IllustrationTL* THE CONTACT OWNS A 2005 CHRYSLER PT CRUISER. THE CONTACT STATED THAT WHILE TRAVELING 25 MPH, THE VEHICLE LOST POWER WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 116,000.
2005 Chrysler Pt Cruiser
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2005 Chrysler Pt Cruiser do not stand out strongly from the model-year median of 202.
About this comparison →How this year compares
Owner complaints by model year
Compare all Pt Cruiser years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
400–25K
2425–50K
4250–75K
2075–100K
24100–150K
9150K+
159 reports with mileage · 28 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 27 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 24 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 18 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
11 crash reports12 fire reports12 injury reports
What owners actually said
187 reportsI PURCHASED THIS VEHICLE USED FROM FRED BEANS, BOYERTOWN, PA ON 8/1/13 WITH APPROX. 78K MILES ON IT. I WAS DRIVING IN TRAFFIC, SLOWING DOWN FOR A TRAFFIC, WHEN MY VEHICLE LOST POWER AND THEN BEGAN TO HESITATE WHEN I ATTEMPTED TO PICK UP SPEED. THERE WAS NO ACCELERATION AND IT APPEARED THE CAR WOULD STALL. IT NEVER STALLED BUT…
Read full complaint
I PURCHASED THIS VEHICLE USED FROM FRED BEANS, BOYERTOWN, PA ON 8/1/13 WITH APPROX. 78K MILES ON IT. I WAS DRIVING IN TRAFFIC, SLOWING DOWN FOR A TRAFFIC, WHEN MY VEHICLE LOST POWER AND THEN BEGAN TO HESITATE WHEN I ATTEMPTED TO PICK UP SPEED. THERE WAS NO ACCELERATION AND IT APPEARED THE CAR WOULD STALL. IT NEVER STALLED BUT I DID PULL OVER AND SHUT THE CAR OFF, STARTED IT AGAIN AND AFTER A FEW MOMENTS, WAS ABLE TO DRIVE NORMALLY FOR A FEW MILES. THE CHECK ENGINE LIGHT WENT ON AND THE CAR HESITATED AGAIN. THIS WAS LOOKED AT AND DETERMINED, SINCE THERE WAS NO OTHER OCCURRENCE, TO BE A "GLITCH" AND THE CHECK ENGINE LIGHT WAS RESET BY THE GARAGE (NO CHARGE AND NO DIAGNOSTICS). IN JANUARY THE SAME PROBLEM OCCURRED AND THE GARAGE REPLACED THE CAM SENSOR. SHORTLY AFTER THAT THE PROBLEM OCCURRED AGAIN AND THE SENSOR WAS AGAIN REPLACED. IT IS NOW APRIL AND AGAIN THE PROBLEM IS OCCURRING, ALL OF THESE INCIDENCES WHILE DRIVING, CAUSING AN UNNECESSARY SLOW DOWN WHICH COULD HAVE RESULTED IN A REAR END COLLISION. I'VE SPOKEN WITH THE DEALERSHIP WHO REFERRED ME TO THE ORIGINAL SHOP THAT REPLACED THE SENSOR (SCOOTY'S, PENNSBURG, PA) AND TO AUTO ZONE WHO SOLD ME THE NEXT SENSOR. I STILL OWE MONEY ON THIS VEHICLE AND APPARENTLY IT'S NOT WORTH HALF OF WHAT I OWE DUE TO THESE PROBLEMS AND I AM CONCERNED ABOUT DRIVING IT MORE THAN A MILE IN CASE THIS PROBLEM OCCURS AGAIN. *TT
I HAVE A CONCERN ABOUT ALL THE ISSUES WITH THIS CAR. ON MARCH 29TH MY FOG LIGHTS WOULD NOT TURN OFF EVEN WHEN IGNITION SWITCH WAS TURNED OFF. I WENT ON LINE AND SAW SEVERAL "BLOGS" ABOUT THIS ISSUE - I AM AN OLDER WOMEN WITH MINIMAL KNOWLEDGE OF THESE THINGS SO I WENT TO A PARTS STORE THAT WAS OPEN AND THE CLERK PULLED THE #8 FU…
Read full complaint
I HAVE A CONCERN ABOUT ALL THE ISSUES WITH THIS CAR. ON MARCH 29TH MY FOG LIGHTS WOULD NOT TURN OFF EVEN WHEN IGNITION SWITCH WAS TURNED OFF. I WENT ON LINE AND SAW SEVERAL "BLOGS" ABOUT THIS ISSUE - I AM AN OLDER WOMEN WITH MINIMAL KNOWLEDGE OF THESE THINGS SO I WENT TO A PARTS STORE THAT WAS OPEN AND THE CLERK PULLED THE #8 FUSE OUT - FOR THE FOG LIGHTS SO MY BATTERY WOULD NOT RUN DOWN BEFORE SERVICE/REPAIR WAS OPEN ON MONDAY- THE MECHANIC STATED HE COULD FIX IT AND ALSO THAT THE DEALERSHIP JUST TOOK IN A USED CRUISER AND THE FOG LIGHTS DID NOT WORK - THEY FOUND THAT SOMEONE HAD TOOK THE FUSES OUT FOR THAT CRUISER ALSO - IS THIS A DEFECTIVE ISSUE- APPEARS NOW ACCORDING TO THE INTERNET THE REPLACEMENT PART HAS BEEN IMPROVED. I ALSO HAD TO REPLACE THE ENTIRE COMPUTER AND AGAIN SEEMS OTHER CRUISER OWNERS HAVE HAD THIS ISSUE ALSO - THIS IS A LOT OF EXPENSE AND WITH THE LOAN ON THE CAR IS DIFFICULT TO NOW GET A DIFFERENT CAR AS THIS DOES SEEM TO BE A LEMON - BUT I HAVE TO KEEP IT TILL I CAN AFFORD TO GET A DIFFERENT CAR - WITH ALL THESE ISSUES - NO ONE WILL WANT THIS ONE EITHER. *TR
I HAVE A 2005 CHRYSLER PT CRUISER AND THE MIDDLE SEATBELT LATCH HAS BECOME COMPLETELY REMOVED. I DID NOT GET IN AN ACCIDENT THE CAUSE OF THIS ISSUE IS UNKNOWN. YESTERDAY THE RIGHT REAR SEATBELT BUCKLE BROKE AS WELL. NOW I HAVE ONE WORKING BELT IN MY BACK SEAT AND TWO CHILDREN. I AM EXTREMELY DISSATISFIED AND WANT TO KNOW WHA…
Read full complaint
I HAVE A 2005 CHRYSLER PT CRUISER AND THE MIDDLE SEATBELT LATCH HAS BECOME COMPLETELY REMOVED. I DID NOT GET IN AN ACCIDENT THE CAUSE OF THIS ISSUE IS UNKNOWN. YESTERDAY THE RIGHT REAR SEATBELT BUCKLE BROKE AS WELL. NOW I HAVE ONE WORKING BELT IN MY BACK SEAT AND TWO CHILDREN. I AM EXTREMELY DISSATISFIED AND WANT TO KNOW WHAT I CAN DO ABOUT IT. I HAVE NO CONFIDENCE IN THE SAFETY OF THIS VEHICLE AND I FEEL THAT SEAT BELTS SHOULD NOT MALFUNCTION LET ALONE COMPLETELY BREAK FOR NO REASON. *TR
TL-THE CONTACT OWNS A 2005 CHRYSLER PT CRUISER. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 50 MPH. THE REAR DRIVER'S LEFT SIDE QUARTER PANEL WINDOW FELL OUT. THE VEHICLE HAD NOT BEEN TAKEN TO A DEALER FOR DIAGNOSIS OR REPAIRS. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE PROBLEM. THE APPROXI…
Read full complaint
TL-THE CONTACT OWNS A 2005 CHRYSLER PT CRUISER. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 50 MPH. THE REAR DRIVER'S LEFT SIDE QUARTER PANEL WINDOW FELL OUT. THE VEHICLE HAD NOT BEEN TAKEN TO A DEALER FOR DIAGNOSIS OR REPAIRS. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 117,000.LJ
TL* THE CONTACT OWNS A 2005 CHRYSLER PT CRUISER. THE CONTACT STATED THAT THE HEADLIGHT ICON ILLUMINATED INDEPENDENTLY ON THE INSTRUMENT PANEL WHEN THE HEADLIGHTS WERE NOT ACTIVATED. IN ADDITION, THE CONTACT NOTICED SMOKE COMING FROM THE TURN SIGNAL HANDLE. THE CONTACT DEACTIVATED THE FUSE BUT LATER NOTICED SMOKE COMING FROM THE …
Read full complaint
TL* THE CONTACT OWNS A 2005 CHRYSLER PT CRUISER. THE CONTACT STATED THAT THE HEADLIGHT ICON ILLUMINATED INDEPENDENTLY ON THE INSTRUMENT PANEL WHEN THE HEADLIGHTS WERE NOT ACTIVATED. IN ADDITION, THE CONTACT NOTICED SMOKE COMING FROM THE TURN SIGNAL HANDLE. THE CONTACT DEACTIVATED THE FUSE BUT LATER NOTICED SMOKE COMING FROM THE WINDOW CONTROL SWITCH ON THE DASHBOARD CONSOLE. THERE WAS ALSO AN EXCESSIVE VIBRATION COMING FROM THE FRONT END OF THE VEHICLE WHEN BEING DRIVEN AT VARIOUS SPEEDS. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS. THE TECHNICIAN STATED THAT THE MOTOR MOUNTS WOULD HAVE TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 70,000.
AFTER COMING FROM THE STORE I NOTICE A BIG SPOT OF OIL ON THE GARAGE FLOOR,I WIPE IT UP WENT INSIDE THE HOUSE THE NEXT DAY I WENT ON SOME ERRANDS CAME BACK TO THE HOUSE AND SOME MORE OIL, AT THIS POINT CALL MY LOCAL PARTS HOUSE HE CAME UP WITH A BAD FRONT OIL SEAL. SO I WANTED TO DID FURTHER INTO THIS, AND FOUND A LOT OF DODGE,…
Read full complaint
AFTER COMING FROM THE STORE I NOTICE A BIG SPOT OF OIL ON THE GARAGE FLOOR,I WIPE IT UP WENT INSIDE THE HOUSE THE NEXT DAY I WENT ON SOME ERRANDS CAME BACK TO THE HOUSE AND SOME MORE OIL, AT THIS POINT CALL MY LOCAL PARTS HOUSE HE CAME UP WITH A BAD FRONT OIL SEAL. SO I WANTED TO DID FURTHER INTO THIS, AND FOUND A LOT OF DODGE, CHRYSLER, OWNER HAD THIS SAME PROBLEM.I PULL UP AND COPY THESE PROBLEM'S SOME P/T OWNERS SAID THE DEALER WANTED TO CHARGE THEM TO CHANGE THE ENGINE BECAUSE OF THE THRUST BEARING WAS TO FAR OUT OF SPECS.AND PUSHING THE FRONT SEAL OUT AND CAUSING LEAK. IF THIS WOULD HAPPEN AT HIGH SPEEDS,THIS WOULD HAVE A TERRIBLE TERRIBLE PROBLEM. I THINK CHRYSLER KNOWS ABOUT THIS, BECAUSE ONE CHRYSLER TECH DID SAY HE KNOWS THE 2.4L HAS A CRANK SEAL ISSUE ON A HANDFUL OF THE VEHICLE. NOW OUR P/T ONLY HAS 55,000 MILES ON IT AND THIS PROBLEM SHOULD NOT BE. MOST OWNER THAT I'VE READ ABOUT HAS MILEAGE NO MORE THAN 110.000.AND SOME HAVE HAD THE SEAL REPLACE TWO-THREE TIMES. I THINK CHRYSLER NEEDS TO STEP UP TO PLATE AND ADDRESS THIS PROBLEM NOW WE ARE STUCK WITHOUT A CAR. THIS COULD COST IN THE THOUSANDS,THIS PROBLEM SHOULD HAVE ADDRESS LONG AGO.THE HOLE UNDER CARRIAGE IS SOAK WITH OIL. *TR
I WAS DRIVING ON THE HIGHWAY 75 MPH, AT SOME POINT THE SIDE REAR WINDOW BLEW OUT , I HEARD THE SOUND OF A OPEN WINDOW BUT COULD NOT FIGURE OUT WHERE IT WAS COMING FROM, I PULLED OVER AND NOTICED THE WINDOW WAS GONE. IF THERE HAD BEEN A MOTOR CYCLE OR ANOTHER VEHICLE IT COULD HAVE CAUSED AN ACCIDENT. *TR
TL* THE CONTACT OWNS A 2005 CHRYSLER PT CRUISER CONVERTIBLE. THE CONTACT STATED THE FIRE WALL RIPPED CAUSING THE CLUTCH PEDAL TO PUSH THROUGH THE FIRE WALL. THE CONTACT STATED THE VEHICLE COULD NOT BE DRIVEN DUE TO THE HOLE IN THE FIRE WALL THE CONTACT DID NOT TAKE THE VEHICLE TO A DEALER OR MECHANIC. THE CONTACT DID NOT NOTIFY…
Read full complaint
TL* THE CONTACT OWNS A 2005 CHRYSLER PT CRUISER CONVERTIBLE. THE CONTACT STATED THE FIRE WALL RIPPED CAUSING THE CLUTCH PEDAL TO PUSH THROUGH THE FIRE WALL. THE CONTACT STATED THE VEHICLE COULD NOT BE DRIVEN DUE TO THE HOLE IN THE FIRE WALL THE CONTACT DID NOT TAKE THE VEHICLE TO A DEALER OR MECHANIC. THE CONTACT DID NOT NOTIFY THE MANUFACTURER OF THE FAILURE. THE FAILURE MILEAGE WAS 145,000.
I WAS DRIVING NORTH ON I95 SUNDAY AND ALL OF A SUDDEN THE REAR DRIVERS SIDE QUARTER WINDOW JUST FLEW OFF WITHOUT ANY WARNING NO BREAKAGE NOTHING HIT IT JUST BLEW OFF. UNFORTUNATELY IT BROKE UP WHEN IT HIT THE PAVEMENT. IS THERE STILL A RECALL #07V149000 THAT CAN STILL TAKE CARE OF THIS PROBLEM? *TR
Official recalls
307V149000 · Visibility:glass, Side/rear
Apr 4, 2007
ON CERTAIN PASSENGER VEHICLES, THE REAR QUARTER GLASS ATTACHING FASTENERS MAY PULL THROUGH THEIR MOUNTS AND ALLOW THE GLASS TO SEPARATE FROM THE VEHICLE.
Consequence & remedy
Consequence: IF THE GLASS SEPARATES WHILE DRIVING, IT COULD STRIKE ANOTHER VEHICLE OR INJURE A PEDESTRIAN.
Remedy: DEALERS WILL REPLACE THE REAR QUARTER GLASS. THE RECALL BEGAN ON APRIL 30, 2007. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
04V481000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
Oct 8, 2004
CERTAIN PASSENGER VEHICLES EQUIPPED WITH 4-WHEEL ANTILOCK BRAKING SYSTEM (ABS), 2.4L HIGH OUTPUT TURBOCHARGED ENGINE, AND 5-SPEED MANUAL TRANSAXLE, MAY EXHIBIT INADEQUATE CLEARANCE BETWEEN THE LEFT FRONT BRAKE TUBE AND THE TRANSAXLE HOUSING.
Consequence & remedy
Consequence: CONTACT BETWEEN THE BRAKE TUBE AND THE TRANSAXLE HOUSING OVER AN EXTENDED PERIOD OF TIME MAY EVENTUALLY LEAD TO PERFORATION OF THE BRAKE TUBE, WHICH COULD LEAD TO A LOSS OF BRAKING FORCE IN THE LEFT FRONT/RIGHT REAR CIRCUIT OF VEHICLE.
Remedy: DEALERS WILL INSTALL REVISED BRAKE TUBES. THE RECALL BEGAN OCTOBER 25, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
04V268000 · Steering:hydraulic Power Assist:hose, Piping, And Connections
Jun 3, 2004
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.4L NON-TURBOCHARGED ENGINES AND AUTOMATIC TRANSAXLES, THE POWER STEERING PRESSURE HOSE MAY CONTACT THE AUTOMATIC TRANSAXLE DIFFERENTIAL COVER, POTENTIALLY DAMAGING THE HOSE.
Consequence & remedy
Consequence: POWER STEERING FLUID LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSPECT AND RELOCATE, OR REPLACE AS NECESSARY, THE POWER STEERING HOSE AND CONFIRM TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END. THE RECALL BEGAN ON SEPTEMBER 20, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA07004 · Rear Quarter Panel Glass Separation
Opened Feb 16, 2007 · Closed Apr 5, 2007
Status: closed (inferred from source dates) · Visibility:glass, Side/rear
DAIMLERCHRYSLER CORPORATION (DCC) WILL RECALL MODEL YEAR 2005 AND 2006 PT CRUISER VEHICLES PRODUCED FROM 5/17/05 THROUGH 9/1/05 TO CORRECT A POTENTIAL DEFECT IN THE REAR QUARTER PANEL GLASS THAT MAY SEPARATE FROM THE VEHICLE.DCC WILL INSPECT THE REAR QUARTER PANEL GLASS AND REPLACE IF NECESSARY.DCC WILL BEGIN NOTIFYING OWNERS IN MAY 2007. VEHICLES PRODUCED PRIOR TO AND AFTER THE ABOVE BUILD DATES ARE NOT AFFECTED.A CHANGE MADE BY THE ASSEMBLY PLANT IN MAY 2005 THAT MODIFIED THE GLASS ATTACHMENT LED TO THE POTENTIAL FOR GLASS SEPARATION.IN SEPTEMBER 2005, SUBSEQUENT CHANGES TO THE PROCESS WERE MADE TO CORRECT THIS.THIS ENGINEERING ANALYSIS IS CLOSED.SEE RECALL 07V149 FOR ADDITIONAL DETAILS.
PE04028 · Engine Compartment Fires
Opened Mar 15, 2004 · Closed Jun 18, 2004
Status: closed (inferred from source dates) · Steering; Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:hose, Piping, And Connections; Steering:hydraulic Power Assist:power Steering Fluid
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Additional source detail variants (4)
Steering
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist:hose, Piping, And Connections
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist:power Steering Fluid
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist System
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.