DT: CONSUMER OWNED THREE 2001 CHRYSLER PT CRUISERS. EACH OF THE VEHICLES HAD PROBLEMS WITH THE FOG LIGHTS AND TURN SIGNAL LIGHT SWITCH , WHICH WAS REPLACED FREE OF CHARGE WHEN ONE VEHICLE WAS OUT OF WARRANTY AND THE FOG LIGHTS AND HEADLIGHTS STAYED ON AND WOULD NOT GO OFF. THE SECOND AND THIRD CRUISERS FOG LIGHTS WOULD NOT…
Read full complaint
DT: CONSUMER OWNED THREE 2001 CHRYSLER PT CRUISERS. EACH OF THE VEHICLES HAD PROBLEMS WITH THE FOG LIGHTS AND TURN SIGNAL LIGHT SWITCH , WHICH WAS REPLACED FREE OF CHARGE WHEN ONE VEHICLE WAS OUT OF WARRANTY AND THE FOG LIGHTS AND HEADLIGHTS STAYED ON AND WOULD NOT GO OFF. THE SECOND AND THIRD CRUISERS FOG LIGHTS WOULD NOT GO OFF, CONSUME R REMOVED THE FUSE. THERE WAS A FLAW IN THE DESIGN OF THE PT CRUISERS HEADLIGHT SWITCH, WHICH WOULD RUN DOWN THE BATTERY. THE SWITCH SHOULD BE REPLACED AT NO CHARGE TO THE CONSUMER. ALSO, THERE SHOULD A BE A REDESIGNED SWITCH, AND A FULL RECALL/REPLACEMENT AFTER THE SWITCH WAS REDESIGNED. IN ORDER TO HAVE TWO PT CRUISERS PASS VA STATE INSPECTION CONSUMER REMOVED FOG LIGHTS BULBS, SOCKET AND WIRING. *AK
NHTSA ODI #10131743
Mileage unknown · Jul 25, 2005
Engine And Engine CoolingExterior LightingPower Train
I WAS DRIVING AND THE FRONT PART OF THE CAR BROKE DOWN I COULDN'T KEEP ON THE SHIFT COULDN'T MOVE TO PARK, DRIVE OR REVERSE. I HAD TO CALL A TOW TRUCK THE PART AN AXEL. I PAID A MECANIC. BUT THE BUSHINGS ARE ALSO MESSED UP THEY ARE TOO EXPENSIVE HERE IN PUERTO RICO IT COSTS ME MORE THATN 1,000 DOLLARS TO FIX IT AND I'VE BEEN DR…
Read full complaint
I WAS DRIVING AND THE FRONT PART OF THE CAR BROKE DOWN I COULDN'T KEEP ON THE SHIFT COULDN'T MOVE TO PARK, DRIVE OR REVERSE. I HAD TO CALL A TOW TRUCK THE PART AN AXEL. I PAID A MECANIC. BUT THE BUSHINGS ARE ALSO MESSED UP THEY ARE TOO EXPENSIVE HERE IN PUERTO RICO IT COSTS ME MORE THATN 1,000 DOLLARS TO FIX IT AND I'VE BEEN DRIVING LIKE THAT SINCE THE DAY I BOUGHT THE CAR. THE DEALER TOLD THAT THE IT DIDN'T HAVE GARANTEEN. KNOW ANOTHER PROBLEM THERE IS IN FEBREUARY I TOOK MY CAR TO THE MECANIC BECAUSE THE CARGOT HOT THEY CHANGE THE WATER BOMB, AND IT CONTINUE TO RISE THE TEMPERATURE, THEN THE TEMOSTAT AND THEY EVEN FLUSHED THE RADIATOR,AND THEY PUT A COMPUTER IF IT CAN DITECT WHERE IS THE PROBLEM.THEY JUST DON'T KNOW WHAT IS THE PROBLEM AND THEY ARE ONE OF THE BEST RADIATOR MECANICS IN BAYAMON PUERTO RICO. WHE N I DRIVE AROUND THERES NO PROBLEM AS LONG I I AM NOT IN A TRAFFIC JAM FOR MORE THAN HALF AN HOUR AND WHEN I GO VISIT MY PARENTS TO THE COUNTRYSIDE GOING UP THE HILLS THAT AFTER TEN MINUTES ON THE HILL THE TEMPERARURE STARTS TO RISE BOTH TIMES THAT I HAVE VISITED MY PARENTS FOR THE PAST FIVE MONTHS AGO I CAN'T GO. THE MECANICS CAN'T FIGURE OUT THE PROBLEM. CAN YOU GIVE ME ANY SUGGETIONS E-MAIL ME BACK AND I CAN GIVE IT TO THE MECANICS . ABOUT THE BUSHINGS I'VE ASKED A PERSON ON THE STREETS THAT HAVE A 2003 PT CRUISER AND SHE SAID THAT THESE CARS HAVE THAT PROBLEM.
NHTSA ODI #10129937
51,101 miles · May 16, 2005
Exterior Lighting
IN OCTOBER, 2004 THE FOG LIGHT INDICATOR WOULD STAY ON, EVEN THOUGH THE FOGS LIGHTS WERE NOT ON. THEN THE FOG LIGHTS STOPPED WORKING ALL TOGETHER. MAY, 2005, THE FOGS LIGHTS CAME BACK ON BY THEMSELVES, EVEN THOUGH NO LIGHTS WERE ON AND THE CAR WAS TURNED OFF. I HAD THE LIGHT STALK REPLACED BY THE DEALER ON THE EXTENDED WARRANT…
Read full complaint
IN OCTOBER, 2004 THE FOG LIGHT INDICATOR WOULD STAY ON, EVEN THOUGH THE FOGS LIGHTS WERE NOT ON. THEN THE FOG LIGHTS STOPPED WORKING ALL TOGETHER. MAY, 2005, THE FOGS LIGHTS CAME BACK ON BY THEMSELVES, EVEN THOUGH NO LIGHTS WERE ON AND THE CAR WAS TURNED OFF. I HAD THE LIGHT STALK REPLACED BY THE DEALER ON THE EXTENDED WARRANTY.
NHTSA ODI #10121009
8,036 miles · May 13, 2004
Exterior Lighting
I WAS DRIVING HOME AT 11:00 PM AND JUST ABOUT TO GET ON I 75, AND MY HEADLIGHTS WENT OUT. I HAD TAIL LIGHTS AND I COULD USE MY FLASHERS. I TOOK IT TO THE DEALERS NEXT DAY AND THEY FOUND NOTHING WRONG WITH IT. I TOLD THEM TO PUT A NEW BATTERY IN IT NO MATTER WHAT. I HAVEN'T DRIVEN IT AT NIGHT SINCE. I'M AFRAID TO DRIVE IT AT NIGH…
Read full complaint
I WAS DRIVING HOME AT 11:00 PM AND JUST ABOUT TO GET ON I 75, AND MY HEADLIGHTS WENT OUT. I HAD TAIL LIGHTS AND I COULD USE MY FLASHERS. I TOOK IT TO THE DEALERS NEXT DAY AND THEY FOUND NOTHING WRONG WITH IT. I TOLD THEM TO PUT A NEW BATTERY IN IT NO MATTER WHAT. I HAVEN'T DRIVEN IT AT NIGHT SINCE. I'M AFRAID TO DRIVE IT AT NIGHT. *AK
NHTSA ODI #10072575
30,077 miles · Jun 6, 2003
Electrical SystemEngine And Engine CoolingEquipment
VEHICLE WAS PARKED FOR APPROX. TWO DAYS, STARTED VEHICHLE AND ALL LIGHTS ON THE INSTRUMENT PANEL STAYED ON; BRAKE LIGHT, ABS LIGHT, ENGINE LIGHT, SECURITY LIGHT, CRUSIE CONTROL, ETC. AS WELL AS WORDS "NO BUG" OVER THE ODEMETER/MILEAGE GAGE. THESE LGHTS WOULD NOT GO OFF AFTER TURNING THE ENGINE ON AND OFF SEVERAL TIMES. THE ENGIN…
Read full complaint
VEHICLE WAS PARKED FOR APPROX. TWO DAYS, STARTED VEHICHLE AND ALL LIGHTS ON THE INSTRUMENT PANEL STAYED ON; BRAKE LIGHT, ABS LIGHT, ENGINE LIGHT, SECURITY LIGHT, CRUSIE CONTROL, ETC. AS WELL AS WORDS "NO BUG" OVER THE ODEMETER/MILEAGE GAGE. THESE LGHTS WOULD NOT GO OFF AFTER TURNING THE ENGINE ON AND OFF SEVERAL TIMES. THE ENGINE LIGHT STAYS ON AND WILL NOT SHUT OFF. SCHEDULED AN APPOINTMENT WITH DEALER TO CONNECT TO COMPUTER. *AK
NHTSA ODI #10021131
Mileage unknown · Jun 14, 2001
Exterior Lighting
LOW BEAM HEADLIGHTS-FROM THE CHRYSLER MANUAL- "THE HEADLAMP LOW BEAM PATTERN HAS A DISTINCT HORIZONTAL CUTOFF LINE WHICH IS USED TO VISUALLY ALIGN THE HEADLAMPS." THIS MEANS THAT THERE IS ONLY PART OF A BEAM FROM EACH LIGHT SHINING ON THE ROAD. THE REST I
NHTSA ODI #746837
Mileage unknown · Feb 11, 2001
Exterior Lighting
LOW BEAM HEADLIGHTS FAIL TO ACTIVATE OR GO OUT. ACTIVIATING HIGH BEAMS RESTORS LOW BEAMS. HAPPENED TWICE SO FAR UPON INITIAL TURN ON. HAVE HEARD OF THEM GOING OUT WHILE DRIVING. CONCERNED!*AK
NHTSA ODI #740735
Mileage unknown · Jan 16, 2001
Exterior LightingSteeringSuspension
1. STEERING WHEEL BECAME LOOSE ON SHAFT WHILE TRAVELING AT 68-70 MPH; 2. HEADLIGHTS WOULD FLICKER FROM BRIGHT TO DIM, AND 3. FRONT WEELS OUT OF ALIGNMENT. MOST PROBLEM WAS CORRECTED BY DEALER. >> PLEASE FEEL FREE TO PROVIDE ANY FURTHER DETAILS ON THIS MATTER. *AK
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.4L NON-TURBOCHARGED ENGINES AND AUTOMATIC TRANSAXLES, THE POWER STEERING PRESSURE HOSE MAY CONTACT THE AUTOMATIC TRANSAXLE DIFFERENTIAL COVER, POTENTIALLY DAMAGING THE HOSE.
Consequence & remedy
Consequence: POWER STEERING FLUID LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSPECT AND RELOCATE, OR REPLACE AS NECESSARY, THE POWER STEERING HOSE AND CONFIRM TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END. THE RECALL BEGAN ON SEPTEMBER 20, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
ON CERTAIN PASSENGER VEHICLES, THE FUEL SUPPLY LINE COULD CONTACT THE AIR-CONDITIONING TUBE SERVICE PORT. THIS CAN CAUSE CHAFING OF THE LINE RESULTING IN A FUEL LEAKAGE.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT THE FUEL LINE FOR ABRASION AND INSTALL A CLIP TO ENSURE ISOLATION. IN CASES WITH EVIDENCE OF FUEL LINE ABRASION, THE FUEL LINE WILL BE REPLACED. OWNER NOTIFICATION BEGAN AUGUST 12, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
ON CERTAIN PASSENGER VEHICLES, THE FUEL PUMP MODULE MOUNTING FLANGE COULD LEAK FUEL IF THE VEHICLE IS INVOLVED IN A ROLLOVER CRASH.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A SECONDARY SEAL OVER THE FUEL PUMP MODULE. OWNER NOTIFICATION BEGAN AUGUST 12, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE RIGHT REAR "65%" SEAT CENTER LOWER ANCHOR WAS MANUFACTURED WITH A WIRE DIAMETER THAT IS GREATER THAN THE MAXIMUM ALLOWABLE DIMENSION AS SPECIFIED IN THE STANDARD.
Consequence & remedy
Consequence: IF THE CONNECTOR FOR A LATCH-TYPE CHILD RESTRAINT IS NOT ATTACHED CORRECTLY TO THE ANCHORAGE POINTS, THE RESTRAINT WILL NOT PROPERLY PROTECT A CHILD IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL INSPECT THE RIGHT REAR SEAT CENTER ANCHOR AND, IF NECESSARY, RESIZE THE ANCHOR TO MEET THE DIAMETER SPECIFIED WITHIN THE STANDARD. OWNER NOTIFICATION BEGAN NOVEMBER 4, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES, PICKUP TRUCKS AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." SOME OF THE OWNER'S MANUALS FOR THESE VEHICLES ARE MISSING INSTRUCTIONS THAT PROVIDE A STEP-BY-STEP PROCEDURE, INCLUDING DIAGRAMS, FOR PROPERLY ATTACHING A CHILD RESTRAINT SYSTEM'S TETHER STRAP TO THE TETHER ANCHORAGE.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE CHILD SEAT MAY NOT BE PROPERLY ATTACHED INCREASING THE RISK OF INJURY TO THE CHILD.
Remedy: OWNERS WILL BE PROVIDED WITH AN ADDENDUM TO THE OWNER'S MANUALS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
PE04028 · Engine Compartment Fires
Opened Mar 15, 2004 · Closed Jun 18, 2004
Status: closed (inferred from source dates) · Steering; Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:hose, Piping, And Connections; Steering:hydraulic Power Assist:power Steering Fluid
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Additional source detail variants (4)
Steering
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist:hose, Piping, And Connections
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist:power Steering Fluid
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist System
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
PE02082 · Safety Belt Cinching Latch Plate
Opened Nov 6, 2002 · Closed Apr 23, 2003
Status: closed (inferred from source dates) · Seat Belts
THERE ARE NO INJURIES OR FATALITIES ASSOCIATED WITH THIS ALLEGED DEFECT.WHILE CONDUCTING THIS INVESTIGATION, ODI FOUND THAT THE SUBJECT CINCHES MEET THE LOAD BEARING REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD 208, AND THAT MANY OF THE REPORTED FAILURES WERE DUE TO INCORRECT CHILD SAFETY SEAT INSTALLATIONS. ADDITIONALLY, THE REPORT RATE IS LOW (1.60/100K).THE INFORMATION AVAILABLE FAILS TO ESTABLISH THE EXISTENCE OF A DEFECT TREND AT THIS TIME.FURTHER ALLOCATION OF AGENCY RESOURCES TO THIS ISSUE IS UNWARRANTED AND THE PRELIMINARY EVALUATION IS BEING CLOSED.
PE02058 · Fuel Hose Abrasion
Opened Jul 19, 2002 · Closed Oct 4, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
No summary supplied.
2001 Chrysler Pt Cruiser Problems, Complaints & Recalls | Skip That Year
Illustration