TL* THE CONTACT OWNED A 2001 CHRYSLER PT CRUISER. THE CONTACT STATED THAT THE VEHICLE WAS INVOLVED IN A FRONT END COLLISION WHILE DRIVING 25 MPH. THE SEAT BELT PRE-TENSIONER DID NOT LOCK AND THE AIR BAGS DID NOT DEPLOY. THE FAILURE OCCURRED WITHOUT WARNING. THE VEHICLE WAS NOT TOWED TO THE CONTACT'S RESIDENCE. A POLICE REPORT WA…
Read full complaint
TL* THE CONTACT OWNED A 2001 CHRYSLER PT CRUISER. THE CONTACT STATED THAT THE VEHICLE WAS INVOLVED IN A FRONT END COLLISION WHILE DRIVING 25 MPH. THE SEAT BELT PRE-TENSIONER DID NOT LOCK AND THE AIR BAGS DID NOT DEPLOY. THE FAILURE OCCURRED WITHOUT WARNING. THE VEHICLE WAS NOT TOWED TO THE CONTACT'S RESIDENCE. A POLICE REPORT WAS FILED. THERE WAS ONE INJURY THAT REQUIRED MEDICAL ATTENTION. THE CONTACT SUFFERED FROM A BRUISED CHEST, HANDS, SHOULDER PAIN, NECK PAIN, AND LEG PAIN. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS INVALID. THE FAILURE MILEAGE WAS APPROXIMATELY 53,000. UPDATED 05/04/16*LJ *CN
NHTSA ODI #10822378
85,540 miles · Sep 6, 2015
Seat Belts
THE DRIVER SEAT BELT WILL NOT STAY FASTENED IT COMES LOSE AND HITS ME IN THE FACE OR HEAD AS IT RETRACTS THE FAILURE OF IT TO LOCK IN IN THIS TYPE OF CIRCUMSTANCE IS DANGEROUS AND THE SEAT BELT IS INEFFECTIVE AND MAKES THE CAR UNSAFE
NHTSA ODI #10761836
97,000 miles · Nov 20, 2013
Seat BeltsCrashInjury
TL* THE CONTACT OWNS A 2001 CHRYSLER PT CRUISER. THE CONTACT STATED THAT ANOTHER VEHICLE CRASHED INTO THE REAR OF HER VEHICLE WHILE SITTING AT A COMPLETE STOP. THE AIR BAGS FAILED TO DEPLOY AND THE SEAT BELT TENSIONER FAILED TO RESTRAIN THE CONTACT. THE CONTACT SUSTAINED INJURIES WHEN SHE WAS THROWN INTO THE STEERING WHEEL. THE…
Read full complaint
TL* THE CONTACT OWNS A 2001 CHRYSLER PT CRUISER. THE CONTACT STATED THAT ANOTHER VEHICLE CRASHED INTO THE REAR OF HER VEHICLE WHILE SITTING AT A COMPLETE STOP. THE AIR BAGS FAILED TO DEPLOY AND THE SEAT BELT TENSIONER FAILED TO RESTRAIN THE CONTACT. THE CONTACT SUSTAINED INJURIES WHEN SHE WAS THROWN INTO THE STEERING WHEEL. THERE WERE A TOTAL OF FOUR VEHICLES INVOLVED IN THE CRASH. THE VEHICLE WAS ABLE TO BE DRIVEN FROM THE CRASH SITE BUT WAS NOT INSPECTED TO DETERMINE THE CAUSE OF THE AIR BAG OR SEATBELT FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 97,000.
NHTSA ODI #10553029
88,000 miles · Sep 14, 2009
Seat Belts
SEAT BELT TENSIONER JAMS IN MIDDLE REAR SEAT OF 2001 CHRYSLER PT CRUISER. I PREVIOUSLY PAID TO REPAIR THIS EXACT SAME PROBLEM IN 2004 AND IT HAS HAPPENED AGAIN. CONTACTED CHRYSLER AND THE LOCAL DEALERSHIP BUT THE ONLY SOLUTION SEEMS FOR ME TO PAY TO FIX IT AGAIN. I HAVE BEEN DRIVING CARS FOR ALMOST 30 YEARS AND HAVE NEVER HAD…
Read full complaint
SEAT BELT TENSIONER JAMS IN MIDDLE REAR SEAT OF 2001 CHRYSLER PT CRUISER. I PREVIOUSLY PAID TO REPAIR THIS EXACT SAME PROBLEM IN 2004 AND IT HAS HAPPENED AGAIN. CONTACTED CHRYSLER AND THE LOCAL DEALERSHIP BUT THE ONLY SOLUTION SEEMS FOR ME TO PAY TO FIX IT AGAIN. I HAVE BEEN DRIVING CARS FOR ALMOST 30 YEARS AND HAVE NEVER HAD A SEAT BELT PROBLEM. I MEAN, SEAT BELTS AREN'T SUPPOSED TO BREAK - YOUR LIFE DEPENDS ON THEM. THIS PROBLEM OCCURRED IN AUGUST 2004 AND AGAIN IN AUGUST 2009. *TR
NHTSA ODI #10283893
151,000 miles · Dec 3, 2008
Air BagsSeat BeltsCrashInjury
TL*THE CONTACT OWNS A 2001 CHRYSLER PT CRUISER. WHILE DRIVING APPROXIMATELY 30 MPH ON NORMAL ROAD CONDITIONS, THE CONTACT REAR ENDED ANOTHER VEHICLE. THE AIR BAGS FAILED TO DEPLOY. THE FAILURE OCCURRED WITHOUT WARNING. IN ADDITION, THE DRIVER'S SIDE SEAT BELT FAILED TO RESTRAIN PROPERLY AND FORCED THE DRIVER INTO THE STEERIN…
Read full complaint
TL*THE CONTACT OWNS A 2001 CHRYSLER PT CRUISER. WHILE DRIVING APPROXIMATELY 30 MPH ON NORMAL ROAD CONDITIONS, THE CONTACT REAR ENDED ANOTHER VEHICLE. THE AIR BAGS FAILED TO DEPLOY. THE FAILURE OCCURRED WITHOUT WARNING. IN ADDITION, THE DRIVER'S SIDE SEAT BELT FAILED TO RESTRAIN PROPERLY AND FORCED THE DRIVER INTO THE STEERING WHEEL. THE DRIVER SUSTAINED SEVERE INJURIES AND THE POLICE AND AMBULANCE WERE CALLED TO THE SCENE. THE VEHICLE WAS TOWED TO THE COLLISION CENTER AND WAS COMPLETELY DESTROYED. THE CAUSE OF THE FAILURE HAS NOT BEEN DETERMINED. THE VIN WAS UNKNOWN. THE FAILURE AND CURRENT MILEAGES WERE 151,000.
NHTSA ODI #10250647
70,450 miles · Oct 22, 2007
Seat Belts
2001 PT CRUISER (TOURING EDITION) THE REAR SEAT, MIDDLE SEAT BELT DOES NOT LOCK UP WHEN THE SEAT BELT IS PULLED/YANKED ON OR THE VEHICLE TURNS CORNERS. MY SON AT 3 MONTHS OLD WENT TIPPING OVER SIDEWAYS WHEN I MADE A LEFT HAND TURN (LESS THEN 15 MPH). HE WAS SAFE AND SECURE IN HIS CAR SEAT WITH MATCHING BASE, BUT THE WHOLE …
Read full complaint
2001 PT CRUISER (TOURING EDITION) THE REAR SEAT, MIDDLE SEAT BELT DOES NOT LOCK UP WHEN THE SEAT BELT IS PULLED/YANKED ON OR THE VEHICLE TURNS CORNERS. MY SON AT 3 MONTHS OLD WENT TIPPING OVER SIDEWAYS WHEN I MADE A LEFT HAND TURN (LESS THEN 15 MPH). HE WAS SAFE AND SECURE IN HIS CAR SEAT WITH MATCHING BASE, BUT THE WHOLE THING TIPPED OVER. I TRIED MANUALLY GETTING IT TO LOCK SO THE BASE OF MY SONS CAR SEAT WOULD STAY IN PLACE, BUT I HAD NO LUCK. HE TIPPED A FEW TIMES, SO I DECIDED TO MOVE THE SEAT CLOSER TO THE DRIVERS SIDE REAR DOOR. SO NOW WHAT? DO I KEEP RISKING HIM TIPPING OVER OR RISK HIM BEING CLOSER ONE OF THE DOORS? *JB
NHTSA ODI #10206529
Mileage unknown · Mar 1, 2005
Seat Belts
THE SEAT BELT DOES NOT RETRACT BACK TO NORMAL POSITION, AND IS NOT PROVIDING PROTECTION TO THE DRIVER IN CASE OF AN ACCIDENT. MANUFACTURER WAS CONTACTED BY CONSUMER, AND INFORMED CONSUMER THAT THE SEAT BELT WAS NOT COVERED BY WARRANTY.*AK
NHTSA ODI #10113201
42,950 miles · Jan 28, 2005
Seat Belts
VEHICLE EXPERIENCED A PROBLEM WITH THE SEAT BELT ON THE DRIVER SIDE. THE BELT WILL NOT COME OUT OF THE RETRACTOR. IT WILL NOT RELEASE OR ALLOW THE DRIVER TO WEAR THE SEAT BELT. OWNER CONTACTED THE DEALER, WHO STATED THEY COULD CHECK FOR THE DEFECT IF THE OWNER WOULD PAY A FEE FOR THE DIAGNOSTICS TO DETERMINE WHY THE BELT WILL N…
Read full complaint
VEHICLE EXPERIENCED A PROBLEM WITH THE SEAT BELT ON THE DRIVER SIDE. THE BELT WILL NOT COME OUT OF THE RETRACTOR. IT WILL NOT RELEASE OR ALLOW THE DRIVER TO WEAR THE SEAT BELT. OWNER CONTACTED THE DEALER, WHO STATED THEY COULD CHECK FOR THE DEFECT IF THE OWNER WOULD PAY A FEE FOR THE DIAGNOSTICS TO DETERMINE WHY THE BELT WILL NOT OPERATE. *AK
NHTSA ODI #10109150
56,025 miles · Jan 5, 2005
Seat Belts
MIDDLE REAR SAFTEY BELT FAILED. THE RIGT REAR SEAT WAS FOLDED FORWARD. THE SEAT BELT JAMMED AND WOULD NOT ALLOW THE SEAT TO BE RAISED. THE SEAT HAD TO BE DISASSEMBLED AND A NEW SEAT BELT INSTALLED. THIS SAFETY DEVICE WAS NOT COVERED UNDER WARRANTY.*AK
NHTSA ODI #10105795
Mileage unknown · Aug 9, 2002
Seat Belts
THE DRIVERS SEAT BELT LOCKS UP TIGHT ANYTIME I LEAN FORWARD TO CHECK FOR CROSS TRAFFIC AT A STOP SIGN OR TO CHECK THE SIDE MIRROR BLIND SPOT BEFORE CHANGING LANES. IT LOCKS IMMEDIATELY, I'M ACTUALLY PINNED TO THE SEAT BACK. I HAVE TO LEAN BACK INTO THE SEAT BACK TO ALLOW IT TO RELEASE BEFORE BEING ABLE TO MOVE MY UPPER BODY FORW…
Read full complaint
THE DRIVERS SEAT BELT LOCKS UP TIGHT ANYTIME I LEAN FORWARD TO CHECK FOR CROSS TRAFFIC AT A STOP SIGN OR TO CHECK THE SIDE MIRROR BLIND SPOT BEFORE CHANGING LANES. IT LOCKS IMMEDIATELY, I'M ACTUALLY PINNED TO THE SEAT BACK. I HAVE TO LEAN BACK INTO THE SEAT BACK TO ALLOW IT TO RELEASE BEFORE BEING ABLE TO MOVE MY UPPER BODY FORWARD. IN THE BEGINNING IT RARELY HAPPENED, NOW IT'S ALMOST ALL THE TIME. ON THE OTHER MATTER OF THE FRONT DISK BRAKES. THE RIGHT SIDE NOT ONLY WORE OUT TWICE AS FAST AS THE LEFT BUT WORE AT AN ANGLE WHICH CAUSED THE METAL BACKING PLATE TO SCRAPE THE ROTOR BEFORE THE SQEEKER WAS EVEN CLOSE TO SCRAPING. I STILL HAVE THE BRAKE PADS.
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.4L NON-TURBOCHARGED ENGINES AND AUTOMATIC TRANSAXLES, THE POWER STEERING PRESSURE HOSE MAY CONTACT THE AUTOMATIC TRANSAXLE DIFFERENTIAL COVER, POTENTIALLY DAMAGING THE HOSE.
Consequence & remedy
Consequence: POWER STEERING FLUID LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSPECT AND RELOCATE, OR REPLACE AS NECESSARY, THE POWER STEERING HOSE AND CONFIRM TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END. THE RECALL BEGAN ON SEPTEMBER 20, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
ON CERTAIN PASSENGER VEHICLES, THE FUEL SUPPLY LINE COULD CONTACT THE AIR-CONDITIONING TUBE SERVICE PORT. THIS CAN CAUSE CHAFING OF THE LINE RESULTING IN A FUEL LEAKAGE.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT THE FUEL LINE FOR ABRASION AND INSTALL A CLIP TO ENSURE ISOLATION. IN CASES WITH EVIDENCE OF FUEL LINE ABRASION, THE FUEL LINE WILL BE REPLACED. OWNER NOTIFICATION BEGAN AUGUST 12, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
ON CERTAIN PASSENGER VEHICLES, THE FUEL PUMP MODULE MOUNTING FLANGE COULD LEAK FUEL IF THE VEHICLE IS INVOLVED IN A ROLLOVER CRASH.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A SECONDARY SEAL OVER THE FUEL PUMP MODULE. OWNER NOTIFICATION BEGAN AUGUST 12, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE RIGHT REAR "65%" SEAT CENTER LOWER ANCHOR WAS MANUFACTURED WITH A WIRE DIAMETER THAT IS GREATER THAN THE MAXIMUM ALLOWABLE DIMENSION AS SPECIFIED IN THE STANDARD.
Consequence & remedy
Consequence: IF THE CONNECTOR FOR A LATCH-TYPE CHILD RESTRAINT IS NOT ATTACHED CORRECTLY TO THE ANCHORAGE POINTS, THE RESTRAINT WILL NOT PROPERLY PROTECT A CHILD IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL INSPECT THE RIGHT REAR SEAT CENTER ANCHOR AND, IF NECESSARY, RESIZE THE ANCHOR TO MEET THE DIAMETER SPECIFIED WITHIN THE STANDARD. OWNER NOTIFICATION BEGAN NOVEMBER 4, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES, PICKUP TRUCKS AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." SOME OF THE OWNER'S MANUALS FOR THESE VEHICLES ARE MISSING INSTRUCTIONS THAT PROVIDE A STEP-BY-STEP PROCEDURE, INCLUDING DIAGRAMS, FOR PROPERLY ATTACHING A CHILD RESTRAINT SYSTEM'S TETHER STRAP TO THE TETHER ANCHORAGE.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE CHILD SEAT MAY NOT BE PROPERLY ATTACHED INCREASING THE RISK OF INJURY TO THE CHILD.
Remedy: OWNERS WILL BE PROVIDED WITH AN ADDENDUM TO THE OWNER'S MANUALS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
PE04028 · Engine Compartment Fires
Opened Mar 15, 2004 · Closed Jun 18, 2004
Status: closed (inferred from source dates) · Steering; Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:hose, Piping, And Connections; Steering:hydraulic Power Assist:power Steering Fluid
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Additional source detail variants (4)
Steering
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist:hose, Piping, And Connections
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist:power Steering Fluid
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist System
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
PE02082 · Safety Belt Cinching Latch Plate
Opened Nov 6, 2002 · Closed Apr 23, 2003
Status: closed (inferred from source dates) · Seat Belts
THERE ARE NO INJURIES OR FATALITIES ASSOCIATED WITH THIS ALLEGED DEFECT.WHILE CONDUCTING THIS INVESTIGATION, ODI FOUND THAT THE SUBJECT CINCHES MEET THE LOAD BEARING REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD 208, AND THAT MANY OF THE REPORTED FAILURES WERE DUE TO INCORRECT CHILD SAFETY SEAT INSTALLATIONS. ADDITIONALLY, THE REPORT RATE IS LOW (1.60/100K).THE INFORMATION AVAILABLE FAILS TO ESTABLISH THE EXISTENCE OF A DEFECT TREND AT THIS TIME.FURTHER ALLOCATION OF AGENCY RESOURCES TO THIS ISSUE IS UNWARRANTED AND THE PRELIMINARY EVALUATION IS BEING CLOSED.
PE02058 · Fuel Hose Abrasion
Opened Jul 19, 2002 · Closed Oct 4, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
No summary supplied.
2001 Chrysler Pt Cruiser Problems, Complaints & Recalls | Skip That Year
Illustration