NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
187 reports106,000 miles · Jul 27, 2018
Electrical SystemExterior LightingFire
TL* THE CONTACT OWNS A 2005 CHRYSLER PT CRUISER. WHILE THE VEHICLE WAS STATIONARY, THE CONTACT NOTICED SMOKE COMING FROM THE ROOT OF THE TURN SIGNAL SWITCH. THE CONTACT IMMEDIATELY PULLED THE FOG LAMP SWITCH, WHICH DIFFUSED THE SMOKE. A POLICE REPORT WAS NOT FILED. THE CONTACT STATED THAT THE FOG LIGHTS WERE ILLUMINATED AT THE T…
Read full complaint
TL* THE CONTACT OWNS A 2005 CHRYSLER PT CRUISER. WHILE THE VEHICLE WAS STATIONARY, THE CONTACT NOTICED SMOKE COMING FROM THE ROOT OF THE TURN SIGNAL SWITCH. THE CONTACT IMMEDIATELY PULLED THE FOG LAMP SWITCH, WHICH DIFFUSED THE SMOKE. A POLICE REPORT WAS NOT FILED. THE CONTACT STATED THAT THE FOG LIGHTS WERE ILLUMINATED AT THE TIME OF THE FAILURE. AN UNKNOWN CHRYSLER DEALER WAS MADE AWARE OF THE FAILURE, BUT THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 106,000.
NHTSA ODI #11114205
85,000 miles · Jun 21, 2018
Electrical System
CAR STALLS WHILE DRIVING. SOMETIMES WONT START.
NHTSA ODI #11102983
39,000 miles · Apr 3, 2018
Engine And Engine CoolingFuel System, GasolineService Brakes
2005 CHRYSLER PT CRUISER. CONSUMER WRITES IN REGARDS TO THE FUEL LEAK LOCATION ON THE INLET NOZZLE FUEL TANK. *SMD THE DEALER STATED CHECK ENGINE LIGHT ON, CRACKED TRIM AROUND A/C UNIT, TRUNK WILL NOT STAY OPEN, FRONT BRAKES NEED REPLACING, AND REAR SHOCK NEED TO BE REPLACED. *TR
NHTSA ODI #10919533
200,000 miles · Mar 2, 2018
Service BrakesVehicle Speed Control
TL* THE CONTACT OWNS A 2005 CHRYSLER PT CRUISER. WHILE DRIVING 40 MPH, THE BRAKES FAILED AND THE BRAKE PEDAL BECAME STIFF. AFTER REMOVING PRESSURE FROM THE BRAKE PEDAL, THE VEHICLE ACCELERATED RAPIDLY WITHOUT WARNING. THE CONTACT STATED THAT THE FAILURE WAS INTERMITTENT. THE DEALER AND MANUFACTURER WERE NOT MADE AWARE OF THE FAI…
Read full complaint
TL* THE CONTACT OWNS A 2005 CHRYSLER PT CRUISER. WHILE DRIVING 40 MPH, THE BRAKES FAILED AND THE BRAKE PEDAL BECAME STIFF. AFTER REMOVING PRESSURE FROM THE BRAKE PEDAL, THE VEHICLE ACCELERATED RAPIDLY WITHOUT WARNING. THE CONTACT STATED THAT THE FAILURE WAS INTERMITTENT. THE DEALER AND MANUFACTURER WERE NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 200,000. THE VIN WAS NOT AVAILABLE.
NHTSA ODI #11075818
135,000 miles · Oct 17, 2017
Steering
TL* THE CONTACT OWNS A 2005 CHRYSLER PT CRUISER. WHILE DRIVING 25 MPH, THE STEERING WHEEL SEIZED WITHOUT WARNING. THE CONTACT PULLED THE VEHICLE OVER AND OBSERVED FLUID LEAKING UNDER THE DRIVER SIDE WHEEL. THE CONTACT BELIEVED THE LEAK ORIGINATED FROM THE RACK AND PINION. THE VEHICLE WAS TOWED HOME. THE LOCAL DEALER AND MANUFACT…
Read full complaint
TL* THE CONTACT OWNS A 2005 CHRYSLER PT CRUISER. WHILE DRIVING 25 MPH, THE STEERING WHEEL SEIZED WITHOUT WARNING. THE CONTACT PULLED THE VEHICLE OVER AND OBSERVED FLUID LEAKING UNDER THE DRIVER SIDE WHEEL. THE CONTACT BELIEVED THE LEAK ORIGINATED FROM THE RACK AND PINION. THE VEHICLE WAS TOWED HOME. THE LOCAL DEALER AND MANUFACTURER WERE NOT CONTACTED OR MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 135,000.
NHTSA ODI #11033993
120,000 miles · Sep 9, 2017
Structure
DRIVERS SIDE REAR QUARTER WINDOW CAME OFF WHILE TRAVELING ON HIGHWAY.
NHTSA ODI #11022457
70,000 miles · Aug 23, 2017
Fuel/propulsion System
PURGE CONTROL VALVE IS FAULTY, CAUSING VEHICLE TO STALL AFTER FUELING. EVERY. SINGLE. TIME. THIS OCCURS BOTH AT THE PUMP IMMEDIATELY AFTER FUELING AS WELL AS WHEN THE CAR IS IN MOTION, PULLING INTO TRAFFIC FROM THE FUEL STATION. THE LATTER HAS CAUSED SAFETY HAZARDS & NEAR-ACCIDENTS COUNTLESS TIMES.
NHTSA ODI #11019155
133,000 miles · Jun 1, 2017
Fuel/propulsion System
STALLS OUT WHILE DRIVING, CAR COMPLETELY STOPS AND YOU CAN'T GO FORWARD, HAVE TO PUT THE CAR IN PARK AND BACK IN DRIVE MULTIPLE TIMES IN ORDER TO EVEN BE ABLE TO DRIVE... CAR COMPLETELY SHUT OFF IN THE MIDDLE OF A BUSY ROAD...
NHTSA ODI #10992738
161,580 miles · Apr 3, 2017
Visibility/wiper
REAR QUARTER WINDOW IS POPPING OUT, IT IS LEAKING AND HAS A GAP ALIGN THE TOP I HAVE DUCT TAPED IT IN PLACE TO PREVENT IT FROM COMING OUT
NHTSA ODI #10970101
99,000 miles · Mar 25, 2017
Steering
THERE IS A CLICKING SOUND WHEN THE STEERING WHEEL IS TURN TO EITHER SIDE. I HAD THE POWER STEERING PRESSURE SWITCH REPLACE TWICE AND THE RACK AND PINION REPLACE AND THE CAR STILL MAKES A CLICKING SOUND WHEN THE WHEEL IS TURN. DEALERSHIP REPLACE THE PART AND AN INDIVIDUAL MECHANIC HAS REPLACE THE SAME SWITCH. TO NO AVIL , I'M HA…
Read full complaint
THERE IS A CLICKING SOUND WHEN THE STEERING WHEEL IS TURN TO EITHER SIDE. I HAD THE POWER STEERING PRESSURE SWITCH REPLACE TWICE AND THE RACK AND PINION REPLACE AND THE CAR STILL MAKES A CLICKING SOUND WHEN THE WHEEL IS TURN. DEALERSHIP REPLACE THE PART AND AN INDIVIDUAL MECHANIC HAS REPLACE THE SAME SWITCH. TO NO AVIL , I'M HAVING THIS PROBLEM.
NHTSA ODI #10968508
NHTSA investigations
2EA07004 · Rear Quarter Panel Glass Separation
Opened Feb 16, 2007 · Closed Apr 5, 2007
Status: closed (inferred from source dates) · Visibility:glass, Side/rear
DAIMLERCHRYSLER CORPORATION (DCC) WILL RECALL MODEL YEAR 2005 AND 2006 PT CRUISER VEHICLES PRODUCED FROM 5/17/05 THROUGH 9/1/05 TO CORRECT A POTENTIAL DEFECT IN THE REAR QUARTER PANEL GLASS THAT MAY SEPARATE FROM THE VEHICLE.DCC WILL INSPECT THE REAR QUARTER PANEL GLASS AND REPLACE IF NECESSARY.DCC WILL BEGIN NOTIFYING OWNERS IN MAY 2007. VEHICLES PRODUCED PRIOR TO AND AFTER THE ABOVE BUILD DATES ARE NOT AFFECTED.A CHANGE MADE BY THE ASSEMBLY PLANT IN MAY 2005 THAT MODIFIED THE GLASS ATTACHMENT LED TO THE POTENTIAL FOR GLASS SEPARATION.IN SEPTEMBER 2005, SUBSEQUENT CHANGES TO THE PROCESS WERE MADE TO CORRECT THIS.THIS ENGINEERING ANALYSIS IS CLOSED.SEE RECALL 07V149 FOR ADDITIONAL DETAILS.
PE04028 · Engine Compartment Fires
Opened Mar 15, 2004 · Closed Jun 18, 2004
Status: closed (inferred from source dates) · Steering; Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:hose, Piping, And Connections; Steering:hydraulic Power Assist:power Steering Fluid
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Additional source detail variants (4)
Steering
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist:hose, Piping, And Connections
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist:power Steering Fluid
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist System
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Illustration