ENGINE CUTS OUT WHILE DRIVING AT ANY SPEED. SOMETIMES IMMEDIATELY RESUMES, SOMETIMES CAR SITS FOR UP TO 45 MINUTES TO PRESUMABLY COOL OFF. STARTED TO HAPPEN ONCE PER WEEK, AND WITHIN A FEW WEEKS WAS ONCE PER DAY. PRESENTS A PROBLEM WHILE DRIVING AT HIGH SPEED ON THE HIGHWAY OR MAKING LOCAL ROAD MANEUVERS AS POWER STEERING AND PO…
Read full complaint
ENGINE CUTS OUT WHILE DRIVING AT ANY SPEED. SOMETIMES IMMEDIATELY RESUMES, SOMETIMES CAR SITS FOR UP TO 45 MINUTES TO PRESUMABLY COOL OFF. STARTED TO HAPPEN ONCE PER WEEK, AND WITHIN A FEW WEEKS WAS ONCE PER DAY. PRESENTS A PROBLEM WHILE DRIVING AT HIGH SPEED ON THE HIGHWAY OR MAKING LOCAL ROAD MANEUVERS AS POWER STEERING AND POWER BRAKES LOOSE POWER. MECHANIC EXAMINED AND CONCLUDED THE FUEL PUMP AND OR FUEL PUMP WIRING WAS FAULTY. *TR
NHTSA ODI #10421421
81,000 miles · Aug 3, 2009
Fuel System, GasolineFire
TL*THE CONTACT OWNS A 1999 CHRYSLER SEBRING CONVERTIBLE. WHILE DRIVING 30 MPH, THE VEHICLE SUDDENLY STALLED AND ALMOST CAUSED A CRASH. THE CONTACT TOOK THE VEHICLE TO THE DEALER, BUT THEY WERE UNABLE TO LOCATE THE CAUSE OF THE FAILURE. HE BELIEVED THAT THERE MAY HAVE BEEN AN ISSUE WITH THE FUEL SYSTEM. HE REMOVED THE FUEL TA…
Read full complaint
TL*THE CONTACT OWNS A 1999 CHRYSLER SEBRING CONVERTIBLE. WHILE DRIVING 30 MPH, THE VEHICLE SUDDENLY STALLED AND ALMOST CAUSED A CRASH. THE CONTACT TOOK THE VEHICLE TO THE DEALER, BUT THEY WERE UNABLE TO LOCATE THE CAUSE OF THE FAILURE. HE BELIEVED THAT THERE MAY HAVE BEEN AN ISSUE WITH THE FUEL SYSTEM. HE REMOVED THE FUEL TANK FROM THE VEHICLE AND FOUND BURNT WIRES, WHICH WERE CONTROLLING THE FUEL PUMP. THE CONTACT REPLACED THE FUEL PUMP WIRES AND THE FUEL PUMP ITSELF, BUT CURRENTLY THE VEHICLE WILL NOT START. HE STATED THAT THE DEALER OVERCHARGES HIM DURING EVERY VISIT AND THEY CANNOT DIAGNOSE THE FAILURE. THE CONTACT BELIEVES THAT IT IS A MANUFACTURER DEFECT THAT SHOULD BE RECALLED. THE FAILURE MILEAGE WAS 81,000 AND CURRENT MILEAGE WAS 110,000.
NHTSA ODI #10279130
Mileage unknown · Aug 21, 2008
Fuel System, Gasoline
FUEL PUMP LEAK. *TR
NHTSA ODI #10239238
Mileage unknown · Oct 30, 2007
Electrical SystemFuel System, Gasoline
MY MOMS FUEL PUMP WENT OUT, I HAD IT REPLACED. THE MECHANIC TOOK THE OLD FUEL PUMP OUT AND DISCOVERED THAT THE WIRING HARNESS WAS MELTED, ON BOTH SIDES. IN THE FUEL TANK AND OUTSIDE OF IT. IT IS ONLY A WONDER THAT THE CAR DID NOT CATCH FIRE. I HAD A NEW FUEL PUMP PUT IN. *TR
NHTSA ODI #10207481
119,000 miles · Sep 27, 2006
Fuel System, Gasoline
DT*: THE CONTACT STATED AT HIGHWAY SPEEDS, THE VEHICLE STALLED WITHOUT WARNING, BUT RESTARTED. THE VEHICLE WAS TAKEN TO THE DEALERSHIP, WHO DETERMINED THE WIRES TO THE FUEL PUMP BECAME HOT AND SHUT DOWN THE PUMP. THE FUEL PUMP AND FILTER WAS REPLACED. UPDATED 2/16/2007 - THE DEALER REPORTED THAT THE FUEL PUMP WIRING WAS FAULT…
Read full complaint
DT*: THE CONTACT STATED AT HIGHWAY SPEEDS, THE VEHICLE STALLED WITHOUT WARNING, BUT RESTARTED. THE VEHICLE WAS TAKEN TO THE DEALERSHIP, WHO DETERMINED THE WIRES TO THE FUEL PUMP BECAME HOT AND SHUT DOWN THE PUMP. THE FUEL PUMP AND FILTER WAS REPLACED. UPDATED 2/16/2007 - THE DEALER REPORTED THAT THE FUEL PUMP WIRING WAS FAULTY. *NM
NHTSA ODI #10169400
25,200 miles · Jun 10, 2004
Fuel System, Gasoline
I HAVE HAD TO HAVE THE FUEL INJECTORS CLEANED FOR THE SECOND TIME IN LESS THAN A YEAR.CAR HAS 35K MILES. WAS TOLD BY DEALER SERVICE CENTER CHRYSLER DOESN'T USE "DIRT RESISTANT" FUEL INJECTORS & THIS IS A PROBLEM WITH MY MODEL/YEAR. OF COURSE CLEANING IS NOT COVERED UNDER WARRANTY AND HAS BEEN OVER $120.00 EACH TIME. CHRYSLER DOE…
Read full complaint
I HAVE HAD TO HAVE THE FUEL INJECTORS CLEANED FOR THE SECOND TIME IN LESS THAN A YEAR.CAR HAS 35K MILES. WAS TOLD BY DEALER SERVICE CENTER CHRYSLER DOESN'T USE "DIRT RESISTANT" FUEL INJECTORS & THIS IS A PROBLEM WITH MY MODEL/YEAR. OF COURSE CLEANING IS NOT COVERED UNDER WARRANTY AND HAS BEEN OVER $120.00 EACH TIME. CHRYSLER DOESN'T CONSIDER THESE DEFECTIVE & WILL NOT REPLACE PER WARRANTY. IT WAS SUGGESTED TO ME BY MECHANIC I USE A CAN OF FUEL INJECTOR CLEANER ONCE A MONTH. *AK
ON CERTAIN PASSENGER VEHICLES, THE FLOOR SHIFTER IGNITION-PARK INTERLOCK MAY FAIL AND ALLOW THE SHIFTER TO BE MOVED OUT OF THE PARK POSITION WITH THE KEY REMOVED. AN INOPERATIVE INTERLOCK MAY ALSO ALLOW THE KEY TO BE REMOVED WHEN THE SHIFTER HAS NOT BEEN PLACED IN THE PARK POSITION.
Consequence & remedy
Consequence: EITHER CIRCUMSTANCE MAY RESULT IN THE VEHICLE ROLLING AWAY WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL A NEW LOAD-LIMITING PUSH ROD INTO THE FLOOR SHIFTER LEVER OF THE AFFECTED VEHICLES. OWNER NOTIFICATION BEGAN ON JUNE 14, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
EA03011 · Auto Trans IGNITION-PARK Interlock
Opened Jul 17, 2003 · Closed Jan 30, 2004
Status: closed (inferred from source dates) · Power Train:automatic Transmission; Power Train:automatic Transmission:lever And Linkage:floor Shift
THE MANUFACTURER REPORTS ABOVE ARE BASED ON DAIMLERCHRYSLER?S (DC) ANALYSIS OF MODEL YEAR (MY) 1998 (POPULATION = 356,384) AND 1999 (POPULATION = 486,948) JA, JX AND LH FAMILY SUBJECT VEHICLE DATA (EARLIER MYS EXCLUDED).THE POPULATION NUMBER INCLUDES ALL MYS.THE PRECISE NUMBER OF DUPLICATES BETWEEN ODI AND DC REPORTS CANNOT BE DETERMINED DUE TO MISSING OR INCOMPLETE INFORMATION.THE FATALITY INCIDENT INVOLVED AN ELDERLY PERSON WHO ATTEMPTED TO STOP A ROLL AWAY VEHICLE AND RECEIVED FATAL INJURIES.ODI ALSO GATHERED INFORMATION ON MY 1997-99 PROWLER VEHICLES IN THIS INVESTIGATION. THE PROWLER VEHICLES WERE MANUFACTURED WITH A DIFFERENT DESIGN SHIFTER MECHANISM (THE SHIFT LEVER IS SHORTER).THERE ARE NO COMPLAINTS OF PROWLER INTERLOCK FAILURE IN ODI?S DATABASE, AND DC HAS RECEIVED NO REPORTS EITHER.THE PROWLER IS EXCLUDED FROM THE RECALL SCOPE.THE INVESTIGATION INVOLVED A CONDITION WHERE THE INTERLOCK SYSTEM COULD FAIL (OR BE MADE INOPERATIVE BY THE OPERATOR) DURING VEHICLE USE, POSSIBLY INADVERTENTLY.THE INTERLOCK SYSTEM IS REQUIRED UNDER FMVSS 114.WITH THE TRANSMISSION IN THE PARK POSITION AND THE IGNITION KEY OFF, THE COMBINED ACTION OF PRESSING THE SHIFT BUTTON AND PULLING THE SHIFT LEVER REARWARD MAY RESULT IN THE OPERATOR OVERCOMING THE INTERLOCK SYSTEM AND CAUSE THE MECHANICAL LINKAGE OF THE SYSTEM TO DISCONNECT.WHEN THIS OCCURS, THERE IS NO OVERT INDICATION TO AN OPERATOR THAT THE SYSTEM IS DEFEATED, AND AN INCREASED RISK OF VEHICLE ROLL-AWAY EXISTS.UNDER RECALL 04V021, DC WILL REPLACE DAMAGED SHIFT MECHANISMS, AND WILL INSTALL ON ALL VEHICLES A DEVICE WHICH INHIBITS THE OPERATOR?S ABILITY TO OVERCOME THE INTERLOCK AND DEFEAT THE SYSTEM.BEGINNING WITH MY 2000, DC INCORPORATED A BRAKE AND TRANSMISSION SHIFTER INTERLOCK (BTSI) SYSTEM INTO THE SUBJECT VEHICLES.INTRODUCTION OF BTSI INVOLVED DESIGN CHANGES TO THE SHIFT MECHANISM, ONE OF WHICH RESULTED IN REDUCED MECHANICAL ADVANTAGE (RMA) OF THE SHIFT BUTTON.THE RMA SHIFTER REQUIRES INCREASED FORCES TO OVERCOME THE INTERLOCK SYSTEM, MAKING THE SHIFTER LESS SUSCEPTIBLE TO DAMAGE.
Additional source detail variants (2)
Power Train:automatic Transmission
THE MANUFACTURER REPORTS ABOVE ARE BASED ON DAIMLERCHRYSLER?S (DC) ANALYSIS OF MODEL YEAR (MY) 1998 (POPULATION = 356,384) AND 1999 (POPULATION = 486,948) JA, JX AND LH FAMILY SUBJECT VEHICLE DATA (EARLIER MYS EXCLUDED).THE POPULATION NUMBER INCLUDES ALL MYS.THE PRECISE NUMBER OF DUPLICATES BETWEEN ODI AND DC REPORTS CANNOT BE DETERMINED DUE TO MISSING OR INCOMPLETE INFORMATION.THE FATALITY INCIDENT INVOLVED AN ELDERLY PERSON WHO ATTEMPTED TO STOP A ROLL AWAY VEHICLE AND RECEIVED FATAL INJURIES.ODI ALSO GATHERED INFORMATION ON MY 1997-99 PROWLER VEHICLES IN THIS INVESTIGATION. THE PROWLER VEHICLES WERE MANUFACTURED WITH A DIFFERENT DESIGN SHIFTER MECHANISM (THE SHIFT LEVER IS SHORTER).THERE ARE NO COMPLAINTS OF PROWLER INTERLOCK FAILURE IN ODI?S DATABASE, AND DC HAS RECEIVED NO REPORTS EITHER.THE PROWLER IS EXCLUDED FROM THE RECALL SCOPE.THE INVESTIGATION INVOLVED A CONDITION WHERE THE INTERLOCK SYSTEM COULD FAIL (OR BE MADE INOPERATIVE BY THE OPERATOR) DURING VEHICLE USE, POSSIBLY INADVERTENTLY.THE INTERLOCK SYSTEM IS REQUIRED UNDER FMVSS 114.WITH THE TRANSMISSION IN THE PARK POSITION AND THE IGNITION KEY OFF, THE COMBINED ACTION OF PRESSING THE SHIFT BUTTON AND PULLING THE SHIFT LEVER REARWARD MAY RESULT IN THE OPERATOR OVERCOMING THE INTERLOCK SYSTEM AND CAUSE THE MECHANICAL LINKAGE OF THE SYSTEM TO DISCONNECT.WHEN THIS OCCURS, THERE IS NO OVERT INDICATION TO AN OPERATOR THAT THE SYSTEM IS DEFEATED, AND AN INCREASED RISK OF VEHICLE ROLL-AWAY EXISTS.UNDER RECALL 04V021, DC WILL REPLACE DAMAGED SHIFT MECHANISMS, AND WILL INSTALL ON ALL VEHICLES A DEVICE WHICH INHIBITS THE OPERATOR?S ABILITY TO OVERCOME THE INTERLOCK AND DEFEAT THE SYSTEM.BEGINNING WITH MY 2000, DC INCORPORATED A BRAKE AND TRANSMISSION SHIFTER INTERLOCK (BTSI) SYSTEM INTO THE SUBJECT VEHICLES.INTRODUCTION OF BTSI INVOLVED DESIGN CHANGES TO THE SHIFT MECHANISM, ONE OF WHICH RESULTED IN REDUCED MECHANICAL ADVANTAGE (RMA) OF THE SHIFT BUTTON.THE RMA SHIFTER REQUIRES INCREASED FORCES TO OVERCOME THE INTERLOCK SYSTEM, MAKING THE SHIFTER LESS SUSCEPTIBLE TO DAMAGE.
Power Train:automatic Transmission:lever And Linkage:floor Shift
THE MANUFACTURER REPORTS ABOVE ARE BASED ON DAIMLERCHRYSLER?S (DC) ANALYSIS OF MODEL YEAR (MY) 1998 (POPULATION = 356,384) AND 1999 (POPULATION = 486,948) JA, JX AND LH FAMILY SUBJECT VEHICLE DATA (EARLIER MYS EXCLUDED).THE POPULATION NUMBER INCLUDES ALL MYS.THE PRECISE NUMBER OF DUPLICATES BETWEEN ODI AND DC REPORTS CANNOT BE DETERMINED DUE TO MISSING OR INCOMPLETE INFORMATION.THE FATALITY INCIDENT INVOLVED AN ELDERLY PERSON WHO ATTEMPTED TO STOP A ROLL AWAY VEHICLE AND RECEIVED FATAL INJURIES.ODI ALSO GATHERED INFORMATION ON MY 1997-99 PROWLER VEHICLES IN THIS INVESTIGATION. THE PROWLER VEHICLES WERE MANUFACTURED WITH A DIFFERENT DESIGN SHIFTER MECHANISM (THE SHIFT LEVER IS SHORTER).THERE ARE NO COMPLAINTS OF PROWLER INTERLOCK FAILURE IN ODI?S DATABASE, AND DC HAS RECEIVED NO REPORTS EITHER.THE PROWLER IS EXCLUDED FROM THE RECALL SCOPE.THE INVESTIGATION INVOLVED A CONDITION WHERE THE INTERLOCK SYSTEM COULD FAIL (OR BE MADE INOPERATIVE BY THE OPERATOR) DURING VEHICLE USE, POSSIBLY INADVERTENTLY.THE INTERLOCK SYSTEM IS REQUIRED UNDER FMVSS 114.WITH THE TRANSMISSION IN THE PARK POSITION AND THE IGNITION KEY OFF, THE COMBINED ACTION OF PRESSING THE SHIFT BUTTON AND PULLING THE SHIFT LEVER REARWARD MAY RESULT IN THE OPERATOR OVERCOMING THE INTERLOCK SYSTEM AND CAUSE THE MECHANICAL LINKAGE OF THE SYSTEM TO DISCONNECT.WHEN THIS OCCURS, THERE IS NO OVERT INDICATION TO AN OPERATOR THAT THE SYSTEM IS DEFEATED, AND AN INCREASED RISK OF VEHICLE ROLL-AWAY EXISTS.UNDER RECALL 04V021, DC WILL REPLACE DAMAGED SHIFT MECHANISMS, AND WILL INSTALL ON ALL VEHICLES A DEVICE WHICH INHIBITS THE OPERATOR?S ABILITY TO OVERCOME THE INTERLOCK AND DEFEAT THE SYSTEM.BEGINNING WITH MY 2000, DC INCORPORATED A BRAKE AND TRANSMISSION SHIFTER INTERLOCK (BTSI) SYSTEM INTO THE SUBJECT VEHICLES.INTRODUCTION OF BTSI INVOLVED DESIGN CHANGES TO THE SHIFT MECHANISM, ONE OF WHICH RESULTED IN REDUCED MECHANICAL ADVANTAGE (RMA) OF THE SHIFT BUTTON.THE RMA SHIFTER REQUIRES INCREASED FORCES TO OVERCOME THE INTERLOCK SYSTEM, MAKING THE SHIFTER LESS SUSCEPTIBLE TO DAMAGE.
RQ03005 · Auto Trans IGNITION-PARK Interlock
Opened Apr 8, 2003 · Closed Jul 16, 2003
Status: closed (inferred from source dates) · Power Train:automatic Transmission:lever And Linkage:floor Shift
THREE OF THE MANFACTURER COMPLAINTS AND TWO OF THE MANUFACTURER CRASHES REPORTED ABOVE WERE DUPLICATES OF ODI REPORTS.THE MAJORITY OF CRASHES OCCURRED AFTER OPERATORS PARKED THE VEHICLE WITHOUT ENGAGING PARK GEAR POSITION; A NON-FUNCTIONAL IGNITION-PARK INTERLOCK SYSTEM SUBSEQUENTLY FAILED TO PREVENT KEY REMOVAL BEFORE THE OPERATORS EXITED THE VEHICLE.MOST OF THE CRASHES WERE MINOR AND INVOLVED MINOR PROPERTY DAMAGE.FOUR OF THE INJURY INCIDENTS OCCURRED WHEN UNATTENDED CHILDREN MOVED THE GEARSHIFT FROM THE PARK POSITION CAUSING THE VEHICLE TO ROLL AWAY, ONE INJURY OCCURRED WHEN THE OPERATOR WAS STRUCK BY A ROLL-AWAY VEHICLE AFTER PARKING AND EXITING.ALL INJURIES WERE RELATIVELY MINOR.A SIGNIFICANT NUMBER OF INTERLOCK SYSTEM FAILURES APPEAR TO BE RELATED TO DISENGAGEMENT OF THE INTERLOCK PIN THAT RIDES IN THE INTERLOCK LEVER SLOT WITHIN THE SHIFT MECHANISM.AN ENGINEERING ANALYSIS WILL BE OPENED TO FURTHER STUDY INTERLOCK SYSTEM FAILURES.
1999 Chrysler Sebring Convertible Problems, Complaints & Recalls | Skip That Year
Illustration