NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
302 reportsClear category filter96,000 miles · Feb 22, 2018
Electrical SystemEngine
TL* THE CONTACT OWNS A 2010 CHRYSLER TOWN AND COUNTRY. ON MULTIPLE OCCASIONS, WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE WOULD SUDDENLY STALL. AFTER RESTARTING THE ENGINE, THE VEHICLE WOULD OPERATE NORMALLY. THE VEHICLE WAS TAKEN TO LANDMARK CHRYSLER (6850 MOUNT ZION BLVD, MORROW, GA), BUT THE FAILURE COULD NOT BE DUPLICATED. THE…
Read full complaint
TL* THE CONTACT OWNS A 2010 CHRYSLER TOWN AND COUNTRY. ON MULTIPLE OCCASIONS, WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE WOULD SUDDENLY STALL. AFTER RESTARTING THE ENGINE, THE VEHICLE WOULD OPERATE NORMALLY. THE VEHICLE WAS TAKEN TO LANDMARK CHRYSLER (6850 MOUNT ZION BLVD, MORROW, GA), BUT THE FAILURE COULD NOT BE DUPLICATED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 96,000.
NHTSA ODI #11074333
76,000 miles · Feb 21, 2018
EngineService BrakesSteering
MY WIFE WAS BACKING OUT OF A DRIVEWAY, THE ENGINE SHUT OFF AND THE POWER BRAKES AND POWER STEERING DIDN'T WORK. THE VEHICLE DRIFTED INTO THE ROAD BECAUSE SHE WAS UNABLE TO STOP IN TIME. THERE WERE NO OTHER CARS INVOLVED IN THE INCIDENT.
NHTSA ODI #11074168
147,000 miles · Jan 23, 2018
Electrical SystemEngineSteering
VEHICLE STARTED HAVING ISSUES IN 2014. VEHICLE JUST WOULD NOT CRANK ONE MORNING. GOT A JUMP START AND TOOK IT TO AUTOZONE AND GOT A NEW BATTERY. ABOUT 3 MONTHS LATER THE SAME THING HAPPENED. GOT A JUMP START, WENT TO AUTOZONE AND THEY FOUND NOTHING WRONG WITH BATTERY, ALTERNATOR OR STARTER. AUTOZONE GAVE ME A NEW BATTERY AN…
Read full complaint
VEHICLE STARTED HAVING ISSUES IN 2014. VEHICLE JUST WOULD NOT CRANK ONE MORNING. GOT A JUMP START AND TOOK IT TO AUTOZONE AND GOT A NEW BATTERY. ABOUT 3 MONTHS LATER THE SAME THING HAPPENED. GOT A JUMP START, WENT TO AUTOZONE AND THEY FOUND NOTHING WRONG WITH BATTERY, ALTERNATOR OR STARTER. AUTOZONE GAVE ME A NEW BATTERY ANYWAY. ABOUT 4 MONTHS LATER, HAPPENED AGAIN. BROUGHT VEHICLE TO CHRYSLER FOR WIN MODULE RECALL FIX AND EXPLAINED WHAT WAS HAPPENING. THEY SAID HANDLING THE RECALL AND A NEW BATTERY SHOULD FIX THE PROBLEM. ABOUT 2 MONTHS LATER, HAD THE SAME PROBLEM. CHRYSLER REPLACE WIN MODULE AGAIN AND I GOT CHRYSLER TO REPLACE BATTERY AT THIS TIME AS I EXPLAINED THAT THE BATTERY WAS BEING AFFECTED DUE TO THE PART THAT WAS BEING RECALLED. ALL WAS FINE FOR ABOUT A YEAR OR SO AND THEN STARTED HAPPENING AGAIN. BROUGHT IT BACK TO CHRYSLER AND THEY SAID BATTERY HAD A DEAD CELL. I EXPLAINED THAT THEY HAD JUST PUT THE BATTERY IN ABOUT A YEAR AGO AND IT SHOULD BE UNDER WARRANTY. THEY TOLD ME, "WE DON'T DO WARRANTY REPLACEMENTS ON WARRANTY REPLACEMENTS". SO, I AM JUST DEALING WITH THE BATTERY RIGHT NOW. MOST RECENTLY, ABOUT 3 MONTHS AGO, DASH BOARD WARNING LIGHTS STARTED ALL COMING IN AT THE SAME TIME. THEN THEY WOULD ALL GO OFF AND ONE SIDE OF THE DASH ILLUMINATION WOULD GO OUT. NEXT START UP, ILLUMINATION WOULD BE FINE AGAIN. THIS HAPPENED SEVERAL TIMES OVER A COUPLE OF MONTHS. THEN, ONE DAY WHILE DRIVING, THE POWER STEERING WENT OUT, THE TRACTION LIGHT CAME ON AND THE VEHICLE SHUT OFF! WAS ABLE TO PUT VEHICLE IN NEUTRAL AND RESTART. THIS HAPPENED A FEW TIMES IN A MONTH, BUT WAS ALWAYS OK AFTER ONE RESTART. NOW, IT KEEPS HAPPENING AND ONLY LASTS A FEW MINUTES BEFORE NEEDING TO BE RESTARTED AGAIN. AFRAID THAT THIS IS GOING TO HAPPEN WHILE TURNING ACROSS ONCOMING TRAFFIC OR IN A SITUATION WHERE WE CAN NOT PULL OVER TO SAFETY AND WILL GET REAR-ENDED.
NHTSA ODI #11064327
70,000 miles · Jan 15, 2018
Engine
THE VAN STALLS OUT WHILE DRIVING AROUND 20 TO 30 MILES PER HOUR.
NHTSA ODI #11062874
120,000 miles · Dec 1, 2017
Electrical SystemEngineVehicle Speed Control
RANDOMLY LOSES POWER, SOMETIMES A SPLIT SECOND, OTHER TIMES A COMPLETE SHUT DOWN AND DOESN'T LET KEY GO. SOMETIMES IT CAUSES THINGS TO STOP WORKING, LIKE CRUISE CONTROL. MORE OFTEN WHEN LIGHTS ARE ON AND OTHER THINGS USED, LIKE A/C OR TURN SIGNALS. SOMETIMES WHEN ONLY LIGHTS ARE USED, AND SOMETIMES LIGHTS NOT EVEN ON.
NHTSA ODI #11051701
99,000 miles · Nov 22, 2017
Electrical SystemEnginePower Train
ENGINE SHUTS OFF WHILE IN MOTION IN DRIVE MODE. THIS HAPPENS AT ANY RATE OF SPEED, 70 MPH TO 10 MPH, IN GOOD WEATHER CONDITIONS, ON THE HIGHWAY AND LOCAL STREETS, DRIVING STRAIGHT OR TURNING SLIGHTLY. THE ABS MODULE TESTED BAD 9 MONTHS AGO AND WAS REPLACED BY AUTO ELECTRIC SPECIALISTS OF HOUSTON. THIS DID NOT SOLVE THE PROBLEM. …
Read full complaint
ENGINE SHUTS OFF WHILE IN MOTION IN DRIVE MODE. THIS HAPPENS AT ANY RATE OF SPEED, 70 MPH TO 10 MPH, IN GOOD WEATHER CONDITIONS, ON THE HIGHWAY AND LOCAL STREETS, DRIVING STRAIGHT OR TURNING SLIGHTLY. THE ABS MODULE TESTED BAD 9 MONTHS AGO AND WAS REPLACED BY AUTO ELECTRIC SPECIALISTS OF HOUSTON. THIS DID NOT SOLVE THE PROBLEM. I HAVE NOT HAD THE ECM REPLACED. MY CHRYSLER DEALERSHIP CANNOT FIND THE PROBLEM AND HAS TOLD ME TO KEEP DRIVING AND TO BRING THE CAR IN RIGHT AWAY IF THE ISSUE HAPPENS AGAIN. THE CAR SCARES ME!!! IT HAS SHUT OFF THREE TIMES NOW IN THE LAST YEAR. I WONDER IF THIS IS THE SAME PROBLEM THAT HAS NOW BEEN REPORTED WITH THE 2017 CHRYSLER PACIFICA?
NHTSA ODI #11048045
110,000 miles · Nov 20, 2017
Electrical SystemEnginePower Train
ON MANY DIFFERENT OCCASIONS, MY 2010 CHRYSLER TOWN AND COUNTRY WILL SHUT OFF WHILE DRIVING. ALL OF THE WARNING LIGHTS ILLUMINATE ON MY DASHBOARD, THE POWER STEERING SHUTS OFF, AND THE ENGINE SHUTS OFF. I MUST COAST TO THE SIDE OF THE ROAD, WITHOUT POWER STEERING, AND TURN THE KEY TO THE OFF POSITION. THEN, I MUST RESTART THE …
Read full complaint
ON MANY DIFFERENT OCCASIONS, MY 2010 CHRYSLER TOWN AND COUNTRY WILL SHUT OFF WHILE DRIVING. ALL OF THE WARNING LIGHTS ILLUMINATE ON MY DASHBOARD, THE POWER STEERING SHUTS OFF, AND THE ENGINE SHUTS OFF. I MUST COAST TO THE SIDE OF THE ROAD, WITHOUT POWER STEERING, AND TURN THE KEY TO THE OFF POSITION. THEN, I MUST RESTART THE VEHICLE. IT ALWAYS RESTARTS, BUT THIS HAPPENS ABOUT ONCE EVERY 2 WEEKS. AFTER READING THE RECALL DETAILS OF THE 2017 CHRYSLER PACIFICAS, THE DESCRIPTION OF THE PROBLEM MATCHES THE PROBLEMS I AM HAVING. MY MECHANIC HAS INSPECTED MY VAN, BUT HE CANNOT DIAGNOSE ANY PROBLEM UNLESS HE, HIMSELF, EXPERIENCES AND WITNESSES THE STALLING OCCUR. *THE PROBLEM HAPPENS WHILE IN MOTION. IT HAS HAPPENED SLOWLY IN A PARKING LOT, AND IT HAS HAPPENED AT 55 MPH ON A HIGHWAY.
NHTSA ODI #11047437
169,812 miles · Oct 27, 2017
EngineService BrakesSteering
2010 TOWN AND COUNTRY ENGINE DIED WHEN IN MOTION GOING AROUND 35 MPH ALSO DIED WHEN COMING TO A STOP AT STOP LIGHT. THE ELECTRONIC STABILITY CONTROL LIGHT WENT ON WHEN ENGINE CUT OFF. LOSS OF POWER STEERING AND POWER BRAKES. WAS ABLE TO PUT IT IN PARK AND RESTART.
NHTSA ODI #11040325
Mileage unknown · Oct 2, 2017
EngineService BrakesSteering
CAR ENGINE DIES MAKING BRAKES GAS PEDAL AND STEERING GO OUT! CAR COMPLAINTS.COM HAS A REPORT ON THIS PROBLEM?! DIRECTED ME TO THIS WEBSITE. PLEASE HELP FEAR FOR MINE AND KIDS SAFETY DRIVING THIS VEHICLE UNDER THESE CIRCUMSTANCES! WE WERE DRIVING WHILE THIS TOOK PLACE.
NHTSA ODI #11031363
84,000 miles · Sep 29, 2017
EnginePower TrainSteering
WHILE DRIVING THE VAN IT RANDOMLY SHUTS DOWN THE ENGINE AND IT IS VERY DIFFICULT TO STEER. YOU CANNOT ACCELERATE OUT OF THE PATH OF TRAFFIC. THIS IS EXTREMELY DANGEROUS!
NHTSA ODI #11030480
Official recalls
5Jul 7, 2020
Chrysler (FCA US LLC) is recalling certain 2008-2010 Chrysler Town and Country and Dodge Grand Caravan and 2007-2011 Dodge Nitro vehicles. These vehicles may have a loose or missing brand emblem in the center of the steering wheel. The loose emblem or the securing nuts for the emblem within the driver air bag module may become projectiles in the event of a driver air bag deployment.
Consequence & remedy
Consequence: Projectiles as a result of driver air bag deployment in the event of a crash can increase the risk of injury.
Remedy: Chrysler will notify owners, and dealers will replace the driver's air bag cover with a redesigned cover, free of charge. The recall began February 11, 2021. Owners may contact FCA US LLC customer service at 1-800-853-1403. Chrysler's number for this recall is W09.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
Chrysler (FCA US LLC) is recalling certain 2008-2010 Chrysler Town and Country and Dodge Grand Caravan and 2007-2011 Dodge Nitro vehicles. These vehicles may have a loose or missing brand emblem in the center of the steering wheel. The loose emblem or the securing nuts for the emblem within the driver air bag module may become projectiles in the event of a driver air bag deployment.
Consequence: Projectiles as a result of driver air bag deployment in the event of a crash can increase the risk of injury.
Remedy: Chrysler will notify owners, and dealers will replace the driver's air bag cover with a redesigned cover, free of charge. The recall began February 11, 2021. Owners may contact FCA US LLC customer service at 1-800-853-1403. Chrysler's number for this recall is W09.
Steering: Steering Wheel/handle Bar
Chrysler (FCA US LLC) is recalling certain 2008-2010 Chrysler Town and Country and Dodge Grand Caravan and 2007-2011 Dodge Nitro vehicles. These vehicles may have a loose or missing brand emblem in the center of the steering wheel. The loose emblem or the securing nuts for the emblem within the driver air bag module may become projectiles in the event of a driver air bag deployment.
Consequence: Projectiles as a result of driver air bag deployment in the event of a crash can increase the risk of injury.
Remedy: Chrysler will notify owners, and dealers will replace the driver's air bag cover with a redesigned cover, free of charge. The recall began February 11, 2021. Owners may contact FCA US LLC customer service at 1-800-853-1403. Chrysler's number for this recall is W09.
Jun 26, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. Chrysler Group LLC (Chrysler) is recalling certain model year 2009-2010 Dodge Journey vehicles manufactured June 29, 2007, to June 17, 2010, and 2008-2010 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured January 26, 2007, to June 17, 2010. Road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the ignition switch and key FOBs, free of charge. The recall began on May 26, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R03. Note: This is an expansion of recall 11V-139.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. Chrysler Group LLC (Chrysler) is recalling certain model year 2009-2010 Dodge Journey vehicles manufactured June 29, 2007, to June 17, 2010, and 2008-2010 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured January 26, 2007, to June 17, 2010. Road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence: If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the ignition switch and key FOBs, free of charge. The recall began on May 26, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R03. Note: This is an expansion of recall 11V-139.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. Chrysler Group LLC (Chrysler) is recalling certain model year 2009-2010 Dodge Journey vehicles manufactured June 29, 2007, to June 17, 2010, and 2008-2010 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured January 26, 2007, to June 17, 2010. Road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence: If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the ignition switch and key FOBs, free of charge. The recall began on May 26, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R03. Note: This is an expansion of recall 11V-139.
May 7, 2014
Chrysler Group, LLC (Chrysler) is recalling certain model year 2010-2014 Chrysler Town and Country and Dodge Grand Caravan vehicles manufactured August 25, 2010, through October 31, 2013. The affected vehicles may experience overheating of the vent window switch in the driver's door armrest.
Consequence & remedy
Consequence: An overheated switch may result in a vehicle fire.
Remedy: Chrysler will notify owners, and dealers will replace the vent window switch with a newer version, free of charge. The owner notification letter was issued and the remedy campaign launched on on December 31, 2014. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P25.
Feb 11, 2014
Freedom Motors Inc., (Freedom Motors) of Savaria Vehicle Group (formerly The Liberty Motor Company) is recalling one model year 2009 Volkswagen Routan and certain model year 2008-2010 Dodge Grand Caravan and Chrysler Town & Country wheelchair accessible vehicles modified by The Liberty Motor Company from February 2008 through January 2011. Over time and with use, the vehicle's rear axle may develop cracks which could lead to axle failure.
Consequence & remedy
Consequence: Failure of the rear axle may increase the risk of a crash.
Remedy: Freedom Motors will notify owners, and dealers will replace the affected axles, free of charge. The recall began on April 1, 2014. Owners can contact Freedom Motors at 1-800-561-9600. Freedom Motors' number for this recall is ENGF0216-3.
Mar 1, 2011
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2010 DODGE JOURNEY, GRAND CARAVAN, AND CHRYSLER TOWN & COUNTRY VEHICLES MANUFACTURER FROM AUGUST 3, 2009, THROUGH JUNE 17, 2010. SOME VEHICLES MAY EXPERIENCE INADVERTENT IGNITION KEY DISPLACEMENT FROM THE RUN TO ACCESSORY POSITION WHILE DRIVING CAUSING THE ENGINE TO SHUT OFF.
Consequence & remedy
Consequence: ENGINE SHUT OFF WHILE DRIVING COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE WIN MODULES FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING JULY 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP14004 · Totally Integrated Power Module Failure
Opened Sep 25, 2014 · Closed Jul 24, 2015
Status: closed (inferred from source dates) · Electrical System
In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV?s, trucks, and vans beginning in the 2007 model year. The petitioner alleges that TIPM defects may result in engine stall, airbag non-deployment, failure of fuel pump shutoff resulting in unintended acceleration, fire, and other symptoms. On September 25, 2014, the Office of Defects Investigation (ODI) opened DP14-004 to evaluate the petition for a grant or deny decision. ODI analyzed complaint data provided by CAS as well as complaints submitted to ODI from consumers. In total, there were 296 complaints submitted by the petitioner in the original petition and five supplements, including 271 complaints related to the subject vehicles equipped with TIPM-7. Approximately 3 percent of CAS complaints are related to vehicles equipped with TIPM-6 and ODI?s review of these complaints did not identify any safety defect trends. ODI conducted a detailed review of complaints narratives submitted by CAS and consumers including careful analysis of vehicle repair histories, warranty claims obtained from the manufacturer and any available Customer Assistance Inquiry reports (CAIR). Analysis of the field data indicated that MY2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles exhibited significantly higher complaint rates related to fuel pump relay (FPR) failures than other subject vehicles. In a September 3, 2014 letter to NHTSA, Chrysler submitted a Defect Information Report (DIR) identifying a defect in the FPR within the TIPM-7 which can result in a no start or stall condition in approximately 188,723 model year (MY) 2011 Jeep Grand Cherokee (WK) and Dodge Durango (WD) vehicles manufactured from January 5, 2010 through July 20, 2011 (14V-530).In a February 24, 2015 letter, Chrysler submitted a second DIR expanding the scope of the FPR defect condition to include an additional 338,216 MY 2012 through 2013 Jeep Grand Cherokee vehicles manufactured from September 17, 2010 through August 19, 2013 and MY 2012 through 2013 Dodge Durango vehicles manufactured from January 18, 2011 through August 19, 2013 (15V-115).ODI analysis of the CAS allegations of TIPM defects resulting in stall while driving, airbag non-deployment, unintended acceleration, fire and other faults identified a single defect condition related to 1 of over 60 different circuits in the TIPM assembly. The most common effect of this defect condition, related to the fuel pump relay, was a no-start concern, but it could also result in stall while driving (76 complaints). No valid evidence was presented in support of claims related to airbag non-deployment, unintended acceleration or fire resulting from TIPM faults and these claims were found to be wholly without merit based on review of the field data and design of the relevant systems and components.Except insofar as the petitioner's contentions relate to the defect condition addressed by the Chrysler recalls, the factual bases of the petitioner's contentions that any further investigation is necessary are unsupported. In our view, additional investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists or a NHTSA order for the notification and remedy of a safety-related defect as alleged by the petitioner at the conclusion of the requested investigation. Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is den
RQ14002 · Air Bag Non-Deployment/Engine Stall
Opened Jun 16, 2014 · Closed Mar 2, 2015
Status: closed (inferred from source dates) · Air Bags; Electrical System:ignition:module
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972
Additional source detail variants (2)
Air Bags
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972
Electrical System:ignition:module
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972
Illustration