NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
39 reportsClear category filter167,000 miles · Feb 21, 2008
Engine And Engine Cooling
TL*THE CONTACT OWNS A 1996 CHRYSLER SEBRING. WHILE DRIVING AT AN UNKNOWN SPEED, THE ENGINE WARNING LIGHT ILLUMINATED ON THE INSTRUMENT CONTROL PANEL. THE VEHICLE THEN IMMEDIATELY STALLED. SEVERAL MINUTES LATER, THE VEHICLE RESTARTED. THE DEALER REPLACED THE CAM SHAFT SENSOR AND THE BATTERY. THE VEHICLE FAILED AN EMISSIONS T…
Read full complaint
TL*THE CONTACT OWNS A 1996 CHRYSLER SEBRING. WHILE DRIVING AT AN UNKNOWN SPEED, THE ENGINE WARNING LIGHT ILLUMINATED ON THE INSTRUMENT CONTROL PANEL. THE VEHICLE THEN IMMEDIATELY STALLED. SEVERAL MINUTES LATER, THE VEHICLE RESTARTED. THE DEALER REPLACED THE CAM SHAFT SENSOR AND THE BATTERY. THE VEHICLE FAILED AN EMISSIONS TEST DUE TO SMOG. THE DEALER REPROGRAMMED THE PCM. ON FEBRUARY 21, 2008, THE VEHICLE HAD A SECOND EMISSIONS TEST AND FAILED AGAIN DUE TO SMOG. THE FAILURE MILEAGE WAS 167,000 AND CURRENT MILEAGE WAS 204,083.
NHTSA ODI #10218810
28,000 miles · Jan 15, 2004
Engine And Engine CoolingService Brakes, HydraulicTires
ON THE ENGINE I HAD THE PULLEY ON THE TIMING BELT COME APART AND JUST LAST MONTH I HAD THE HEAD GASKET START TO LEAK FROM THE BACK. TIMING BELT 28,000 HEAD GASKET 37,500. I HAVE HAD TO REPLACE ALL 4 TIRES THAT WHERE ON THE CAR. ALL BY 29,000 MILES--SOME EARLIER AND THEN LATER. THE BRAKES WERE REPLACES AT THE SAME TIME AS T…
Read full complaint
ON THE ENGINE I HAD THE PULLEY ON THE TIMING BELT COME APART AND JUST LAST MONTH I HAD THE HEAD GASKET START TO LEAK FROM THE BACK. TIMING BELT 28,000 HEAD GASKET 37,500. I HAVE HAD TO REPLACE ALL 4 TIRES THAT WHERE ON THE CAR. ALL BY 29,000 MILES--SOME EARLIER AND THEN LATER. THE BRAKES WERE REPLACES AT THE SAME TIME AS THE TIMING BELT PULLEY. I KNEW THEY NEEDED REPLACEMENT AND HAD AN APPOINTMENT TO GET THEM REPLACED WHEN THE TIMEING BELT WENT OUT. IT IS A 1996 BUT I ONLY HAVE 37,500 MILES.
NHTSA ODI #10069961
46,805 miles · Jan 15, 2004
Engine And Engine CoolingStructureSuspension
2.4 HEAD GASKET. EXHAUST MANIFOLD. MILEAGE ILLUMINATION. POPPING NOISE FRONT SUSPENSION. RATTLE REAR SUSPENSION, POPING WHEN LFT DOOR GLASS WINDOW PUT UP.LOW FUEL LITE . CAR ONLY HAS 46805 MILES WHEN YOU CAN READ MILEAGE
NHTSA ODI #10068722
29,000 miles · Jul 31, 2003
Engine And Engine Cooling
PROBLEMS WITH MY 1996 CHRYSLER SEBRING. IT GOES THRO TONS OF OIL, I KEEP HAVING TO ADD OIL TO THE CAR, EVERYTHING HAS BEEN BREAKING ON IT. NOW IT PERIODICALLY STALLS OUT NON STOP. THERE IS ONLY 85K MILES ON THE CAR AND IT SHOULD NOT BE HAVING THESE PROBLEMS. I HAVE PUT IN THOUSANDS OF DOLLARS INTO THIS CAR FOR REPAIRS. IT…
Read full complaint
PROBLEMS WITH MY 1996 CHRYSLER SEBRING. IT GOES THRO TONS OF OIL, I KEEP HAVING TO ADD OIL TO THE CAR, EVERYTHING HAS BEEN BREAKING ON IT. NOW IT PERIODICALLY STALLS OUT NON STOP. THERE IS ONLY 85K MILES ON THE CAR AND IT SHOULD NOT BE HAVING THESE PROBLEMS. I HAVE PUT IN THOUSANDS OF DOLLARS INTO THIS CAR FOR REPAIRS. IT WAS UNDER WARRANTY BY CHRYSLER AND I TOOK IT IN FOR THE OIL ISSUE AND THEY SAID THEY SAW NO PROBLEM, THAT WARRANTY RAN OUT AND MY EXTENDED ONE KICKED IN AND THEY SAID IT HAD OIL LEAKS AND KEPT 'FIXING' THEM. ONCE THAT WARRANTY RAN OUT THEY CHANGED THEIR STORY TO 'THE ENGINE IS CONSUMING THE OIL, THAT'S NOT UNDER WARRANTY'. MEANWHILE I AM LEFT WITH A HORRID CAR THAT WONT RUN. *PH
NHTSA ODI #10030498
Mileage unknown · Apr 25, 2002
Engine And Engine CoolingFuel System, GasolineVisibility
VEHICLE STALLS INTERMITTENTLY, MOSTLY WHEN SLOWING DOWN AND USING ELECTRICAL PART, SUCH AS POWER WINDOWS. DEALER REPLACED FUEL PUMP, BUT IT DID NOT REMEDY THE PROBLEM. *AK
NHTSA ODI #8008616
Mileage unknown · Mar 6, 2002
Engine And Engine Cooling
ENGINE BLEWOUT AND VEHICLE BECAME INOPERABLE. CONTACTED DEALER, AND DEALER WAS NOT WILLING TO DO ANYTHING.*AK
NHTSA ODI #8005071
Mileage unknown · Mar 5, 2002
Engine And Engine Cooling
WHILE DRIVING, CONSUMER SMELLED OIL BURNING WHICH SEEMED TO BE COMING FROM THE ENGINE, VEHICLE WAS SERVICED AND TECHNICIAN NOTICED THAT ENGINE HEAD GASKET NEEDED TO BE REPLACED.*AK. CONSUMER STATED OIL WAS LEAKING FROM THE HEAD GASKET.*JB
NHTSA ODI #8004964
Mileage unknown · Jan 26, 2002
Engine And Engine Cooling
THIS IS THE FIFTH ENGINE IN THE RALEIGH AREA THAT HAS HAD THIS FAILURE BETWEEN 60000 AND 80000 MILES, IT IS SIMILAR TO THE FAILURE NOTED WITH THE SIMILAR NEON ENGINE, AND A TECHNICAL BULLETIN HAS BEEN RELEASED. *AK
NHTSA ODI #757360
Mileage unknown · Aug 29, 2001
Engine And Engine Cooling
RADIATOR: THE WHOLE INSIDE OF THE PIPES; HOSES; RADIATOR IS RUSTED. EVERY TIME I GET AN OIL CHANGE I MUST GET MY RADIATOR FLUSHED AND THE COOLANT IS COMPLETELY RUST COLOR. IT TAKES ABOUT 6 FLUSHES FOR IT TO BE CLEAR AGAIN. THIS IS ABNORMAL FOR A CAR WITH ONLY 86000 MILES ON IT. I WANT ALL THE HOSES AND RADIATOR REPLACED FRE…
Read full complaint
RADIATOR: THE WHOLE INSIDE OF THE PIPES; HOSES; RADIATOR IS RUSTED. EVERY TIME I GET AN OIL CHANGE I MUST GET MY RADIATOR FLUSHED AND THE COOLANT IS COMPLETELY RUST COLOR. IT TAKES ABOUT 6 FLUSHES FOR IT TO BE CLEAR AGAIN. THIS IS ABNORMAL FOR A CAR WITH ONLY 86000 MILES ON IT. I WANT ALL THE HOSES AND RADIATOR REPLACED FREE OF CHARGE. CONVERTIBLE TOP: ALL THE SEEMS HAVE COME UNSTITCHED...I'VE HAD TO GLUE THEM WITH SPECIAL GLUE. THE EDGING AROUND THE WINDOWS LEAKS. THIS SHOULD NOT HAPPEN!
NHTSA ODI #751353
Mileage unknown · Jul 16, 2001
Engine And Engine Cooling
VEHICLE STALLS AT ANY SPEED AND AT ANY TIME. VEHICLE WAS AT DEALER'S 20 TIMES. CANNOT REMEDY PROBLEM. *AK
NHTSA ODI #892834
Official recalls
7Jul 8, 2002
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.5L V6 ENGINES, THE THROTTLE CONTROL CABLE CAN FRAY CAUSING THE THROTTLE TO BIND OR STICK.
Consequence & remedy
Consequence: THIS COULD POTENTIALLY RESULT IN A LOSS OF THROTTLE CONTROL, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE THROTTLE CABLE ASSEMBLY. OWNER NOTIFICATION BEGAN AUGUST 5, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Dec 18, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. IF THE RUBBER BOOTS ON THE LOWER LATERAL ARM BALL JOINTS OF THE FRONT SUSPENSION WERE DAMAGED DURING ASSEMBLY, DIRT AND WATER CAN INTRUDE. ALSO, MMC HAS ADDED THE POTENTIAL OF LEAKING MOISTURE, WHICH CAN CAUSE THE BALL STUD TO CORRODE.
Consequence & remedy
Consequence: THIS CONDITION COULD CAUSE THE LOWER LATERAL ARM BALL JOINT TO SEPARATE, INCREASING THE RISK OF A VEHICLE CRASH. THIS CAMPAIGN SUPERCEDES MMC'S PREVIOUS SAFETY RECALL CAMPAIGN, SEE 99V-066.
Remedy: DEALERS WILL INSPECT THE LOWER LATERAL ARM BALL JOINT FOR WEAR. BALL JOINTS THAT EXHIBIT WEAR BEYOND THE ESTABLISHED TOLERANCE WILL BE REPLACED WITH NEWLY DESIGNED LATERAL ARM BALL JOINTS. BALL JOINTS THAT ARE WITHIN THE ESTABLISHED TOLERANCE WILL BE CLEANED AND A SPECIAL SEALANT WILL BE APPLIED TO PREVENT INTRUSION OF MOISTURE.
Apr 5, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES. IF THE RUBBER BOOTS ON THE LOWER LATERAL ARM BALL JOINTS OF THE FRONT SUSPENSION WERE DAMAGED DURING ASSEMBLY, DIRT AND WATER CAN INTRUDE.
Consequence & remedy
Consequence: THIS CONDITION COULD CAUSE THE LOWER LATERAL ARM BALL JOINT TO SEPARATE, INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL INSPECT THE RUBBER BOOTS, AND IF THE BOOT IS DAMAGED, THEY WILL REPLACE THE LOWER LATERAL ARM AND BALL JOINT ON THE AFFECTED VEHICLES.
Aug 6, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS. THE ADJUSTMENT OF THE CABLE CONNECTING THE CONSOLE SHIFTER MECHANISM TO THE IGNITION KEY CAN CAUSE A TRAPPED KEY CONDITION WHICH CAN RESULT IN A LOW FORCE REQUIRED TO DEPRESS THE SHIFT BUTTON. A COMBINATION OF APPLYING A MIS-ADJUSTED RELEASE BUTTON WITH A LOW FORCE ATTEMPT TO SHIFT OUT OF PARK WITH THE KEY IN THE LOCKED POSITION, CAN BREAK THE CONNECTING PIN IN THE SHIFTER.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE "IGNITION-PARK" INTERLOCK SYSTEM WILL BE NONFUNCTIONAL.
Remedy: DEALERS WILL INSPECT FOR PROPER OPERATION OF THE SYSTEM. ANY VEHICLES THAT ARE NOT FUNCTIONAL AFTER THE INSPECTION WILL HAVE THE SHIFT MECHANISM AND CABLE REPLACED WITH A "SELF-ADJUSTING" DESIGN.
Nov 13, 1997
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE LOWER CONTROL ARM BALL JOINT CAN SEPARATE DUE TO LOSS OF LUBRICATION.
Consequence & remedy
Consequence: SEPARATION OF THE BALL JOINT COULD CAUSE A LOSS OF STEERING CONTROL INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL INSPECT THE BALL JOINT END HOUSING COVER SEAL FOR LEAKAGE WITH A HIGH PRESSURE AIR TESTER AND THE RUBBER BOOT WILL BE VISUALLY INSPECTED FOR DAMAGE. IF THE COVER SEAL LEAKS OR THE BOOT IS DAMAGED, THE LOWER CONTROL ARM WILL BE REPLACED.
Feb 10, 1997
THE ELECTRICAL CONTACTS IN THE POWER MIRROR SWITCH CAN ACCUMULATE ROAD SALT DUE TO WATER ENTERING INTO THE SWITCH.
Consequence & remedy
Consequence: THIS CAN RESULT IN A HIGH RESISTANCE SHORT CIRCUIT AND POSSIBLY CAUSE A VEHICLE FIRE.
Remedy: DEALERS WILL REPLACE THE POWER MIRROR SWITCH WITH A NEWLY DESIGNED SWITCH.
Jul 2, 1996
THE POWER BRAKE BOOSTER VACUUM HOSE WAS IMPROPERLY INSTALLED ON THE INTAKE MANIFOLD VACUUM NIPPLE.
Consequence & remedy
Consequence: A DISCONNECTED VACUUM HOSE CAUSES AN INCREASE IN ENGINE IDLE SPEED AND LOSS OF POWER ASSIST DURING BRAKE APPLICATION INCREASING THE RISK OF A VEHICLE ACCIDENT.
Remedy: DEALERS WILL FULLY INSTALL THE INTAKE MANIFOLD VACUUM HOSE TO THE VACUUM NIPPLE ON THE INTAKE MANIFOLD.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5PE02082 · Safety Belt Cinching Latch Plate
Opened Nov 6, 2002 · Closed Apr 23, 2003
Status: closed (inferred from source dates) · Seat Belts
THERE ARE NO INJURIES OR FATALITIES ASSOCIATED WITH THIS ALLEGED DEFECT.WHILE CONDUCTING THIS INVESTIGATION, ODI FOUND THAT THE SUBJECT CINCHES MEET THE LOAD BEARING REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD 208, AND THAT MANY OF THE REPORTED FAILURES WERE DUE TO INCORRECT CHILD SAFETY SEAT INSTALLATIONS. ADDITIONALLY, THE REPORT RATE IS LOW (1.60/100K).THE INFORMATION AVAILABLE FAILS TO ESTABLISH THE EXISTENCE OF A DEFECT TREND AT THIS TIME.FURTHER ALLOCATION OF AGENCY RESOURCES TO THIS ISSUE IS UNWARRANTED AND THE PRELIMINARY EVALUATION IS BEING CLOSED.
RQ00015 · Lower Contrtol Arm Ball Joint
Opened Aug 2, 2000 · Closed Apr 20, 2001
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
Additional source detail variants (3)
Suspension
There is no summary currently available
Suspension
There is no summary currently available
Suspension
There is no summary currently available
EA98014 · Automatic Transaxle Ignition Interlock
Opened May 29, 1998 · Closed Sep 14, 1998
Status: closed (inferred from source dates) · Power Train
ALLEGED FAILURE OF THE AUTOMATIC TRANSAXLE IGNITION INTERLOCK SYSTEM THAT EITHER ALLOWS THE IGNITION KEY TO BE REMOVED WHEN THE TRANSMISSION GEAR SELECTOR IS NOT IN THE PARK POSITION AND THE TRANSMISSION GEAR SELECTOR TO BE SHIFTED WHEN THE IGNITION KEY IS REMOVED OR PREVENTS THEIGNITION KEY FROM BEING REMOVED WHEN THE TRANSMISSION GEAR SELECTOR IS IN THE PARK, OR ANY OTHER, POSITION.
EA97025 · Convertible Top Cover Disengagement
Opened Nov 24, 1997 · Closed Nov 17, 1998
Status: closed (inferred from source dates) · Structure
ALLEGED THAT THE CONVERTIBLE TOP COVER MAY DISENGAGE FROM THE SUBJECT VEHICLES WHILE DRIVING.
PE97029 · Convertible Top Cover Disengagement
Opened Jun 17, 1997 · Closed Nov 24, 1997
Status: closed (inferred from source dates) · Structure
ODI HAS RECEIVED THREE REPORTS ALLEGING DISENGAGEMENT OF THE CONVERTIBLE TOP COVER FROM THE SUBJECT VEHICLES WHILE DRIVING.
Illustration