NHTSA owner reports · September 18, 2026 snapshot.
Suspension complaints
66 reportsClear category filter100,000 miles · Aug 8, 2016
Suspension
TL* THE CONTACT OWNS A 2001 CHRSYLER PT CRUISER. WHILE DRIVING AT ANY SPEED, THE FRONT END OF THE VEHICLE MADE A LOUD NOISE. THE CONTACT STATED THAT THE CROSS MEMBER FRAME HAD RUSTED OUT. THE VIN WAS EXCLUDED FROM NHTSA CAMPAIGN NUMBER: 16V387000 (SUSPENSION). THE DEALER WAS NOTIFIED, BUT THE VEHICLE WAS NOT REPAIRED. THE APPROX…
Read full complaint
TL* THE CONTACT OWNS A 2001 CHRSYLER PT CRUISER. WHILE DRIVING AT ANY SPEED, THE FRONT END OF THE VEHICLE MADE A LOUD NOISE. THE CONTACT STATED THAT THE CROSS MEMBER FRAME HAD RUSTED OUT. THE VIN WAS EXCLUDED FROM NHTSA CAMPAIGN NUMBER: 16V387000 (SUSPENSION). THE DEALER WAS NOTIFIED, BUT THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.
NHTSA ODI #10894111
60,245 miles · Feb 24, 2016
EngineSuspensionVisibility/wiper
"TAKATA RECALL " IN MY PT CRUISER THE ENGINE DROPPED DOWN IN THE CAR AND THE FRONT AXLE BAR AND FRAME WAS BROKEN AND THE WHEELS COULD NOT TURN OR CONTROL THE CAR I AM LUCKY TO BE ALIVE THE VEHICLE WAS IN MOTION ON A CITY STREET TRYING TO TURN INTO A ICE CREAM SHOP THE CAR IS STILL DOING A SUDDEN JERKING WHEN DRIVEN AND AFTER PA…
Read full complaint
"TAKATA RECALL " IN MY PT CRUISER THE ENGINE DROPPED DOWN IN THE CAR AND THE FRONT AXLE BAR AND FRAME WAS BROKEN AND THE WHEELS COULD NOT TURN OR CONTROL THE CAR I AM LUCKY TO BE ALIVE THE VEHICLE WAS IN MOTION ON A CITY STREET TRYING TO TURN INTO A ICE CREAM SHOP THE CAR IS STILL DOING A SUDDEN JERKING WHEN DRIVEN AND AFTER PAYING A LOT OF MONEY TO GET IT STARTED AND FIXED I AM STILL HAVING PROBLEMS WITH THIS CAR AND NO MONEY TO GET ANOTHER.
NHTSA ODI #10838021
42,000 miles · Jan 12, 2016
Suspension
WHILE DRIVING THE VEHICLE PULLED THE STEERING WHEEL HARD TO THE RIGHT. WE WERE DRIVING SLOW IN TOWN, HAD THIS HAPPENED AT HIGHWAY SPEED A WRECK WOULD HAVE BEEN UNAVOIDABLE . GOT THE VEHICLE TOWED HOME AND TOOK A LOOK AT IT . FOUND THE FRONT SUB FRAME (TO WHICH THE STEERING GEAR, LOWER CONTROL ARMS AND SUCH ARE BOLTED TO) HAD RUS…
Read full complaint
WHILE DRIVING THE VEHICLE PULLED THE STEERING WHEEL HARD TO THE RIGHT. WE WERE DRIVING SLOW IN TOWN, HAD THIS HAPPENED AT HIGHWAY SPEED A WRECK WOULD HAVE BEEN UNAVOIDABLE . GOT THE VEHICLE TOWED HOME AND TOOK A LOOK AT IT . FOUND THE FRONT SUB FRAME (TO WHICH THE STEERING GEAR, LOWER CONTROL ARMS AND SUCH ARE BOLTED TO) HAD RUSTED TO THE POINT THAT IT CRACKED , ON THE RIGHT HAND SIDE. THIS ALLOWED THE RIGHT LOWER CONTROL ARM TO SHIFT BACKWARD CAUSING THE DEATH PULL TO THE RIGHT.
NHTSA ODI #10819858
180,000 miles · Dec 19, 2014
EngineStructureSuspension
I FILED A CLAIM WITH CHRYSLER ABOUT THE RUSTED OUT ENGINE CRADLE AND THEY REFUSED TO REPLACE IT. *TR
NHTSA ODI #10667333
112,332 miles · Mar 28, 2014
Electrical SystemSteeringSuspension
I BOUGHT A CAR FROM NORTH COAST AUTO MALL AND IT HAD A LOT OF SUSPENSION PROBLEMS. THEY ENSURED ME THAT THEY WOULD FIX THESE ISSUES IF I BOUGHT THE CAR. AFTER BUYING THE CAR, THEY HAVE HAD ME IN AND OUT OF THEIR SHOP 4 OR 5 TIMES TO WHICH THEY ONLY LUBE THE PARTS OR LIE TO ME CLAIMING THAT THE CAR HAS BEEN FIXED. I FEEL THAT THI…
Read full complaint
I BOUGHT A CAR FROM NORTH COAST AUTO MALL AND IT HAD A LOT OF SUSPENSION PROBLEMS. THEY ENSURED ME THAT THEY WOULD FIX THESE ISSUES IF I BOUGHT THE CAR. AFTER BUYING THE CAR, THEY HAVE HAD ME IN AND OUT OF THEIR SHOP 4 OR 5 TIMES TO WHICH THEY ONLY LUBE THE PARTS OR LIE TO ME CLAIMING THAT THE CAR HAS BEEN FIXED. I FEEL THAT THIS BUSINESS PRACTICE IS UNSAFE AND MISLEADING. THEY CLAIMED TO HAVE REPLACED A CONTROL ARM TO WHICH GOODYEAR LATER (WHEN I WAS BUYING TIRES) INFORMED ME THAT MY CONTROL ARMS WERE BAD. I WAS SURPRISED TO HEAR THIS. NORTH COAST SHOULD BE INVESTIGATED AS THEY ARE SELLING UNSAFE CARS, CLAIMING TO REPAIR ISSUES AND THEN PUTTING ME IN AN UNSAFE CAR. 30 CLAIMS HAVE BEEN MADE ABOUT SIMILAR ISSUES VIA THE BETTER BUSINESS BUREAU, THE FEDERAL TRADE COMMISSION AND THE OHIO ATTORNEY GENERAL. I FEEL THAT THEY SHOULD BE INVESTIGATED FOR SAFETY REASONS. *TR
NHTSA ODI #10575277
56,000 miles · Mar 4, 2014
Suspension
WHILE SLOWING DOWN TO STOP FOR A RED LIGHT MY CAR SUDDENLY VEERED TO THE RIGHT. I HAD TO TURN THE STEERING WHEEL TO THE LEFT TO KEEP THE CAR STRAIGHT WHILE I STOPPED. I HAD THE CAR TOWED TO A GARAGE AND UPON INSPECTION THEY FOUND THE CROSSMEMBERS UNDER THE ENGINE WERE COMPLETELY RUSTED AND BROKEN. I BOUGHT THE CAR NEW AND ALTHO…
Read full complaint
WHILE SLOWING DOWN TO STOP FOR A RED LIGHT MY CAR SUDDENLY VEERED TO THE RIGHT. I HAD TO TURN THE STEERING WHEEL TO THE LEFT TO KEEP THE CAR STRAIGHT WHILE I STOPPED. I HAD THE CAR TOWED TO A GARAGE AND UPON INSPECTION THEY FOUND THE CROSSMEMBERS UNDER THE ENGINE WERE COMPLETELY RUSTED AND BROKEN. I BOUGHT THE CAR NEW AND ALTHOUGH THE CAR IS 13 YEARS OLD IT ONLY HAS 56,000 MILES AND HAS ALWAYS BEEN STORED IN A GARAGE.
NHTSA ODI #10567308
62,000 miles · Nov 12, 2013
Suspension
WHILE DRIVING AT 30 MILES AN HOUR, THE FRONT SUSPENSION CROSS-MEMBER BROKE AS A RESULT OF SEVERE RUST. THIS CAUSED THE RIGHT FRONT WHEEL TO STEER TOWARDS THE DITCH CREATING A SIGNIFICANT SAFETY HAZARD. THE RUST WAS CAUSED BY WATER DRAINING FROM THE AIR CONDITIONER ONTO THE PASSENGER'S SIDE OF THE CROSS-MEMBER. I HAVE ATTEMPTED T…
Read full complaint
WHILE DRIVING AT 30 MILES AN HOUR, THE FRONT SUSPENSION CROSS-MEMBER BROKE AS A RESULT OF SEVERE RUST. THIS CAUSED THE RIGHT FRONT WHEEL TO STEER TOWARDS THE DITCH CREATING A SIGNIFICANT SAFETY HAZARD. THE RUST WAS CAUSED BY WATER DRAINING FROM THE AIR CONDITIONER ONTO THE PASSENGER'S SIDE OF THE CROSS-MEMBER. I HAVE ATTEMPTED TO ORDER A REPLACEMENT PART FROM CHRYSLER BUT SO FAR THE OUTLOOK FOR DELIVERY HAS CHANGED FOUR TIMES AND IS CURRENTLY ESTIMATED FOR 12/25/2013 (2.5 MONTHS AFTER THE CAR BECAME INOPERABLE). NOT ONLY DOES CHRYSLER IGNORE THE NUMEROUS REPORTS OF THIS COMMONLY REPORTED DESIGN FLAW, THEY ARE PROVING TO BE INCAPABLE AT PROVIDING REPLACEMENT PARTS. THIS IS EVIDENT AS I AM ONE OF 28 CAR OWNERS WHO ARE WAITING FOR THIS PART FROM CHRYSLER, AND THERE IS HIGH DEMAND FOR THIS PART FROM JUNKYARDS. *TR
NHTSA ODI #10552013
75,000 miles · Oct 19, 2013
Power TrainStructureSuspension
UPON INSPECTION DURING A REPAIR FOR ANOTHER PROBLEM IT WAS DISCOVERED THAT THE FRONT SUSPENSION CROSSMEMBER KNOWN AS THE K-FRAME IS SEVERELY CORRODED AND WILL LIKELY NOT PASS ANOTHER SAFETY INSPECTION. THE REST OF THE UNDERNEATH OF THIS CAR IS RELATIVELY RUST-FREE AND THIS IS A LOW MILEAGE VEHICLE FOR ITS AGE. IF THIS PART FA…
Read full complaint
UPON INSPECTION DURING A REPAIR FOR ANOTHER PROBLEM IT WAS DISCOVERED THAT THE FRONT SUSPENSION CROSSMEMBER KNOWN AS THE K-FRAME IS SEVERELY CORRODED AND WILL LIKELY NOT PASS ANOTHER SAFETY INSPECTION. THE REST OF THE UNDERNEATH OF THIS CAR IS RELATIVELY RUST-FREE AND THIS IS A LOW MILEAGE VEHICLE FOR ITS AGE. IF THIS PART FAILS GOING DOWN THE HIGHWAY THE ENGINE, TRANSMISSION, ETC. WILL ALL DROP AND CAUSE THE VEHICLE TO LOSE CONTROL. *TR
NHTSA ODI #10548509
59,700 miles · Sep 3, 2013
EngineStructureSuspensionCrash
I WAS MAKING A RIGHT HAND TURN FROM A MAIN ROAD ONTO A SIDE STREET. WHILE THE CAR WAS TURNING, I HEARD A CLUNK AND THE STEERING WHEEL WAS JERKED FROM MY HANDS. THE CAR PULLED HARD TO THE RIGHT AND CRASHED INTO THE CURB. THE CAR WAS TOWED TO THE REPAIR SHOP AND THE SERVICE TECH SHOWED ME THE ENGINE CRADLE WAS COMPLETELY RUSTED OU…
Read full complaint
I WAS MAKING A RIGHT HAND TURN FROM A MAIN ROAD ONTO A SIDE STREET. WHILE THE CAR WAS TURNING, I HEARD A CLUNK AND THE STEERING WHEEL WAS JERKED FROM MY HANDS. THE CAR PULLED HARD TO THE RIGHT AND CRASHED INTO THE CURB. THE CAR WAS TOWED TO THE REPAIR SHOP AND THE SERVICE TECH SHOWED ME THE ENGINE CRADLE WAS COMPLETELY RUSTED OUT AND THE K FRAME WAS CRACKED ALL THE WAY THRU. IT'S TO RUSTED TO BE WELDED AND I WAS TOLD THIS IS A COMMON PROBLEM WITH THE CRUISER AND DODGE NEON, SINCE THEY USE THE SAME FRAME. THE TECH ALSO TOLD ME I WAS LUCKY THAT I WASN'T MOVING AT HIGH SPEED OR THE RESULTS COULD HAVE BEEN FATAL. HE ALSO TOLD ME THAT CHRYSLER IS AWARE OF THIS PROBLEM, THEY ARE COMPLETELY OUT OF REPLACEMENT PARTS, AND THEY BASICALLY IGNORE ANY COMPLAINTS. *JB
NHTSA ODI #10541698
76,000 miles · Aug 14, 2013
StructureSuspension
THE FRONT SUSPENSION CROSS-MEMBER IS SEVERELY RUSTED AND WILL REQUIRE REPLACEMENT BEFORE THE CAR WILL PASS INSPECTION. THE CAR WAS IN FOR ROUTINE SERVICE WHEN MY MECHANIC POINTED OUT THAT THE ONLY RUSTED PART ON THE VEHICLE WAS THE FRONT SUSPENSION CROSS-MEMBER AND THAT IT WAS BORDERING ON UNSAFE. THIS CAR HAS RELATIVELY LOW M…
Read full complaint
THE FRONT SUSPENSION CROSS-MEMBER IS SEVERELY RUSTED AND WILL REQUIRE REPLACEMENT BEFORE THE CAR WILL PASS INSPECTION. THE CAR WAS IN FOR ROUTINE SERVICE WHEN MY MECHANIC POINTED OUT THAT THE ONLY RUSTED PART ON THE VEHICLE WAS THE FRONT SUSPENSION CROSS-MEMBER AND THAT IT WAS BORDERING ON UNSAFE. THIS CAR HAS RELATIVELY LOW MILES AT 76K AND IS IN EXCELLENT CONDITION OTHERWISE. THIS RUSTED PART COULD FAIL WITH NO INDICATION THAT DANGER WAS IMMINENT AND CAUSE LOSS OF STEERING AND ULTIMATELY A VEHICLE CRASH AT ANY SPEED. *TR
NHTSA ODI #10535272
Official recalls
5Jun 3, 2004
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.4L NON-TURBOCHARGED ENGINES AND AUTOMATIC TRANSAXLES, THE POWER STEERING PRESSURE HOSE MAY CONTACT THE AUTOMATIC TRANSAXLE DIFFERENTIAL COVER, POTENTIALLY DAMAGING THE HOSE.
Consequence & remedy
Consequence: POWER STEERING FLUID LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSPECT AND RELOCATE, OR REPLACE AS NECESSARY, THE POWER STEERING HOSE AND CONFIRM TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END. THE RECALL BEGAN ON SEPTEMBER 20, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Aug 8, 2002
ON CERTAIN PASSENGER VEHICLES, THE FUEL SUPPLY LINE COULD CONTACT THE AIR-CONDITIONING TUBE SERVICE PORT. THIS CAN CAUSE CHAFING OF THE LINE RESULTING IN A FUEL LEAKAGE.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT THE FUEL LINE FOR ABRASION AND INSTALL A CLIP TO ENSURE ISOLATION. IN CASES WITH EVIDENCE OF FUEL LINE ABRASION, THE FUEL LINE WILL BE REPLACED. OWNER NOTIFICATION BEGAN AUGUST 12, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Aug 8, 2002
ON CERTAIN PASSENGER VEHICLES, THE FUEL PUMP MODULE MOUNTING FLANGE COULD LEAK FUEL IF THE VEHICLE IS INVOLVED IN A ROLLOVER CRASH.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A SECONDARY SEAL OVER THE FUEL PUMP MODULE. OWNER NOTIFICATION BEGAN AUGUST 12, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Jun 14, 2002
CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE RIGHT REAR "65%" SEAT CENTER LOWER ANCHOR WAS MANUFACTURED WITH A WIRE DIAMETER THAT IS GREATER THAN THE MAXIMUM ALLOWABLE DIMENSION AS SPECIFIED IN THE STANDARD.
Consequence & remedy
Consequence: IF THE CONNECTOR FOR A LATCH-TYPE CHILD RESTRAINT IS NOT ATTACHED CORRECTLY TO THE ANCHORAGE POINTS, THE RESTRAINT WILL NOT PROPERLY PROTECT A CHILD IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL INSPECT THE RIGHT REAR SEAT CENTER ANCHOR AND, IF NECESSARY, RESIZE THE ANCHOR TO MEET THE DIAMETER SPECIFIED WITHIN THE STANDARD. OWNER NOTIFICATION BEGAN NOVEMBER 4, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Nov 9, 2000
VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES, PICKUP TRUCKS AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." SOME OF THE OWNER'S MANUALS FOR THESE VEHICLES ARE MISSING INSTRUCTIONS THAT PROVIDE A STEP-BY-STEP PROCEDURE, INCLUDING DIAGRAMS, FOR PROPERLY ATTACHING A CHILD RESTRAINT SYSTEM'S TETHER STRAP TO THE TETHER ANCHORAGE.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE CHILD SEAT MAY NOT BE PROPERLY ATTACHED INCREASING THE RISK OF INJURY TO THE CHILD.
Remedy: OWNERS WILL BE PROVIDED WITH AN ADDENDUM TO THE OWNER'S MANUALS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3PE04028 · Engine Compartment Fires
Opened Mar 15, 2004 · Closed Jun 18, 2004
Status: closed (inferred from source dates) · Steering; Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:hose, Piping, And Connections; Steering:hydraulic Power Assist:power Steering Fluid
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Additional source detail variants (4)
Steering
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist:hose, Piping, And Connections
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist:power Steering Fluid
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist System
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
PE02082 · Safety Belt Cinching Latch Plate
Opened Nov 6, 2002 · Closed Apr 23, 2003
Status: closed (inferred from source dates) · Seat Belts
THERE ARE NO INJURIES OR FATALITIES ASSOCIATED WITH THIS ALLEGED DEFECT.WHILE CONDUCTING THIS INVESTIGATION, ODI FOUND THAT THE SUBJECT CINCHES MEET THE LOAD BEARING REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD 208, AND THAT MANY OF THE REPORTED FAILURES WERE DUE TO INCORRECT CHILD SAFETY SEAT INSTALLATIONS. ADDITIONALLY, THE REPORT RATE IS LOW (1.60/100K).THE INFORMATION AVAILABLE FAILS TO ESTABLISH THE EXISTENCE OF A DEFECT TREND AT THIS TIME.FURTHER ALLOCATION OF AGENCY RESOURCES TO THIS ISSUE IS UNWARRANTED AND THE PRELIMINARY EVALUATION IS BEING CLOSED.
PE02058 · Fuel Hose Abrasion
Opened Jul 19, 2002 · Closed Oct 4, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
No summary supplied.
Illustration