2008 Dodge Avenger

The contact owns a 2008 Dodge Avenger. The contact stated that while driving at an undisclosed speed, the vehicle stalled. The battery, the check engine, and the throttle body warning lights were illuminated. Additionally, the contact noticed an abnormal odor while the vehicle was parked. The contact noticed there was smoke coming from underneath the hood. The contact's father lifted the hood and removed the positive (+) charge cable from the battery. The contact's father replaced the battery and the alternator; however, the failure recurred while driving. The contact's father replaced the alternator for the second time. The contact related the failure to NHTSA Campaign Numbers: 08V152000 (Electrical System) and 07V426000 (Fuel System, Gasoline), however, the dealer confirmed that the VIN was not included in the recall. The vehicle was not diagnosed nor repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 255,000.

VEHICLE STARTED HAVING ISSUES STARTING AND THEN IT WOULD START AND RUN FINE AND THEN DIE.I WAS CONTACTED AND NOTICED THAT THE FUEL PUMP WAS NOT COMING ON AND THEN WOULD ALL THE SUDDEN COME ON ANDTHEN QUIT SO I REMOVED THE REAR SEAT AND UNPLUGGED THE WIRE HARNESS AND COULD SEE WHERE IT HAD BEEN BURNED AND LOOKED AT THE TOP OF THE PUMP WHERE THE HARNESS PLUGS IN AND COULD SEE AND SMELL GAS.I REMOVED THE FUEL PUMP AND YOU COULD SEE WHERE ONE OF THE WIRE HARNESSES INSIDE THE FUEL TANK ON THE FUEL PUMP HAD BURNED A HOLE ALL THE WAY THROUGH.IN THE WHOLE PROCESS OF THIS NO FUSE EVER BLEW TO SHUT POWER OFF AND WAS TOLD THERE IS NO FUSE BY SOMEONE AT THE DODGE DEALER.I PROCEEDED TO LOOK ON THE INTERNET AND FOUND NUMEROUS ACCOUNTS OF THIS SAME ISSUE AND NOBODY HAS REPORTED IT THE CHANGED THERE FUEL PUMP BUT THAT DOES NOT FIX THE ISSUE. IF THERE IS NO FUSE TO BLOW SOMEBODY IS GOING TO GET HURT AND IF THERE IS A FUSE WHY ARE THEY NOT BLOWING. *TR

TL* THE CONTACT OWNS A 2008 DODGE AVENGER. THE CONTACT STATED THAT THE VEHICLE STALLED SEVERAL TIMES AND THE CHECK ENGINE LIGHT WAS ILLUMINATED AS THE FAILURE OCCURRED. THE VEHICLE WAS TAKEN TO THE MECHANIC WHERE A DIAGNOSTIC WAS PERFORMED, WHICH LOCATED THE FAILURE AT THE FUEL INJECTOR. THE FUEL INJECTOR WAS REPLACED, HOWEVER THE FAILURE WAS NOT CORRECTED. THE MECHANIC ADVISED THE CONTACT THAT MAIN COMPUTER MAY HAVE NEEDED TO BE REPROGRAMMED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 112,023.

WHEN FILLING UP TANK THE TANK EJECTS ABOUT A QUART OF GASOLINE WHEN FINISHED PUMPING GAS. EVEN WHEN TRYING TO GO SLOW AT THE END. THE GASOLINE "BURPS" OUT ALL OVER THE SIDE OF THE VEHICLE, THE OPERATOR AND GROUND. THIS ISN'T SAFE BECAUSE THE POTENTIALLY HOT ROTOR IS DIRECTLY UNDERNEATH THE FILL PORT MIGHT START A FIRE WHILE THE OPERATOR IS DOUSED WITH FUEL. *TR

TL* THE CONTACT OWNS A 2008 DODGE AVENGER. THE CONTACT STATED THAT WHILE REFUELING THE VEHICLE, FUEL SPILLED BACK OUT FROM THE FILLER NECK VALVE. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTICS. THE TECHNICIAN ADVISED THE CONTACT THAT THE VENT TUBING AND THE NECK OF THE FUEL TANK WOULD HAVE TO BE REPLACED. THE VEHICLE WAS REPAIRED HOWEVER, THE FAILURE CONTINUED. THE VEHICLE WAS TAKEN BACK TO THE DEALER WHERE THE TECHNICIAN STATED THAT THE FUEL TANK WOULD HAVE TO BE REPLACED. THE VEHICLE WAS NOT FURTHER REPAIRED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 96,000.

THE GAS TANK IS NOT VENTING PROPERLY, RESULTING IN GAS SPRAY WHEN FILLING UP. MY VEHICLE IS SPRAYING FUEL AT EVERY FILLUP AND DOES NOT MATTER WHICH STATION, PUMP, PUMP POSITION, OR FILLING RATE. THE SPRAY CAN BE REDUCED BY SLOWING THE FILLING RATE WHEN CLOSE TO FULL BUT IS VERY DIFFICULT TO PREVENT OVERFLOW. THIS SPRAY IS ENOUGH TO AND HAS SOAKED MY SHOES AND PANTS. I HAVE RESEARCHED SEVERAL FORUMS AND CONTACTED MY DEALERSHIP. I AM TOLD THE TANK USUALLY NEEDS REPLACED AT A HIGH SERVICE COST. I AM REPORTING THIS AS A SAFETY CONCERN BECAUSE MOST OWNERS CAN NOT IMMEDIATELY AFFORD A ~$900 SERVICE CHARGE. I WILL CONTINUE TO ATTEMPT TO MANAGE THIS OVERFILL SPRAY BY NOT FILLING IT ALL THE WAY UNTIL I CAN AFFORD THE REPAIR. THANK YOU FOR YOUR TIME. *TR

WHEN FILLING UP MY GAS TANK, THE GAS PUMP DOES NOT STOP. THIS HAPPENS AT ALL STATIONS EVERY TIME. THE FUEL IS QUITE EXPLOSIVE WHEN FULL, AND JUMPS OUT OF THE TANK GETTING FUEL EVERYWHERE. IT JUMPS ABOUT A FOOT OUT OF THE TANK. YOU CAN HEAR THAT THERE IS AN AIR POCKET IN MY GAS TANK. I CAN NEVER FILL IT FULL AND HAVE TO STOP JUST SHORT. I ALSO HAVE TO CHECK MY FUEL BY TURNING THE IGNITION TO THE ON POSITION WHICH APPARENTLY NOW HAS MESSED WITH MY LOCKS ACCORDING TO THE MANUAL, IF YOU TURN IT TO THE ON/LOCK POSITION 4 TIMES IN A ROW IT DOES SOMETHING TO YOUR LOCKS. SO NOW MY LOCKS ARE MESSED UP TOO. I BROUGHT IT TO THE DEALERSHIP AND THEY STATED IT WOULD COST OVER 400 DOLLARS TO REPLACE. *TR

AT OR AROUND 50,000 MILES, IT BECAME ALMOST IMPOSSIBLE TO FILL THE FUEL TANK WITHOUT A VIOLENT BACKSPLASH OF GAS. NO MATTER HOW SLOWLY YOU FILL, OR HOW MANY OPPORTUNITIES YOU GIVE IT TO VENT, YOU STILL END UP WITH A SPILL. WHEN I SAY SPILL, IT MEANS THAT GAS LITERALLY PROJECTS OUTWARD ONTO THE GROUND, AND DOWN THE SIDE OF THE CAR. OFTEN THE TIRE ENDS UP SOAKED, AND OCCASIONALLY YOUR CLOTHING AND OR SHOES. I HAVE FOUND OTHER PEOPLE ON AVENGER SITES COMPLAINING OF THE EXACT SAME THING, THEREFORE I KNOW THIS IS NOT RARE. AROUND THE SAME TIME THIS BEGAN, THE CAR ALSO BEGAN STALLING IN RAINY WEATHER. I DON"T KNOW IF THESE ARE CONNECTED, BUT IT SEEMS SUSPECT. APPARENTLY OTHER PEOPLE HAVE BEEN TOLD BY THEIR DEALERSHIPS THAT THE ENTIRE FUEL TANK HAS TO BE CHANGED DUE TO A FAULTY ROLLOVER VALVE. *TR