IllustrationI HAVE AN ADDITIONAL COMPLAINT: 11286310. TRACTION CONTROL AND ABS SYSTEM DEACTIVATED WHILE DRIVING AROUND TOWN. ENGINE CUT OFF WHILE DRIVING, SPEEDOMETER DASH CLUSTER STOPS WORKING WHILE DRIVING, WITH CHILDREN IN VEHICLE (MINIVAN). U110A DTC. NETWORK, MFG, FUEL AND AIR METERING FAULT. DRIVING SAFETY ISSUE. *TR
2012 Chrysler Town And Country
Owner reports · Recalls · Investigations
More warning signs than most Town And Country years
Owner complaints for the 2012 Chrysler Town And Country are substantially higher than the model-year median of 216.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Town And Country years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
450–25K
7625–50K
7350–75K
5675–100K
97100–150K
25150K+
372 reports with mileage · 262 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 395 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 100 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 56 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
7 crash reports16 fire reports19 injury reports
Electronic Stability Control (esc) complaints
9 reports1) -STEREO AND NAVIGATION SYSTEM ON END OFF 2) - WARNING LIGHT'S TURN ON ON THE BOARD AND RUN OUT OF POWER 0 POWER 3) - INJECCION PROBLEM
1) THE THIRD ROW PIER FOLDING SEATS HAVE TWICE BEEN INADVERTENTLY ACTIVATED BY A CHILD TOUCHING THE BUTTON, AND NARROWLY ESCAPING BEING CRUSHED BY THE FOLDING SEAT. ALSO, THE SEAT JAMMED IN THE HALF FOLDED POSITION AND THE DEALERSHIP WANTED $2600+ TO FIX IT. THE POWER FOLDING SEATS ARE A DEATH TRAP IF SOMEONE CANNOT GET OUT OF…
Read full complaint
1) THE THIRD ROW PIER FOLDING SEATS HAVE TWICE BEEN INADVERTENTLY ACTIVATED BY A CHILD TOUCHING THE BUTTON, AND NARROWLY ESCAPING BEING CRUSHED BY THE FOLDING SEAT. ALSO, THE SEAT JAMMED IN THE HALF FOLDED POSITION AND THE DEALERSHIP WANTED $2600+ TO FIX IT. THE POWER FOLDING SEATS ARE A DEATH TRAP IF SOMEONE CANNOT GET OUT OF THE WAY WHEN THE BUTTON HAS BEEN ACTIVATED. 2) TWICE NOW, THE ELECTRICAL SYSTEM HAS BEEN FLASHING RANDOM CODES- THE TIRE PRESSURE GAUGE WHEN THE TIRE PRESSURE IS FINE, THE ABS AND TRACTION LIGHT, AND ALSO WEIRD MINI ROUGH IDLES AT VERY LOW SPEEDS IN HEAVY TRAFFIC. IT IS A REPEAT PROBLEM THAT THE SHOP SEEMS TO ONLY TEMPORARILY FIX.
THE SCREW ON MY LEFT SIDED POWER LIFT GATE COMPLETELY BROKE. THE CAR WAS AT A STANDSTILL.
WHILE DRIVING AT VARIOUS SPEEDS THE VAN WILL SHUT OFF WE WILL LOSE POWER STEERING AND BRAKES YOU LOSE ALL POWER AS IF THE KEY IS OFF,I WILL JIGGLE THE KEY AND IT WILL START BACK UP OR IT WILL POWER UP, YOU SHIFT INTO NUETRAL AND TURN THE KEY AND START BACK UP IT IS INTERMITTENT AND IT COULD HAPPEN WHILE DRIVING SLOW OR DRIVING 7…
Read full complaint
WHILE DRIVING AT VARIOUS SPEEDS THE VAN WILL SHUT OFF WE WILL LOSE POWER STEERING AND BRAKES YOU LOSE ALL POWER AS IF THE KEY IS OFF,I WILL JIGGLE THE KEY AND IT WILL START BACK UP OR IT WILL POWER UP, YOU SHIFT INTO NUETRAL AND TURN THE KEY AND START BACK UP IT IS INTERMITTENT AND IT COULD HAPPEN WHILE DRIVING SLOW OR DRIVING 70MPH DOWN THE HIGHWAY.
THE BLIND SPOT DETECTION SYSTEM HAS FAILED. SENSORS IN THE REAR BUMPER HAVE FAILED CAUSING THE SYSTEM TO BE INOPERABLE. I HAVE SEEN SEVERAL SIMILAR COMPLAINTS WITH THE NHTSA FOR THIS VEHICLE FILED UNDER ELECTRICAL, UNKNOWN AND OTHER. THIS SAFETY FEATURE FAILED AT JUST OVER 50K MILES ON THIS VEHICLE. THIS FAILURE OCCURRED WHI…
Read full complaint
THE BLIND SPOT DETECTION SYSTEM HAS FAILED. SENSORS IN THE REAR BUMPER HAVE FAILED CAUSING THE SYSTEM TO BE INOPERABLE. I HAVE SEEN SEVERAL SIMILAR COMPLAINTS WITH THE NHTSA FOR THIS VEHICLE FILED UNDER ELECTRICAL, UNKNOWN AND OTHER. THIS SAFETY FEATURE FAILED AT JUST OVER 50K MILES ON THIS VEHICLE. THIS FAILURE OCCURRED WHILE THE VEHICLE WAS IN OPERATION IN LIGHT TRAFFIC ON A CITY STREET. THE SERVICE BLIND SPOT SYSTEM MESSAGE DISPLAYED ON THE DASH WHERE THE SPEED OF THE VEHICLE IS NORMALLY DISPLAYED AND YELLOW WARNING LIGHTS APPEARED IN EACH REAR VIEW MIRROR. PRICED THE PARTS AT APPROX. $900.00 PER SENSOR UNINSTALLED. THE SYSTEM HAS BEEN SHUT OFF AT THIS TIME. THIS IS A NECESSARY SAFETY FEATURE FOR THIS LARGE FAMILY VEHICLE WITH NUMEROUS BLIND SPOTS. NUMEROUS COMPLAINTS RELATED TO THESE FAILING SENSORS (WITH THE NHTSA AND OTHER CONSUMER SITES) INDICATE THE PART IS INFERIOR AND/OR HAS BEEN INSTALLED BY THE MANUFACTURER IN AN AREA (EXPOSED UNDERSIDE OF REAR BUMPER FASCIA) WHERE IT IS MOST SUSCEPTIBLE TO WATER AND OTHER CORROSIVE ELEMENTS.
ALTERNATOR WENT OUT AT 86K. KNOWN ISSUE WITH EXACT SAME PART # ON OTHER CHRYSLER PRODUCTS HAVE BEEN RECALLED. VAN IS IN THE SHOP NOW GETTING A $480 REPLACEMENT INSTALLED PLUS 1.2 HOURS OF LABOR FOR A PART THAT IF ON ANOTHER VEHICLE WOULD BE COVERED UNDER AN EXISTING RECALL.
WARNING LIGHTS ON BOTH MIRRORS FOR BLIND SPOT DETECTION STAY ON ALWAYS - WITH THE DING DING DING SOUNDS RINGING ON AND OFF - WEATHER DRIVING DOWN THE ROAD OR SITTING STILL PARKED, IF THE CAR IS RUNNING, THE PROBLEM IS THERE. I BELIEVE THIS UNSAFE ISSUE SHOULD BE FIXED BY A RECALL, AS IT IS A PROBLEM THAT IS VERY UNSAFE & …
Read full complaint
WARNING LIGHTS ON BOTH MIRRORS FOR BLIND SPOT DETECTION STAY ON ALWAYS - WITH THE DING DING DING SOUNDS RINGING ON AND OFF - WEATHER DRIVING DOWN THE ROAD OR SITTING STILL PARKED, IF THE CAR IS RUNNING, THE PROBLEM IS THERE. I BELIEVE THIS UNSAFE ISSUE SHOULD BE FIXED BY A RECALL, AS IT IS A PROBLEM THAT IS VERY UNSAFE & DANGEROUS, MANY FOLKS WHOM HAVE PURCHASED THIS VEHICLE ARE EXPERIENCING THE SAME UNSAFE PROBLEM! I PAID FOR THIS FEATURE ON THE VEHICLE, TO ADD SAFETY AND NOW IT IS CAUSING JUST THE OPPOSITE, UNSAFE DRIVING CONDITIONS. THIS REALLY CONCERNS ME, A SAFETY FEATURE FAILING ON ALL THESE CARS AND ESPECIALLY AT SUCH LOW MILEAGE. WITH THIS FEATURE MALFUNCTIONING, IT IS MUCH MORE DANGEROUS THAN TEXTING OR TALKING ON THE PHONE WHILE DRIVING. WHAT IS THE CRITERIA TO GET A RECALL IN PLACE, DO PEOPLE HAVE TO HAVE ACCIDENTS OR DIE TO GET A PROBLEM RECALLED, HOW IS IT DECIDED.
I WAS DRIVING OUR TOWN AND COUNTRY VAN ON THE INTERSTATE AND WAS GOING TO CHANGE LANES TO MY LEFT. THE BLIND SPOT DETECTION DID NOT COME ON TO WARN ME THAT A CAR WAS THERE. ALMOST HIT THE OTHER CAR. THIS HAS HAPPENED MANY TIMES SINCE. ON 9-27-1014 DRIVING OUT OF THE DRIVEWAY AT OUR HOUSE THE BLIND SPOT DETECTION DID NOT PICK UP …
Read full complaint
I WAS DRIVING OUR TOWN AND COUNTRY VAN ON THE INTERSTATE AND WAS GOING TO CHANGE LANES TO MY LEFT. THE BLIND SPOT DETECTION DID NOT COME ON TO WARN ME THAT A CAR WAS THERE. ALMOST HIT THE OTHER CAR. THIS HAS HAPPENED MANY TIMES SINCE. ON 9-27-1014 DRIVING OUT OF THE DRIVEWAY AT OUR HOUSE THE BLIND SPOT DETECTION DID NOT PICK UP THE GARBAGE CAN ON THE SIDE OF THE DRIVE AND HIT THE CAN CAUSING $ 361.53 OF DAMAGE. TOLD CHRYSLER BUT THEY SAID NO RECALLS FOR THIS. NOW THE BLIND SPOT SYSTEM IS NOT WORKING AT ALL AND THE DASH IS DINGING ALL THE TIME. I SEE THERE WAS A RECALL FOR A 2009 TOWN AND COUNTRY VAN FOR THIS PROBLEM NO. J01. MANY PEOPLE ARE COMPLAINING ON THE INTERNET ABOUT THIS FIX COSTING $ 2,000 AT THE DEALER. SEEMS THERE SHOULD BE A RECALL FOR THIS 2012 VAN AS SAFETY HAS BEEN LOST AND CRASHES ARE EXPECTED TO HAPPEN. *TR
Official recalls
525V876000 · Equipment Adaptive/mobility:wheelchair Restraints/securement:latch/anchor:
Dec 17, 2025
Rollx Vans (Rollx) is recalling certain GMC Yukon, Sierra, Chevrolet Express 2500, Ford Transit, E-250, Toyota Sienna, Sienna Hybrid, Honda Odyssey, Chrysler Town and Country, Voyager, Pacifica, Dodge Grand Caravan, and Ram Promaster vehicles equipped with QRT-Deluxe and QRT-Max wheelchair restraints. Please refer to Rollx's recall report for specific model year information. The retractors may not lock, preventing the wheelchair from being properly secured.
Consequence & remedy
Consequence: An unsecured wheelchair can move during transit, increasing the risk of injury.
Remedy: Rollx will work with Q'Straint to inspect and replace the retractors as necessary, free of charge. Owner notification letters were mailed February 5, 2026. Owners may contact Rollx's customer service at 1-800-956-6668.
14V234000 · Electrical System
May 7, 2014
Chrysler Group, LLC (Chrysler) is recalling certain model year 2010-2014 Chrysler Town and Country and Dodge Grand Caravan vehicles manufactured August 25, 2010, through October 31, 2013. The affected vehicles may experience overheating of the vent window switch in the driver's door armrest.
Consequence & remedy
Consequence: An overheated switch may result in a vehicle fire.
Remedy: Chrysler will notify owners, and dealers will replace the vent window switch with a newer version, free of charge. The owner notification letter was issued and the remedy campaign launched on on December 31, 2014. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P25.
12V191000 · Equipment
May 2, 2012
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2012 TOWN AND COUNTRY AND DODGE GRAND CARAVAN VEHICLES, MANUFACTURED FROM MARCH 9, 2012 THROUGH MARCH 12, 2012. SOME VEHICLES MAY BE EQUIPPED WITH A RIGHT SIDE LIFTGATE PINCH SENSOR THAT DOES NOT FUNCTION PROPERLY. AS A RESULT, INCREASED FORCE MAY BE REQUIRED IN ORDER TO STOP THE POWER LIFTGATE DURING FINAL CLOSING STAGES.
Consequence & remedy
Consequence: THE POWER LIFTGATE DOOR MAY CLOSE ON AN APPENDAGE, INCREASING THE RISK OF INJURY.
Remedy: CHRYSLER WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT AND REPLACE THE RIGHT SIDE LIFTGATE PINCH SENSORS, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 18, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
12V141000 · Suspension:rear
Apr 3, 2012
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2012 TOWN AND COUNTRY AND DODGE GRAND CARAVAN VEHICLES MANUFACTURED FROM NOVEMBER 15, 2011, THROUGH NOVEMBER 21, 2011. SOME VEHICLES MAY BE EQUIPPED WITH RIGHT REAR HUB AND BEARING ASSEMBLIES THAT WERE NOT FULLY MACHINED.
Consequence & remedy
Consequence: THIS COULD RESULT IN A DECREASE IN DURABILITY, WHICH MAY LEAD TO WHEEL SEPARATION, INCREASING THE RISK OF A CRASH.
Remedy: CHRYSLER WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE RIGHT REAR HUB AND BEARING ASSEMBLY, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 27, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
11V487000 · Engine And Engine Cooling
Sep 29, 2011
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2012 CHRYSLER VEHICLES, INCLUDING 200 AND TOWN AND COUNTRY MODELS, DODGE VEHICLES, INCLUDING CHARGER, DURANGO, GRAND CARAVAN AND JOURNEY MODELS AND JEEP GRAND CHEROKEE VEHICLES MANUFACTURED FROM AUGUST 31, 2011, THROUGH SEPTEMBER 13, 2011, THAT ARE EQUIPPED WITH 3.6L ENGINES. THESE ENGINES MAY EXPERIENCE CONNECTING ROD BEARING FAILURE DUE TO DEBRIS INSIDE THE ENGINE BLOCK.
Consequence & remedy
Consequence: CONNECTING ROD FAILURE MAY LEAD TO ENGINE SEIZURE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: CHRYSLER WILL NOTIFY OWNERS AND REPLACE THE ENGINE FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT NOVEMBER 18, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE19014 · Active Head Rest Inadvertent Deployment
Opened Sep 9, 2019 · Closed Feb 25, 2026
Status: closed (inferred from source dates) · Seats; Seats:front Assembly:head Restraint
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Seats
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Seats:front Assembly:head Restraint
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
DP14004 · Totally Integrated Power Module Failure
Opened Sep 25, 2014 · Closed Jul 24, 2015
Status: closed (inferred from source dates) · Electrical System
In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV?s, trucks, and vans beginning in the 2007 model year. The petitioner alleges that TIPM defects may result in engine stall, airbag non-deployment, failure of fuel pump shutoff resulting in unintended acceleration, fire, and other symptoms. On September 25, 2014, the Office of Defects Investigation (ODI) opened DP14-004 to evaluate the petition for a grant or deny decision. ODI analyzed complaint data provided by CAS as well as complaints submitted to ODI from consumers. In total, there were 296 complaints submitted by the petitioner in the original petition and five supplements, including 271 complaints related to the subject vehicles equipped with TIPM-7. Approximately 3 percent of CAS complaints are related to vehicles equipped with TIPM-6 and ODI?s review of these complaints did not identify any safety defect trends. ODI conducted a detailed review of complaints narratives submitted by CAS and consumers including careful analysis of vehicle repair histories, warranty claims obtained from the manufacturer and any available Customer Assistance Inquiry reports (CAIR). Analysis of the field data indicated that MY2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles exhibited significantly higher complaint rates related to fuel pump relay (FPR) failures than other subject vehicles. In a September 3, 2014 letter to NHTSA, Chrysler submitted a Defect Information Report (DIR) identifying a defect in the FPR within the TIPM-7 which can result in a no start or stall condition in approximately 188,723 model year (MY) 2011 Jeep Grand Cherokee (WK) and Dodge Durango (WD) vehicles manufactured from January 5, 2010 through July 20, 2011 (14V-530).In a February 24, 2015 letter, Chrysler submitted a second DIR expanding the scope of the FPR defect condition to include an additional 338,216 MY 2012 through 2013 Jeep Grand Cherokee vehicles manufactured from September 17, 2010 through August 19, 2013 and MY 2012 through 2013 Dodge Durango vehicles manufactured from January 18, 2011 through August 19, 2013 (15V-115).ODI analysis of the CAS allegations of TIPM defects resulting in stall while driving, airbag non-deployment, unintended acceleration, fire and other faults identified a single defect condition related to 1 of over 60 different circuits in the TIPM assembly. The most common effect of this defect condition, related to the fuel pump relay, was a no-start concern, but it could also result in stall while driving (76 complaints). No valid evidence was presented in support of claims related to airbag non-deployment, unintended acceleration or fire resulting from TIPM faults and these claims were found to be wholly without merit based on review of the field data and design of the relevant systems and components.Except insofar as the petitioner's contentions relate to the defect condition addressed by the Chrysler recalls, the factual bases of the petitioner's contentions that any further investigation is necessary are unsupported. In our view, additional investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists or a NHTSA order for the notification and remedy of a safety-related defect as alleged by the petitioner at the conclusion of the requested investigation. Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is den