TL* THE CONTACT OWNS A 2004 CHRYSLER PT CRUISER. WHILE DRIVING APPROXIMATELY 15 MPH, ANOTHER VEHICLE CRASHED INTO THE PASSENGER SIDE OF THE CONTACT'S VEHICLE. THE AIR BAGS FAILED TO DEPLOY. THE CONTACT SUSTAINED HEAD INJURIES AND WHIPLASH. MEDICAL ATTENTION WAS NOT RECEIVED. THE DRIVER OF THE OTHER VEHICLE SUSTAINED HEAD INJURIE…
Read full complaint
TL* THE CONTACT OWNS A 2004 CHRYSLER PT CRUISER. WHILE DRIVING APPROXIMATELY 15 MPH, ANOTHER VEHICLE CRASHED INTO THE PASSENGER SIDE OF THE CONTACT'S VEHICLE. THE AIR BAGS FAILED TO DEPLOY. THE CONTACT SUSTAINED HEAD INJURIES AND WHIPLASH. MEDICAL ATTENTION WAS NOT RECEIVED. THE DRIVER OF THE OTHER VEHICLE SUSTAINED HEAD INJURIES THAT REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS DRIVEN TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT CALLED MCHENRY AUTO MART (LOCATED AT 725 MCHENRY AVE, SUITE A, MODESTO, CA 95350 (209) 408-8802) WHERE THE CONTACT WAS ASKED IF SHE WAS LATE ON HER PAYMENT. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS UNKNOWN.
NHTSA ODI #11020979
160,600 miles · Dec 17, 2014
Air BagsSeat BeltsInjury
AS I WAS DRIVING THERE WAS SUDDENLY A LOUD EXPLOSION AND THE SMELL OF BLACK POWDER (LIKE A GUNSHOT) AND I WAS HIT VERY HARD IN THE UPPER RIGHT CHEST, DRIVER'S SIDE, BY A SHOCK WAVE THAT FELT AS IF I HAD BEEN SHOT. THE ODOR WAS COMING FROM THE AREA NEAR THE BRAKE AND GAS PEDALS. THE AIR BAG LIGHT HAD BEEN COMING ON AND OFF RANDOM…
Read full complaint
AS I WAS DRIVING THERE WAS SUDDENLY A LOUD EXPLOSION AND THE SMELL OF BLACK POWDER (LIKE A GUNSHOT) AND I WAS HIT VERY HARD IN THE UPPER RIGHT CHEST, DRIVER'S SIDE, BY A SHOCK WAVE THAT FELT AS IF I HAD BEEN SHOT. THE ODOR WAS COMING FROM THE AREA NEAR THE BRAKE AND GAS PEDALS. THE AIR BAG LIGHT HAD BEEN COMING ON AND OFF RANDOMLY FOR MONTHS. IT NEVER STAYED ON MORE THAN A FEW SECONDS. I HAD THE CAR IN FOR ITS BIG VA STATE INSPECTION, TO THE TUNE OF $2059.03, IN APRIL AT THE CHRYSLER DEALERSHIP WHERE I HAVE TAKEN IT FOR ONE YEAR. AIR BAGS ARE NOT PART OF A REGULAR INSPECTION SO IT WAS NOT CHECKED. I WAS ABLE TO DRIVE THE CAR INTO THE NEAREST CHRYSLER DEALERSHIP, BY LUCK IT WAS WITHIN A MILE OF WHERE THE INCIDENT HAPPENED), AND ASKED THE MEN IN SERVICE, WHO KNOW ME AND HAD SERVICED THIS CAR FOR TEN YEARS, TO COME OUT AND SMELL IT. THEY CONCURRED IT SMELLED AS IF AN EXPLOSION HAD HAPPENED INSIDE THE CAR. THE AIRBAG HAD NOT DEPLOYED; NOR SHOULD IT HAVE...THERE WAS NO CRASH OR ANYTHING. I LEFT THE CAR THERE. MY CHEST HURT. I CONTACTED CHRYSLER IN DETROIT AND A WEEK LATER THEY SENT THEIR SPECIAL VA ENGINEER WITH HIS COMPUTER TO CHECK THE COMPUTER IN THE CAR. THE OTHER DAY I RECEIVED AN OFFICIAL LETTER THAT MY CLAIM WAS BEING DENIED; NOTHING HAD BEEN FOUND. SO I WENT OVER TO THE DEALERSHIP AND THE SERVICE MAN DROVE IT AROUND THE LOT TO GIVE TO ME. I WAS GOING TO TAKE IT HOME. HE HAD NOT PUT THE SEAT BELT ON TO DRIVE IT TO ME. I GOT IN AND THE AIRBAG LIGHT WAS ON ALL THE TIME AND THE SEAT BELT WOULD NOT EXTEND. I CANNOT DRIVE THE CAR WITH AN INOPERABLE SEAT BELT AND WITH THE AIR BAG LIGHT ON. IT MUST HAVE BEEN THE PROPELLANT THAT HIT ME IN THE CHEST, AS THE BAG DID NOT DEPLOY. IT WAS SO FAST, SO HARD, AND SCARED ME TO DEATH. I REPORTED THIS TO YOU AFTER IT HAPPENED, BUT AM RE-REPORTING IT NOW BECAUSE OF THE "RESULTS" OF CHRYSLER'S OFFICIAL INSPECTION.
NHTSA ODI #10664840
160,000 miles · Dec 16, 2014
Air BagsFire
TL* THE CONTACT OWNS A 2004 CHRYSLER PT CRUISER. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 55 MPH, THERE WAS A LOUD BANG AND THE AIR BAG WARNING LIGHT ILLUMINATED. IN ADDITION, THE CONTACT STATED THAT THERE WAS AN AROMA OF SMOKE INSIDE THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTI…
Read full complaint
TL* THE CONTACT OWNS A 2004 CHRYSLER PT CRUISER. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 55 MPH, THERE WAS A LOUD BANG AND THE AIR BAG WARNING LIGHT ILLUMINATED. IN ADDITION, THE CONTACT STATED THAT THERE WAS AN AROMA OF SMOKE INSIDE THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 160,000. UPDATED 1/21/15*CN UPDATED 9/11/2017*CN
NHTSA ODI #10664555
160,000 miles · Nov 22, 2014
Air BagsInjury
I HAVE HAD THE CAR TUNED AND INSPECTED THIS PAST YEAR AND HAD MENTIONED THAT THE AIR BAG LIGHT CAME ON SPORADICALLY. LIKE THE "CHECK ENGINE LIGHT," IT APPARENTLY MEANT NOTHING, I WAS TOLD, AS IT WAS THE ORIGINAL, NEVER USED, AIRBAG. YESTERDAY AS I WAS DRIVING ON A FOUR-LAND HIGHWAY THERE WAS A LARGE EXPLOSION AND THE SMELL OF CO…
Read full complaint
I HAVE HAD THE CAR TUNED AND INSPECTED THIS PAST YEAR AND HAD MENTIONED THAT THE AIR BAG LIGHT CAME ON SPORADICALLY. LIKE THE "CHECK ENGINE LIGHT," IT APPARENTLY MEANT NOTHING, I WAS TOLD, AS IT WAS THE ORIGINAL, NEVER USED, AIRBAG. YESTERDAY AS I WAS DRIVING ON A FOUR-LAND HIGHWAY THERE WAS A LARGE EXPLOSION AND THE SMELL OF CORDITE, AS IF I HAD BEEN SHOT. MY CHEST FELT CRUSHED, AS IF IT HAD BEEN HIT, COMPRESSED, WHATEVER...AND THE SEAT BELTS TIGHTENED, BUT THE AIR BAG DID NOT DEPLOY. I DID NOT KNOW WHAT HAD HAPPENED. I THOUGHT I HAD BEEN SHOT. NO BLOOD, NO BULLET HOLE. CHEST HURT. CHEST DID NOT HURT BECAUSE OF A SEATBELT, BUT THE COMPRESSION FROM THE BLAST. I WAS IN THE RIGHT LANE AND JUST HELD THE CAR STEADY, VERY DISORIENTED AND SHAKEN. CHEST HURT. I REALIZED I WAS WITHIN A MILE (A MIRACLE) OF ONE OF THE TWO CHRYSLER DEALERSHIPS THAT HAS WORKED ON THIS CAR OVER THE PAST 15 YEARS, SO I DROVE IT IN AND STUMBLED, BREATHLESS, INTO THE SERVICE AREA,, WHERE THEY KNEW ME AT ONCE BY NAME. THEY KNEW I WAS SHAKEN AND WAS HAVING TROUBLE TALKING AND WALKING. MY CHEST HAD BEEN HIT VERY HARD AND I FOUND OUT THE AIR HAD BEEN KNOCKED OUT OF MY LUNGS. THEY HAVE THE CAR, HAD NEVER SEEN THIS HAPPEN BEFORE. NO ONE HAS WORKED ON IT YET. I AM GOING OVER THERE TODAY TO ASK THEM NOT TO WORK ON IT UNTIL MY LAWYER DECIDES IF IT IS "EVIDENCE" FOR SOME NEW KIND OF AIR BAG HAZARD. I HAVE NO CAR NOW. I WANT OTHER DRIVERS AND OWNERS TO KNOW THAT A TEN-YEAR-OLD CAR AND TEN-YEAR-OLD AIRBAG ARE DANGEROUS. THIS CAR HAS NEVER HAD AN ACCIDENT AND THIS IS THE ORIGINAL AIRBAG. MY IDEA: AIRBAGS NEED TO BE ROTATED OUT AND CHANGED EVERY FEW YEARS SO THIS DOES NOT HAPPEN. *TR
NHTSA ODI #10660201
190,000 miles · Jun 18, 2014
Air BagsCrash
WHEN ENTERING THE FREEWAY ON THE ON-RAMP, A VAN IN FRONT OF ME STOPPED. I CRASHED INTO THE VAN. I HIT MY CHEST HARD ON THE STEERING WHEEL. THE AIRBAGS DID NOT GO OFF. *TR
NHTSA ODI #10604337
111,000 miles · Nov 29, 2012
Air BagsCrashInjury
I HIT ANOTHER VEHICLE ON THE FREEWAY. MY AIRBAG DID NOT DEPLOY. I AM VERY SORE (NO OTHER INJURIES). THE CAR WAS TOTALED. *TR
NHTSA ODI #10486502
85,000 miles · Nov 18, 2011
Air Bags
TL* THE CONTACT OWNS A 2004 CHRYSLER PT CRUISER. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT WAS ILLUMINATED. THE DEALER MADE AN ATTEMPT TO DIAGNOSE THE FAILURE, BUT THE CONTACT REFUSED. THE MANUFACTURER WAS NOT CONTACTED. A LOCAL MECHANIC MADE AN ATTEMPT TO REPAIR THE DEFECT ALSO BUT THE FAILURE RECURRED. THE FAILURE…
Read full complaint
TL* THE CONTACT OWNS A 2004 CHRYSLER PT CRUISER. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT WAS ILLUMINATED. THE DEALER MADE AN ATTEMPT TO DIAGNOSE THE FAILURE, BUT THE CONTACT REFUSED. THE MANUFACTURER WAS NOT CONTACTED. A LOCAL MECHANIC MADE AN ATTEMPT TO REPAIR THE DEFECT ALSO BUT THE FAILURE RECURRED. THE FAILURE AND THE CURRENT MILEAGE WAS 85,000.
NHTSA ODI #10436370
90,000 miles · May 16, 2011
Air Bags
TL*THE CONTACT OWNS A 2004 CHRYSLER PT CRUISER. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT SUDDENLY ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THEY PERFORMED A DIAGNOSTIC TEST WHICH CONCLUDED THAT THE BLOWING MODULE NEEDED TO BE REPLACED; HOWEVER, HER WARRANTY DID NOT COVER THAT TYPE OF FAILURE. THE MANUFACTUR…
Read full complaint
TL*THE CONTACT OWNS A 2004 CHRYSLER PT CRUISER. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT SUDDENLY ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THEY PERFORMED A DIAGNOSTIC TEST WHICH CONCLUDED THAT THE BLOWING MODULE NEEDED TO BE REPLACED; HOWEVER, HER WARRANTY DID NOT COVER THAT TYPE OF FAILURE. THE MANUFACTURER WAS NOT AWARE OF THE FAILURE. NO REPAIRS WERE PERFORMED. THE CURRENT AND FAILURE MILEAGE WAS APPROXIMATELY 90,000. THE VIN WAS UNAVAILABLE.
NHTSA ODI #10401024
30,000 miles · Aug 22, 2006
Air BagsCrashInjury
DT*: THE CONTACT STATED THE VEHICLE WAS INVOLVED IN A CRASH WHILE DRIVING 20 MPH. THE VEHICLE ROLLED, AND THE AIR BAGS DID NOT DEPLOY. THE CONTACT WAS WEARING A SAFETY BELT, BUT STILL INCURRED MUSCULAR AND NEUROLOGICAL INJURIES. A POLICE REPORT WAS TAKEN. THE VEHICLE WAS TAKEN TO A PRIVATE REPAIR SHOP, BUT WAS UNABLE TO DET…
Read full complaint
DT*: THE CONTACT STATED THE VEHICLE WAS INVOLVED IN A CRASH WHILE DRIVING 20 MPH. THE VEHICLE ROLLED, AND THE AIR BAGS DID NOT DEPLOY. THE CONTACT WAS WEARING A SAFETY BELT, BUT STILL INCURRED MUSCULAR AND NEUROLOGICAL INJURIES. A POLICE REPORT WAS TAKEN. THE VEHICLE WAS TAKEN TO A PRIVATE REPAIR SHOP, BUT WAS UNABLE TO DETERMINE THE PROBLEM.
NHTSA ODI #10166242
Mileage unknown · Mar 15, 2006
Air BagsCrashInjury
MY WIFE WAS IN AN ACCIDENT. SHE HIT A GUARD RAIL HEAD ON AND THE AIR BAGS DID NOT DEPLOY. SHE HIT IT HARD ENOUGH TO BEND THE FRAME 3 INCHES OUT OF SQUARE. THIS RESULTED IN BODILY INJURY. *NM
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.4L NON-TURBOCHARGED ENGINES AND AUTOMATIC TRANSAXLES, THE POWER STEERING PRESSURE HOSE MAY CONTACT THE AUTOMATIC TRANSAXLE DIFFERENTIAL COVER, POTENTIALLY DAMAGING THE HOSE.
Consequence & remedy
Consequence: POWER STEERING FLUID LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSPECT AND RELOCATE, OR REPLACE AS NECESSARY, THE POWER STEERING HOSE AND CONFIRM TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END. THE RECALL BEGAN ON SEPTEMBER 20, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE04028 · Engine Compartment Fires
Opened Mar 15, 2004 · Closed Jun 18, 2004
Status: closed (inferred from source dates) · Steering; Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:hose, Piping, And Connections; Steering:hydraulic Power Assist:power Steering Fluid
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Additional source detail variants (4)
Steering
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist:hose, Piping, And Connections
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist:power Steering Fluid
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist System
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
2004 Chrysler Pt Cruiser Problems, Complaints & Recalls | Skip That Year
Illustration