IllustrationAIRBAG ISSUES HAVE ALWAYS BEEN A PROBLEM AND CAR WAS PURCHASED BRAND NEW. DRIVER SIDE HEAD RESTRAINT IS FAULTY AGAIN AND REPAIRS WILL COST 1100 TO REPLACE THE ENTIRE HEAD REST.*DT *TR CONSUMER STATED AIRBAG LIGHT CAME ON WITHIN HAVING THE CAR FOR ABOUT A YEAR.*JB
2012 Dodge Avenger
Owner reports · Recalls · Investigations
More warning signs than most Avenger years
Owner complaints for the 2012 Dodge Avenger are substantially higher than the model-year median of 157.
About this comparison →How this year compares
Owner complaints by model year
Compare all Avenger years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
370–25K
7225–50K
10650–75K
8775–100K
74100–150K
15150K+
391 reports with mileage · 162 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 109 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 108 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility/wiper. Review the 95 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
34 crash reports7 fire reports30 injury reports
Air Bags complaints
109 reportsTL* THE CONTACT OWNS A 2012 DODGE AVENGER. WHILE THE CONTACT'S VEHICLE WAS STOPPED AT A YIELD SIGN, IT WAS REAR ENDED BY ANOTHER VEHICLE TRAVELING APPROXIMATELY 60 MPH. THE CONTACT'S VEHICLE WAS PUSHED INTO ONCOMING TRAFFIC. THE CONTACT STATED THAT THE SEAT BELTS NEVER ENGAGED AND THE AIR BAGS DID NOT DEPLOY. THE CONTACT WAS KN…
Read full complaint
TL* THE CONTACT OWNS A 2012 DODGE AVENGER. WHILE THE CONTACT'S VEHICLE WAS STOPPED AT A YIELD SIGN, IT WAS REAR ENDED BY ANOTHER VEHICLE TRAVELING APPROXIMATELY 60 MPH. THE CONTACT'S VEHICLE WAS PUSHED INTO ONCOMING TRAFFIC. THE CONTACT STATED THAT THE SEAT BELTS NEVER ENGAGED AND THE AIR BAGS DID NOT DEPLOY. THE CONTACT WAS KNOCKED UNCONSCIOUS AND SUSTAINED A HEAD CONTUSION, CONCUSSION, NECK SPRAIN, AND BACK INJURIES. THE CONTACT'S DAUGHTER SUSTAINED MINOR INJURIES THAT DID NOT REQUIRE MEDICAL ATTENTION. THE CONTACT WAS TAKEN TO THE HOSPITAL FOR MEDICAL TREATMENT AND UNDERWENT SEVERAL BRAIN SCANS. SHE WAS ALSO CURRENTLY EXPERIENCING MINOR SEIZURES. A POLICE REPORT WAS FILED. THE VEHICLE WAS INITIALLY TOWED TO THE CONTACT'S HOME. THE CONTACT'S INSURANCE COMPANY HAD THE VEHICLE TOWED TO LITHIA CHRYSLER JEEP DODGE RAM OF CORPUS CHRISTI (4313 S STAPLES ST, CORPUS CHRISTI, TX 78411, 361-288-2510) WHERE IT WAS KEPT FOR TWO MONTHS. THE CONTACT STATED THAT THE DEALER PERFORMED AN UNKNOWN RECALL REPAIR REGARDING THE ACTIVE HEAD RESTRAINT WHILE THE VEHICLE WAS IN THEIR POSSESSION. THE CONTACT'S INSURANCE COMPANY PAID FOR ALL THE REPAIRS TO THE VEHICLE, BUT A LEAK WAS STILL PRESENT. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE CAUSE OF THE FAILURES WAS NOT DETERMINED. AFTER REVIEWING THE CARFAX REPORT, THE CONTACT DISCOVERED THAT THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBERS: 17V640000 (SEATS, AIR BAGS) AND 16V668000 (SEAT BELTS, AIR BAGS); HOWEVER, SHE NEVER RECEIVED ANY NOTIFICATIONS. THE FAILURE MILEAGE WAS APPROXIMATELY 60,000.
VEHICLE WAS SERVICED FOR AIRBAG RECALLS HOWEVER THE LIGHT STAYS ON CONSTANTLY. NOT LONG AFTER BUYING THE VEHICLE, I WOULD PUT USE THE TURN SIGNAL AND THE WINDSHIELD WIPERS WOULD COME ON, THEY STILL DO FROM TIME TO TIME. I TOOK IT IN FOR SERVICE AT THE DEALER AND THEY COULD NOT FIGURE OUT THE PROBLEM. ALSO, FROM TIME …
Read full complaint
VEHICLE WAS SERVICED FOR AIRBAG RECALLS HOWEVER THE LIGHT STAYS ON CONSTANTLY. NOT LONG AFTER BUYING THE VEHICLE, I WOULD PUT USE THE TURN SIGNAL AND THE WINDSHIELD WIPERS WOULD COME ON, THEY STILL DO FROM TIME TO TIME. I TOOK IT IN FOR SERVICE AT THE DEALER AND THEY COULD NOT FIGURE OUT THE PROBLEM. ALSO, FROM TIME TO TIME, THE AIR CONDITIONER BUTTON WILL NOT WORK. THE ONLY WAY TO GET IT TO WORK IS TO RAPIDLY TURN THE KNOB FROM SIDE TO SIDE. IT HAS SOMETIMES TAKEN UP TO 5 MINUTES TO GET IT TO WORK.
AIR BAG LIGHT WAS COMING ON AND OFF FOR DRIVERS HEAD REST AIR BAG WAS TAKEN IN FOR THAT RECALL NOW SAME PROBLEM IS HAPPENING AGAIN ALSO HAVE THAT AWESOME DODGE DEFECT WERE THE HEATER BLOWS HOT ON DRIVERS SIDE AND ICE ICE COLD ON PASSENGER SIDE THESE ARE PRETTY MAJOR DEFECTS WITCH DODGE HAS KNOWN ABOUT AND SHOULD BE HELD ACCOUNT…
Read full complaint
AIR BAG LIGHT WAS COMING ON AND OFF FOR DRIVERS HEAD REST AIR BAG WAS TAKEN IN FOR THAT RECALL NOW SAME PROBLEM IS HAPPENING AGAIN ALSO HAVE THAT AWESOME DODGE DEFECT WERE THE HEATER BLOWS HOT ON DRIVERS SIDE AND ICE ICE COLD ON PASSENGER SIDE THESE ARE PRETTY MAJOR DEFECTS WITCH DODGE HAS KNOWN ABOUT AND SHOULD BE HELD ACCOUNTABLE
HAD RECALLS DONE ON VEHICLE BUT DASH LIGHT FOR AIRBAGS IS ON AND STAYS ON FOR LAST 3 YEARS NOW
TL* TAKATA RECALL. THE CONTACT WAS A PASSENGER IN A 2012 DODGE AVENGER. THE CONTACT WAS INVOLVED IN A FRONT END CRASH AND THE AIR BAGS DEPLOYED INCORRECTLY, WHICH INJURED THE CONTACT. MEDICAL ATTENTION WAS RECEIVED. THE AIR BAGS WERE REPLACED FROM THE ORIGINAL TAKATA AIR BAGS. A POLICE REPORT WAS FILED. THE DRIVER'S INSURANCE CO…
Read full complaint
TL* TAKATA RECALL. THE CONTACT WAS A PASSENGER IN A 2012 DODGE AVENGER. THE CONTACT WAS INVOLVED IN A FRONT END CRASH AND THE AIR BAGS DEPLOYED INCORRECTLY, WHICH INJURED THE CONTACT. MEDICAL ATTENTION WAS RECEIVED. THE AIR BAGS WERE REPLACED FROM THE ORIGINAL TAKATA AIR BAGS. A POLICE REPORT WAS FILED. THE DRIVER'S INSURANCE COMPANY TOWED THE VEHICLE AND DECLARED IT DESTROYED. THE CAUSE OF THE FAILURE WAS UNKNOWN. THE VIN AND FAILURE MILEAGE WERE UNKNOWN. *TT*JB CONSUMER STATED VIN UPDATED, CONSUMER WAS A PASSENGER NOT THE OWNER. *JB *DT PHOTOS ATTACHED 'PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).'*JB
TAKATA RECALL ALSO HEATER CORE ISSUE. HEAT ONLY BLOWS ON DRIVERS SIDE WHEN SET TO HEAT AND COLD AIR BLOWS ON PASSENGER SIDE. SEEMS TO BE A KNOWN ISSUE WITH CHRYSLER BUT THEY DO NOT WANT TO FORCE A RECALL. TRANSMISSION ALSO SLAMS INTO GEAR WHEN STOPPING AND AT TIMES BEFORE ACCELERATION. NO DIP STICK TO VERIFY FLUID LEVEL. DEAL…
Read full complaint
TAKATA RECALL ALSO HEATER CORE ISSUE. HEAT ONLY BLOWS ON DRIVERS SIDE WHEN SET TO HEAT AND COLD AIR BLOWS ON PASSENGER SIDE. SEEMS TO BE A KNOWN ISSUE WITH CHRYSLER BUT THEY DO NOT WANT TO FORCE A RECALL. TRANSMISSION ALSO SLAMS INTO GEAR WHEN STOPPING AND AT TIMES BEFORE ACCELERATION. NO DIP STICK TO VERIFY FLUID LEVEL. DEALER STATES NOTHING WRONG WITH IT. THEY STATED THEY FLUSHED HEATER CORE AND STILL HAVE SAME ISSUE. THIS HAPPENS DRIVING IN WINTER OR SUMMER ON HIGHWAY, CITY STREETS.
WHILE SITTING IN THE STATIONARY VEHICLE THE DRIVER SIDE ACTIVE HEADREST DEPLOYED WITH OUT BEING IN A COLLISION.
S61 AIRBAG RECALL- I'VE HAD THIS ISSUES FIXED TWICE ALREADY AND I STILL HAVE THE ISSUE OF THE STANDING AIRBAG LIGHT. I'VE BEEN TOLD AS LONG AS THE LIGHT IS ON MY AIRBAG WILL NOT DEPLOY IN THE CASES OF AN ACCIDENT. I WAS TOLD NUMEROUS TIMES THAT BECAUSE THE S61 RECALL WAS COMPLETED. I SHOULD BE OK, BUT HOW CAN I BE SURE WHEN TH…
Read full complaint
S61 AIRBAG RECALL- I'VE HAD THIS ISSUES FIXED TWICE ALREADY AND I STILL HAVE THE ISSUE OF THE STANDING AIRBAG LIGHT. I'VE BEEN TOLD AS LONG AS THE LIGHT IS ON MY AIRBAG WILL NOT DEPLOY IN THE CASES OF AN ACCIDENT. I WAS TOLD NUMEROUS TIMES THAT BECAUSE THE S61 RECALL WAS COMPLETED. I SHOULD BE OK, BUT HOW CAN I BE SURE WHEN THE AIRBAG LIGHT IS STILL ON. THE FIRST TIME I GOT THIS ITEM FIXED IT TOOK TWO WEEKS FOR THE AIRBAG LIGHT TO COME BACK ON. THE SECOND TIME I GOT THIS ISSUE FIXED IT TOOK A MONTH OR SO SO FOR THE AIRBAG LIGHT TO START COMING BACK ON INTERMITTENTLY. I'M SPENDING A LOT MORE TIME ON THE ROAD NOW AND THE AIRBAG LIGHT IS ON ALL THE TIME NOW. I'VE TAKEN IT IN FOR THE THIRD TIME, BUT TO A DIFFERENT DEALERSHIP. THEY REFUSED TO FIX THE THE ISSUE, BECAUSE THEY WEREN'T THE ONES WHO DID THE FIRST TWO RECALLS. WHEN I AS FOR THEM TO PROVIDE ME WITH SOMETHING IN WRITING INCASE I GET IN A ACCIDENT AND MY AIRBAG DOESN'T DEPLOY STATING WHY THEY WOULDN'T FIX IT THEY AGREE TO DO SO, BUT I HAVE TO PAY OUT OF POCKET FOR THE DIAGNOSIS AND ANY REPAIRS THAT WOULD NEED TO BE COMPLETED. IM NOT SURE IF THERE ARE OTHER PEOPLE WHO HAVE HAD ISSUE WITH THIS TYPE OF RECALL, JUST HOPING SOMEONE CAN LOOK IT TO IT.
TAKATA RECALL" I HAVE EXPERIENCED PROBLEMS WITH THE ALTERNATOR 3 TIMES, THIS VEHICLE IS A 2012 DODGE AVENGER, THE MILEAGE THAT I STARTED RECEIVING PROBLEMS WERE PROBALY 67,000 AND 80,000. I HAVE REPLACED THE ALTERNATOR 3 TIMES, 2 TIMES IN THE LAST 2 YEARS. THE PROBLEM STARTED WHEN THE EGINE LIGHT ALERTED ME THERE WAS A PROBLEM …
Read full complaint
TAKATA RECALL" I HAVE EXPERIENCED PROBLEMS WITH THE ALTERNATOR 3 TIMES, THIS VEHICLE IS A 2012 DODGE AVENGER, THE MILEAGE THAT I STARTED RECEIVING PROBLEMS WERE PROBALY 67,000 AND 80,000. I HAVE REPLACED THE ALTERNATOR 3 TIMES, 2 TIMES IN THE LAST 2 YEARS. THE PROBLEM STARTED WHEN THE EGINE LIGHT ALERTED ME THERE WAS A PROBLEM I THEN TOOK THE CAR TO GET IT CHECKED AND THEY SAID THAT THE CHARGING SYSTEM WAS NOT CHARGING THE ALTERNATOR PROPERLY, THEN IT RESULTED IN BATTERY ISSUES DRAINING THE BATTERY, IF I TURNED MY LIGHTS OR WIPERS ON OR ANYTHING ELECTRICAL THE PROBLEM WAS WORSE. THEN THE CAR STALLED ON THE INTERSTATE, FROM THERE I WAS TOWED TO A CAR MAX. THERE THEY CHARGED ME FOR THE LABOR ON THE ALTERNATOR BECAUSE I HAD AN EXTTENDED WARRANTY AT THE TIME OF THIS PARTICULAR FAILURE. THE NEXT INCIDENT I HAD TO GET THE BATTERY REPLACED AND IT WAS THE ALTERNATOR AGAIN AFTER I REPLACED THE BATTERY. TOOK THE CAR TO REPLACE AGAIN ANOTHER ALTERNATOR FAILURE. I WAS DRIVING EVERY TIME I EXPERIENCE PROBLEMS. SEE ALSO 11081233
Official recalls
317V640000 · Air Bags:frontal:sensor/control MODULE-INACTIVE ; Seats:front Assembly:head Restraint
Oct 10, 2017
Chrysler (FCA US LLC) is recalling certain 2012 Jeep Liberty and 2012-2013 Chrysler 200 and Dodge Avenger vehicles. A component within the occupant restraint controller (ORC) may fail and prevent the active headrests from deploying in the event of a rear-end crash.
Consequence & remedy
Consequence: If the active headrests do not deploy in certain rear-end crashes, the front seat occupants have an increased risk of injury.
Remedy: Chrysler will notify owners, and dealers will replace the ORC as necessary, free of charge. The recall began on December 4, 2017. Owners may contact FCA customer service at 1-800-853-1403. FCA's number for this recall is T56.
Additional source detail variants (2)
Seats:front Assembly:head Restraint
Chrysler (FCA US LLC) is recalling certain 2012 Jeep Liberty and 2012-2013 Chrysler 200 and Dodge Avenger vehicles. A component within the occupant restraint controller (ORC) may fail and prevent the active headrests from deploying in the event of a rear-end crash.
Consequence: If the active headrests do not deploy in certain rear-end crashes, the front seat occupants have an increased risk of injury.
Remedy: Chrysler will notify owners, and dealers will replace the ORC as necessary, free of charge. The recall began on December 4, 2017. Owners may contact FCA customer service at 1-800-853-1403. FCA's number for this recall is T56.
Air Bags:frontal:sensor/control MODULE-INACTIVE
Chrysler (FCA US LLC) is recalling certain 2012 Jeep Liberty and 2012-2013 Chrysler 200 and Dodge Avenger vehicles. A component within the occupant restraint controller (ORC) may fail and prevent the active headrests from deploying in the event of a rear-end crash.
Consequence: If the active headrests do not deploy in certain rear-end crashes, the front seat occupants have an increased risk of injury.
Remedy: Chrysler will notify owners, and dealers will replace the ORC as necessary, free of charge. The recall began on December 4, 2017. Owners may contact FCA customer service at 1-800-853-1403. FCA's number for this recall is T56.
16V668000 · Air Bags; Air Bags:frontal:sensor/control MODULE-INACTIVE ; Seat Belts:pretensioner
Sep 15, 2016
Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Chrysler 200, 2010 Chrysler Sebring, 2010-2012 Dodge Caliber and 2010-2014 Jeep Patriot, Compass and Dodge Avenger vehicles. The Occupant Restraint Control (OCR) module may short circuit, preventing the frontal air bags, seat belt pretensioners, and side air bags from deploying in the event of a crash.
Consequence & remedy
Consequence: If the frontal air bags, seat belt pretensioners, and side air bags are disabled, there is an increased risk of injury to the vehicle occupants in the event of a vehicle crash that necessitates deployment of these safety systems.
Remedy: Chrysler will notify owners, and dealers will replace the OCR, free of charge. Interim letters informing owners that parts are not available yet were mailed on October 26, 2016. The recall began on August 15, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S61.
Additional source detail variants (3)
Seat Belts:pretensioner
Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Chrysler 200, 2010 Chrysler Sebring, 2010-2012 Dodge Caliber and 2010-2014 Jeep Patriot, Compass and Dodge Avenger vehicles. The Occupant Restraint Control (OCR) module may short circuit, preventing the frontal air bags, seat belt pretensioners, and side air bags from deploying in the event of a crash.
Consequence: If the frontal air bags, seat belt pretensioners, and side air bags are disabled, there is an increased risk of injury to the vehicle occupants in the event of a vehicle crash that necessitates deployment of these safety systems.
Remedy: Chrysler will notify owners, and dealers will replace the OCR, free of charge. Interim letters informing owners that parts are not available yet were mailed on October 26, 2016. The recall began on August 15, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S61.
Air Bags:frontal:sensor/control MODULE-INACTIVE
Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Chrysler 200, 2010 Chrysler Sebring, 2010-2012 Dodge Caliber and 2010-2014 Jeep Patriot, Compass and Dodge Avenger vehicles. The Occupant Restraint Control (OCR) module may short circuit, preventing the frontal air bags, seat belt pretensioners, and side air bags from deploying in the event of a crash.
Consequence: If the frontal air bags, seat belt pretensioners, and side air bags are disabled, there is an increased risk of injury to the vehicle occupants in the event of a vehicle crash that necessitates deployment of these safety systems.
Remedy: Chrysler will notify owners, and dealers will replace the OCR, free of charge. Interim letters informing owners that parts are not available yet were mailed on October 26, 2016. The recall began on August 15, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S61.
Air Bags
Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Chrysler 200, 2010 Chrysler Sebring, 2010-2012 Dodge Caliber and 2010-2014 Jeep Patriot, Compass and Dodge Avenger vehicles. The Occupant Restraint Control (OCR) module may short circuit, preventing the frontal air bags, seat belt pretensioners, and side air bags from deploying in the event of a crash.
Consequence: If the frontal air bags, seat belt pretensioners, and side air bags are disabled, there is an increased risk of injury to the vehicle occupants in the event of a vehicle crash that necessitates deployment of these safety systems.
Remedy: Chrysler will notify owners, and dealers will replace the OCR, free of charge. Interim letters informing owners that parts are not available yet were mailed on October 26, 2016. The recall began on August 15, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S61.
13V282000 · Air Bags; Electrical System
Jul 2, 2013
Chrysler is recalling certain model year 2011-2013 Sebring and 200 vehicles manufactured June 28, 2011, through December 13, 2012; model year 2011-2013 Dodge Avenger vehicles manufactured June 25, 2011, through January 14, 2013; model year 2011-2012 Dodge Nitro vehicles manufactured June 17, 2011, through December 15, 2011; and model year 2011-2012 Jeep Liberty vehicles manufactured June 17, 2011, through August 15, 2012. Electrical over-stress of a resistor in the occupant restraint control module may lead to the non-deployment of the active head restraints during a rear impact collision.
Consequence & remedy
Consequence: In the event of a crash necessitating the deployment of the active head restraints , their non-deployment could increase the risk of injury.
Remedy: Chrysler will notify owners, and dealers will flash the Totally Integrated Power Module (TIPM) or replace the occupant restraint control module, as needed, free of charge. The recall began on November 19, 2013. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign number is N38.
Additional source detail variants (2)
Air Bags
Chrysler is recalling certain model year 2011-2013 Sebring and 200 vehicles manufactured June 28, 2011, through December 13, 2012; model year 2011-2013 Dodge Avenger vehicles manufactured June 25, 2011, through January 14, 2013; model year 2011-2012 Dodge Nitro vehicles manufactured June 17, 2011, through December 15, 2011; and model year 2011-2012 Jeep Liberty vehicles manufactured June 17, 2011, through August 15, 2012. Electrical over-stress of a resistor in the occupant restraint control module may lead to the non-deployment of the active head restraints during a rear impact collision.
Consequence: In the event of a crash necessitating the deployment of the active head restraints , their non-deployment could increase the risk of injury.
Remedy: Chrysler will notify owners, and dealers will flash the Totally Integrated Power Module (TIPM) or replace the occupant restraint control module, as needed, free of charge. The recall began on November 19, 2013. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign number is N38.
Electrical System
Chrysler is recalling certain model year 2011-2013 Sebring and 200 vehicles manufactured June 28, 2011, through December 13, 2012; model year 2011-2013 Dodge Avenger vehicles manufactured June 25, 2011, through January 14, 2013; model year 2011-2012 Dodge Nitro vehicles manufactured June 17, 2011, through December 15, 2011; and model year 2011-2012 Jeep Liberty vehicles manufactured June 17, 2011, through August 15, 2012. Electrical over-stress of a resistor in the occupant restraint control module may lead to the non-deployment of the active head restraints during a rear impact collision.
Consequence: In the event of a crash necessitating the deployment of the active head restraints , their non-deployment could increase the risk of injury.
Remedy: Chrysler will notify owners, and dealers will flash the Totally Integrated Power Module (TIPM) or replace the occupant restraint control module, as needed, free of charge. The recall began on November 19, 2013. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign number is N38.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE19014 · Active Head Rest Inadvertent Deployment
Opened Sep 9, 2019 · Closed Feb 25, 2026
Status: closed (inferred from source dates) · Seats; Seats:front Assembly:head Restraint
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Seats
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Seats:front Assembly:head Restraint
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.