IllustrationTHERE IS A KNOCKING NOISE ON FRONT PASSENGER'S AXLE AND MODERATE VIBRATION THAT ONLY OCCURS WHEN THE VEHICLE GOES OVER 40 MPH. DEALERSHIP INDICATES THAT THE SWAY BARS ARE BENT, AND THE BUSHINGS ARE BAD.*AK
2003 Chrysler Voyager
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Voyager years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 19 of 32 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 8 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 5 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 4 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports1 injury reports
What owners actually said
32 reports2003 CHRYSLER VOYAGER'S FRONT BUMPER CRACKED DURING THE COLD WINTER MONTHS.*MR *NM
THE PLASTIC MOLDING THAT COVERED THE FRONT BUMPER CRACKED . THE CRACKING OF THAT MOLDING WAS CAUSED BY THE COLD WEATHER (BELOW 10 DEGREE F). CONSUMER WAS CONCERNED THAT PIECES OF THE CRACKED BUMPER MY CAUSES DAMAGE TO THE FRONT WINDSHIELD OR TO THE TIRES WHILE DRIVING. DEALER WAS NOTIFIED.*AK *NM
THERE IS A WATER LEAK THROUGH THE STEERING COLUMN DOWN TO THE DRIVER'S SIDE CARPET FLOOR. THE WATER TENDS TO MAKE THE ACCELERATOR AND BRAKE PADS WET. ALSO, STEERING COLUMN TENDS TO MAKE A CLICKING SOUND WHENEVER THE VEHICLE IS BEING DRIVEN.*AK
CONSUMER RECEIVED RECALL 04V386000 CONCERNING POWER STEERING. DEALER REFUSED TO DO THE WORK. *AK
THE RIGHT SIDE SLIDING DOOR HAD NO WAY OF STOPPING. AS A RESULT, THE DRIVER'S ARM WAS INJURED WHEN THE DOOR SLAMMED SHUT. THE DRIVER SPRAINED WRIST.*AK
WHILE THE VEHICLE WAS PARKED IN THE DRIVEWAY, THE CONSUMER NOTICED THAT THE REAR PASSENGER WINDOW HAD BLOWN OUT. *AK THE DESIGN OF THE WINDOWS SUPPORT FOR THE GLASS OVER THE BODY RUBBER CUSHIONS, CAUSED THE GLASS TO VIBRATE AND SHATTER. *SCC *JB
THE HORN WAS REPLACED THREE TIMES, HOWEVER THE PROBLEM RECURRED. *JB THE HORN WAS REPORTED 3 TIMES. THE DEALER SAID IT WAS THE WAY THE HORN WAS DESIGNED. THE CONSUMER TRIED TO USE THE HORN 3 TIMES IN ORDER TO AVOID CONTACT WITH ANOTHER VEHICLE. (THE HORN DID NOT WORK DUE TO THE CENTRAL POINT) *SCC *JB
THERE WAS A HOWLING NOISE COMING FROM VEHICLE. THE DEALER WAS CONTACTED AND WAS UNABLE TO THE DUPLICATE THE PROBLEM. *AK THE DEALER SUGGESTED IT WAS A CUSTOMARY NOISE. THE DEALER REPLACED THE CATALYTIC CONVERTER, BUT THE SOUND STILL EXISTED. THE VAN WAS TAKEN AGAIN AND THE EXHAUST MANIFOLD WAS REPLACED BUT THERE WAS STILL…
Read full complaint
THERE WAS A HOWLING NOISE COMING FROM VEHICLE. THE DEALER WAS CONTACTED AND WAS UNABLE TO THE DUPLICATE THE PROBLEM. *AK THE DEALER SUGGESTED IT WAS A CUSTOMARY NOISE. THE DEALER REPLACED THE CATALYTIC CONVERTER, BUT THE SOUND STILL EXISTED. THE VAN WAS TAKEN AGAIN AND THE EXHAUST MANIFOLD WAS REPLACED BUT THERE WAS STILL NO RESULT. (THIS WAS THE 5TH TIME TAKEN TO THE DEALER WITH NO RESULT) THE NOISE SEEMED TO COME WHEN ACCELERATING. *SCC *JB
WHILE DRIVING 60 MPH ON THE HIGHWAY VEHICLE WOULDN'T SHIFT AND SUDDENLY DECELERATED. VEHICLE WAS TAKEN TO THE DEALER, WHO STATED THAT PROBLEM COULD BE IN THE ENGINE OR THE COMPUTER, BUT WAS NOT ABLE TO DETERMINE THE PROBLEM. *AK
Official recalls
104V386000 · Steering:hydraulic Power Assist:hose, Piping, And Connections
Aug 5, 2004
ON CERTAIN MINIVANS EQUIPPED WITH 3.3 OR 3.8L V-6 ENGINE, THE UPPER POWER STEERING COOLER HOSE MAY SPLIT AND CAUSE A FLUID LEAK.
Consequence & remedy
Consequence: POWER STEERING FLUID LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN AN UNDER HOOD FIRE.
Remedy: DEALERS WILL REPLACE THE UPPER POWER STEERING COOLER HOSE. THIS RECALL BEGAN ON SEPTEMBER 27, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1DP14002 · Engine Stall After Refueling
Opened Sep 5, 2014 · Closed Apr 6, 2015
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly
This defect petition evaluates July 7, 2014 allegations from an owner of a model year (MY) 2007 Dodge Grand Caravan minivan that engine stall occurs in these vehicles without warning after refueling.The petitioner's vehicle is a Chrysler RS platform minivan.The RS platform includes MY 2003 through 2007 Dodge Grand Caravan, Dodge Caravan, Chrysler Town and Country and Chrysler Voyager minivans.NHTSA evaluated the petition by analyzing consumer complaints submitted to the Agency, analyzing field data, reviewing technical information provided in Chrysler's response to an Agency information request and testing an RS minivan identified by its owner as experiencing post-refuel engine stalls.After completing this evaluation, NHTSA has concluded that further investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists.The stalls occurring in these vehicles only occur immediately after filling up the fuel tank and happen at low engine speeds. The failure rate is low, even after 8 to 13 years of the vehicles being in service, and there are no reports of crashes or injuries resulting from the stall condition.In the Agency's view, additional investigation is unlikely to result in finding the existence of a safety-related defect in the subject vehicles.Given the need to allocate and prioritize NHTSA's limited resources to best accomplish the Agency's safety mission, the petition is denied.This action does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency will take further action if warranted by future circumstances. More details concerning our review can be found in the Federal Register Notice for this action.The following 161 VOQs are included in the petition evaluation: 10209242, 10229468, 10240708, 10260923, 10275939, 10276532, 10296487, 10298175, 10328669, 10330144, 10346517, 10349789, 10354758, 10363689, 10372112, 10372368, 10372514, 10378031, 10379764, 10382938, 10387448, 10394063, 10398877, 10413918, 10418652, 10420924, 10427063, 10437525, 10445392, 10446902, 10470028, 10471249, 10473733, 10502231, 10503114, 10504260, 10509862, 10511988, 10512120, 10512385, 10512650, 10513147, 10538154, 10549841, 10551763, 10555188, 10555418, 10556754, 10565367, 10574012, 10574398, 10586555, 10587212, 10587559, 10593433, 10607841, 10607913, 10608922, 10615810, 10622468, 10628141, 10632112, 10632128, 10632172, 10632175, 10632231, 10632262, 10632266, 10632270, 10632305, 10632316, 10632326, 10632370, 10632385, 10632399, 10632492, 10632542, 10632765, 10632833, 10632928, 10633197, 10633281, 10633409, 10633421, 10633483, 10633507, 10637752, 10637804, 10637950, 10637975, 10638032, 10638289, 10638290, 10638401, 10638968, 10639218, 10639623, 10641157, 10641603, 10641614, 10641836, 10644339, 10644705, 10649713, 10649895, 10649932, 10650313, 10652590, 10653147, 10653783, 10654533, 10655226, 10658900, 10659679, 10660320, 10662588, 10662645, 10662662, 10663473, 10667056, 10667437, 10668081, 10668094, 10668131, 10668612, 10668969, 10668970, 10669584, 10669678, 10669729, 10669775, 10669866, 10669895, 10669992, 10670422, 10670506, 10676348, 10676732, 10677120, 10679795, 10679934, 10680057, 10680290, 10680342, 10680714, 10681512, 10682584, 10682906, 10683022, 10683114, 10683549, 10683620, 10683697, 10683743, 10689898, 10690761, 10691284, 10691556, 10691751, 10693061, 10694300