NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
164 reportsClear category filterMileage unknown · Nov 10, 2014
Electrical System
TL* THE CONTACT OWNS A 2008 CHRYSLER TOWN AND COUNTRY. THE CONTACT RECEIVED A NOTIFICATION FOR NHTSA CAMPAIGN ID NUMBER: 14V373000 (ELECTRICAL SYSTEM) AND STATED THAT THE PART NEEDED WAS UNAVAILABLE TO REPAIR THE VEHICLE. THE DEALER WAS UNABLE TO INFORM THE CONTACT OF WHEN THE PART WOULD BECOME AVAILABLE. THE MANUFACTURER WAS NO…
Read full complaint
TL* THE CONTACT OWNS A 2008 CHRYSLER TOWN AND COUNTRY. THE CONTACT RECEIVED A NOTIFICATION FOR NHTSA CAMPAIGN ID NUMBER: 14V373000 (ELECTRICAL SYSTEM) AND STATED THAT THE PART NEEDED WAS UNAVAILABLE TO REPAIR THE VEHICLE. THE DEALER WAS UNABLE TO INFORM THE CONTACT OF WHEN THE PART WOULD BECOME AVAILABLE. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.
NHTSA ODI #10653903
100,000 miles · Nov 5, 2014
Electrical SystemEngineSteering
MY CHRYSLER TOWN & COUNTRY CONSTANTLY HAS ISSUES WITH FLICKERING LIGHTS, WHACKED OUT SPEEDOMETER, ALL LIGHTS IN DASH GO HAYWIRE INCLUDING HEADLIGHTS. SOMETIMES THE ENGINE SHUTS DOWN TEMPORARILY WHILE DRIVING OR EVEN FAILS AT STOPLIGHTS. WELL A WHILE AGO I HAD TAKEN MY SON TO THE DOCTORS AND ON THE WAY HOME MY VAN STARTED ACTING …
Read full complaint
MY CHRYSLER TOWN & COUNTRY CONSTANTLY HAS ISSUES WITH FLICKERING LIGHTS, WHACKED OUT SPEEDOMETER, ALL LIGHTS IN DASH GO HAYWIRE INCLUDING HEADLIGHTS. SOMETIMES THE ENGINE SHUTS DOWN TEMPORARILY WHILE DRIVING OR EVEN FAILS AT STOPLIGHTS. WELL A WHILE AGO I HAD TAKEN MY SON TO THE DOCTORS AND ON THE WAY HOME MY VAN STARTED ACTING UP SO BAD THAT THE ENGINE COMPLETELY SHUT DOWN INCLUDING POWER STEERING AND CAUSED ME TO GO INTO THE NEXT LANE AND LUCKILY WE WEREN'T HIT BY ANOTHER DRIVER! AFTER SITTING THERE IN THE MIDDLE OF THE LANE DURING RUSH HOUR FOR ABOUT 10 MINUTES IT FINALLY DECIDED TO START UP BUT THIS IS NOW A CONSTANT ISSUE. AFTER SEEING SO MANY COMPLAINTS WITH THE SAME ISSUE I DON'T UNDERSTAND HOW THE MANUFACTURER IS GETTING AWAY WITH NO RECALL. I FEAR FOR MY SAFETY EVERY DAY AND HAVE ALREADY FORKED WAY TOO MUCH MONEY INTO IT TRYING TO FIND A SOLUTION TO THE PROBLEM. PLEASE ANYBODY HAVING THE SAME ISSUE PLEASE FILE A COMPLAINT IN HOPES THAT THEY WILL ISSUE A RECALL. THANKS *TR
NHTSA ODI #10652910
127,000 miles · Nov 3, 2014
Electrical SystemSeatsInjury
TL* THE CONTACT OWNS A 2005 CHRYSLER TOWN AND COUNTRY. THE CONTACT STATED THAT THE COIL THAT HEATS THE DRIVER SEAT BURNED A HOLE THROUGH THE SEAT. THE CONTACT SUSTAINED A BURN ON THE LEG THAT DID NOT REQUIRE MEDICAL ATTENTION. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROX…
Read full complaint
TL* THE CONTACT OWNS A 2005 CHRYSLER TOWN AND COUNTRY. THE CONTACT STATED THAT THE COIL THAT HEATS THE DRIVER SEAT BURNED A HOLE THROUGH THE SEAT. THE CONTACT SUSTAINED A BURN ON THE LEG THAT DID NOT REQUIRE MEDICAL ATTENTION. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 127,000.
NHTSA ODI #10652057
200,000 miles · Oct 20, 2014
Electrical SystemEngineVehicle Speed Control
MY HEADLIGHTS, ODOMETER & PRND21 BEGAN FLICKERING INTERMITTENTLY. CONDITION WORSENED AND GAUGES WOULD TURN OFF AND BACK ON, WARNING LIGHTS WOULD FLICKER OFF & ON, RADIO CUTS OUT. CONDITION HAS PROGRESSED - NOW VAN HAS STALLED OUT WHILE DRIVING THREE TIMES. BATTERY IS GOOD, GROUNDS ARE CONNECTED. THIS COMPLAINT SEEMS TO BE COMM…
Read full complaint
MY HEADLIGHTS, ODOMETER & PRND21 BEGAN FLICKERING INTERMITTENTLY. CONDITION WORSENED AND GAUGES WOULD TURN OFF AND BACK ON, WARNING LIGHTS WOULD FLICKER OFF & ON, RADIO CUTS OUT. CONDITION HAS PROGRESSED - NOW VAN HAS STALLED OUT WHILE DRIVING THREE TIMES. BATTERY IS GOOD, GROUNDS ARE CONNECTED. THIS COMPLAINT SEEMS TO BE COMMON, YET DEALERSHIPS DO NOT SEEM TO HAVE REPAIR INFORMATION FROM CHRYSLER. STALLING WHILE DRIVING IS DANGEROUS - CHRYSLER SHOULD HELP IDENTIFY A SOLUTION AND ISSUE A SERVICE BULLETIN. *TR
NHTSA ODI #10648979
129,850 miles · Oct 8, 2014
Electrical SystemExterior Lighting
WHILE DRIVING TO WORK MY HEADLIGHTS WENT OUT. I HAD TO TURN THE HEADLIGHT SWITCH OFF AND ON A FEW TIMES TO GET THE LIGHTS BACK. GOOD THING THAT I WAS JUST LEAVING TOWN AND NOT ON THE FREEWAY YET. *TR
NHTSA ODI #10643456
25,000 miles · Jul 12, 2014
Electrical SystemEngineFuel/propulsion System
WHENEVER WE FILL UP WITH GAS, SHORTLY AFTER PULLING OUT OF THE STATION THE ENGINE STALLS. SOMETIMES SOONER THAN LATER BUT SOMETIMES WHILE IN AN INTERSECTION. IT ALWAYS STARTS BACK UP AND PROBLEM GOES AWAY, BUT WHEN THE STALL HAPPENS IS UNPREDICTABLE. I FEAR FOR MY LIFE AS WELL AS MY FAMILIES LIFE. I'VE SEEN SEVERAL OTHER COMPLAI…
Read full complaint
WHENEVER WE FILL UP WITH GAS, SHORTLY AFTER PULLING OUT OF THE STATION THE ENGINE STALLS. SOMETIMES SOONER THAN LATER BUT SOMETIMES WHILE IN AN INTERSECTION. IT ALWAYS STARTS BACK UP AND PROBLEM GOES AWAY, BUT WHEN THE STALL HAPPENS IS UNPREDICTABLE. I FEAR FOR MY LIFE AS WELL AS MY FAMILIES LIFE. I'VE SEEN SEVERAL OTHER COMPLAINTS SIMILAR TO THIS AND MAYBE THERE IS A REPAIR WITH THIS BUT NONE ARE DEFINITE AND VERY EXPENSIVE. PLEASE HELP WITH ANY INFO. *TR
NHTSA ODI #10610024
Mileage unknown · Jun 30, 2014
Electrical System
ON MULTIPLE OCCASIONS WHEN I OWNED THIS VEHICLE, WHEN DRIVING HIGHWAY SPEEDS OVER 65 MPH THE CAR SUDDENLY LOST ALL POWER WHEN I HIT A BUMP IN THE ROAD COMPLETE WITH LOSS OF POWER STEERING. ALTHOUGH I WAS NOT IN AN ACCIDENT, THERE WERE MANY CLOSE CALLS INCLUDING ALMOST BEING HIT FROM BEHIND BY A TRACTOR TRAILER. SHAKEN, I CALLED …
Read full complaint
ON MULTIPLE OCCASIONS WHEN I OWNED THIS VEHICLE, WHEN DRIVING HIGHWAY SPEEDS OVER 65 MPH THE CAR SUDDENLY LOST ALL POWER WHEN I HIT A BUMP IN THE ROAD COMPLETE WITH LOSS OF POWER STEERING. ALTHOUGH I WAS NOT IN AN ACCIDENT, THERE WERE MANY CLOSE CALLS INCLUDING ALMOST BEING HIT FROM BEHIND BY A TRACTOR TRAILER. SHAKEN, I CALLED THE CAR AGENCY EVERY TIME I HAD AN EXPERIENCE AND BROUGHT THE VEHICLE IN AFTER EACH INCIDENT BOTH IN NJ AND IN SOUTH CAROLINA. ON EVERY OCCASION, I WAS TOLD THERE WAS NOTHING WRONG WITH THE CAR AND NO ERROR CODES WERE PRODUCED FROM THE COMPUTER. I QUESTIONED WHETHER THERE WERE ANY RECALLS OR BULLETINS, AND DEMANDED THAT A CHRYSLER REP. REVIEW THE COMPLAINTS, TO NO AVAIL. I HAVE SINCE TRADED IN THE VEHICLE FOR A KIA BUT FEEL COMPELLED TO REPORT THIS AFTER READING REPORTS ABOUT THIS FOR CARS 2007-2009. THIS PROBLEM EXTENDS FURTHER BACK THAN BEING REPORTED. *TR
NHTSA ODI #10607233
110,000 miles · May 22, 2014
Electrical SystemPower Train
MY 2005 CHRYSLER TOWN/COUNTRY CAME TO A COMPLETE STOP ON A RESIDENTIAL STREET AFTER MY HAND/PURSE RAN INTO THE KEY IN THE IGNITION. I COASTED TO A STOP. LUCKILY, SINCE IT WAS ON A SIDE STREET WITH NO ONE BEHIND ME I WAS ABLE TO REMAIN CALM, PUT IT INTO PARK AND STARTED THE VEHICLE BACK UP WITH NO PROBLEM. THERE HAS NOT BEEN A…
Read full complaint
MY 2005 CHRYSLER TOWN/COUNTRY CAME TO A COMPLETE STOP ON A RESIDENTIAL STREET AFTER MY HAND/PURSE RAN INTO THE KEY IN THE IGNITION. I COASTED TO A STOP. LUCKILY, SINCE IT WAS ON A SIDE STREET WITH NO ONE BEHIND ME I WAS ABLE TO REMAIN CALM, PUT IT INTO PARK AND STARTED THE VEHICLE BACK UP WITH NO PROBLEM. THERE HAS NOT BEEN A PROBLEM SINCE THEN. I HAVE MADE SURE TO LIGHTEN THE LOAD ON MY KEYCHAIN, ONLY HAVING 2 KEYS AND NOTHING ELSE. I CAN NOT IMAGINE WHAT WOULD HAVE HAPPENED HAD I BEEN ON THE FREEWAY GOING 70 MPH!!! THAT IS WHY I AM SUBMITTING THIS COMPLAINT. THE KEY SURELY SHOULD HAVE A SAFETY FEATURE BUILT INTO IT THAT WOULD NOT ALLOW IT TO TURN THE VEHICLE OFF WHILE IT IS BEING DRIVEN AND IN GEAR (DRIVE). A SIMPLE BUMP SHOULD NOT MAKE THAT KEY MOVE INTO A NON-DRIVABLE POSITION. I THINK A DEFECT LIKE THIS COULD INDEED CAUSE A FATAL CRASH AND NEEDS TO BE FIXED. MY DEALERSHIP ASSURES ME ALL MY RECALLS ARE UP TO DATE. *TR
NHTSA ODI #10593372
140,000 miles · May 14, 2014
Air BagsElectrical SystemFire
VEHICLE WAS RUNNING WHILE PARKED. SMOKE STARTED COMING FROM THE STEERING COLUMN AND AIR VENTS WITH A BURNING ELECTRICAL SMELL. GOT OUT OF CAR TO CHECK UNDER HOOD AND AIRBAG DEPLOYED. TURNED THE KEY OFF AND FOUND A FUSE IN THE FUSE BOX HAD MELTED. CAR WOULD THEN START, BUT DIE WITHIN SECONDS. THE POWER DOOR LOCKS AND RADIO W…
Read full complaint
VEHICLE WAS RUNNING WHILE PARKED. SMOKE STARTED COMING FROM THE STEERING COLUMN AND AIR VENTS WITH A BURNING ELECTRICAL SMELL. GOT OUT OF CAR TO CHECK UNDER HOOD AND AIRBAG DEPLOYED. TURNED THE KEY OFF AND FOUND A FUSE IN THE FUSE BOX HAD MELTED. CAR WOULD THEN START, BUT DIE WITHIN SECONDS. THE POWER DOOR LOCKS AND RADIO WOULD NOT WORK, BUT THE POWER WINDOWS WOULD. *TR
NHTSA ODI #10588313
102,000 miles · May 7, 2014
Electrical SystemLatches/locks/linkages
MY POWER LOCKS DO NOT WORK WITH THE FOB OR WITH THE INSIDE POWER LOCK BUTTON. I'VE READ SO MANY COMPLAINTS ONLINE ABOUT THIS EXACT ISSUE THAT IT IS ACTUALLY MAKING ME MORE ANGRY. THE DOOR LOOKS ARE A PRETTY BASIC FEATURE OF A VEHICLE. NOT TO MENTION THE FACT THAT PEOPLE DON'T NORMALLY BUY MINIVANS UNLESS THEY HAVE KIDS ETC. WE H…
Read full complaint
MY POWER LOCKS DO NOT WORK WITH THE FOB OR WITH THE INSIDE POWER LOCK BUTTON. I'VE READ SO MANY COMPLAINTS ONLINE ABOUT THIS EXACT ISSUE THAT IT IS ACTUALLY MAKING ME MORE ANGRY. THE DOOR LOOKS ARE A PRETTY BASIC FEATURE OF A VEHICLE. NOT TO MENTION THE FACT THAT PEOPLE DON'T NORMALLY BUY MINIVANS UNLESS THEY HAVE KIDS ETC. WE HAVE 3 KIDS AND NOT HAVING THIS DOOR LOCK FEATURE IS RIDICULOUS. BY THE WAY, IT MAKES THE AUTOMATIC OPENING DOORS PRETTY USELESS, BC THEY WON'T UNLOCK! *TR
NHTSA ODI #10586977
NHTSA investigations
7DP14002 · Engine Stall After Refueling
Opened Sep 5, 2014 · Closed Apr 6, 2015
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly
This defect petition evaluates July 7, 2014 allegations from an owner of a model year (MY) 2007 Dodge Grand Caravan minivan that engine stall occurs in these vehicles without warning after refueling.The petitioner's vehicle is a Chrysler RS platform minivan.The RS platform includes MY 2003 through 2007 Dodge Grand Caravan, Dodge Caravan, Chrysler Town and Country and Chrysler Voyager minivans.NHTSA evaluated the petition by analyzing consumer complaints submitted to the Agency, analyzing field data, reviewing technical information provided in Chrysler's response to an Agency information request and testing an RS minivan identified by its owner as experiencing post-refuel engine stalls.After completing this evaluation, NHTSA has concluded that further investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists.The stalls occurring in these vehicles only occur immediately after filling up the fuel tank and happen at low engine speeds. The failure rate is low, even after 8 to 13 years of the vehicles being in service, and there are no reports of crashes or injuries resulting from the stall condition.In the Agency's view, additional investigation is unlikely to result in finding the existence of a safety-related defect in the subject vehicles.Given the need to allocate and prioritize NHTSA's limited resources to best accomplish the Agency's safety mission, the petition is denied.This action does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency will take further action if warranted by future circumstances. More details concerning our review can be found in the Federal Register Notice for this action.The following 161 VOQs are included in the petition evaluation: 10209242, 10229468, 10240708, 10260923, 10275939, 10276532, 10296487, 10298175, 10328669, 10330144, 10346517, 10349789, 10354758, 10363689, 10372112, 10372368, 10372514, 10378031, 10379764, 10382938, 10387448, 10394063, 10398877, 10413918, 10418652, 10420924, 10427063, 10437525, 10445392, 10446902, 10470028, 10471249, 10473733, 10502231, 10503114, 10504260, 10509862, 10511988, 10512120, 10512385, 10512650, 10513147, 10538154, 10549841, 10551763, 10555188, 10555418, 10556754, 10565367, 10574012, 10574398, 10586555, 10587212, 10587559, 10593433, 10607841, 10607913, 10608922, 10615810, 10622468, 10628141, 10632112, 10632128, 10632172, 10632175, 10632231, 10632262, 10632266, 10632270, 10632305, 10632316, 10632326, 10632370, 10632385, 10632399, 10632492, 10632542, 10632765, 10632833, 10632928, 10633197, 10633281, 10633409, 10633421, 10633483, 10633507, 10637752, 10637804, 10637950, 10637975, 10638032, 10638289, 10638290, 10638401, 10638968, 10639218, 10639623, 10641157, 10641603, 10641614, 10641836, 10644339, 10644705, 10649713, 10649895, 10649932, 10650313, 10652590, 10653147, 10653783, 10654533, 10655226, 10658900, 10659679, 10660320, 10662588, 10662645, 10662662, 10663473, 10667056, 10667437, 10668081, 10668094, 10668131, 10668612, 10668969, 10668970, 10669584, 10669678, 10669729, 10669775, 10669866, 10669895, 10669992, 10670422, 10670506, 10676348, 10676732, 10677120, 10679795, 10679934, 10680057, 10680290, 10680342, 10680714, 10681512, 10682584, 10682906, 10683022, 10683114, 10683549, 10683620, 10683697, 10683743, 10689898, 10690761, 10691284, 10691556, 10691751, 10693061, 10694300
EA11010 · Loss Of Headlight Illumination
Opened Sep 6, 2011 · Closed Nov 29, 2012
Status: closed (inferred from source dates) · Electrical System; Exterior Lighting; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
The subject vehicle (SV) population includes MY 2005-2006 vehicles built between March 2004 and December 2005 manufactured with a TRW supplied headlight switch assembly (HSA).The HSA was the primary focus of the investigation; earlier and later vehicles utilized different HSAs.Consumers complain that the headlights in the subject vehicles do not illuminate when the HSA is turned on, or that the headlights extinguish while on (subject failure).No other driving lights are affected.The front marker, tail, and instrument lamps operate.Also, the high beams can be illuminated by holding the turn signal stalk in the up position.As reported by consumers, turning the HSA off and on typically corrects the failure.Initially the failures occur infrequently but they become progressively more frequent with age.Chrysler has indicated its intention to offer of an extended lifetime warranty on the HSA, so that consumers with this problem can have their HSA replaced at no charge when they begin experiencing the subject failure.Commencing sometime in early 2013, Chrysler will send letters to SV owners notifying them of the lifetime warranty.The SV headlight system design is essentially the same as that described in EA 05-009, which involved headlight anomalies in earlier model Chrysler minivans; refer to it to for additional information.The subject failure is caused by friction between the plastic cam and metal surfaces of the electrical contacts in the HSA, which results in the production of plastic particles (debris).Analysis shows that debris can collect on the electrical contact that controls the headlights, resulting in an open circuit and preventing the headlights from turning on.Subsequent operation of the HSA may temporarily displace the debris, at which time the headlights operate correctly.Lubricant was applied to the plastic cam beginning in December 2005, reducing debris production.Consequently, subsequent failure levels were lower.The report counts shown above include only those that involve the subject failure.Reports involving other failure modes which were identified have not been included either because they were not safety related, or if they were safety related, because there was no defect trend.The single crash event listed in the Failure Report Summary Table above involved a deer strike allegedly due to loss of headlights in February 2006.No injuries were reported in this crash.An April 2004 non-crash incident (?Other? above) involved a momentary loss of headlights.The consumer drove into a ditch, and one minor injury was alleged. The subject vehicles experienced a 2.2% warranty claim rate.While standing alone this would appear to be significant, a portion of these warranty claims likely involve other problems with the HSA unrelated to the subject failure.In view of the on road experience of drivers in rapidly restoring headlight illumination by turning the headlight switch off and on again, the rate and particularly the recent trend in problems with the switch, and Chrysler?s extended lifetime warranty coupled with the owner notification of that extended warranty, further investigation does not appear to be warranted.Accordingly, the investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.Details on Chrysler?s lifetime HSA warranty extension for the SV population will be available in the public file for this investigation.
Additional source detail variants (4)
Electrical System
The subject vehicle (SV) population includes MY 2005-2006 vehicles built between March 2004 and December 2005 manufactured with a TRW supplied headlight switch assembly (HSA).The HSA was the primary focus of the investigation; earlier and later vehicles utilized different HSAs.Consumers complain that the headlights in the subject vehicles do not illuminate when the HSA is turned on, or that the headlights extinguish while on (subject failure).No other driving lights are affected.The front marker, tail, and instrument lamps operate.Also, the high beams can be illuminated by holding the turn signal stalk in the up position.As reported by consumers, turning the HSA off and on typically corrects the failure.Initially the failures occur infrequently but they become progressively more frequent with age.Chrysler has indicated its intention to offer of an extended lifetime warranty on the HSA, so that consumers with this problem can have their HSA replaced at no charge when they begin experiencing the subject failure.Commencing sometime in early 2013, Chrysler will send letters to SV owners notifying them of the lifetime warranty.The SV headlight system design is essentially the same as that described in EA 05-009, which involved headlight anomalies in earlier model Chrysler minivans; refer to it to for additional information.The subject failure is caused by friction between the plastic cam and metal surfaces of the electrical contacts in the HSA, which results in the production of plastic particles (debris).Analysis shows that debris can collect on the electrical contact that controls the headlights, resulting in an open circuit and preventing the headlights from turning on.Subsequent operation of the HSA may temporarily displace the debris, at which time the headlights operate correctly.Lubricant was applied to the plastic cam beginning in December 2005, reducing debris production.Consequently, subsequent failure levels were lower.The report counts shown above include only those that involve the subject failure.Reports involving other failure modes which were identified have not been included either because they were not safety related, or if they were safety related, because there was no defect trend.The single crash event listed in the Failure Report Summary Table above involved a deer strike allegedly due to loss of headlights in February 2006.No injuries were reported in this crash.An April 2004 non-crash incident (?Other? above) involved a momentary loss of headlights.The consumer drove into a ditch, and one minor injury was alleged. The subject vehicles experienced a 2.2% warranty claim rate.While standing alone this would appear to be significant, a portion of these warranty claims likely involve other problems with the HSA unrelated to the subject failure.In view of the on road experience of drivers in rapidly restoring headlight illumination by turning the headlight switch off and on again, the rate and particularly the recent trend in problems with the switch, and Chrysler?s extended lifetime warranty coupled with the owner notification of that extended warranty, further investigation does not appear to be warranted.Accordingly, the investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.Details on Chrysler?s lifetime HSA warranty extension for the SV population will be available in the public file for this investigation.
Exterior Lighting
The subject vehicle (SV) population includes MY 2005-2006 vehicles built between March 2004 and December 2005 manufactured with a TRW supplied headlight switch assembly (HSA).The HSA was the primary focus of the investigation; earlier and later vehicles utilized different HSAs.Consumers complain that the headlights in the subject vehicles do not illuminate when the HSA is turned on, or that the headlights extinguish while on (subject failure).No other driving lights are affected.The front marker, tail, and instrument lamps operate.Also, the high beams can be illuminated by holding the turn signal stalk in the up position.As reported by consumers, turning the HSA off and on typically corrects the failure.Initially the failures occur infrequently but they become progressively more frequent with age.Chrysler has indicated its intention to offer of an extended lifetime warranty on the HSA, so that consumers with this problem can have their HSA replaced at no charge when they begin experiencing the subject failure.Commencing sometime in early 2013, Chrysler will send letters to SV owners notifying them of the lifetime warranty.The SV headlight system design is essentially the same as that described in EA 05-009, which involved headlight anomalies in earlier model Chrysler minivans; refer to it to for additional information.The subject failure is caused by friction between the plastic cam and metal surfaces of the electrical contacts in the HSA, which results in the production of plastic particles (debris).Analysis shows that debris can collect on the electrical contact that controls the headlights, resulting in an open circuit and preventing the headlights from turning on.Subsequent operation of the HSA may temporarily displace the debris, at which time the headlights operate correctly.Lubricant was applied to the plastic cam beginning in December 2005, reducing debris production.Consequently, subsequent failure levels were lower.The report counts shown above include only those that involve the subject failure.Reports involving other failure modes which were identified have not been included either because they were not safety related, or if they were safety related, because there was no defect trend.The single crash event listed in the Failure Report Summary Table above involved a deer strike allegedly due to loss of headlights in February 2006.No injuries were reported in this crash.An April 2004 non-crash incident (?Other? above) involved a momentary loss of headlights.The consumer drove into a ditch, and one minor injury was alleged. The subject vehicles experienced a 2.2% warranty claim rate.While standing alone this would appear to be significant, a portion of these warranty claims likely involve other problems with the HSA unrelated to the subject failure.In view of the on road experience of drivers in rapidly restoring headlight illumination by turning the headlight switch off and on again, the rate and particularly the recent trend in problems with the switch, and Chrysler?s extended lifetime warranty coupled with the owner notification of that extended warranty, further investigation does not appear to be warranted.Accordingly, the investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.Details on Chrysler?s lifetime HSA warranty extension for the SV population will be available in the public file for this investigation.
Exterior Lighting:headlights
The subject vehicle (SV) population includes MY 2005-2006 vehicles built between March 2004 and December 2005 manufactured with a TRW supplied headlight switch assembly (HSA).The HSA was the primary focus of the investigation; earlier and later vehicles utilized different HSAs.Consumers complain that the headlights in the subject vehicles do not illuminate when the HSA is turned on, or that the headlights extinguish while on (subject failure).No other driving lights are affected.The front marker, tail, and instrument lamps operate.Also, the high beams can be illuminated by holding the turn signal stalk in the up position.As reported by consumers, turning the HSA off and on typically corrects the failure.Initially the failures occur infrequently but they become progressively more frequent with age.Chrysler has indicated its intention to offer of an extended lifetime warranty on the HSA, so that consumers with this problem can have their HSA replaced at no charge when they begin experiencing the subject failure.Commencing sometime in early 2013, Chrysler will send letters to SV owners notifying them of the lifetime warranty.The SV headlight system design is essentially the same as that described in EA 05-009, which involved headlight anomalies in earlier model Chrysler minivans; refer to it to for additional information.The subject failure is caused by friction between the plastic cam and metal surfaces of the electrical contacts in the HSA, which results in the production of plastic particles (debris).Analysis shows that debris can collect on the electrical contact that controls the headlights, resulting in an open circuit and preventing the headlights from turning on.Subsequent operation of the HSA may temporarily displace the debris, at which time the headlights operate correctly.Lubricant was applied to the plastic cam beginning in December 2005, reducing debris production.Consequently, subsequent failure levels were lower.The report counts shown above include only those that involve the subject failure.Reports involving other failure modes which were identified have not been included either because they were not safety related, or if they were safety related, because there was no defect trend.The single crash event listed in the Failure Report Summary Table above involved a deer strike allegedly due to loss of headlights in February 2006.No injuries were reported in this crash.An April 2004 non-crash incident (?Other? above) involved a momentary loss of headlights.The consumer drove into a ditch, and one minor injury was alleged. The subject vehicles experienced a 2.2% warranty claim rate.While standing alone this would appear to be significant, a portion of these warranty claims likely involve other problems with the HSA unrelated to the subject failure.In view of the on road experience of drivers in rapidly restoring headlight illumination by turning the headlight switch off and on again, the rate and particularly the recent trend in problems with the switch, and Chrysler?s extended lifetime warranty coupled with the owner notification of that extended warranty, further investigation does not appear to be warranted.Accordingly, the investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.Details on Chrysler?s lifetime HSA warranty extension for the SV population will be available in the public file for this investigation.
Exterior Lighting:headlights:switch
The subject vehicle (SV) population includes MY 2005-2006 vehicles built between March 2004 and December 2005 manufactured with a TRW supplied headlight switch assembly (HSA).The HSA was the primary focus of the investigation; earlier and later vehicles utilized different HSAs.Consumers complain that the headlights in the subject vehicles do not illuminate when the HSA is turned on, or that the headlights extinguish while on (subject failure).No other driving lights are affected.The front marker, tail, and instrument lamps operate.Also, the high beams can be illuminated by holding the turn signal stalk in the up position.As reported by consumers, turning the HSA off and on typically corrects the failure.Initially the failures occur infrequently but they become progressively more frequent with age.Chrysler has indicated its intention to offer of an extended lifetime warranty on the HSA, so that consumers with this problem can have their HSA replaced at no charge when they begin experiencing the subject failure.Commencing sometime in early 2013, Chrysler will send letters to SV owners notifying them of the lifetime warranty.The SV headlight system design is essentially the same as that described in EA 05-009, which involved headlight anomalies in earlier model Chrysler minivans; refer to it to for additional information.The subject failure is caused by friction between the plastic cam and metal surfaces of the electrical contacts in the HSA, which results in the production of plastic particles (debris).Analysis shows that debris can collect on the electrical contact that controls the headlights, resulting in an open circuit and preventing the headlights from turning on.Subsequent operation of the HSA may temporarily displace the debris, at which time the headlights operate correctly.Lubricant was applied to the plastic cam beginning in December 2005, reducing debris production.Consequently, subsequent failure levels were lower.The report counts shown above include only those that involve the subject failure.Reports involving other failure modes which were identified have not been included either because they were not safety related, or if they were safety related, because there was no defect trend.The single crash event listed in the Failure Report Summary Table above involved a deer strike allegedly due to loss of headlights in February 2006.No injuries were reported in this crash.An April 2004 non-crash incident (?Other? above) involved a momentary loss of headlights.The consumer drove into a ditch, and one minor injury was alleged. The subject vehicles experienced a 2.2% warranty claim rate.While standing alone this would appear to be significant, a portion of these warranty claims likely involve other problems with the HSA unrelated to the subject failure.In view of the on road experience of drivers in rapidly restoring headlight illumination by turning the headlight switch off and on again, the rate and particularly the recent trend in problems with the switch, and Chrysler?s extended lifetime warranty coupled with the owner notification of that extended warranty, further investigation does not appear to be warranted.Accordingly, the investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.Details on Chrysler?s lifetime HSA warranty extension for the SV population will be available in the public file for this investigation.
AQ10001 · Fleet Vehicle Recall Completion Audit
Opened Nov 18, 2010 · Closed Dec 28, 2015
Status: closed (inferred from source dates) · Unknown Or Other
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.
PE10022 · Loss Of Headlight Illumination
Opened Jul 12, 2010 · Closed Sep 13, 2011
Status: closed (inferred from source dates) · Electrical System; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
To date, ODI has interviewed several complainants who confirmed that the headlights fully extinguish, and remain extinguished, on an intermittent basis.In most cases this occurred while the vehicle was in motion.The occurrences do not show a repeatable pattern, and the problem occurs at a low frequency, typically one or more weeks between failures.For this reason most complainants have not attempted diagnosis or repair of the problem, so the cause is unknown, and the problem continues to occur.In the cases where repairs have been attempted, which consisted mainly of headlight switch and body control module replacements, mixed success is reported.In interviews complainants advised ODI that they can usually toggle the headlight switch, or turn on the high beams by actuating the column stalk (pulling it upward), when the headlights unexpectedly turn off.Complainants report that toggling the switch is usually effective, and the high beams have always been available when the column is used.During the course of the interviews ODI was able to obtain a few suspect headlamp switches for further evaluation.No verifiable crashes or injuries have been identified in the vehicle owner complaints (VOQs).Chrysler notes that its complaints also include allegations of dimming or flickering of the headlights in addition to loss of headlamps, and that their analysis of available data indicates a declining trend occurring in the field.Chrysler data reports two alleged crash incidents; one where a consumers vehicle lost forward lighting and struck a deer, and one where a consumer alleged their lighting stopped working, causing them to depart the roadway and drive into a ditch.A minor injury is alleged in this second incident.Both incidents occurred several years ago, and neither allegation has been confirmed by ODI.ODI is upgrading this investigation to an Engineering Analysis (EA11-010) to continue its analysis of the alleged defect and its consequences, which will include additional analysis of consumer reports, their frequency and trend, and Chrysler's technical information for the headlight system and its components.Additionally testing will be conducted to evaluate possible root cause(s) of the alleged defect, and will include analysis of suspect components collected from the field, and/or assessment of subject vehicles that have reportedly experienced the condition.
Additional source detail variants (3)
Electrical System
To date, ODI has interviewed several complainants who confirmed that the headlights fully extinguish, and remain extinguished, on an intermittent basis.In most cases this occurred while the vehicle was in motion.The occurrences do not show a repeatable pattern, and the problem occurs at a low frequency, typically one or more weeks between failures.For this reason most complainants have not attempted diagnosis or repair of the problem, so the cause is unknown, and the problem continues to occur.In the cases where repairs have been attempted, which consisted mainly of headlight switch and body control module replacements, mixed success is reported.In interviews complainants advised ODI that they can usually toggle the headlight switch, or turn on the high beams by actuating the column stalk (pulling it upward), when the headlights unexpectedly turn off.Complainants report that toggling the switch is usually effective, and the high beams have always been available when the column is used.During the course of the interviews ODI was able to obtain a few suspect headlamp switches for further evaluation.No verifiable crashes or injuries have been identified in the vehicle owner complaints (VOQs).Chrysler notes that its complaints also include allegations of dimming or flickering of the headlights in addition to loss of headlamps, and that their analysis of available data indicates a declining trend occurring in the field.Chrysler data reports two alleged crash incidents; one where a consumers vehicle lost forward lighting and struck a deer, and one where a consumer alleged their lighting stopped working, causing them to depart the roadway and drive into a ditch.A minor injury is alleged in this second incident.Both incidents occurred several years ago, and neither allegation has been confirmed by ODI.ODI is upgrading this investigation to an Engineering Analysis (EA11-010) to continue its analysis of the alleged defect and its consequences, which will include additional analysis of consumer reports, their frequency and trend, and Chrysler's technical information for the headlight system and its components.Additionally testing will be conducted to evaluate possible root cause(s) of the alleged defect, and will include analysis of suspect components collected from the field, and/or assessment of subject vehicles that have reportedly experienced the condition.
Exterior Lighting:headlights
To date, ODI has interviewed several complainants who confirmed that the headlights fully extinguish, and remain extinguished, on an intermittent basis.In most cases this occurred while the vehicle was in motion.The occurrences do not show a repeatable pattern, and the problem occurs at a low frequency, typically one or more weeks between failures.For this reason most complainants have not attempted diagnosis or repair of the problem, so the cause is unknown, and the problem continues to occur.In the cases where repairs have been attempted, which consisted mainly of headlight switch and body control module replacements, mixed success is reported.In interviews complainants advised ODI that they can usually toggle the headlight switch, or turn on the high beams by actuating the column stalk (pulling it upward), when the headlights unexpectedly turn off.Complainants report that toggling the switch is usually effective, and the high beams have always been available when the column is used.During the course of the interviews ODI was able to obtain a few suspect headlamp switches for further evaluation.No verifiable crashes or injuries have been identified in the vehicle owner complaints (VOQs).Chrysler notes that its complaints also include allegations of dimming or flickering of the headlights in addition to loss of headlamps, and that their analysis of available data indicates a declining trend occurring in the field.Chrysler data reports two alleged crash incidents; one where a consumers vehicle lost forward lighting and struck a deer, and one where a consumer alleged their lighting stopped working, causing them to depart the roadway and drive into a ditch.A minor injury is alleged in this second incident.Both incidents occurred several years ago, and neither allegation has been confirmed by ODI.ODI is upgrading this investigation to an Engineering Analysis (EA11-010) to continue its analysis of the alleged defect and its consequences, which will include additional analysis of consumer reports, their frequency and trend, and Chrysler's technical information for the headlight system and its components.Additionally testing will be conducted to evaluate possible root cause(s) of the alleged defect, and will include analysis of suspect components collected from the field, and/or assessment of subject vehicles that have reportedly experienced the condition.
Exterior Lighting:headlights:switch
To date, ODI has interviewed several complainants who confirmed that the headlights fully extinguish, and remain extinguished, on an intermittent basis.In most cases this occurred while the vehicle was in motion.The occurrences do not show a repeatable pattern, and the problem occurs at a low frequency, typically one or more weeks between failures.For this reason most complainants have not attempted diagnosis or repair of the problem, so the cause is unknown, and the problem continues to occur.In the cases where repairs have been attempted, which consisted mainly of headlight switch and body control module replacements, mixed success is reported.In interviews complainants advised ODI that they can usually toggle the headlight switch, or turn on the high beams by actuating the column stalk (pulling it upward), when the headlights unexpectedly turn off.Complainants report that toggling the switch is usually effective, and the high beams have always been available when the column is used.During the course of the interviews ODI was able to obtain a few suspect headlamp switches for further evaluation.No verifiable crashes or injuries have been identified in the vehicle owner complaints (VOQs).Chrysler notes that its complaints also include allegations of dimming or flickering of the headlights in addition to loss of headlamps, and that their analysis of available data indicates a declining trend occurring in the field.Chrysler data reports two alleged crash incidents; one where a consumers vehicle lost forward lighting and struck a deer, and one where a consumer alleged their lighting stopped working, causing them to depart the roadway and drive into a ditch.A minor injury is alleged in this second incident.Both incidents occurred several years ago, and neither allegation has been confirmed by ODI.ODI is upgrading this investigation to an Engineering Analysis (EA11-010) to continue its analysis of the alleged defect and its consequences, which will include additional analysis of consumer reports, their frequency and trend, and Chrysler's technical information for the headlight system and its components.Additionally testing will be conducted to evaluate possible root cause(s) of the alleged defect, and will include analysis of suspect components collected from the field, and/or assessment of subject vehicles that have reportedly experienced the condition.
RQ09003 · Front Air Bag Crash Sensor Failure
Opened Jul 1, 2009 · Closed Feb 18, 2010
Status: closed (inferred from source dates) · Air Bags:frontal; Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:sensor/control MODULE-INACTIVE
CHRYSLER WILL REPLACE THE FRAME RAIL-MOUNTED FRONT AIR BAG CRASH SENSORS IN APPROXIMATELY 312,442 MODEL YEAR (MY) 2005 AND 2006 CHRYSLER MINIVANS (RECALL 10V-008).THESE VEHICLES ARE EQUIPPED WITH FRONT CRASH SENSORS WITH ULTRADUR BRAND PLASTIC HOUSINGS AND STEEL BUSHINGS AND WERE BUILT BETWEEN JANUARY 19, 2005 AND APRIL 5, 2006.THIS ACTION COVERS VEHICLES ORIGINALLY SOLD, OR CURRENTLY REGISTERED, IN 27 STATES (ALASKA, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA AND WISCONSIN) AND THE DISTRICT OF COLUMBIA.VEHICLES SOLD OR CURRENTLY REGISTERED OUTSIDE OF THESE STATES, APPROXIMATELY 185,000 MY 2005-2006 MINIVANS, ARE NOT INCLUDED IN THE RECALL.ALTHOUGH THESE VEHICLES USE THE SAME CRASH SENSORS AND WERE BUILT DURING THE SAME PERIOD AS THE ONES DESCRIBED ABOVE, THEY EXPERIENCE SIGNIFICANTLY LOWER FAILURE RATES BECAUSE OF REDUCED ROAD SALT EXPOSURE.ALSO, MY 2006-2007 MINIVANS BUILT AFTER APRIL 5, 2006, ARE NOT INCLUDED IN THE RECALL.THESE VEHICLES ARE EQUIPPED WITH FRONT CRASH SENSORS WITH CRASTIN BRAND PLASTIC HOUSINGS AND STEEL BUSHINGS AND EXPERIENCE SIGNIFICANTLY LOWER FAILURE RATES COMPARED TO THE RECALLED VEHICLES.NHTSA AND CHRYSLER DIFFER REGARDING THE SIGNIFICANCE AND IMPACT OF THE DEFECT, BUT IN THE INTEREST OF REMEDYING THE AFFECTED VEHICLES EXPEDITIOUSLY AND TO AVOID A PROTRACTED DISPUTE, CHRYSLER IS IMPLEMENTING STEPS TO REPLACE THE FRONT CRASH SENSORS.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED THAT FURTHER USE OF ITS RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THE SUBJECT VEHICLES.THE AGENCY WILL MONITOR THE ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SELECT DOCUMENT SEARCH FOR ADDITIONAL INFORMATION.
Additional source detail variants (3)
Air Bags:frontal
CHRYSLER WILL REPLACE THE FRAME RAIL-MOUNTED FRONT AIR BAG CRASH SENSORS IN APPROXIMATELY 312,442 MODEL YEAR (MY) 2005 AND 2006 CHRYSLER MINIVANS (RECALL 10V-008).THESE VEHICLES ARE EQUIPPED WITH FRONT CRASH SENSORS WITH ULTRADUR BRAND PLASTIC HOUSINGS AND STEEL BUSHINGS AND WERE BUILT BETWEEN JANUARY 19, 2005 AND APRIL 5, 2006.THIS ACTION COVERS VEHICLES ORIGINALLY SOLD, OR CURRENTLY REGISTERED, IN 27 STATES (ALASKA, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA AND WISCONSIN) AND THE DISTRICT OF COLUMBIA.VEHICLES SOLD OR CURRENTLY REGISTERED OUTSIDE OF THESE STATES, APPROXIMATELY 185,000 MY 2005-2006 MINIVANS, ARE NOT INCLUDED IN THE RECALL.ALTHOUGH THESE VEHICLES USE THE SAME CRASH SENSORS AND WERE BUILT DURING THE SAME PERIOD AS THE ONES DESCRIBED ABOVE, THEY EXPERIENCE SIGNIFICANTLY LOWER FAILURE RATES BECAUSE OF REDUCED ROAD SALT EXPOSURE.ALSO, MY 2006-2007 MINIVANS BUILT AFTER APRIL 5, 2006, ARE NOT INCLUDED IN THE RECALL.THESE VEHICLES ARE EQUIPPED WITH FRONT CRASH SENSORS WITH CRASTIN BRAND PLASTIC HOUSINGS AND STEEL BUSHINGS AND EXPERIENCE SIGNIFICANTLY LOWER FAILURE RATES COMPARED TO THE RECALLED VEHICLES.NHTSA AND CHRYSLER DIFFER REGARDING THE SIGNIFICANCE AND IMPACT OF THE DEFECT, BUT IN THE INTEREST OF REMEDYING THE AFFECTED VEHICLES EXPEDITIOUSLY AND TO AVOID A PROTRACTED DISPUTE, CHRYSLER IS IMPLEMENTING STEPS TO REPLACE THE FRONT CRASH SENSORS.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED THAT FURTHER USE OF ITS RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THE SUBJECT VEHICLES.THE AGENCY WILL MONITOR THE ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SELECT DOCUMENT SEARCH FOR ADDITIONAL INFORMATION.
Air Bags:frontal:driver Side:inflator Module
CHRYSLER WILL REPLACE THE FRAME RAIL-MOUNTED FRONT AIR BAG CRASH SENSORS IN APPROXIMATELY 312,442 MODEL YEAR (MY) 2005 AND 2006 CHRYSLER MINIVANS (RECALL 10V-008).THESE VEHICLES ARE EQUIPPED WITH FRONT CRASH SENSORS WITH ULTRADUR BRAND PLASTIC HOUSINGS AND STEEL BUSHINGS AND WERE BUILT BETWEEN JANUARY 19, 2005 AND APRIL 5, 2006.THIS ACTION COVERS VEHICLES ORIGINALLY SOLD, OR CURRENTLY REGISTERED, IN 27 STATES (ALASKA, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA AND WISCONSIN) AND THE DISTRICT OF COLUMBIA.VEHICLES SOLD OR CURRENTLY REGISTERED OUTSIDE OF THESE STATES, APPROXIMATELY 185,000 MY 2005-2006 MINIVANS, ARE NOT INCLUDED IN THE RECALL.ALTHOUGH THESE VEHICLES USE THE SAME CRASH SENSORS AND WERE BUILT DURING THE SAME PERIOD AS THE ONES DESCRIBED ABOVE, THEY EXPERIENCE SIGNIFICANTLY LOWER FAILURE RATES BECAUSE OF REDUCED ROAD SALT EXPOSURE.ALSO, MY 2006-2007 MINIVANS BUILT AFTER APRIL 5, 2006, ARE NOT INCLUDED IN THE RECALL.THESE VEHICLES ARE EQUIPPED WITH FRONT CRASH SENSORS WITH CRASTIN BRAND PLASTIC HOUSINGS AND STEEL BUSHINGS AND EXPERIENCE SIGNIFICANTLY LOWER FAILURE RATES COMPARED TO THE RECALLED VEHICLES.NHTSA AND CHRYSLER DIFFER REGARDING THE SIGNIFICANCE AND IMPACT OF THE DEFECT, BUT IN THE INTEREST OF REMEDYING THE AFFECTED VEHICLES EXPEDITIOUSLY AND TO AVOID A PROTRACTED DISPUTE, CHRYSLER IS IMPLEMENTING STEPS TO REPLACE THE FRONT CRASH SENSORS.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED THAT FURTHER USE OF ITS RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THE SUBJECT VEHICLES.THE AGENCY WILL MONITOR THE ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SELECT DOCUMENT SEARCH FOR ADDITIONAL INFORMATION.
Air Bags:frontal:sensor/control MODULE-INACTIVE
CHRYSLER WILL REPLACE THE FRAME RAIL-MOUNTED FRONT AIR BAG CRASH SENSORS IN APPROXIMATELY 312,442 MODEL YEAR (MY) 2005 AND 2006 CHRYSLER MINIVANS (RECALL 10V-008).THESE VEHICLES ARE EQUIPPED WITH FRONT CRASH SENSORS WITH ULTRADUR BRAND PLASTIC HOUSINGS AND STEEL BUSHINGS AND WERE BUILT BETWEEN JANUARY 19, 2005 AND APRIL 5, 2006.THIS ACTION COVERS VEHICLES ORIGINALLY SOLD, OR CURRENTLY REGISTERED, IN 27 STATES (ALASKA, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA AND WISCONSIN) AND THE DISTRICT OF COLUMBIA.VEHICLES SOLD OR CURRENTLY REGISTERED OUTSIDE OF THESE STATES, APPROXIMATELY 185,000 MY 2005-2006 MINIVANS, ARE NOT INCLUDED IN THE RECALL.ALTHOUGH THESE VEHICLES USE THE SAME CRASH SENSORS AND WERE BUILT DURING THE SAME PERIOD AS THE ONES DESCRIBED ABOVE, THEY EXPERIENCE SIGNIFICANTLY LOWER FAILURE RATES BECAUSE OF REDUCED ROAD SALT EXPOSURE.ALSO, MY 2006-2007 MINIVANS BUILT AFTER APRIL 5, 2006, ARE NOT INCLUDED IN THE RECALL.THESE VEHICLES ARE EQUIPPED WITH FRONT CRASH SENSORS WITH CRASTIN BRAND PLASTIC HOUSINGS AND STEEL BUSHINGS AND EXPERIENCE SIGNIFICANTLY LOWER FAILURE RATES COMPARED TO THE RECALLED VEHICLES.NHTSA AND CHRYSLER DIFFER REGARDING THE SIGNIFICANCE AND IMPACT OF THE DEFECT, BUT IN THE INTEREST OF REMEDYING THE AFFECTED VEHICLES EXPEDITIOUSLY AND TO AVOID A PROTRACTED DISPUTE, CHRYSLER IS IMPLEMENTING STEPS TO REPLACE THE FRONT CRASH SENSORS.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED THAT FURTHER USE OF ITS RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THE SUBJECT VEHICLES.THE AGENCY WILL MONITOR THE ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SELECT DOCUMENT SEARCH FOR ADDITIONAL INFORMATION.
EA06003 · Front Air Bag Crash Sensor Failure
Opened Mar 8, 2006 · Closed May 22, 2007
Status: closed (inferred from source dates) · Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE
DAIMLERCHRYSLER (DCC) WILL REPLACE THE FRAME RAIL-MOUNTED FRONT AIR BAG CRASH SENSORS IN APPROXIMATELY 270,958 MY 2005 DAIMLERCHRYSLER MINIVANS (NHTSA RECALL NO. 07V-192).THESE VEHICLES ARE EQUIPPED WITH FRONT CRASH SENSORS WITH BRASS BUSHINGS AND WERE BUILT BETWEEN APRIL 24, 2003 AND FEBRUARY 2, 2005.THIS ACTION COVERS VEHICLES ORIGINALLY SOLD, OR CURRENTLY REGISTERED, IN 27 STATES (ALASKA, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA AND WISCONSIN) AND THE DISTRICT OF COLUMBIA.VEHICLES SOLD OR CURRENTLY REGISTERED OUTSIDE OF THESE STATES, APPROXIMATELY 133,128 MY 2005 MINIVANS, WILL RECEIVE A LIFETIME WARRANTY ON THE FRONT CRASH SENSORS.ALTHOUGH THESE VEHICLES USE THE SAME BRASS BUSHING SENSORS AND WERE BUILT DURING THE SAME PERIOD AS THE ONES DESCRIBED ABOVE, THEY EXPERIENCE SIGNIFICANTLY LOWER FAILURE RATES BECAUSE OF REDUCED ROAD SALT EXPOSURE.DCC WILL ALSO PROVIDE WRITTEN NOTIFICATION TO ALL AFFECTED VEHICLE OWNERS.NHTSA AND DCC DIFFER REGARDING THE SIGNIFICANCE AND IMPACT OF THE DEFECT, BUT IN THE INTEREST OF REMEDYING THE AFFECTED VEHICLES EXPEDITIOUSLY AND TO AVOID A PROTRACTED DISPUTE, DCC IS IMPLEMENTING STEPS TO REPLACE THE SUBJECT COMPONENTS.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED THAT FURTHER USE OF ITS RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THE SUBJECT VEHICLES.THE AGENCY WILL MONITOR THE ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SELECT DOCUMENT SEARCH FOR ADDITIONAL INFORMATION.
Additional source detail variants (2)
Air Bags:frontal
DAIMLERCHRYSLER (DCC) WILL REPLACE THE FRAME RAIL-MOUNTED FRONT AIR BAG CRASH SENSORS IN APPROXIMATELY 270,958 MY 2005 DAIMLERCHRYSLER MINIVANS (NHTSA RECALL NO. 07V-192).THESE VEHICLES ARE EQUIPPED WITH FRONT CRASH SENSORS WITH BRASS BUSHINGS AND WERE BUILT BETWEEN APRIL 24, 2003 AND FEBRUARY 2, 2005.THIS ACTION COVERS VEHICLES ORIGINALLY SOLD, OR CURRENTLY REGISTERED, IN 27 STATES (ALASKA, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA AND WISCONSIN) AND THE DISTRICT OF COLUMBIA.VEHICLES SOLD OR CURRENTLY REGISTERED OUTSIDE OF THESE STATES, APPROXIMATELY 133,128 MY 2005 MINIVANS, WILL RECEIVE A LIFETIME WARRANTY ON THE FRONT CRASH SENSORS.ALTHOUGH THESE VEHICLES USE THE SAME BRASS BUSHING SENSORS AND WERE BUILT DURING THE SAME PERIOD AS THE ONES DESCRIBED ABOVE, THEY EXPERIENCE SIGNIFICANTLY LOWER FAILURE RATES BECAUSE OF REDUCED ROAD SALT EXPOSURE.DCC WILL ALSO PROVIDE WRITTEN NOTIFICATION TO ALL AFFECTED VEHICLE OWNERS.NHTSA AND DCC DIFFER REGARDING THE SIGNIFICANCE AND IMPACT OF THE DEFECT, BUT IN THE INTEREST OF REMEDYING THE AFFECTED VEHICLES EXPEDITIOUSLY AND TO AVOID A PROTRACTED DISPUTE, DCC IS IMPLEMENTING STEPS TO REPLACE THE SUBJECT COMPONENTS.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED THAT FURTHER USE OF ITS RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THE SUBJECT VEHICLES.THE AGENCY WILL MONITOR THE ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SELECT DOCUMENT SEARCH FOR ADDITIONAL INFORMATION.
Air Bags:frontal:sensor/control MODULE-INACTIVE
DAIMLERCHRYSLER (DCC) WILL REPLACE THE FRAME RAIL-MOUNTED FRONT AIR BAG CRASH SENSORS IN APPROXIMATELY 270,958 MY 2005 DAIMLERCHRYSLER MINIVANS (NHTSA RECALL NO. 07V-192).THESE VEHICLES ARE EQUIPPED WITH FRONT CRASH SENSORS WITH BRASS BUSHINGS AND WERE BUILT BETWEEN APRIL 24, 2003 AND FEBRUARY 2, 2005.THIS ACTION COVERS VEHICLES ORIGINALLY SOLD, OR CURRENTLY REGISTERED, IN 27 STATES (ALASKA, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA AND WISCONSIN) AND THE DISTRICT OF COLUMBIA.VEHICLES SOLD OR CURRENTLY REGISTERED OUTSIDE OF THESE STATES, APPROXIMATELY 133,128 MY 2005 MINIVANS, WILL RECEIVE A LIFETIME WARRANTY ON THE FRONT CRASH SENSORS.ALTHOUGH THESE VEHICLES USE THE SAME BRASS BUSHING SENSORS AND WERE BUILT DURING THE SAME PERIOD AS THE ONES DESCRIBED ABOVE, THEY EXPERIENCE SIGNIFICANTLY LOWER FAILURE RATES BECAUSE OF REDUCED ROAD SALT EXPOSURE.DCC WILL ALSO PROVIDE WRITTEN NOTIFICATION TO ALL AFFECTED VEHICLE OWNERS.NHTSA AND DCC DIFFER REGARDING THE SIGNIFICANCE AND IMPACT OF THE DEFECT, BUT IN THE INTEREST OF REMEDYING THE AFFECTED VEHICLES EXPEDITIOUSLY AND TO AVOID A PROTRACTED DISPUTE, DCC IS IMPLEMENTING STEPS TO REPLACE THE SUBJECT COMPONENTS.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED THAT FURTHER USE OF ITS RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THE SUBJECT VEHICLES.THE AGENCY WILL MONITOR THE ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SELECT DOCUMENT SEARCH FOR ADDITIONAL INFORMATION.
PE05061 · Front Air Bag Crash Sensor Failure
Opened Nov 10, 2005 · Closed Mar 8, 2006
Status: closed (inferred from source dates) · Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE
THE MODEL YEAR (MY) 2005 DAIMLERCHRYSLER (DC) MINIVANS HAVE THE NEW ADVANCED FRONTAL AIR BAG SYSTEMS WITH TWO FRONT CRASH SENSORS MOUNTED ON THE FRAME RAILS BEHIND THE FRONT BUMPER AND A MAIN CRASH SENSOR INSIDE THE AIR BAG CONTROL MODULE MOUNTED IN THE PASSENGER COMPARTMENT.ACCORDING TO DC, THE FRONT CRASH SENSORS ARE DESIGNED TO OPTIMIZE DETECTION OF FRONTAL OFFSET AND ANGULAR CRASHES.THE ADVANCED AIR BAG SYSTEM OFFERS DIFFERENT LEVELS OF AIR BAG INFLATION BASED ON INPUT FROM THE CRASH SENSORS.THIS INVESTIGATION REVEALED THAT THE FRONT CRASH SENSORS CAN CORRODE FROM WATER ENTERING THE SENSOR ASSEMBLY.DC IS STILL INVESTIGATING ALL POTENTIAL ROOT CAUSES OF SENSOR FAILURES.A CORRODED SENSOR CAN SET A FAULT CODE, ILLUMINATE THE AIR BAG WARNING LAMP, AND BECOME DISABLED.IT APPEARS THAT FAILURE OF ONE OR BOTH FRONT CRASH SENSORS CAN POTENTIALLY RESULT IN NO/LATE DEPLOYMENT OF FRONTAL AIR BAGS AND NON-DEPLOYMENT OF DRIVER'S HIGHER INFLATION LEVELS IN CERTAIN FRONTAL CRASHES.IT SHOULD BE NOTED THAT OCCUPANTS OF VEHICLES INVOLVED IN A CRASH MAY NOT BE AWARE OF LATE OR IMPROPERLY REDUCED LEVEL OF AIR BAG INFLATION AND THUS FIELD REPORTING OF SUCH EVENTS MAY BE SUPPRESSED.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA06-003) FOR FURTHER INVESTIGATION OF MY 2005 (AND 2006) DC MINIVANS.NOTE: TOTAL NUMBER OF ODI AND MANUFACTURER COMPLAINTS INCLUDES SOME DUPLICATE REPORTS.
Additional source detail variants (2)
Air Bags:frontal
THE MODEL YEAR (MY) 2005 DAIMLERCHRYSLER (DC) MINIVANS HAVE THE NEW ADVANCED FRONTAL AIR BAG SYSTEMS WITH TWO FRONT CRASH SENSORS MOUNTED ON THE FRAME RAILS BEHIND THE FRONT BUMPER AND A MAIN CRASH SENSOR INSIDE THE AIR BAG CONTROL MODULE MOUNTED IN THE PASSENGER COMPARTMENT.ACCORDING TO DC, THE FRONT CRASH SENSORS ARE DESIGNED TO OPTIMIZE DETECTION OF FRONTAL OFFSET AND ANGULAR CRASHES.THE ADVANCED AIR BAG SYSTEM OFFERS DIFFERENT LEVELS OF AIR BAG INFLATION BASED ON INPUT FROM THE CRASH SENSORS.THIS INVESTIGATION REVEALED THAT THE FRONT CRASH SENSORS CAN CORRODE FROM WATER ENTERING THE SENSOR ASSEMBLY.DC IS STILL INVESTIGATING ALL POTENTIAL ROOT CAUSES OF SENSOR FAILURES.A CORRODED SENSOR CAN SET A FAULT CODE, ILLUMINATE THE AIR BAG WARNING LAMP, AND BECOME DISABLED.IT APPEARS THAT FAILURE OF ONE OR BOTH FRONT CRASH SENSORS CAN POTENTIALLY RESULT IN NO/LATE DEPLOYMENT OF FRONTAL AIR BAGS AND NON-DEPLOYMENT OF DRIVER'S HIGHER INFLATION LEVELS IN CERTAIN FRONTAL CRASHES.IT SHOULD BE NOTED THAT OCCUPANTS OF VEHICLES INVOLVED IN A CRASH MAY NOT BE AWARE OF LATE OR IMPROPERLY REDUCED LEVEL OF AIR BAG INFLATION AND THUS FIELD REPORTING OF SUCH EVENTS MAY BE SUPPRESSED.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA06-003) FOR FURTHER INVESTIGATION OF MY 2005 (AND 2006) DC MINIVANS.NOTE: TOTAL NUMBER OF ODI AND MANUFACTURER COMPLAINTS INCLUDES SOME DUPLICATE REPORTS.
Air Bags:frontal:sensor/control MODULE-INACTIVE
THE MODEL YEAR (MY) 2005 DAIMLERCHRYSLER (DC) MINIVANS HAVE THE NEW ADVANCED FRONTAL AIR BAG SYSTEMS WITH TWO FRONT CRASH SENSORS MOUNTED ON THE FRAME RAILS BEHIND THE FRONT BUMPER AND A MAIN CRASH SENSOR INSIDE THE AIR BAG CONTROL MODULE MOUNTED IN THE PASSENGER COMPARTMENT.ACCORDING TO DC, THE FRONT CRASH SENSORS ARE DESIGNED TO OPTIMIZE DETECTION OF FRONTAL OFFSET AND ANGULAR CRASHES.THE ADVANCED AIR BAG SYSTEM OFFERS DIFFERENT LEVELS OF AIR BAG INFLATION BASED ON INPUT FROM THE CRASH SENSORS.THIS INVESTIGATION REVEALED THAT THE FRONT CRASH SENSORS CAN CORRODE FROM WATER ENTERING THE SENSOR ASSEMBLY.DC IS STILL INVESTIGATING ALL POTENTIAL ROOT CAUSES OF SENSOR FAILURES.A CORRODED SENSOR CAN SET A FAULT CODE, ILLUMINATE THE AIR BAG WARNING LAMP, AND BECOME DISABLED.IT APPEARS THAT FAILURE OF ONE OR BOTH FRONT CRASH SENSORS CAN POTENTIALLY RESULT IN NO/LATE DEPLOYMENT OF FRONTAL AIR BAGS AND NON-DEPLOYMENT OF DRIVER'S HIGHER INFLATION LEVELS IN CERTAIN FRONTAL CRASHES.IT SHOULD BE NOTED THAT OCCUPANTS OF VEHICLES INVOLVED IN A CRASH MAY NOT BE AWARE OF LATE OR IMPROPERLY REDUCED LEVEL OF AIR BAG INFLATION AND THUS FIELD REPORTING OF SUCH EVENTS MAY BE SUPPRESSED.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA06-003) FOR FURTHER INVESTIGATION OF MY 2005 (AND 2006) DC MINIVANS.NOTE: TOTAL NUMBER OF ODI AND MANUFACTURER COMPLAINTS INCLUDES SOME DUPLICATE REPORTS.
Illustration