NHTSA owner reports · September 18, 2026 snapshot.
Power Train complaints
47 reportsClear category filter37,230 miles · Jun 23, 2005
Power Train
I WAS TRAVELLING EAST ON THE 91 FREEWAY IN LOS ANGELES AT ABOUT 5:10PM ON WEDNESDAY, JUNE 22, 2005. I WAS IN VERY HEAVY TRAFFIC TRAVELLING AT ABOUT 35 MILES PER HOUR WHEN THE (AUTOMATIC) TRANSMISSION DISENGAGED. THERE WAS NO UNUSUAL NOISE PRECEDING THE DISENGAGEMENT EXCEPT THAT THE ENGINE REVVED, OF COURSE. FORTUNATELY, I WAS…
Read full complaint
I WAS TRAVELLING EAST ON THE 91 FREEWAY IN LOS ANGELES AT ABOUT 5:10PM ON WEDNESDAY, JUNE 22, 2005. I WAS IN VERY HEAVY TRAFFIC TRAVELLING AT ABOUT 35 MILES PER HOUR WHEN THE (AUTOMATIC) TRANSMISSION DISENGAGED. THERE WAS NO UNUSUAL NOISE PRECEDING THE DISENGAGEMENT EXCEPT THAT THE ENGINE REVVED, OF COURSE. FORTUNATELY, I WAS IN THE RIGHT-HAND LANE APPROACHING THE BELLFLOWER OFFRAMP. THE CAR ROLLED TO A STOP NEAR THE END OF THE OFFRAMP IN THE MIDDLE OF TRAFFIC. I HAD TO HAVE THE CAR TOWED TO DONAVEE CHRYSLER IN PLACENTIA, CA. WE TOOK DELIVERY OF THE CAR ON MAY 27, 2001 AND IT ONLY HAS 37,230 MILES ON IT. THE SERVICE DEPARTMENT TOLD ME THAT THE CAR WAS OUT OF WARRANTY AND THAT IT WOULD COST $850 JUST TO REMOVE THE TRANSMISSION BEFORE THEY COULD EVEN BEGIN TO DETERMINE WHAT WENT WRONG - PARTS AND REPAIRS WILL BE EXTRA.
NHTSA ODI #10126378
15,000 miles · Jan 31, 2005
Power Train
I HAVE BEEN EXPERIENCING SHIFTER PROBLEMS, THAT HAS MADE IT OCCASIONALLY DIFFICULT TO SHIFT INTO OR IT WOULD DROP OUT OF REVERSE GEAR. WHILE DOING A BATTERY CHECK I NOTICED THE SHIFT LINKAGE APPEARED TO BE LYING ON TOP OF THE TRANSAXLE. UPON FURTHER INVESTIGATION AFTER REMOVING THE AIR BOX I NOTICED THAT INDEED LINKAGE WAS LYING…
Read full complaint
I HAVE BEEN EXPERIENCING SHIFTER PROBLEMS, THAT HAS MADE IT OCCASIONALLY DIFFICULT TO SHIFT INTO OR IT WOULD DROP OUT OF REVERSE GEAR. WHILE DOING A BATTERY CHECK I NOTICED THE SHIFT LINKAGE APPEARED TO BE LYING ON TOP OF THE TRANSAXLE. UPON FURTHER INVESTIGATION AFTER REMOVING THE AIR BOX I NOTICED THAT INDEED LINKAGE WAS LYING THERE WITHOUT BEING SECURED IN POSITION. THERE APPEARS TO BE AN INDENTATION FOR RETAINER CLIP, THERE WAS NO EVIDENCE THAT ONE HAD BEEN USED OR IF IT HAD IT CAME OFF EARLY ON. I REALIZE MORE AUTOMATIC PT?S WERE SOLD THAN MANUAL 5-SPEED UNITS. I ALSO REALIZE THAT IT IS POSSIBLE THAT ONLY MY VEHICLE MAY HAVE THIS PROBLEM. ALTHOUGH I BELIEVE THAT TO BE UNLIKELY, THEREFORE I AM FILING A FORMAL COMPLAINT, BASED ON THE INITIAL RESPONSE I RECEIVED FROM THE LOCAL DEALERSHIP SERVICE AND PARTS DEPARTMENT. I BELIEVE CONTINUED UNCONTROLLED WEAR COULD RESULT IN A MISHAP SHOULD THE LINKAGE COME OFF WHILE DRIVING. HAD THE RETAINER CLIP BEEN INSTALLED IT WOULD HAVE PREVENTED THIS TYPE WEAR WITH LESS THAN 70,000 MILES. *AK
NHTSA ODI #10108327
Mileage unknown · Jan 1, 2005
Power Train
I WAS DRIVING DOWN I-84 AT 65 MPH WHEN THE TRANSMISSION LOCKED UP, LOSING ALL GEARS EXCEPT 1ST. THIS CAUSED THE CAR TO DECELERATE RAPIDLY AND THE CAR TO VEER TO THE RIGHT. I MANAGED TO GET TO THE OFF-RAMP WITHOUT INCIDENT. THE CAR NOW NEEDS THE TRANSMISSION REBUILT WITH ONLY 69,000 MILES ON IT. *JB
NHTSA ODI #10104885
50,000 miles · Nov 12, 2004
Interior LightingPower Train
SOME OF THE ILLUMINATING LIGHTS IN THE DASHBOARD FOR SPEED AND RPM AND FUEL HAVE GONE OUT. I HAD MENTIONED THIS TO CHRYSLER WHEN MY TRANSMISSION DIED AND THEY DID NOTHING. ISN'T THEM ANOTHER E-MAIL IN SEPTEMBER AND THEY STILL HAVE DONE NOTHING. I FEEL THIS IS A SAFETY HAZARD IF YOU CAN NOT READ YOUR GAUGES AT NIGHT TIME WITHO…
Read full complaint
SOME OF THE ILLUMINATING LIGHTS IN THE DASHBOARD FOR SPEED AND RPM AND FUEL HAVE GONE OUT. I HAD MENTIONED THIS TO CHRYSLER WHEN MY TRANSMISSION DIED AND THEY DID NOTHING. ISN'T THEM ANOTHER E-MAIL IN SEPTEMBER AND THEY STILL HAVE DONE NOTHING. I FEEL THIS IS A SAFETY HAZARD IF YOU CAN NOT READ YOUR GAUGES AT NIGHT TIME WITHOUT TAKING YOUR ATTENTION AWAY FROM THE ROAD TO TURN ON THE INTERIOR LIGHT TO SEE THE GAUGES. *JB
NHTSA ODI #10098748
61,000 miles · Sep 23, 2004
Power Train
THE TRANSMISSION ON MY 2001 PT CRUISER LET GO AT 61000 MILES. I WOULD THINK THAT IT WOULD LAST A LOT LONGER THAN THAT! *JB
NHTSA ODI #10093115
47,066 miles · Sep 8, 2004
Fuel System, GasolinePower TrainSteering
I HAVE A 2001 PT CRUISER. I HAD AN INCIDENT IN WISCONSIN 11/24/03 WHERE MY STEERING WHEEL LOCKED AND COULD NOT BE UNLOCKED, THUS I COULD NOT START THE CAR. I HAD IT TOWED TO THE DEALERSHIP THE NEXT DAY. THEY FOUND NOTHING WRONG. ON 2/26/04 THE STEERING COLUMN WAS CLICKING. I TOOK IT TO A DEALERSHIP IN ST. LOUIS. THE STEERI…
Read full complaint
I HAVE A 2001 PT CRUISER. I HAD AN INCIDENT IN WISCONSIN 11/24/03 WHERE MY STEERING WHEEL LOCKED AND COULD NOT BE UNLOCKED, THUS I COULD NOT START THE CAR. I HAD IT TOWED TO THE DEALERSHIP THE NEXT DAY. THEY FOUND NOTHING WRONG. ON 2/26/04 THE STEERING COLUMN WAS CLICKING. I TOOK IT TO A DEALERSHIP IN ST. LOUIS. THE STEERING COLUMN HAD TO BE REPLACED A BEARING WENT OUT AT 38913 MILES. THEN 8/31/04 I HAD JUST PULLED INTO MY SUBDIVISION AFTER A LONG TRIP AND THE CAR WOULD REV BUT DID NOT ACCELERATE. I TOOK IT TO A LOCAL GARAGE DUE TO THE MECHANICS STRIKE AT THE DEALERSHIPS. THE FRONT PUMP OF THE TRANSMISSION IS OUT AND NEEDS A NEW TRANSMISSION AT 47066 MILES. IN ADDITION, NEITHER OF THE TWO DEALERSHIPS MENTIONED A FUEL SYSTEM RECALLS THE WERE ISSUED IN 8/02 AND NOT COMPLETED ON MY CAR.*AK
NHTSA ODI #10090619
61,520 miles · Aug 12, 2004
Power Train
WHILE DRIVING 60 MPH, THE TRANSMISSION SHIFTED OUT OF GEAR AND LOCKED UP WITHOUT WARNING. THE CONSUMER MANAGED TO PULL OVER AND HAD THE VEHICLE TOWED. PLEASE PROVIDE ADDITIONAL DETAILS. *JB
NHTSA ODI #10087798
93,000 miles · Jul 19, 2004
Engine And Engine CoolingPower Train
PROBLEMS WITH TRANSMISSION IN 2001 PT CRUISER.*MR THE VEHICLE COOLING FAN MOTOR FAILED THEN A WEEK LATER THE PLANETARY GEAR EXPLODED. THE VEHICLE IS CURRENTLY SITTING IN THE CONSUMERS DRIVEWAY. *NM
NHTSA ODI #10083398
Mileage unknown · Feb 10, 2004
Power Train
THE TRANS AXLE BROKE IN OUR 2001 CHRYSLER PT ON SUN-1/25/04 AND WAS TOWED TO THE SARASOTA CHRYSLER DEALER WHO GOT TO IT TUESDAY TO SAY NOT UNDER WARRANTY(WE ARE 2ND OWNER-HAD 2 YRS) SO NEED A NEW ONE. THEY DID NOT OFFER TO PULL OUT AND REBUILD. IT WAS UNDER WARRANTY, IT WOULD HAVE BEEN REBUILT. THEY DID NOT NOTIFY US OF RECALL …
Read full complaint
THE TRANS AXLE BROKE IN OUR 2001 CHRYSLER PT ON SUN-1/25/04 AND WAS TOWED TO THE SARASOTA CHRYSLER DEALER WHO GOT TO IT TUESDAY TO SAY NOT UNDER WARRANTY(WE ARE 2ND OWNER-HAD 2 YRS) SO NEED A NEW ONE. THEY DID NOT OFFER TO PULL OUT AND REBUILD. IT WAS UNDER WARRANTY, IT WOULD HAVE BEEN REBUILT. THEY DID NOT NOTIFY US OF RECALL NOR FIX THAT. WE JUST MOVED HERE FROMMD. IN AUGUST AND DID NOT GET FUEL RECALL SOMEHOW. SAFETY SEAT WE DID GET ,BUT DID NOT DO. DUE TO $2400 QUOTE, WE TOWED THE AUTO HME AND GAVE THEM A DEPOSIT TO ORDER A NEW TRANSMISSION FROM CHRYSLER SINCE A USED ONE COULD NOT BE FOUND. NOW WE STILL DO NOT HAVE NOR CAN BE TOLD WHEN IT WILL COME IN OFF "BACKORDER"? FOR A 2001 POPULAR AUTO? CALLED CHRYSLER TO VERIFY TO SEE WHAT COULD BE DONE SINCE WE ARE RENTING A CAR NOW FOR 3 WEEKS WITH 4 YR OLD CAR NOT WORKING AND CANNOT BE FIXED DUE TO UNAVAILABLE PARTS. IT IS NOT LIKE IT IS A FIERO OR ANTIQUE, OR UNUSUAL. WE CALLED CHRYSLER WHO CHECKED WITH DEALER ON "RECALL " COMPLAINT -SPOKE TO [XXX] AND SHE SAID SHE DID NOT ASK THEM THAT. ASKED HER ABOUT PARTS AND WAS TOLD SHE COULD "RUSH" AND HOPEFULLY GET A TRANSMISSION FOR US SOON, BUT WE WOULD HAVE TO PAY EXTRA! STILL NO TIME FRAME WAS QUOTED. WE ARE STUCK AND DO NOT KNOW WHERE TO TURN . THE CAR HAS NOT HAD OTHER PROBLEMS AND ONLY HAS UNDER 60,000 MILES SO IT IS HARD TO UNDERSTAND THAT CHRYSLER WILL NOT STAND BEHIND THEIR PRODUCT OR OFFER MORE HELP FOR CONSUMER SATISFACTION ON A VERY POPULAR AUTO. IT IS A 5 SPEED. WE WOULD LIKE TO KNOW WHO CAN HELP OR WHAT RIGHTS WE HAVE. VIN# [XXX]....PLEASE FORWARD THIS OR REPLY. I AM SO DISAPPOINTED IN THIS AMERICAN PRODUCT, THAT I MAY TRADE FOR FOREIGN. MOST SINCERELY, [XXX]. *AK UPDATED 07/30/2012 *JS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) *TR
NHTSA ODI #10056966
31,000 miles · Jan 15, 2004
Electrical SystemPower TrainSteering
2001 CHRYSLER PT CRUISER: THE BATTERY LIGHT KEEPS COMING ON. I'VE TAKEN TO DEALER FOUR TIME NOW FOR THAT PROBLEM. HAD THE BATTERY REPLACED TWICE. HAD THE REGULATOR IN THE COMPUTER REPLACED. I AM STILL HAVING PROBLEMS. THE TRANSMISSION HAD TO BE REPLACED. IT IS A MANUAL TRANSMISSION. HAD THE CLUTCH REPLACED. ALL OF THIS …
Read full complaint
2001 CHRYSLER PT CRUISER: THE BATTERY LIGHT KEEPS COMING ON. I'VE TAKEN TO DEALER FOUR TIME NOW FOR THAT PROBLEM. HAD THE BATTERY REPLACED TWICE. HAD THE REGULATOR IN THE COMPUTER REPLACED. I AM STILL HAVING PROBLEMS. THE TRANSMISSION HAD TO BE REPLACED. IT IS A MANUAL TRANSMISSION. HAD THE CLUTCH REPLACED. ALL OF THIS DUE TO FAULTY PARTS! THE VEHICLE KEEPS PULLING TO THE RIGHT. HAD IT FIXED ONCE AND IT STILL PULLS. THE DATE ENTERED IS WHEN EVERYTHING STARTED. *CB
NHTSA ODI #10053260
Official recalls
5Jun 3, 2004
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.4L NON-TURBOCHARGED ENGINES AND AUTOMATIC TRANSAXLES, THE POWER STEERING PRESSURE HOSE MAY CONTACT THE AUTOMATIC TRANSAXLE DIFFERENTIAL COVER, POTENTIALLY DAMAGING THE HOSE.
Consequence & remedy
Consequence: POWER STEERING FLUID LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSPECT AND RELOCATE, OR REPLACE AS NECESSARY, THE POWER STEERING HOSE AND CONFIRM TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END. THE RECALL BEGAN ON SEPTEMBER 20, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Aug 8, 2002
ON CERTAIN PASSENGER VEHICLES, THE FUEL SUPPLY LINE COULD CONTACT THE AIR-CONDITIONING TUBE SERVICE PORT. THIS CAN CAUSE CHAFING OF THE LINE RESULTING IN A FUEL LEAKAGE.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT THE FUEL LINE FOR ABRASION AND INSTALL A CLIP TO ENSURE ISOLATION. IN CASES WITH EVIDENCE OF FUEL LINE ABRASION, THE FUEL LINE WILL BE REPLACED. OWNER NOTIFICATION BEGAN AUGUST 12, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Aug 8, 2002
ON CERTAIN PASSENGER VEHICLES, THE FUEL PUMP MODULE MOUNTING FLANGE COULD LEAK FUEL IF THE VEHICLE IS INVOLVED IN A ROLLOVER CRASH.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A SECONDARY SEAL OVER THE FUEL PUMP MODULE. OWNER NOTIFICATION BEGAN AUGUST 12, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Jun 14, 2002
CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE RIGHT REAR "65%" SEAT CENTER LOWER ANCHOR WAS MANUFACTURED WITH A WIRE DIAMETER THAT IS GREATER THAN THE MAXIMUM ALLOWABLE DIMENSION AS SPECIFIED IN THE STANDARD.
Consequence & remedy
Consequence: IF THE CONNECTOR FOR A LATCH-TYPE CHILD RESTRAINT IS NOT ATTACHED CORRECTLY TO THE ANCHORAGE POINTS, THE RESTRAINT WILL NOT PROPERLY PROTECT A CHILD IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL INSPECT THE RIGHT REAR SEAT CENTER ANCHOR AND, IF NECESSARY, RESIZE THE ANCHOR TO MEET THE DIAMETER SPECIFIED WITHIN THE STANDARD. OWNER NOTIFICATION BEGAN NOVEMBER 4, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Nov 9, 2000
VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES, PICKUP TRUCKS AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." SOME OF THE OWNER'S MANUALS FOR THESE VEHICLES ARE MISSING INSTRUCTIONS THAT PROVIDE A STEP-BY-STEP PROCEDURE, INCLUDING DIAGRAMS, FOR PROPERLY ATTACHING A CHILD RESTRAINT SYSTEM'S TETHER STRAP TO THE TETHER ANCHORAGE.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE CHILD SEAT MAY NOT BE PROPERLY ATTACHED INCREASING THE RISK OF INJURY TO THE CHILD.
Remedy: OWNERS WILL BE PROVIDED WITH AN ADDENDUM TO THE OWNER'S MANUALS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3PE04028 · Engine Compartment Fires
Opened Mar 15, 2004 · Closed Jun 18, 2004
Status: closed (inferred from source dates) · Steering; Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:hose, Piping, And Connections; Steering:hydraulic Power Assist:power Steering Fluid
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Additional source detail variants (4)
Steering
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist:hose, Piping, And Connections
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist:power Steering Fluid
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist System
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
PE02082 · Safety Belt Cinching Latch Plate
Opened Nov 6, 2002 · Closed Apr 23, 2003
Status: closed (inferred from source dates) · Seat Belts
THERE ARE NO INJURIES OR FATALITIES ASSOCIATED WITH THIS ALLEGED DEFECT.WHILE CONDUCTING THIS INVESTIGATION, ODI FOUND THAT THE SUBJECT CINCHES MEET THE LOAD BEARING REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD 208, AND THAT MANY OF THE REPORTED FAILURES WERE DUE TO INCORRECT CHILD SAFETY SEAT INSTALLATIONS. ADDITIONALLY, THE REPORT RATE IS LOW (1.60/100K).THE INFORMATION AVAILABLE FAILS TO ESTABLISH THE EXISTENCE OF A DEFECT TREND AT THIS TIME.FURTHER ALLOCATION OF AGENCY RESOURCES TO THIS ISSUE IS UNWARRANTED AND THE PRELIMINARY EVALUATION IS BEING CLOSED.
PE02058 · Fuel Hose Abrasion
Opened Jul 19, 2002 · Closed Oct 4, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
No summary supplied.
Illustration