAME ISSUES THAT I DID. I WAS TOLD THE CVT TRANSMISSION GOES INTO "LIMP" MODE WHEN THIS HAPPENS AND BASICALLY SHUTS DOWN. I WAS ALSO LED TO BELIEVE THEY COULD DO NOTHING ABOUT IT. I'M SURPRISED THERE ISN'T A RECALL ON THIS MODEL AND TRANSMISSION. WHEN I GOGGLED 2010 DODGE CALIBER TRANSMISSION PROBLEMS, I CAME UP WITH A UTUBE VIDEO DOCUMENTING EXACTLY WHAT I HAD EXPERIENCED. *TR
MY CAR WILL NOT START WITH THE FACTORY KEY, OR THE REPLACEMENT KEY. I GOT THE REPLACEMENT KEY ABOUT 1 YEAR AGO AND THIS THE THIRD TIME THAT BOTH KEYS WILL NOT CRANK THE CAR. I HAD TO WAIT 20 MINS IN THE HOT CAR UNTIL IT WOULD CRANK. *TR
WHEN GETTING A JUMP FROM ANOTHER CAR THE COMPUTER WENT OUT HAD TO PAY A LITTLE UNDER $900 DOLLARS. THE STRUTS ARE ALSO GOING OUT. THE CAR IS MAKING A ROWING NOISE. SOMETIMES THE CAR DID NOT HAVE PICK UP OR SPEED WHEN STEPPING ON ACCELERATOR. *TR
Official recalls
216V668000 · Air Bags; Air Bags:frontal:sensor/control MODULE-INACTIVE ; Seat Belts:pretensioner
Sep 15, 2016
Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Chrysler 200, 2010 Chrysler Sebring, 2010-2012 Dodge Caliber and 2010-2014 Jeep Patriot, Compass and Dodge Avenger vehicles. The Occupant Restraint Control (OCR) module may short circuit, preventing the frontal air bags, seat belt pretensioners, and side air bags from deploying in the event of a crash.
Consequence & remedy
Consequence: If the frontal air bags, seat belt pretensioners, and side air bags are disabled, there is an increased risk of injury to the vehicle occupants in the event of a vehicle crash that necessitates deployment of these safety systems.
Remedy: Chrysler will notify owners, and dealers will replace the OCR, free of charge. Interim letters informing owners that parts are not available yet were mailed on October 26, 2016. The recall began on August 15, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S61.
Additional source detail variants (3)
Seat Belts:pretensioner
Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Chrysler 200, 2010 Chrysler Sebring, 2010-2012 Dodge Caliber and 2010-2014 Jeep Patriot, Compass and Dodge Avenger vehicles. The Occupant Restraint Control (OCR) module may short circuit, preventing the frontal air bags, seat belt pretensioners, and side air bags from deploying in the event of a crash.
Consequence: If the frontal air bags, seat belt pretensioners, and side air bags are disabled, there is an increased risk of injury to the vehicle occupants in the event of a vehicle crash that necessitates deployment of these safety systems.
Remedy: Chrysler will notify owners, and dealers will replace the OCR, free of charge. Interim letters informing owners that parts are not available yet were mailed on October 26, 2016. The recall began on August 15, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S61.
Air Bags:frontal:sensor/control MODULE-INACTIVE
Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Chrysler 200, 2010 Chrysler Sebring, 2010-2012 Dodge Caliber and 2010-2014 Jeep Patriot, Compass and Dodge Avenger vehicles. The Occupant Restraint Control (OCR) module may short circuit, preventing the frontal air bags, seat belt pretensioners, and side air bags from deploying in the event of a crash.
Consequence: If the frontal air bags, seat belt pretensioners, and side air bags are disabled, there is an increased risk of injury to the vehicle occupants in the event of a vehicle crash that necessitates deployment of these safety systems.
Remedy: Chrysler will notify owners, and dealers will replace the OCR, free of charge. Interim letters informing owners that parts are not available yet were mailed on October 26, 2016. The recall began on August 15, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S61.
Air Bags
Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Chrysler 200, 2010 Chrysler Sebring, 2010-2012 Dodge Caliber and 2010-2014 Jeep Patriot, Compass and Dodge Avenger vehicles. The Occupant Restraint Control (OCR) module may short circuit, preventing the frontal air bags, seat belt pretensioners, and side air bags from deploying in the event of a crash.
Consequence: If the frontal air bags, seat belt pretensioners, and side air bags are disabled, there is an increased risk of injury to the vehicle occupants in the event of a vehicle crash that necessitates deployment of these safety systems.
Remedy: Chrysler will notify owners, and dealers will replace the OCR, free of charge. Interim letters informing owners that parts are not available yet were mailed on October 26, 2016. The recall began on August 15, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S61.
10V197000 · Latches/locks/linkages:doors:latch
May 11, 2010
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2010 DODGE CALIBER VEHICLES. SOME VEHICLES MAY HAVE BEEN BUILT WITH AN INCORRECT DOOR LOCK ROD IN THE RIGHT FRONT DOOR.
Consequence & remedy
Consequence: AN UNLATCHED DOOR COULD INCREASE THE RISK OF AN UNBELTED FRONT SEAT PASSENGER BEING EJECTED FROM THE VEHICLE.
Remedy: DEALERS WILL INSPECT AND REPLACE THE FRONT RIGHT DOOR LOCK ROD AS REQUIRED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING JUNE 2010. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE19014 · Active Head Rest Inadvertent Deployment
Opened Sep 9, 2019 · Closed Feb 25, 2026
Status: closed (inferred from source dates) · Seats; Seats:front Assembly:head Restraint
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Seats
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Seats:front Assembly:head Restraint
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.