Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
370–25K
11625–50K
10150–75K
5675–100K
56100–150K
18150K+
384 reports with mileage · 234 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Electrical System. Review the 78 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Structure. Review the 67 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Suspension. Review the 66 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
36 crash reports17 fire reports24 injury reports
What owners actually said
618 reports
42,000 miles · Jan 12, 2016
Suspension
WHILE DRIVING THE VEHICLE PULLED THE STEERING WHEEL HARD TO THE RIGHT. WE WERE DRIVING SLOW IN TOWN, HAD THIS HAPPENED AT HIGHWAY SPEED A WRECK WOULD HAVE BEEN UNAVOIDABLE . GOT THE VEHICLE TOWED HOME AND TOOK A LOOK AT IT . FOUND THE FRONT SUB FRAME (TO WHICH THE STEERING GEAR, LOWER CONTROL ARMS AND SUCH ARE BOLTED TO) HAD RUS…
Read full complaint
WHILE DRIVING THE VEHICLE PULLED THE STEERING WHEEL HARD TO THE RIGHT. WE WERE DRIVING SLOW IN TOWN, HAD THIS HAPPENED AT HIGHWAY SPEED A WRECK WOULD HAVE BEEN UNAVOIDABLE . GOT THE VEHICLE TOWED HOME AND TOOK A LOOK AT IT . FOUND THE FRONT SUB FRAME (TO WHICH THE STEERING GEAR, LOWER CONTROL ARMS AND SUCH ARE BOLTED TO) HAD RUSTED TO THE POINT THAT IT CRACKED , ON THE RIGHT HAND SIDE. THIS ALLOWED THE RIGHT LOWER CONTROL ARM TO SHIFT BACKWARD CAUSING THE DEATH PULL TO THE RIGHT.
NHTSA ODI #10819858
Mileage unknown · Jan 7, 2016
Wheels
I HAVE ALWAYS HAD TROUBLE KEEPING AIR IN THE TIRE OF THIS CAR. I HAVE TALKED TO OTHER OWNERS AND THEY TO HAVE HAD TROUBLE. IT IS THE CHROME WHEELS THAT IS CAUSING THE PROBLEM. WE HAVE NOT HAD AN ACCIDENT BUT I'M SURE SOME ONE HAS. IT ALSO HAPPENED IN MY DAUGHTERS STRATUS RT , CHROME WHEELS. I TALKED TO GM PEOPLE THAT HAD CHROME…
Read full complaint
I HAVE ALWAYS HAD TROUBLE KEEPING AIR IN THE TIRE OF THIS CAR. I HAVE TALKED TO OTHER OWNERS AND THEY TO HAVE HAD TROUBLE. IT IS THE CHROME WHEELS THAT IS CAUSING THE PROBLEM. WE HAVE NOT HAD AN ACCIDENT BUT I'M SURE SOME ONE HAS. IT ALSO HAPPENED IN MY DAUGHTERS STRATUS RT , CHROME WHEELS. I TALKED TO GM PEOPLE THAT HAD CHROME WHEEL FROM THAT ERA AND THEY TO HAD PROBLEMS WITH THE CHROME WHEELS. I WAS WONDERING IF YOU HAVE HAD ANY OTHER COMPLAINTS OF THIS NATURE. I STILL HAVE THE CAR BUT MY DAUGHTER GOT RID OF HERS. WE HAD TO PUT ANOTHER TIRE ON THE CAR THIS WEEK BECAUSE THE TIRES KEEP LOSING AIR. I TALKED TO THE DEALERSHIP YEARS BACK AND THEY SAID THERE WAS KNOW PROBLEM. I SHOULD HAVE DONE THIS YEARS AGO BUT NEVER DID.
NHTSA ODI #10818823
155,621 miles · Sep 9, 2015
SteeringStructure
TL* THE CONTACT OWNS A 2001 CHRYSLER PT CRUISER. THE CONTACT STATED THAT THE SERVICE ENGINE WARNING LIGHT FLICKERED AND SUDDENLY REMAINED ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE UNDERBODY PREMATURELY RUSTED AND COULD FRACTURE AT ANY MOMENT. THE VEHICLE WAS ALSO TAKEN TO AN INDEPENDENT REPAI…
Read full complaint
TL* THE CONTACT OWNS A 2001 CHRYSLER PT CRUISER. THE CONTACT STATED THAT THE SERVICE ENGINE WARNING LIGHT FLICKERED AND SUDDENLY REMAINED ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE UNDERBODY PREMATURELY RUSTED AND COULD FRACTURE AT ANY MOMENT. THE VEHICLE WAS ALSO TAKEN TO AN INDEPENDENT REPAIR WHO DIAGNOSED THAT THE CASING FOR THE FRAME NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. IN ADDITION, THE CONTACT STATED THAT POWER STEERING FLUID HAD TO BE CONSTANTLY ADDED TO THE VEHICLE. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 04V268000 (STEERING). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 155,621.
NHTSA ODI #10762585
85,540 miles · Sep 6, 2015
Seat Belts
THE DRIVER SEAT BELT WILL NOT STAY FASTENED IT COMES LOSE AND HITS ME IN THE FACE OR HEAD AS IT RETRACTS THE FAILURE OF IT TO LOCK IN IN THIS TYPE OF CIRCUMSTANCE IS DANGEROUS AND THE SEAT BELT IS INEFFECTIVE AND MAKES THE CAR UNSAFE
NHTSA ODI #10761836
46,403 miles · Jul 27, 2015
Steering
FRONT SUB FRAME (CROSS MEMBER) BROKE APART AT WELD.
NHTSA ODI #10743592
Mileage unknown · Jun 16, 2015
TiresCrash
AFTER REGULAR ROAD DRIVEING FOR A MONTH HAD FRONT TIRES WEAR DOWN TO STEEL BELT, PURCHASED TIRES AT WALMART SO TOOK CAR BACK IN TO HAVE TIRES LOOKED AT WAS TOLD IT WAS AN ALIGNMENT ISSUE. I KNOW THIS IS NOT THE CASE BECAUSE CAR HAD JUST BEEN SERVICED AND ALIGNMENT CHECKED THE SAME DAY TIRE WERE PUT ON CAR. THE WEAR OUT IS ON THE…
Read full complaint
AFTER REGULAR ROAD DRIVEING FOR A MONTH HAD FRONT TIRES WEAR DOWN TO STEEL BELT, PURCHASED TIRES AT WALMART SO TOOK CAR BACK IN TO HAVE TIRES LOOKED AT WAS TOLD IT WAS AN ALIGNMENT ISSUE. I KNOW THIS IS NOT THE CASE BECAUSE CAR HAD JUST BEEN SERVICED AND ALIGNMENT CHECKED THE SAME DAY TIRE WERE PUT ON CAR. THE WEAR OUT IS ON THE INSIDES OF BOTH FRONT TIRES, AND MINOR WEAR ON THE INSIDES OF THE REAR TIRES AS WELL AS MAJORITY OF THE TREAD IS WORN OFF AS WELL ON ALL 4 TIRES. THIS WEAR DOWN CAUSED ME TO GO INTO DITCH IN SNOWY CONDITIONS, WHILE DRIVEING AT SAFE SPEEDS.
NHTSA ODI #10725607
Mileage unknown · Jun 1, 2015
Electrical SystemEnginePower TrainFire
WAS DRIVING VEHICLE GOING 55 MPH AND DASHBOARD FAULTS OUT WITH INCOHERENT READINGS AND TRANSAXLE SHIFTS SELF INTO NEUTRAL. I SHIFT GEAR SELECTOR INTO NEUTRAL AND BACK INTO DRIVE. DASHBOARD READINGS GO BACK TO NORMAL AND TRANSAXLE GOES BACK INTO DRIVE. 15 SECONDS LATER BATTERY LIGHT COMES ON. CONTINUE DRIVING TO FIND A PLACE TO P…
Read full complaint
WAS DRIVING VEHICLE GOING 55 MPH AND DASHBOARD FAULTS OUT WITH INCOHERENT READINGS AND TRANSAXLE SHIFTS SELF INTO NEUTRAL. I SHIFT GEAR SELECTOR INTO NEUTRAL AND BACK INTO DRIVE. DASHBOARD READINGS GO BACK TO NORMAL AND TRANSAXLE GOES BACK INTO DRIVE. 15 SECONDS LATER BATTERY LIGHT COMES ON. CONTINUE DRIVING TO FIND A PLACE TO PARK. AFTER ABOUT 10 SECONDS ENGINE STALLS OUT. SHIFT GEAR SELECTOR INTO NEUTRAL AND TRY TO RESTART VEHICLE BUT IT WON'T START. COAST TO A STOP AND OPEN HOOD. NOTICE AN ODD SMELL. OPEN HOOD AND ALTERNATOR IS ON FIRE. CLOSE HOOD AND GRAB PERSONAL BELONGINGS (EXCEPT FOR PHONE CHARGER) OUT OF VEHICLE. CALL 911 AS VEHICLE BURNS UP. FIRE AND POLICE ARRIVE AND EXTINGUISH FIRE BUT VEHICLE BADLY DESTROYED BY BEING ENGULFED IN FLAMES.
NHTSA ODI #10722604
85,000 miles · May 25, 2015
Unknown Or Other
DASHBOARD STARTED CRACKING AND CONTINUED TO CRACK FROM WINDSHIELD AREA ALL THE WAY DOWN TO BOTTOM,THEN ANOTHER CRACK STARTED AND DID THE SAME.THESE DASHBOARDS ARENT MADE PROPERLY AND BOTH CRACKS ARE ON THE PASSENGER SIDE.IM AFRAID THE AIRBAG WILL DEPLOY SOMEDAY.MY WIFE HAS A CHRYSLER 300M 1999 AND SHE HAS THE SAME PROBLEM WITH …
Read full complaint
DASHBOARD STARTED CRACKING AND CONTINUED TO CRACK FROM WINDSHIELD AREA ALL THE WAY DOWN TO BOTTOM,THEN ANOTHER CRACK STARTED AND DID THE SAME.THESE DASHBOARDS ARENT MADE PROPERLY AND BOTH CRACKS ARE ON THE PASSENGER SIDE.IM AFRAID THE AIRBAG WILL DEPLOY SOMEDAY.MY WIFE HAS A CHRYSLER 300M 1999 AND SHE HAS THE SAME PROBLEM WITH HER DASHBOARD.
NHTSA ODI #10721339
100,000 miles · Apr 25, 2015
Unknown Or Other
I SLOWED DOWNED FOR A RAIL ROAD CROSSING AND AFTER I CROSSED IT THE FRONT END DROPPED DOWN . I LOST CONTROL OF THE CAR . THE CAR VEERED RIGHT . I GOT STOPPED BEFORE I GOT TO THE DITCH . WE COULDN'T MOVE THE CAR . HAD IT TOWED TO A GARAGE . AFTER INSPECTION THEY TOLD ME THE FRAME THAT HOLDS THE SUSPENSION TOGETHER RUSTED THROUGH …
Read full complaint
I SLOWED DOWNED FOR A RAIL ROAD CROSSING AND AFTER I CROSSED IT THE FRONT END DROPPED DOWN . I LOST CONTROL OF THE CAR . THE CAR VEERED RIGHT . I GOT STOPPED BEFORE I GOT TO THE DITCH . WE COULDN'T MOVE THE CAR . HAD IT TOWED TO A GARAGE . AFTER INSPECTION THEY TOLD ME THE FRAME THAT HOLDS THE SUSPENSION TOGETHER RUSTED THROUGH AND BROKE IN HALF . IT PUSHED THE SUSPENSION UP AND AGAINST THE ENGINE . IF I WOULD HAVE BEEN GOING ANY FASTER COULD HAVE VEERED LEFT TO A HEAD ON CRASH OR HIT THE DITCH AND FLIPPED THE CAR . DEFINITELY THINK THIS IS DESIGN FLAW , WHEN YOUR FRAME FAILS AND YOU LOOSE CONTROL OF YOUR VEHICLE . A POT HOLE COULD AT 55 MPH COULD HAVE DONE THE SAME THING ONLY WITH MORE TRAGIC CONSEQUENCES. *TR
NHTSA ODI #10712825
209,999 miles · Apr 6, 2015
Fuel/propulsion System
FUEL LINE WAS CHAFING AGAINST THE AIR CONDITIONING SERVICE PORT CAUSING A LEAK IN THE FUEL LINE. FUEL WAS SPRAYING IN THE ENGINE COMPARTMENT. EXTREME FIRE HAZARD. *TR
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.4L NON-TURBOCHARGED ENGINES AND AUTOMATIC TRANSAXLES, THE POWER STEERING PRESSURE HOSE MAY CONTACT THE AUTOMATIC TRANSAXLE DIFFERENTIAL COVER, POTENTIALLY DAMAGING THE HOSE.
Consequence & remedy
Consequence: POWER STEERING FLUID LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSPECT AND RELOCATE, OR REPLACE AS NECESSARY, THE POWER STEERING HOSE AND CONFIRM TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END. THE RECALL BEGAN ON SEPTEMBER 20, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
ON CERTAIN PASSENGER VEHICLES, THE FUEL SUPPLY LINE COULD CONTACT THE AIR-CONDITIONING TUBE SERVICE PORT. THIS CAN CAUSE CHAFING OF THE LINE RESULTING IN A FUEL LEAKAGE.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT THE FUEL LINE FOR ABRASION AND INSTALL A CLIP TO ENSURE ISOLATION. IN CASES WITH EVIDENCE OF FUEL LINE ABRASION, THE FUEL LINE WILL BE REPLACED. OWNER NOTIFICATION BEGAN AUGUST 12, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
ON CERTAIN PASSENGER VEHICLES, THE FUEL PUMP MODULE MOUNTING FLANGE COULD LEAK FUEL IF THE VEHICLE IS INVOLVED IN A ROLLOVER CRASH.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A SECONDARY SEAL OVER THE FUEL PUMP MODULE. OWNER NOTIFICATION BEGAN AUGUST 12, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE RIGHT REAR "65%" SEAT CENTER LOWER ANCHOR WAS MANUFACTURED WITH A WIRE DIAMETER THAT IS GREATER THAN THE MAXIMUM ALLOWABLE DIMENSION AS SPECIFIED IN THE STANDARD.
Consequence & remedy
Consequence: IF THE CONNECTOR FOR A LATCH-TYPE CHILD RESTRAINT IS NOT ATTACHED CORRECTLY TO THE ANCHORAGE POINTS, THE RESTRAINT WILL NOT PROPERLY PROTECT A CHILD IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL INSPECT THE RIGHT REAR SEAT CENTER ANCHOR AND, IF NECESSARY, RESIZE THE ANCHOR TO MEET THE DIAMETER SPECIFIED WITHIN THE STANDARD. OWNER NOTIFICATION BEGAN NOVEMBER 4, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES, PICKUP TRUCKS AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." SOME OF THE OWNER'S MANUALS FOR THESE VEHICLES ARE MISSING INSTRUCTIONS THAT PROVIDE A STEP-BY-STEP PROCEDURE, INCLUDING DIAGRAMS, FOR PROPERLY ATTACHING A CHILD RESTRAINT SYSTEM'S TETHER STRAP TO THE TETHER ANCHORAGE.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE CHILD SEAT MAY NOT BE PROPERLY ATTACHED INCREASING THE RISK OF INJURY TO THE CHILD.
Remedy: OWNERS WILL BE PROVIDED WITH AN ADDENDUM TO THE OWNER'S MANUALS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
PE04028 · Engine Compartment Fires
Opened Mar 15, 2004 · Closed Jun 18, 2004
Status: closed (inferred from source dates) · Steering; Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:hose, Piping, And Connections; Steering:hydraulic Power Assist:power Steering Fluid
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Additional source detail variants (4)
Steering
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist:hose, Piping, And Connections
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist:power Steering Fluid
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist System
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
PE02082 · Safety Belt Cinching Latch Plate
Opened Nov 6, 2002 · Closed Apr 23, 2003
Status: closed (inferred from source dates) · Seat Belts
THERE ARE NO INJURIES OR FATALITIES ASSOCIATED WITH THIS ALLEGED DEFECT.WHILE CONDUCTING THIS INVESTIGATION, ODI FOUND THAT THE SUBJECT CINCHES MEET THE LOAD BEARING REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD 208, AND THAT MANY OF THE REPORTED FAILURES WERE DUE TO INCORRECT CHILD SAFETY SEAT INSTALLATIONS. ADDITIONALLY, THE REPORT RATE IS LOW (1.60/100K).THE INFORMATION AVAILABLE FAILS TO ESTABLISH THE EXISTENCE OF A DEFECT TREND AT THIS TIME.FURTHER ALLOCATION OF AGENCY RESOURCES TO THIS ISSUE IS UNWARRANTED AND THE PRELIMINARY EVALUATION IS BEING CLOSED.
PE02058 · Fuel Hose Abrasion
Opened Jul 19, 2002 · Closed Oct 4, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
No summary supplied.
2001 Chrysler Pt Cruiser Problems, Complaints & Recalls | Skip That Year
Illustration