NHTSA owner reports · September 18, 2026 snapshot.
Steering complaints
121 reportsClear category filter90,000 miles · Mar 31, 2014
Steering
THIS PROBLEM HAS HAPPENED MULTIPLE TIMES OF THE PRIOR 2-3 YEARS. WE BOUGHT THE VAN USED AND THE PROBLEM HAS HAPPENED MULTIPLE TIMES SINCE PURCHASED. IN THE RAIN OR WHEN THERE IS STANDING WATER ON THE ROAD, THE POWER STEERING WILL FAIL. THIS USUALLY HAPPENS AT LOWER SPEEDS, AND OFTEN WHILE LOWING DOWN OR TURNING. THE POWER STEERI…
Read full complaint
THIS PROBLEM HAS HAPPENED MULTIPLE TIMES OF THE PRIOR 2-3 YEARS. WE BOUGHT THE VAN USED AND THE PROBLEM HAS HAPPENED MULTIPLE TIMES SINCE PURCHASED. IN THE RAIN OR WHEN THERE IS STANDING WATER ON THE ROAD, THE POWER STEERING WILL FAIL. THIS USUALLY HAPPENS AT LOWER SPEEDS, AND OFTEN WHILE LOWING DOWN OR TURNING. THE POWER STEERING WILL STOP TEMPORARILY AND YOU LOSE ALL CONTROL OF THE VEHICLE. THIS HAS HAPPENED TO MY WIFE TWICE WHILE SHE WAS TURNING IN TRAFFIC. THE POWER STEERING WILL START WORKING AGAIN USUALLY IN LESS THAN A MINUTE. IT IS VERY DANGEROUS, AS YOU HAVE NO CONTROL. IT ONLY HAPPENS WHEN THERE IS STANDING WATER IN THE ROAD DURING OR JUST AFTER MODERATE TO HEAVY RAIN. THERE HAVE BEEN MULTIPLE REPORTS OF THIS PROBLEM ON THE CHRYSLER FORUMS. WE TOOK OUR VAN TO A MECHANIC AND THEY REPLACED THE RACK AND PINION, BUT THE PROBLEM HAS PERSISTED. I HAVE READ O N THE CHRYSLER FORUM WHERE OTHERS HAVE REPLACED THE POWER STEERING PUMP, PULLEYS, BELTS, ETC. AND STILL HAVE THE SAME PROBLEM. *TR
NHTSA ODI #10575809
55,000 miles · Jun 8, 2013
Steering
WHEN RAINING OR DRIVING THROUGH A SMALL PUDDLE, THE POWER STEERING LOCKS UP AND I HAVE NO CONTROL OVER VEHICLE. THIS MAY LAST UP TO 30 SECONDS BEFORE RETURNING TO NORMAL. VERY DANGEROUS! *TR
NHTSA ODI #10515815
91,000 miles · May 7, 2013
EngineSteering
I HAD JUST STARTED THE VAN TO START TO EXIT A PARKING LOT. I WAS TRAVELING ABOUT 5 MPH. AS I ROUNDED A CORNER TO THE EXIT, THE VAN'S ENGINE JUST SHUT OFF. I COULDN'T STEER AND THE BRAKES DIDN'T WORK. I HAD TO COAST UNTIL THE VAN STOPPED TO THE GEAR IN PARK AND ATTEMPT A RESTART. AFTER I WAS AT A COMPLETE STANDSTILL I WAS ABLE T…
Read full complaint
I HAD JUST STARTED THE VAN TO START TO EXIT A PARKING LOT. I WAS TRAVELING ABOUT 5 MPH. AS I ROUNDED A CORNER TO THE EXIT, THE VAN'S ENGINE JUST SHUT OFF. I COULDN'T STEER AND THE BRAKES DIDN'T WORK. I HAD TO COAST UNTIL THE VAN STOPPED TO THE GEAR IN PARK AND ATTEMPT A RESTART. AFTER I WAS AT A COMPLETE STANDSTILL I WAS ABLE TO CHANGE THE GEAR TO PARK AND RESTART THE VAN. AFTER THAT IT DIDN'T STALL AT ALL ON THE RIDE HOME. *TR
NHTSA ODI #10511024
5,000 miles · Oct 2, 2012
Service BrakesSteeringStructure
TL* THE CONTACT OWNS A 2005 CHRYSLER TOWN AND COUNTRY. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED BRAKE FAILURE NUMEROUS TIMES. THE MOST RECENT FAILURE OCCURRED WHILE DRIVING THROUGH AN INTERSECTION AT APPROXIMATELY 25 MPH AND THE BRAKES FAILED TO ENGAGE. THE CONTACT WAS ABLE TO COAST THE VEHICLE INTO A PARKING AREA AND WAS…
Read full complaint
TL* THE CONTACT OWNS A 2005 CHRYSLER TOWN AND COUNTRY. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED BRAKE FAILURE NUMEROUS TIMES. THE MOST RECENT FAILURE OCCURRED WHILE DRIVING THROUGH AN INTERSECTION AT APPROXIMATELY 25 MPH AND THE BRAKES FAILED TO ENGAGE. THE CONTACT WAS ABLE TO COAST THE VEHICLE INTO A PARKING AREA AND WAS ABLE TO STOP BUY ENGAGING THE EMERGENCY BRAKE. THE BRAKE PAD AND TIRES WERE REPLACED AT 18,000 MILES, THE STRUT WAS REPLACED AT 5,000 MILES, AND THE ROTORS WERE REPLACED AT 28,000 MILES HOWEVER, THE FAILURE WAS NOT CORRECTED. THE STEERING WHEEL MADE A GRINDING NOISE AND WAS HARD TO TURN. IN ADDITION, THE DOORS COULD NOT BE UNLOCKED AUTOMATICALLY OR MANUALLY AND SOMETIMES THE DOORS OPENED INDEPENDENTLY WHILE DRIVING. THE VEHICLE WAS TOWED TO THE DEALER WHO INSPECTED THE VEHICLE AND STATED THAT THE BRAKE MASTER CYLINDER EXHIBITED OIL CONSUMPTION THEREFORE, THE VEHICLE WAS UNSAFE TO DRIVE AND THEY COULD NOT COMPLETE THE VEHICLE INSPECTION. THE FAILURE MILEAGE WAS 5,000 AND THE CURRENT MILEAGE WAS 48,800.
NHTSA ODI #10478353
Mileage unknown · Mar 13, 2012
Steering
STEERING MAKES NOISES AND RACK AND PINION IS LEAKING ON BOTH SIDES AFTER 89K MILES. VEHICLE DOES NOT PASS STATE INSPECTION BECAUSE OF THAT. CHRYSLER DOES NOT COVER THE REPAIR ALTHOUGH IT SEEMS TO BE A MANUFACTURER DEFECT JUDGING FROM THE NUMBER OF INCIDENTS THAT CAN BE FOUND HERE OR ELSEWHERE ON THE INTERNET. *TR
NHTSA ODI #10451545
Mileage unknown · Feb 6, 2012
Steering
TL* THE CONTACT OWNS A 2005 CHRYSLER TOWN AND COUNTRY. THE CONTACT STATED THAT THERE WAS A HUMMING NOISE COMING FROM THE STEERING AREA. A LOCAL MECHANIC DIAGNOSED THAT THE POWER STEERING PUMP AND LINE WOULD NEED TO BE REPLACED. NEITHER THE DEALER NOR THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED…
Read full complaint
TL* THE CONTACT OWNS A 2005 CHRYSLER TOWN AND COUNTRY. THE CONTACT STATED THAT THERE WAS A HUMMING NOISE COMING FROM THE STEERING AREA. A LOCAL MECHANIC DIAGNOSED THAT THE POWER STEERING PUMP AND LINE WOULD NEED TO BE REPLACED. NEITHER THE DEALER NOR THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS UNAVAILABLE AND THE CURRENT MILEAGE WAS 128,000.
NHTSA ODI #10446877
90,000 miles · Dec 13, 2011
Steering
TL* THE CONTACT OWNS A 2005 CHRYSLER TOWN AND COUNTRY. THE CONTACT STATED THAT HE WOULD HEAR A NOISE COMING FROM THE STEERING COLUMN WHILE DRIVING APPROXIMATELY 15 MPH. THE CONTACT REPLACED THE POWER STEERING PUMP HIMSELF, BUT THE FAILURE CONTINUED. THE CONTACT ALSO STATED THAT THE NOISE HAD BECOME LOUDER OVER TIME. IN ADDITION,…
Read full complaint
TL* THE CONTACT OWNS A 2005 CHRYSLER TOWN AND COUNTRY. THE CONTACT STATED THAT HE WOULD HEAR A NOISE COMING FROM THE STEERING COLUMN WHILE DRIVING APPROXIMATELY 15 MPH. THE CONTACT REPLACED THE POWER STEERING PUMP HIMSELF, BUT THE FAILURE CONTINUED. THE CONTACT ALSO STATED THAT THE NOISE HAD BECOME LOUDER OVER TIME. IN ADDITION, THE STEERING WHEEL MOMENTARILY SEIZED ON ONE OCCASION. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 90,000.
NHTSA ODI #10439702
130,000 miles · Nov 23, 2011
Steering
TL* THE CONTACT OWNS A 2005 CHRYSLER TOWN AND COUNTRY. THE CONTACT STATED THAT A LOUD WHINING NOISE EMITTED FROM THE STEERING COLUMN WHILE DRIVING. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, WHO PERFORMED A DIAGNOSTIC TEST. THE FAILURE WAS LOCATED AT THE POWER STEERING PUMP. THE DEALER REPLACED THE POWER STEERING PUMP, BUT T…
Read full complaint
TL* THE CONTACT OWNS A 2005 CHRYSLER TOWN AND COUNTRY. THE CONTACT STATED THAT A LOUD WHINING NOISE EMITTED FROM THE STEERING COLUMN WHILE DRIVING. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, WHO PERFORMED A DIAGNOSTIC TEST. THE FAILURE WAS LOCATED AT THE POWER STEERING PUMP. THE DEALER REPLACED THE POWER STEERING PUMP, BUT THE FAILURE CONTINUED. THE DEALER PERFORMED A SECOND DIAGNOSTIC TEST THAT LOCATED THE FAILURE AT THE RACK AND PINION. THE RACK A PINION WAS LEAKING FLUID. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 130,000 AND THE CURRENT MILEAGE WAS 138,000.
NHTSA ODI #10436822
74,000 miles · Nov 21, 2011
Steering
VAN WAS MAKING HORRIBLE NOISE WHEN TURNING. TOOK VEHICLE TO THE MECHANIC. HAD TO REPLACE RACK AND PINION. HAD POWER STEERING PUMP REPLACED ALSO. THIS VAN HAS BEEN NOTHING BUT A MONEY PIT. I SEE MANY OTHERS WITH THIS COMPLAINT. I ALSO FILED A COMPLAINT A WHILE BACK HAVING MAJOR ELECTRICAL ISSUES. I SEE THE RACK AND PINION I…
Read full complaint
VAN WAS MAKING HORRIBLE NOISE WHEN TURNING. TOOK VEHICLE TO THE MECHANIC. HAD TO REPLACE RACK AND PINION. HAD POWER STEERING PUMP REPLACED ALSO. THIS VAN HAS BEEN NOTHING BUT A MONEY PIT. I SEE MANY OTHERS WITH THIS COMPLAINT. I ALSO FILED A COMPLAINT A WHILE BACK HAVING MAJOR ELECTRICAL ISSUES. I SEE THE RACK AND PINION IS A MAJOR ISSUE ALSO. IT WAS VERY EXPENSIVE TO FIX AS WELL AS MY ELECTRICAL PROBLEMS. RECALL ON ANYTHING???? *TR
NHTSA ODI #10436624
Mileage unknown · Nov 16, 2011
Steering
WAS TOLD I NEED TO REPLACE THE RACK AND PINION STEERING ON MY VEHICLE. LESS THAN A YEAR AGO I HAD THE PUMP FOR THIS REPLACED. *TR
NHTSA ODI #10436014
NHTSA investigations
7DP14002 · Engine Stall After Refueling
Opened Sep 5, 2014 · Closed Apr 6, 2015
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly
This defect petition evaluates July 7, 2014 allegations from an owner of a model year (MY) 2007 Dodge Grand Caravan minivan that engine stall occurs in these vehicles without warning after refueling.The petitioner's vehicle is a Chrysler RS platform minivan.The RS platform includes MY 2003 through 2007 Dodge Grand Caravan, Dodge Caravan, Chrysler Town and Country and Chrysler Voyager minivans.NHTSA evaluated the petition by analyzing consumer complaints submitted to the Agency, analyzing field data, reviewing technical information provided in Chrysler's response to an Agency information request and testing an RS minivan identified by its owner as experiencing post-refuel engine stalls.After completing this evaluation, NHTSA has concluded that further investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists.The stalls occurring in these vehicles only occur immediately after filling up the fuel tank and happen at low engine speeds. The failure rate is low, even after 8 to 13 years of the vehicles being in service, and there are no reports of crashes or injuries resulting from the stall condition.In the Agency's view, additional investigation is unlikely to result in finding the existence of a safety-related defect in the subject vehicles.Given the need to allocate and prioritize NHTSA's limited resources to best accomplish the Agency's safety mission, the petition is denied.This action does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency will take further action if warranted by future circumstances. More details concerning our review can be found in the Federal Register Notice for this action.The following 161 VOQs are included in the petition evaluation: 10209242, 10229468, 10240708, 10260923, 10275939, 10276532, 10296487, 10298175, 10328669, 10330144, 10346517, 10349789, 10354758, 10363689, 10372112, 10372368, 10372514, 10378031, 10379764, 10382938, 10387448, 10394063, 10398877, 10413918, 10418652, 10420924, 10427063, 10437525, 10445392, 10446902, 10470028, 10471249, 10473733, 10502231, 10503114, 10504260, 10509862, 10511988, 10512120, 10512385, 10512650, 10513147, 10538154, 10549841, 10551763, 10555188, 10555418, 10556754, 10565367, 10574012, 10574398, 10586555, 10587212, 10587559, 10593433, 10607841, 10607913, 10608922, 10615810, 10622468, 10628141, 10632112, 10632128, 10632172, 10632175, 10632231, 10632262, 10632266, 10632270, 10632305, 10632316, 10632326, 10632370, 10632385, 10632399, 10632492, 10632542, 10632765, 10632833, 10632928, 10633197, 10633281, 10633409, 10633421, 10633483, 10633507, 10637752, 10637804, 10637950, 10637975, 10638032, 10638289, 10638290, 10638401, 10638968, 10639218, 10639623, 10641157, 10641603, 10641614, 10641836, 10644339, 10644705, 10649713, 10649895, 10649932, 10650313, 10652590, 10653147, 10653783, 10654533, 10655226, 10658900, 10659679, 10660320, 10662588, 10662645, 10662662, 10663473, 10667056, 10667437, 10668081, 10668094, 10668131, 10668612, 10668969, 10668970, 10669584, 10669678, 10669729, 10669775, 10669866, 10669895, 10669992, 10670422, 10670506, 10676348, 10676732, 10677120, 10679795, 10679934, 10680057, 10680290, 10680342, 10680714, 10681512, 10682584, 10682906, 10683022, 10683114, 10683549, 10683620, 10683697, 10683743, 10689898, 10690761, 10691284, 10691556, 10691751, 10693061, 10694300
EA11010 · Loss Of Headlight Illumination
Opened Sep 6, 2011 · Closed Nov 29, 2012
Status: closed (inferred from source dates) · Electrical System; Exterior Lighting; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
The subject vehicle (SV) population includes MY 2005-2006 vehicles built between March 2004 and December 2005 manufactured with a TRW supplied headlight switch assembly (HSA).The HSA was the primary focus of the investigation; earlier and later vehicles utilized different HSAs.Consumers complain that the headlights in the subject vehicles do not illuminate when the HSA is turned on, or that the headlights extinguish while on (subject failure).No other driving lights are affected.The front marker, tail, and instrument lamps operate.Also, the high beams can be illuminated by holding the turn signal stalk in the up position.As reported by consumers, turning the HSA off and on typically corrects the failure.Initially the failures occur infrequently but they become progressively more frequent with age.Chrysler has indicated its intention to offer of an extended lifetime warranty on the HSA, so that consumers with this problem can have their HSA replaced at no charge when they begin experiencing the subject failure.Commencing sometime in early 2013, Chrysler will send letters to SV owners notifying them of the lifetime warranty.The SV headlight system design is essentially the same as that described in EA 05-009, which involved headlight anomalies in earlier model Chrysler minivans; refer to it to for additional information.The subject failure is caused by friction between the plastic cam and metal surfaces of the electrical contacts in the HSA, which results in the production of plastic particles (debris).Analysis shows that debris can collect on the electrical contact that controls the headlights, resulting in an open circuit and preventing the headlights from turning on.Subsequent operation of the HSA may temporarily displace the debris, at which time the headlights operate correctly.Lubricant was applied to the plastic cam beginning in December 2005, reducing debris production.Consequently, subsequent failure levels were lower.The report counts shown above include only those that involve the subject failure.Reports involving other failure modes which were identified have not been included either because they were not safety related, or if they were safety related, because there was no defect trend.The single crash event listed in the Failure Report Summary Table above involved a deer strike allegedly due to loss of headlights in February 2006.No injuries were reported in this crash.An April 2004 non-crash incident (?Other? above) involved a momentary loss of headlights.The consumer drove into a ditch, and one minor injury was alleged. The subject vehicles experienced a 2.2% warranty claim rate.While standing alone this would appear to be significant, a portion of these warranty claims likely involve other problems with the HSA unrelated to the subject failure.In view of the on road experience of drivers in rapidly restoring headlight illumination by turning the headlight switch off and on again, the rate and particularly the recent trend in problems with the switch, and Chrysler?s extended lifetime warranty coupled with the owner notification of that extended warranty, further investigation does not appear to be warranted.Accordingly, the investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.Details on Chrysler?s lifetime HSA warranty extension for the SV population will be available in the public file for this investigation.
Additional source detail variants (4)
Electrical System
The subject vehicle (SV) population includes MY 2005-2006 vehicles built between March 2004 and December 2005 manufactured with a TRW supplied headlight switch assembly (HSA).The HSA was the primary focus of the investigation; earlier and later vehicles utilized different HSAs.Consumers complain that the headlights in the subject vehicles do not illuminate when the HSA is turned on, or that the headlights extinguish while on (subject failure).No other driving lights are affected.The front marker, tail, and instrument lamps operate.Also, the high beams can be illuminated by holding the turn signal stalk in the up position.As reported by consumers, turning the HSA off and on typically corrects the failure.Initially the failures occur infrequently but they become progressively more frequent with age.Chrysler has indicated its intention to offer of an extended lifetime warranty on the HSA, so that consumers with this problem can have their HSA replaced at no charge when they begin experiencing the subject failure.Commencing sometime in early 2013, Chrysler will send letters to SV owners notifying them of the lifetime warranty.The SV headlight system design is essentially the same as that described in EA 05-009, which involved headlight anomalies in earlier model Chrysler minivans; refer to it to for additional information.The subject failure is caused by friction between the plastic cam and metal surfaces of the electrical contacts in the HSA, which results in the production of plastic particles (debris).Analysis shows that debris can collect on the electrical contact that controls the headlights, resulting in an open circuit and preventing the headlights from turning on.Subsequent operation of the HSA may temporarily displace the debris, at which time the headlights operate correctly.Lubricant was applied to the plastic cam beginning in December 2005, reducing debris production.Consequently, subsequent failure levels were lower.The report counts shown above include only those that involve the subject failure.Reports involving other failure modes which were identified have not been included either because they were not safety related, or if they were safety related, because there was no defect trend.The single crash event listed in the Failure Report Summary Table above involved a deer strike allegedly due to loss of headlights in February 2006.No injuries were reported in this crash.An April 2004 non-crash incident (?Other? above) involved a momentary loss of headlights.The consumer drove into a ditch, and one minor injury was alleged. The subject vehicles experienced a 2.2% warranty claim rate.While standing alone this would appear to be significant, a portion of these warranty claims likely involve other problems with the HSA unrelated to the subject failure.In view of the on road experience of drivers in rapidly restoring headlight illumination by turning the headlight switch off and on again, the rate and particularly the recent trend in problems with the switch, and Chrysler?s extended lifetime warranty coupled with the owner notification of that extended warranty, further investigation does not appear to be warranted.Accordingly, the investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.Details on Chrysler?s lifetime HSA warranty extension for the SV population will be available in the public file for this investigation.
Exterior Lighting
The subject vehicle (SV) population includes MY 2005-2006 vehicles built between March 2004 and December 2005 manufactured with a TRW supplied headlight switch assembly (HSA).The HSA was the primary focus of the investigation; earlier and later vehicles utilized different HSAs.Consumers complain that the headlights in the subject vehicles do not illuminate when the HSA is turned on, or that the headlights extinguish while on (subject failure).No other driving lights are affected.The front marker, tail, and instrument lamps operate.Also, the high beams can be illuminated by holding the turn signal stalk in the up position.As reported by consumers, turning the HSA off and on typically corrects the failure.Initially the failures occur infrequently but they become progressively more frequent with age.Chrysler has indicated its intention to offer of an extended lifetime warranty on the HSA, so that consumers with this problem can have their HSA replaced at no charge when they begin experiencing the subject failure.Commencing sometime in early 2013, Chrysler will send letters to SV owners notifying them of the lifetime warranty.The SV headlight system design is essentially the same as that described in EA 05-009, which involved headlight anomalies in earlier model Chrysler minivans; refer to it to for additional information.The subject failure is caused by friction between the plastic cam and metal surfaces of the electrical contacts in the HSA, which results in the production of plastic particles (debris).Analysis shows that debris can collect on the electrical contact that controls the headlights, resulting in an open circuit and preventing the headlights from turning on.Subsequent operation of the HSA may temporarily displace the debris, at which time the headlights operate correctly.Lubricant was applied to the plastic cam beginning in December 2005, reducing debris production.Consequently, subsequent failure levels were lower.The report counts shown above include only those that involve the subject failure.Reports involving other failure modes which were identified have not been included either because they were not safety related, or if they were safety related, because there was no defect trend.The single crash event listed in the Failure Report Summary Table above involved a deer strike allegedly due to loss of headlights in February 2006.No injuries were reported in this crash.An April 2004 non-crash incident (?Other? above) involved a momentary loss of headlights.The consumer drove into a ditch, and one minor injury was alleged. The subject vehicles experienced a 2.2% warranty claim rate.While standing alone this would appear to be significant, a portion of these warranty claims likely involve other problems with the HSA unrelated to the subject failure.In view of the on road experience of drivers in rapidly restoring headlight illumination by turning the headlight switch off and on again, the rate and particularly the recent trend in problems with the switch, and Chrysler?s extended lifetime warranty coupled with the owner notification of that extended warranty, further investigation does not appear to be warranted.Accordingly, the investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.Details on Chrysler?s lifetime HSA warranty extension for the SV population will be available in the public file for this investigation.
Exterior Lighting:headlights
The subject vehicle (SV) population includes MY 2005-2006 vehicles built between March 2004 and December 2005 manufactured with a TRW supplied headlight switch assembly (HSA).The HSA was the primary focus of the investigation; earlier and later vehicles utilized different HSAs.Consumers complain that the headlights in the subject vehicles do not illuminate when the HSA is turned on, or that the headlights extinguish while on (subject failure).No other driving lights are affected.The front marker, tail, and instrument lamps operate.Also, the high beams can be illuminated by holding the turn signal stalk in the up position.As reported by consumers, turning the HSA off and on typically corrects the failure.Initially the failures occur infrequently but they become progressively more frequent with age.Chrysler has indicated its intention to offer of an extended lifetime warranty on the HSA, so that consumers with this problem can have their HSA replaced at no charge when they begin experiencing the subject failure.Commencing sometime in early 2013, Chrysler will send letters to SV owners notifying them of the lifetime warranty.The SV headlight system design is essentially the same as that described in EA 05-009, which involved headlight anomalies in earlier model Chrysler minivans; refer to it to for additional information.The subject failure is caused by friction between the plastic cam and metal surfaces of the electrical contacts in the HSA, which results in the production of plastic particles (debris).Analysis shows that debris can collect on the electrical contact that controls the headlights, resulting in an open circuit and preventing the headlights from turning on.Subsequent operation of the HSA may temporarily displace the debris, at which time the headlights operate correctly.Lubricant was applied to the plastic cam beginning in December 2005, reducing debris production.Consequently, subsequent failure levels were lower.The report counts shown above include only those that involve the subject failure.Reports involving other failure modes which were identified have not been included either because they were not safety related, or if they were safety related, because there was no defect trend.The single crash event listed in the Failure Report Summary Table above involved a deer strike allegedly due to loss of headlights in February 2006.No injuries were reported in this crash.An April 2004 non-crash incident (?Other? above) involved a momentary loss of headlights.The consumer drove into a ditch, and one minor injury was alleged. The subject vehicles experienced a 2.2% warranty claim rate.While standing alone this would appear to be significant, a portion of these warranty claims likely involve other problems with the HSA unrelated to the subject failure.In view of the on road experience of drivers in rapidly restoring headlight illumination by turning the headlight switch off and on again, the rate and particularly the recent trend in problems with the switch, and Chrysler?s extended lifetime warranty coupled with the owner notification of that extended warranty, further investigation does not appear to be warranted.Accordingly, the investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.Details on Chrysler?s lifetime HSA warranty extension for the SV population will be available in the public file for this investigation.
Exterior Lighting:headlights:switch
The subject vehicle (SV) population includes MY 2005-2006 vehicles built between March 2004 and December 2005 manufactured with a TRW supplied headlight switch assembly (HSA).The HSA was the primary focus of the investigation; earlier and later vehicles utilized different HSAs.Consumers complain that the headlights in the subject vehicles do not illuminate when the HSA is turned on, or that the headlights extinguish while on (subject failure).No other driving lights are affected.The front marker, tail, and instrument lamps operate.Also, the high beams can be illuminated by holding the turn signal stalk in the up position.As reported by consumers, turning the HSA off and on typically corrects the failure.Initially the failures occur infrequently but they become progressively more frequent with age.Chrysler has indicated its intention to offer of an extended lifetime warranty on the HSA, so that consumers with this problem can have their HSA replaced at no charge when they begin experiencing the subject failure.Commencing sometime in early 2013, Chrysler will send letters to SV owners notifying them of the lifetime warranty.The SV headlight system design is essentially the same as that described in EA 05-009, which involved headlight anomalies in earlier model Chrysler minivans; refer to it to for additional information.The subject failure is caused by friction between the plastic cam and metal surfaces of the electrical contacts in the HSA, which results in the production of plastic particles (debris).Analysis shows that debris can collect on the electrical contact that controls the headlights, resulting in an open circuit and preventing the headlights from turning on.Subsequent operation of the HSA may temporarily displace the debris, at which time the headlights operate correctly.Lubricant was applied to the plastic cam beginning in December 2005, reducing debris production.Consequently, subsequent failure levels were lower.The report counts shown above include only those that involve the subject failure.Reports involving other failure modes which were identified have not been included either because they were not safety related, or if they were safety related, because there was no defect trend.The single crash event listed in the Failure Report Summary Table above involved a deer strike allegedly due to loss of headlights in February 2006.No injuries were reported in this crash.An April 2004 non-crash incident (?Other? above) involved a momentary loss of headlights.The consumer drove into a ditch, and one minor injury was alleged. The subject vehicles experienced a 2.2% warranty claim rate.While standing alone this would appear to be significant, a portion of these warranty claims likely involve other problems with the HSA unrelated to the subject failure.In view of the on road experience of drivers in rapidly restoring headlight illumination by turning the headlight switch off and on again, the rate and particularly the recent trend in problems with the switch, and Chrysler?s extended lifetime warranty coupled with the owner notification of that extended warranty, further investigation does not appear to be warranted.Accordingly, the investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.Details on Chrysler?s lifetime HSA warranty extension for the SV population will be available in the public file for this investigation.
AQ10001 · Fleet Vehicle Recall Completion Audit
Opened Nov 18, 2010 · Closed Dec 28, 2015
Status: closed (inferred from source dates) · Unknown Or Other
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.
PE10022 · Loss Of Headlight Illumination
Opened Jul 12, 2010 · Closed Sep 13, 2011
Status: closed (inferred from source dates) · Electrical System; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
To date, ODI has interviewed several complainants who confirmed that the headlights fully extinguish, and remain extinguished, on an intermittent basis.In most cases this occurred while the vehicle was in motion.The occurrences do not show a repeatable pattern, and the problem occurs at a low frequency, typically one or more weeks between failures.For this reason most complainants have not attempted diagnosis or repair of the problem, so the cause is unknown, and the problem continues to occur.In the cases where repairs have been attempted, which consisted mainly of headlight switch and body control module replacements, mixed success is reported.In interviews complainants advised ODI that they can usually toggle the headlight switch, or turn on the high beams by actuating the column stalk (pulling it upward), when the headlights unexpectedly turn off.Complainants report that toggling the switch is usually effective, and the high beams have always been available when the column is used.During the course of the interviews ODI was able to obtain a few suspect headlamp switches for further evaluation.No verifiable crashes or injuries have been identified in the vehicle owner complaints (VOQs).Chrysler notes that its complaints also include allegations of dimming or flickering of the headlights in addition to loss of headlamps, and that their analysis of available data indicates a declining trend occurring in the field.Chrysler data reports two alleged crash incidents; one where a consumers vehicle lost forward lighting and struck a deer, and one where a consumer alleged their lighting stopped working, causing them to depart the roadway and drive into a ditch.A minor injury is alleged in this second incident.Both incidents occurred several years ago, and neither allegation has been confirmed by ODI.ODI is upgrading this investigation to an Engineering Analysis (EA11-010) to continue its analysis of the alleged defect and its consequences, which will include additional analysis of consumer reports, their frequency and trend, and Chrysler's technical information for the headlight system and its components.Additionally testing will be conducted to evaluate possible root cause(s) of the alleged defect, and will include analysis of suspect components collected from the field, and/or assessment of subject vehicles that have reportedly experienced the condition.
Additional source detail variants (3)
Electrical System
To date, ODI has interviewed several complainants who confirmed that the headlights fully extinguish, and remain extinguished, on an intermittent basis.In most cases this occurred while the vehicle was in motion.The occurrences do not show a repeatable pattern, and the problem occurs at a low frequency, typically one or more weeks between failures.For this reason most complainants have not attempted diagnosis or repair of the problem, so the cause is unknown, and the problem continues to occur.In the cases where repairs have been attempted, which consisted mainly of headlight switch and body control module replacements, mixed success is reported.In interviews complainants advised ODI that they can usually toggle the headlight switch, or turn on the high beams by actuating the column stalk (pulling it upward), when the headlights unexpectedly turn off.Complainants report that toggling the switch is usually effective, and the high beams have always been available when the column is used.During the course of the interviews ODI was able to obtain a few suspect headlamp switches for further evaluation.No verifiable crashes or injuries have been identified in the vehicle owner complaints (VOQs).Chrysler notes that its complaints also include allegations of dimming or flickering of the headlights in addition to loss of headlamps, and that their analysis of available data indicates a declining trend occurring in the field.Chrysler data reports two alleged crash incidents; one where a consumers vehicle lost forward lighting and struck a deer, and one where a consumer alleged their lighting stopped working, causing them to depart the roadway and drive into a ditch.A minor injury is alleged in this second incident.Both incidents occurred several years ago, and neither allegation has been confirmed by ODI.ODI is upgrading this investigation to an Engineering Analysis (EA11-010) to continue its analysis of the alleged defect and its consequences, which will include additional analysis of consumer reports, their frequency and trend, and Chrysler's technical information for the headlight system and its components.Additionally testing will be conducted to evaluate possible root cause(s) of the alleged defect, and will include analysis of suspect components collected from the field, and/or assessment of subject vehicles that have reportedly experienced the condition.
Exterior Lighting:headlights
To date, ODI has interviewed several complainants who confirmed that the headlights fully extinguish, and remain extinguished, on an intermittent basis.In most cases this occurred while the vehicle was in motion.The occurrences do not show a repeatable pattern, and the problem occurs at a low frequency, typically one or more weeks between failures.For this reason most complainants have not attempted diagnosis or repair of the problem, so the cause is unknown, and the problem continues to occur.In the cases where repairs have been attempted, which consisted mainly of headlight switch and body control module replacements, mixed success is reported.In interviews complainants advised ODI that they can usually toggle the headlight switch, or turn on the high beams by actuating the column stalk (pulling it upward), when the headlights unexpectedly turn off.Complainants report that toggling the switch is usually effective, and the high beams have always been available when the column is used.During the course of the interviews ODI was able to obtain a few suspect headlamp switches for further evaluation.No verifiable crashes or injuries have been identified in the vehicle owner complaints (VOQs).Chrysler notes that its complaints also include allegations of dimming or flickering of the headlights in addition to loss of headlamps, and that their analysis of available data indicates a declining trend occurring in the field.Chrysler data reports two alleged crash incidents; one where a consumers vehicle lost forward lighting and struck a deer, and one where a consumer alleged their lighting stopped working, causing them to depart the roadway and drive into a ditch.A minor injury is alleged in this second incident.Both incidents occurred several years ago, and neither allegation has been confirmed by ODI.ODI is upgrading this investigation to an Engineering Analysis (EA11-010) to continue its analysis of the alleged defect and its consequences, which will include additional analysis of consumer reports, their frequency and trend, and Chrysler's technical information for the headlight system and its components.Additionally testing will be conducted to evaluate possible root cause(s) of the alleged defect, and will include analysis of suspect components collected from the field, and/or assessment of subject vehicles that have reportedly experienced the condition.
Exterior Lighting:headlights:switch
To date, ODI has interviewed several complainants who confirmed that the headlights fully extinguish, and remain extinguished, on an intermittent basis.In most cases this occurred while the vehicle was in motion.The occurrences do not show a repeatable pattern, and the problem occurs at a low frequency, typically one or more weeks between failures.For this reason most complainants have not attempted diagnosis or repair of the problem, so the cause is unknown, and the problem continues to occur.In the cases where repairs have been attempted, which consisted mainly of headlight switch and body control module replacements, mixed success is reported.In interviews complainants advised ODI that they can usually toggle the headlight switch, or turn on the high beams by actuating the column stalk (pulling it upward), when the headlights unexpectedly turn off.Complainants report that toggling the switch is usually effective, and the high beams have always been available when the column is used.During the course of the interviews ODI was able to obtain a few suspect headlamp switches for further evaluation.No verifiable crashes or injuries have been identified in the vehicle owner complaints (VOQs).Chrysler notes that its complaints also include allegations of dimming or flickering of the headlights in addition to loss of headlamps, and that their analysis of available data indicates a declining trend occurring in the field.Chrysler data reports two alleged crash incidents; one where a consumers vehicle lost forward lighting and struck a deer, and one where a consumer alleged their lighting stopped working, causing them to depart the roadway and drive into a ditch.A minor injury is alleged in this second incident.Both incidents occurred several years ago, and neither allegation has been confirmed by ODI.ODI is upgrading this investigation to an Engineering Analysis (EA11-010) to continue its analysis of the alleged defect and its consequences, which will include additional analysis of consumer reports, their frequency and trend, and Chrysler's technical information for the headlight system and its components.Additionally testing will be conducted to evaluate possible root cause(s) of the alleged defect, and will include analysis of suspect components collected from the field, and/or assessment of subject vehicles that have reportedly experienced the condition.
RQ09003 · Front Air Bag Crash Sensor Failure
Opened Jul 1, 2009 · Closed Feb 18, 2010
Status: closed (inferred from source dates) · Air Bags:frontal; Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:sensor/control MODULE-INACTIVE
CHRYSLER WILL REPLACE THE FRAME RAIL-MOUNTED FRONT AIR BAG CRASH SENSORS IN APPROXIMATELY 312,442 MODEL YEAR (MY) 2005 AND 2006 CHRYSLER MINIVANS (RECALL 10V-008).THESE VEHICLES ARE EQUIPPED WITH FRONT CRASH SENSORS WITH ULTRADUR BRAND PLASTIC HOUSINGS AND STEEL BUSHINGS AND WERE BUILT BETWEEN JANUARY 19, 2005 AND APRIL 5, 2006.THIS ACTION COVERS VEHICLES ORIGINALLY SOLD, OR CURRENTLY REGISTERED, IN 27 STATES (ALASKA, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA AND WISCONSIN) AND THE DISTRICT OF COLUMBIA.VEHICLES SOLD OR CURRENTLY REGISTERED OUTSIDE OF THESE STATES, APPROXIMATELY 185,000 MY 2005-2006 MINIVANS, ARE NOT INCLUDED IN THE RECALL.ALTHOUGH THESE VEHICLES USE THE SAME CRASH SENSORS AND WERE BUILT DURING THE SAME PERIOD AS THE ONES DESCRIBED ABOVE, THEY EXPERIENCE SIGNIFICANTLY LOWER FAILURE RATES BECAUSE OF REDUCED ROAD SALT EXPOSURE.ALSO, MY 2006-2007 MINIVANS BUILT AFTER APRIL 5, 2006, ARE NOT INCLUDED IN THE RECALL.THESE VEHICLES ARE EQUIPPED WITH FRONT CRASH SENSORS WITH CRASTIN BRAND PLASTIC HOUSINGS AND STEEL BUSHINGS AND EXPERIENCE SIGNIFICANTLY LOWER FAILURE RATES COMPARED TO THE RECALLED VEHICLES.NHTSA AND CHRYSLER DIFFER REGARDING THE SIGNIFICANCE AND IMPACT OF THE DEFECT, BUT IN THE INTEREST OF REMEDYING THE AFFECTED VEHICLES EXPEDITIOUSLY AND TO AVOID A PROTRACTED DISPUTE, CHRYSLER IS IMPLEMENTING STEPS TO REPLACE THE FRONT CRASH SENSORS.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED THAT FURTHER USE OF ITS RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THE SUBJECT VEHICLES.THE AGENCY WILL MONITOR THE ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SELECT DOCUMENT SEARCH FOR ADDITIONAL INFORMATION.
Additional source detail variants (3)
Air Bags:frontal
CHRYSLER WILL REPLACE THE FRAME RAIL-MOUNTED FRONT AIR BAG CRASH SENSORS IN APPROXIMATELY 312,442 MODEL YEAR (MY) 2005 AND 2006 CHRYSLER MINIVANS (RECALL 10V-008).THESE VEHICLES ARE EQUIPPED WITH FRONT CRASH SENSORS WITH ULTRADUR BRAND PLASTIC HOUSINGS AND STEEL BUSHINGS AND WERE BUILT BETWEEN JANUARY 19, 2005 AND APRIL 5, 2006.THIS ACTION COVERS VEHICLES ORIGINALLY SOLD, OR CURRENTLY REGISTERED, IN 27 STATES (ALASKA, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA AND WISCONSIN) AND THE DISTRICT OF COLUMBIA.VEHICLES SOLD OR CURRENTLY REGISTERED OUTSIDE OF THESE STATES, APPROXIMATELY 185,000 MY 2005-2006 MINIVANS, ARE NOT INCLUDED IN THE RECALL.ALTHOUGH THESE VEHICLES USE THE SAME CRASH SENSORS AND WERE BUILT DURING THE SAME PERIOD AS THE ONES DESCRIBED ABOVE, THEY EXPERIENCE SIGNIFICANTLY LOWER FAILURE RATES BECAUSE OF REDUCED ROAD SALT EXPOSURE.ALSO, MY 2006-2007 MINIVANS BUILT AFTER APRIL 5, 2006, ARE NOT INCLUDED IN THE RECALL.THESE VEHICLES ARE EQUIPPED WITH FRONT CRASH SENSORS WITH CRASTIN BRAND PLASTIC HOUSINGS AND STEEL BUSHINGS AND EXPERIENCE SIGNIFICANTLY LOWER FAILURE RATES COMPARED TO THE RECALLED VEHICLES.NHTSA AND CHRYSLER DIFFER REGARDING THE SIGNIFICANCE AND IMPACT OF THE DEFECT, BUT IN THE INTEREST OF REMEDYING THE AFFECTED VEHICLES EXPEDITIOUSLY AND TO AVOID A PROTRACTED DISPUTE, CHRYSLER IS IMPLEMENTING STEPS TO REPLACE THE FRONT CRASH SENSORS.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED THAT FURTHER USE OF ITS RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THE SUBJECT VEHICLES.THE AGENCY WILL MONITOR THE ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SELECT DOCUMENT SEARCH FOR ADDITIONAL INFORMATION.
Air Bags:frontal:driver Side:inflator Module
CHRYSLER WILL REPLACE THE FRAME RAIL-MOUNTED FRONT AIR BAG CRASH SENSORS IN APPROXIMATELY 312,442 MODEL YEAR (MY) 2005 AND 2006 CHRYSLER MINIVANS (RECALL 10V-008).THESE VEHICLES ARE EQUIPPED WITH FRONT CRASH SENSORS WITH ULTRADUR BRAND PLASTIC HOUSINGS AND STEEL BUSHINGS AND WERE BUILT BETWEEN JANUARY 19, 2005 AND APRIL 5, 2006.THIS ACTION COVERS VEHICLES ORIGINALLY SOLD, OR CURRENTLY REGISTERED, IN 27 STATES (ALASKA, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA AND WISCONSIN) AND THE DISTRICT OF COLUMBIA.VEHICLES SOLD OR CURRENTLY REGISTERED OUTSIDE OF THESE STATES, APPROXIMATELY 185,000 MY 2005-2006 MINIVANS, ARE NOT INCLUDED IN THE RECALL.ALTHOUGH THESE VEHICLES USE THE SAME CRASH SENSORS AND WERE BUILT DURING THE SAME PERIOD AS THE ONES DESCRIBED ABOVE, THEY EXPERIENCE SIGNIFICANTLY LOWER FAILURE RATES BECAUSE OF REDUCED ROAD SALT EXPOSURE.ALSO, MY 2006-2007 MINIVANS BUILT AFTER APRIL 5, 2006, ARE NOT INCLUDED IN THE RECALL.THESE VEHICLES ARE EQUIPPED WITH FRONT CRASH SENSORS WITH CRASTIN BRAND PLASTIC HOUSINGS AND STEEL BUSHINGS AND EXPERIENCE SIGNIFICANTLY LOWER FAILURE RATES COMPARED TO THE RECALLED VEHICLES.NHTSA AND CHRYSLER DIFFER REGARDING THE SIGNIFICANCE AND IMPACT OF THE DEFECT, BUT IN THE INTEREST OF REMEDYING THE AFFECTED VEHICLES EXPEDITIOUSLY AND TO AVOID A PROTRACTED DISPUTE, CHRYSLER IS IMPLEMENTING STEPS TO REPLACE THE FRONT CRASH SENSORS.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED THAT FURTHER USE OF ITS RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THE SUBJECT VEHICLES.THE AGENCY WILL MONITOR THE ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SELECT DOCUMENT SEARCH FOR ADDITIONAL INFORMATION.
Air Bags:frontal:sensor/control MODULE-INACTIVE
CHRYSLER WILL REPLACE THE FRAME RAIL-MOUNTED FRONT AIR BAG CRASH SENSORS IN APPROXIMATELY 312,442 MODEL YEAR (MY) 2005 AND 2006 CHRYSLER MINIVANS (RECALL 10V-008).THESE VEHICLES ARE EQUIPPED WITH FRONT CRASH SENSORS WITH ULTRADUR BRAND PLASTIC HOUSINGS AND STEEL BUSHINGS AND WERE BUILT BETWEEN JANUARY 19, 2005 AND APRIL 5, 2006.THIS ACTION COVERS VEHICLES ORIGINALLY SOLD, OR CURRENTLY REGISTERED, IN 27 STATES (ALASKA, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA AND WISCONSIN) AND THE DISTRICT OF COLUMBIA.VEHICLES SOLD OR CURRENTLY REGISTERED OUTSIDE OF THESE STATES, APPROXIMATELY 185,000 MY 2005-2006 MINIVANS, ARE NOT INCLUDED IN THE RECALL.ALTHOUGH THESE VEHICLES USE THE SAME CRASH SENSORS AND WERE BUILT DURING THE SAME PERIOD AS THE ONES DESCRIBED ABOVE, THEY EXPERIENCE SIGNIFICANTLY LOWER FAILURE RATES BECAUSE OF REDUCED ROAD SALT EXPOSURE.ALSO, MY 2006-2007 MINIVANS BUILT AFTER APRIL 5, 2006, ARE NOT INCLUDED IN THE RECALL.THESE VEHICLES ARE EQUIPPED WITH FRONT CRASH SENSORS WITH CRASTIN BRAND PLASTIC HOUSINGS AND STEEL BUSHINGS AND EXPERIENCE SIGNIFICANTLY LOWER FAILURE RATES COMPARED TO THE RECALLED VEHICLES.NHTSA AND CHRYSLER DIFFER REGARDING THE SIGNIFICANCE AND IMPACT OF THE DEFECT, BUT IN THE INTEREST OF REMEDYING THE AFFECTED VEHICLES EXPEDITIOUSLY AND TO AVOID A PROTRACTED DISPUTE, CHRYSLER IS IMPLEMENTING STEPS TO REPLACE THE FRONT CRASH SENSORS.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED THAT FURTHER USE OF ITS RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THE SUBJECT VEHICLES.THE AGENCY WILL MONITOR THE ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SELECT DOCUMENT SEARCH FOR ADDITIONAL INFORMATION.
EA06003 · Front Air Bag Crash Sensor Failure
Opened Mar 8, 2006 · Closed May 22, 2007
Status: closed (inferred from source dates) · Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE
DAIMLERCHRYSLER (DCC) WILL REPLACE THE FRAME RAIL-MOUNTED FRONT AIR BAG CRASH SENSORS IN APPROXIMATELY 270,958 MY 2005 DAIMLERCHRYSLER MINIVANS (NHTSA RECALL NO. 07V-192).THESE VEHICLES ARE EQUIPPED WITH FRONT CRASH SENSORS WITH BRASS BUSHINGS AND WERE BUILT BETWEEN APRIL 24, 2003 AND FEBRUARY 2, 2005.THIS ACTION COVERS VEHICLES ORIGINALLY SOLD, OR CURRENTLY REGISTERED, IN 27 STATES (ALASKA, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA AND WISCONSIN) AND THE DISTRICT OF COLUMBIA.VEHICLES SOLD OR CURRENTLY REGISTERED OUTSIDE OF THESE STATES, APPROXIMATELY 133,128 MY 2005 MINIVANS, WILL RECEIVE A LIFETIME WARRANTY ON THE FRONT CRASH SENSORS.ALTHOUGH THESE VEHICLES USE THE SAME BRASS BUSHING SENSORS AND WERE BUILT DURING THE SAME PERIOD AS THE ONES DESCRIBED ABOVE, THEY EXPERIENCE SIGNIFICANTLY LOWER FAILURE RATES BECAUSE OF REDUCED ROAD SALT EXPOSURE.DCC WILL ALSO PROVIDE WRITTEN NOTIFICATION TO ALL AFFECTED VEHICLE OWNERS.NHTSA AND DCC DIFFER REGARDING THE SIGNIFICANCE AND IMPACT OF THE DEFECT, BUT IN THE INTEREST OF REMEDYING THE AFFECTED VEHICLES EXPEDITIOUSLY AND TO AVOID A PROTRACTED DISPUTE, DCC IS IMPLEMENTING STEPS TO REPLACE THE SUBJECT COMPONENTS.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED THAT FURTHER USE OF ITS RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THE SUBJECT VEHICLES.THE AGENCY WILL MONITOR THE ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SELECT DOCUMENT SEARCH FOR ADDITIONAL INFORMATION.
Additional source detail variants (2)
Air Bags:frontal
DAIMLERCHRYSLER (DCC) WILL REPLACE THE FRAME RAIL-MOUNTED FRONT AIR BAG CRASH SENSORS IN APPROXIMATELY 270,958 MY 2005 DAIMLERCHRYSLER MINIVANS (NHTSA RECALL NO. 07V-192).THESE VEHICLES ARE EQUIPPED WITH FRONT CRASH SENSORS WITH BRASS BUSHINGS AND WERE BUILT BETWEEN APRIL 24, 2003 AND FEBRUARY 2, 2005.THIS ACTION COVERS VEHICLES ORIGINALLY SOLD, OR CURRENTLY REGISTERED, IN 27 STATES (ALASKA, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA AND WISCONSIN) AND THE DISTRICT OF COLUMBIA.VEHICLES SOLD OR CURRENTLY REGISTERED OUTSIDE OF THESE STATES, APPROXIMATELY 133,128 MY 2005 MINIVANS, WILL RECEIVE A LIFETIME WARRANTY ON THE FRONT CRASH SENSORS.ALTHOUGH THESE VEHICLES USE THE SAME BRASS BUSHING SENSORS AND WERE BUILT DURING THE SAME PERIOD AS THE ONES DESCRIBED ABOVE, THEY EXPERIENCE SIGNIFICANTLY LOWER FAILURE RATES BECAUSE OF REDUCED ROAD SALT EXPOSURE.DCC WILL ALSO PROVIDE WRITTEN NOTIFICATION TO ALL AFFECTED VEHICLE OWNERS.NHTSA AND DCC DIFFER REGARDING THE SIGNIFICANCE AND IMPACT OF THE DEFECT, BUT IN THE INTEREST OF REMEDYING THE AFFECTED VEHICLES EXPEDITIOUSLY AND TO AVOID A PROTRACTED DISPUTE, DCC IS IMPLEMENTING STEPS TO REPLACE THE SUBJECT COMPONENTS.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED THAT FURTHER USE OF ITS RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THE SUBJECT VEHICLES.THE AGENCY WILL MONITOR THE ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SELECT DOCUMENT SEARCH FOR ADDITIONAL INFORMATION.
Air Bags:frontal:sensor/control MODULE-INACTIVE
DAIMLERCHRYSLER (DCC) WILL REPLACE THE FRAME RAIL-MOUNTED FRONT AIR BAG CRASH SENSORS IN APPROXIMATELY 270,958 MY 2005 DAIMLERCHRYSLER MINIVANS (NHTSA RECALL NO. 07V-192).THESE VEHICLES ARE EQUIPPED WITH FRONT CRASH SENSORS WITH BRASS BUSHINGS AND WERE BUILT BETWEEN APRIL 24, 2003 AND FEBRUARY 2, 2005.THIS ACTION COVERS VEHICLES ORIGINALLY SOLD, OR CURRENTLY REGISTERED, IN 27 STATES (ALASKA, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA AND WISCONSIN) AND THE DISTRICT OF COLUMBIA.VEHICLES SOLD OR CURRENTLY REGISTERED OUTSIDE OF THESE STATES, APPROXIMATELY 133,128 MY 2005 MINIVANS, WILL RECEIVE A LIFETIME WARRANTY ON THE FRONT CRASH SENSORS.ALTHOUGH THESE VEHICLES USE THE SAME BRASS BUSHING SENSORS AND WERE BUILT DURING THE SAME PERIOD AS THE ONES DESCRIBED ABOVE, THEY EXPERIENCE SIGNIFICANTLY LOWER FAILURE RATES BECAUSE OF REDUCED ROAD SALT EXPOSURE.DCC WILL ALSO PROVIDE WRITTEN NOTIFICATION TO ALL AFFECTED VEHICLE OWNERS.NHTSA AND DCC DIFFER REGARDING THE SIGNIFICANCE AND IMPACT OF THE DEFECT, BUT IN THE INTEREST OF REMEDYING THE AFFECTED VEHICLES EXPEDITIOUSLY AND TO AVOID A PROTRACTED DISPUTE, DCC IS IMPLEMENTING STEPS TO REPLACE THE SUBJECT COMPONENTS.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED THAT FURTHER USE OF ITS RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THE SUBJECT VEHICLES.THE AGENCY WILL MONITOR THE ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SELECT DOCUMENT SEARCH FOR ADDITIONAL INFORMATION.
PE05061 · Front Air Bag Crash Sensor Failure
Opened Nov 10, 2005 · Closed Mar 8, 2006
Status: closed (inferred from source dates) · Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE
THE MODEL YEAR (MY) 2005 DAIMLERCHRYSLER (DC) MINIVANS HAVE THE NEW ADVANCED FRONTAL AIR BAG SYSTEMS WITH TWO FRONT CRASH SENSORS MOUNTED ON THE FRAME RAILS BEHIND THE FRONT BUMPER AND A MAIN CRASH SENSOR INSIDE THE AIR BAG CONTROL MODULE MOUNTED IN THE PASSENGER COMPARTMENT.ACCORDING TO DC, THE FRONT CRASH SENSORS ARE DESIGNED TO OPTIMIZE DETECTION OF FRONTAL OFFSET AND ANGULAR CRASHES.THE ADVANCED AIR BAG SYSTEM OFFERS DIFFERENT LEVELS OF AIR BAG INFLATION BASED ON INPUT FROM THE CRASH SENSORS.THIS INVESTIGATION REVEALED THAT THE FRONT CRASH SENSORS CAN CORRODE FROM WATER ENTERING THE SENSOR ASSEMBLY.DC IS STILL INVESTIGATING ALL POTENTIAL ROOT CAUSES OF SENSOR FAILURES.A CORRODED SENSOR CAN SET A FAULT CODE, ILLUMINATE THE AIR BAG WARNING LAMP, AND BECOME DISABLED.IT APPEARS THAT FAILURE OF ONE OR BOTH FRONT CRASH SENSORS CAN POTENTIALLY RESULT IN NO/LATE DEPLOYMENT OF FRONTAL AIR BAGS AND NON-DEPLOYMENT OF DRIVER'S HIGHER INFLATION LEVELS IN CERTAIN FRONTAL CRASHES.IT SHOULD BE NOTED THAT OCCUPANTS OF VEHICLES INVOLVED IN A CRASH MAY NOT BE AWARE OF LATE OR IMPROPERLY REDUCED LEVEL OF AIR BAG INFLATION AND THUS FIELD REPORTING OF SUCH EVENTS MAY BE SUPPRESSED.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA06-003) FOR FURTHER INVESTIGATION OF MY 2005 (AND 2006) DC MINIVANS.NOTE: TOTAL NUMBER OF ODI AND MANUFACTURER COMPLAINTS INCLUDES SOME DUPLICATE REPORTS.
Additional source detail variants (2)
Air Bags:frontal
THE MODEL YEAR (MY) 2005 DAIMLERCHRYSLER (DC) MINIVANS HAVE THE NEW ADVANCED FRONTAL AIR BAG SYSTEMS WITH TWO FRONT CRASH SENSORS MOUNTED ON THE FRAME RAILS BEHIND THE FRONT BUMPER AND A MAIN CRASH SENSOR INSIDE THE AIR BAG CONTROL MODULE MOUNTED IN THE PASSENGER COMPARTMENT.ACCORDING TO DC, THE FRONT CRASH SENSORS ARE DESIGNED TO OPTIMIZE DETECTION OF FRONTAL OFFSET AND ANGULAR CRASHES.THE ADVANCED AIR BAG SYSTEM OFFERS DIFFERENT LEVELS OF AIR BAG INFLATION BASED ON INPUT FROM THE CRASH SENSORS.THIS INVESTIGATION REVEALED THAT THE FRONT CRASH SENSORS CAN CORRODE FROM WATER ENTERING THE SENSOR ASSEMBLY.DC IS STILL INVESTIGATING ALL POTENTIAL ROOT CAUSES OF SENSOR FAILURES.A CORRODED SENSOR CAN SET A FAULT CODE, ILLUMINATE THE AIR BAG WARNING LAMP, AND BECOME DISABLED.IT APPEARS THAT FAILURE OF ONE OR BOTH FRONT CRASH SENSORS CAN POTENTIALLY RESULT IN NO/LATE DEPLOYMENT OF FRONTAL AIR BAGS AND NON-DEPLOYMENT OF DRIVER'S HIGHER INFLATION LEVELS IN CERTAIN FRONTAL CRASHES.IT SHOULD BE NOTED THAT OCCUPANTS OF VEHICLES INVOLVED IN A CRASH MAY NOT BE AWARE OF LATE OR IMPROPERLY REDUCED LEVEL OF AIR BAG INFLATION AND THUS FIELD REPORTING OF SUCH EVENTS MAY BE SUPPRESSED.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA06-003) FOR FURTHER INVESTIGATION OF MY 2005 (AND 2006) DC MINIVANS.NOTE: TOTAL NUMBER OF ODI AND MANUFACTURER COMPLAINTS INCLUDES SOME DUPLICATE REPORTS.
Air Bags:frontal:sensor/control MODULE-INACTIVE
THE MODEL YEAR (MY) 2005 DAIMLERCHRYSLER (DC) MINIVANS HAVE THE NEW ADVANCED FRONTAL AIR BAG SYSTEMS WITH TWO FRONT CRASH SENSORS MOUNTED ON THE FRAME RAILS BEHIND THE FRONT BUMPER AND A MAIN CRASH SENSOR INSIDE THE AIR BAG CONTROL MODULE MOUNTED IN THE PASSENGER COMPARTMENT.ACCORDING TO DC, THE FRONT CRASH SENSORS ARE DESIGNED TO OPTIMIZE DETECTION OF FRONTAL OFFSET AND ANGULAR CRASHES.THE ADVANCED AIR BAG SYSTEM OFFERS DIFFERENT LEVELS OF AIR BAG INFLATION BASED ON INPUT FROM THE CRASH SENSORS.THIS INVESTIGATION REVEALED THAT THE FRONT CRASH SENSORS CAN CORRODE FROM WATER ENTERING THE SENSOR ASSEMBLY.DC IS STILL INVESTIGATING ALL POTENTIAL ROOT CAUSES OF SENSOR FAILURES.A CORRODED SENSOR CAN SET A FAULT CODE, ILLUMINATE THE AIR BAG WARNING LAMP, AND BECOME DISABLED.IT APPEARS THAT FAILURE OF ONE OR BOTH FRONT CRASH SENSORS CAN POTENTIALLY RESULT IN NO/LATE DEPLOYMENT OF FRONTAL AIR BAGS AND NON-DEPLOYMENT OF DRIVER'S HIGHER INFLATION LEVELS IN CERTAIN FRONTAL CRASHES.IT SHOULD BE NOTED THAT OCCUPANTS OF VEHICLES INVOLVED IN A CRASH MAY NOT BE AWARE OF LATE OR IMPROPERLY REDUCED LEVEL OF AIR BAG INFLATION AND THUS FIELD REPORTING OF SUCH EVENTS MAY BE SUPPRESSED.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA06-003) FOR FURTHER INVESTIGATION OF MY 2005 (AND 2006) DC MINIVANS.NOTE: TOTAL NUMBER OF ODI AND MANUFACTURER COMPLAINTS INCLUDES SOME DUPLICATE REPORTS.
Illustration