IllustrationI WAS DRIVING ON THE ROAD I WAS GOING TO APPLY BRIGHT LIGHTS WHEN I DID SO THEY DID NOT COME ON MY WINDSHIELD WIPERS CAME ON TRY TO TURN THEM OFF THEY WOULD NOT DO SO HAD NO TURNING SIGNALS LEFT OR RIGHT AND COULD NOT GET THE WIPERS TO STOP
2012 Chrysler Town And Country
Owner reports · Recalls · Investigations
More warning signs than most Town And Country years
Owner complaints for the 2012 Chrysler Town And Country are substantially higher than the model-year median of 216.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Town And Country years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
450–25K
7625–50K
7350–75K
5675–100K
97100–150K
25150K+
372 reports with mileage · 262 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 395 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 100 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 56 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
7 crash reports16 fire reports19 injury reports
Visibility/wiper complaints
16 reportsWHILE ATTEMPTING TO CLEAR THE VEHICLES WINDSHIELD OF FROST AND FOG THE A/C UNIT GOES OUT. THE A/C UNIT IS AN INTEGRAL PART OF CLEARING THE WINDSHIELD OF FOG AND FROST. THIS IS A WELL KNOW PROBLEM TO CHRYSLER AND THEY REFUSE TO EVEN HELP WITH THE NEEDED REPAIR.
THE OBJECT SENSOR MODULES ARE LOCATED IN A "WET ZONE" YET THE PART IS NOT WATER PROOF. THE MOISTURE BLEW OUT THE CIRCUIT BOARD OF THE MODULE AND ACTUALLY DEFORMED THE HOUSING. WHEN I REMOVED THE PASSENGER SIDE SENSOR I FOUND IT WAS PACKED WITH MUD AND OTHER DEBRIS. THE SENSORS WENT SIMALTANEOUSLY AND THE TRIANGLE WARNING …
Read full complaint
THE OBJECT SENSOR MODULES ARE LOCATED IN A "WET ZONE" YET THE PART IS NOT WATER PROOF. THE MOISTURE BLEW OUT THE CIRCUIT BOARD OF THE MODULE AND ACTUALLY DEFORMED THE HOUSING. WHEN I REMOVED THE PASSENGER SIDE SENSOR I FOUND IT WAS PACKED WITH MUD AND OTHER DEBRIS. THE SENSORS WENT SIMALTANEOUSLY AND THE TRIANGLE WARNING LIGHT STAY "LIT UP" AS YOU DRIVE. I LOOKED INTO HAVING THE ISSUE FIXED AND FOUND THAT THE MODULE IS OVER $800 - THAT IS OVER $1600 TO FIX A "SAFETY NUISANCE" A POOR DESIGN CAUSED THE ISSUE. THE WARNING SIGNAL IS A DISTRACTION AND A CONSTATNT REMINDER THAT I DO NOT HAVE THE MONEY TO FIX THE ISSUE. IF YOU CAN NOT RECALL FOR THE POOR DESIGN OF A MARKETED "SAFETY SYSTEM" THEN THEY SHOULD AT LEAST MAKE THE PART MORE FEASIBLE OR PROVIDE DIRECTIONS ON HOW TO PULL THE FUSE THAT TURNS ON WARNING LIGHT.
RELATED TO RECALL # P25. PREVIOUSLY THE REAR WINDOW SWITCH WAS REPLACED AS PART OF P25. EXPERIENCING VERY SIMILAR ISSUE WITH DRIVER SIDE WINDOW CONTROL SWITCH AFTER A RAINY DAY WHERE A SMALL AMOUNT OF RAIN CAME INSIDE FROM GOING THROUGH DRIVETHROUGHS ETC. AFTER THAT AND SINCE, WINDOWS OPEN AND CLOSE RANDOMLY DURING DRIVING CA…
Read full complaint
RELATED TO RECALL # P25. PREVIOUSLY THE REAR WINDOW SWITCH WAS REPLACED AS PART OF P25. EXPERIENCING VERY SIMILAR ISSUE WITH DRIVER SIDE WINDOW CONTROL SWITCH AFTER A RAINY DAY WHERE A SMALL AMOUNT OF RAIN CAME INSIDE FROM GOING THROUGH DRIVETHROUGHS ETC. AFTER THAT AND SINCE, WINDOWS OPEN AND CLOSE RANDOMLY DURING DRIVING CAUSING A DISTRACTION AND ALLOWING SNOW/RAIN INSIDE. OFTEN THE WINDOWS JUST GET STUCK. AFFECTS 2 FRONT, 2 PASSENGER WINDOWS AND 2 SIDE MIRRORS. FROM INSPECTION IT APPEARS THAT CIRCUIT IS SHORTING AROUND CORROSION AND HAD SIGNIFICANT DISCOLORING OF BOARD, POSSIBLY GROUND LAYER. UPON REMOVING BOARD THAT IS IN CONTROL SWITCH HOUSING FOUND MOISTURE GETS TRAPPED ON BOARD BETWEEN RUBBER COVER AND CAUSES CORROSION AND FAILURE. COULD EVENTUALLY CAUSE MOTOR BURNOUT AND FIRE I SUPPOSE JUST LIKE REAR ONE. CAUSED WINDOW TO ROLL DOWN AND GET STUCK DURING SNOW STORM RECENTLY. NOW CAN'T GET THEM DOWN AT ALL. CONTACTED CHRYSLER AND TOLD ME TO BRING IN TO DEALER. DID SO AND THEY REFUSED TO COVER UNDER EXISTING WARRANTY. THEN DEALER CALLED CHRYSLER AND ESCALATED IT TO MORE SENIOR CUSTOMER SUPPORT. TOLD ME IF I HAD "GIVEN PATRONAGE TO THE CHRYSLER DEALERSHIP MORE OFTEN THEN THEY PROBABLY WOULD JUST COVER IT" BUT THAT SINCE I "WAS NOT A REGULAR CUSTOMER" THEY WOULD NOT HELP ME. *TR
TL* THE CONTACT OWNS A 2012 CHRYSLER TOWN AND COUNTRY. WHILE REVERSING OUT OF THE GARAGE, THE DRIVER AND PASSENGER SIDE BLIND SPOT MIRRORS FAILED TO FUNCTION. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE BLIND SPOT SENSOR AND THE HARNESS SWITCH THAT CONTROLLED THE CORNER VENT WINDOWS NEEDED TO BE REPLACED.…
Read full complaint
TL* THE CONTACT OWNS A 2012 CHRYSLER TOWN AND COUNTRY. WHILE REVERSING OUT OF THE GARAGE, THE DRIVER AND PASSENGER SIDE BLIND SPOT MIRRORS FAILED TO FUNCTION. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE BLIND SPOT SENSOR AND THE HARNESS SWITCH THAT CONTROLLED THE CORNER VENT WINDOWS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 70,000.
VEHICLE DASH POWER CYCLED, ALL ALARMS CAME ON, GAUGES STOPPED WORKING, A/C QUIT, WINDOWS WILL NOT WORK, WINDSHIELD WIPERS WILL NOT TURN OFF, TURN SIGNALS QUIT, CRUISE QUIT, POWER DOORS WILL NOT OPEN, RADIO/ENTERTAINMENT SYSTEM FAILED. "NO BUS" DISPLAYED ON EVIC (DASH). THIS HAS HAPPENED AT STARTUP AND WHILE DRIVING STREETS OR HI…
Read full complaint
VEHICLE DASH POWER CYCLED, ALL ALARMS CAME ON, GAUGES STOPPED WORKING, A/C QUIT, WINDOWS WILL NOT WORK, WINDSHIELD WIPERS WILL NOT TURN OFF, TURN SIGNALS QUIT, CRUISE QUIT, POWER DOORS WILL NOT OPEN, RADIO/ENTERTAINMENT SYSTEM FAILED. "NO BUS" DISPLAYED ON EVIC (DASH). THIS HAS HAPPENED AT STARTUP AND WHILE DRIVING STREETS OR HIGHWAY SPEEDS. PULLING BATTERY CABLES OFF TO RESET DOES NOT WORK. PROBLEM JUST SEEMS TO CLEAR UP ON ITS OWN.
MYSELF, THE DRIVER AND MY WIFE WERE (RIDING IN THE PASSENGER SEAT), WITH MY SON 2 YEAR OLD SITTING IN HIS CAR SEAT IN THE MIDDLE ROW. THE CURRENT OUTSIDE TEMPERATURE OUTSIDE WAS 70 DEGREES F . WE HAD JUST DROVE THROUGH A SMALL RESIDENTIAL AREA GOING APPROX. 30 MPH. WE CAME TO A STOP LIGHT , WHILE WAITING FOR THE LIGHT TO CHANGE …
Read full complaint
MYSELF, THE DRIVER AND MY WIFE WERE (RIDING IN THE PASSENGER SEAT), WITH MY SON 2 YEAR OLD SITTING IN HIS CAR SEAT IN THE MIDDLE ROW. THE CURRENT OUTSIDE TEMPERATURE OUTSIDE WAS 70 DEGREES F . WE HAD JUST DROVE THROUGH A SMALL RESIDENTIAL AREA GOING APPROX. 30 MPH. WE CAME TO A STOP LIGHT , WHILE WAITING FOR THE LIGHT TO CHANGE THERE WAS A LOUD POP , ALMOST SOUNDED LIKE A FIRE CRACKER GOING OFF. WE INSTANTLY TURNED AROUND TO FIND THE REAR GATE WINDOW SHATTER. AT FIRST I THOUGHT THE VEHICLE SITTING BEHIND ME AT THE LIGHT HAD HIT MY VEHICLE, BUT WHEN I LOOKED HE WAS PARKED NEARLY 8 FEET AWAY. I TALK TO THE GUY AND HIS WIFE SITTING BEHIND ME AND HE SAID , THAT IT WAS WEIRD IT LOOK AS IF THE WINDOW BLEW OUT FROM THE INSIDE. THE WINDOW JUST EXPLODE. HERE WERE THE CURRENT VARIABLES TAKING PLACE IN THE CAR WHILE AT STOP. 1. THE REAR DEFROST WAS NOT ON 2.THE REAR SIDE VENT WINDOWS WERE BOTH FULLY OPEN 3. OUTSIDE TEMPERATURE WAS A COMFORTABLE 70 DEGREES F. NOW AS FOR THE AFTER MATH THERE'S NOT REALLY MUCH TO TELL OTHER THAN THE WINDOW SHATTERED(COMPLETELY GONE) AND GLASS ALL OVER THE PLACE INCLUDING RIGHT NEXT TO MY SONS CAR SEAT. THE FOCAL POINT OF THE BREAK SEEMED TO BE LOCATED AT NEAR DEAD CENTER. I'VE JUST CONTACTED CHRYSLER ABOUT THIS AND I AM GOING TOMORROW TO SEE WHAT THEY SAY. WHEN I GOOGLED THIS PROBLEM I FOUND A HANDFUL OF TOWN AND COUNTRY FROM 01 TO 13 WITH THIS PROBLEM. BUT THEY TELL ME ON THE PHONE THIS IS NOT A COMMON THING AND WILL NEED FCA DEALER TO LOOK AT IT , WHICH IS FINE MY ONLY CONCERN IS THEY FIX THE ISSUE, BECAUSE I CAN REPLACE A WINDOW BUT THIS DOES NOT SOLVE THE UNDERLING PROBLEM. HAD THERE BEEN PEOPLE IN THE 3RD ROW SEATING WHAT WOULD HAVE HAPPEN TO THEM? THIS VEHICLE (MINIVAN) WAS PURCHASED TO BE USED AS OUR FAMILY VEHICLE AND NOW SADLY I AM WORRIED TO DRIVE WITH MY TWO YEAR OLD SON IN IT. HOPEFULLY A RESOLUTION CAN BE MADE
TL* THE CONTACT OWNS A 2012 CHRYSLER TOWN AND COUNTRY. WHILE DRIVING AT ANY SPEED, THE BLIND SPOT SENSOR FAILED TO FUNCTION PROPERLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE TWO REAR SENSORS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPR…
Read full complaint
TL* THE CONTACT OWNS A 2012 CHRYSLER TOWN AND COUNTRY. WHILE DRIVING AT ANY SPEED, THE BLIND SPOT SENSOR FAILED TO FUNCTION PROPERLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE TWO REAR SENSORS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 45,000.
ALL SAFETY FEATURES SUDDENLY STOPPED WORKING. THE BLIND SPOT MONITORING, REAR CROSS PATH DETECTION, PARK ASSIST, REAR VIEW CAMERA, AND COMPASS ALL STOPPED. I WAS TOLD THIS IS FROM DRIVING THE CAR IN THE WINTER! APPARENTLY, THERE ARE TWO MODULES LOCATED BEHIND THE BUMPER THAT HAVE CORRODED SEVERELY. THE SNOW AND SALT IS THROWN…
Read full complaint
ALL SAFETY FEATURES SUDDENLY STOPPED WORKING. THE BLIND SPOT MONITORING, REAR CROSS PATH DETECTION, PARK ASSIST, REAR VIEW CAMERA, AND COMPASS ALL STOPPED. I WAS TOLD THIS IS FROM DRIVING THE CAR IN THE WINTER! APPARENTLY, THERE ARE TWO MODULES LOCATED BEHIND THE BUMPER THAT HAVE CORRODED SEVERELY. THE SNOW AND SALT IS THROWN OFF THE TIRES DIRECTLY ON THESE INTEGRATED UNITS THAT ARE NOT SEALED SUFFICIENTLY AND SO THE UNITS CORRODE AND FAIL. THIS IS ABSOLUTELY A DESIGN FAILURE. THESE CRITICAL UNITS THAT RUN ALL SAFETY EQUIPMENT SHOULD NOT BE PLACED SO CARELESSLY AND NOT PROPERLY PROTECTED. PLEASE SEE CHRYSLER RECALLS AND FIXES THIS DESIGN FAILURE. THANK YOU.
ENGINE DIES RIGHT AFTER STARTING, SOME TIMES 2 OR 3 CONSECUTIVE TIMES. SOME TIMES WHEN ENGINE STARTS, SOUNDS LIKE IT IS RUNNING ON 3 CYLINDERS. ALSO AT TIMES THE WIPERS COME BY THEM SELVES, EVEN WHEN IT'S NOT RAINING! *TR
Official recalls
525V876000 · Equipment Adaptive/mobility:wheelchair Restraints/securement:latch/anchor:
Dec 17, 2025
Rollx Vans (Rollx) is recalling certain GMC Yukon, Sierra, Chevrolet Express 2500, Ford Transit, E-250, Toyota Sienna, Sienna Hybrid, Honda Odyssey, Chrysler Town and Country, Voyager, Pacifica, Dodge Grand Caravan, and Ram Promaster vehicles equipped with QRT-Deluxe and QRT-Max wheelchair restraints. Please refer to Rollx's recall report for specific model year information. The retractors may not lock, preventing the wheelchair from being properly secured.
Consequence & remedy
Consequence: An unsecured wheelchair can move during transit, increasing the risk of injury.
Remedy: Rollx will work with Q'Straint to inspect and replace the retractors as necessary, free of charge. Owner notification letters were mailed February 5, 2026. Owners may contact Rollx's customer service at 1-800-956-6668.
14V234000 · Electrical System
May 7, 2014
Chrysler Group, LLC (Chrysler) is recalling certain model year 2010-2014 Chrysler Town and Country and Dodge Grand Caravan vehicles manufactured August 25, 2010, through October 31, 2013. The affected vehicles may experience overheating of the vent window switch in the driver's door armrest.
Consequence & remedy
Consequence: An overheated switch may result in a vehicle fire.
Remedy: Chrysler will notify owners, and dealers will replace the vent window switch with a newer version, free of charge. The owner notification letter was issued and the remedy campaign launched on on December 31, 2014. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P25.
12V191000 · Equipment
May 2, 2012
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2012 TOWN AND COUNTRY AND DODGE GRAND CARAVAN VEHICLES, MANUFACTURED FROM MARCH 9, 2012 THROUGH MARCH 12, 2012. SOME VEHICLES MAY BE EQUIPPED WITH A RIGHT SIDE LIFTGATE PINCH SENSOR THAT DOES NOT FUNCTION PROPERLY. AS A RESULT, INCREASED FORCE MAY BE REQUIRED IN ORDER TO STOP THE POWER LIFTGATE DURING FINAL CLOSING STAGES.
Consequence & remedy
Consequence: THE POWER LIFTGATE DOOR MAY CLOSE ON AN APPENDAGE, INCREASING THE RISK OF INJURY.
Remedy: CHRYSLER WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT AND REPLACE THE RIGHT SIDE LIFTGATE PINCH SENSORS, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 18, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
12V141000 · Suspension:rear
Apr 3, 2012
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2012 TOWN AND COUNTRY AND DODGE GRAND CARAVAN VEHICLES MANUFACTURED FROM NOVEMBER 15, 2011, THROUGH NOVEMBER 21, 2011. SOME VEHICLES MAY BE EQUIPPED WITH RIGHT REAR HUB AND BEARING ASSEMBLIES THAT WERE NOT FULLY MACHINED.
Consequence & remedy
Consequence: THIS COULD RESULT IN A DECREASE IN DURABILITY, WHICH MAY LEAD TO WHEEL SEPARATION, INCREASING THE RISK OF A CRASH.
Remedy: CHRYSLER WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE RIGHT REAR HUB AND BEARING ASSEMBLY, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 27, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
11V487000 · Engine And Engine Cooling
Sep 29, 2011
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2012 CHRYSLER VEHICLES, INCLUDING 200 AND TOWN AND COUNTRY MODELS, DODGE VEHICLES, INCLUDING CHARGER, DURANGO, GRAND CARAVAN AND JOURNEY MODELS AND JEEP GRAND CHEROKEE VEHICLES MANUFACTURED FROM AUGUST 31, 2011, THROUGH SEPTEMBER 13, 2011, THAT ARE EQUIPPED WITH 3.6L ENGINES. THESE ENGINES MAY EXPERIENCE CONNECTING ROD BEARING FAILURE DUE TO DEBRIS INSIDE THE ENGINE BLOCK.
Consequence & remedy
Consequence: CONNECTING ROD FAILURE MAY LEAD TO ENGINE SEIZURE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: CHRYSLER WILL NOTIFY OWNERS AND REPLACE THE ENGINE FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT NOVEMBER 18, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE19014 · Active Head Rest Inadvertent Deployment
Opened Sep 9, 2019 · Closed Feb 25, 2026
Status: closed (inferred from source dates) · Seats; Seats:front Assembly:head Restraint
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Seats
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Seats:front Assembly:head Restraint
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
DP14004 · Totally Integrated Power Module Failure
Opened Sep 25, 2014 · Closed Jul 24, 2015
Status: closed (inferred from source dates) · Electrical System
In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV?s, trucks, and vans beginning in the 2007 model year. The petitioner alleges that TIPM defects may result in engine stall, airbag non-deployment, failure of fuel pump shutoff resulting in unintended acceleration, fire, and other symptoms. On September 25, 2014, the Office of Defects Investigation (ODI) opened DP14-004 to evaluate the petition for a grant or deny decision. ODI analyzed complaint data provided by CAS as well as complaints submitted to ODI from consumers. In total, there were 296 complaints submitted by the petitioner in the original petition and five supplements, including 271 complaints related to the subject vehicles equipped with TIPM-7. Approximately 3 percent of CAS complaints are related to vehicles equipped with TIPM-6 and ODI?s review of these complaints did not identify any safety defect trends. ODI conducted a detailed review of complaints narratives submitted by CAS and consumers including careful analysis of vehicle repair histories, warranty claims obtained from the manufacturer and any available Customer Assistance Inquiry reports (CAIR). Analysis of the field data indicated that MY2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles exhibited significantly higher complaint rates related to fuel pump relay (FPR) failures than other subject vehicles. In a September 3, 2014 letter to NHTSA, Chrysler submitted a Defect Information Report (DIR) identifying a defect in the FPR within the TIPM-7 which can result in a no start or stall condition in approximately 188,723 model year (MY) 2011 Jeep Grand Cherokee (WK) and Dodge Durango (WD) vehicles manufactured from January 5, 2010 through July 20, 2011 (14V-530).In a February 24, 2015 letter, Chrysler submitted a second DIR expanding the scope of the FPR defect condition to include an additional 338,216 MY 2012 through 2013 Jeep Grand Cherokee vehicles manufactured from September 17, 2010 through August 19, 2013 and MY 2012 through 2013 Dodge Durango vehicles manufactured from January 18, 2011 through August 19, 2013 (15V-115).ODI analysis of the CAS allegations of TIPM defects resulting in stall while driving, airbag non-deployment, unintended acceleration, fire and other faults identified a single defect condition related to 1 of over 60 different circuits in the TIPM assembly. The most common effect of this defect condition, related to the fuel pump relay, was a no-start concern, but it could also result in stall while driving (76 complaints). No valid evidence was presented in support of claims related to airbag non-deployment, unintended acceleration or fire resulting from TIPM faults and these claims were found to be wholly without merit based on review of the field data and design of the relevant systems and components.Except insofar as the petitioner's contentions relate to the defect condition addressed by the Chrysler recalls, the factual bases of the petitioner's contentions that any further investigation is necessary are unsupported. In our view, additional investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists or a NHTSA order for the notification and remedy of a safety-related defect as alleged by the petitioner at the conclusion of the requested investigation. Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is den