NHTSA owner reports · September 18, 2026 snapshot.
Fuel/propulsion System complaints
29 reportsClear category filter6,000 miles · Aug 27, 2014
Fuel/propulsion System
THIS IS ANOTHER ISSUE I'VE HAD WITH THIS CAR SINCE I BOUGHT IT BACK AROUND THANKSGIVING 2006. THE CARS FUEL GAUGE DOES NOT GIVE AN ACCURATE READING. I'VE FOUND INFO ABOUT THIS PROBLEM ONLINE WHICH INVOLVES REPLACING THE FUEL SENDING UNIT HOSES OR SOMETHING. I CALLED CHRYSLER ABOUT THIS AND I CANT BELIEVE THEY DO NOT COVER THE CO…
Read full complaint
THIS IS ANOTHER ISSUE I'VE HAD WITH THIS CAR SINCE I BOUGHT IT BACK AROUND THANKSGIVING 2006. THE CARS FUEL GAUGE DOES NOT GIVE AN ACCURATE READING. I'VE FOUND INFO ABOUT THIS PROBLEM ONLINE WHICH INVOLVES REPLACING THE FUEL SENDING UNIT HOSES OR SOMETHING. I CALLED CHRYSLER ABOUT THIS AND I CANT BELIEVE THEY DO NOT COVER THE COST OF THIS OBVIOUS DEFECT. TONS OF INFO ON THE WEB ABOUT THIS ONE TOO. I'VE LIVED WITH THIS ISSUE AS WELL AS MY NUMEROUS SUSPENSION PROBLEMS. THANKFULLY I KNOW MY CARS MPG'S SO I CAN CALCULATE WHERE MY FUEL TANK SHOULD BE USING THE TRIP ODOMETER LIKE I DO ON MY MOTORCYCLE - STILL VERY ANNOYING AND SHOULD BE FIXED FREE OF CHARGE. *TR
NHTSA ODI #10628931
83,000 miles · Mar 17, 2014
Electrical SystemEngineFuel/propulsion System
THIS HAS HAPPENED MANY TIMES BEFORE YESTERDAY. WHILE DRIVING ON THE FREEWAY, THE CHECK ENGINE LIGHT COMES ON, AND THE CAR GO INTO A "LIMP" MODE (VERY LITTLE POWER), AND EVEN AT FULL PEDAL, IT SLOWLY SLOWS DOWN. HAVING HAD IT HAPPEN SEVERAL TIMES BEFORE, I LEARNED TO PULL OVER, AND SHUT OFF THE CAR, AND LET IT SET FOR A FEW MINUT…
Read full complaint
THIS HAS HAPPENED MANY TIMES BEFORE YESTERDAY. WHILE DRIVING ON THE FREEWAY, THE CHECK ENGINE LIGHT COMES ON, AND THE CAR GO INTO A "LIMP" MODE (VERY LITTLE POWER), AND EVEN AT FULL PEDAL, IT SLOWLY SLOWS DOWN. HAVING HAD IT HAPPEN SEVERAL TIMES BEFORE, I LEARNED TO PULL OVER, AND SHUT OFF THE CAR, AND LET IT SET FOR A FEW MINUTES. SOMETIMES TIMES THIS IS NOT EASY, OR SAFE TO DO. THEN IT IS HARD TO RESTART, BUT WILL DRIVE SOMEWHAT BETTER. THIS ALLOWS ME TO GET TO A PLACE THAT I CAN SHUT IT OFF FOR AN EXTENDED AMOUNT OF TIME (1/2 HOUR), AND THEN IT RUNS MORE LIKE NORMAL, BUT THE CHECK ENGINE LIGHT STAY ON FOR SEVERAL DAYS. AFTER THE CHECK ENGINE LIGHT GOES OUT, IT IS RUNNING NORMAL AGAIN UNTIL THE NEXT TIME. SO FAR, THIS HAS NOT CAUSED AN ACCIDENT, BUT I'M SURE SOMEBODY WILL BE HURT OR KILLED BEFORE THIS GETS RECALLED. GOOD LUCK FOLLOW DRIVERS. *TR
NHTSA ODI #10572913
123,000 miles · Feb 23, 2014
Fuel/propulsion System
VEHICLE ROLLED TO A STOP ALONG THE ROAD. WAS UNABLE TO RESTART. I REMOVED THE REAR SEAT TO INSPECT THE FUEL PUMP AND CONNECTIONS. BOTH THE TOP OF THE PLASTIC FUEL PUMP AND IT'S PLASTIC CONNECTION WAS MELTED FROM AN ELECTRICAL MELT DOWN, JUST MILLIMETERS FROM THE FULL GAS TANK. THIS COULD'VE RESULT IN AN EXPLOSION AND FATALITY. A…
Read full complaint
VEHICLE ROLLED TO A STOP ALONG THE ROAD. WAS UNABLE TO RESTART. I REMOVED THE REAR SEAT TO INSPECT THE FUEL PUMP AND CONNECTIONS. BOTH THE TOP OF THE PLASTIC FUEL PUMP AND IT'S PLASTIC CONNECTION WAS MELTED FROM AN ELECTRICAL MELT DOWN, JUST MILLIMETERS FROM THE FULL GAS TANK. THIS COULD'VE RESULT IN AN EXPLOSION AND FATALITY. APPARENTLY FROM WHAT I'VE BEEN READING ONLINE THIS IS QUITE COMMON WITH THIS MODEL. SOMETHING NEEDS TO BE DONE BEFORE THERE IS A FATALITY. *TR
NHTSA ODI #10565497
27,654 miles · May 14, 2013
EngineFuel/propulsion System
MY ENGINE STALLS WHEN AT STOP LIGHT/SIGNS. THIS HAPPENS AFTER REFUELING THE CAR. I HEARD OF OTHER CHRYSLER/DODGE MODELS THAT HAVE HAD THE SAME PROBLEM THAT ARE BEING INVESTIGATED THOUGH MY CAR IS NOT THE SAME ENGINE OR YEARS BEING LOOKED AT. ENGINE IS 2.4 L. IT DOES THIS FOR UP TO ABOUT 10 TIMES AND I CAN KEEP IT RUNNING IN NEU…
Read full complaint
MY ENGINE STALLS WHEN AT STOP LIGHT/SIGNS. THIS HAPPENS AFTER REFUELING THE CAR. I HEARD OF OTHER CHRYSLER/DODGE MODELS THAT HAVE HAD THE SAME PROBLEM THAT ARE BEING INVESTIGATED THOUGH MY CAR IS NOT THE SAME ENGINE OR YEARS BEING LOOKED AT. ENGINE IS 2.4 L. IT DOES THIS FOR UP TO ABOUT 10 TIMES AND I CAN KEEP IT RUNNING IN NEUTRAL AND REVVING THE ENGINE. NOT SURE OF THE DATE THAT I FIRST NOTICES THIS BUT HAS BEEN HAPPENING FOR ABOUT A YEAR OR SO. MILEAGE AND DATE ARE FROM LATEST TIME. *TR
NHTSA ODI #10511919
27,000 miles · Feb 27, 2013
Electrical SystemFuel/propulsion SystemVehicle Speed Control
ENGINE WARNING LIGHTS FLASH, WARNING CHECK ENGINE LIGHT DISAPPEAR, REAPPEAR AT WILL, WONT START, SYSTEM FAILURE, LOSS OF POWER, SPEED LIMIT ACUTE LOSS OF POWER, STALLING OF ENGINE WHILE AT FREEWAY SPEEDS, STALLING OUT AT 35-40 MPH SPEEDS, NOISE AT GAS PEDAL. *TR
NHTSA ODI #10500681
83,362 miles · Sep 24, 2012
Fuel/propulsion System
AFTER DAYS OF CAR HESITATING AND TRYING TO STALL, VEHICLE BROKE DOWN AND WAS UNABLE TO BE STARTED IN PARKING LOT OF LOCAL GROCERY STORE. VEHICLE WAS TOWED HOME AND AFTER FURTHER INVESTIGATION WAS FOUND TO BE A FAULTY FUEL PUMP CAUSING THE ISSUE. THE FUEL PUMP WAS CHANGED. OLD FUEL PUMP WAS FACTORY PART, AND WAS FOUND TO HAVE B…
Read full complaint
AFTER DAYS OF CAR HESITATING AND TRYING TO STALL, VEHICLE BROKE DOWN AND WAS UNABLE TO BE STARTED IN PARKING LOT OF LOCAL GROCERY STORE. VEHICLE WAS TOWED HOME AND AFTER FURTHER INVESTIGATION WAS FOUND TO BE A FAULTY FUEL PUMP CAUSING THE ISSUE. THE FUEL PUMP WAS CHANGED. OLD FUEL PUMP WAS FACTORY PART, AND WAS FOUND TO HAVE BURNT WIRING AND MELTED PINS. AFTER FURTHER INVESTIGATION HAVE FOUND THIS IS A COMMON PROBLEM, AND AM SEVERELY CONCERNED AS TO WHY PART WAS NEVER RECALLED. BETWEEN TOWING, FUEL PUMP, AND ALSO BATTERY CHANGE FROM CRANKING CAR TRYING TO GET IT TO START, REPAIRS WERE OVER $350. *TR
NHTSA ODI #10476914
177,000 miles · Aug 27, 2012
Fuel/propulsion SystemFire
TL* THE CONTACT OWNS A 2007 DODGE CALIBER. THE CONTACT STATED THAT THE FUEL PUMP IGNITED AND BURNING FUMES STARTED TO EMIT INTO THE VEHICLE. THE CONTACT INSPECTED THE VEHICLE AND STATED THAT A PLUG ON TOP OF THE FUEL PUMP MELTED AND BECAME EXPOSED TO THE FUEL VAPORS. AS A RESULT, THE WIRING HARNESS AND FUEL PUMP NEEDED TO BE REP…
Read full complaint
TL* THE CONTACT OWNS A 2007 DODGE CALIBER. THE CONTACT STATED THAT THE FUEL PUMP IGNITED AND BURNING FUMES STARTED TO EMIT INTO THE VEHICLE. THE CONTACT INSPECTED THE VEHICLE AND STATED THAT A PLUG ON TOP OF THE FUEL PUMP MELTED AND BECAME EXPOSED TO THE FUEL VAPORS. AS A RESULT, THE WIRING HARNESS AND FUEL PUMP NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE. THE VEHICLE WAS REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 177,000.
NHTSA ODI #10472670
83,500 miles · May 22, 2012
Fuel/propulsion System
A SMALL BRASS BUSHING FELL ON MY RIGHT FOOT ONE DAY WHILE DRIVING. I PICKED IT UP AND PUT IT IN THE CONSOLE CUP HOLDER. A FEW DAYS LATER WHILE ACCELERATING ONTO THE HIGHWAY THE GAS PEDAL STUCK AND THE ENGINE REVVED. THIS HAS HAPPENED A FEW TIMES SINCE. I CALLED CHRYSLER TO CHECK IF MY CALIBER WAS COVERED UNDER THE GAS PEDAL …
Read full complaint
A SMALL BRASS BUSHING FELL ON MY RIGHT FOOT ONE DAY WHILE DRIVING. I PICKED IT UP AND PUT IT IN THE CONSOLE CUP HOLDER. A FEW DAYS LATER WHILE ACCELERATING ONTO THE HIGHWAY THE GAS PEDAL STUCK AND THE ENGINE REVVED. THIS HAS HAPPENED A FEW TIMES SINCE. I CALLED CHRYSLER TO CHECK IF MY CALIBER WAS COVERED UNDER THE GAS PEDAL RECALL. I WAS TOLD THE RECALL ONLY COVERED VEHICLES FROM A CERTAIN DATE RANGE. MY CALIBER WAS MANUFACTURED 2/06. *TT
NHTSA ODI #10459236
109,000 miles · May 15, 2012
Fuel/propulsion System
WHEN PUMPING GAS I CANNOT ALLOW IT TO 'FILL UP' BECAUSE THE GAS WILL LEAK OUT INSTEAD OF TELLING THE HANDLE TO STOP PUMPING GAS AS IT NORMALLY SHOULD. I AM AWARE THAT DODGE DURANGO HAD A RECALL ON THIS VERY MATTER, YET THE CALIBER HAS NOT. I HAVE TO KEEP TRACK OF HOW MANY GALLONS I PUT IN SO AS NOT TO LET IT OVER FLOW. AM I THE …
Read full complaint
WHEN PUMPING GAS I CANNOT ALLOW IT TO 'FILL UP' BECAUSE THE GAS WILL LEAK OUT INSTEAD OF TELLING THE HANDLE TO STOP PUMPING GAS AS IT NORMALLY SHOULD. I AM AWARE THAT DODGE DURANGO HAD A RECALL ON THIS VERY MATTER, YET THE CALIBER HAS NOT. I HAVE TO KEEP TRACK OF HOW MANY GALLONS I PUT IN SO AS NOT TO LET IT OVER FLOW. AM I THE ONLY OWNER OF A DODGE CALIBER HAVING THIS ISSUE WITH THE FUEL SYSTEM/GASOLINE? *JS
NHTSA ODI #10458545
Official recalls
4Dec 21, 2017
Chrysler (FCA US LLC) is recalling various Dodge, Chrysler, and RAM vehicles equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers. A list of the affected trailer models is available at: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17V824-0103.pdf. These extinguishers may become clogged, preventing the extinguisher from discharging as expected or requiring excessive force to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf
Consequence & remedy
Consequence: If the fire extinguisher does not function properly, it can increase the risk of injury in the event of a fire.
Remedy: Chrysler will notify owners instructing them to contact Kidde for a replacement fire extinguisher, free of charge. The recall began February 14, 2018. Owners may contact Chrysler customer service at 1-800-853-1403 or Kidde customer service service toll-free at 1-855-262-3540, or online at www.kidde.com and click on "Product Safety Recall" for more information. Chrysler's number for this recall is T82.
Jun 3, 2010
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2007 DODGE CALIBER AND JEEP COMPASS PASSENGER VEHICLES MANUFACTURED FROM MARCH 7 THROUGH MAY 19, 2006. THE PIVOT BUSHINGS IN VEHICLES WITH OVERSIZED ACCELERATOR PEDAL BEARING POCKETS MAY BECOME DISLODGED AND POTENTIALLY CAUSE THE ACCELERATOR PEDAL TO BIND OR STICK.
Consequence & remedy
Consequence: SHOULD THE PEDAL BIND OR BECOME STUCK, IT CAN BE OVERCOME BY SMART BRAKES WHICH OVERRIDE THE ACCELERATOR PEDAL IN CERTAIN CONDITIONS.
Remedy: CHRYSLER WILL NOTIFY OWNERS AND DEALERS WILL INSPECT AND REPLACE ALL AFFECTED ACCELERATOR PEDAL ASSEMBLIES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 29, 2010. OWNERS MAY CONTACT CHRYSLER TOLL-FREE AT 1-800-853-1403.
May 7, 2007
CERTAIN PASSENGER VEHICLES EQUIPPED WITH REAR DISC BRAKES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD (FMVSS) NO. 135, "LIGHT VEHICLE BRAKE SYSTEMS." THE LENGTH OF THE REAR WHEEL HUB MOUNTING BOLTS MAY PREVENT ACTUATION OF THE PARK BRAKE.
Consequence & remedy
Consequence: THIS COULD ALLOW UNINTENDED MOVEMENT OF THE VEHICLE UNDER CERTAIN CONDITIONS AND CAUSE A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL REPLACE THE REAR WHEEL HUB MOUNTING BOLTS AND REPAIR THE PARK BRAKE FREE OF CHARGE. THE RECALL BEGAN ON MAY 8, 2007. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Dec 29, 2006
ON CERTAIN VEHICLES, THE ANTILOCK BRAKE SYSTEM (ABS) CONTROL MODULE SOFTWARE MAY CAUSE THE REAR BRAKES TO LOCK UP DURING CERTAIN BRAKING CONDITIONS.
Consequence & remedy
Consequence: THIS COULD RESULT IN A LOSS OF VEHICLE CONTROL AND CAUSE A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL REPROGRAM THE ABS ELECTRONIC CONTROL UNIT. THE RECALL BEGAN ON FEBRUARY 19, 2007. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE10012 · Sticking Accelerator Pedal
Opened Apr 29, 2010 · Closed Aug 26, 2010
Status: closed (inferred from source dates) · Vehicle Speed Control:accelerator Pedal
In their Defect Information Report (DIR) of June 3, 2010, Chrysler Group, LLC (Chrysler) notified NHTSA that it will conduct a safety recall of approximately 25,265 model year 2007 Dodge Caliber vehicles and 71 model year 2007 Jeep Compass vehicles manufactured from March 7, 2006 through May 19, 2006.The recall will remedy a defect in the accelerator pedal assembly (accelerator pedal) of the Electronic Throttle Control (ETC) system that can cause the accelerator pedal to stick in an open position and not return to the idle position when released.As stated in the opening resume, the subject vehicles (Caliber) are equipped with an ETC accelerator pedal manufactured by the CTS Corporation, the same supplier of the ETC accelerator pedal used in the recently recalled Toyota vehicles.The ETC accelerator pedal used in Caliber and Compass vehicles is not the same as those used in the recalled Toyota vehicles.They are of a different design, were manufactured using different tooling, and fail in a different manner.According to Chrysler and CTS, oversized bearing pockets in the ETC accelerator pedal housing of the Caliber and Compass vehicles allows the accelerator pedal pivot shaft bearings to dislodge from the housing.If this occurs, the accelerator pedal can stick in an open position (i.e., fails to return to the closed position) or be slow to return.Chrysler's DIR notes that the subject vehicles are equipped with Smart Brake Technology and contends that the impact of a binding or sticking accelerator pedal can be negated by its Smart Brake system.In Chrysler's view, the system enables the brake pedal input to override the throttle control system and safely depower the vehicle and minimizes the potential for safety consequences resulting from the defect in the accelerator pedal.Further, Chrysler states, as a result of the presence of this technology, Chrysler Group LLC has concluded that the condition described in this report does not present an unreasonable risk to motor vehicle safety.ODI does not concur with Chrysler's position that the Smart Brake technology employed in the subject vehicles eliminates unreasonable risks to safety stemming from the ETC accelerator pedal defect.Aside from the fact that the technology is applicable only to situations where the brake pedal is activated, the Smart Brake system implemented in the subject vehicles will override a stuck throttle under a discrete set of conditions.Because driver behaviors (e.g., kicking at the accelerator pedal to dislodge it, or pumping the brake pedal instead of steady application) may delay or prevent activation of the Smart Brake system in the subject vehicles, ODI believes that this Smart Brake system does not totally eliminate unreasonable risks to safety posed by this defect or the necessity of a safety recall in this case.See Safety Recall file 10V-234 for recall details.
Illustration