NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
78 reportsClear category filter230,000 miles · Nov 17, 2012
Electrical SystemExterior LightingSuspension
I BOUGHT A 2001 PT CRUISER AND WITHIN A COUPLE OF WEEKS THE HEADLIGHTS STOPPED WORKING. REPLACED MULTI FUNCTION SWITCH BUT DID NOT HELP. HAD TO RE-WIRE THE LIGHTS TO MAKE THEM WORK. ALSO IT SOUNDS LIKE THE PASSENGER SIDE FRONT TIRE HAS SOMETHING LOOSE. POSSIBLY BUSHINGS?? I'VE SEEN SEVERAL COMPLAINTS ABOUT THE LIGHTS. WHAT…
Read full complaint
I BOUGHT A 2001 PT CRUISER AND WITHIN A COUPLE OF WEEKS THE HEADLIGHTS STOPPED WORKING. REPLACED MULTI FUNCTION SWITCH BUT DID NOT HELP. HAD TO RE-WIRE THE LIGHTS TO MAKE THEM WORK. ALSO IT SOUNDS LIKE THE PASSENGER SIDE FRONT TIRE HAS SOMETHING LOOSE. POSSIBLY BUSHINGS?? I'VE SEEN SEVERAL COMPLAINTS ABOUT THE LIGHTS. WHAT IS IT GONNA TAKE TO GET A RECALL IN PLACE? WE GOT A TICKET FOR IT. *TR
NHTSA ODI #10485037
143,000 miles · Sep 7, 2012
Electrical SystemExterior Lighting
VEHICLE WAS USED TO DRIVE TO LOCAL STORE AT NIGHT. FOG LIGHTS WERE NOT TURNED ON AT ANY TIME. I PARKED IN DEPARTMENT STORE PARKING LOT AND CAME OUT AFTER SHOPPING FOR ABOUT 45 MINUTES AND NOTICED A BURNING SMELL COMING FROM PT CRUISER. OPENED THE DRIVERS DOOR AND ODOR BECAME MORE APPARENT. NOTICED SMOKE ROLLING OUT OF STEERING C…
Read full complaint
VEHICLE WAS USED TO DRIVE TO LOCAL STORE AT NIGHT. FOG LIGHTS WERE NOT TURNED ON AT ANY TIME. I PARKED IN DEPARTMENT STORE PARKING LOT AND CAME OUT AFTER SHOPPING FOR ABOUT 45 MINUTES AND NOTICED A BURNING SMELL COMING FROM PT CRUISER. OPENED THE DRIVERS DOOR AND ODOR BECAME MORE APPARENT. NOTICED SMOKE ROLLING OUT OF STEERING COLUMN. ALSO NOTICED FOG LAMP INDICATOR ON DASHBOARD WAS ON. HOWEVER, ALL LIGHTS AND SWITCHES WERE OFF. I HAD TO PULL OUT SEVERAL FUSES UNTIL I FOUND THE ONE RELATED TO THE FOG LAMPS. THAT WAS THE ONLY WAY TO QUICKLY POWER OFF THE FOG LAMPS AND STOP THE SMOLDERING. THIS IS A POTENTIAL FIRE HAZARD! *TR
NHTSA ODI #10474214
40,000 miles · May 9, 2012
Electrical SystemExterior LightingService Brakes, Hydraulic
WEB SITE TOPIX WILL CONFIRM THE INCREDIBLE # OF FOLKS THAT HAVE HAD FOG LAMPS TURN ON AFTER CAR IS SHUT DOWN CAUSING BATTERY DRAIN. 100'S HAVE PAID FOR REPLACEMENT PART MULTI-FUNCTION SWITCH. THIS CONTROLS FOG, HEAD, ACCESSORY, & DASH LIGHTING. TO PREVENT THE FOG LAMPS FROM COMING ON BY THEMSELVES, MOST HAVE REMOVED FUSE # 8 TO …
Read full complaint
WEB SITE TOPIX WILL CONFIRM THE INCREDIBLE # OF FOLKS THAT HAVE HAD FOG LAMPS TURN ON AFTER CAR IS SHUT DOWN CAUSING BATTERY DRAIN. 100'S HAVE PAID FOR REPLACEMENT PART MULTI-FUNCTION SWITCH. THIS CONTROLS FOG, HEAD, ACCESSORY, & DASH LIGHTING. TO PREVENT THE FOG LAMPS FROM COMING ON BY THEMSELVES, MOST HAVE REMOVED FUSE # 8 TO REMOVE THE FOG LAMPS FROM THE CIRCUIT. PEOPLE REPORT SMOKE COMING FROM TURN SIGNAL LEVER, & THE COMPLETE LOSS OF ALL LIGHTING IS QUITE COMMON. I PERSONALLY HAVE REPLACED THE MULTI-FUNCTION SWITCH 3 TIMES ON MY WIFE'S 2001 P.T. CRUISER WITH ONLY 50,000 TOTAL MILES & SHE BEING ORIGINAL OWNER. BY PARKING HER CAR MINUS FUSE # 8, NOT USING DOME LIGHTING, & ALWAYS PARKING WITH THE SIGNAL LEVER IN THE DOWN OR LEFT TURN POSITION HAS PREVENTED THE MYSTERY FOG LAMP ISSUE, & KEPT HER BATTERY FUNCTIONING. THIS "TEMP" SOLUTION HAS ALLOWED HER ABOUT 6 OR 8 MONTHS OF DRIVING W/O THE PROBLEMS OTHER PT OWNERS STRUGGLE WITH. SOONER OR LATER SOMEONE WILL LOSE LIGHTING OR A FIRE WILL OCCUR INSIDE THE STEERING WHEEL WHICH WILL CAUSE SERIOUS INJURY, LOSS OF VEHICLE & POSSIBLY DEATH. CHRYSLER DENIES ANY KNOWLEDGE, BUT WANTS MORE THAN $1,000.000 TO ANALYZE & REPAIR. THROUGH THE TOPIX P.T FORUM I WAS ABLE TO LEARN HOW TO DO THE WORK MYSELF FOR FAR LESS THAN $100. MANY ARE GETTING RIPPED OFF FOR HUNDREDS WHILE CHRYSLER KNOWS FULL WELL OF THE ISSUE. NO LESS THAN AN INVESTIGATION, PERHAPS STARTED WITH THE TOPIX FORUM WILL DEMONSTRATE THE INCREDIBLE NUMBER OF FAILURES THAT STILL PLAGUE THE P.T. ON LATER MODELS SUCH AS 2001 THRU 06 OR 08. ALSO NEED 3RD. BRAKE JOB, & THE RIMS DO NOT SEAL CAUSING LOW TIRES THAT HURT MPG. DRIVING COMFORT, & SAFETY. DEALER & I HAVE TRIED MICHELIN TIRES HOPING THE PROBLEM WAS WITH THE FACTORY INSTALLED GOODYEARS. I STILL HEAR EVERY 100 MILES OR SO THAT MY WIFE'S P.T NEEDS ADDITIONAL AIR PRESSURE. *TR
NHTSA ODI #10457944
134,221 miles · Feb 1, 2012
Electrical SystemVehicle Speed Control
CAR STALLS ON TURNS PARTICULARLY TO THE LEFT, UPON KEY INSERTION HARD CRANK OR STARTS AND IDLES ROUGHLY THEN SHUTS OFF WITH OUT WARNING. WHILE IDLING AT STOP LIGHTS THE RPMS MAY OR MAY NOT (REV,) AFTER SO MANY MINS OF DRIVING ACCELERATION BECOMES MORE DIFFICULT AT INTERVALS & STALLING USUALLY WHILE TURNING AT INTERSECTIONS. OR G…
Read full complaint
CAR STALLS ON TURNS PARTICULARLY TO THE LEFT, UPON KEY INSERTION HARD CRANK OR STARTS AND IDLES ROUGHLY THEN SHUTS OFF WITH OUT WARNING. WHILE IDLING AT STOP LIGHTS THE RPMS MAY OR MAY NOT (REV,) AFTER SO MANY MINS OF DRIVING ACCELERATION BECOMES MORE DIFFICULT AT INTERVALS & STALLING USUALLY WHILE TURNING AT INTERSECTIONS. OR GOING OVER BUMPS OR UP HILLS. THIS HAPPENS SOME WHAT SPORADICALLY SO I NEVER CAN TELL WHEN I'M SAFE TO GO. DEFINITELY NOT SOMETHING U WANT TO THINK ABOUT W MIN COVERAGE EITHER WAY. *TR
NHTSA ODI #10446131
69,896 miles · Sep 29, 2011
Electrical SystemExterior Lighting
I AM THE ORIGINAL OWNER OF THIS PT CRUISER, PURCHASED ON NOVEMBER 22, 2000. MY MULTI-SWITCH WILL NOT TURN ON MY FOG LIGHTS AND THE INDICATOR IN THE INSTRUMENT CLUSTER DOES NOT LIGHT. I HAVE READ MANY ONLINE ARTICLES FROM OWNERS WITH THE SAME PROBLEM. WHY WON'T CHRYSLER FIX THIS ON GOING PROBLEM? *TT
NHTSA ODI #10427927
73,000 miles · Aug 13, 2010
Electrical System
TL*THE CONTACT OWNS A 2001 CHRYSLER PT CRUISER. THE CONTACT STATED THAT HE WAS ABLE TO TAKE THE KEY OUT OF THE IGNITION IN ANY POSITION (OFF, ACCESSORY, ETC) WHILE THE ENGINE WAS RUNNING EVEN IF IT WAS NOT SHIFTED INTO PARK. THE CONTACT NOTICED THE FAILURE EVERY TIME HE DROVE THE VEHICLE. THE VEHICLE HAD NOT BEEN INSPECTED OR RE…
Read full complaint
TL*THE CONTACT OWNS A 2001 CHRYSLER PT CRUISER. THE CONTACT STATED THAT HE WAS ABLE TO TAKE THE KEY OUT OF THE IGNITION IN ANY POSITION (OFF, ACCESSORY, ETC) WHILE THE ENGINE WAS RUNNING EVEN IF IT WAS NOT SHIFTED INTO PARK. THE CONTACT NOTICED THE FAILURE EVERY TIME HE DROVE THE VEHICLE. THE VEHICLE HAD NOT BEEN INSPECTED OR REPAIRED AT THE TIME OF THE COMPLAINT. THE CONTACT CALLED THE MANUFACTURER WHO REFERRED HIM TO NHTSA. THE CURRENT MILEAGE WAS APPROXIMATELY 95,000. THE FAILURE MILEAGE WAS APPROXIMATELY 73,000.
NHTSA ODI #10349204
85,452 miles · Aug 5, 2010
Electrical System
I OWN A 2001 CHRYSLER PT CRUISER. I PURCHASED IT USED IN 2006. IT'S BEEN IN THE SHOP NUMEROUS TIMES BECAUSE THE BATTERY KEEPS GOING BAD. IN 4 YEARS I'VE REPLACED THE BATTERY 3 TIMES. TODAY I WAS ALMOST IN A SERIOUS ACCIDENT. I WAS DRIVING AND IT JUST STALLED IN TRAFFIC! IT JUST DIED, LIKE IT RAN OUT OF GAS. THIS VEHICLE IS A SAF…
Read full complaint
I OWN A 2001 CHRYSLER PT CRUISER. I PURCHASED IT USED IN 2006. IT'S BEEN IN THE SHOP NUMEROUS TIMES BECAUSE THE BATTERY KEEPS GOING BAD. IN 4 YEARS I'VE REPLACED THE BATTERY 3 TIMES. TODAY I WAS ALMOST IN A SERIOUS ACCIDENT. I WAS DRIVING AND IT JUST STALLED IN TRAFFIC! IT JUST DIED, LIKE IT RAN OUT OF GAS. THIS VEHICLE IS A SAFETY HAZARD! I CALLED A TOW TRUCK IT'S IN THE SHOP TONIGHT. MECHANIC THINKS IT'S THE PCM/ POWERTRAIN CONTROL MODULE, COST AROUND $1000.00!! *TR
NHTSA ODI #10347556
Mileage unknown · Jul 24, 2010
Electrical SystemLatches/locks/linkages
DOOR LOCKS RANDOMLY LOCK AND UNLOCK THEMSELVES. REMOTES AND INTERIOR LOCK SWITCHES ARE NON-FUNCTIONAL. PRODUCES THE RISK OF LOCKING OCCUPANTS OUT OF THE CAR, OR UNLOCKING AT NIGHT AND POSES HIGHER RISK OF THEFT. *TR
NHTSA ODI #10345091
Mileage unknown · Mar 1, 2010
Electrical System
ELECTRICAL SHORT / FAILURE IN THE CAR HORN (SIMULTANEOUSLY AFFECTING THE LCD OF THE CLOCK/RADIO). ISSUE STEMS FROM SOME ELECTRICAL WIRING IN THE STEERING COLUMN; NOT SURE HOW THE TWO ARE RELATES BUT WHEN I BANG ON MY STEERING WHEEL THE LCD COMES BACK AND THE HORN IS FUNCTIONAL AGAIN. POTENTIAL SAFETY HAZARD AS IT AFFECTS THE HOR…
Read full complaint
ELECTRICAL SHORT / FAILURE IN THE CAR HORN (SIMULTANEOUSLY AFFECTING THE LCD OF THE CLOCK/RADIO). ISSUE STEMS FROM SOME ELECTRICAL WIRING IN THE STEERING COLUMN; NOT SURE HOW THE TWO ARE RELATES BUT WHEN I BANG ON MY STEERING WHEEL THE LCD COMES BACK AND THE HORN IS FUNCTIONAL AGAIN. POTENTIAL SAFETY HAZARD AS IT AFFECTS THE HORN AND ABILITY TO AVOID ACCIDENTS. NO KNOWN FIX FROM MANUFACTURER ALARMS ME. *TR
NHTSA ODI #10315111
69,000 miles · Mar 20, 2009
Electrical System
UNEXPLAINABLE COMPLETE BATTERY DRAIN BEGAN IN 08/2008. DISCOVERED IN 03/2009 THAT THE FOG LIGHTS WERE COMING ON AND STAYING ON WHEN CAR WAS ON AS WELL AS WHEN OFF AND PARKED THUS, CAUSING THE BATTERY DRAIN. ONLY WAY TO KEEP FOG LIGHTS OFF WAS TO ENGAGE THE LEFT TURN SIGNAL OR REMOVE THE FUSE. TOOK TO DEALER 03/21/2009 AND FOUND …
Read full complaint
UNEXPLAINABLE COMPLETE BATTERY DRAIN BEGAN IN 08/2008. DISCOVERED IN 03/2009 THAT THE FOG LIGHTS WERE COMING ON AND STAYING ON WHEN CAR WAS ON AS WELL AS WHEN OFF AND PARKED THUS, CAUSING THE BATTERY DRAIN. ONLY WAY TO KEEP FOG LIGHTS OFF WAS TO ENGAGE THE LEFT TURN SIGNAL OR REMOVE THE FUSE. TOOK TO DEALER 03/21/2009 AND FOUND THE ISSUE IS WITH THE MULTIFUNCTION SWITCH, WITH A REPLACEMENT COST OF $269. WENT AHEAD WITH THE REPLACEMENT AS I DO USE THE FOG LIGHTS. HAVE SEARCHED INTERNET AND HAVE FOUND MANY, MANY CASES OF THIS EXACT PART DEFECT. CHRYSLER SHOULD RECALL. *TR
NHTSA ODI #10262513
Official recalls
5Jun 3, 2004
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.4L NON-TURBOCHARGED ENGINES AND AUTOMATIC TRANSAXLES, THE POWER STEERING PRESSURE HOSE MAY CONTACT THE AUTOMATIC TRANSAXLE DIFFERENTIAL COVER, POTENTIALLY DAMAGING THE HOSE.
Consequence & remedy
Consequence: POWER STEERING FLUID LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSPECT AND RELOCATE, OR REPLACE AS NECESSARY, THE POWER STEERING HOSE AND CONFIRM TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END. THE RECALL BEGAN ON SEPTEMBER 20, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Aug 8, 2002
ON CERTAIN PASSENGER VEHICLES, THE FUEL SUPPLY LINE COULD CONTACT THE AIR-CONDITIONING TUBE SERVICE PORT. THIS CAN CAUSE CHAFING OF THE LINE RESULTING IN A FUEL LEAKAGE.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT THE FUEL LINE FOR ABRASION AND INSTALL A CLIP TO ENSURE ISOLATION. IN CASES WITH EVIDENCE OF FUEL LINE ABRASION, THE FUEL LINE WILL BE REPLACED. OWNER NOTIFICATION BEGAN AUGUST 12, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Aug 8, 2002
ON CERTAIN PASSENGER VEHICLES, THE FUEL PUMP MODULE MOUNTING FLANGE COULD LEAK FUEL IF THE VEHICLE IS INVOLVED IN A ROLLOVER CRASH.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A SECONDARY SEAL OVER THE FUEL PUMP MODULE. OWNER NOTIFICATION BEGAN AUGUST 12, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Jun 14, 2002
CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE RIGHT REAR "65%" SEAT CENTER LOWER ANCHOR WAS MANUFACTURED WITH A WIRE DIAMETER THAT IS GREATER THAN THE MAXIMUM ALLOWABLE DIMENSION AS SPECIFIED IN THE STANDARD.
Consequence & remedy
Consequence: IF THE CONNECTOR FOR A LATCH-TYPE CHILD RESTRAINT IS NOT ATTACHED CORRECTLY TO THE ANCHORAGE POINTS, THE RESTRAINT WILL NOT PROPERLY PROTECT A CHILD IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL INSPECT THE RIGHT REAR SEAT CENTER ANCHOR AND, IF NECESSARY, RESIZE THE ANCHOR TO MEET THE DIAMETER SPECIFIED WITHIN THE STANDARD. OWNER NOTIFICATION BEGAN NOVEMBER 4, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Nov 9, 2000
VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES, PICKUP TRUCKS AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." SOME OF THE OWNER'S MANUALS FOR THESE VEHICLES ARE MISSING INSTRUCTIONS THAT PROVIDE A STEP-BY-STEP PROCEDURE, INCLUDING DIAGRAMS, FOR PROPERLY ATTACHING A CHILD RESTRAINT SYSTEM'S TETHER STRAP TO THE TETHER ANCHORAGE.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE CHILD SEAT MAY NOT BE PROPERLY ATTACHED INCREASING THE RISK OF INJURY TO THE CHILD.
Remedy: OWNERS WILL BE PROVIDED WITH AN ADDENDUM TO THE OWNER'S MANUALS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3PE04028 · Engine Compartment Fires
Opened Mar 15, 2004 · Closed Jun 18, 2004
Status: closed (inferred from source dates) · Steering; Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:hose, Piping, And Connections; Steering:hydraulic Power Assist:power Steering Fluid
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Additional source detail variants (4)
Steering
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist:hose, Piping, And Connections
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist:power Steering Fluid
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist System
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
PE02082 · Safety Belt Cinching Latch Plate
Opened Nov 6, 2002 · Closed Apr 23, 2003
Status: closed (inferred from source dates) · Seat Belts
THERE ARE NO INJURIES OR FATALITIES ASSOCIATED WITH THIS ALLEGED DEFECT.WHILE CONDUCTING THIS INVESTIGATION, ODI FOUND THAT THE SUBJECT CINCHES MEET THE LOAD BEARING REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD 208, AND THAT MANY OF THE REPORTED FAILURES WERE DUE TO INCORRECT CHILD SAFETY SEAT INSTALLATIONS. ADDITIONALLY, THE REPORT RATE IS LOW (1.60/100K).THE INFORMATION AVAILABLE FAILS TO ESTABLISH THE EXISTENCE OF A DEFECT TREND AT THIS TIME.FURTHER ALLOCATION OF AGENCY RESOURCES TO THIS ISSUE IS UNWARRANTED AND THE PRELIMINARY EVALUATION IS BEING CLOSED.
PE02058 · Fuel Hose Abrasion
Opened Jul 19, 2002 · Closed Oct 4, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
No summary supplied.
Illustration